Bradley Corporation S19-125SFMBF Guide d'installation
- Catégorie
- Articles sanitaires
- Taper
- Guide d'installation
P.O. Box 309, Menomonee Falls, WI USA 53052-0309
PHONE 800.BRADLEY (800.272.3539) FAX 262.251.5817
bradleycorp.com
Installation
215-1568 Rev. D; ECN 15-05-010
© 2015 Bradley
Page 1 of 7 3/31/2015
S19-125SBF
S19-125SFMBF
Barrier Free Recess-Mounted
Drench Shower
Table of Contents
Pre-Installation Information.........................2
Assembly of Components..........................3
Service Parts ...................................3
Cabinet Dimensions ..............................4
Rough-Ins ......................................5
Installation....................................6–7
www.bradleycorp.com
PUSH
TO
ACTIVATE
SHOWER
www
.bradleycorp.com
PUSH
TO
ACTIVA
TE
SHOWER
S19-125SBF
S19-125SFMBF
2
S19-125SBF, S19-125SFMBF Installation
3/31/2015 Bradley • 215-1568 Rev. D; ECN 15-05-010
IMPORTANT
Read this installation manual completely to ensure proper installation, then file it with the
owner or maintenance department. Compliance and conformity to drain requirements and
other local codes and ordinances is the responsibility of the installer.
Separate parts from packaging and make sure all parts are accounted for before discarding
any packaging material. If any parts are missing, do not begin installation until you obtain
the missing parts.
Flush the water supply lines before beginning installation and after installation is complete.
Test the unit for leaks and adequate water flow. Main water supply to the eyewash should be
“ON” at all times. Provisions shall be made to prevent unauthorized shutoff.
The ANSI Z358.1 standard requires an uninterrupted supply of flushing fluid. Bradley
plumbed emergency fixtures require a minimum of 30 PSI (0.21 MPa) flowing pressure.
Flushing fluid should be tepid per ANSI Z358.1.
The inspection and testing results of this equipment should be recorded weekly to verify
proper operation. This equipment should be inspected annually to ensure compliance with
ANSI Z358.1.
Workers who may come in contact with potentially hazardous materials should be trained
regarding the placement and proper operation of emergency equipment per ANSI Z358.1.
For questions regarding the operation or installation of this product, visit www.bradleycorp.
com or call 1-800-BRADLEY.
Product warranties and parts information may also be found under ”Products” on our web
site at www.bradleycorp.com.
Installation
THIS
SIDE
UP
Packing List
•
•
•
•
P.O. Box 309, Menomonee F
alls,
WI 53051
R
TEST THIS
UNIT EACH
WEEK
Test-operate valv
e(s) each week and sign
below.
Report an
y malfunctions immediatel
y.
Ventil(e) wöc
hentlich im
Testbetrieb prüfen,
bestätigt
durch Untersc
hrift. Jeglic
he Störung sofor
t melden.
Date
Datum
Date
Signed
Unterschrift
Signe
Date
Date
Date Signed
Signed
Signed
DIESES GERÄT 1ST
WÖC
HENTLICH ZU
PRÜFEN.
ESSAI HEBDOMA
DAIRE
Test le fonctionnement des v
alves chaque semaine et
signe en bas. S'il y à quelqu
e chose qui ne v
a pas fait
un rappor
t immédiatement.
P.O. BOX 309, MENOMONEE FALLS, WI 53052-0309 USA
TEL: 1-800-BRADLEY FAX: (262-251-5817)
http://www.bradleycorp.com
114-051
Supplies Required:
• Teflon tape and Pipe sealant
• Piping to 1” NPT water supply inlet on unit
• Adequate supply pipe supports
• Hardware to mount escutcheon to ceiling
• Minimum 4” (102 mm) drain to accommodate 30 gallons per minute discharge for drench shower waste
• Sign-mounting hardware
3
Installation S19-125SBF, S19-125SFMBF
Bradley • 215-1568 Rev. D; ECN 15-05-010 3/31/2015
Assembly of Components and Parts List
113-864
(S19-125SBF ONLY)
204-421
www.bradleycorp.com
114-090
114-090
Valve/Handle Prepack
(includes Handle and Valve Assembly)
S45-2238
P.O. Box 309, Menomonee Falls, WI 53051
R
TEST THIS UNIT EACH WEEK
Test-operate valve(s) each week and sign below.
Report any malfunctions immediately.
Ventil(e) wöchentlich im Testbetrieb prüfen, bestätigt
durch Unterschrift. Jegliche Störung sofort melden.
Date
Datum
Date
Signed
Unterschrift
Signe
Date
Date
Date Signed
Signed
Signed
DIESES GERÄT 1ST WÖCHENTLICH ZU PRÜFEN.
ESSAI HEBDOMADAIRE
Test le fonctionnement des valves chaque semaine et
signe en bas. S'il y à quelque chose qui ne va pas fait
un rapport immédiatement.
150-212
(S19-125SBF ONLY)
186-1495
(COVER PLATE)
www.bradleycorp.com
PUSH
TO
ACTIVAT E
SHOWER
204-605
(LABEL)
S24-189
(S19-125SBF only)
S24-197
(S19-125SFMBF only)
169-1027
(S19-125SBF only)
4
S19-125SBF, S19-125SFMBF Installation
3/31/2015 Bradley • 215-1568 Rev. D; ECN 15-05-010
S19-125 Series Cabinet Dimensions
14"
(357mm)
7-11/16"
(195mm)
8-7/16"
(214mm)
2-1/4"
(57mm)
10"
(254mm)
12-1/2"
(318mm)
7"
(178mm)
3" (76mm)
Side View Front View
5
Installation S19-125SBF, S19-125SFMBF
Bradley • 215-1568 Rev. D; ECN 15-05-010 3/31/2015
82" (2083mm) min.
to
96" (2438mm) max.
to floor
25"
(635mm)
min.
38" (965mm)
to 48" (1219mm)
from floor
S19-125SBF S19-125SFMBF
Ceiling hole
Ø 1-3/8" (35mm)
Wall opening
6" (152mm) wide
10" (254mm) high
Piping and
adequate
supports by
installer
38" (965mm)
to 48" (1219mm)
from floor
Ceiling hole
Ø 5" (127mm)
Piping and
adequate
supports by
installer
25"
(635mm)
min.
6" (152mm) min.
clearance
82" (2083mm) min.
to
96" (2438mm) max.
to floor
1
Rough-ins
6
S19-125SBF, S19-125SFMBF Installation
3/31/2015 Bradley • 215-1568 Rev. D; ECN 15-05-010
S19-125SBF S19-125SFMBF
Piping and
adequate
supports by
installer
Piping and
adequate
supports by
installer
2
Installation
NOTE: Use
teflon tape
only.
NOTE: Use
teflon tape
only.
7
Installation S19-125SBF, S19-125SFMBF
Bradley • 215-1568 Rev. D; ECN 15-05-010 3/31/2015
www.bradleycorp.com
114-090
To Showerhead
Connect supply
piping.
1" NPT supply
line
3
Connect Water Supply
-
1
-
2
-
3
-
4
-
5
-
6
-
7
Bradley Corporation S19-125SFMBF Guide d'installation
- Catégorie
- Articles sanitaires
- Taper
- Guide d'installation
dans d''autres langues
Documents connexes
Autres documents
-
Bradley S19345JFB Guide d'installation
-
-
-
-
-
-
-