Bauknecht ACK 6400 IN Mode d'emploi

INSTRUCTIONS AND ADVICE

FOR INSTALLING, USING AND SERVICING

OF COOKERS

Model: ACK6400IN

GB

461308296_02/2014

2

The appliance was designed and made in accordance with the European standards listed

below:

=> EN 30-1-1, EN 30-2-1 and EN 437 plus subsequent amendments (gas)

=> EN 60 335-1 and EN 60 335-2-6 (electrical) plus relative amendments

The appliance complies with the prescriptions of the European Directives as below:

=> 2006/95 EC concerning electrical safety (BT).

=> 2004/108 EC concerning electromagnetic compatibility (EMC)

=> 2009/142 CE concerning gas safety.

-----------------------------------------------------------------------------------------------------------------------------------------

Oven accessories that could come into contact with foodstuffs are made with materials that comply with

the provisions of the 89/109 EC directive dated 21/12/88.

---------------------------------------------------------------------------------------------------------------------------------------------------

This product complies with EU Directive 2002/96/EC.

The crossed-out dustbin symbol reported on the appliance indicates that the appliance

must be disposed of separately from other domestic refuse at the end of its useful life.

It must therefore be delivered to a waste recycling centre specically for electric and electronic

equipment or returned to the retailer at the moment of purchase of a new equivalent appliance.

The user is responsible for delivering the appliance to the appropriate collection centre at the end of

its useful life, Failure to do so may result in a ne, as provided for by laws governing waste disposal.

Differential collection of waste products for eventual recycling, treatment and environmentally friendly

disposal helps reduce possible negative effects on the environment and health, and also enables the

materials making up the product to be recycled.

For more detailed information on the available refuse collection systems, refer to the local Municipal

Solid Waste disposal centre or the shop where the product was purchased.

Producers and importers are responsible for fullling their obligations as regards recycling, treatment

and environmentally friendly disposal by directly or indirectly participating in the collection system.

3

ASSISTANCE AND SPARE PARTS

3

IMPORTANT NOTES AND PRECAUTIONS FOR USE

4-6

DESCRIPTION OF THE APPLIANCE

7-8

INSTRUCTIONS FOR THE USER

9-15

TROUBLESHOOTING

16

TECHNICAL FEATURES

16-17

INSTRUCTIONS FOR THE INSTALLER

18-25

CONTENTS

Before this appliance left the factory it was tested and ne-tuned by specialised expert personnel in

order to guarantee its best functioning results.

Any subsequent repairs or adjustments that may be necessary must be done with the maximum of

care and attention by qualied personnel.

For this reason we recommend you always contact our Service Centre specifying the brand, the

model, its serial number and type of problem you are facing with it. All data related to your appliance

are printed on the data label afxed behind the appliance as well as on its original packaging.

A duplicate data label is contained in this booklet also. Please attach this label on the handbook or to

an accessible surface near by the appliance for easy reference.

This information enables the technical assistant to come and visit you with the correct spares and

guarantee a prompt and suitable service.

You will only nd original spare parts at our Service Centre and authorised dealers.

ASSISTANCE AND SPARE PARTS

4

IMPORTANT NOTES AND PRECAUTIONS FOR USE

You have purchased one of our

products for which we thank you. We

are condent that this new appliance,

modern, functional and practical, made

with top quality materials, will meet all

your demands. This new appliance

is easy to use but before installing

and using it, it is important to read

this handbook through carefully.

It provides information for a safe

installation, use and maintenance. Keep

this handbook in a safe place for future

reference.

The manufacturer reserves the right

to make all the modications to its

products that it deems necessary

or useful, also in your interests,

without prejudicing its essential

functional and safety characteristics.

The manufacturer cannot be held

responsible for any inaccuracies due to

printing or transcription errors that may

be found in this handbook.

N.B.: the pictures shown in the gures in

this handbook are purely indicative.

• The installation, adjustments,

conversions and maintenance

operations listed in section

«INSTRUCTIONS FOR THE

INSTALLER» must only be carried out

by authorised personnel .

• The installation of all-gas and combi

appliances must comply with the

standards in force.

• The appliance must only be used for

its original purpose, that is, cooking

for domestic use. Any other use is

considered improper and, as such,

dangerous.

