Ducane 20529914 Manuel utilisateur

Marque: Ducane

Modèle: 20529914

Catégorie: Barbecues

Taper: Manuel utilisateur

ASSEMBLY, ENSAMBLAJE, ASSEMBLAGE - PG 3

Customer Service: 1-800-382-2637

#20529914

 DANGER

If you smell gas:

1. Shut off gas to the appliance.

2. Extinguish any open ﬂames.

3. Open lid.

4. If odor continues, keep away from the

appliance and immediately call your gas

supplier or your ﬁre department.

Leaking gas may cause a ﬁre or explosion

which can cause serious bodily injury or

death, or damage to property.

 WARNING

1. Do not store or use gasoline or other

ﬂammable liquids or vapors in the

vicinity of this or any other appliance .

2. An LP cylinder not connected for use

shall not be stored in the vicinity of this

or any other appliance.

WARNING: Follow all leak-check

procedures carefully in this manual prior

to barbecue operation. Do this even if the

barbecue was dealer-assembled.

NOTICE TO INSTALLER: These instructions

must be left with the owner and the owner

should keep them for future use.

THIS GAS APPLIANCE IS DESIGNED FOR

OUTDOOR USE ONLY.

WARNING: Do not try to light this

appliance without reading the “Lighting

Instructions” section of this manual.

You must read this owners Guide

before operatinG Your Gas Grill

20529914_US 04/03/06 LP

US ENGLISH

MERIDIAN

Appliance Rating:

Appliance Total: ~120V a.c. only 60Hz

1500W(max.)

Warming Drawer:~120V a.c. only 60Hz

650W(max.)

Rotisserie Motor: ~120V a.c. only 60Hz

4.0W(max.)

FOR HOUSEHOLD USE ONLY

SAVE THESE INSTRUCTIONS FOR

FUTURE REFERENCE

LP GAS GRILL OWNER'S MANUAL

GUÍA DEL PROPIETARIO DEL ASADOR DE GAS LICUADO DE PROPANO - PG 23

GUIDE DE L’UTILISATEUR DU GRILL À GAZ PL - PG 41

2 www.ducane.com

DANGERS AND WARNINGS

DANGER

Failure to follow the Dangers, Warnings and Cautions contained in this Owner’s Manual may result in serious bodily injury or

death, or in a ﬁre or an explosion causing damage to property.

WARNING

 Do not store a spare or disconnected liquid propane cylinder under or near this barbecue.

 Improper assembly may be dangerous. Please carefully follow the assembly instructions in this manual

 After a period of storage, and/or non-use, the Ducane

gas barbecue should be checked for gas leaks and burner obstructions

before use. See instructions in this manual for correct procedures.

 Do not operate the Ducane

gas barbecue if there is a gas leak present.

 Do not use a ﬂame to check for gas leaks.

 Combustible materials should never be within 24 inches of the top, bottom, back or sides of your Ducane

gas barbecue.

 Do not put a barbecue cover or anything ﬂammable on, or in the storage area under the barbecue.

 Your Ducane

gas barbecue should never be used by children. Accessible parts of the barbecue may be very hot. Keep young

children away while it is in use.

 You should exercise reasonable care when operating your Ducane

gas barbecue. It will be hot during cooking or cleaning and

should never be left unattended or moved while in operation.

 Should the burners go out while in operation, turn all gas valves off. Open the lid and wait ﬁve minutes before attempting to

relight using the lighting instructions.

 Do not use charcoal or lava rock in your Ducane

gas barbecue.

 Never lean over open grill or place hands or ﬁngers on the front edge of the cooking box.

 Should a grease ﬁre occur, turn off all burners and leave lid closed until ﬁre is out.

 Do not enlarge valve oriﬁces or burner ports when cleaning the valves or burners.

 The Ducane

gas barbecue should be thoroughly cleaned on a regular basis.

 Liquid propane gas is not natural gas. The conversion or attempted use of natural gas in a liquid propane unit or liquid

propane gas in a natural gas unit is dangerous and will void your warranty.



Do not attempt to disconnect any gas ﬁtting while your barbecue is in operation.



Use heat-resistant barbecue mitts or gloves when operating barbecue.



Keep any electrical supply cord and the fuel supply hose away from any heated surfaces.



Combustion byproducts produced when using this product contain chemicals known to the state of California to cause cancer,

birth defects, or other reproductive harm.

 Do not use this barbecue unless all parts are in place. The unit must be properly assembled according to the instructions

outlined in the “Assembly Guide”.

LIQUID PROPANE GAS UNITS ONLY:

 Use the regulator that is supplied with your Ducane

gas barbecue.



Do not attempt to disconnect the gas regulator or any gas ﬁtting while your barbecue is in operation.



A dented or rusty liquid propane cylinder may be hazardous and should be checked by your liquid propane supplier. Do not

use a liquid propane cylinder with a damaged valve.



Although your liquid propane cylinder may appear to be empty, gas may still be present, and the cylinder should be

transported and stored accordingly.

 If you see, smell or hear the hiss of escaping gas from the liquid propane cylinder:

1. Move away from liquid propane cylinder.

2. Do not attempt to correct the problem yourself.

3. Call your ﬁre department.

IMPORTANT SAFEGUARDS

 Read all instructions.

 WARNING: Use only outdoors, do not expose to rain. This is to prevent electric shock which can cause serious bodily injury or

death.

 WARNING: Disconnect appliance from supply circuit before performing maintenance and cleaning.

 WARNING: For protection against risk of electric shock, connect to properly grounded outlets only.

 WARNING: For protection against risk of electric shock, keep extension cord connection dry and off the ground.

 Use extreme caution when removing tray or disposing of hot grease.

 Do not clean with metal scouring pads. Pieces can break off the pad and touch electrical parts, creating a risk of electric

shock.

 Do not use charcoal in this appliance.

 Only use metal or glass containers in the warming drawer.

 Do not place any ﬂammable materials in the warming drawer. This includes matches, lighters, paper, cooking oils, pressurized

containers and alcohol.

 Do not touch surfaces that may be hot. Use handles or knobs provided.

 To protect against electrical shock do not immerse cord, plugs, portable appliances (or other speciﬁc part or parts) in water or

other liquid.

 Close supervision is necessary when any appliance is used by or near children.

 Make sure appliance is OFF and remove plug from outlet when not in use, before putting on or taking off parts, and before

cleaning. Allow to cool before handling.

 Do not operate any appliance with a damaged cord or plug or after the appliance malfunctions or is dropped or damaged in

any manner. Contact Ducane customer service at 1-800-DUCANES.

 The use of accessory attachments not recommended by the appliance manufacturer may cause injuries.

 Do not let cord hang over edge of table or counter or touch hot surfaces.

 Where applicable, always attach plug to appliance and check that the control is OFF before plugging cord into wall outlet.

To disconnect, turn the control to OFF, then remove plug from wall outlet.

 Do not use appliance for other than intended use.

 Avoid contacting moving parts.

 SAVE THESE INSTRUCTIONS

ASSEMBLY, ENSAMBLAJE, ASSEMBLAGE

CAUTION: Although we make every effort to ensure that the assembly process is as easy and as safe as possible, it is inherent

with fabricated steel parts that corners and edges can cause cuts if improperly handled during assembly procedures. Be careful

while handling any parts during assembly. IT IS STRONGLY RECOMMENDED THAT HANDS BE PROTECTED WITH A PAIR OF WORK

GLOVES.



PRECAUCIÓN: Aunque hacemos todo lo posible para que el proceso de ensamblaje sea tan fácil y seguro, es imposible

evitar que, con las partes fabricadas de acero, las esquinas y los bordes causen cortes si no son usados apropiadamente

durante el proceso de ensamblaje. ES MUY RECOMENDABLE QUE LAS MANOS SEAN PROTEGIDAS POR GUANTES DE

TRABAJO.



ATTENTION : Bien que nous fassions tous les efforts possibles pour s’assurer que le processus d’assemblage soit aussi

facile et sécuritaire que possible, il est inhérent que la fabrication de pièces métalliques laissent des coins et des bords

tranchants qui puissent causer des blessures lors de la manipulation incorrecte pendant les procédures d’assemblage. Soyez

prudent lors de la manipulation de toute pièce durant l’assemblage. IL EST FORTEMENT RECOMMANDÉ DE PORTER DES

GANTS POUR PROTÉGER VOS MAINS.

