ProAire PROCD150 Manuel utilisateur

150 PINT

Before using your

commercial dehumidifier,

please read this manual

carefully and keep it

for future reference,

along with your receipt.

FOR MODEL:

PROCD150

COMMERCIAL

DEHUMIDIFIER

USER MANUAL

-1-

General Information .................................................................................. 1

Important Safety Instructions .................................................................... 2

Structure Diagram .................................................................................... 3

Setup Instructions ................................................................................ 4 – 5

Control Panel ....................................................................................... 6 – 7

Operating Instructions .............................................................................. 8

Maintenance ...................................................................................... 9 – 10

Troubleshooting ...................................................................................... 11

Error Codes ............................................................................................ 12

Purchase/Maintenance Records ............................................................ 13

• Please DO NOT dispose of any packaging until you have

checked that the appliance is operational.

• After removing the packaging, ensure the contents are intact

and complete. In the unlikely event of missing parts, contact

Consumer Services at 844-472-2473.

• DO NOT leave children unattended with any of the packaging

as it is a potential source of danger.

• Disposal of all packaging must be carried out responsibly,

safely, and in accordance with your local regulations.

• ALWAYS recycle the packaging material where possible.

• When using any electrically powered product, basic safety

precautions should always be followed.

• Please read these instructions carefully and in full before using

the product.

TABLE OF CONTENTS

GENERAL INFORMATION

-2-

WARNING - to reduce the risk of re, electrical shock or

injury to persons or property:

1. Always operate the product from a power source of the same

voltage, frequency and rating as indicated on the product

identication plate.

2. To minimize shock and re hazards, proper grounding is important.

The power cord is equipped with a three-prong grounding plug for

protection against shock hazards. Never cut off the third prong.

3. Your unit must be used in a properly grounded wall receptacle. If

the wall receptacle you intend to use is not adequately grounded or

protected by a time delay fuse or circuit breaker, have a qualied

electrician install the proper receptacle.

4. Do not use extension cords or an adapter plug with this unit. If it is

necessary to use an extension cord, use an approved heavy duty

extension cord only (available at most local hardware stores).

5. Do not operate this product with a damaged power cord plug. If

the supply cord is damaged it must be replaced by qualied repair

person in order to avoid hazard.

6. To reduce the risk of electric shock, do not expose the unit or power

cord to moisture of any kind.

7. Turn off and unplug from the power socket when not in use, before

assembling or before cleaning.

8. The dehumidier is not intended for use by young children without

supervision. Young children should be supervised to ensure that they

do not play with the dehumidier.

9. Disabled persons and the elderly may require assistance with set up

and usage.

10. Do not place objects on the product or allow objects to obstruct the

inlet or outlet openings; do not operate in close proximity to walls,

curtains, etc.

11. Use of attachments or accessories not recommended or sold by the

product distributor may cause injury to persons or damage to property.

12. This product is intended for normal, light commercial use only.

13. Contact a qualied service technician for repair or maintenance of

this unit. Do not attempt to dismantle the appliance.

14. Do not operate the appliance on a metal surface.

15. Do not use the appliance in articially hot or humid conditions or

allow it to be used in a hazardous environment.

16. Do not clean the appliance with organic solvent.

17. This instruction manual is an integral part of the appliance and

should be stored for future reference. It must accompany the unit in

event of ownership transfer or for reference by a service engineer.

IMPORTANT SAFETY INSTRUCTIONS

-3-

DO NOT OBSTRUCT THE AIR INLET OR OUTLET.

WARNING

1. Metal handle

2. Control panel

3. Wheels

4. Drain hose bracket

5. Air outlet grille

6. Air inlet grille

7. Power cord

8. Drain hose

STRUCTURE DIAGRAM

NOTE: You will need to install the handle.

Six bolts are included for the installation.

-4-

IMPORTANT

Place dehumidier in the upright position. When transporting a

dehumidier to site, allow the dehumidier to stand upright for

30 minutes before switching ON. This is necessary to allow the

refrigerant system to stabilize and avoid system damage.

SETTING UP THE DEHUMIDIFIER:

Operate the dehumidier in an enclosed area as this creates a drying

chamber. Close all doors, windows and areas that open to external areas

to maximize the dehumidier’s water removal efciency. Keep trafc

through the drying chamber to a minimum. Place the dehumidier in the

center of the room, away from walls and furnishings. DO NOT allow the

airow to be obstructed.

Illustration of correct positioning for best performance.

