Ryobi RYRM8034 Le manuel du propriétaire

OPERATOR’S MANUAL

MANUEL D’UTILISATION

MANUAL DEL OPERADOR

ELECTRIC ZERO TURN MOWER

TONDEUSE ÉLECTRIQUE

À BRAQUAGE ZÉRO

PODADORA ELÉCTRICA

DE GIRO CERO

RYRM8003/

RYRM8003CAN

WARNING: To reduce the

risk of injury, the user must read and

understand the operator’s manual

before using this product.

TABLE OF CONTENTS

Important Safety Instructions .......... 2-5

Symbols .......................................... 6-7

Safety Labels .................................. 8-9

Features ...................................... 10-12

Operation .................................... 13-22

Maintenance ............................... 22-29

Accessories ....................................... 29

Troubleshooting .......................... 30-31

Slope Guide ................................ 33-34

Parts Ordering/Service ........ Back Page

AVERTISSEMENT : Pour

réduire les risques de blessures,

l’utilisateur doit lire et veiller à bien

comprendre le manuel d’utilisation avant

d’employer ce produit.

TABLE DES MATIÈRES

Instructions importantes

concernant la sécurité..................... 2-5

Symboles ........................................ 6-7

Étiquettes de sécurité ..................... 8-9

Caractéristiques .......................... 10-12

Utilisation .................................... 13-22

Entretien ...................................... 22-30

Accessoires .......................................30

Dépannage .................................. 31-32

Guide de pente ........................... 33-34

Commande de pièces /

réparation .......................... Páge arrière

ADVERTENCIA: Para reducir

el riesgo de lesiones, el usuario debe leer

y comprender el manual del operador

antes de usar este producto.

ÍNDICE DE CONTENIDO

Instrucciones de seguridad

importantes ..................................... 2-5

Símbolos ......................................... 6-7

Etiquetas de seguridad ................... 8-9

Características ............................ 10-12

Funcionamiento .......................... 13-21

Mantenimiento ............................ 22-30

Accesorios ........................................30

Corrección de problemas ........... 31-32

Guía de pendientes ..................... 33-34

Pedidos de piezas/

servicio ...........................Pág. posterior

SAVE THIS MANUAL FOR

FUTURE REFERENCE

CONSERVER CE MANUEL

POUR FUTURE RÉFÉRENCE

GUARDE ESTE MANUAL

PARA FUTURAS CONSULTAS

Accessories

Accessoires

Accesorios

2 — English

DANGER:

READ ALL SAFETY WARNINGS, INSTRUCTIONS,

AND ASSEMBLY INSTRUCTIONS PROVIDED WITH

THIS PRODUCT. Use of a Zero Turn Mower requires an

understanding of how the mower and controls operate.

Failure to follow all warnings and instructions will result in

death, serious personal injury, electric shock, and/or ﬁre.

READ ALL INSTRUCTIONS

This cutting machine is capable of amputating hands and

feet and throwing objects. Failure to observe all safety

instructions could result in serious injury or death.

Avoid dangerous environment — Do not use the lawn

mower in damp or wet conditions or operate in the rain.

Keep children away — Keep all bystanders,

children, and pets at least 100 ft. away. Stop

the mower and turn off the machine if anyone

enters the area.

Tragic accidents can occur if the operator is

not alert to the presence of children. Children

are often attracted to the machine and the

mowing activity. NEVER assume that chil-

dren will remain where you last saw them.

• Keep children out of the mowing area and in the watch-

ful care of a responsible adult other than the operator.

• Be alert; stop and turn machine off if a child enters

the area.

• Before and while backing, maneuvering in reverse, or

turning around, look behind and down for small children,

bystanders, and pets.

• Never carry children, even with the blades

shut off. They may fall off and be seriously

injured or interfere with safe machine op-

eration. Children who have been given

rides in the past may suddenly appear in the mowing

area for another ride and be run over or backed over

by the machine.

• Never allow children to operate the machine.

WARNING:

CHILDREN CAN BE KILLED OR SERIOUSLY INJURED

BY THIS EQUIPMENT. The American Academy of Pedi-

atrics recommends that children be a minimum of 16

years of age before operating a riding lawn mower.

• Use extreme care when approaching blind corners,

shrubs, trees, or other objects that may block your

view of a child.

Wear heavy, long pants, long sleeves, gloves, and protec-

tive footwear that will protect your feet and improve your

footing on slippery surfaces. Do not wear loose-ﬁtting

clothing, short pants, sandals, or go barefoot. Do not wear

jewelry of any kind. They can be caught in moving parts.

Never leave a running machine unattended. Always turn

off blades, set parking brake, stop motor, and remove

key before dismounting.

Check brake operation before each use and frequently

during use. Adjust and service as required.

Keep hands and feet away from cutting area, which is lo-

cated under the mower deck and inside the side discharge

chute. Keep clear of the side discharge chute opening at

all times. Do not reach under the mower deck.

Operate the lawn mower only in daylight or good artiﬁcial

light.

Use safety glasses — Always wear eye protection with

side shields marked to comply with ANSI Z87.1. Use face

mask if operation is dusty.

Use the right appliance — Do not use the lawn mower for

any job except that for which it is intended.

Do not force the lawn mower — It will do the job better

and safer at the rate for which it was designed.