4 www.ducane.com



11mm (7/16”)

ASSEMBLY, ENSAMBLAJE, ASSEMBLAGE

TOOLS NEEDED:

CAUTION: Always remove the

warming rack when using the

rotisserie.

HERRAMIENTAS REQUERIDAS:



OBSERVACIÓN: Siempre

quite la rejilla de calentamiento

cuando esté usando el sistema

rotativo.

OUTILS NECESSAIRES:



REMARQUE : Enlevez

toujours la grille de chauffage

lors de l’utilisation de la

rôtisserie.

5 6

11mm (7/16”)

ASSEMBLY, ENSAMBLAJE, ASSEMBLAGE



WARNING: The rotisserie motor must be

stored indoors when not in use. DO NOT leave it

mounted to the grill.

NOTE: The bolts to install the stainless

steel side shelf are threaded into the grill

cart on the right side of the grill. Remove the

bolts and re-install when attaching the stainless steel

side shelf.



PRECAUCIÓN: El motor deber ser almacenado

dentro, cuando no esté en uso. NO LO DEJE

montado en la parrilla.

OBSERVACIÓN: Los tornillos utilizados para armar las mesas

de acero inoxidables están atornillados a la izquierda y derecha

del asador. Quite los tornillos y renstálese cuando valla armar

las mesas de acero inoxidable.



AVERTISSEMENT : Le moteur de rôtisserie doit

être entreposé à l’intérieur lorsqu’il n’est pas

utilisé. NE le laissez PAS installé sur le gril.

REMARQUE: Les boulons pour l’installation des deux étagères

latérales en acier inoxydable sont vissés dans le chariot du

grill, sur les côtés gauche et droit du grill. Retirez ces boulons

puis ré-installez-les lorsque vous ﬁxez les étagères latérales en

acier inoxydable.

6 www.ducane.com

Ducane Products, Co. hereby warrants to the ORIGINAL PURCHASER of this Ducane

Meridian

Series gas grill that it will be free of defects in material and workmanship from the

date of purchase as follows:

Ten-Year Limited Warranty

• Stainless steel cabinetry and grill lid excluding discoloration and scratches

Five-Year Limited Warranty

• Stainless steel cooking grates

• Stainless steel primary grill burners

• Side Burner Inserts

• Stainless steel rotisserie burners

One-Year Limited Warranty

• Rotisserie motor

• Electric Warming Drawer

• Ignition system

• All remaining parts

The above warranty period(s) applies only to grills used in a non-commercial setting when assembled

and operated in accordance with the printed instructions accompanying the grill.

Ducane may require valid proof of your date of purchase. Please retain your receipt of purchase or

invoice as reasonable proof.

This Limited Warranty shall be limited to repair or replacement of parts that prove defective under

normal, non-commercial use and which, on examination shall indicate, to Ducane’s satisfaction, that

they are defective. Before returning any parts, please contact Ducane’s Customer Service at 1-800-

DUCANES (1-800-382-2637).

If Ducane conﬁrms the defect and approves the claim, Ducane will elect to replace such parts without

charge. If you are required to return defective parts, transportation charges must be paid by you.

Ducane will return parts to purchaser, freight or postage prepaid.

This Limited Warranty does not cover failures or operating difﬁculties due to accident, abuse, misuse,

alteration, misapplication, vandalism, improper installation, use in a commercial enterprise, improper

maintenance, including but not limited to damage caused by insects within burner tubes, as described

in the owner’s manual.

Deterioration or damage due to severe weather conditions, such as hail, hurricanes, earthquakes, or

tornadoes is not covered by this Limited Warranty.

Deterioration or discoloration due to exposure to chemicals, either directly or in the atmosphere, is

not covered by this Limited Warranty.

There are no other express warrants except as set forth herein and any applicable implied warranties

of merchantability and ﬁtness are limited in duration to the period of coverage of this express written

Limited Warranty. Some regions do not allow limitation on how long an implied warranty lasts, so

this limitation may not apply to you.

Ducane is not liable for any special, indirect or consequential damages. Some regions do not allow the

exclusion or limitation of incidental and consequential damages, so this limitation or exclusion may

not apply to you.

Ducane does not authorize any person or company to assume for it any other obligation or liability in

connection with the sale, installation, use, removal, return or replacement of its equipment; and no

such representations are binding on Ducane.

This Limited Warranty applies only to products sold at and purchased from a retail entity excluding

on-line auction services.

Ducane Products Co.

1656 Fuldner Road

Barnwell, SC 29812

USA

www.ducane.com

ASSEMBLY, ENSAMBLAJE, ASSEMBLAGE

WARRANTY, GARANTÍA, GARANTIE

Ducane Products, Co., por el presente documento garantiza al COMPRADOR ORIGINAL de esta

parrilla a gas de la Serie Inoxidable de Ducane

que estará libre de defectos de materiales y fabricación

desde la fecha de adquisición así

Garantía limitada de diez años

• Gabinete de acero inoxidable y tapa de la parrilla, excluyendo descoloración y rasguños

Garantía limitada de cinco años

• Rejillas para cocción en acero inoxidable

• Quemadores primarios de la parrilla en acero inoxidable

• Insertos de quemadores laterales

• Quemadores para asador en acero inoxidabl

Garantía limitada de un año

• Motor del asador

• Cajón de calentamiento eléctrico

• Sistema de encendido

• Todas las demás partes

Los anteriores períodos de garantía sólo se aplican a parrillas usadas en ambientes no comerciales

cuando sean ensambladas y operadas de acuerdo con las instrucciones impresas que acompañan la

parrilla.

Ducane puede solicitar una prueba válida de su fecha de adquisición. Por favor guarde su recibo de

compra o la factura como prueba razonable.

Esta Garantía Limitada se limitará a la reparación o reemplazo de partes que se pruebe que estaban

defectuosas bajo un uso normal y no comercial, y que, tras ser examinadas, indiquen a satisfacción de

Ducane que efectivamente están defectuosas. Antes de devolver cualquier parte, por favor contacte al

Servicio al Cliente de Ducane al 1-800-DUCANES (1-800-382-2637).

Si Ducane confirma el defecto y aprueba la reclamación, Ducane elegirá reemplazar dicha parte sin

ningún cargo. Si se le solicita que devuelva las partes defectuosas, los costos de transporte deberán

ser asumidos por usted. Ducane devolverá las partes al comprador con flete o timbre pagado por

anticipado.

Esta Garantía Limitada no cubre fallos o dificultades de operación debidos a accidentes, abuso,

mal uso, alteración, mal manejo, vandalismo, instalación inadecuada, uso en empresa comercial,

mantenimiento indebido, e incluye, pero no se limita, a daños causados por insectos al interior de los

tubos quemadores, como se describe en el manual del usuario.

El deterioro o daño debido a condiciones climáticas extremas, tales como granizo, huracanes,

terremotos o tornados no está cubierto por esta Garantía Limitada.

El deterioro o la decoloración debidos a la exposición a químicos, bien sea directamente o en la

atmósfera no están cubiertos por esta Garantía Limitada.

No hay ninguna otra garantía expresa salvo las que están contenidas en este documento, y cualquier

garantía implícita aplicable de comerciabilidad y adecuación está limitada a la duración del período

de cobertura de esta expresa Garantía Limitada. Algunas regiones no admiten una limitación al

tiempo de duración de una garantía implícita, de forma que esta limitación no aplica para usted.

Ducane no es responsable por ningún daño especial, indirecto o resultante. Algunas regiones no

admiten la exclusión o limitación de daños incidentales o resultantes, de forma que esta limitación

podría no aplicar para usted.

Ducane no autoriza a ninguna persona o compañía a asumir en su nombre ninguna otra obligación

o responsabilidad en relación con la venta, instalación, uso, retiro, devolución o reemplazo de este

equipo; y ninguna de dichas representaciones obligan a Ducane.

