Dometic CRG3333BIFBB, CRG3335LIFBB Mode d'emploi

Marque: Dometic

Modèle: CRG3333BIFBB, CRG3335LIFBB

Catégorie: Cuisinières

Taper: Mode d'emploi

HOT AND COOKING

RV RANGE 17

CRG3333BIFBB, CRG3335LIFBB

EN CRG 3000 Series Range

Installation and Operation Manual ........2

FR Cuisinière CRG série 3000

Manuel d’installation et d’utilisation .....17

WARNING: If the information in this manual is not followed

exactly, a ﬁre or explosion may result, causing property

damage, personal injury, or death.

• Do not store or use gasoline or other ﬂammable vapors

and liquids in the vicinity of this or any other appliance.

• WHAT TO DO IF YOU SMELL GAS

–Do not try to light any appliance.

–Do not touch any electrical switch.

–Do not use any phone in your recreational vehicle.

–Clear the recreational vehicle of all occupants.

–Turn oﬀ the gas supply tank valve(s) or main gas

supply.

–Immediately call your gas supplier for instructions.

–If you cannot reach your gas supplier, call the ﬁre

department.

• Have the gas system checked and leakage source

corrected by a qualiﬁed installer, service agency,

manufacturer or dealer, or the gas supplier.

WARNING

Cancer and Reproductive Harm

www.P65Warnings.ca.gov

2EN

Contents CRG 3000 Series Range

1 Explanation of Symbols and Safety

Instructions ............................ 2

1.1 Recognize Safety Information .............2

1.2 Understand Signal Words ................2

1.3 Supplemental Directives .................3

1.4 General Safety Messages ................3

2 Intended Use ........................... 4

3 General Information ..................... 4

4 Specifications .......................... 4

5 Wiring Diagram ......................... 4

6 Preinstallation .......................... 5

6.1 Preparing the Cabinet ...................5

6.2 Cutting the Opening ....................5

7 Installation ............................. 6

7.1 Placing the Range ......................7

7.2 Connecting the Gas Lines ................8

7.3 Connecting the Electrical ................8

7.4 Securing the Range .....................9

7.5 Performing a Gas Pressure Test ............9

7.6 Finishing the Installation ................10

8 Operation ............................. 10

8.1 Understanding the Control Knob Settings .. 11

8.2 Lighting the Cooktop Burners. . . . . . . . . . . . 11

8.3 Lighting the Oven Burner ...............12

8.4 Extinguishing the Flame ................12

8.5 Operating the Oven Light ...............12

9 Maintenance .......................... 13

9.1 Removing or Reinstalling the Glass Bi-Fold

Cover ...............................13

9.2 Removing or Reinstalling the Oven Door ...14

9.3 Checking the Burner Flames and Oven

Burner ..............................14

9.4 Replacing the Oven Light ...............14

9.5 Replacing the Control Knob LED .........14

9.6 Cleaning the Range ....................15

9.7 Storing the Range .....................15

10 Troubleshooting ....................... 16

11 Replacement Parts ..................... 16

12 Disposal .............................. 16

LIMITED TWO-YEAR WARRANTY ............. 16

Contents

Service Center & Dealer Locations

Visit: www.dometic.com

Please read these instructions carefully and follow all instructions,

guidelines, and warnings included in this product manual in order to

ensure that you install, use, and maintain the product properly at all

times. These instructions MUST stay with this product.

By using the product, you hereby conﬁrm that you have read

all instructions, guidelines, and warnings carefully and that you

understand and agree to abide by the terms and conditions as set

forth herein. You agree to use this product only for the intended

purpose and application and in accordance with the instructions,

guidelines, and warnings as set forth in this product manual as well

as in accordance with all applicable laws and regulations. A failure

to read and follow the instructions and warnings set forth herein may

result in an injury to yourself and others, damage to your product,

or damage to other property in the vicinity. This product manual,

including the instructions, guidelines, and warnings, and related

documentation, may be subject to changes and updates. For up-to-

date product information, please visit www.dometic.com.

1 Explanation of Symbols and

Safety Instructions

This manual has safety information and instructions to

help you eliminate or reduce the risk of accidents and

injuries.

1.1 Recognize Safety Information

This is the safety alert symbol. It is used to alert

you to potential physical injury hazards. Obey all

safety messages that follow this symbol to avoid

possible injury or death.

1.2 Understand Signal Words

A signal word will identify safety messages and property

damage messages, and also will indicate the degree or

level of hazard seriousness.

CRG 3000 Series Range Explanation of Symbols and Safety Instructions

DANGER!

Indicates a hazardous situation that, if not avoided,

will result in death or serious injury.

WARNING

Indicates a hazardous situation that, if not avoided,

could result in death or serious injury.

CAUTION

Indicates a hazardous situation that, if not avoided,

could result in minor or moderate injury.

NOTICE: Used to address practices not related to

physical injury.

IIndicates additional information that is not related

to physical injury.

1.3 Supplemental Directives

To reduce the risk of accidents and injuries, please

observe the following directives before proceeding to

install or operate this appliance:

• Read and follow all safety information and

instructions.

• Read and understand these instructions before

installing or operating this product.

• The installation must comply with all applicable local

or national codes, including the latest edition of the

following standards:

U.S.A.

• ANSI/NFPA70, National Electrical Code (NEC)

• ANSI/NFPA1192, Recreational Vehicles Code

• ANSI Z21.57, Recreational Vehicles Code

Canada

• CSA C22.1, Parts l & ll, Canadian Electrical Code

• CSA Z240 RV Series, Recreational Vehicles

1.4 General Safety Messages

WARNING: FIRE, BURN, CARBON

MONOXIDE, AND/OR EXPLOSION HAZARD.