Do not charge lawn mower in rain, or in wet locations.

Stay alert — Watch what you are doing and use common

sense when operating the lawn mower. Do not operate

the mower while tired, upset, or under the inﬂuence of

drugs, alcohol, or medication. A moment of inattention

while operating the lawn mower may result in serious

personal injury.

Maintain lawn mower with care — Keep machine in good

working condition. Keep blades sharp and guards in place

and in working order. To prevent serious personal injury,

damage to the mower, and for best performance, replace

damaged or unevenly worn blades.

Always park on level ground.

Check all nuts, bolts, and screws before each use for

proper tightness to be sure the equipment is in safe work-

ing condition. Mower blades are sharp. Wrap the blades or

wear gloves, and use extra caution when servicing them.

Replace blade if it is bent, cracked, or damaged in any

way. An unbalanced blade causes vibration that could

IMPORTANT SAFETY INSTRUCTIONS

3 — English

IMPORTANT SAFETY INSTRUCTIONS

damage the motor drive unit or cause personal injury.

Sharpen a dull blade equally at each end to maintain the

balance. Clean the blade thoroughly and check its bal-

ance by supporting it horizontally on a thin nail through

its center hole. The nail should be in a horizontal posi-

tion. If either end of the blade rotates downward, remove

some metal from the heavy lower end until the blade is

balanced. It is balanced when neither end drops.

The side discharge chute is a spring-loaded guard that

covers the side discharge opening on the mower deck

and deﬂects grass clippings and debris away from the

operator. Always ensure that the motor is off and the

blades have stopped moving before inspecting, mov-

ing, cleaning, or performing maintenance on the side

discharge chute.

Always use safety protective devices. Do not operate

the mower without the side discharge chute in place and

working properly.

Never interfere with the intended function of a safety de-

vice or reduce the protection provided by a safety device.

Check their proper operation regularly.

Never tamper with safety devices. Check for proper

operation regularly.

Follow manufacturer’s instructions for proper operation

and installation of accessories. Only use accessories ap-

proved by the manufacturer. The use of other accessories

may increase the risk of injury.

Clear the work area before each use. Remove all objects

such as rocks, sticks, metal, wire, bones, toys, fallen tree

limbs, tree nuts, or other objects which can be thrown

by the blade.

Objects struck by the lawn mower blades can cause

severe injuries to persons. The lawn should always be

carefully examined and cleared of all objects prior to

each mowing.

If the lawn mower strikes a foreign object, follow these

steps:

• Stop the lawn mower, set the parking brake, wait until

the blades come to a complete stop, and then remove

start key.

• Thoroughly inspect the mower for any damage.

• Replace the blade if it is damaged in any way. Repair

any damage before restarting and continuing to operate

the mower.

Slopes are a major factor related to loss of control and

tip-over accidents, which can result in se-

vere injury or death. Operation on all slopes

requires extra caution. If you cannot back up

the slope or if you feel uneasy on it, do not

mow it. Do not reverse down a slope. Never

use on steep slopes greater than 15°.

• Never attempt to ride on a steep slope or mow a slope

that is greater than 15°. To determine the angle of your

slope, use the Slope Guide at the back of this manual.

For your safety, measure any slope before using the

machine on the sloped area. Use a slope measuring

device in addition to the slope gauge at the back of

this manual.

• Mow up and down slopes, not across.

• Watch for holes, ruts, bumps, rocks, or other hidden

objects. Uneven terrain could overturn the machine.

Tall grass can hide obstacles.

• Use a slow speed so you will not have to stop suddenly

or accidentally accelerate while on a slope. Rapid accel-

eration or braking could cause the front of the machine

to lift and roll over resulting in serious personal injury

or death. Avoid uphill starts.

• Do not mow on wet grass or unstable surfaces. Tires

may lose traction and you may lose control.

• Always keep the joystick in the forward position when

going down slopes. Do not move to neutral and coast

downhill, which may cause you to lose control of the

mower.

• Avoid starting, stopping, or turning on a slope. If the

tires lose traction, disengage the blades and proceed

slowly straight down the slope.

• Keep all movement on slopes slow and gradual. Do

not make sudden changes in speed or direction, which

could cause the machine to roll over.

• Use extra care while operating machine with baggers

or other attachments; they can affect the stability of the

machine. A heavy bagger could cause loss of control or

overturn the machine. Do not use machine with bagger

on slopes greater than 10°.

• Do not try to stabilize the machine by putting your foot

on the ground.

• Stay at least two mowing widths (7 feet) away from any

ditches, drop-offs, or water. Front caster wheels can

rotate when mower is stopped, even with the brake ap-

plied, and cause the mower to go over the edge or into

the water and result in death or serious personal injury.

Never direct discharged material toward anyone. Plan

your mowing pattern to avoid discharge of material to-

ward bystanders, roads, sidewalks, windows, cars, and

the like. Also, avoid discharging material against a wall

or obstruction, which may cause the material to ricochet

back toward the operator.

Stop the blade when crossing gravel surfaces to avoid

discharging gravel and rocks and drive the mower slowly

and carefully to avoid loss of control.

4 — English

IMPORTANT SAFETY INSTRUCTIONS

Use extra care when approaching blind corners, shrubs,

trees, or other objects that may block your view.

