Dometic RMD8501, RMD8505, RMD8551, RMD8555 Mode d'emploi

Marque: Dometic

Modèle: RMD8501, RMD8505, RMD8551, RMD8555

Catégorie: Frigos

Taper: Mode d'emploi

RECORD THIS INFORMATION FOR FUTURE REFERENCE

BEFORE INSTALLING THE UNIT:

Model No. Serial No.

Product No.

Date Purchased Place of Purchase

REFRIGERATOR MODEL

RMD 8501 RMD 8505

RMD 8551 RMD 8555

FOR YOUR SAFETY

If you smell gas:

1. Shut off gas supply at

main valve.

2. Open windows.

3. Don't touch electrical

switches.

4. Extinguish any open

flame.

5. Immediately call your

gas supplier.

WARNING!

Improper installation, adjustment,

alteration, service or maintenance

can cause injury or property dama-

ge. Refer to this manual. For assi-

stance or additional information

consult a qualified installer, service

agency or the gas supplier.

AVIS!

Cet appareil doit être réparé

seulement par un réparateur

autorisé. Modification de l'appareil

pourrait être extrèmement

dangeruse, et pourrait causer mal

ou mort.

FOR YOUR SAFETY!

Do not store or use gasoline

or other flammable vapors

and liquids in the vicinity of

this or any other appliance.

IMPORTANT INSTRUCTIONS

READ CAREFULLY

FOR CHILD SAFETY!

DANGER: Risk of child entrapment.

Before you throw away your old

refrigerator: Take off the doors, leave the shelves in place, so that

children may not easily climb inside.

For Mobile Home or Recreational Vehicle

Installation

Operation by LP Gas, 12V DC or 120V AC

OPERATING INSTRUCTIONS

Dometic Corporation

LaGrange, IN 46761

USA

289 0665 13

01/2014

FOR SERVICE CENTER

ASSISTANCE

CALL: 800-544-4881

USA

SERVICE OFFICE

The Dometic Corp.

2320 Indust. Parkway

Elkhart, IN 46516

Phone: 574-294-2511

CANADA

Dometic Corp.

46 Zatonski, Unit 3

Brantford, ON N3T 5L8

Canada

Phone: 519-720-9578

REFRIGERATOR

MODEL

RMD 8501 RMD 8505

RMD 8551 RMD 8555

FRANÇAIS PAGE 31

289 0457 13_USCD_EN_RMD85xx-Operation_N1_Layout 1 11.04.2014 12:37 Seite 1

DO NOT USE A FLAME TO CHECK FOR

GAS LEAKS

DANGER!

WARNING!

Electrical Grounding Instructions

This appliance is equipped with a three-

prong (grounding) plug for your protec-

tion against shock hazards and should

be plugged directly into a properly

grounded three-prong receptacle.

Do not cut or remove the grounding

prong from this plug.

Most LP gas appliances used in recrea-

tional vehicles are vented to the outside

of the vehicle. When parked close to a

gasoline pump, it is possible that the

gasoline fumes could enter this type of

appliance and ignite from the burner

flame, CAUSING A FIRE OR AN EXPLO-

SION.

FOR YOUR SAFETY, it is recommended

that all LP gas appliances which are

vented to the outside should be shut off

when refueling.

The refrigerator must be shut off during

refueling.

WARNING!

Work on gas equipment, exhaust system

and electrical facilities must be carried

out by authorised personnel only.

Substantial damage to property and/or

injury to persons can arise through

unprofessional procedures.

Never open the absorber cooling unit! It

is under high pressure.

There is a danger of injury!

WARNING!

It is imperative that the operating pressu-

re of the pressure reducer on the gas

system corresponds to the data speci-

fied on the rating plate of the refrigerator.

If the values are different, the appliance

can be damaged and a dangerous situa-

tion can be produced.

WARNING!

The refrigerator is not suitable for the

proper storage of medication. Please

observe in addition the instructions in the

medication package inserts.

WARNING!

Making ice cubes:

Only use drinking water!

WARNING!

Protect children:

When disposing of the refrigerator,

detach all refrigerator doors and leave

the storage racks in the refrigerator. In

this way inadvertent entrappment and

suffocation is prevented.

289 0457 13_USCD_EN_RMD85xx-Operation_N1_Layout 1 11.04.2014 12:37 Seite 2

CAUTION!

The refrigerator unit becomes very hot

during operation. Protect yourself

against contact with high temperature

parts when ventilation grilles are remo-

ved.

