red lion N-Tron 1003GX2 Manuel utilisateur

Marque: red lion

Modèle: N-Tron 1003GX2

Catégorie: Commutateurs réseau

Taper: Manuel utilisateur

Ce manuel convient également à

N-Tron

1000 Series

Industrial Gigabit Media Converters

& Gigabit Ethernet Switches

Hardware Guide | March 2015

Buy: www.ValinOnline.com | Phone 844-385-3099 | Email: [email protected]

20 Willow Springs Circle

York, PA 17406

Inc. All other company and product names are trademarks of their respective owners.

The information contained in this document is subject to change without notice. Red Lion makes no warranty

of any kind with regard to this material, including, but not limited to, the implied warranties of merchantability

or fitness for a particular purpose. In no event shall Red Lion be liable for any incidental, special, indirect or

consequential damages whatsoever included but not limited to lost profits arising out of errors or omissions

in this manual or the information contained herein.

CONTACT INFORMATION :

AMERICAS

York, PA: +1 (717) 767-6511

Mobile, AL: +1 (251) 342-2164

Ballston Lake, NY: +1 (518) 877-5173

Hours: 8am-6pm Eastern Standard Time

(UTC/GMT -5 hours)

ASIA-PACIFIC

Shanghai, P.R. China: +86 21-6113-3688 x767

Hours: 10am-6pm China Standard Time

(UTC/GMT +8 hours)

EUROPE

The Netherlands: +31 33-4723-225

Hours: 9am-6pm Central European Time

(UTC/GMT +1 hour)

Buy: www.ValinOnline.com | Phone 844-385-3099 | Email: [email protected]

N-Tron 1000 Series Hardware Guide i

Table of Contents Revised 2015-03-24

Table of Contents

Preface

Disclaimer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . iii

Compliance Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . iii

Part 15 of the Federal Communications Commission (FCC) - A Rules: Interference . . . . . . iii

Industry Canada . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . iii

Environmental Impact Statement . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . iv

Toxic Emissions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . iv

Trademark Acknowledgments . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . iv

Release Notes and Document Updates . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . iv

Publication History . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . iv

Related Documents . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . iv

Document Comments . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . iv

Additional Product Information. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . iv

Warnings and Cautions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . v

General Safety Cautions and Warnings . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . v

Electrical Safety Warnings . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . v

Environmental Safety Cautions and Warnings . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . vii

Hazardous Location Warning . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . vii

Laser Safety Warning . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . viii

Introduction and Specifications

Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-1

Key Features . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-1

Product Ordering Guide . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-2

Model 1002MC Key Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-3

Model 1002MC Regulatory Approvals . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-4

Safety . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-4

EMI . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-4

EMS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-4

Warranty. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-4

Model 1003GX2 - Key Specifications. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-5

Model 1003GX2 Regulatory Approvals . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-6

Safety . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-6

EMI . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-6

EMS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-6

Buy: www.ValinOnline.com | Phone 844-385-3099 | Email: [email protected]

Table of Contents Revised 2015-03-24

ii N-Tron 1000 Series Hardware Guide

Warranty. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-6

Model 1005TX - Key Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-7

Model 1005TX Regulatory Approvals . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-7

Safety . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-7

EMI . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-7

EMS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-7

Warranty. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-8

Model 1008TX - Key Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-9

Model 1008TX Regulatory Approvals . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-9

Safety . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-9

EMI . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-9

EMS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-10

Warranty. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-10

Installation

Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-11

Unpacking . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-11

Inspection . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-11

Installing/Mounting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-11

DIN-Rail Mounting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-12

Connections . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-13

Power Connection (Top View) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-13

Ground Connection . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-13

N-Tron Series Switch Grounding Techniques for 1000 Series . . . . . . . . . . . . . . . . . . . . . . . . 2-13

Cable Connection . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-15

Operation and Maintenance

Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-17

Controls and Indicators . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-17

Model 1002MC, 1003GX2, 1005TX Indicators . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-17