Never make any adjustments or repairs with the motor

running and/or blades moving. Turn off power switch

and remove key.

Stop the motor, set the parking brake, wait until the

blades come to a complete stop, and remove start key

before unclogging the side discharge chute or opening.

The cutting blades continue to rotate for a few seconds

after the motor is shut off. Never place any part of the

body in the blade area until you are sure the blades have

stopped rotating.

If the mower should start to vibrate abnormally, stop the

motor and check immediately for the cause. Replace the

blades if they are unevenly worn or damaged in any way.

Vibration is generally a sign of a damaged mower blade.

Disengage mower blades when not mowing.

Service on the product and charger must be performed

by qualiﬁed repair personnel only. Service or maintenance

performed by unqualiﬁed personnel could result in injury

to the user or damage to the product.

Use only authorized replacement parts when servicing

the product. Use identical replacement blades only. Use

of unauthorized parts may create a risk of serious injury

to the user or damage to the product.

Maintain or replace safety instructions labels, as neces-

sary.

Remove start key — Remove start key from the mower

before storing, servicing, or changing accessories such

as blades. Such preventive safety measures reduce the

risk of starting the mower accidentally.

Stop the unit and remove the start key when not in use.

Transport the unit with the motor stopped and the start

key removed from the mower.

Battery tools do not have to be plugged into an electrical

outlet; therefore, they are always in operating condition.

Be aware of possible hazards when not using your bat-

tery tool or when changing accessories. Following this

rule will reduce the risk of electric shock, ﬁre, or serious

personal injury.

Do not use battery-operated mower in rain.

Remove the start key before servicing, cleaning, or

removing material from the gardening appliance.

Store idle lawn mower indoors — When not in use,

mower should be stored indoors in a dry, locked place

out of the reach of children. The start key should also

be removed and stored in a separate location out of the

reach of children.

Follow instructions for changing accessories.

Only allow responsible adults, who are trained, familiar

with and understand the instructions, and are physically

capable to operate this machine.

Never carry passengers.

Never operate machine in a closed area.

Do not mow in reverse unless absolutely necessary.

Always look down and behind before and while backing.

Slow down before turning.

Watch for traffic when operating near or crossing

roadways.

Mowers with rear-wheel drive require more traction than

front-wheel-drive mowers. Use extreme caution when

mowing on slopes or when crossing wet surfaces to

prevent possible tipover.

While mowing, keep a distance of at least 7 feet from

drop-offs, embankments, water, and marsh-like surfaces.

Use extra care when loading or unloading the machine

into a trailer; press the low speed drive button and care-

fully move the joystick as needed to control the speed.

Always back onto the trailer when loading. When loading

or unloading the mower, do not exceed the maximum

recommended operation angle of 15°.

Use full width ramps for loading and unloading a machine

for transport.

Data indicates operators age 60 years and above are

involved in a large percentage of riding mower related

injuries. These operators should evaluate their ability to

operate the riding mower safely enough to protect them-

selves and others from serious injury.

Keep machine free of grass, leaves, or other debris build

up. Allow machine to cool before storing.

Never use a hose, water, or any liquids to clean or rinse

off the lawn mower. Corrosive liquids, water, fertilizers,

and chemicals used to treat lawns can enter the lawn

mower and/or battery compartment and damage elec-

tronic components and/or the battery pack, which can

result in a short circuit, increased risk of ﬁre, and serious

personal injury. Remove any buildup of grass and leaves

on or around the mower housing and/or underneath the

mower deck. An exception to clean the underside of the

mower deck may be made when using a Ryobi acces-

sory designed for this purpose, in accordance with the

accessory instructions. Wipe the mower clean with a dry

cloth occasionally.

Stop the motor, wait until blades come to a complete

stop, and remove the start key before cleaning the lawn

mower or removing the mulch cover.

5 — English

IMPORTANT SAFETY INSTRUCTIONS

ADDITIONAL SAFETY RULES FOR

BATTERIES

Do not use a BATTERY pack or tool that is damaged

or modiﬁed. Damaged or modiﬁed batteries may exhibit

unpredictable behaviour resulting in ﬁre, EXPLOSION or

risk of injury.

Do not dispose of the batteries in a ﬁre. The batteries

could explode. Check with local codes for possible spe-

cial disposal instructions.

Keep all metal objects like paper clips, coins, keys, nails,

screws, or other small metal objects away from the battery

and battery terminals that can make a connection from

one terminal to another. Shorting the battery terminals

together may cause serious burns or a ﬁre.

Exercise care in handling batteries in order not to short the

battery with conducting materials such as rings, brace-

lets, and keys. The battery or conductor may overheat

and cause burns.

Under abusive conditions, liquid may be ejected from

the battery; avoid contact. If contact accidentally occurs,

ﬂush with water. If liquid contacts eyes, additionally seek

medical help. Liquid ejected from the battery may cause

irritation or burns.

Do not charge battery in an area of extreme heat or cold.

Batteries will charge best at temperatures from 50˚F to

100˚F.

Follow all charging instructions and do not charge the

battery pack or appliance outside of the temperature

range speciﬁed in the instructions. Charging improperly

or at temperatures outside of the speciﬁed range may

damage the battery and increase the risk of ﬁre.