If the connection cable is damaged it

must be replaced by the Customer

Service at Dometic, or by respectively

qualified personnel, in order to prevent

any hazards.

As a basic rule, shut and lock the refrige-

rator before you start your journey!

CAUTION!

Changing the batteries :

n Remove discharged batteries.

n Replace the batteries completely.

n Do not mix different types of batteries.

n Observe the correct polarity !

n Do not connect non-rechargeable bat-

teries to a charger.

n Remove rechargeable batteries from

the battery compartment before char-

ging.

n Avoid short circuits on the contacts in

the battery compartment!

n Remove the batteries from the battery

compartment if the refrigerator will

not be used for a long time.

289 0457 13_USCD_EN_RMD85xx-Operation_N1_Layout 1 11.04.2014 12:37 Seite 3

1.0 General . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6

1.1 Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6

1.2 Guide to these operating instructions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .6

1.3 Copyright protection . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6

1.4 Explanation of symbols used in this manual . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6

1.5 Warranty . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7

1.6 Limitation of liability . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7

1.7 Customer services . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7

1.8 Spare parts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7

1.9 Environmental notices . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8

1.9.1 Disposal . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8

1.9.2 Energy-saving-tips . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8

2.0 Safety instructions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9

2.1 Application according to regulations . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .9

2.2 User's responsibility . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9

2.3 Protection of children when disposing of the equipment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9

2.4 Working upon and checking the refrigerator . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9

2.5 Information on coolant . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10

2.6 Operating the refrigerator with gas . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10

2.7 Safety instructions when storing foodstuffs . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10

2.8 Testing LP gas safety shutoff . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11

3.0 Description of model . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12

3.1 Model identification . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12

3.2 Refrigerator rating plate . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12

3.3 Technical data . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13

3.4 Description of refrigerator . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14

4.0 Refrigerator operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15

4.1 Cleaning . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15

4.2 Maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15

4.3 Electrical operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15

4.4 Gas operation (liquid gas) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16

4.5 Explanation of operating controls . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16

4.6 RMD 8xx1models . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18

4.6.1 Electrical operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18

4.6.2 Gas operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18

4.6.3 Setting of cooling compartment temperature . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18

4.7 RMD 8xx5 models . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18

4.7.1 Manual operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18

4.7.2 Automatic operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19

4.7.3 Setting of cooling compartment temperature . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19

4.7.4 Refuelling while in automatic mode operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19

4.7.5 Additional features . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19

4.8 Self-contained gas operation and optional battery compartment . . . . . . . . . . . . . . . . . . . . . . 20

4.8.1 Inserting / changing the batteries . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20

4.9 Frameheating . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21

4.10 Door locking . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21

4.10.1 Fastening and releasing the door lock hook when parking the vehicle . . . . . . . . . . . . . . . . . . . . . . . . . . 22

4.11 Lighting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22

4.12 Positioning the storage racks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22

Table of contents

289 0457 13_USCD_EN_RMD85xx-Operation_N1_Layout 1 11.04.2014 12:37 Seite 4

4.13 Storing food and making ice cubes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .23

4.13.1 Storing products in the cooling compartment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23

4.13.2 Storing products in the freezer compartment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23

4.13.3 Making ice cubes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23

4.13.4 Refrigerator compartments . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24

4.14 Shutting off the refrigerator . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24

4.15 Defrosting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24

4.16 Operation during low outside temperatures . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25

4.16.1 Installing the winter cover . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25

4.17 Changing the decor panel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 26

4.18 Troubleshooting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 27

4.19 Information on failure display and trouble-shooting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28

4.19.1 Status indicators . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28

Dometic GmbH

In der Steinwiese 16

D-57074 Siegen

www.dometic.com

289 0457 13_USCD_EN_RMD85xx-Operation_N1_Layout 1 11.04.2014 12:37 Seite 5

General

1.0 General

You have made an excellent choice in selec-

ting the Dometic Absorption Refrigerator. We

are sure that you will be satisfied with your

new refrigerator in all respects. The refrigera-

tor, which works silently, meets high quality

standards and guarantees the efficient utilisa-

tion of resources and energy throughout its

entire life cycle, during manufacture, in use

and when being disposed of.

1.1 Introduction

The information, texts and illustrations in these

instructions are copyright protected and are

subject to industrial property rights.

No part of these instructions may be reprodu-

ced, copied or utilised in any other way wit-

hout written authorisation by Dometic.

1.3 Copyright protection

Before you start using the refrigerator,

please read the operating instructions

carefully.