• The manufacturer cannot be held

responsible for any damage to persons

or property resulting from an incorrect

installation, maintenance or use of the

appliance.

• Once the packaging has been

removed from the outer surfaces and

the various inner parts, thoroughly

check that the appliance is in perfect

condition. If you have any doubts do

not use the appliance and call in an

authorised person.

• The packaging materials used

(cardboard, plastic bags, polystyrene

foam, nails, etc.) must not be

left within easy reach of children

because they are a potential hazard

source. All packaging materials used

are environmentally-friendly and

recyclable.

• The electrical safety of this appliance

is only guaranteed if it is correctly

connected to a suitable earth system,

as prescribed by the electrical safety

standards. The manufacturer disclaims

all responsibility if these instructions

are not followed. Should you have

any doubts, seek the assistance of an

authorised person.

• Before connecting the appliance

ensure that the rating plate data

corresponds to that of the gas

and electricity supply (see section

«TECHNICAL FEATURES»).

• NOT FOR USE IN MARINE CRAFT,

CARAVANS OR MOBILE HOMES

UNLESS EACH BURNER IS FITTED

WITH A FLAME SAFEGUARD.

• DO NOT MODIFY THIS APPLIANCE

• DOMESTIC USE ONLY

WARNING - The appliance and its

accessible parts become hot during

use. Care should be taken to avoid

touching heating element. Children

less than 8 years of age shall be kept

away unless continuosly supervised.



5

IMPORTANT NOTES AND PRECAUTIONS FOR USE

• The oven door glass and the

accessible parts will become hot

when in use. To avoid burns and

scalds young children should be

kept away.

• Do not use this appliance as a space

heater.

• Do not touch any electrical appliance

if hands or feet are wet or damp.

• Do not use the appliance bare

footed.

• Do not pull the power lead to take the

plug out of the socket.

• Do not leave the appliance outside

under the sun, rain, etc.

• Young children should be supervised

to ensure that they not play with the

appliance.

• This appliance can be used by

children aged from 8 years and

above and persons with reduced

physical, sensory or mental

capabilities or lack of esperience

and knolegde if they have been

given supervision or instruction

concerning use of the appliance

in a safe way and understand the

hazards involved.Children shall not

play with the appliance. Cleaning

and user maintenance shall not

be made by children with out

supervision.

• WARNING - ln order to prevent

accidental tipping of the appliance, for

example by a child climbing over the

open oven door, or too high weights

are leant on the open oven door, two

chains must be screwed on the back

on the cooker and xed to the wall

with hooks .Ensure the chains are

taut .Please refer to instructions for

installation..

• Before cooking for the rst time,

ensure the oven is empty and its door

closed, heat the oven at maximum

temperature for two hours. This will

allow the protective coating on the

interior of the oven to be burnt off

and dissipate the associated smells.

Ensure adequate ventilation in the

cooker whilst burning off and don’t

be alarmed by a little bit of smoke

during this process.

• The instructions for ovens that

have the shelves should indicate

in detail the correct installation of

the shelves. The rear stopper of

the oven rack must be positioned

upwards.

• Unattended cooking on a hob with

fat or oil can be dangerous and may

result in re.

• Never try to extinguish a re with

water, but switch of the appliance

and then cover ame e.g. with a

lide or a re blanket .

• Danger of re: Do not store items

on the cooking surfaces

• Do not use harsh abrasive cleaners

or sharp metal scrapers to clean

the oven glass door since they can

scratch the surface, which may

result in shattering of the glass.

• NEVER use sponges or abrasive

products, and solvents to remove

stains or adhesives on the painted

or stainless steel surfaces.

• Switch off the oven before removing

the fan guard for cleaning. Replace

the guard after cleaning in

accordance with the instructions.

• The oven can be equipped with

temperature probe. Only use the

temperature probe recommended

for this oven by our Service

Centre.

• Remove any spillage from the lid

before opening.

6

IMPORTANT NOTES AND PRECAUTIONS FOR USE

• The appliance is not intended to be

operated by means of an external

timer or separate remote-control

system

• Ensure that the appliance is

switched off before replacing the

lamp to avoid the possibility of

electric shock..

• The cookers can be equipped with

a small compartment under the

oven that can be used for storing

things Remember that the surfaces

become hot, it is strictly forbidden to

place inammable materials inside.