Model 1008TX Indicators . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-18

Maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-19

Verify/Troubleshoot Cable Interface . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-19

Cleaning . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-19

Red Lion Controls N-Tron 1000 Series Limited Warranty . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-20

Buy: www.ValinOnline.com | Phone 844-385-3099 | Email: [email protected]

N-Tron 1000 Series Hardware Guide iii

Preface Revised 2015-03-24

Preface

Disclaimer

Portions of this document are intended solely as an outline of methodologies to be followed during the

maintenance and operation of N-Tron 1000 Series equipment. It is not intended as a step-by-step guide or a

complete set of all procedures necessary and sufficient to complete all operations.

While every effort has been made to ensure that this document is complete and accurate at the time of release, the

information that it contains is subject to change. Red Lion Controls is not responsible for any additions to or

alterations of the original document. Industrial networks vary widely in their configurations, topologies, and traffic

conditions. This document is intended as a general guide only. It has not been tested for all possible applications,

and it may not be complete or accurate for some situations.

Users of this document are urged to heed warnings and cautions summarized at the front of the document, such as

electrical hazard warnings.

Compliance Information

It is recommended that the owner of this equipment determine and ensure conformance with any specific and

applicable local regulations.

Part 15 of the Federal Communications Commission (FCC) - A Rules: Interference

Every effort has been made to ensure that this equipment is designed to comply with the limits for a Class A digital

device, as described in the FCC Rules.

This product complies with Part 15 of the FCC-A Rules.

Operation is subject to the following conditions:

1. This device may not cause harmful Interference

2. This device must accept any interference received, including interference that may cause undesired operation.

This equipment has been tested and found to comply with the limits for a Class A digital device, pursuant to Part 15

of the FCC Rules. These limits are designed to provide reasonable protection against harmful interference in a

residential installation. This equipment generates, uses, and can radiate radio frequency energy and, if not

installed and used in accordance with the instructions, may cause harmful interference to radio communications.

Operation of this device in a residential area is likely to cause harmful interference in which case the user will be

required to correct the interference at their own expense.

Industry Canada

This Class A digital apparatus meets all requirements of the Canadian Interference Causing Equipment

Regulations. Operation is subject to the following two conditions; (1) this device may not cause harmful

interference, and (2) this device must accept any interference received, including interference that may cause

undesired operation.

Cet appareillage numérique de la classe A répond à toutes les exigences de l'interférence canadienne causant des

règlements d'équipement. L'opération est sujette aux deux conditions suivantes: (1) ce dispositif peut ne pas

causer l'interférence nocive, et (2) ce dispositif doit accepter n'importe quelle interférence reçue, y compris

l'interférence qui peut causer l'opération peu désirée.

Buy: www.ValinOnline.com | Phone 844-385-3099 | Email: [email protected]

Preface Revised 2015-03-24

iv N-Tron 1000 Series Hardware Guide

Environmental Impact Statement

Red Lion equipment contains no hazardous materials as defined by the United States Environmental Protection

Agency (USEPA). Red Lion recommends that all failed product be returned to Red Lion for failure analysis and

proper disposal.

Toxic Emissions

Red Lion equipment releases no toxic emissions.

Trademark Acknowledgments

Ethernet is a registered trademark of Xerox Corporation.

EtherNet/IP

and CIP

are registered trademarks of ODVA.

Release Notes and Document Updates

The hard copy and electronic media versions of this document are revised only at major releases and therefore,

may not always contain the latest product information. As needed, Documentation Notes and or Product Bulletins

will be provided between major releases to describe any new information or document changes.

The latest online version of this document and all product updates can be accessed through the Red Lion web

site.

Publication History

The following information lists the release history of this document.

Related Documents

Visit the Technical Resources page on the Red Lion website at the following link to view available documents

related to this product.

Document Comments

Red Lion appreciates all comments that will help us to improve our documentation quality. The user can

submit comments through the Red Lion Customer Service. Simply email us.