These instructions provide you with the neces-

sary guidance for the proper use of your refri-

gerator. Observe in particular the safety

instructions. Observation of the instructions

and handling recommendations is important

for dealing with the refrigerator safely and for

protecting you from injury and the refrigerator

from damage. You must understand what you

have read before you carry out a task.

Keep these instructions in a safe place

close to the refrigerator so they may be

referred to at any time.

1.2 Guide to these operating

instructions

1.4 Explanation of symbols

used in this manual

Warning notices are identified by symbols. A

supplementary text gives you an explanation

of the degree of danger.

Observe these warning notices rigorously.

You will thus protect yourself and other

people from injury, and the appliance from

damage.

Warning notices

DANGER indicates an imminent hazardous

situation which, if not avoided, could result in

death or serious injury.

DANGER!

WARNING indicates a potentially hazardous

situation which, if not avoided, could result in

death or serious injury

WARNING!

WARNING indicates a potentially hazardous

situation which, if not avoided, could result in

death or serious injury

CAUTION!

CAUTION (used without the safety alert sym-

bol) indicates a potentially hazardous situation

which, if not avoided, may result in damage to

the appliance.

CAUTION!

289 0457 13_USCD_EN_RMD85xx-Operation_N1_Layout 1 11.04.2014 12:37 Seite 6

General

Information

INFORMATION gives you supplementary and

useful guidance when dealing with your refrige-

rator.

Environmental Tips

ENVIRONMENTAL TIPS gives you useful gui-

dance for saving energy and disposal of the

appliance.

Warranty arrangements are in accordance

with the normal conditions applicable for the

country concerned. Please contact your

dealer in the event of a warranty claim.

Any damage due to improper use is not cover-

ed by the warranty. The warranty does not

cover any modifications to the appliance or

the use of non-original Dometic parts. The

warranty does not apply if the installation and

operating instructions are not adhered to and

no liability shall be entertained.

1.5 Warranty

All information and guidance in these opera-

ting instructions were prepared after taking

into consideration the applicable standards

and regulations as well as the current state of

the art. Dometic reserves the right to make

changes at any time which are deemed to be

in the interest of improving the product and

safety.

1.6 Limitation of liability

Dometic will assume no liability for damage in

the case of :

n non-observation of the operating instructi-

ons

n application not in accordance with the

regulations or provisions

n use of non-original spare parts

n modifications and interferences to

the appliance

Dometic offers a customer service network.

Find your authorised customer service centre

by calling the phone number indicated on the

front page. You can also obtain the address

information of the nearest customer service

from www.dometic.com. When contacting

Dometic Customer Services, please state the

model, product number and serial number

together with the MLC code, if applicable. You

will find this information on the rating plate

inside the refrigerator. We recommend that

you note this data in the field provided on the

front page of this operation manual.

1.7 Customer services

1.8 Spare parts

You can order parts directly from Dometic by

calling the retail sales department at 1-800

544 4881. Please be sure to have your model

number available so the correct parts list can

be obtained.

289 0457 13_USCD_EN_RMD85xx-Operation_N1_Layout 1 11.04.2014 12:37 Seite 7

General

n At an average ambient temperature of 77°F

(25°C), it is sufficient to operate the refrige-

rator at middle thermostat setting.

n Where possible, always store precooled

products.

n Do not expose the refrigerator to direct

sunlight or any other heat source (e.g. hea-

ter).

n Ensure that air circulation of the refrigerati-

on unit is not obstructed.

n Arrange the shelves evenly in the refrigera-

tor (in the cooling compartment) in order to

achieve the most efficient use of energy.

1.9.2 Energy-saving-tips

Refrigerators manufactured by Dometic are

free of CFC/HCFC and HFC. Ammonia (a

natural compound of hydrogen and nitrogen)

is used in the cooling unit as a coolant. Non-

ozone-hazardous cyclopentane is used as a

propellant for manufacturing PU foam insulati-

on.

In order to ensure that the recyclable packa-

ging materials are re-used, they should be

sent to the customary local collection system.

The appliance should be transferred to a suit-

able waste disposal company that will ensure

re-use of the recyclable components and pro-

per disposal of the rest. For eco-friendly drai-

ning of the coolant from all absorber refrigera-

tion units, a suitable disposal plant should be

1.9 Environmental notices

1.9.1 Disposal

n Do not overfill the storage grids and com-

partments to prevent obstructing the inter-

nal air circulation.

n Maintain a clearance of approx. 0.4 inches

(10 mm) between chilled products and

post-evaporator ("cooling fins").

n Defrosting at regular intervals saves energy

(see section "Defrosting").

n Open the refrigerator door only for a short

period of time when removing products.

n Run the refrigerator for about 12 hours

before filling it.