Esta Garantía Limitada aplica únicamente a productos vendidos en y comprados de una entidad

detallista, excluyendo servicios de subasta en línea.

Ducane Products Co.

1656 Fuldner Road

Barnwell, SC 29812

USA

www.ducane.com

Par la présente, Ducane Products, Co., garantie à l’ACHETEUR ORIGINAL du gril au gaz en

acier inoxydable Ducane

qu’elle sera sans vices de matériaux et de fabrication à partir de la date

d’achat, tel que suit:

Garantie Limitée de Dix Ans

• Habillage et couvercle de gril en acier inoxydable à l’exception de décoloration et

d’égratignures.

Garantie Limitée de Cinq Ans

• Gril de cuisson en acier inoxydable

• Brûleurs primaire en acier inoxydable

• Insertions du bruleurs du côté

• brûleurs de tournebroche en acier inoxydable

Garantie Limitée d’un An

• Moteur du tournebroche

• Tiroir de chauffage électrique

• Système d’allumage

• Toutes autres pièces

La(Les) période(s) de garantie ci-haut mentionné s’applique seulement au grils personnel, et non

ceux qui sont utilisés dans un milieu commercial, quand assemblé et opéré selon les instructions

inclues avec le gril.

Ducane pourra exiger une preuve d’achat valable. Veuillez conserver votre preuve d’achat ou votre

facture comme preuve.

Cette garantie sera limitée à la réparation ou le remplacement de pièces qui s’avèrent être défectueux

sous des conditions d’utilisation normal, non-commercial, et qui, après exam indiquera, à la satisfac-

tion de Ducane’s, une défectuosité. Avant de retourner les pièces, veuillez contacter le service a

clientèle de Ducane au 1-800-DUCANES (1-800-382-2637).

ISi Ducane conﬁrme la défectuosité et approuve la demande, Ducane choisira de remplacer ses pièces

sans frais. Si vous êtes obligé de retourner des pièces déféctueueses, vous devez assumer tous les frais

de transports, fret ou port-pré-payé.

Cette garantie limitée ne couvre pas les pannes ou les difﬁcultés d’opération résultant d’accidents,

abus, emploi abusif ou mauvaise opération, vandalisme, mauvaise installation, utilisation commerci-

ale, mauvais entretien, incluant mais pas limitée aux dommages causés par les insectes dans les tubes

de brûleurs, tel que décrites dans le guide d’achat.

La détérioration ou les dommages dû aux conditions sévère de température, notamment, grêles,

ouragans, tremblements de terre , ou tornades ne sont pas couvert par cette garantie limitée.

La détérioration ou la décoloration dû à une exposition au produits chimique, directement ou dans

l’atmosphère, ne sont pas couverte par cette garantie limitée.

Il n’y a pas d’autres garantie expresse à part celles détaillées et n’importe quelle garantie tacite de

qualité marchande et de compatibilité applicable est limitée à la durée de la période de couverture de

cette garantie expresse limitée. Certaines régions ne permettent pas la limitation de garantie tacite,

donc la limitation ne pourrait vous être applicable.

Ducane n’est pas responsable des dommages, indirects ou conséquents. Certaines régions ne per-

mettent pas l’exclusion ou la limitation de dommages accessoires ou immatériels, donc, l’exclusion ou

la limitation ci-haut mentionnée ne pourrait vous être applicable.

Ducane n’autorise aucune personne ou entreprise, d’assumer à son nom, n’important quelle

obligation ou responsabilité reliée à la vente, l’installation, l’utilisation, l’enlèvement, le retour ou le

remplacement de son équipement; et ce, notamment, aucune répresentations de ce genre engage

Ducane.

Cette garantie limitée s’applique seulement aux produits vendu par, ou procuré chez, un détaillant,

excluant tous sites de vente aux enchères en-ligne..

Ducane Products Co.

1656 Fuldner Road

Barnwell, SC 29812

USA

www.ducane.com

IMPORTANT

We urge you to read this manual carefully and to follow the recommendations enclosed. This will help assure you of the most enjoyable and trouble-free operation of your new

Ducane

Gas Grill. We also advise you to keep this manual for future reference.

 WARNING: Your grill has been designed to operate using

only the gas speciﬁed on the rating plate. Do not attempt to

operate your grill on other gases. Failure to follow this warn-

ing could lead to a ﬁre hazard and bodily harm, and will void

your warranty.

 CAUTION: FOR YOUR SAFETY Do not store any ﬂammable

materials in any cabinets beneath the grill burner box or in

the vicinity of your grill.

 WARNING: Be sure to have your LP (propane) tank ﬁlled by

a reputable propane dealer. An incorrectly ﬁlled or an over-

ﬁlled LP tank can be dangerous. The overﬁlled condition

combined with the warming of the LP tank (a hot summer

day, tank left in the sun) can cause LP gas to be released by

the pressure relief valve on the tank since the temperature

increase causes the propane to expand. LP gas released

from the tank is ﬂammable and can be explosive.

CALIFORNIA PROPOSITION 65



WARNING: The burning of gas cooking fuel generates some

by-products which are on the list of substances known by

the State of California to cause cancer or reproductive harm.

California law requires businesses to warn customers of po-

tential exposure to such substances. To minimize exposure

to these substances always operate this unit according to

the use and care manual, ensuring you provide good ventila-

tion when cooking with gas.

SAFETY INFORMATION

WARRANTY, GARANTÍA, GARANTIE

8 www.ducane.com

INSTALLATION Liquid Propane Gas Grills

Locating Your Grill

• Your Ducane

Gas Grill is manufactured for outdoor use only! Any grill, charcoal

or gas, produces carbon monoxide while in operation and the gas should not be

allowed to accumulate in a conﬁned area. Never operate this grill inside your home

or recreational vehicle or any enclosed area.

• When locating your grill, choose a safe outdoor location away from ﬂammable or

combustible surfaces and out of trafﬁc paths. Ducane

strongly recommends a 24”

clearance to combustible surfaces.

• Consult your local codes for possible additional restrictions on location or operation

of your grill.

• As your grill uses gas, it requires air to burn properly. Do not locate your grill in

such manner or as to obstruct the ﬂow of combustion and ventilation air around the

grill.

• When possible, adjust your grills’ position to reduce the likelihood of wind blowing

onto it.

 CAUTION: Never operate your grill under any overhead com-

bustible construction.

 CAUTION: This grill is not intended to be installed in or at-

tached to a recreational vehicle. It is also not intended to be

installed in or on a boat.

 WARNING: Do not store or use gasoline or other ﬂammable

vapors and liquids in the vicinity of this or any other ap-

pliance. Failure to follow this warning could lead to a ﬁre,

explosion and bodily harm.

Assembly

Make sure your grill is assembled properly. Detailed assembly instructions are packed

with each grill giving speciﬁc assembly procedures for each model. Follow these in-

structions carefully to ensure the correct and safe assembly of the grill.

 CAUTION: Although we take every effort to ensure that the

assembly process is as easy and as safe as possible, it is

inherent with fabricated steel parts that corners and edges

can cause cuts if improperly handled during assembly pro-

cedures. Be careful while handling any parts during assem-

bly. It is strongly recommended that you protect hands with

a pair of work gloves.

24”

Leveling

It is important for the proper operation of the grill that it be located on a level surface.

Grounding Instructions

This appliance shall be grounded while in use to protect the operator from electrical

shock. The appliance is equipped with a 3-conductor cord and a 3-prong grounding-

type plug to ﬁt the proper grounding-type receptacle. Plug into a GFCI-protected

outdoor receptacle, where available.

Extension Cords

Use only 3-wire extension cords that have 3-prong grounding-type plugs and 3-

pole cord connectors that accept the plug from the appliance. Only extension cords

identiﬁed by the marking with the sufﬁx letters W-A, and tagged “Suitable for use

with outdoor appliances” shall be used outdoors. Use only extension cords having an

electrical rating not less than the rating of the appliance. Do not use damaged extension

cords. Examine extension cord before using and replace if damaged. Do not abuse

extension cord and do not tug on any cord to disconnect. Keep cord away from heat

and sharp edges.