Additional Product Information

Additional product information can be obtained by contacting the local sales representative or Red Lion through the

contact numbers and/or e-mail addresses listed on the inside of the front cover.

ISSUE/REVISION RELEASE DATE CONTENT DESCRIPTION

Revised 2014-01-23 January 2014 Document Updates

Revised 2015-03-17 March 2015 Added 1008TX Model, Format Changes

Revised 2015-03-24 March 2015 Format Changes to Cover, Page Header and Tables

Buy: www.ValinOnline.com | Phone 844-385-3099 | Email: [email protected]

N-Tron 1000 Series Hardware Guide v

Preface Revised 2015-03-24

Warnings and Cautions

Warnings apply to situations where personal injury or death may result.

Cautions apply to where reduced function or damage to equipment may result.

General Safety Cautions and Warnings

Electrical Safety Warnings

CAUTION: If the N-Tron series equipment is used in the manner not specified by Red Lion, the

protection provided by the equipment may be impaired.

ATTENTION: Si l' N-Tron série équipement est utilisé d'une manière non spécifiée par Red Lion,

la protection fournie par l'équipement peut être compromise.

CAUTION: Do not perform any services on the unit unless qualified to do so. Do not substitute

unauthorized parts or make unauthorized modifications to the unit.

ATTENTION: Ne pas effectuer de services sur l'appareil s'il n'est pas qualifié pour le faire. Ne pas

substituer pièces non autorisées ou de modifications non autorisées de l'appareil.

CAUTION: Do not operate the equipment in a manner not specified by this manual.

ATTENTION: Ne pas faire fonctionner l'équipement d'une manière non spécifiée par ce manuel.

WARNING: Install only in accordance with Local and National Codes of authorities having

jurisdiction.

ALERTE: Installer uniquement, conformément aux codes locaux et nationaux des autorités ayant

compétence.

WARNING: Do not work on equipment or cables during periods of lightning activity.

ALERTE: Ne pas travailler sur le matériel ou les câbles pendant les périodes d'activité de la

foudre.

Buy: www.ValinOnline.com | Phone 844-385-3099 | Email: [email protected]

Preface Revised 2015-03-24

vi N-Tron 1000 Series Hardware Guide

WARNING: Properly ground the unit before connecting anything else to the unit. Units not

properly grounded may result in a safety risk and could be hazardous and may void the warranty.

See the grounding technique section of this Hardware Guide for proper ways to ground the unit.

ALERTE: Correctement à la terre de l'unité avant tout raccordement à l'unité. Unités pas

correctement mise à la terre peut entraîner un risque de sécurité et pourraient être dangereux et

peut annuler la garantie. Voir la section technique de mise à la terre de ce mode d'emploi des

moyens appropriés à la masse de l'appareil.

WARNING: This equipment must be used with a Listed UL Industrial Power Supply.

ALERTE: Cet équipement doit être utilisé avec une alimentation UL Listed industrielle.

WARNING: This equipment (1005TX and 1008TX) must be used with a Listed UL Class 2 Power

Supply.

ALERTE: Cet équipement (1005TX and 1008TX) doit être utilisé avec une alimentation UL Listed

Classe 2.

WARNING: A Recognized or Listed fuse, rated maximum 3A, minimum 30VDC, must be installed

on the line side of the device.

ALERTE: Un fusible reconnu ou classé, classé 3A maximale, 30VDC minimum, doit être installé

sur le côté de la ligne de l'appareil.

WARNING: Use 110°C or higher rated copper wire, (0.22Nm) 2 lb/in tightening torque for field

installed conductors.

ALERTE: Utilisez 110°C ou nominale supérieure fil de cuivre, (0,22 Nm) 2 lb/pouce couple de

serrage pour le champ installé conducteurs.

WARNING: Do not operate the unit with the end plates removed, as this could create a shock or

fire hazard.

ALERTE : Ne pas faire fonctionner l'unité avec les plaques d'extrémité retiré, ce qui pourrait créer

une décharge électrique ou un incendie.