Never use use this appliance as a space heater

to heat or warm the room. Doing so may result in

carbon monoxide poisoning and the overheating

of the oven. Failure to obey this warning could

result in death or serious injury:

WARNING: FIRE, BURN, CARBON

MONOXIDE, AND/OR EXPLOSION HAZARD.

Failure to obey the following warnings could

result in death or serious injury:

• Use only Dometic replacement parts and

components that are speciﬁcally approved for use

with the appliance.

• Avoid improper installation, adjustment, alterations,

service, or maintenance of the appliance. Do not

repair or replace any part of the appliance unless

speciﬁcally recommended in this manual. Installation,

service, and maintenance must be done by a

qualiﬁed service person only.

• Do not modify this product in any way. Modiﬁcation

can be extremely hazardous.

• Do not store items of interest to children in cabinets

above the range. Children climbing on the range to

reach the item could be seriously injured.

• In case of ﬁre or gas leak, be sure to turn oﬀ the main

gas shutoﬀ valve.

• Remove the oven door from any unused range if it is

to be stored or discarded.

WARNING: TIPPING HAZARD. Failure to obey

the following warnings could result in death

or serious injury:

• Stepping, leaning, or sitting on the door or drawer of

this range can result in serious injuries and also cause

damage to the range. Do not allow children to climb

or play around the range. The weight of a child on

an open door may cause the range to tip, resulting in

serious burns or other injury.

• Children should not be le alone or unattended in the

area where the appliance is in use. They should never

be allowed to sit or stand on any part of the appliance.

4EN

Intended Use CRG 3000 Series Range

WARNING: SUFFOCATION OR CHOKING

HAZARD.

Remove all tape and packaging before using the

range. Recycle/dispose of the carton and plastic

bags aer unpacking the range. Never allow

children to play with packaging material. Failure to

obey this warning could result in death or serious

injury.

2 Intended Use

The CRG 3000 Series Ranges (hereinaer referred to

as “range,” “product,” or “appliance”) are designed

and intended for use inside a recreational vehicle

(hereinaer referred to as “RV”). This range is intended

to be built into a cabinet structure and is not intended

for attachment to a structure. This range is only suitable

for the intended purpose and application in accordance

with these instructions.

This manual provides information that is necessary for

proper installation and/or operation of the range. Poor

installation and/or improper operating or maintenance

will result in unsatisfactory performance and a possible

failure. The manufacturer accepts no liability for any injury

or damage to the product resulting from:

• Incorrect assembly or connection, including excess

voltage

• Incorrect maintenance or use of spare parts

other than original spare parts provided by the

manufacturer

• Alterations to the product without express permission

from the manufacturer

• Use for purposes other than those described in this

manual

Dometic reserves the right to change product

appearance and product speciﬁcations.

3 General Information

IThe images used in this document are for reference

purposes only. Components and component

locations may vary according to speciﬁc product

models. Measurements may vary ±0.38 in. (10 mm).

Dometic recommends that the following tools and

materials be used while installing the appliance.

Recommended Tools

Drill Screwdriver

Saw Manometer

Wrench Basic Electrical Connection

Tools

4 Speciﬁcations

This section shows the range speciﬁcations by model.

Model CRG 3333 CRG 3335

Door Black Steel Glass

Bi-Fold Glass Cover No Yes

Width 20.3 in.

(516 mm) 20.3 in.

(516 mm)

Height 16.0 in.

(406 mm) 16.0 in.

(406 mm)

Depth 17.8 in.

(561 mm) 17.8 in.

(561 mm)

Size 17 in.

(452 mm) 17 in.

(452 mm)

Cooktop Burners 3 3

Oven Burners 1 1

Le Burner BTU 6500 6500

Front Burner BTU 9000 9000

Right Burner BTU 6500 6500

Oven Burner BTU 7200 7200

Inputs Propane 12 VDC,

Propane

Ignition Piezo Piezo

Knob with LED No Yes

Oven Lamp No Yes

5 Wiring Diagram

WARNING: ELECTRIC SHOCK HAZARD.

Turn power oﬀ before performing any electrical

installation or maintenance activities. Failure to obey

this warning could result in death or serious injury.

CRG 3000 Series Range Preinstallation

Figure 1 provides an example of the CRG 3335 model

light wiring.

GND

12 VDC

1 3

wwee

1 Wiring Diagram

q Oven Lamp r Ignition Pins

w Patch Board t Igniter

e Lamp Switch y Lamp Panel

6 Preinstallation

WARNING: FIRE HAZARD.

Failure to obey the warnings or preinstallation

instructions in this section could result in property

damage, death, or serious injury.

This section provides information on preparing the

cabinet and opening for the range installation.

6.1 Preparing the Cabinet

For proper range operation, the cabinet must:

• Be properly constructed.

• Be squared to the counter top and cabinet face.

For proper range operation, the cabinet opening must:

• Be level from side-to-side and from front-to-rear.

• Be free from gaps between the range and any

adjacent cabinet.

• Meet the minimum clearances to combustibles.

• Be positioned so that combustible material cannot be

placed next to the range sides.

• Applies to the CRG 3335 model only: Provide DC

electrical supply conductors with strain relief at the

range.

• Be framed-in or guarded to prevent the creation of

storage space around the recessed portion of the

range, except for the vent thimble.

• Have closed openings around the gas and electrical

service outlets at the time of installation, except

where the construction of the range provides the

necessary closure.

• The range must be completely separated and/or

sealed from the other air moving or air-consuming

devices such as, but not limited to, furnaces,

microwave ovens, clothes dryers, cooling fans, and

doors or drawers in common cabinets. If not, it can

aﬀect the appliance(s) combustion air supply by

creating either a negative or positive dra.

6.2 Cutting the Opening

1. Before cutting the opening, perform the following

checks:

– Verify the cutout location.