• Do not use a steam cleaner to clean

a hob, oven or range.

• The appliance is to be placed directly

on the oor and shall not be mounted

on a base.

• If the appliance is tted with a glass

lid, this can shatter when heated.

Turn off all the burners or disconnect

all the plates, and allow them to cool

before closing the lid (g.3)

• Avoid using the oven as a larder or as

a saucepan cupboard when you are

not using it for cooking: if the oven is

turned on accidentally it could cause

damage and accidents.

• If you are using an electrical socket

near the appliance, make sure that

the cables are not touching the cooker

and are far enough away from all hot

parts.

• When you have nished using the

appliance check that all the controls are

in the off or closed position, checking

that the “0” of the knob corresponds to

the “

•” symbol serigraphed on the front

panel.

• Switch off the electrical supply before

you start cleaning or servicing the

appliance.

• In the case of a failure or malfunction,

turn the appliance off and switch off

the electrical supply and do not tamper

with it. All repairs or adjustments must

be carried out with maximum care and

the proper attention of an authorised

person.

• For this reason we recommend you

call our Service Centre.

7









1

2

DESCRIPTION OF THE APPLIANCE

PRESENTATION

The cooker is tted with the hob all gas and the gas

burners are supplied with safety thermocouples

Each knob on the front panel has a diagram printed

above it showing to which burner or hotplate it refers.

The combination of the different sized burners offers

the possibility of various types of cooking.

The cookers are tted with different oven: all gas or

gas and electric grill or all electric oven.

The oven walls are tted with various runners (g. 1)

on which the following accessories can be placed.

Supply and quantities vary from model to model

(g. 2):

• oven shelf rack

• drip tray

• set spit

The cookers can be tted with a small compartment

under the oven which can be used for the storage of

items or to keep food warm when the oven is in use.

Do not use for storing inammable materials.

8

DESCRIPTION OF THE APPLIANCE

DESCRIPTION OF THE CONTROLS

HOB GAS BURNER KNOB (A)

By rotating the knob in an anticlockwise direction, the

following symbols appear:

0 = Closed position

= “Full on” position

= “Reduced rate” position

THERMOSTAT KNOB FOR GAS OVEN/GRILL (B)

By rotating the knob in an anticlockwise direction, the

following functions appear:

0 = Closed position

from Min to Maxi (260°C)

= Oven temperatures

Turn the knob clockwise if you want to use the gas grill

or the electric grill















B

























D



C

LIGHT AND ROTISSERIE COMMUTATOR

KNOB (C)

By turning the knob clockwise or anti clockwise

we will nd the following symbols:

TIMER (D)

To set cooking time, rst wind the timer up by turning it

completely once from left to right and then back to the

number of minutes you want. The timer will ring when

the set time has elapsed.

A

9

HOB: GENERAL NOTES ON SAFETY

• When using the burners or the plates, do not leave

the appliance unsupervised. Ensure that children

do not play with the appliance. In particular, make

sure that pan handles are positioned correctly and

supervise the cooking of foods which use oils and

fats, as these are highly inammable.

• Do not use aerosols or sprays near the appliance

when it is in use.

• If the appliance is tted with a lid, remove any food

residues on the surface before opening.

• If the appliance is tted with a crystal glass lid, this

can shatter when heated. Turn off all the burners

and to attend that is cooled, before closing the lid

(g. 3).

• Even after use, the burners or the plates remain

hot for a long period; to avoid burning, do not place

hands or other objects on them.

• After using the appliance, ensure that all the controls

are in the closed or off position.

When a gas cooker is being used it produces heat

and humidity in the room where it is installed.

For this reason the room must be well ventilated,

keeping the natural ventilation openings free

and switching on the mechanical aeration

system see «VENTILATION and LOCATION

AND AERATION» paragraph )If the cooker is

used for a long time additional aeration may be

necessary, for instance, opening a window, or a

more effective aeration by increasing the power

of the mechanical system if there is one.

INSTRUCTIONS FOR THE USER

LIGHTING THE BURNERS

Lighting of burners equipped with safety

thermocouples

When the burners are equipped with safety

thermocouples you have to press and turn

counterclockwise to the “Full on “ position ,

the knob corresponding to the burner you wish to use.