CAUTION: Observe proper DC Voltage polarity when installing power input cables. Reversing

voltage polarity can cause permanent damage to the unit and voids the warranty.

ATTENTION: Respecter la polarité correcte de tension DC lors de l'installation des câbles

d'alimentation d'entrée. Inversion de polarité de tension peut causer des dommages permanents à

l'appareil et annule la garantie.

Buy: www.ValinOnline.com | Phone 844-385-3099 | Email: [email protected]

N-Tron 1000 Series Hardware Guide vii

Preface Revised 2015-03-24

Environmental Safety Cautions and Warnings

Hazardous Location Warning

CAUTION: This equipment is suitable for use in Class I, Division 2, Groups A, B, C, and D or

non-hazardous locations only.

ATTENTION: Cet équipement est adapté pour une utilisation dans la classe I, Division 2, Groupes

A, B, C et D ou non dangereux endroits seulement.

WARNING: Explosion Hazard – Substitution of components may impair suitability for Class I,

Division 2.

ALERTE - Risque d'explosion - Remplacement d'un composant peut empêcher la conformité de

Classe I, Division 2.

WARNING: Do not operate the equipment in the presence of flammable gases or fumes. Operat-

ing electrical equipment in such an environment constitutes a definite safety hazard.

ALERTE : Ne pas utiliser le matériel en présence de gaz ou de vapeurs inflammables. L'utilisation

de matériel électrique dans un tel environnement constitue un danger certain.

WARNING – Explosion Hazard – Do not connect or disconnect any connections while circuit is

live unless area is known to be non-hazardous.

ALERTE - Risque d'explosion - Ne pas brancher ou débrancher les connexions lorsque le circuit

est sous tension sauf si la zone est connue pour être non dangereux.

WARNING: Disconnect the power and allow to cool 5 minutes before touching.

ALERTE: Déconnectez le câble d'alimentation et laisser refroidir 5 minutes avant de la toucher.

WARNING (1005TX and 1008TX only): This equipment is open-type device and is meant to be

installed in an enclosure suitable for the environment that is only accessible with the use of a tool.

ALERTE (1005TX and 1008TX uniquement): Cet équipement est ouvert de type périphérique et

est destiné à être installé dans un boîtier adapté à l'environnement qui n'est accessible qu'avec

l'utilisation d'un outil.

Buy: www.ValinOnline.com | Phone 844-385-3099 | Email: [email protected]

Preface Revised 2015-03-24

viii N-Tron 1000 Series Hardware Guide

Laser Safety Warning

CAUTION (1002MC and 1003GX2 only): CLASS 1 LASER PRODUCT. Do not stare into the

laser.

ATTENTION (1002MC et 1003GX2 uniquement): PRODUIT LASER CLASSE 1. Ne pas regarder

dans le laser.

Buy: www.ValinOnline.com | Phone 844-385-3099 | Email: [email protected]

N-Tron 1000 Series Hardware Guide 1-1

Introduction and Specifications Revised 2015-03-24

Section 1 Introduction and Specifications

Introduction

The N-Tron 1000 Series Unmanaged Industrial Gigabit Ethernet Switches support high speed layer 2 switching

between ports. This series of switches are housed in a ruggedized aluminum enclosure, and provide Category-5

compliant 10/100/1000Base-T connections for high performance network design, and hub/repeater upgrades.

All fiber products utilize the IEEE compliant LC duplex connectors for fiber optic communications in a convenient

SFP (Small Form Pluggable) modular design. All 10/100/1000Base-T ports utilize the RJ45 shielded connectors.

The 1002MC/MCE is a two port unmanaged media converter that converts 10/100/1000Base-T copper to

1000BaseSX/LX full duplex fiber.

The 1003GX2/GXE2 is a three port unmanaged switch that offers one 10/100/1000Base-T copper port and two

1000BaseT/SX/LX full duplex copper/fiber ports.

