User's Information Manual 1264A
H2339500A
WARNING
If the information in this manual is not
followed exactly, a re or explosion may
result causing property damage, personal
injury or loss of life.
Do not store or use gasoline or other
ammable vapors and liquids in the vicinity
of this or any other appliance.
WHAT TO DO IF YOU SMELL GAS
• Do not try to light any appliance.
• Do not touch any electrical switch; do not
use any phone in your building.
• Immediately call your gas supplier from a
nearby phone. Follow the gas supplier's
instructions.
• If you cannot reach your gas supplier, call
the re department.
Installation and service must be performed
by a qualied installer, service agency, or gas
supplier.
FOR YOUR SAFETY: This product must be installed and serviced by a professional service technician,
qualied in boiler installation and maintenance. Improper installation and/or operation could create
carbon monoxide gas in ue gases which could cause serious injury, property damage, or death.
Improper installation and/or operation will void the warranty.
AVERTISSEMENT
Assurez-vous de bien suivres les instructions
données dans cette notice pour réduire au
minimum le risque d’incendie ou d’explosion
ou pour éviter tout dommage matériel, toute
blessure ou la mort.
Ne pas entreposer ni utiliser d’essence ni
d’autres vapeurs ou liquides inammables dans
le voisinage de cet appareil ou de tout autre
appareil.
QUE FAIRE SI VOUS SENTEZ UNE ODEUR DE GAZ:
• Ne pas tenter d’allumer d’appareils.
• Ne touchez à aucun interrupteur. Ne pas vous
servir des téléphones dansle bâtiment où vous
vous trouvez.
• Appelez immédiatement votre fournisseur de
gaz depuis un voisin. Suivez les instructions
du fournisseur.
• Si vous ne pouvez rejoindre le fournisseur de
gaz, appelez le sservice des incendies.
L’installation et l’entretien doivent être assurés par
un installateur ou un service d’entretien qualié ou
par le fournisseur de gaz.
User's Information
Manual
Hydronic Boiler
Model BMT2H
Water Heater
Model BMT2V
Sizes 200, 300, 400
Page 2
Bradford White Corp
TABLE OF CONTENTS
SECTION 1.
Caring For Your Brute Deluxe
1.1 General Care ......................................................3
1.2 Annual Inspection of Flues and Vents ................3
1.3 Shutting Down the Brute Deluxe ........................ 3
1.4 To Restart the Brute Deluxe ............................... 3
1.5 In the Event of Power Failure .............................3
1.6 Full Service Every 3 Years .................................. 3
Brute Deluxe Hydronic Boilers and Water Heaters. 200, 300, 400
Page 3
SECTION 1.
Caring For Your Brute Deluxe
Your Brute Deluxe will require very little
Maintenance. However, as with any ne appliance
there are certain steps that should be taken to ensure
continuing optimum performance.
1.1 General Care
Keep the area around the Brute Deluxe clean and
free from combustible materials, gasoline and other
ammable liquids and vapors.
The Brute Deluxe must be completely isolated
and protected from any source of corrosive chemical
fumes such as trichlorethylene, perchlorethylene,
chlorine, etc.
Keep grille openings on the boiler free for proper
ventilation of interior components.
Do not obstruct or block a free ow of air to the
boiler to ensure proper ventilation.
If desired, clean the jacket surfaces with a damp
cloth and mild detergent. Do not use ammable
cleaning materials.
If sidewall vented, keep the vent terminal clear
of obstructions — do not pile snow against the vent
terminal. Clean the air lter(s) often, and then develop
an appropriate maintenance schedule.
1.2 Annual Inspection of Flue and Vents
Visually inspect the vent pipe once a year. Should
any deterioration exist, have the aected parts replaced
by a qualied service person.
1.3 Shutting Down the Brute Deluxe
1. Switch o the main electrical disconnect switch.
2. Close all manual gas valves.
3. If freezing is anticipated, drain the Brute Deluxe
and be sure to also protect the building piping
from freezing. This step to be performed by a
qualied service person.
1.4 To Restart the Brute Deluxe
If drained, follow the Installation and
Operation Manual for proper lling and purging.
1. Switch o the main electrical disconnect switch.
2. Close all manual gas valves.
3. WAIT FIVE (5) MINUTES.
4. Set the aquastat or thermostat to its lowest
setting.
5. Open all manual gas valves.
6. Reset all safety switches (low water cut o,
manual reset high limit, etc.).
7. Set the temperature controller to the desired
temperature setting and switch on electrical
power.
8. Burner will go through a prepurge period and
ignitor warm-up period, followed by ignition.
1.5 In the Event of a Power Failure
The Brute Deluxe can not be operated during an
electrical power outage. If there is an extended power
outage with danger from freezing, then the Brute
Deluxe (and all other water systems) should be drained
completely. When draining the boiler, turn o main
electrical disconnect switch. When placing back in
service, refer to start-up instructions in the Installation
and Operation Manual for lling and purging.
Draining and lling shall only be done by a qualied
service person.
1.6 Full Service Every Three (3) Years
In addition to the annual visual inspections, a
qualied service agency should conduct a detailed
inspection of all ue product carrying areas of the
boiler and its venting system.
WARNING
Do not use this boiler if any part has been
under water. Immediately call a qualied
service technician to inspect the boiler and to
replace any part of the control system and any
gas control which has been under water.
WARNING
Should overheating occur or the gas supply
fail to shut o, do not turn o or disconnect the
electrical supply to the pump. Instead, shut
o the gas supply at a location external to the
boiler.
FOR SERVICE
Contact your installing contractor, gas utility,
Bradford White dealer, or call Bradford White
for the nearest authorized representative in
your area.
H2339500A
200 Lafayette St.
Middleville, MI 49333
Warranty: (800) 531-2111
www.BradfordWhite.com
Litho in U.S.A. © Bradford White 1809 Document 1264A
-
1
-
2
-
3
-
4