Automatically the ignition spark shoots. Once lit, keep

the knob pressed for about 10 seconds.

Matches can be used to light the burners in a blackout.

Optimum use of the burners

To get the maximum yield with the minimum

consumption of gas it is handy to keep the following

points in mind:

• Once the burner has been lit, adjust the ame

according to your needs.

• Use an appropriately sized pan for each burner (see

the table below and g. 4).

• When the content of the pan start to boil, turn

the knob down to “Reduced rate position” (small

ame).

• Always put a lid on the pan.

Burners Ø pan cm

Ultrarapid 22÷24

Semi-rapid 16÷18

Auxiliary 12÷14

43

10

INSTRUCTIONS FOR THE USER

OVEN: GENERAL SAFETY INSTRUCTIONS

• Do not leave the oven unsupervised during use.

Ensure that children do not play with the appliance.

• Always keep the appliance lid open when using the

oven, in order to prevent overheating.

• Always grip the centre of the oven door when

opening. Do not practice excessive pressures on

the door when it is open.

• Do not worry if condensation forms on the door and

on the internal walls of the oven during cooking.

This does not compromise its efciency.

• When opening the oven door, be very careful of

scalding vapours.

• The appliance becomes very hot during use. Do not

touch the heating elements inside the oven. Wear

oven gloves when placing or removing pans from

the oven.

• When inserting or removing food from the oven,

check that excess juices do not overow onto the

oven base (oils and fats are highly inammable

when overheated).

• Use containers that will resist the temperatures

indicated on the thermostat knob.

• For good results during cooking, we strongly

recommend not to cover the base of the oven or the

grill with aluminium foil or other materials.

• When grilling always put a little water in the grill

pan. The water prevents the grease from burning

and from giving off bad smells and smoke. Add

more water during grilling to compensate for

evaporation.

• After using the appliance ensure that all the controls

are in the off position.

• WARNING!!! During and after use, the oven door

glass and the accessible parts can be very hot,

therefore keep children away from the appliance.

IMPORTANT!!

Always keep the oven door closed during baking

or grilling.

WHAT TO DO THE FIRST TIME YOU USE THE

OVEN

If the appliance has a programming accessory,

place it on the manual position, and, before cooking

for the rst time, ensure the oven is empty and its door

closed, heat the oven at maximum temperature for

2 hours. This will allow the protective coating on the

interior of the oven to be burnt off and dissipate the

associated smells. During this time do not stay in the

same room and keep it aerated.

After the hour or so has elapsed leave the oven to cool

down and then clean its interior with hot water and a

mild detergent. Also wash the accessories (shelves,

trays, drip pan, spit..) prior to use.

Prior to any cleaning, disconnect the appliance

from the electricity mains.

11



5

HOW TO USE THE ELECTRIC GRILL

SWITCHING THE ELECTRIC GRILL

Turn the oven knob round to the symbol .

The red warning light will come on to indicate that the

grill heating element has been activated.

The top heating element is turned on and it distributes

heat directly onto the food. When the grill turns on so

will the eventual spit motor.

Besides grilling, it can be used to slightly brown

cooked food.

An automatic thermostat regulates the inner

temperature, therefore, do not use the grill

immediately after a cooking in the oven.

Always keep the oven door closed during the

use of the electric grill.

When the gas grill burner is lit the oven door

must be left open.

INSTRUCTIONS FOR THE USER

HOW TO USE GAS OVEN AND GAS GRILL

The oven and grill burner can be tted with a

safety thermocouple so, once the burner has

been lit, keep the knob pressed for about 15

seconds. If, at the end of this time, the burner

fails to light, release the knob and wait at least

1 minute before trying again. Should the burner

turn out accidentally, turn the knob round to the

closed position and wait at least 1 minute before

lighting it again.

AUTOMATIC ELECTRIC IGNITION OF OVEN

BURNER

Open the oven door push and turn the oven knob

counterclockwise until it reaches to the maximum

temperature position. Automatically the ignition spark

shoots. Matches can be used to light the burners in

a blackou; placing a lighted match to the burner through

the hole (B) (g. 5).

After the oven burner has been lit (check through

the opening (B) (g. 5) that it has ignited), adjust

the temperature according to your needs Close the

door gently so the ames will not blow out and wait 15

minutes before putting any food in to cook. Our oven can

cook all foods (meat, sh, bread, pizza, cakes, etc.).