CONNECTION Liquid Propane Gas Grills

Type of Gas

• Your LP grill is factory built to operate using liquid propane only. Never attempt to

operate your grill on gases other than the type speciﬁed on the grill rating plate.

• The regulator supplied with your liquid propane gas grill is set for 11” water

column pressure and is for use with propane gas only. This regulator and the fac-

tory-supplied hose assembly must be used when operating your grill with a 20 lb. LP

gas cylinder.

• If replacement of the hose and/or regulator becomes necessary, factory-speciﬁed

parts are required.

• For safety and design reasons, the conversion of a Ducane

grill from operation

using LP gas to operation using natural gas requires the change out of the entire gas

supply system of the grill. If this becomes necessary, see your dealer for additional

information.

Handling Liquid Propane Gas

Propane gas should be handled and stored with care. We suggest asking your propane

gas dealer, when having your tank ﬁlled, for a short course in handling, care and

storage of propane gas tanks. Most dealers will be glad to instruct you on how to store

and handle your tank. Make sure your tank is never stored inside! Keep it outside in a

well-ventilated area in an upright position away from your gas grill.

Portable Installation

Complete portability is afforded to the grill head when mounted on the portable cart.

When so installed, it is necessary to use a 20 lb. capacity liquid propane tank. Use no

other size. The tank retainer is designed to accommodate only this size tank.

CONNECTION Liquid Propane Gas Grills

Type 1 Connective Coupling

All Ducane liquid propane gas grill regulators are equipped with a UL-listed tank

connection as per the latest edition of ANSI Z21.58. This will require a liquid propane

tank that is similarly equipped with a Type 1 connection in the tank valve. This Type 1

coupling allows you to make a fast and totally safe hookup between your gas grill and

your liquid propane tank. It eliminates the chance of leaks due to a POL ﬁtting that is

not properly tightened. Gas will not ﬂow from the tank unless the Type 1 coupling is

fully engaged into the coupling.

 WARNING: The Type 1 connective coupling supplied with

your grill must not be replaced with a different type of grill/tank

connection system. Removal will result in loss of warranty and,

if improperly done, may result in serious bodily injury or death,

or in a ﬁre or an explosion causing damage to property.

 WARNING: Do not let the regulator hose loop up towards the

bottom of the burner box.

The propane cylinder valve connection provided with this grill incorporates the four

important safeguards listed:

Hand Assembly

1. Make sure the cylinder valve and all appliance valves are in their “OFF” positions.

2. When connecting regulator/burner valve assembly to cylinder valve, turn large

plastic nut clockwise until it stops.

3. Gas will not ﬂow unless plastic nut is fully engaged.

4. HAND TIGHTEN ONLY.

Disconnecting Cylinder

1. Turn cylinder valve and all appliance valves “OFF”.

2. Turn large plastic nut counterclockwise to disengage coupling.

 WARNING: Do not use a tool to tighten the connection.

Using a tool could damage the regulator coupling and could

cause a leak resulting in serious bodily injury or death, or in a

ﬁre or an explosion causing damage to property.

TYPE 1 CONNECTIVE COUPLING

Type 1 Valve

Hand Wheel

External Thread

Themally Sensitive Nut

Propane Regulator

Excess Flow Control

The propane regulator assembly incorporates a ﬂow limiting device designed to supply

the grill with sufﬁcient gas ﬂow, yet control any excess ﬂow.

Rapid changes in pressure can trigger the ﬂow limiting device. If the cylinder valve is

turned to allow gas ﬂow while a burner valve is open, the surge of pressure will cause

the device to activate. The device will remain closed until the pressure is equalized.

This should occur within a 5-second time frame. If the ﬂame remains low, shut off

the gas valves, wait ﬁve seconds and relight grill one burner at a time.

IMPORTANT

Installation must conform with local codes or, in the absence of local codes, with

either the National Fuel Gas Code, ANSI Z223.1/NFPA 54, or can/cga-149.1, Natural

Gas and Propane Installation Code.

IMPORTANT

The liquid propane tank supply system must:

1. Have a safety relief device having direct communication with the vapor space of the

tank

2. Be arranged for vapor withdrawal

3. Include a collar on the tank to protect the tank valve

4 . Be equipped with an overﬁll protection device (OPD). The tank should be 12 inches

in diameter and 18½ inches tall.

CHECKING GAS LEAKS

Before operating your grill and after refueling, check carefully to be certain that all con-

nections are tight and there are no gas leaks. The easiest way to do this is to mix up a

little soapy water, like you would for washing dishes. Turn on the gas and brush a little

of the mixture around ﬁttings. If new bubbles form, you have a leak!

IMPORTANT

See Assembly Guide for LP tank installation.

Type of Liquid Propane Tank

For LP gas grills, the LP gas supply cylinder to be used must be constructed and

marked in accordance with the speciﬁcations for LP Gas Cylinders of the US Depart-

ment of Transportation (DOT) or the National Standard of Canada, CAN/CSA-B339

Cylinders, Spheres and Tubes for the Transportation of Dangerous Goods. This tank

must be provided with a shut-off valve terminating in a liquid propane gas tank valve

outlet. The valve must be equipped with a Type 1 connection complying with the latest

edition of ANSI Z21.58.

To ensure that this does not cause difﬁculty in lighting the grill, follow these instruc-

tions

1. Make sure all burner valves are OFF.

2. Open cylinder valve and wait 5 seconds.

3. Follow lighting instructions.

10 www.ducane.com

IMPORTANT

When connecting or replacing any gas pipe or ﬁttings, all joints must be sealed with

leak-proof sealing compound approved for use with natural and propane gases. After

making connections, check all joints for leaks using soapy water and a brush.

Gas Leak Checks

Never use a match or ﬂame for leak detection. Use soapy water or testing solution.

Brush the solution onto connection points and look closely for bubbles indicating

escaping gas. If leaks are detected, shut off the main gas supply valve and securely

retighten connections, then repeat the leak test.

On cabinet models, perform this operation before placing the tank into its storage

compartment. After placing the tank in the compartment, recheck the tank to see if

any connections were disturbed.

 WARNING: Never use an open ﬂame when testing for gas

leaks. Use of an open ﬂame may result in serious bodily

injury or death, or in a ﬁre or an explosion causing damage

to property.

Liquid Propane Tank Safety Tips

• Remember to handle your portable liquid propane tank carefully when you take

it to your dealer for a reﬁll. Avoid dropping it or bumping it against sharp objects.

Liquid propane tanks are sturdily constructed, but a series of hard jolts could dam-

age the container.

• When transporting the tank to your local propane gas dealer, make sure the valve

is closed tightly and the protective cover is in place. Prop the tank securely in an

upright position so it can’t roll around your vehicle.

• If you plan to make stops for other shopping or errands, have your liquid propane

tank ﬁlled at the last stop before going home. Again, see that the reﬁlled tank is

secure in an upright position, and when you return home, remove the reﬁlled tank

from your vehicle. Never leave a portable liquid propane tank inside a vehicle which

may become overheated by the sun.

• Your local liquid propane gas dealer will gladly offer you additional safety tips.

Store Liquid Propane Tank Safely

Whether you’re between cross-country treks in your recreational vehicle or looking for

a place to keep the liquid propane tank that provides fuel for your outdoor grill, keep

in mind some basic safety rules about storing portable liquid propane tanks. Don’t

store the tanks - whether full or empty - inside your home, the living area of an R.V.,

a garage, basement or workshop. It isn’t likely that liquid propane will leak from the

tanks, but if it should, the fuel could be exposed to sparks from automobiles, power

tools or other appliances. When storing or transporting your LP tank, it must remain

in an upright position. Never lie your LP tank down on its side whether it is full or

empty. Never store a spare tank near your grill.

 CAUTION: Never transport or move your grill or grill tank

without ﬁrst closing the manual valve on your liquid propane

gas tank.

CAUTION: Place dust cap on cylinder valve outlet whenever

the cylinder is not in use. Only install the type of dust cap on

the cylinder valve outlet that is provided with the cylinder valve.

Other types of caps or plugs may result in leakage of propane.

The best place to store a liquid propane tank is in a shady or protected spot outdoors,

behind your home or garage, but where it is out of reach of children. Liquid propane

won’t evaporate, because it’s in a strong, closed container. And it won’t lose any of its

clean-burning heat content, even if left outside year-round.