The 1005TX is a five port unmanaged switch that offers five 10/100/1000Base-T copper ports.

The 1008TX is an eight port unmanaged switch that offers eight 10/100/1000Base-T copper ports.

Key Features

• Compact Space Saving Package

• Full IEEE 802.3 Compliance

• Unmanaged Operation

• Jumbo Frame Support (1005TX and 1008TX only)

• Extended Environmental Specifications

• -40°C to 85°C Operating and Storage Temperature

• Supports Full/Half Duplex Operation

• Up to 16.0 Gb/s Maximum Throughput

• MDIX Auto Sensing Cable

• Auto Sensing Speed and Flow Control

• Full Wire Speed Communication

• Store-and-Forward Switching Technology

• Redundant Power Inputs (10-30 VDC, 10-49VDC for 1008TX)

• LED Link/Activity Status Indication

• Hardened Metal Enclosure

• Industry Standard 35mm DIN Rail Mounted Enclosure

Buy: www.ValinOnline.com | Phone 844-385-3099 | Email: [email protected]

N-Tron 1000 Series Hardware Guide 1-2

Introduction and Specifications Revised 2015-03-24

Product Ordering Guide

The 1000 Series Media Converter and Unmanaged Industrial Gigabit Ethernet Switch model part numbers and net-

work applications are presented in Table 1.

Table 1. Ordering Guide

Where: “YY” or “ZZ” is: 10 for 10km maximum fiber segment length

40 for 40km maximum fiber segment length

80 for 80km maximum fiber segment length

PART NUMBER APPLICATION

1002MC-SX 1000BaseSX Multimode fiber Media Converter

1002MC-LX-YY 1000BaseLX Singlemode fiber Media Converter

1003GX2 Three port; One 10/100/100BaseT; Two 1000BaseSX/LX Gigabit Ethernet Switch

1003GX2-B One 10/100/1000BaseT port; Two 1000BaseSX/LX ports with mix-and-match SFP Mini-GBIC

fiber transceivers. Note: Unit must be populated with two SFP transceivers upon shipment

1003GX2-SX One 10/100/1000BaseT port; Two (2) 1000BaseSX SFP Mini-GBIC fiber transceivers

1003GX2-LX-10 One 10/100/1000BaseT port; Two (2) 1000BaseLX-10 SFP transceivers

1003GX2-LX-40 One 10/100/1000BaseT port; Two (2) 1000BaseLX-40 SFP transceivers

1003GX2-LX-80 One 10/100/1000BaseT port; Two (2) 1000BaseLX-80 SFP transceivers

1005TX Five port 10/100/1000BaseT Gigabit Ethernet switch

1008TX Eight port 10/100/1000BaseT Gigabit Ethernet switch

NTSFP-SX One 1000BaseSX Multimode SFP Gigabit Transceiver with LC Style Connector for up to

550m fiber segment length (two required per unit)

NTSFP-LX-ZZ One 1000BaseLX Singlemode SFP Gigabit Transceiver with LC Style Connector for up to ZZ

fiber segment length (two required per unit)

NTPS-24-1.3 DIN-Rail Power Supply [email protected] amp; Used with all models

1000-PM Panel Mount kit; Used with all models

Buy: www.ValinOnline.com | Phone 844-385-3099 | Email: [email protected]

N-Tron 1000 Series Hardware Guide 1-3

Introduction and Specifications Revised 2015-03-24

Model 1002MC Key Specifications

Table 2. 1002MC - Key Specifications

Table 3. Gigabit Fiber Transceiver SFP Characteristics

PHYSICAL ELECTRICAL

Height 4.0” (10.16 cm) Input Voltage 10-30 VDC (Regulated)

Width 1.0” (2.54 cm) Input Current 200mA max. @ 24VDC

(Steady State)

Depth w/ typical SFP installed 3.61” (9.165 cm) Inrush Current 13 Amp/0.8 ms max. @