Do not modify or attempt to repair the appliance or the

battery pack (as applicable) except as indicated in the

instructions for use and care.

Do not expose the battery pack or appliance to ﬁre or

excessive temperature. Exposure to ﬁre or temperature

above 265°F may cause explosion.

Do not store lawn mower in locations where the tempera-

ture is less than -22F or more than 120F. If the lawn mower

is stored at temperatures below 50F or above 100F, re-

move the batteries and store separately according to the

temperature range recommended in the battery manual.

Do not store mower or batteries outside or in vehicles.

Do not use lawn mower in locations where the tempera-

ture is less than 15F or more than 104F.

Only use RYOBI Electric Riding Lawn Mower 80 volt and

40V lithium batteries.

Use this product only with batteries and chargers listed in

tool/appliance/battery pack/charger correlation supple-

ments 998000922 for 80V and 988000-842 for 40V.

Recharge only with the charger speciﬁed by the manu-

facturer. A charger that is suitable for one type of battery

pack may create a risk of ﬁre when used with another

battery pack.

ADDITIONAL SAFETY RULES FOR TOWING

Do not tow a load that exceeds ½ the mower weight + ½

the operator weight. Never exceed 50 lbs (22 kg) tongue

weight.

Use common sense when towing. Too heavy of a load

while on a slope is dangerous. Tires can lose traction with

the ground and cause you to lose control of your mower.

When towing, never use on steep slopes greater than 5°.

Follow manufacturer’s recommendations for wheel

weights or counterweights.

Do not put the mower into neutral when on a decline. Try

not to coast when towing.

Only use hitches that are approved for use with your

speciﬁc mower. Do not attach towed equipment except

at the approved hitch point.

Never allow children or others in or on towed equipment.

Stopping distance increases with speed and weight of

load being towed. Travel slowly and allow plenty of time

and distance to stop.

Do not turn sharply when towing. Make wide turns to

avoid jack-kniﬁng. Use additional caution when turning

or operating under adverse surface conditions. Use care

when reversing.

Do not attempt to pull or dislodge stationary objects with

the tow hitch. The machine may pivot about the rear drive

wheels and lift upwards, resulting in serious personal

injury or death.

Do not use a chain, cable, or rope to pull accessories not

intended for towing. Only tow accessories that include

a tow attachment.

Use low speed when towing.

6 — English

Some of the following symbols may be used on this product. Please study them and learn their meaning. Proper inter-

pretation of these symbols will allow you to operate the product better and safer.

SYMBOL NAME DESIGNATION/EXPLANATION

Safety Alert Indicates a potential personal injury hazard.

Read Operator’s

Manual

To reduce the risk of injury, user must read and understand operator’s

manual before using this product.

Eye Protection Always wear eye protection with side shields marked to comply with

ANSI Z87.1.

Keep Children Away Keep children out of the mowing area and in the watchful care of a

responsible adult other than the operator.

Wet Conditions Alert

Risk of ﬁre and burns. Do not expose battery, battery compartment, or

electronic components to rain, water, or liquids. Do not charge battery or

expose mower to rain or damp locations. Do not operate on wet ground.

Electric Shock Failure to use in dry conditions and to observe safe practices can result

in electric shock.

Electricity This product is considered to have hazardous voltage.

The following signal words and meanings are intended to explain the levels of risk associated with this product.

SYMBOL SIGNAL MEANING

DANGER: Indicates a hazardous situation, which, if not avoided, will result in death or

serious injury.

WARNING: Indicates a hazardous situation, which, if not avoided, could result in death or

serious injury.

CAUTION: Indicates a hazardous situation, that, if not avoided, may result in minor or

moderate injury.

NOTICE: (Without Safety Alert Symbol) Indicates information considered important, but

not related to a potential injury (e.g. messages relating to property damage).

SYMBOLS

7 — English

SYMBOLS

Some of the following symbols may be used on this product. Please study them and learn their meaning. Proper inter-

pretation of these symbols will allow you to operate the product better and safer.

SYMBOL NAME DESIGNATION/EXPLANATION

Keep Hands and Feet

Away Keep hands and feet away from blade and cutting area.

No Reach Do not reach hands or feet under mower deck.

No Slope Do not operate on steep slopes or inclines greater than 15º. Mow up

and down the face of slopes, never across.

Keep Children and

Bystanders Away Keep all children, bystanders, and animals at least 100 ft. away.

Ricochet Thrown objects can ricochet and result in personal injury or property

damage.

Thrown Objects Thrown objects can ricochet and result in personal injury or property

damage. Never direct discharged material toward anyone.

No Passengers Never carry children or anyone, even when the blades are off.

Back With Caution

Always look down and behind you before and when maneuvering in

reverse or turning around. Make sure children, bystanders, and pets

are clear of the area.

Keep Away from

Ditches, Drop-offs,

andWater

Stay at least two mowing widths (7 feet) away from any ditches, drop-

offs, or water. Front caster wheels can rotate when mower is stopped,

even with brake applied, and cause mower to go over the edge or into

the water.

Recycle Symbol

This product uses lithium-ion (Li-ion) batteries. Local, state, or federal

laws may prohibit disposal of batteries in ordinary trash. Consult your

local waste authority for information regarding available recycling and/

or disposal options.