SETUP INSTRUCTIONS

-5-

NOTE: The drain hose for the ejector pump is 40 ft long and can drain

up to 16 ft vertically. Attempting to push water vertically more than 16

ft vertically may cause water backup in the pump, which can result in

leakage. See image above.

DRAINAGE:

The dehumidier pump connects to a plastic drainage hose. The hose

is stored on the back of the appliance. Uncoil the entire hose, ensuring

there are no kinks or restrictions, and place the unattached end into a

drain or run outdoors.

Ensure that draining running to the outdoors does not create a hazard

that could cause someone to slip.

Water drains MUST be checked regularly when used.

SETUP INSTRUCTIONS (continued)

-6-

ON/OFF: Press the key to turn the unit ON or OFF.

PURGE: Press the key to empty water from the pump reservoir.

During normal operation the pump purges automatically when the

reservoir is full. Use “PURGE” before moving the machine to avoid

water spillage. The pump will close automatically after 40 seconds of

continuous operation.

and : Press and keys to set or adjust humidity in the

range of 26% and 90%. When the environmental humidity is below 26%,

“CO” will be displayed.

Defrost Indicator: The unit begins to defrost when the defrost indicator

illuminates; the unit has stopped defrosting when the light is no longer

illuminated. When defrosting is complete, the unit begins to dehumidify

again automatically.

1. ON/OFF Key

2. UP and DOWN Keys

3. Purging Indicator

4. Defrosting Indicator

CONTROL PANEL

5. PURGE Key

6. HUMIDITY and TIME Display

7. TIME Key

8. Operating Indicator

-7-

TIME: Press this to display working hours and total working time.

• Once the unit is running, the display will show the humidity setting

(left) and current humidity (right). Humidity setting can be changed by

pressing “Up” or “Down.”

• Time settings are based on minutes. For example, if the display shows

“0000:50,” this means that the unit has worked for 50 minutes since

powered on. If you want to view the total working time, press “T” again

and the display will show this for 10 seconds, then return automatically

to the original working hours. (Pressing “T” before the 10 seconds will

return the display to the original working hours.)

• If the unit is powered on but not in operation, the LED will not display

anything. If “T” is pressed once, the working hours from the previous

time the unit ran will display for 10 seconds. Within the 10 seconds, if

“T” is pressed again, the total working time will display for 10 seconds.

If there is no action within those 10 seconds, the LED will automatically

shut off.

• If “T” is pressed when LED displays the total working time, the LED

will shut off immediately. The current working time will be deleted by

pressing and holding down “T” for 5 seconds; the time will be reset, but

the deleted time will be added into the total working time.

NOTE: The total working time cannot be deleted. If the time is beyond

the range of what the LED can show, it will be deleted and restart

from zero.

NOTE: If a power outage occurs while the unit is powered on, the unit

automatically resumes operation at the most recent settings when power

is restored.

Error Messages (E1, E2, E3, E4): See the troubleshooting guide at the

back of this manual for meanings/assistance.

CONTROL PANEL (continued)

-8-

General Use:

Press the ON/OFF key to turn the unit on. It will begin working

automatically.

After use, press ON/OFF key to turn the unit off. Water pump will turn

on automatically for 40 seconds to drain the remaining water in the unit,

then turn off automatically.

Key Lock Function

If the keys of “T” and “P” are pressed for 2 seconds simultaneously, the

operation light will continue to illuminate at the speed of 50 Hz and all

of the keys on the control panel will lock. The control panel can then be

unlocked by pressing the “T” and “P” keys together again for 2 seconds.

Vent Hose Function

To speed up drying in very damp place, use a plastic pipe (vent hose)

with a diameter larger than 6.7 inches. Attach the vent hose to the

exhaust ring (see below) to expedite drying by directing the heat

(exhaust) toward the wet area.

OPERATING INSTRUCTIONS

Vent Hose

(not included)

ATTENTION:

• DO NOT switch the power OFF by disconnecting at the main

socket outlet.

• To avoid water spillage, DO NOT move the dehumidier for at least

3 minutes after turning the power OFF.

-9-

To clean the air lter:

Ensure the dehumidier is turned OFF and the plug is removed from the

power outlet before performing maintenance.

The working performance of the dehumidier will be greatly reduced if

the lter becomes blocked.

1. Remove the lter as shown in the diagram below.

2. Vacuum any debris from the lter using the vacuum hose and nozzle

attachment.

3. Using lukewarm water and a mild detergent, wash the lter and allow

to air dry completely.