– Verify that the cutout dimensions and clearances

match those indicated in Figure 2 and Figure 3.

– Conﬁrm a propane-certiﬁed gas line is in place

that meets the appropriate RV and gas codes.

2. Cut the hole for the range.

6EN

Installation CRG 3000 Series Range

ttuu

2 Cutout Dimensions and Clearances

Reference Dimension Description

q30.0 in. (762 mm) Minimum clearance*

w2.4 in. (61 mm) Minimum distance from the

range to a wall or cabinet*

e20.3 in. (516 mm) Cutout width

r16.0 in. (406 mm) Cutout height

t17.8 in. (452 mm) Cutout depth

y1.8 in. (46 mm) Distance between the

counter and the power

cord outlet

u1.5 in. (38 mm) Distance from the power

cord outlet to the counter

* The minimum clearance to combustible materials allowed from the

surface of the range to a combustible object (curtains, board, wall,

ﬂoor, etc.). Consider both sides, the back side, and above the cabinet

when determining clearances. CSA certiﬁcation requires a minimum top

clearance of 30.0 in. (762 mm) to overhead combustible construction

when installed with a range hood spaced a minimum of 0.25 in. (6 mm)

from the construction.

IThe maximum depth of cabinets installed above the

range is 13 in. (330 mm).

3 Range Dimensions and Clearance to Walls

Reference Dimension Description

q9.0 in. (229 mm) Minimum clearance to rear

wall from burner center

w21.3 in. (541 mm) Range width

e17.8 in. (452 mm) Range depth

7 Installation

WARNING: FIRE, EXPLOSION, BURN, AND/

OR CARBON MONOXIDE HAZARD. Failure to

obey the following warnings could result in

death or serious injury.

• Gas leaks may occur in your system and may not be

detected by smell alone. Gas suppliers recommend

you purchase and install a UL-approved gas detector

and alarm. Install and use in accordance with the

manufacturer’s instructions.

• Do not use matches, candles, or other sources of

ignition to test ﬁttings and gas lines for leaks.

• Do not install any structure directly above the stove

(for the width of the stove) except a range hood.

CRG 3000 Series Range Installation

WARNING: PROJECTILE HAZARD.

This range must be permanently installed. Failure

to secure the range permanently could result in the

range becoming airborne in the occupant space of

the vehicle in the event of an accident, creating a

risk of serious blunt force injury.

CAUTION: ELECTRICAL SHOCK HAZARD.

Be sure to label all wires before removing or

servicing the range. Failure to obey this caution

could result in minor or moderate injury.

This section provides information on placing the range,

connecting the lines, and leak testing.

IThe example images in this section show the

CRG3335 model.

7.1 Placing the Range

4 Opening the Glass Bi-Fold Cover

q Glass Bi-Fold Cover

1. Remove the range from the packaging.

2. If the range has a glass bi-fold cover, open it by liing

the cover straight up and folding the front section of

the cover over and behind the back section of the

cover.

5 Removing the Grate

q Grate w Glass Bi-Fold Cover

3. Li the grate up and oﬀ of the range and place it on a

ﬂat, secure surface.

4. Remove the four screws that hold the cooktop and

glass bi-fold cover in place. Keep for reinstallation.

6 Tilting the Cooktop

q Glass Bi-Fold Cover w Cooktop

e Tabs

5. If the range has a glass bi-fold cover, carefully lower it.

8EN

Installation CRG 3000 Series Range

6. Li the rear of the cooktop and slide it to the rear of

the range until the tabs clear the console.

7 Removing the Cooktop

q Cooktop w Range

7. Li the cooktop out of the range and place it on a ﬂat,

secure surface.

8 Sliding the Range into the Cabinet Opening

8. Gently push the range into the cabinet opening.

9. Verify the range is level (side to side, front to rear).

7.2 Connecting the Gas Lines

9 Placing the Gas Line

q Gas Regulator w Gas Supply Line

1. Turn oﬀ all gas to the RV.

2. Connect a gas supply line to the gas regulator in the

upper-le rear corner of the cooktop.

IAll openings in the cabinetry around the gas supply

line must be closed at the time of installation.

7.3 Connecting the Electrical

IApplies to the CRG 3335 model only.

1. Turn oﬀ all power to the RV.

2. Make the connections. See “Wiring Diagram” on

page 4.

– Connect the red wire to the positive 12 VDC

power circuit.

– Connect the black wire to the negative 12 VDC

power circuit.

CRG 3000 Series Range Installation

7.4 Securing the Range

10 Securing the Range

q Mounting Hole w Screw

1. Conﬁrm the range is level (side to side, front to rear)

and that the mounting holes are aligned at the front

of the range.

2. Secure the range by tightening a screw into each of

the four mounting hole locations.

7.5 Performing a Gas Pressure Test

WARNING: FIRE, EXPLOSION, AND/OR

BURN HAZARD. Failure to obey the following

warnings could result in death or serious

injury:

• Extinguish all open ﬂames and do not smoke around

gas lines.

• Do not use the oven until the connection has been

leak tested and the connection does not leak.

• Leak testing must be conducted according to the

manufacturer’s instructions.

This section shows how to perform gas pressure testing

and gas leak testing prior to operating the range. When

conducting the range gas pressure testing prior to

operation:

• The range and any individual shut-oﬀ valves must

be disconnected from the gas supply piping system

when pressure testing the system at pressures

exceeding 0.5 psi (3.5 kPa).

• The gas supply pressure for checking the regulator

setting must be at least 1.0 in. W.C. (0.25 kPa) above

the manufacturer’s speciﬁed manifold pressure. The

maximum gas supply pressure is 13.8 in. W.C (3.4 kPa).