24VDC

Weight 0.70 lbs (0.32 kg) Input Ripple Less than 100 mV

DIN Rail 35 mm Input Wire Size 12-24 AWG

ENVIRONMENTAL NETWORK MEDIA

Operating Temperature -40°C to 85°C 10BaseT  Cat-3

Storage Temperature -40°C to 85°C 100BaseT  Cat-5

Operating Humidity 10% to 90%

(Non Condensing)

1000BaseT  Cat-5e

Operating Altitude 0 to 10,000 ft. 1000BaseSX Multimode 50-62.5/125m

1000BaseLX Singlemode 7-10/125m

CONNECTOR RECOMMENDED MINIMUM WIRING CLEARANCE

10/100/1000BaseTX One (1) RJ45 TX Copper Port Top 1 " (2.54 cm)

1000Base-X SFP One (1) SFP LC Duplex

Gigabit Fiber Port

Front 4 " (10.16 cm)

NTSFP-SX NTSFP-LX-10 NTSFP-LX-40 NTSFP-LX-80

FIBER LENGTH

550m with 50/125m

275m @ 62.5/125m

10km 40km 80km

TX POWER MIN

-9.5dBm -9.5dBm -2dBm 0dBm

RX SENSITIVITY MAX

-17dBm -20dBm -22dBm -24dBm

WAVELENGTH

850nm 1310nm 1310nm 1550nm

ASSUMED FIBER LOSS

3.5 to 3.75 dB/km 0.45 dB/km 0.35 dB/km 0.25 dB/km

LASER TYPE

VCSEL FP DFB DFB

Buy: www.ValinOnline.com | Phone 844-385-3099 | Email: [email protected]

N-Tron 1000 Series Hardware Guide 1-4

Introduction and Specifications Revised 2015-03-24

Model 1002MC Regulatory Approvals

Safety

For use in Class I, Division 2, Groups A, B, C and D Hazardous Locations.

• UL 508, Industrial Control Equipment.

• ANSI/ISA-12.12.01-2007 for use in Class I and II, Division 2 and Class III Divisions 1 and 2 Hazardous

(Classified) Locations Groups A, B, C, D. T4A.

• cUL C22.2 No. 14-M05

• cUL C22.2 No. 213-M1987 for use in Class I, Division 2 Hazardous Locations.

EMI

•

EN61000-6-4, EN55011 - Class A

• FCC Title 47, Part 15, Subpart B - Class A

• ICES-003 – Class A

EMS

•

EN61000-6-2

• EN61000-4-2 (ESD)

• EN61000-4-3 (RS)

• EN61000-4-4 (EFT)

• EN61000-4-5 (Surge)

• EN61000-4-6 (Conducted Disturbances)

Warranty

3 years from the date of purchase.

Buy: www.ValinOnline.com | Phone 844-385-3099 | Email: [email protected]

N-Tron 1000 Series Hardware Guide 1-5

Introduction and Specifications Revised 2015-03-24

Model 1003GX2 - Key Specifications

Table 4. 1003GX2 Key Specifications

Table 5. Gigabit Fiber Transceiver (SFP) Characteristics

PHYSICAL ELECTRICAL

Height 4.0” (10.16 cm) Input Voltage 10-30 VDC (Regulated)

Width 1.0” (2.54 cm) Input Current 200mA max. @ 24VDC

(Steady State)

Depth w/ typical

SFP installed

3.61” (9.165 cm) Inrush Current 13 Amp/0.8 ms max. @

24VDC

Weight 0.7 lbs (0.32 kg) Input Ripple Less than 100 mV

DIN Rail 35 mm Input Wire Size 12-24 AWG

ENVIRONMENTAL NETWORK MEDIA

Operating Temperature -40°C to 85°C 10BaseT  Cat-3

Storage Temperature -40°C to 85°C 100BaseT  Cat-5

Operating Humidity 10% to 90%

(Non Condensing)