4. Once completely dry, re-install the lter into the dehumidier.

MAINTENANCE

Lift upwards to remove

filter for cleaning

Air Filter

-10-

MAINTENANCE (continued)

The battery allows the user to check the total working time of the unit

even when the unit is powered off. (Press the “T” button to check this.)

1. Remove the screws in

the four corners of the

control panel.

2. Once the screws are

removed, carefully lift the

control panel to access

the PCB.

3. On the PCB is a 6F22

9V battery. Remove the

battery and replace with

a new battery.

4. Ret the control panel

onto the PCB.

5. Replace the four screws.

• Check the electrical cord for damage before each use.

• Additionally, it is a good practice to check the drain hose on a

monthly basis for any obstructions. Disconnect and clear any debris

present, then reconnect the hose.

• When cleaning the surface of the unit, do not use any harsh or

abrasive cleaners. Additionally, do not expose the power cord/plug,

control panel, and/or motor to direct moisture.

Battery (6F22 9V)

Changing the battery:

Maintenance Notes:

-11-

Please check the following troubleshooting tips before

calling for assistance.

NOTE: If you have tried the above troubleshooting and need additional

assistance, contact Consumer Services at 844-472-2473.

PROBLEM CAUSE SOLUTION

Dehumidier

does not operate

No power to appliance. Connect plug to power

outlet.

Power not turned on. Switch power on.

E4 error is displayed. Check drainage ow.

Dehumidier

collects little/no

water

Insufcient working time Allow more working time

Filter is blocked Clean lter

Low ambient

temperature

Increase ambient

temperature

Condensate hose is

blocked

Check hose for

restrictions

Difference between set

humidity and current

actual humidity is

minimal

Adjust humidity setting to

a lesser setting

Humidity is too low for

the unit to run.

No need to run the unit.

Dehumidier

is operating

but room is not

drying

Doors and windows are

open

Seal room from external

areas by closing doors,

windows, etc.

TROUBLESHOOTING

-12-

WARNING: DO NOT attempt to rectify errors using unqualied personnel.

To remedy the following errors, a qualied professional is required.

NOTE: With any error code, it is suggested to turn the unit off, wait ve

minutes, and then turn the unit on again. If the error code is still present, a

qualied professional is required to x the problem.

CODE MEANING

DISPLAY

READING

SOLUTION*

E1 Coil sensor

error

Flashes every

30 seconds

Replace coil sensor. Call for

replacement part.

E2 Humidity

sensor error

Flashes every

30 seconds

Replace humidity sensor. Call

for replacement part.

E3 Low or no

refrigerant

Flashes

continually

Turn the unit off, wait 5

minutes, and power the unit

ON. If E3 shows again within

15 mins after turning the unit

back on, then we can conrm

the unit refrigerant leak

requires professional repair.

Call your local HVAC repair

shop for assistance.

E4 Water pump

fault or

blockage

Flashes

continually

Dehumidier will turn OFF

automatically. Check for

blockages in the water hose. If

there are no visible blockages,

the pump or water pipe may

need to be replaced.

ERROR CODES

*NOTE: If the error occurs within one year from the date of purchase,

contact Consumer Services at 844-472-2473 for warranty assistance

prior to contacting a repair person. You must have the original

purchase receipt for warranty assistance.

-13-

PURCHASE RECORD

MAINTENANCE RECORD

Purchase Date:

Serial Number:

Distributor: Tel.

DATE SERVICE PERFORMED PERFORMED BY

Distributed by:

Perfect Aire, LLC

5401 Dansher Rd.

Countryside, IL 60525

Specification and performance data is subject to change without notice.

Printed in China

844-4PA-AIRE | 844-472-2473

www.perfectaire.us

PA/PROCD150Manual/06082018

70 LITRES / 95 LITRES

MODÈLE:

PROCD150

PROCD200

DESHUMIDIFICATEUR

D'AIR MOBIL

PROFESSIONNEL

MANUEL D'INSTALLATION

& D'UTILISATION

PROCD150

PROCD200

INFORMATIONS GENERALES







 

 





 

 





 

 INSTRUCTIONS IMPORTANTES



 



 

 







 





 

 





 

 











 

















 





 



  





 INSTRUCTIONS IMPORTANTES



 



 

 







 





 

 





 

 











 

















 





 



  





5

8

6

8

5

DY-65L

DY-85L

La page charge ...

ProAire PROCD150 Manuel utilisateur

Ce manuel convient également à

ProAire PROCD150 Manuel utilisateur

dans d''autres langues

Documents connexes

Autres documents