11 Finding the Gas Regulator

q Leak Check Fitting Screw

1. Make sure all control knobs are turned to the oﬀ

position, then turn on the gas.

2. Use a screwdriver to remove the leak check ﬁtting

screw in the gas manifold.

3. Place a manometer on the ﬁtting.

4. Check for leaks using 9–13.8 W.C. (2.2–3.4 kPa).

10 EN

Operation CRG 3000 Series Range

5. If the pressure gauge falls below 9, there is a leak.

Perform the following actions:

a. Make sure all control knobs are turned to the oﬀ

position.

b. Apply a gas leak detection liquid (soapy water) to

the connection. Bubbles within the liquid indicate

the leak location.

c. To stop the leak, tighten the loose joint or take the

range to a Dometic Service Center.

6. Reinstall the leak check ﬁtting screw in the gas

manifold.

7.6 Finishing the Installation

1. Place the tabs on the front of the cooktop into the

slots on the console.

2. Align the four screws on the side with the cooktop.

3. Secure the cooktop to the range using the screws

previously removed. See “7.1 Placing the Range” on

page 7.

4. Open the glass bi-fold cover if the model is

equipped.

5. Gently place the grate on the cooktop, aligning it

with the holes on each side

6. Close the glass bi-fold cover.

7. Turn the power on.

8 Operation

WARNING: BURN, FIRE, EXPLOSION, AND/

OR CARBON MONOXIDE HAZARD. Failure to

obey these warnings could result in death or

serious injury.

• Never use this appliance as a space heater to heat

or warm the room. Doing so may result in carbon

monoxide poisoning and the overheating of the

oven.

• Do not store ﬂammable or combustible material

on, in, or near the range or in the cabinets above, or

above and adjacent to, the range. While using the

range, frequently check the temperature of contents

within the cabinet areas above the range.

• Do not use the oven or warmer drawer (if equipped)

as a storage area or space heater.

• Loose-ﬁtting or hanging garments should never be

worn while using the range. Do not let clothing or

other ﬂammable materials contact hot surfaces.

• Use dry potholders only. Moist or damp potholders

on hot surfaces may result in burns from steam. Do

not let potholder touch hot heating elements. Do

not use a towel or other bulky cloth.

• Do not heat unopened containers. They could

explode and the hot contents may splatter.

• Do not attempt to operate the oven during a power

failure. If the power fails, always turn oﬀ the oven.

• Do not use stove top grills on the burner grates of

sealed gas burners.

• Do not touch the surface burners, areas near these

burners, oven burners, or interior surfaces of the

oven or warmer drawer (if equipped). Both surface

burners and oven burners may be hot even though

ﬂames are not visible. Areas near surface burners may

become hot enough to cause burns. During and aer

use, do not touch, or let clothing or other ﬂammable

materials touch these areas, until they have had

suﬃcient time to cool.

• Do not use water or ﬂour on grease ﬁres. Smother

the ﬁre using a pan lid, baking soda, or a dry-

chemical or foam-type extinguisher.

• Know which knob controls each surface burner. Place

a pan of food on the burner before turning it on, and

turn the burner oﬀ before removing the pan.

• Always turn the knob to the proper position when

igniting the top burners. Visually check that the

burner has lit, then adjust the ﬂame so it does not

extend beyond the edge of the utensil.

• Be sure that all cooking pans are safe for use on the

range surface. Only certain kinds of pans are suitable

for surface or burner use without breaking due to

sudden changes in temperature. Do not adjust the

burner ﬂames to extend beyond the edge of the

cooking pan.

CRG 3000 Series Range Operation

• Use the proper pan size. This appliance is equipped

with one or more surface burners of diﬀerent sizes.

Select pans with a ﬂat bottom large enough to cover

the surface burner.

• Turn pan handles inward but do not extend them

over adjacent burners.

• Never leave burners unattended when in use. Pan

contents may boil over, smoke, or melt.

• Do not block air ﬂow through the oven. Never cover

the rear vent, any internal cavity holes, or the space at

the bottom of the oven door. Never cover an entire

rack with materials such as aluminum foil.

• Do not use a searing grill on the cooktop.

• Do not use decorative surface burner covers.

• Do not touch the heating elements or the interior

surfaces of the oven. Heating elements may be hot

even though they are dark in color.

• Use care when opening the oven door or warmer

drawer (if equipped). Stand to the side of the range

when opening the door of a hot oven. Let hot air or

steam escape before you remove or replace food in

the oven/warmer drawer (if equipped).

• Always place oven racks in the desired location

while the oven/warmer drawer (if equipped) is cool.

If rack must be moved while the oven is hot, use

extreme caution. Use potholders and grasp the rack

with both hands to reposition. Do not let potholders

contact the hot heating elements in the oven/warmer

drawer (if equipped). Remove all items from the rack

before moving.

• Do not use a broiler pan without its insert.

NOTICE: Do not cook with the control knob set in an

active position. Damage to the ignition module and

burner electrodes may result.

8.1 Understanding the Control Knob

Settings

This section details the symbols and decals shown on

the cooktop and oven knob controls.

8.1.1 Cooktop Control Knob Settings

Setting Recommended Use

Identify the burner the knob controls

Set the ignite position

• Light the burner

• Start food cooking

• Bring liquids to a boil

• Hold liquids at a boil

• Cook food at diﬀerent temperature levels

Keep food warm

OFF Turn the burner oﬀ

IAer the top burners have been on for a period of

time, a popping sound may occur when the burner

is turned oﬀ. This is normal and does not create a

safety hazard.