Direct Current Type or a characteristic of current

V Volts Voltage

A Amperes Current

Hz Hertz Frequency (cycles per second)

W Watt Power

hrs Hours Time

8 — English

SAFETY LABELS

The following labels are found on the product. For your safety, please review and understand all of the labels before start-

ing the product. If any of the labels come off the unit or become hard to read, contact an authorized service center for

replacement.

4

12

3

5

2

1

6

4

9 — English

SAFETY LABELS

6

NOTE: Your mower labels may feature additional translations,

or separate translated versions of the labels may be included.

Translated labels can be installed over the labels currently on the

mower. For best adhesion, always clean and dry mounting surface

before installing.

5

10 — English

PRODUCT SPECIFICATIONS

Motor .................................................................. 80 Volt DC

Height Adjustments ............................. 1-1/2 in. to 4-1/2 in.

Wheel Size ........................................13 in. front, 18 in. rear

Deck Size ................................................................... 54 in.

Turning Radius .............................................................. 0 in.

FEATURES

Max. Speed: High Speed Drive ...............................8 MPH

Medium Speed Drive .........................6 MPH

Low Speed Drive ................................4 MPH

Reverse ..............................................4 MPH

Cold Tire Pressure ...................... 15 PSI Front, 18 PSI Rear

Charger Input.....................................120 V, AC only, 60 Hz

Charge Rate ..................................................................14A

Fig. 1

CHARGER

DECK HEIGHT

ADJUSTMENT

LEVER SEAT

ADJUSTMENT

BAR

SEAT

SUSPENSION

KNOB

STORAGE

HEADLIGHTS

SIDE

DISCHARGE

CHUTE

STORAGE

JOYSTICK

START

KEY

AUTO

STOP PLUG

USB

PORT

FRONT

CASTER WHEELS

BLADE

ENGAGE

KNOB

11 — English

FEATURES

Fig. 2

40V BATTERY

PORTS

40V BATTERY

PORT

80V BATTERY

PORTS

APPROVED

HITCH POINT

DRIVE

SPEED MENU

HEADLIGHTS BLUETOOTH

SETTINGS

LCD CONTROL

SCREEN

BLADE SPEED

CHARGING

PORT

BRAKE

PEDAL

JOYSTICK

PARKING

BRAKE

CUP HOLDERS

STORAGE

USB PORT

80V BATTERY COVER

40V BATTERY COVERS

12 — English

KNOW YOUR LAWN MOWER

See Figures 1 and 2.

The safe use of this product requires an understanding of

the information on the product and in this operator’s manual

as well as a knowledge of the project you are attempting.

Before use of this product, familiarize yourself with all op-

erating features and safety rules.

ADJUSTABLE ARM RESTS

Two arm rests provide support for your arms and added

comfort while you are mowing.

AUTO STOP PLUG

The auto stop plug can be used to maintain your preferred

deck height cutting position or as a deck lift lockout when

removing the cutting deck. See the Maintenance section for

more information on removing the cutting deck.

BATTERY COVER

The battery cover protects the battery port from moisture

and debris.

BLADE ENGAGE KNOB

Pull the blade engage knob up to activate the mower’s cut-

ting blades. Push the knob down to stop the cutting blades.

BLADE SPEED BUTTON

Press the blade speed button to increase or decrease the

speed of the blades.

BRAKE PEDAL

The brake pedal is used for stopping the mower in an emer-

gency situation or when parking.

CHARGER

The mower’s charger has a key hole hanging feature for

convenient, space saving storage. When hanging by the

keyhole slots, use at least one additional screw in the hole

in the mounting ﬂange to secure in place. Always mount

in such a way that the charger’s LED status light is visible

while charging.

DECK HEIGHT ADJUSTMENT LEVER

The deck height adjustment lever is used to raise or lower

the cutting deck. Set the auto stop plug at your normally

desired cutting height for ease of use when mowing.

DRIVE SPEED BUTTON

Press the drive speed button to limit the speed of the mower

when you’re operating in tight spaces or on slopes. This

setting is also useful for inexperienced users when they are

ﬁrst learning to operate the mower.

HEADLIGHT BUTTON

Turn the headlights on and off using the headlight button.

iDRIVE JOYSTICK

The iDrive joystick easily allows the user to operate the

mower with only one hand. The software is designed to cor-

rect gradual wheel turns to help eliminate divots in the lawn.

LCD SCREEN

The LCD screen monitors and activates many of the features

on the mower.

PARKING BRAKE

Use the parking brake to lock the mower in the braked position.

POWER SWITCH WITH START KEY

The power switch is used to turn the mower on and off. The

start key must be inserted before the switch can be oper-

ated. When the key is in the ON position, the power switch is

also used to power optional manufacturer-approved mower

accessories.

SEAT ADJUSTMENT LEVER

Use the seat adjustment lever to move the seat to the desired

position.

STORAGE COMPARTMENTS

Two storage areas with USB ports offer a convenient place

to store your cell phone or MP3 player.

USB PORT

The two USB charging ports provide charging power of

5volts DC at up to 2 amps for your cell phone, MP3 player,

or other USB devices. Consult the owner’s manual for your

device for speciﬁc charging requirements.

Connect one end of a USB cable (not provided) to your

device and the other end to the USB charging port on the

mower, to begin charging your device.