Do not dispose of batteries in domestic waste.

Take your used batteries to your dealer or a

collection point.

Forced ventilation: To achieve a better air cir-

culation at high ambient temperatures, this

appliance is equipped with an additional fan.

289 0457 13_USCD_EN_RMD85xx-Operation_N1_Layout 1 11.04.2014 12:37 Seite 8

Safety instructions

2.0 Safety instructions

The refrigerator is not suitable for the

proper storage of medication. Please

observe in addition the instructions in the

medication package inserts.

WARNING!

This refrigerator is designed for installation in

recreation vehicles such as caravans or

motorhomes. The appliance has been type-

approval tested for this application.

The refrigerator is to be used solely for storing

foodstuffs.

2.1 Application according to

regulations

2.4 Working upon and checking

the refrigerator

2.3 Protection of children when

disposing of the equipment

When disposing of the refrigerator,

detach all refrigerator doors and leave the

storage racks in the refrigerator. In this

way inadvertent entrappment and suffo-

cation is prevented.

WARNING!

Work on gas equipment, exhaust system

and electrical facilities must be carried

out by authorised personnel only.

Substantial damage to property and/or

injury to persons can arise through

unprofessional procedures.

WARNING!

Never use an unshielded flame to check

gas bearing parts and pipes for leakage!

There is a danger of fire or explosion.

DANGER!

Never open the absorber cooling unit! It is

under high pressure.

There is a danger of injury!

WARNING!

Anyone operating the refrigerator must be

familiar with the safe handling and understand

the advice in these operating instructions.

Children may only operate the appliance, if

they have been made aware of how to opera-

te the refrigerator safely and the dangers

attending incorrect operation.

2.2 User's responsibility

289 0457 13_USCD_EN_RMD85xx-Operation_N1_Layout 1 11.04.2014 12:37 Seite 9

Safety instructions

2.5 Information on coolant

Ammonia is used as a coolant.

This is a natural compound also used in hou-

sehold cleaning agents (1 litre of Salmiak

cleaner contains up to 7.05 oz (200g) of

ammonia - about twice as much as is used in

the refrigerator). Sodium chromate is used for

corrosion protection (1.8% by weight of the

solvent).

In the event of leakage (easily identifiable from

the strong odor), proceed as follows:

- Switch off the appliance.

- Air the room thoroughly.

- Inform authorised customer services.

For your safety it was ascertained in an

expert's report that no impairment of health

exists when the coolant is discharged.

No refrigerator of any kind can improve the

quality of the food; refrigerators can only

maintain the food's quality for a short dura-

tion as from the time of storing it.

Please observe the following particular

conditions for storing food in a refrigerator

that is built into a vehicle:

n A change in the climatic conditions such as

temperature fluctuations

n High temperatures inside the vehicle when

it is closed and parked in direct sunlight

(temperatures are possible up to 122°F

(50°C) )

n Use of the refrigerator during travel with the

power supply of 12V DC

n A refrigerator built in behind a window and

exposed to direct sunlight

n Storing the products too soon, i.e. shortly

after starting up the appliance for use.

Under these particular conditions the refrige-

rator cannot guarantee reaching the tempera-

ture needed for perishables.

Perishables include all products with a stipula-

ted use-by date and a minimum storage tem-

2.7 Safety instructions when

storing foodstuffs

It is imperative that the operating pressure

corresponds to the data specified on the

rating plate of the appliance. Compare the

operating pressure of the rating plate with the

data specified on the pressure reducing valve

of the liquid gas cylinder.

2.6 Operating the refrigerator

with gas

WARNING!

Operating the appliance with gas is not

permitted

n at petrol stations

n on ferry boats

n while transporting the caravan/motor-

home by a transporter or breakdown

vehicle.

There is the danger of fire!

Leave the equipment switched off.

If you smell gas:

* authorised specialist personnel

Authorised specialist personnel are accredited

experts who are able, by virtue of their training and

knowledge, to vouch that the inspection and repair

work has been carried out properly.

n Open all windows and leave the room.

n Do not operate any electrical equipment

and prevent the use of open flames.

n Close the locking tap of the gas supply and

the valve on the cylinder.

n Contact authorised specialist personnel*

for advice.