8.1.2 Oven Control Knob Settings

Setting Recommended Use

Pilot

Push/Hold • Light the oven pilot

• Keep the oven pilot lit for continued use

of the oven

Broil Set the oven temperature to broil

330 – 500 Set the oven to a particular temperature

OFF Turn the oven pilot oﬀ

8.2 Lighting the Cooktop Burners

qqww

12 Lighting the Cooktop Burners

q Igniter Control Knob w Burner Control Knob

12 EN

Operation CRG 3000 Series Range

1. Turn all cooktop control knobs to the oﬀ position.

2. Turn on the gas supply.

3. If the range is equipped with a glass bi-fold cover,

raise it before using the cooktop.

4. Select a cooktop burner to light. Do not attempt to

light more than one cooktop burner at a time.

5. Push in the selected cooktop burner’s control knob

and turn it counterclockwise until it points to the

lightning bolt decal.

6. Turn the igniter control knob clockwise until there is

an audible click. Continue turning it until the cooktop

burner ignites, then release the igniter control knob.

7. Repeat steps 4–6 as needed for other burners.

8. Push the burner control knob in and turn it to adjust

the ﬂame to the desired level.

8.3 Lighting the Oven Burner

qqww

13 Lighting the Oven Pilot

q Igniter Control Knob w Oven Control Knob

1. Turn all control knobs to the oﬀ position.

2. Turn on the gas supply.

3. Push in, hold, and turn the oven control knob

counterclockwise until it points to the pilot position.

4. While continuing to push and hold the oven control

knob in, turn the igniter control knob clockwise until

there are audible clicks. Continue these actions until

the burner ignites.

5. Release both control knobs and verify that the burner

stays lit.

6. Repeat steps 3–5 if the pilot extinguishes.

IThe oven burner has been factory set and requires

no further adjustment.

8.4 Extinguishing the Flame

Turn the active cooktop and/or oven control knobs

clockwise to the oﬀ position.

8.5 Operating the Oven Light

IApplies to the CRG 3335 model only.

14 Oven Light Switch

To turn the oven light on, push the rocker switch on the

front panel to one of three positions:

– Turn on oven light and control knob lights

– Turn oﬀ the oven light and control knob lights

– Turn on the control knob lights only

CRG 3000 Series Range Maintenance

9 Maintenance

WARNING: BURN, FIRE, EXPLOSION, AND/

OR CARBON MONOXIDE HAZARD. Failure to

obey the following warnings could result in

death or serious injury:

• Always disconnect the unit from power before

cleaning and/or servicing. Maintenance must be

done by a qualiﬁed service person only.

• Keep the range’s cooktop area clear of combustible

cleaning materials, gasoline, and other ﬂammable

vapors and liquids.

• Do not obstruct the ﬂow of combustion and

ventilation air.

• Make sure all controls are oﬀ and the range surfaces,

burner grates, burners, and oven surfaces are cool

before cleaning or disassembling the range.

• Do not use oven cleaners, bleach, or rust removers

on the range’s cooktop or burner grates.

• Clean the oven with oven cleaner only. Follow

directions on the cleaning product container.

• Do not use a wire brush or metallic item for cleaning

burner ports or oriﬁces. Brushes may “shed” bristles,

that may lodge in the oriﬁce or burner ports and

cause a ﬁre or explosion.

NOTICE: Failure to obey the following items could result

in damage:

• Do not use abrasive cleaning materials, oven cleaner,

or harsh chemicals on the front panel as these may

damage or remove the printed items.

• When cleaning around the burners, use care to

prevent damage to the electrode (if so equipped).

• Clean all surfaces as soon as possible aer boil overs

or spillovers. Do not allow foods containing acids

(such as lemon juice, tomato juice, or vinegar) to

remain on porcelain or painted surfaces. Acids may

remove the glossy ﬁnish. Pitting and discoloration will

result if spills are allowed to remain for any length of

time on stainless steel. Do not allow spills to remain

on the tops of the burners. The burner tops could

be permanently stained if spills are not cleaned up

promptly.

• Use warm soapy water to clean the burner grates,

burner box, painted surfaces, porcelain surfaces,

stainless steel surfaces, and plastic items on your

range’s cooktop. Do not use gritty or acid-type

cleaners. Do not use steel wool or abrasive cleaners.

Use only non-abrasive plastic scrubbing pads.

The maintenance and cleaning instructions provided in

this section should be performed at regular intervals, or

as needed, depending on the use of the appliance.

Failure to properly maintain the appliance may void the

warranty and could result in unsafe operation. Preventive

maintenance is not covered under the warranty.

NOTICE: Exhaust fan ventilation hoods and grease

ﬁlters should be kept clean. Do not allow grease to

accumulate on the hood or ﬁlter. Greasy deposits in

the fan could catch ﬁre. When you are cooking food

under the hood, turn the fan on. Refer to the hood

manufacturer’s instructions for cleaning instructions.

9.1 Removing or Reinstalling the

Glass Bi-Fold Cover

IApplies to the CRG 3335 model only.

15 Removing the Glass Bi-Fold Cover

q Screw

1. Fold the glass bi-fold cover.

14 EN

Maintenance CRG 3000 Series Range

2. Locate the screws securing the cover to the range.

3. Loosen screws and remove them from the mounting

holes.

4. Carefully li the glass bi-fold cover oﬀ of the range

and place it in a ﬂat, secure area.

5. Reverse these steps to reinstall the glass bi-fold cover.

IWhen attaching the glass bi-fold cover, always

carefully open and close the cover to verify it is

secured properly and will not break free from the

range.

9.2 Removing or Reinstalling the

Oven Door

CAUTION: ELECTRIC SHOCK, BURN, CUT

AND/OR BROKEN LIMB HAZARD. Failure to

follow the following warnings could result in

minor or moderate injury:

• Make sure the oven is cool and the power to the oven

has been turned oﬀ before removing the oven door.

The oven door is heavy and fragile.

• Use both hands to remove the oven door. The

oven door front is glass. Handle it carefully to avoid

breaking the oven door.