NOTICE:

Attempting to charge devices rated more than 2 amps

could damage the USB charging port and/or the mower.

Always close the USB cover when not in use to prevent

debris from becoming trapped in port.

NOTE: The USB port is only powered when the start key is

in the ON position.

WARNING:

Never use headphones or any electronic device, such

as a smart phone or tablet, while operating the mower.

Distracted operation can result in an accident that could

result in death or serious personal injury to the operator

or a bystander.

FEATURES

13 — English

WARNING:

Do not allow familiarity with products to make you care-

less. Remember that a careless fraction of a second is

sufﬁcient to inﬂict serious injury.

WARNING:

Always wear eye protection with side shields marked to

comply with ANSI Z87.1. Failure to do so could result in

objects being thrown into your eyes resulting in possible

serious injury.

WARNING:

Always turn off mower, make sure blades have stopped

moving, and remove the start key from the mower when

you are assembling parts, making adjustments, cleaning,

or when not in use. This will prevent accidental starting

that could cause serious personal injury.

WARNING:

Always inspect mower for missing or damaged parts and

blades for damage or uneven or excessive wear prior to

use. Use of the mower with damaged or missing parts

can result in serious personal injury.

NOTICE:

Before each use, inspect the entire product for damaged,

missing, or loose parts such as screws, nuts, bolts, caps,

etc. Tighten securely all fasteners and caps and do not

operate this product until all missing or damaged parts

are replaced. Please contact customer service or an

authorized service center for assistance.

APPLICATIONS

You may use this product for the purpose listed below:

Mowing your lawn

OPERATION

SETTING THE PARKING BRAKE

See Figure 3.

To set the parking brake:

Place the joystick in the neutral and locked position.

(See Learning to Drive the Mower later in the Opera-

tion section.)

Fully depress and hold the brake pedal.

Press your foot forward and fully depress the parking

brake with your toes.

Release the brake pedal.

To release the parking brake: depress and release the

brake pedal.

WARNING:

Never leave the mower unattended when the motor is

running or with the key in the power switch. Verify that

the parking brake is set and the key has been removed.

Failure to set the parking brake could cause the mower

to move, and leaving the key could allow unauthorized

use that could result in serious personal injury.

BRAKE

PEDAL

Fig. 3

PARKING

BRAKE

14 — English

OPERATION

ADJUSTING THE SEAT

See Figure 4.

Adjust the seat position forward or backward to ensure you

are able to make ﬁrm contact with the brake pedal before

operating the mower. The seat suspension knob allows the

adjustment of a softer or ﬁrmer ride.

To move the seat forward or backward:

Turn the key to the OFF position and set the parking brake.

Sit down on seat and lift the seat adjustment bar.

While lifting up the bar, slide the seat to the desired

position.

Release the bar and make sure the seat is locked in posi-

tion before operating the mower.

To adjust the seat suspension:

Turn the key to the OFF position and set the parking brake.

Sit down on seat and while holding the suspension knob,

rotate it to adjust the seat for a softer to ﬁrmer setting.

WARNING:

Be sure the seat is locked into place before operating the

mower. A seat that is not secure can cause the operator

to shift and lose control of the mower and result in pos-

sible death or serious personal injury.

ADJUSTING THE ARMREST

See Figure 5.

Both armrests adjust up and down for the most comfort-

able operating height. The left armrest adjusts forward and

backward.

To move the armrests up and down:

Turn the key to the OFF position and set the parking brake.

Remove the two bolts as shown.

Raise or lower the armrest to the desired height making

sure both bolt holes are still in alignment with the holes

in the seat frame.

Reinstall bolts and tighten securely.

To move the left armrest forward or backward:

Turn the key to the OFF position and set the parking brake.

Loosen the knob and adjust the armrest to the desired

position.

Tighten the knob ﬁrmly to secure the armrest in place.

WARNING:

Be sure the armrests are locked into place before operat-

ing the mower. An armrest that is not secure can cause

the operator to shift and lose control of the mower and

result in possible death or serious personal injury.

Fig. 4

SEAT ADJUSTMENT BAR

SEAT SUSPENSION KNOB

tooltip

Fig. 5

KNOB

ARMREST

SEAT

BOLT

SEAT

FRAME

15 — English

OPERATION

SETTING THE CUTTING DECK HEIGHT

See Figure 6.

Before using the mower, raise the deck height to the cutting

position best suited for your lawn.

NOTE: To prevent scalping the lawn when encountering

high spots, the cutting deck wheels should be positioned

approximately 1/2 in. off the ground when the mower is at

the desired cutting height. When shipped, the cutting deck

wheels are set to the 1.5 in. position. Depending on your de-

sired cutting height, you may need to change the position of

the cutting deck wheels. To do so, refer to Adjusting Cutting

Deck Wheels in the Maintenance section of this manual.

To adjust the cutting deck height:

Stop the mower and disengage blades.

Turn key to OFF position and set the parking brake.

To raise the cutting deck, grasp the deck height adjust-

ment lever, push left to disengage from slot, move toward

the back of the mower, then push right into slot to secure.

To lower the cutting deck, grasp the deck height adjust-

ment lever, push left to disengage from slot, move toward

the front of the mower, then push right into slot to secure.