AUTOMATIC ELECTRICAL IGNITION OF GRILL

BURNER.

Open the oven door push lightly the oven knob (C) and

turn clockwise to the grill position , then depress

the knob. Automatically the ignition shoots. Matches

can be used to light the burners in a blackout.

HOW TO USE THE SPIT (g.6)

• Place the chicken or piece of meat to roast rmly

between the two forks on the spit and make sure it is

evenly balanced to prevent straining the motor.

• Fix the spit holder into its hold on the appropriate

level, now place the spit onto its hold and push its

end (A) into place in the engine (E).

• Always use the drip pan to catch the gravy, as

indicated in the paragraph “USEFUL COOKING

TIPS”.

• Gas grill burner: position the oven knob on the

symbol

and light the grill burner. Start the spit

motor with the spit roast switch .





6

12

INSTRUCTIONS FOR THE USER

USEFUL COOKING TIPS

Cakes and bread:

• Heat the oven for at least 15 minutes before you

start cooking bread or cakes.

• Do not open the door during baking because the

cold air would stop the yeast from rising.

• When the cake is cooked turn the oven off and

leave it in for about 10 minutes.

• Do not use the enamelled oven tray or drip pan,

supplied with the oven, to cook cakes in.

• How do you know when the cake is cooked? About

5 minutes before the end of cooking time, put a

cake tester or skewer in the highest part of the

cake. If it comes out clean the cake is cooked.

• And if the cake sinks? The next time use less

liquids or lower the temperature 10°C.

• If the cake is too dry: Make some tiny holes

with a toothpick and pour some drops of fruit

juice or spirits on it. The next time, increase the

temperature 10°C and set a shorter cooking

time.

• If the cake is too dark on top: the next time put

the cake on a lower shelf, cook it at a lower

temperature and longer.

• If the top of the cake is burnt: cut off the burnt layer

and cover with sugar or decorate it with cream,

jam, confectioner’s cream, etc..

• If the cake is too dark underneath: the next time

place it on a higher shelf and cook it at a lower

temperature.

• If the cake or bread is cooked nicely outside but

is still uncooked inside: the next time use less

liquids, cook at a lower temperature and longer.

• If the cake will not come out of the tin: slide a

knife around the edges, place a damp cloth over

the cake and turn the tin upside down. The next

time grease the tin well and sprinkle it with our or

bread crumbs.

• If the biscuits will not come away from the baking

tray: put the tray back in the oven for a while and

lift the biscuits up before they cool. The next time

use a sheet of baking parchment to prevent this

happening again.

Meat:

• If, when cooking meat, the time needed is more

than 40 minutes, turn the oven off 10 minutes

before the end of cooking time to exploit the

residual heat (energy saving).

• Your roast will be juicier if cooked in a closed pan;

it will be crispier if cooked without a lid.

• Normally white meat, poultry and sh need

medium temperatures (less than 200°C).

• To cook “rare” red meats, high temperatures (over

200°C) and short cooking times are needed.

• For a tasty roast, lard and spice the meat.

• If your roast is tough: the next time leave the meat

to ripen longer.

• If your roast is too dark on top or underneath: the

next time put it on a higher or lower shelf, lower

the temperature and cook longer.

• Your roast is underdone? Cut it in slices, arrange

the slices on a baking tray with the gravy and

nish cooking it.

Grilling:

• Sparingly grease and avour the food before

grilling it.

• Always use the grill pan to catch the juices that drip

from the meat during grilling (g.7).

• Always put a little water in the drip pan. The water

prevents the grease from burning and from giving

off bad smells and smoke. Add more water during

cooking because it evaporates.

• Turn the food half way through cooking.

• If you are grilling fatty poultry (goose) pierce the

skin so the fat can drip away.

The aluminium can be easily corroded if it

comes into contact with organic acids present

in the foods or added during baking (vinegar,

lemon juice). Therefore it is advised not to put

directly the foods on aluminium or enamelled

trays, but ALWAYS use the proper oven paper.