• Grasp only the sides of the oven door. Do not

grasp the handle as it may swing in your hand

uncontrollably and cause damage.

• To avoid injury from the hinge bracket snapping

closed, be sure that both levers are securely in place

before removing the oven door.

• Do not force the oven door open or closed.

IThe oven door is heavy. Consider getting another

person to help remove or place the oven door, if

needed.

1. Open the oven door all the way.

2. Flip the hinge levers (one on each side) forward

(toward the oven door).

3. Push the oven door closed until it stops. It will be

about halfway open.

4. Holding it ﬁrmly on both sides and using both hands,

pull the oven door straight out of the hinge slots.

5. Place the oven door in a ﬂat, secure location.

6. Reverse these steps to reinstall the oven door.

9.3 Checking the Burner Flames and

Oven Burner

1. Light the cooktop burners, one at a time. See

“Lighting the Cooktop Burners” on page 11.

2. Conﬁrm that the cooktop burner ﬂames are present

and adjust when the cooktop burner control knob is

turned.

3. Light the oven pilot. See “Lighting the Oven Burner”

on page 12.

4. Conﬁrm the pilot ﬂame is present and the oven

burner adjusts when the oven control knob is turned.

9.4 Replacing the Oven Light

IApplies to the CRG 3335 model only.

1. Turn oﬀ the main power supply or unplug the range if

the plug is accessible.

2. Remove the glass cover over the light bulb.

3. Remove the light bulb.

4. Replace the light bulb with one rated for:

– Temperatures: up to 572 °F ( 300 °C)

– Voltage: 12 V

– Wattage: 15 W

– Type: G9

5. Replace the light bulb cover.

6. Reconnect the range to the main power supply.

9.5 Replacing the Control Knob LED

IApplies to the CRG 3335 model only.

Call Dometic Customer Service to replace control knob

LED lights.

CRG 3000 Series Range Maintenance

9.6 Cleaning the Range

16 Wiping the Range

q Grate w Cooktop

e So Cloth

1. Remove the grate.

2. Clean with warm, soapy water, then rinse with clean

water.

3. Dry with a so cloth.

IHeavy burned-on soil may require repeated

cleaning steps until the soil is completely removed.

Additional Cleaning Methods

Item Cleaning Method

Control Knobs Pull the knobs straight oﬀ of the

stems to clean. Use a mild liquid

cleaner or glass cleaner.

Control Panel Use a spray glass cleaner, applying

the cleaner to a paper towel. Do not

spray glass cleaner directly on the

panel. Do not use oven cleaner on

the control panel.

Range Cooktop

Surface Use a mild liquid cleaner or glass

cleaner.

Item Cleaning Method

Grate Clean the area as soon as possible

once the area is cool. Use a non-

abrasive, plastic, scrubbing pad, as

necessary.

Burners, Burner

Ports, or Oriﬁces If clogged, gently brush the

perforated areas with a lightweight

brush (toothbrush) or carefully clean

the holes out using a toothpick.

Oven Use warm, soapy water. For heavy

soil, use an oven-cleaning spray and

follow the manufacturer directions

on the label. Use a non-abrasive,

plastic, scrubbing pad, as necessary.

9.7 Storing the Range

17 Spraying the Range

q Vegetable Oil

1. Dry all surfaces.

2. Spray surfaces with vegetable oil or a similar product

to prevent rust during storage.

3. Clean oil oﬀ the surface of the range before

operating.

16 EN

Troubleshooting CRG 3000 Series Range

10 Troubleshooting

Problem Possible Cause Recommended

Solution

The cooktop

burner does

not work.

The knob of the

burner is not

turned to the

proper position.

See “Lighting the

Cooktop Burners” on

page 11.

The main gas valve

is closed. Open the main gas

valve.

The propane

supply is depleted. Fill the propane

tanks.

The igniter control

knob is defective. Replace the igniter

control knob.

The burner is wet. Dry the burner

thoroughly.

The burner

does not fully

ignite.

The burner port or

oriﬁce is blocked. Clean the burner port

or oriﬁce.

The burner is wet. Dry the burner

thoroughly.

11 Replacement Parts

For the most current parts information, visit www.

dometic.com.

12 Disposal

MPlace the packaging material in the appropriate

recycling waste bins, whenever possible. Consult

a local recycling center or specialist dealer for

details about how to dispose of the product in

accordance with all applicable national and local

regulations.

LIMITED TWO-YEAR

WARRANTY

LIMITED TWO-YEAR WARRANTY AVAILABLE AT

WWW.DOMETIC.COM/WARRANTY.

IF YOU HAVE QUESTIONS, OR TO OBTAIN A COPY

OF THE LIMITED WARRANTY FREE OF CHARGE,

CONTACT:

DOMETIC CORPORATION

CUSTOMER SUPPORT CENTER

5155 VERDANT DRIVE

ELKHART, INDIANA 46516

1-800-544-4881 OPT 1

AVERTISSEMENT: Suivre à la lettre les consignes énoncées

dans ce manuel, sinon il y aurait risque de départ de feu ou

d’explosion causant des dégâts matériels, des blessures

personnelles, voire la mort.

• Ne pas stocker ni utiliser d’essence ou d’autres vapeurs ou

liquides inﬂammables à proximité de cet appareil ou de

tout autre.

• QUE FAIRE EN CAS D’ODEUR DE GAZ

–Ne pas essayer d’allumer un quelconque appareil.

–Ne toucher aucun interrupteur électrique.

–Ne pas utiliser de téléphone dans votre véhicule récréatif.

–Évacuer tous les occupants du véhicule récréatif.

–Fermer le gaz au réservoir ou à l’arrivée de gaz réseau.

–Communiquer immédiatement avec le fournisseur de

gaz pour recevoir ses instructions.