289 0457 13_USCD_EN_RMD85xx-Operation_N1_Layout 1 11.04.2014 12:37 Seite 10

Safety instructions

perature of 39.2°F (+4°C) or less, especially for

meat, poultry, fish, sausages, pre-packed

foods.

n Pack raw and cooked foods separately

(e.g. in containers, aluminium foil, etc.).

n Only remove the outside packaging of

single packs if all the necessary informati-

on, e.g. the use-by date, can also be read

on the single packs.

n Do not leave cooled goods outside the

refrigerator for too long.

n Place the foods with the next use-by date

at the front, accordingly.

n Pack away any left-over food and eat at the

first opportunity.

n Wash your hands before and after handling

any food.

n Regularly clean the inside of the refrigera-

tor.

Please observe the instructions and informati-

on regarding the use-by date on the outside

packaging of the food.

Please observe section

"4.1 Cleaning"

of this

instruction.

2.8 Testing LP gas safety shutoff

When testing the gas supply system at test

pressures in excess of 1/2 psig (3.5 kPa), the

refrigerator and its individual shutoff valve

must be disconnected from the gas supply

piping system.

When testing the gas supply system at pres-

sures less than or equal to 1/2 psig (3.5 kPa),

the appliance must be isolated from the gas

supply piping by closing its individual manual

shutoff valve.

In case detailed instructions on the installation

and connection to the gas supply are required,

contact your dealer or distributor.

The gas safety shutoff must be tested after the

refrigerator is connected to LP gas supply.

To test the gas safety shutoff, proceed as fol-

lows:

n Start the refrigerator according to the

instructions for LP Gas Operation. See

"Section 4.6.2. Gas operation"

n Check that the gas flame is lit. Allow it to

burn a few minutes to ensure a full, stable

flame.

n Keep button (1) (FIG. 10, PG. 18) pressed

for 3 seconds. The display disappears and

the appliance is fully switched off.

Within 1-2 seconds the gas valve should

automatically close. The flame is off.

n Apply a commercial leak detection solution

to the burner jet. No bubbles should ap-

pear.

Bubbles indicate a gas leak and the safety

valve must be replaced by a qualified ser-

viceman.

n Rinse the burner jet with water. Light the

burner and allow it to burn for five minutes.

289 0457 13_USCD_EN_RMD85xx-Operation_N1_Layout 1 11.04.2014 12:37 Seite 11

Fig. 1

Description of model

3.0 Description of model

3.1 Model identification

1 = manual energy selection, automatic ignition

(MES)

5 = automatic and manual energy selection,

automatic ignition (AES)

Example :

RM D 8 5 5 1

1 = MES* / 5 = AES*

Model range "8"

Refrigerator Mobile /

Mobile Absorption Refrigerator

Double door refrigerator

3.2 Refrigerator rating plate

Model number

Product number

Serial number

Electrical rating details

Gas pressure

289 0457 13_USCD_EN_RMD85xx-Operation_N1_Layout 1 11.04.2014 12:37 Seite 12

Fig. 2

RMD 8551

RMD 85xx

Example

The rating plate is to be found on the inside of

the refrigerator. It contains all important details

of the refrigerator. You can read off from this

the model identification, the product number

and the serial number. You will need these

details whenever you contact the customer

service centre or when ordering spare parts.

Description of model

3.3 Technical data

Model Dimensions Gross capacity (Cu.ft.)

Rating details

Consumption * Net Ignition

H x W x D (inches) mains/battery electricity/gas weight Piezo Automat

Depth incl. door freezer compartm. over 24hrs

RMD 8501

(mm) (lit.)

RMD 8505

(mm) (lit.)

RMD 8551

(mm) (lit.)

RMD 8555

(mm) (lit.)

49x20.6x22.32

1245x523x567

49x20.6x22.32

1245x523x567

49x20.6x24.50

1245x523x622

49x20.6x24.50

1245x523x622

5.65

160

5.65

160

6.71

190

6.71

190

88.2 lb

40 kg

88.2 lb

40 kg

91.5 lb

41.5 kg

91.5 lb

41.5 kg

1.06

1.23

250 W / 170 W

•

ca.4.2 KWh / 15.5 oz

440g

ca.4.2 KWh / 15.5 oz

440g

ca.4.2 KWh / 15.5 oz

440g

ca.4.2 KWh / 15.5 oz

440g

289 0457 13_USCD_EN_RMD85xx-Operation_N1_Layout 1 11.04.2014 12:37 Seite 13

3.4 Description of refrigerator

Freezer compartment

Operating controls

Post-evaporator for cooling compartment

Condensation water drain channel

Data plate

Vegetable bin

Upper door shelf with flap, egg shelf available as option may be inserted

Lower door shelf with bottle holders

Fig. 3

Description of model

289 0457 13_USCD_EN_RMD85xx-Operation_N1_Layout 1 11.04.2014 12:37 Seite 14

4.0 Refrigerator operation

Refrigerator operation

The refrigerator is equipped to operate on

three power modes:

n Mains voltage (120V AC)

n Direct-current voltage (12V DC)

n Gas (propane)

Select the desired power mode by the energy

selector button. Appliances with automatic

energy selection (AES) are additionally provi-

ded with "automatic mode" function. Then the

AES system automatically selects the best

energy source for each particular situation.