13

INSTRUCTIONS FOR THE USER

COOKING / BAKING TIMETABLE

FOODS

Weight

kg

Position of the oven shelf

from the bottom

COOKING BY

NATURAL CONVECTION

Temperature

in °C

Cooking Time

in minutes

MEAT

Roast veal

Roast beef

Roast pork

Roast lamb

1

2

1 - 2

200-225

100-120

40-50

100-120

GAME

Roast hare

Roast pheasant

Roast partridge

1

2 - 3

200-Max

50-60

60-70

50-60

POULTRY

Roast chicken

Roast turkey

Roast duck

1

2

200-225

80-90

100-120

90-110

FISH

Roast sh

Casseroled sh

1

2

1 - 2

200

175

30-35

20-25

BAKED PASTA

Lasagne

Cannelloni

2,5

2

210-225

60-75

PIZZA

1 2 225-Max 25-30

BREAD

1 2 225-Max 20-25

PASTRIES

Biscuits in general

Shortcrust pastry

Victoria sponge 0,8

3

2 - 3

3

190

200

15

20

40-45

CAKES

Angel cake

Fruit cake

Chocolate cake

0,8

2 - 3

190

200

52

65

45

The values given in the tables (temperatures and cooking times) are approximate and may vary according to each person’s cooking habits.

This table gives cooking times on only one shelf.

If you are cooking with a fan oven and you are using more than one shelf (placing the shelves on the 2nd and 4th position or on the 1st and

and 3rd position) cooking time will be about 5 to 10 minutes longer.

GRILLING TIMETABLE

FOODS

Weight

kg

Position of the oven shelf

from the bottom

COOKING BY NATURAL

CONVECTION

Temperature

in °C

Cooking Time in minutes

1

st

side 2

nd

side

MEAT

Chop

Beefsteaks

Half chicken (each half 0.5 kg)

0,50

0,15

1

3 - 4

4

2 - 3

225-Max

200-225

225

12-15

5

20

12-15

5

20

FISH

Trout

Bass

Sole

0,42

0,.40

0,20

3

3 - 4

225-Max

18

15

10

18

15

10

BREAD

Toast 3 - 4 225-Max 2-3 2-3

The values given in the tables (temperatures and cooking times) are approximate and may vary according to each person’s cooking habits. In

particular, temperatures and times for grilling meat will greatly depend on the thickness of the meat and on personal tastes.

14





7

CLEANING AND MAINTENANCE

• Prior to any maintenance work or cleaning,

disconnect the appliance from the electricity

mains.

• Do not use a steam cleaner to clean this

appliance.

• Do not wash the parts if they are still hot.

• Do not use metal pads, abrasive powders or

corrosive spray products for cleaning

• Do not leave vinegar, coffee, milk, salty water

or the juice of lemon or tomato on enamelled

surfaces for any length of time.

HOT PLATE

The enamelled steel pan supports, enamelled burner

caps and burner heads need to be cleaned after each

time they are used with warm soapy water, rinsed

and then dried well to keep them in good condition.

WARNINGS:

• After cleaning, check that the heads burners and

the relative burner caps, are correctly positioned in

their housings (g. 7).

• Take care not to disturb the ignition spark plugs or

ame failure devices.

• If you nd a tap is difcult to open or close do not

force it but call for technical assistance urgently.

• If any liquid spills over it must always be removed

with a sponge.

STRUCTURE

All the cooker parts (in enamelled or painted metal,

steel, or glass) should be cleaned frequently with

warm soapy water and then rinsed and dried with a

soft cloth.

DO NOT use rough or abrasive materials or sharp

metal scrapers to clean the oven glass doors as they

could scratch and cause the glass to break

OVEN CAVITY

Do not spray or wash the thermostat bulb with

acid based products (check the product label

before use).

The manufacturer cannot be held liable for any

damage caused by incorrect cleaning.

The oven cavity should be cleaned after each use

to remove cooking residuals and or grease or sugar

which, if burnt on when the oven is used again, will

form deposits or unremovable stains as well as

unpleasant smells.

To maintain the shine of the enamelled parts, clean

them with warm soapy water, rinse and dry them

thoroughly. ALWAYS wash the accessories used.

OVEN SEAL

The oven seal guarantees the correct functioning of

the oven. We recommend you:

• clean it, avoiding abrasive tools or products.

• check its state now and then.

If the oven door seal has become hard or is

damaged, contact our Service Centre and avoid

using the oven until it has been repaired.