 WARNING: When not connected to your grill, any LP gas tank

must be stored in an upright position in a cool, shady, ventilated,

outdoor location away from your grill or any other heat source.

If this information is not followed exactly, a ﬁre causing death or

serious injury may occur.

Filling a Propane Tank

It is extremely important that your LP tank be ﬁlled properly when you take it to be

reﬁlled. Be sure to use a reputable LP dealer and ask him (and watch, if possible) how

he ﬁlls the tank and knows when to stop. An overﬁlled LP tank can be dangerous.

The proper way to ﬁll a tank is by weight. The empty tank should be placed on a scale

and the scale weights readjusted to a weight which would allow up to 80% of the total

weight of propane (LP) to be put into the tank. When this weight is reached, the ﬁlling

operation must be ended. If the tank is not completely empty, the scale readjustment

must be changed to consider the propane (LP) already in the tank.

 WARNING: An LP (propane) tank is overﬁlled if it contains

more than 80% by weight of its total capacity of propane

(LP). An incorrectly ﬁlled or an overﬁlled LP (propane) tank

can be dangerous. If this information is not followed ex-

actly, a ﬁre causing death or serious injury may occur. If a

tank is overﬁlled and the weather causes the warming of

the LP tank, (a hot day, tank left in sun or stored indoors)

internal pressure is created due to expansion of the propane

which in turn causes the LP gas to be released through the

pressure relief valve on the tank. The pressure relief valve

is a safety device required on 20 lb. propane tanks by the

Department of Transportation to prevent a catastrophic tank

failure due to excessive pressure. LP gas released from the

tank is ﬂammable and can be explosive.

CONNECTION Liquid Propane Gas Grills

Temperature-Activated Shut-Off

The large plastic nut on the regulator assembly is designed in coordination with

a check valve in the cylinder valve to shut off the ﬂow of gas when exposed to

temperatures between 240-300ºF.

In the event of a ﬁre or hose break, one of the safeguards will function to control

or stop the ﬂow of gas from the propane cylinder. Never attempt to use damaged

equipment.

NORMAL OPERATION

 WARNING: Your Ducane

grill was not designed to operate

with the Rotisserie Burner and the Main Burner(s) on at the

same time. Failure to follow this warning will lead to an over-

heating condition which would damage grill components

and cause bodily harm.

 WARNING: Keep any electrical supply cord and the fuel sup-

ply hose away from any heated surfaces.

Plug in Accessory Power to Your Grill

Connect your grill to a convenient outdoor outlet. This appliance shall be grounded

while in use to protect the operator from electrical shock. The appliance is equipped

with a 3-conductor cord and a 3-prong grounding-type plug to ﬁt the proper

grounding-type receptacle. Plug into a GFCI protected outdoor receptacle, where

available.

 WARNING: Use only 3-wire extension cords that have 3-prong

grounding-type plugs and 3-pole cord connectors that accept

the plug from the appliance. Only extension cords identiﬁed by

the marking with the sufﬁx letters W-A, and tagged “Suitable for

use with outdoor appliances” shall be used outdoors. Use only

extension cords having an electrical rating not less than the

rating of the appliance. Do not use damaged extension cords.

Examine extension cord before using and replace if damaged.

Do not abuse extension cord and do not tug on any cord to

disconnect. Keep cord away from heat and sharp edges.

Lighting Your Grill

 WARNING: Before each use of your grill it is important to

inspect the full length of the gas line hose. Your hose can

be accessed through the cabinet doors. If it is evident there

is excessive abrasion or wear, or the hose is cut, the hose

must be replaced with a manufacturer recommended part

prior to the appliance being put into operation.

IMPORTANT

If an external electrical source is used it must be electrically grounded in accordance

with local codes and/or the National Electrical Code ANSI/NFPA 70, or the Canadian

Electrical Code, CSA C22.1

Preheating Grill

It is extremely important that your grill be up to temperature before you begin using

it. After lighting, close the lid and preheat the grill on “high” for 10 minutes. This

preheating will ensure that the cooking grid is hot enough for proper grilling.

 WARNING: Never leave a grill unattended to guard against

possible grease ﬁres getting out of control. Grease ﬁres can

be severe and cause grill damage, property damage and

bodily harm.

Open or Close Lid for Grilling

Cooking with the lid open or closed is a matter of personal preference. Cooking with

the lid closed is recommended if you enjoy cooking at maximum “searing” tempera-

tures. This method will also speed the cooking process, and will give you a more ro-

bust, smoky, outdoor ﬂavor. If you prefer cooking slower, with less ﬂare up, we suggest

the lid-open method.

We recommend always cooking with your lid CLOSED if you are in a windy area or

colder climate. Your Ducane

gas grill has been designed and constructed to give

you maximum ﬂexibility and cooking performance. Be creative, try different cooking

methods on your grill to determine what suits your needs best…there is no “right” or

“wrong” way to cook…just different individual styles.

Check your parts list or your authorized dealer for the proper replacement hose as-

sembly. It will be necessary to open the doors to fully inspect the hose.

 DANGER: Make sure that the lid is in the full open postion

any time you attempt to light your grill. Failure to open the

lid could lead to delayed ignition which may result in serious

bodily injury or death, or in a ﬁre or an explosion causing

damage to property.

 WARNING: The burner control knobs must be in the OFF

position before turning on the liquid propane cylinder tank

valve. If they are not in the OFF position, when you turn on

the LP cylinder valve, the “excess gas ﬂow control” feature

will activate, limiting the gas ﬂow of gas from the LP cylin-

der. If this should occur, turn off the LP cylinder valve and

burner control knobs. Then start over.

 DANGER: When the “excess gas ﬂow control” feature is ac-

tivated, a small amount of gas is still ﬂowing to the burners.

After turning OFF the cylinder valve, wait at least 5 minutes

for the gas to clear before attempting to light the barbecue.

Failure to do so may result in an explosive ﬂame-up, which

can cause serious bodily injury or death.

 WARNING: Please remember that this is an outdoor gas

cooking appliance. Many areas of the grill generate extreme

heat. We have taken every precaution to protect you from

the contact areas. However, it is impossible to isolate all

high-temperature areas. Therefore, use good judgment and

a certain degree of caution when grilling on this product. We

suggest a covered, protected hand during operation of grill.

Do not move your grill when it is in operation or hot to the

touch. Wait until your unit is turned off and properly cooled

down before moving from place to place. Failure to follow

this warning could result in personal injury.

12 www.ducane.com

NORMAL OPERATION

Main Burner Snap Ignition

Follow the simple steps listed below to light the Main Burner(s) of your grill:

1. Open the lid and make sure that all burners are in the “OFF” position.

2. Turn main gas supply on.

3. Push the control knob in and turn to “HIGH”. This action will spark the igniter and

light the pilot tube and then Main Burner.

4. If ignition does not occur within 5 seconds, turn control knob “OFF” and repeat

ignition step number 3.

5. Verify that each burner has ignited by visual inspection of a ﬂame.

 WARNING: If ignition still does not occur, turn control knob

OFF and wait 5 minutes before manually lighting the burner

with match. See Match Lighting instructions.

Match Lighting Your Grill Main Burners

Follow the simple steps listed below to match light the Main Burner(s) of grill, in the

event snap ignition fails:

 WARNING: (Make sure that 5 minutes have elapsed since

last attempt of lighting.) Make sure that the lid is in the

full open position any time you attempt to light your grill.

Failure to open the lid could lead to delayed ignition which

may result in serious bodily injury or death, or in a ﬁre or an

explosion causing damage to property.

 WARNING: Do not lean over an open barbecue.

1. Open the lid and make sure that all burners are in the “OFF” position.

 DANGER: Failure to open the lid while igniting the main

burners, or not waiting 5 minutes to allow the gas to clear

if the side burner does not light, may result in an explosive

ﬂame-up which can cause bodily injury or death.

2. Turn main gas supply on.

3. Put match in the match holder and strike match.

4. Push in selected MAIN BURNER control knob and turn to “HIGH”.

5. Insert match holder and light match down through cooking grate to ignite the

selected Main Burner.