–S’il est impossible de joindre le fournisseur, appeler

les pompiers.

• Faire vériﬁer le circuit de gaz et réparer l’origine de la fuite

par un installateur qualiﬁé, un centre de réparation, le

fabricant ou le revendeur, ou le fournisseur de gaz.

AVERTISSEMENT

Cancer et eﬀets nocifs sur la

reproduction

www.P65Warnings.ca.gov

CHAUD ET EN CUISSON

CUISINIÈRE VR 17

CRG3333BIFBB, CRG3335LIFBB

FR Cuisinière CRG série 3000

Manuel d’installation et d’utilisation .....18

Sommaire Cuisinière CRG série 3000

1 Explication des symboles et

consignes de sécurité

Ce manuel contient des consignes de sécurité et des

instructions pour aider l’utilisateur à éliminer ou à réduire

le risque d’accidents et de blessures.

1.1 Reconnaître les consignes de

sécurité

C’est le symbole d’alerte à la sécurité. Il signale

des risques de blessures physiques. Obéir à tous les

messages de sécurité qui suivent ce symbole pour

éviter les risques de blessures ou de mort.

Sommaire

1 Explication des symboles et consignes de

sécurité ............................... 18

1.1 Reconnaître les consignes de sécurité .....18

1.2 Comprendre les mots-indicateurs ........19

1.3 Directives supplémentaires ..............19

1.4 Messages de sécurité d’ordre général .....19

2 Indication ............................. 20

3 Information générale ...................20

4 Caractéristiques techniques ............. 21

5 Diagramme de câblage ................. 21

6 Avant l’installation .....................22

6.1 Préparation de l’armoire ................22

6.2 Découpe de l’ouverture ................22

7 Installation ............................ 23

7.1 Placement de la cuisinière ...............24

7.2 Branchement des conduites de gaz .......25

7.3 Branchements électriques ..............26

7.4 Sécurisation de la cuisinière .............26

7.5 Test de la pression de gaz ...............26

7.6 Fin de l’installation .....................27

8 Fonctionnement ....................... 27

8.1 Explication des réglages du bouton de

commande ..........................29

8.2 Allumage des brûleurs de la table de

cuisson ..............................29

8.3 Allumage du brûleur du four .............30

8.4 Extinction de la flamme .................30

8.5 Fonctionnement de la lampe dufour ......30

9 Entretien .............................. 31

9.1 Retrait ou réinstallation du couvercle en

verre plié en deux .....................31

9.2 Retrait ou réinstallation de la porte du four ..32

9.3 Contrôle des flammes de brûleur et de la

veilleuse du four ......................32

9.4 Remplacement de l’éclairage du four ......33

9.5 Remplacement de la DEL du bouton de

commande ..........................33

9.6 Nettoyage de la cuisinière ..............33

9.7 Rangement de la cuisinière ..............34

10 Dépannage ...........................34

11 Pièces de rechange ..................... 34

12 Mise au rebut ..........................34

GARANTIE LIMITÉE DE DEUX ANS ............35

Liste des centres de service et des revendeurs

Consultez: www.dometic.com

Veuillez lire attentivement ces instructions et suivre tous les avertissements,

instructions et directives inclus dans ce manuel du produit aﬁn de vous

assurer que vous installez, utilisez et entretenez le produit correctement à

tout moment. Ces instructions DOIVENT être conservées avec ce produit.

En utilisant le produit, vous conﬁrmez par la présente que vous avez lu

attentivement tous les avertissements, instructions et directives et que

vous comprenez et acceptez de respecter les conditions générales

énoncées dans le présent document. Vous acceptez d’utiliser ce produit

uniquement pour l’usage et l’application prévus et conformément

aux instructions, directives et avertissements ﬁgurant dans ce manuel

du produit ainsi qu’en accord avec toutes les lois et réglementations

applicables. Le fait de ne pas lire et de ne pas suivre les instructions et les

avertissements énoncés dans le présent document peut entraîner des

blessures pour vous-même et pour d’autres personnes, des dommages

à votre produit ou des dommages à d’autres biens situés à proximité.

Ce manuel du produit, y compris les instructions, les directives et les

avertissements, ainsi que la documentation connexe, peut faire l’objet

de modiﬁcations et de mises à jour. Pour obtenir des informations à jour

sur les produits, veuillez consulter www.dometic.com.

Cuisinière CRG série 3000 Explication des symboles et consignes de sécurité

1.2 Comprendre les mots-indicateurs

Un mot-indicateur identiﬁe les messages de sécurité et

les messages liés aux dégâts matériels, et signale aussi le

degré ou niveau de gravité du danger.

DANGER!

Indique une situation dangereuse qui, si elle n’est

pas évitée, causera la mort ou des blessures

graves.

AVERTISSEMENT

Indique une situation dangereuse qui, si elle n’est

pas évitée, peut causer la mort ou des blessures

graves.

ATTENTION

Indique une situation dangereuse qui, si elle n’est

pas évitée, peut causer des blessures légères ou

modérées.

AVIS: Utilisé pour signaler des pratiques non liées

àune blessure physique.

IFournit des renseignements additionnels sans

rapport avec des blessures physiques.

1.3 Directives supplémentaires

Pour réduire le risque d’accidents et de blessures,

observer les directives suivantes avant de continuer à

installer ou utiliser cet appareil:

• Lire et suivre toutes les consignes de sécurité et les

instructions.

• Lire et comprendre toutes les instructions avant

d’installer ou d’utiliser ce produit.