OVEN SIDEWALL GRIDS (g.8)

To allow for a better cleaning of the side grids, you can

extract them this way:

1. Push with a nger on the last of the slots to release

the grid from its hold.

2. Lift it towards the top and extract the grid.

To put them back into place, reverse the order of this

operation.

INSTRUCTIONS FOR THE USER





8

15





CLEANING THE INNER OVEN DOOR GLASS (g.9)

One of the features of our cookers is that the inner

oven door glass can be easily removed for cleaning

without the aid of specialized personnel. Just open the

oven door and remove the support securing the glass

ATTENTION!! This operation can be done also

with the door tted on appliance, but in this

way, pay attention that when the glass is pull

upwards, the force of the hinges can close the

door roughly.

LOCK AT LEAST ONE HINGE (g.11)

REPLACING THE OVEN LAMP (g. 10)

Ensure the appliance is switched off before

replacing the lamp to avoid the possibility of

electric shock..

In the event the oven lamps need replacing, the new

lamps must comply with the following requisites: 15

W - 230 V~ - 50 Hz - E 14 - and must be resistant to

high temperature (300°C).

• Extract the side grids as indicated in the previous

paragraph.

• Unscrew glass protection cap (V) from bulb holder

by lifting it with a screwdriver (C) against the inside

wall of the oven.

• Substitute the bulb and reposition all elements

back by following the operation in reverse order.

INSTRUCTIONS FOR THE USER

9

10

OVEN DOOR REMOVAL

The oven door can be removed to give easier access

to the oven when cleaning.

To remove, proceed as follows:

• Open the oven door and insert rivet or nail (R) in the

hole (F) of the hinge (g.11).

• Partially close the door, forcing it upwards at the

same time to free stop tooth and hinge sector.

• Once the hinge is free, pull the door forwards tilting

it slightly upwards to free sector.

• To reassemble proceed in the reverse order, paying

attention to the correct position of sectors.





11

16









OUTSIDE COOKER DIMENSIONS

TYPE /COOKER

height

h /mm

width

L/mm

depth

P/mm

60 x 60

850 600 600

Some of the problems occur because of simple maintenance oversights or operation mistakes and can easily be

resolved without having to call for technical assistance.

PROBLEM REMEDY

The appliance is not working

• Make sure the gas cock is open

• Check the plug is in

• Check that the knobs are set correctly for cooking and then repeat the

operations given in the handbook

• Check the electrical system safety switches (RCD). If there is failure in

the system call an electrician in.

The electric oven is not working

• Check that the programmer accessory, if there is one, is on the manual

position and then repeat the operations described in the manual

The thermostat is not working

• Call our Service Centre

The electric thermostat warning

light does not switch on during use

• Turn the thermostat round to a hotter temperature

• Turn the selector round to a different function

TROUBLESHOOTING

TECHNICAL FEATURES

17

BURNER DISPOSITION AND TECHNICAL DATA TABLE

Burners Operating pressure gas Rate

Diameter

injector

Heat input

Air reg.

sleve opening

By-pass

n. Denomination mbar g/h L/h 1/100 mm Min Max “X”mm 1/100 mm

3 Semi-rapide

LPG - Butane

LPG - Propane

Natural

28-30

37

20

131

129

171

68

98-Z

600

1800

= 34

4 Auxiliary

LPG - Butane

LPG - Propane

Natural

28-30

37

20

73

71

95

51

75-X

400

1000

= 28

6 Ultrarapid

LPG - Butane

LPG - Propane

Natural

28-30

37

20

236

232

309

95

125-K

1350

3250

= 62

7 Oven

LPG - Butane

LPG - Propane

Natural

28-30

37

20

236

232

309

75

115

900

2500

Complete

1

52

8 Grill

LPG - Butane

LPG - Propane

Natural

28-30

37

20

145

143

190

66

100

=

1800

Complete

2

TECHNICAL FEATURES

ELECTRIC COMPONENTS

Description Nominal data

Oven lamp

Fan motor

Spit motor

Cable type and section

15 W - E 14 – T 300

20 W

4 W

H05 RR-F - 3 x 0.75 or 1 mm

2









18







12

INSTRUCTIONS FOR THE INSTALLER

TECHNICAL INFORMATION

• The installation, adjustments, conversions and

maintenance operations listed in this part must

only be carried out by qualied personnel. The

manufacturer cannot be held responsible for any

damage to persons or property resulting from an

incorrect installation of the appliance.