CAUTION:

Hold the deck height adjustment lever ﬁrmly when setting

the deck height and only release when it is secure in the

desired slot. Quickly letting go of the lever may create a

pinching or pulling hazard to the operator’s hand.

NOTE: Once you have determined the correct cutting height

for your lawn, install the auto stop plug just below that posi-

tion to easily return to the correct mowing height every time.

CHARGING THE MOWER

See Figure 7.

WARNING:

Only charge mower batteries indoors in a dry location. Do

not charge battery or expose mower to rain or damp loca-

tions. Water and liquids can come in contact with mower

components and the battery and damage connections

and electronic components, which can result in a short

circuit, increased risk of ﬁre, and serious personal injury.

DECK HEIGHT

ADJUSTMENT LEVER

Mower batteries must be fully charged before ﬁrst use. To

verify mower batteries are fully charged, check the battery

level indicator on the LCD screen.

For best results:

Do not charge in an area of extreme heat or cold.

Never charge a frozen battery.

Mount or place the charger in an area with adequate

ventilation, ideally with the charger in a horizontal position

with the cooling ﬁns facing up.

Fig. 6

AUTO STOP

PLUG

CHARGER

PLUG

CHARGING

PORT

Fig. 7

16 — English

OPERATION

To charge:

Make sure both the charger and mower connections are

clean and free of dirt or debris.

Insert charger plug into charging port on mower, making

sure it is properly connected.

Connect charger to power supply using normal household

current of 120 V, AC only, 60 Hz. The batteries should

automatically begin to charge.

NOTE: The charger is equipped with a plug featuring a

grounding pin and must be plugged into a matching stan-

dard three-prong outlet that has been properly installed

and grounded in accordance with all local codes and

ordinances. Do not use a two-prong outlet, adaptors, or

modify the plug provided. If it will not ﬁt the outlet, have

the proper outlet installed by a qualiﬁed electrician.

When powered and connected to the mower, the LED

indicator on the charger will illuminate to indicate the

charger’s status. Refer to the operator’s manual for the

charger to determine the meaning of the LED’s display.

When you are ready to mow, disconnect the charger from

the power supply, then disconnect the charger from the

mower.

NOTICE:

Always turn power switch to off position and remove key

when charging mower and when mower is not in use.

NOTICE:

Always connect the mower to the charger when the unit

is not in use. If it is not possible to leave the mower char-

ger connected, make sure to charge the batteries fully at

least once a month.

Fig. 8

SAFETY INTERLOCK SYSTEM

See Figure 8.

This mower features a Safety Interlock System to protect the

operator by shutting off the blades if the operator leaves the

seat with the blades running. Test the system before each

use to be sure it is working correctly.

To test:

Position the mower on a level surface.

Set the parking brake.

Make sure joystick is in the neutral position and the blade

engage knob is down.

Install start key and turn to ON position.

Raise blade engage knob to activate blades.

Brieﬂy lift off the seat, but do not get off the mower.

The blades should shut off within 5 seconds. If they don’t,

contact customer service. Do not operate the mower until

the safety interlock system has been repaired.

17 — English

OPERATION

LEARNING TO DRIVE THE MOWER

See Figures 9 - 12.

Operating a zero turn mower is different than operating a

standard riding mower. Zero turn mowers are rear-wheel

drive and the wheels operate independently based on the

position of the joystick. Before you begin to mow your grass,

we strongly encourage you to ﬁnd a large, level, and open

area to practice operating the mower using the instructions

that follow. Once you can comfortably and reliably perform

each of these maneuvers, you are ready to begin mowing.

WARNING:

Clear the area of bystanders before operating the mower.

If anyone enters the practice area, stop immediately and

do not continue practicing until the bystanders leave the

area.

WARNING:

Avoid sudden starts, stops, and turns, as well as exces-

sive speed, especially when ﬁrst learning to operate the

mower. The mower can spin rapidly, which may cause

you to lose control and could result in death, serious per-

sonal injury and/or damage to the mower. Engage the low

speed drive function to limit the amount of speed avail-

able until you are fully capable of operating the mower

in all situations.

The joystick is used to control the mower’s direction, as well

as starting and stopping.

WARNING:

Keep your hand on the joystick at all times when the

mower is in motion. Do not release the joystick to slow or

stop the mower. Releasing the joystick while the mower is

in motion could lead to loss of control and result in death,

serious personal injury, and/or damage to the mower.

When entering and exiting the mower seat, the joystick

should always be in the neutral position (centered and

pushed down into the locked position).

Once you are seated and ready to begin, press and

release the brake pedal to make sure the parking brake

is released.

Be sure the joystick is the neutral position. The center

position is used also to bring the mower to a gradual stop.

Insert the start key and turn to the ON position.

Select the desired drive speed (high, medium, or low)

from the LCD screen.

Fig. 9

FORWARD

LEFT RIGHT

REVERSE

NEUTRAL

Fig. 10

ENGAGED DISENGAGED

NEUTRAL

18 — English

FORWARD

LEFT TURN

FORWARD

RIGHT TURN

OPERATION

Lift the joystick to release it from the locked, neutral posi-

tion. Push the joystick forward (from neutral) to drive the

mower forward in a straight line. The farther forward the

joystick is pushed, the faster the mower will go. To slow

down, pull joystick back toward the neutral position.

To stop, move the joystick back into the center, neutral

position.