 WARNING: If the burner does not light, turn the selected

burner control knob to OFF and wait 5 minutes to let the gas

clear before trying again to light burner(s).

6. Verify selected Main Burner(s) has ignited by visual inspection of a ﬂame.

OFF / ARRET / APAGADO

MAIN BURNER

Post-heating Grill

In order to assist cleaning your cook grid and to completely vaporize remaining juices,

post-heat grill for 10 minutes with the burners on “high” and the lid closed.

 CAUTION: Do not cover the cook grate during the post-heat-

ing period.

After the post-heating of your grill is completed turn the control knobs to the “OFF”

position.

Propane Tank Shut-Off

After the burner box cools down, the propane tank valve should also be closed. If you

do not want to wait for the burner box to cool down, use a covered hand to turn off the

propane tank valve.

NORMAL OPERATION

Match Lighting Your Grill Side Burner

Follow the simple steps listed below to match light the Side Burner of grill, in the event

snap ignition fails:

1. Open the lid and make sure that all burners are in the “OFF” position.

 DANGER: Failure to open the lid while igniting the Side

Burner, or not waiting 5 minutes to allow the gas to clear if

the Side Burner does not light, may result in an explosive

ﬂame-up which can cause bodily injury or death.

2. Turn main gas supply on.

3. Put match in the match holder and strike match.

 WARNING: Do not lean over an open barbecue.

4. Select the Front or rear SIDE BURNER.

5. Push in Side Burner control knob and turn to “high”.

6. Insert match holder and lit match through trivet to ignite the Side Burner.

 WARNING: If burner does not light, turn the Side Burner

control knob to OFF and wait 5 minutes to let the gas clear

before trying again to light burner.

7. Verify Side Burner has ignited by visual inspection of a ﬂame.

Side Burner Snap Ignition

Follow the simple steps listed below to light the Side Burner (SB) of your grill:

 DANGER: Failure to open the lid while igniting the side

burner, or not waiting 5 minutes to allow the gas to clear

if the side burner does not light, may result in a explosive

ﬂame-up which can cause bodily injury or death.

1. Open the lid and make sure that all burners are in the “OFF” position.

2. Turn main gas supply on.

3. Select the Front or rear SIDE BURNER.

4. Push the SIDE BURNER control knob in and turn to “HIGH”. This action will spark

the igniter and light the Side Burner.

5. If ignition does not occur within 5 seconds, turn control knob “OFF” and repeat igni-

tion step number 3.

6. Verify Side Burner has ignited by visual inspection of a ﬂame.

 WARNING: If ignition still does not occur, turn control knob

OFF and wait 5 minutes before manually lighting the burner

with match. See Match Lighting instructions.

REAR SIDE BURNER

OFF / ARRET / APAGADO

FRONT SIDE BURNER

OFF / ARRET / APAGADO

Rotisserie Burner Electronic Ignition

Follow the simple steps listed below to light the Rotisserie Burner of your grill:

 DANGER: Failure to open the lid while igniting the Rotisserie

Burner, or not waiting 5 minutes to allow the gas to clear if

the Rotisserie Burner does not light, may result in a explo-

sive ﬂame-up which can cause bodily injury or death.

 CAUTION: The Rotisserie Burner ﬂame may be difﬁcult to

see on a bright sunny day.

14 www.ducane.com

NORMAL OPERATION

ROTISSERIE BURNER

OFF / ARRET / APAGADO

Match Lighting Your Rotisserie Burner

Follow the simple steps listed below to match light the Rotisserie Burner of grill, in the

event electronic ignition fails:

1. Open the lid and make sure that all burners are in the “OFF” position.

 DANGER: Failure to open the lid while igniting the Rotisserie

Burner, or not waiting 5 minutes to allow the gas to clear if

the Rotisserie Burner does not light, may result in an explo-

sive ﬂame-up which can cause bodily injury or death.

2. Turn main gas supply on.

3. Remove warming rack. NOTE:

Always remove the warming rack when using the

rotisserie.

4. Put match in the match holder and strike match.

 WARNING: Do not lean over an open barbecue.

5. Push the ROTISSERIE BURNER control knob in and turn to “high”. Continue to

hold the ROTISSERIE BURNER control knob in until 20 seconds after the burner

has ignited. Then release the ROTISSERIE BURNER control knob.

6. Hold match holder and lit match to the middle of the Rotisserie Burner to ignite.

 WARNING: If burner does not light, turn the selected burner

control knob to OFF and wait 5 minutes to let the gas clear

before trying again to light burner(s).

7. Verify Rotisserie Burner has ignited by visual inspection of a ﬂame. (The burner will

glow red.)

 WARNING: Never leave a grill unattended. This will guard

against possible grease ﬁres getting out of control. Grease

ﬁres can be severe and cause grill damage, property dam-

age and bodily harm.

 WARNING: Please remember that this is an outdoor gas

cooking appliance. Many areas of the grill generate extreme

heat. We have taken every precaution to protect you from

the contact areas. However, it is impossible to isolate all

high-temperature areas. Therefore, use good judgment and

a certain degree of caution when grilling on this product. We

suggest a covered, protected hand during operation of grill.

Do not move your grill when it is in operation or hot to the

touch. Wait until your unit is turned off and properly cooled

down before moving from place to place. Failure to follow

this warning could result in personal injury.

1. Open the lid and make sure that all burners are in the “OFF” position.

2. Turn main gas supply on.

3. Remove warming rack. NOTE: Always remove the warming rack when using the

rotisserie.

4. Push the ROTISSERIE BURNER control knob in and turn to “HIGH”. Continue to

hold the ROTISSERIE BURNER control knob in until 20 seconds after the burner

has ignited. Then release the ROTISSERIE BURNER control knob.

5. Push the electronic ignition button in and hold until the Rotisserie Burner is

completely ignited. You will be able to both hear and see a spark in front of the

Rotisserie Burner.

6. If ignition does not occur within 5 seconds, turn control knob “OFF” and repeat

ignition step numbers 3 and 4.

7. Verify Rotisserie Burner has ignited by visual inspection of a ﬂame. (The burner will

glow red.)

 WARNING: If ignition still does not occur, turn control knob

OFF and wait 5 minutes before manually lighting the burner

with match. See Match Lighting instructions.

NORMAL OPERATION

Using the Rotisserie

WARNINGS:

Read all instructions before using your rotisserie.

 This rotisserie is for outdoor use only.

 Remove motor and store in a dry place when not in use.

 Do not touch hot surfaces. Use barbecue mitts.

 This rotisserie is not for use by children.

 To protect against electrical hazards do not immerse cord,

plugs, or motor in water or other liquids.

 Unplug the motor from outlet when not in use or before

cleaning.

 Do not use rotisserie for other than intended use.

 Make sure motor is OFF before placing it on the motor

bracket.

 Do not operate the rotisserie motor with a damaged cord or

plug.

 Do not operate the rotisserie motor if it should malfunction.

 The rotisserie motor is equipped with a three prong (ground-

ing) power cord for your protection against shock hazard.

 The power cord should be plugged directly into a properly

grounded three prong receptacle. If use of an extension cord

is required, be sure that it is a minimum 16 AWG, 3 wire well

insulated cord, marked for outdoor use only and properly

grounded.

 When using an extension cord, make sure it is not in contact

with a hot or sharp surface.

 Outdoor extension cords should be marked with the letters

“W-A” and a tag stating “Suitable for use with outdoor appli-

ances”.

 Do not cut or remove the grounding prong from the rotis-

serie motor power cord.

 Do not let cord hang over any sharp edge or hot surface.

 Do not expose to rain.

 To reduce the risk of electric shock, keep extension cord

connection dry and off the ground.

 A short power cord is supplied to reduce the risk of tripping

over the cord. Extension cords may be used, but caution

must be taken to prevent tripping over the cord.

 In absence of local codes the rotisserie motor must be

grounded electrically in accordance with the National Elec-

trical Code, ANSI/NFPA 70, or Canadian Electrical Code, CSA

C22.1.