4.1 Cleaning

Before starting up the refrigerator, it is recom-

mended that you clean it inside and repeat this

at regular intervals.

Use a soft cloth and lukewarm water with a

mild detergent. Then wipe out the appliance

with clean water and dry thoroughly.

Keep the condensation water drain channel

free of deposits.

To avoid material alterations, do not use soap

or hard, abrasive or soda-based cleaning

agents. Do not allow the door seal to come

into contact with oil or grease.

4.2 Maintenance

4.3 Electrical operation

12V-voltage (on-board power supply)

The refrigerator should only be used in

12VDC-operation while the vehicle’s engi-

ne is running, otherwise the on-board-

battery would be discharged within a few

hours!

CAUTION!

n In compliance with the applicable regulati-

ons, please note that the gas unit and the

connected ventilation ducts must be chec-

ked by authorised technical personnel after

first use and after every other year for com-

pliance with the European Standard EN

1949. A test certificate has to be issued. It

is the user's responsibility to arrange

this test.

n The gas burner must be inspected and

cleaned as necessary at least once a

year. When using liquefied petroleum

gas (tank or refill cylinders) the mainten-

ance interval is reduced to half-yearly or

quarterly.

Keep the evidence of maintenance work

carried out on your refrigerator.

n Work on gas and electrical equipment

shall be carried out by qualified person-

nel only.

It is recommended that this is carried out

by an authorised customer services depart-

ment.

We recommend maintenance following an

extended shutdown of the vehicle. Please

contact our customer services.

n When the appliance is first put into operati-

on, there may be a mild odour which will

disappear after a few hours.

n Park the vehicle level, particularly when

starting up the refrigerator and filling with

food before starting a journey.

n The cooling unit is silent in operation.

n The refrigerator will take several hours to

reach its operating temperature in the coo-

ling compartment. The freezer compart-

ment should be cold about one hour after

switching on the refrigerator.

289 0457 13_USCD_EN_RMD85xx-Operation_N1_Layout 1 11.04.2014 12:37 Seite 15

Refrigerator operation

The control panel buttons are not accessible

when the refrigerator door is closed. Open the

bottom door to reach the operating buttons.

Depending on the door opening direction,

there are two LEDs on the left or right edge of

the control panel. The outer LED (1) indicates

that the refrigerator is operational (blue). The

other LED (2) lights red in the event of a fault.

Fig. 5

Mains power (120V)

This option should only be selected where

the supply voltage of the connection for

power supply corresponds to the value

specified on the data plate. Any difference

in values may result in damage the appli-

ance.

CAUTION!

4.4 Gas operation (Liquid gas)

Prior to starting the refrigerator in gas

mode :

n Open the gas cylinder valve.

n Open the shut-off valve for gas supply to

the refrigerator.

As a basic rule, gas operation is prohibi-

ted in petrol stations!

WARNING!

Operating controls without battery compartments

Fig. 6

Operating controls with battery compartments (L, R)

L R

Refrigerators for self-contained (gas) opera-

tion contain two battery compartments in the

control panel which are located on the left and

right next to the button bar.

n The refrigerator must be operated using

liquid gas (propane) (no natural gas or

town gas).

n When using LPG gas, please consider that

the burner needs cleaning at shorter inter-

vals due to the gas combustion method (2

- 3 times per year recommended.

n In Europe, gas operation is permitted while

travelling only on the condition that the gas

system of the vehicle is equipped with a

hose rupture protection. The national regu-

lations of the respective country must be

observed.

n For physical reasons, gas ignition faults

could occur starting from an altitude above

sea level of approx. 3280 ft. / 1000 m (No

malfunction!)

n On the initial refrigerator start-up or after a

cylinder change, air may be trapped in the

gas line. To purge the air from the lines,

switch on the refrigerator and any other gas

appliances (e.g. stove) for a short time. The

gas ignites without delay.

n Each refrigerator with manual ignition is

equipped with an automatic flame safety

valve which interrupts the gas supply auto-

matically after approx. 30 seconds when

the flame has extinguished.