Pull the joystick backward (from neutral) to drive the

mower in reverse in a straight line. The farther back the

joystick is pulled, the faster the mower will go. To slow

down, push the joystick back toward the neutral position.

To stop, move the joystick back into the center, neutral

position.

To make turns, push the joystick in the desired turn direc-

tion. When driving forward or reverse, the angle of the

joystick will control the direction of the turn.

To make a zero turn, slow down, but make sure the rear

wheels are still in motion. Then move the joystick directly

to the right or left of neutral. This determines the direction

of the of the rotation of the turn.

NOTE: Perform zero turns at a slow speed to help prevent

damage to your lawn.

REVERSE

RIGHT TURN

REVERSE

LEFT TURN

ZERO TURN

LEFT

ZERO TURN

RIGHT

Fig. 11

Fig. 12

19 — English

OPERATION

OPERATING THE MOWER

See Figures 13 - 14.

WARNING:

Clear the area of bystanders before operating the mower.

If anyone enters the mowing area, stop immediately and

do not return to mowing until the bystanders leave the

area.

Before starting the mower:

Ensure work area is clear of children, bystanders, and

pets.

Clear the work area of objects that may be thrown by the

mower blades.

Check brake operation.

Check tire pressure.

Check for loose fasteners.

Check to make sure all guards are in place and working

properly.

Clean debris from mower.

Test safety interlock system.

Adjust seat to desired position.

Verify battery charge level.

NOTICE:

When the level of battery charge reaches the red zone on

the battery charge indicator, the blades will automatically

shut off. Return immediately to recharge. Continuing to

mow when the battery charge level is in the red zone

can cause the mower to become stranded away from

the charging area.

NOTE: If the mower becomes stranded away from the

charger, it will be necessary to place the joystick in neutral

and push the mower back to the charging location.

Mowing:

Raise the mower deck to its highest position.

Make sure the joystick is in the neutral position.

Insert start key and turn to ON position.

Release the parking brake.

Engage joystick, then drive to desired mowing location.

Stop the mower, turn key to OFF position, and set the

parking brake.

Lower the cutting deck to desired position.

Turn start key to ON position and release parking brake.

Raise blade engage knob to activate blades and mow

as desired.

Fig. 13

FORWARD MOWING

Fig. 14

REVERSE MANEUVERING

DANGER:

Stay at least two mowing widths (7 feet) away from any

ditches, drop-offs, or water. Front caster wheels can

rotate when mower is stopped, even with the brake

applied, and cause the mower to go over the edge or into

the water and result in death or serious personal injury.

20 — English

OPERATION

WARNING:

Use caution when crossing over gravel paths or drive-

ways. Before crossing, disengage the blades and raise

the cutting deck to the highest position to minimize the

possibility of ricochet. Drive slowly to avoid loss of trac-

tion and control.

WARNING:

Do not mow in reverse unless absolutely necessary.

Always look down and behind before and while backing to

make sure no children, bystanders, or pets enter the mow-

ing area. Remember that a careless fraction of a second is

sufﬁcient to inﬂict death or serious injury.

WARNING:

Do not attempt to change direction suddenly between

forward and reverse while the mower is in motion. Always

come to a complete stop before changing the mower

direction to avoid loss of control and prevent death or

serious personal injury.

When mowing is complete:

Stop mower on a ﬂat, level surface by placing the joystick

in the neutral position. Do not stop the mower on a slope.

Push the blade engage knob down to turn blades off.

Place the joystick in the neutral position.

Set the parking brake.

Turn the start key OFF.

Remove the start key if leaving the mower unattended,

even if just for a brief period.

WARNING:

If the mower emits a beeping noise after you leave the

seat, verify that the parking brake is set and the key has

been removed. Failure to set the parking brake could

cause the mower to move, and leaving the key could

allow unauthorized use that could result in serious per-

sonal injury.

MOWING TIPS

See Figure 15.

Keep mower blades sharp.

Make sure the lawn is clear of stones, sticks, wires, toys,

tree nuts, tree branches, and other objects that could

damage the lawn mower blades or motor. Do not mow

over property stakes or other metal posts. Such objects

could damage the blade or be accidentally thrown by the

mower in any direction and cause serious personal injury

to the operator and others.

For a healthy lawn, always cut off one-third or less of the

total length of the grass.

When mowing large areas, start by turning to the right so

that clippings will discharge away from shrubs, fences,

driveways, etc. After one or two rounds, mow back and

forth across the lawn, turning around in the edges of

already mowed grass.

NOTICE:

To prevent damage to your lawn, use a slow speed while

turning rather than spinning in a tight circle.

When cutting heavy grass, reduce speed to allow for more

effective cutting and a proper discharge of the clippings.

New or thick grass may require a narrower cut or a higher

cutting height.

Keep the mower deck and side discharge chute clean.

Remove grass clippings, leaves, dirt, and any other ac-

cumulated debris before and after each use. Do not spray

with a garden hose to clean.

NOTE: Always stop mower, allow blades to completely

stop, and remove the start key before cleaning under-

neath the mower.

Fig. 15

La page charge ...

Ryobi RYRM8034 Le manuel du propriétaire

Ryobi RYRM8034 Le manuel du propriétaire

dans d''autres langues

Documents connexes

Autres documents