• The safety and automatic adjustment devices of the

appliances may, during its life, only be modied by

the manufacturer or duly authorised supplier.

• In accordance with the gas standard, the all-gas

and combi appliances are “class 1” (free standing)

or “class 2 subclass 1” (recessed) and, as such,

must comply with the clearances specied in g

.12

consequently any side walls must be no higher than

the work top.

The appliance is to be placed directly on the oor and

should not be mounted on a base.

• The walls adjacent to and surrounding the appliances

must be able to withstand an temperature of 95°C.

• The installation of all-gas and combi appliances

must comply with the standards in force.

• This appliance is not connected to a ue for

discharge of the combustion products; therefore, it

must be connected in compliance with the above

mentioned installation rules. Particular attention

must be paid to the instructions given below for

ventilation and aeration.

INSTALLATION

UNPACKING YOUR COOKER

• Once the wrapping has been removed from the outer

surfaces and the various inner parts, thoroughly

check that the appliance is in perfect condition.

If you have any doubts do not use the appliance and

call in a qualied person.

• Some parts mounted on the appliance are protected

by a plastic lm. This protection must be removed

before using the appliance. We recommend slitting

the plastic lm along the edges with a sharp knife or

pin.

• Do not move the appliance by the handle.

The packaging materials used (cardboard, bags,

polystyrene foam, nails etc.) must not be left

anywhere within easy reach of children as they

are a potential hazard source.

19



13

14

15

17





16

air inlet min. sect. 100 cm

2

VENTILATION

The appliance should not be installed in a room of

volume less than 20 m³.

The quantity of air necessary is that required for a

regular combustion of the gas and for the ventilation of

the room. The natural ow of air must be direct through

permanent openings in the walls of the room that open

directly to the outside with a minimum cross section of

100 cm

2

(g. 13). These openings must be positioned

so they cannot be obstructed.

Indirect ventilation is also allowed by taking air from

adjacent rooms to the one to be ventilated, strictly

complying with the prescriptions of the standards in

force.

LOCATION AND AERATION

Gas cookers must always discharge the products

of combustion and the moisture through hoods

connected to ues or directly to the outside (g. 14).

If it is impossible to use a hood, a fan installed on

the window or wall, facing the outside, is allowed and

should be switched on each time the appliance is used

(g. 15) provided the rules and regulations in force

relating to ventilation.

POSITIONING THE COOKER

The appliances are tted with the following parts to

enable them to be correctly positioned:

• Spacers, positioned behind the rear panel to keep

the appliance at the minimum required distance

from the back wall. These must not be removed.

• Adjustable feet (g. 17), to be tted to the appliance,

which allow the height of the cooker to be aligned

with other kitchen furniture This can be done by

means of the terminal part of the leg themselves.

• The socket or the switch must be accessible once

the appliance is installed.

Backguard (A). In order to install the backguard,(

if present) it is necessary to loosen the screws

(V) positioned on the back of the hob and then

to x the backgaurd as indicated in gure 16

INSTRUCTIONS FOR THE INSTALLER

air inlet min. sect. 100 cm

2

air inlet min. sect. 100 cm

2

20

INSTRUCTIONS FOR THE INSTALLER

770 mm +/- 5

20 mm +/- 3

Wall

Position of threaded pin

chain tilt

Threaded pin

Masonary wall

SECURING THE COOKER TO WALL

Note:- The installation of the chain provided is for

safety reasons, it must be installed as indicated

below.

.

To prevent the cooker tipping forwards in the event of

children standing on the oven door or where users put

extreme weight on the door when in open position, two

chains MUST BE xed to the back of the oven which

should at all times be secured to the threaded pins .

The threaded pins should be secured to the wall at the

back of the cooker.

Assembly instructions

• Secure threaded pins into wall immediately behind

and to the left-hand side about 770 mm from the oor.

Finished xing the chains must be stretched

La page charge ...

Bauknecht ACK 6400 IN Mode d'emploi

Bauknecht ACK 6400 IN Mode d'emploi

dans d''autres langues

Documents connexes

Autres documents