4.5 Explanation of operating

controls

Proceed to the description that applies

to YOUR model.

NOTE!

Fig. 4

Indicator LEDs

289 0457 13_USCD_EN_RMD85xx-Operation_N1_Layout 1 11.04.2014 12:37 Seite 16

Refrigerator operation

Fig. 7

Fig. 8

Manual energy selection / automatic igniti-

on MES (RMD 8xx1) :

1 = Power ON/OFF switch

= Energy selector button 120V~

= Energy selector button GAS

= Energy selector button 12V-

= Pushbutton ON/OFF frameheating

= Temperature level selection

= Temperature level display

= Indicator LED failure /

Reset button GAS FAILURE

1 2 3 4 6 7 8 9

120V AC operation

n Select "Mains voltage" by pressing button (2)

n Set temperature step by pressing button (7)

Switching ON/OFF

n Switch ON by pressing button (1), 2s

n Switch OFF by pressing button (1), > 2s

12V DC operation (vehicle’s battery)

n Select "Battery voltage" by pressing button

(4)

n Set temperature step by pressing button (7)

Gas operation

n Select "Gas" by pressing button (3)

n Set temperature step by pressing button (7)

Manual operation

n Select energy source with buttons (2,3,4)

n Set temperature step by pressing button (7)

Switching ON/OFF

n Switch ON by pressing button (1), 2s

n Switch OFF by pressing button (1), > 2s

Automatic operation

n Change over to "Automatic" with button (5)

Automatical energy selection (if available)

Sequence of priority: 1.) Solar (12V -)

2.) 120V~

3.) 12V-

4.) Liquid gas

n Set temperature step by pressing button (7)

Automatic energy selection / automatic

ignition AES (RMD 8xx5) :

1 = Power ON/OFF switch

= Energy selector button 120V~

= Energy selector button GAS

= Energy selector button 12V-

= Selector button "AUTOMATIC"

= Pushbutton ON/OFF frameheating

= Temperature level selection

= Temperature level display

= Indicator LED failure /

Reset button GAS FAILURE

1 2 3 4 5 6 8 97

289 0457 13_USCD_EN_RMD85xx-Operation_N1_Layout 1 11.04.2014 12:37 Seite 17

Refrigerator operation

Fig. 9

To start the refrigerator, press button (1) for 2

seconds.

The refrigerator starts with the last selected

type of energy.

120V operation :

Press button (2) :

12V operation :

Press button (4) :

4.6.1 Electrical operation

Fig. 10

Gas operation :

Press button (3) :

The ignition process is activated automatical-

ly by means of an automatic igniter.

The flame extinguishes after reaching the pre-

set cooling compartment temperature and

ignites again if the cooling compartment tem-

perature increases again. If the flame is not lit

after the first ignition attempt, the automatic

igniter repeats the ignition twice (duration 30 s)

at time intervals of 2 minutes. If the flame is

not lit afterwards, a fault is indicated.

4.6.2 Gas operation

Fig. 11

4.6.3 Setting of cooling compartment

temperature

MES-appliances (manual energy selection)

4.6 RMD 85x1 models

To start the refrigerator, press button (1) for 2

seconds.

The refrigerator starts with the last selected

type of energy.

230V operation :

Press button (2) :

12V operation :

Press button (4) :

Gas operation :

Press button (3) :

Fig. 12

Select the desired cooling compartment tem-

perature by pressing button (7) .

The LED display (8) of the selected temperatu-

re setting is illuminated.

The scale starts with MIN position at the left

LED position (small bar = highest temperature)

and climbs up to MAX position at the right

LED position (large bar = lowest temperature).

Note: The temperature levels do not relate to

absolute temperature values.

4.7.1 Manual operation

AES appliances

(manual + automatic energy selection)

4.7 RMD 85x5 models

289 0457 13_USCD_EN_RMD85xx-Operation_N1_Layout 1 11.04.2014 12:37 Seite 18

Refrigerator operation

In order to prevent unintended switching to

gas operation during refuelling, the electronic

system starts gas operation of the refrigerator

after the motor has been turned off for 15

minutes. During this period the appliance is

ready for operation ("stand-by"). The tempera-

ture level LEDs do not light then while all other

indicators remain active.

The use of unshielded flames is prohibited

in petrol station environments.

Should the refuelling stop last longer than

15 minutes, the refrigerator has to be swit-

ched off or switched over to another ener-

gy type.

WARNING!