1000BaseT  Cat-5e

Operating Altitude 0 to 10,000 ft. 1000BaseSX Multimode 50-62.5/125m

1000BaseLX Singlemode 7-10/125m

CONNECTORS RECOMMENDED MINIMUM WIRING CLEARANCE

10/100/1000BaseTX One (1) RJ45 TX Copper Port Top 1 " (2.54 cm)

1000Base-X SFP Up to two (2) SFP LC Duplex

Gigabit Fiber Ports

Front 4 " (10.16 cm)

NTSFP-SX NTSFP-LX-10 NTSFP-LX-40 NTSFP-LX-80

FIBER LENGTH

550m with 50/125m

275m @ 62.5/125m

10km 40km 80km

TX POWER MIN

-9.5dBm -9.5dBm -2dBm 0dBm

RX SENSITIVITY MAX

-17dBm -20dBm -22dBm -24dBm

WAVELENGTH

850nm 1310nm 1310nm 1550nm

ASSUMED FIBER LOSS

3.5 to 3.75 dB/km 0.45 dB/km 0.35 dB/km 0.25 dB/km

LASER TYPE

VCSEL FP DFB DFB

Buy: www.ValinOnline.com | Phone 844-385-3099 | Email: [email protected]

N-Tron 1000 Series Hardware Guide 1-6

Introduction and Specifications Revised 2015-03-24

Model 1003GX2 Regulatory Approvals

Safety

For use in Class I, Division 2, Groups A, B, C and D Hazardous Locations.

• UL 508, Industrial Control Equipment.

• ANSI/ISA-12.12.01-2007 for use in Class I and II, Division 2 and Class III Divisions 1 and 2 Hazardous

(Classified) Locations Groups A, B, C, D. T4A.

• cUL C22.2 No. 14-M05

• cUL C22.2 No. 213-M1987 for use in Class I, Division 2 Hazardous Locations.

EMI

•

EN61000-6-4, EN55011 - Class A

• FCC Title 47, Part 15, Subpart B - Class A

• ICES-003 – Class A

EMS

•

EN61000-6-2

• EN61000-4-2 (ESD)

• EN61000-4-3 (RS)

• EN61000-4-4 (EFT)

• EN61000-4-5 (Surge)

• EN61000-4-6 (Conducted Disturbances)

Warranty

3 years from the date of purchase.

Buy: www.ValinOnline.com | Phone 844-385-3099 | Email: [email protected]

N-Tron 1000 Series Hardware Guide 1-7

Introduction and Specifications Revised 2015-03-24

Model 1005TX - Key Specifications

Table 6. 1005TX Key Specifications

Model 1005TX Regulatory Approvals

Safety

For use in Class I, Division 2, Groups A, B, C and D Hazardous Locations.

• UL 508, Industrial Control Equipment

• ANSI/ISA-12.12.01-2007 for use in Class I and II, Division 2 and Class III Divisions 1 and 2 Hazardous

(Classified) Locations Groups A, B, C, D. T4

• cUL C22.2 No. 14-M05

• cUL C22.2 No. 213-M1987 for use in Class I, Division 2 Hazardous Locations.

EMI

•

EN61000-6-4, EN55011 - Class A

• FCC Title 47, Part 15, Subpart B - Class A

• ICES-003 – Class A

PHYSICAL ELECTRICAL

Height 4.0” (10.16 cm) Input Voltage 10-30 VDC (Regulated)

Width 1.0” (2.54 cm) Input Current 230mA max. @ 24VDC

(Steady State)

Depth w/ typical

SFP installed

3.61” (9.165 cm) Inrush Current 13 Amp/0.61 ms max. @

24VDC

Weight 0.7 lbs (0.32 kg) Input Ripple Less than 100 mV

DIN Rail 35 mm Input Wire Size 12-24 AWG

ENVIRONMENTAL NETWORK MEDIA

Operating Temperature -40°C to 85°C 10BaseT  Cat-3

Storage Temperature -40°C to 85°C 100BaseT  Cat-5

Operating Humidity 10% to 90%

(Non Condensing)

1000BaseT  Cat-5e

Operating Altitude 0 to 10,000 ft.