• L’installation doit se conformer à tous les codes

locaux ou nationaux applicables, y compris la toute

dernière édition des normes suivantes:

États-Unis

• ANSI/NFPA 70, Code national de l’électricité (CNE)

• ANSI/NFPA 1192, Code des véhicules récréatifs

• ANSI Z21.57, Code des véhicules récréatifs

Canada

• CSA C22.1, Parties l et ll, Code canadien de

l’électricité

• CSA Z240 RV Series, véhicules récréatifs

1.4 Messages de sécurité d’ordre

général

AVERTISSEMENT : RISQUE D’INTOXICATION

AU MONOXYDE DE CARBONE, DE BRÛLURE,

DE DÉPART DE FEU ET/OU D’EXPLOSION.

Ne jamais utiliser cet appareil comme chauﬀage

d’appoint pour chauﬀer ou réchauﬀer la pièce.

Cela peut entraîner une intoxication au monoxyde

de carbone et la surchauﬀe du four. Le non-respect

de cet avertissement pourrait entraîner de graves

blessures, voire la mort.

AVERTISSEMENT : RISQUE D’INTOXICATION

AU MONOXYDE DE CARBONE, DE BRÛLURE,

DE DÉPART DE FEU ET/OU D’EXPLOSION.

Lenon-respect de ces avertissements pourrait

entraîner de graves blessures, voire la mort:

• Utiliser uniquement des pièces et composants de

rechange Dometic spéciﬁquement approuvés pour

une utilisation avec cet appareil.

• Éviter l’installation, le réglage, les altérations, les

réparations ou la maintenance incorrects de l’appareil.

Ne pas réparer ou remplacer une quelconque pièce de

l’appareil, sauf recommandation contraire spéciﬁque dans

le manuel. L’installation, les réparations et la maintenance

doivent être conﬁées à un agent technique qualiﬁé.

• Ne pas modiﬁer ce produit d’une quelconque

manière. Une modiﬁcation peut être extrêmement

dangereuse.

• Ne pas ranger d’objets intéressant les enfants dans

les armoires au-dessus de la cuisinière. Un enfant

grimpant sur la cuisinière pour atteindre un tel objet

s’expose à des blessures graves.

• En cas d’incendie ou de fuite de gaz, veiller à fermer

la vanne d’arrêt de gaz principale.

• Retirer la porte du four de toute cuisinière non utilisée

si cette dernière doit être entreposée ou mise au rebut.

20 FR

Indication Cuisinière CRG série 3000

AVERTISSEMENT : RISQUE DE BASCULEMENT.

Le non-respect de ces avertissements

pourrait entraîner de graves blessures,

voirela mort:

• Marcher, s’appuyer ou s’asseoir sur la porte ou

letiroir de cette cuisinière peut entraîner des

blessures graves et endommager la cuisinière.

Nepas permettre aux enfants de grimper ou de

jouerautour de la cuisinière. Le poids d’un enfant

surune porte ouverte peut faire basculer la cuisinière,

cequi pourrait entraîner de graves brûlures ou

d’autres blessures.

• Les enfants ne doivent pas être laissés seuls ou sans

surveillance dans la zone où l’appareil est utilisé. Ils ne

doivent jamais être autorisés à s’asseoir ou à se lever

sur une partie quelconque de l’appareil.

AVERTISSEMENT: RISQUE DE SUFFOCATION

OU D’ÉTOUFFEMENT.

Retirez tout le ruban adhésif et l’emballage avant

d’utiliser la cuisinière. Recyclez et jetez le carton et

les sacs en plastique après avoir déballé la cuisinière.

Ne laissez jamais les enfants jouer avec le matériel

d’emballage. Le non-respect de cet avertissement

pourrait entraîner de graves blessures, voire la mort.

2 Indication

Les cuisinières CRG série 3000 (ci-après dénommées

cuisinière, produit ou appareil) sont conçues et destinées

à être utilisées à l’intérieur d’un véhicule récréatif (ci-

après dénommé VR). Cette cuisinière est destinée à être

intégrée dans une armoire et ne devrait pas être ﬁxée à

une structure. Cette cuisinière est uniquement adaptée

à l’usage et à l’application prévus conformément aux

présentes instructions.

Ce manuel fournit les informations nécessaires à

une installation et/ou un fonctionnement corrects

de la cuisinière. Une mauvaise installation et/ou un

mauvais fonctionnement ou entretien entraînera des

performances insatisfaisantes et possiblement, une

panne. Le fabricant décline toute responsabilité en cas

de blessure ou de dommage au produit résultant de:

• Assemblage ou connexion incorrects, y compris la

surtension

• Entretien ou utilisation incorrects de pièces

détachées autres que les pièces détachées d’origine

fournies par le fabricant

• Altération du produit sans la permission expresse du

fabricant

• Utilisation à d’autres ﬁns que celles décrites dans ce

manuel

Dometic se réserve le droit de modiﬁer l’apparence et

les spéciﬁcations des produits.

3 Information générale

ILes images utilisées dans ce document sont

uniquement fournies à titre de référence. Les

composants et leur emplacement peuvent varier

selon le modèle. Les mesures peuvent varier de

±0,38 po (10mm).

Dometic recommande l’utilisation des outils et du

matériel suivants pour l’installation du produit.

Outils recommandés

Perceuse Tournevis

Scie Manomètre

Clé Outils de base pour la

connexion électrique

La page est en cours de chargement...

Dometic CRG3333BIFBB, CRG3335LIFBB Mode d'emploi

Marque: Dometic

Modèle: CRG3333BIFBB, CRG3335LIFBB

Catégorie: Cuisinières

Taper: Mode d'emploi

Télécharger le PDF

rapport

dans d''autres langues

English: Dometic CRG3333BIFBB, CRG3335LIFBB Operating instructions

Dometic CRG3333BIFBB, CRG3335LIFBB Mode d'emploi

Dometic CRG3333BIFBB, CRG3335LIFBB Mode d'emploi

dans d''autres langues

Documents connexes

Autres documents