4.7.5 Additional features (MES / AES)

To start the refrigerator, press button (1) for 2

seconds.

The refrigerator starts with the last selected

type of energy.

Automatic operation :

Press button (5) : A

Upon switching on, the electronics automati-

cally selects one of the three possible energy

types: 120V - 12V - liquid gas. The control

electronics automatically ensures that the

refrigerator is supplied with the optimum sour-

ce of energy in each respective case.

Sequence of priority: 1.) Solar (12V-)

2.) 120V~

3.) 12V-

4.) Liquid gas

If sufficient mains voltage is available (more

than 195 V), this power source is selected as

prime option. If a solar system capable of

powering the refrigerator is installed, the solar

12V supply takes priority.

The 12V operation is otherwise only effective

while the engine is running.

According to the sequence of priority the elec-

tronics selects GAS as energy source only, if

both of the electrical energy source are not

available.

Manual operation is possible at any time.

Fig. 13

4.7.2 Automatic operation

4.7.4 Refuelling while in AES mode

operation

4.7.3 Setting of cooling compartment

temperature

See point

4.6.3 Setting of cooling compart-

ment temperature

n The brightness of the display reduces after

a few seconds if no other buttons are pres-

sed. The indicator lights again if a button is

pressed. Press the button again to activate

the required function.

n Failures are indicated by flashing of the fai-

lure indicator LED.

n Should the door be kept open for too long

(more than 2 minutes), an acoustic signal is

initiated (pulsing whistle tone).

n Should the electronic control detect any fai-

lure, an acoustic signal will sound (pulsing

whistle tone). At the same time the display

starts flashing (for trouble-shooting, please

refer to section

Information on failure dis-

play and trouble-shooting

289 0457 13_USCD_EN_RMD85xx-Operation_N1_Layout 1 11.04.2014 12:37 Seite 19

Refrigerator operation

Fig. 14

Left battery compartment

Fig. 16

Opening right battery compartment

Fig. 15

Opening left battery compartment

Fig. 17

4.8.1 Inserting / changing the batteries

open

press

open

Switch off the refrigerator, as described in sec-

tion

Shutting of the refrigerator

n Remove discharged batteries.

n Replace the batteries completely.

n Do not mix different types of batteries.

n Observe the correct polarity !

n Do not connect non-rechargeable bat-

teries to a charger.

n Remove rechargeable batteries from

the battery compartment before char-

ging.

n Avoid short circuits on the contacts in

the battery compartment!

n Remove the batteries from the battery

compartment if the refrigerator will not

be used for a long time

CAUTION!

Protect the environment!

Do not dispose of batteries in domestic waste.

Take your used batteries to your dealer or a

collection point.

An optional battery compartment in the elec-

tronics case for internal (self-contained) power

supply of the electronics is available for the

model variants RMD 85x1 (appliances with

electronics).

4.8 Gas operation with internal

batteries (option)

Load the battery compartment with batteries

(8 x AA 1.5 V) before operating the refrigerator.

Batteries are not included !

All operating modes can be selected while the

on-board 12 V DC power supply is active. The

battery compartment is disconnected from the

power supply.

If the vehicle on-board 12 V DC power supply

is not present or there is an interruption of the

mains power supply during operation, the

electronics automatically switch to the appli-

ance internal battery power supply.

The refrigerator can now only be operated

in the gas mode.

All LED indicators except the GAS LED are not

lit during operation with the batteries inside

the appliance. The GAS LED flashes every 15

seconds.

If a button is pressed, the temperature level

LEDs (7, Fig. 7,8) also light.

If the voltage of the battery inside the applian-

ce is too low, an acoustic signal (whistle tone)

sounds every 15 seconds.

Then replace the batteries in the battery com-

partment.

Self-contained gas operation

289 0457 13_USCD_EN_RMD85xx-Operation_N1_Layout 1 11.04.2014 12:37 Seite 20

La page charge ...

Dometic RMD8501, RMD8505, RMD8551, RMD8555 Mode d'emploi

Marque: Dometic

Modèle: RMD8501, RMD8505, RMD8551, RMD8555

Catégorie: Frigos

Taper: Mode d'emploi

Télécharger le PDF

rapport

dans d''autres langues

English: Dometic RMD8501, RMD8505, RMD8551, RMD8555 Operating instructions

Dometic RMD8501, RMD8505, RMD8551, RMD8555 Mode d'emploi

Dometic RMD8501, RMD8505, RMD8551, RMD8555 Mode d'emploi

dans d''autres langues

Documents connexes