 WARNING: Setup the rotisserie with food before lighting

Rotisserie Burner. Operating the Rotisserie

1. Remove rotisserie shaft from grill.

2. Loosen and remove right side bearing, the counterbalance and right side spit fork.

3. Push the rotisserie shaft through the center of the food.

4. Slide the right side spit fork back onto the shaft. Insert the tines of both spit forks

into the food. The food should be centered on the shaft. Tighten spit fork thumb

screws.

5. Place left side bearing (welded in place) groove into the left side spit rod mount

cut-out.

6. Place the right side bearing onto the spit rod and insert the pointed end of the spit

rod into the rotisserie motor.

7. Line up both the groove on the right side bearing with the right side spit rod

mount cut-out, and slide the motor over the motor mounting bracket ﬂange and

push down. Note: The thumbscrew is only tightened when the rotisserie is not

in use. Do not tighten the thumbscrew when using so that the spit rod can rotate

freely.

8. The rotisserie shaft should rotate so that the heavy side of the meat or poultry ro-

tates down to the bottom. Large cuts of meat may require the removal of the cook

grates to allow full rotation of the spit rod. Note: Remount the food and/or use the

counterbalance if necessary for better balance on the spit rod. The counterbal-

ance can be mounted after Step 5 above.

9. Plug the motor in and turn it on.

10. Follow Lighting Instructions. The cord can be routed through the access hole at

the back of the grill Plug cord into the accessory outlet inside the base cabinet.

 CAUTION: Do not use more than 9.5A from the receptacle.



16 www.ducane.com

NORMAL OPERATION

Cooking with the Rotisserie

• When using the rotisserie, the lid must be closed except when basting.

• Meats (except poultry and ground meat) should be brought to room temperature

before cooking. (20 to 30 minutes should be adequate for most foods. If frozen

defrost completely before cooking.)

• Tie meat or poultry with a string, if necessary, to make the shape as uniform as pos-

sible before putting it on the spit.

• Remove cooking grates and warming rack to allow food to turn freely.

• Follow Lighting Instructions for Rotisserie Burner under Lighting Your Grill sec

tion.

• Set Rotisserie Burner on “med-high” based on outside air temperatures.

• Place food within area of burner.

• If you wish to save drippings for gravy, place a drip pan directly under the food on

top of the heat distribution plates.

• Food preparation steps are the same for rotisserie cooking as for regular cooking.

NOTE: When using the Rotisserie Burner, grill thermometer will not reﬂect the tem-

perature inside the cooking box.

Operating the Electric Warming Drawer

 CAUTION: When operating additional appliances while the

rotisserie motor is in use, the household electrical

circuit could overload.



WARNING: Do not use or spill liquids on our near the

accessory outlet.

1. Make sure that the grill has been plugged into a properly grounded outlet.

2. Before using the Electric Warming Drawer, move the humidity control knob, so

that the humidity control vent is partially open. This will prevent moisture and

steam from forming in the Warming Drawer.

3. Carefully place food to be warmed inside the Warming Drawer



Do not touch hot surfaces. Use barbecue mitts.

4. Close drawer and turn the power switch to on.

5. Adjust the control knob to reach the desired warming temperature.

 WARNING: Moist foods may cause steam to form in the

Warming Drawer. Use an oven mitt when opening the Warm-

ing Drawer to prevent steam from contacting skin. Steam may

cause serious burns to skin.

RMING DR

OFF / ARRET /

GADO

WARMING DRAWER OPERATION

1. Read all instructions before use.

2. Push switch to ON.

3. Select desired temperature and

humidity control.

HELPFUL HINTS

Flare Ups

Any time you cook fatty foods over an open ﬂame, you can expect ﬂare ups. Flare ups

are caused by the ﬂash which occurs when the natural juices fall on the heat distribu-

tion plates. Controlled ﬂare ups give foods their delicious outdoor ﬂavor and appear-

ance. Excessive ﬂare ups may occur when your grill is not level or when cooking fatty

foods such as spare ribs and chicken parts, especially if the cooking temperature is set

too high. These ﬂare ups should be controlled or your food will burn, although it will

not burn nearly as much as you might think even in the direct ﬂame.

 WARNING: Do not spray or pour any liquid into the cooking

box to control ﬂare ups. Doing so will void your warranty

and may damage the grill.

To help control ﬂare ups, we suggest using leaner cuts of meats and trimming excess

fat from the meats to be grilled. Also, your grill should be level. If ﬂare ups do occur,

use the “Low” control setting and relocate the meat on the cooking grid until the ﬂare

ups have subsided.

1. To prevent food from sticking to the grid, preheat the cooking surface with the hood

down for 10 minutes. Place the meat product on the grid and allow it to remain

there for at least half of the suggested grilling time.

2. It is unnecessary to keep ﬂipping meat products— allow them to sear and seal in

their juices, then halfway through the cooking period, with a spatula, ﬂip the meat

product onto its other side. When grilling chicken, always place the meat side on the

grill ﬁrst.

3. A light coating of oil applied to any of the meat products prior to grilling will also

help. The use of a commercial spray cooking product is also helpful. This spray

should only be used prior to lighting your grill but never during the cooking period.

Use of spray cooking product can leave a black stain on areas of your cook grate.

This is not harmful and does not affect cooking; however, if this becomes an appear-

ance problem, the best way to remove the discoloration is by placing the cook grate

in a self-cleaning oven during the clean cycle.

When Using the Rotisserie

 WARNING: The rotisserie motor must be stored indoors

when not in use. Do not leave it mounted on the grill.

1. When using the rotisserie, the hood must be closed except when basting.

2. Important: Always light rotisserie burner with the hood in the full open position.

3. It is important to evenly balance the meat on the spit rod. This can be difﬁcult

especially with a turkey. Proper balancing will lead to more even cooking and

prolong the life of the rotis motor.

4. Pliers may be used to tighten thumb screws on meat forks when larger cuts of

meat are being rotissed.

5. Use twine to secure the meat on the spit rod, especially fowl or other cuts of meat

that require tying.

Rotisserie Bracket (Motor Bracket Side)

When mounting the spit rod motor onto the motor bracket (right side burner box), the

ears of the motor bracket must be fully inserted into the spit motor slots.

Accomplish this by sliding the spit motor down to the stops of the spit motor bracket.

The spit rod should not be making surface contact with the slot in the spit motor

bracket. See Assembly Guide for more information.

Shelf/Shelves

Do not use shelf or shelves as a cutting board. Clean with soap and water.

Moving Portable Grills

When your grill is not in use and you wish to relocate it, we recommend you push the

grill by the side shelf.

 CAUTION: If your grill is portable and you are using a gas

tank, make sure you turn the appliance control knobs ﬁrst,

and then the gas supply tank. On permanent installations, it

is strongly recommended that the inline ﬁeld installed cutoff

valve also be turned off when the grill is not in use.

Storing Liquid Propane Gas Grills

After you have ﬁnished cooking and have cleaned your grill (see Maintenance section

for cleaning) turn your grill off!

When the grill is to be stored indoors, the connection between the propane gas sup-

ply tank and the grill must be disconnected, and the tank removed from the grill

and stored outdoors in a well-ventilated space. When the propane gas supply tank is

not removed from the grill, the grill and the tank must be stored outdoors in a well

ventilated space.

Gauging Amount of Fuel in Liquid Propane Tank

To gauge the amount of propane fuel in your gas tank, (propane tank without gauge)

the grill must be in operation. Place your hand at the top of the tank and slowly move

it down the side until the tank feels cool to the touch of your hand. This will indicate

the approximate amount of propane gas in your tank.

Gas Valve Oriﬁce

 WARNING: Any alteration made to the oriﬁce(s) such as drill-

ing it out, will void your warranty and may result in serious

bodily injury or death, or in a ﬁre or an explosion causing

damage to property.

18 www.ducane.com

TROUBLESHOOTING

PROBLEM CHECK and CURE IMPORTANT

IGNITION SYSTEM

Be sure that there is gas ﬂow to the burners by attempting to match light your burners.

If match lighting is successful, the problem lies somewhere in the ignition system and

will need to be checked.

MAIN GRILLING BURNERS

 CAUTION: Always turn the gas supply off at the tank before

proceeding with any troubleshooting procedures.