CONNECTORS RECOMMENDED MINIMUM WIRING CLEARANCE

10/100/1000BaseTX Five (5) RJ45 TX Copper

Ports

Top 1 " (2.54 cm)

Front 2 " (5.08 cm)

Buy: www.ValinOnline.com | Phone 844-385-3099 | Email: [email protected]

N-Tron 1000 Series Hardware Guide 1-8

Introduction and Specifications Revised 2015-03-24

EMS

•

EN61000-6-2

• EN61000-4-2 (ESD)

• EN61000-4-3 (RS)

• EN61000-4-4 (EFT)

• EN61000-4-5 (Surge)

• EN61000-4-6 (Conducted Disturbances)

Warranty

3 years from the date of purchase.

Buy: www.ValinOnline.com | Phone 844-385-3099 | Email: [email protected]

N-Tron 1000 Series Hardware Guide 1-9

Introduction and Specifications Revised 2015-03-24

Model 1008TX - Key Specifications

Table 7. 1008TX Key Specifications

Model 1008TX Regulatory Approvals

Safety

For use in Class I, Division 2, Groups A, B, C and D Hazardous Locations.

• UL 508, Industrial Control Equipment.

• ANSI/ISA-12.12.01-2013 for use in Class I and II, Division 2 and Class III Divisions 1 and 2 Hazardous (Classi-

fied) Locations Groups A, B, C, D. T4.

• cUL C22.2 No. 14-M05

• cUL C22.2 No. 213-M1987 for use in Class I, Division 2 Hazardous Locations.

EMI

•

FCC Title 47, Part 15, Subpart B - Class A

• Industry Canada ICES-003 – Class A

• EN 55011 - Class A

• EN 61000-6-4

• EN 61000-3-2/3

PHYSICAL ELECTRICAL

Height 4.63” (11.76 cm) Input Voltage 10-49 VDC (Regulated)

Width 1.55” (3.94 cm) Input Current 290mA max. @ 24VDC

(Steady State)

Depth w/ typical

SFP installed

4.08” (10.37 cm) Inrush Current 20 Amp/0.06 ms max. @

24VDC

Weight 0.7 lbs (0.32 kg) Input Ripple Less than 100 mV

DIN Rail 35 mm Input Wire Size 12-24 AWG

ENVIRONMENTAL NETWORK MEDIA

Operating Temperature -40°C to 85°C 10BaseT  Cat-3

Storage Temperature -40°C to 85°C 100BaseT  Cat-5

Operating Humidity 10% to 90%(Non Condens-

ing)

1000BaseT  Cat-5e

Operating Altitude 0 to 10,000 ft.

CONNECTORS RECOMMENDED MINIMUM WIRING CLEARANCE

10/100/1000BaseTX Eight (8) RJ45 TX Copper

Ports

Top 1 " (2.54 cm)

Front 2 " (5.08 cm)

Buy: www.ValinOnline.com | Phone 844-385-3099 | Email: [email protected]

N-Tron 1000 Series Hardware Guide 1-10

Introduction and Specifications Revised 2015-03-24

EMS

•

EN 61000-6-2

• EN 61000-4-2/3/4/5/6/8/11

Warranty

3 years from the date of purchase.

Buy: www.ValinOnline.com | Phone 844-385-3099 | Email: [email protected]

La page charge ...

red lion N-Tron 1003GX2 Manuel utilisateur

Marque: red lion

Modèle: N-Tron 1003GX2

Catégorie: Commutateurs réseau

Taper: Manuel utilisateur

Ce manuel convient également à

Télécharger le PDF

rapport

dans d''autres langues

English: red lion N-Tron 1003GX2 User manual

red lion N-Tron 1003GX2 Manuel utilisateur

Ce manuel convient également à

red lion N-Tron 1003GX2 Manuel utilisateur

dans d''autres langues

Documents connexes

Autres documents