If, for any reason, the snap ignition fails to ignite the main grilling burner(s), repeat the

lighting procedures described on the grill control panel.

 WARNING: The hood must be in the full open position any

time you attempt to light your grill. Failure to open the

hood could lead to delayed ignition resulting in bodily

harm.

After shutting off the main gas supply, remove the cook grate and heat distribution

plates. Turn snap igniter counter clockwise and check if the electrode is sparking to the

igniter tube. Try the snap igniter several times.

If the main burner(s) still fails to ignite, make

sure that there is gas ﬂowing to the burner(s)

by attempting to match light the burner(s).

If the burners will match light, then proceed

with the ignition checkout.

If for any reason the igniter system is still

inoperative, follow match lighting instructions.

WARMING DRAWER

If, for any reason, the Warming Drawer fails to operate:

1. Repeat the operating procedures described earlier.

2. Check that the grill has been plugged into an outlet with household current.

3. Check that the power to the circuit is on.

4. If the outlet is a GFCI device, check that the device has been reset.

ROTISSERIE BURNER ELECTRONIC

IGNITION

With a fresh battery installed, push electronic ignition button and check if there is a

spark between the two electrode tips. There needs to be a 1/8” to 3/16” gap between

the electrode tips. If the gap is lesser or greater, carefully bend the electrode tips until

you have the correct gap of 1/8” to 3/16”(A).

Verify that the battery is in good condition

and installed correctly. If so, try a new

battery.

If for any reason the igniter system is still

inoperative, follow match lighting instructions.

BURNERS WITH POOR FLAME

Check to be sure burner ports, shutter, end of the burner (venturi) and oriﬁce(s) are

free of any obstructions. Also, if your grill has been stored over a prolonged period of

time, check to make sure no spiderwebs have been formed in the shutter end of the

burner (venturi) or over oriﬁces.

On an LP grill, if an extremely low ﬂame is present, or is hard to ignite, the

ﬂow-limiting device may have activated. To reset the ﬂow limiter turn all burners control

knobs to “high”. Wait at least 1 minute. Turn burner control knobs “OFF”, reconnect

the regulator to the cylinder. Turn cylinder valve on slowly. Refer to Lighting Insructions.

If you still have a poor ﬂame, please contact

dealer for futher assistance or call Customer

Service AT 1-800-DUCANES

If problems cannot be corrected by using these methods, please contact the Customer Service Representative in your area using the contact information on our

web site. Log onto www.ducane.com.

Yes, you paid a lot of money for your grill, but even an expensive grill doesn’t clean

and maintain itself, and you want it to look good and function properly. That’s why

this section of your manual is so important. This section gives you the information

necessary to help you keep your grill looking new and working properly. Reading and

following the instructions in this section will make your grill investment pay off for

many years.

90-Day Grill Maintenance Schedule

It is recommended that every 90 days the following maintenance procedure is fol-

lowed, but it is absolutely necessary to perform this maintenance at least once a year.

By doing so you will extend the life of your gas grill.

Cleaning the Hood

The exterior of the hood should be maintained with a stainless steel cleaner. The inside

of the hood may be cleaned with a solution of warm water and liquid detergent to

remove any grease build-up.

IMPORTANT

• Keep appliance area clear and free from combustible materials, gasoline and other

ﬂammable vapors and liquids at all times.

• Do not locate your grill in such a manner or otherwise obstruct the ﬂow of combus

tion and ventilation air around the grill.

• As part of the normal maintenance schedule, check to be sure that all ventilation

openings are free and clear from debris.

MAINTENANCE

Cleaning the Stainless Steel Cook Grate

To keep your grill operating properly, the stainless steel cook grate should be cleaned

regularly.

1. The stainless steel cook grate can be easily cleaned after the post-heating period.

As soon as the 10 minutes post-heating is completed, turn the gas off. Open the lid

with a covered hand and with the use of a brass brush, rub the grid surface.

The Ducane

stainless steel cook grate has been constructed of strong, sturdy stainless

steel. You will ﬁnd this cooking surface to be extremely durable while providing more

heat directly to your cooking surface for faster, more economical cooking.

Cleaning the Heat Distribution Plates

Your stainless steel heat distribution plates should also be brushed down with the use

of a brass long-handled brush.

Cleaning the Burner Box

Clean when cook grate and heat distribution plates are removed from burner box.

Clean out any ash or deposits from burner box using warm soapy water and a soft

cloth. Allow to dry before replacing all parts.

A small amount of grease may accumulate on the bottom of the burner box. It can be

scraped up and discarded with a ﬂat-blade putty knife. Use a soap and water solution

to clean after you have scraped.

Prolonged grilling with the hood in the down position may cause a grease build up in-

side the hood that will begin to ﬂake (this is not paint). If this develops, clean the inside

of the hood with a warm water and soap solution. Be careful not to get the burner wet.

Preserve Your Cabinet, Control Panel and Shelf/Shelves

Your cabinet, control panel and shelves are made from stainless steel. To keep the

stainless steel looking its best is a simple matter. Clean it with soap and water, rinse

with clear water and wipe dry. It’s that easy. We recommend the use of a diluted liquid

dishwashing detergent and water solution. For stubborn particles, the use of a non-me-

tallic brush can be used. Do not use a wire brush on your cooking shelf.

 CAUTION: Do not use a wire brush or abrasive cleaners on

the lid, cabinet and shelves of your grill as this will scratch

the surface.

CAUTION: When cleaning surfaces be sure to rub in the

direction of the grain to preserve the look of your stainless

steel.

Grease Fires

The recommendations in the Maintenance section, concerning cleaning our grill, and

in the Normal Operation section concerning preheating and post-heating your grill are

extremely important for two reasons:

1. Keep your grill cooking at its best by keeping the cooking surfaces and heat trans-

mitting components clean. Keeping your grill clean is the best way of keeping your

grill cooking properly.

MAINTENANCE

2. For safety reasons. A dirty grill is susceptible to grease ﬁres.

Depending on the amount of cooking, the types of food cooked, the amount of pre-

heating and post-heating and the amount of cleaning performed on a grill, any grill

can be susceptible to a grease ﬁre. A build up of meat fats, cooking marinades, basting

sauces, salts, etc. can ignite and cause a severe grease ﬁre.

If a grease ﬁre were to occur on a Ducane

grill, ﬂames would probably be seen under

the burner box. A severe grease ﬁre could lead to a burned hose or regulator which

would allow gas to feed the ﬁre and, obviously, make the ﬁre worse.

Any type of ﬁre requires that the grill components (hose, regulators, LP tanks, etc...)

involved be checked for continued safe operation. If a leak is suspected, the gas supply

system (hose, manifold, tank, ﬁttings, etc...) must be leak tested, using a soapy water

solution, to verify the source of the leak. If no leak is found, then the problem was most

likely a grease ﬁre.

A grease ﬁre can be severe enough to damage your grill and/or cause property damage

and/or cause bodily harm. Ducane does not want this to happen and neither do you.

Follow our cleaning recommendations to avoid grease ﬁres.

 WARNING: Check the grease tray for grease build-up before

each use. Remove excess grease to avoid a grease ﬁre.

ANNUAL MAINTENANCE

Inspection and Cleaning of the Spider/Insect Screens

To inspect the Spider/Insect screens.

1. Turn “OFF” gas at source.

2. Remove the cooking grate and the heat distribution plates, exposing the burner

tubes.

20 www.ducane.com

3. Remove the two(2) screws and washers holding each

valve to the control panel and control knob bezel.

ANNUAL MAINTENANCE

4. Loosen the control panel by removing two(2) screws

on each end.

5. Pull control panel away from grill a few inches.

Disconnect wire from the electronic igniter for the

rotisserie burner.

La page charge ...

Ducane 20529914 Manuel utilisateur

Marque: Ducane

Modèle: 20529914

Catégorie: Barbecues

Taper: Manuel utilisateur

Télécharger le PDF

rapport

dans d''autres langues

English: Ducane 20529914 User manual
español: Ducane 20529914 Manual de usuario

Ducane 20529914 Manuel utilisateur

Ducane 20529914 Manuel utilisateur

dans d''autres langues

Documents connexes