Ducane 30400043 Le manuel du propriétaire

Marque: Ducane

Modèle: 30400043

Catégorie: Barbecues

Taper: Le manuel du propriétaire

Ce manuel convient également à

ASSEMBLY, ENSAMBLAJE, ASSEMBLAGE - PG 3

Customer Service: 1-800-382-2637

#20529917

 DANGER

If you smell gas:

1. Shut off gas to the appliance.

2. Extinguish any open ﬂ ames.

3. Open lid.

4. If odor continues, keep away from the

appliance and immediately call your gas

supplier or your ﬁ re department.

Leaking gas may cause a ﬁ re or explosion

which can cause serious bodily injury or

death, or damage to property.

 WARNING

1. Do not store or use gasoline or other

ﬂ ammable liquids or vapors in the

vicinity of this or any other appliance .

2. An LP cylinder not connected for use

shall not be stored in the vicinity of this

or any other appliance.

 WARNING: Follow all leak-check

procedures carefully in this manual prior

to barbecue operation. Do this even if the

barbecue was dealer-assembled.

NOTICE TO INSTALLER: These instructions

must be left with the owner and the owner

should keep them for future use.

THIS GAS APPLIANCE IS DESIGNED FOR

OUTDOOR USE ONLY.

 WARNING: Do not try to light this

appliance without reading the “Lighting

Instructions” section of this manual.

YOU MUST READ THIS OWNERS GUIDE

BEFORE OPERATING YOUR GAS GRILL

205299917_US 02/01/06 NG

US ENGLISH

FOR HOUSEHOLD USE ONLY

SAVE THESE INSTRUCTIONS FOR

FUTURE REFERENCE

NATURAL GAS GRILL OWNER'S MANUAL

GUÍA DEL PROPIETARIO DE LA PARRILLA DE GAS NATURAL - PG 23

GUIDE DE L’UTILISATEUR DU BARBECUE AU GAZ NATUREL

PG 39

2 www.ducane.com

DANGERS AND WARNINGS

 DANGER

Failure to follow the Dangers, Warnings and Cautions contained in this Owner’s Manual may result in serious bodily injury or

death, or in a ﬁ re or an explosion causing damage to property.

 WARNING

 Do not store a spare or disconnected liquid propane cylinder under or near this barbecue.

 Improper assembly may be dangerous. Please carefully follow the assembly instructions in this manual

 After a period of storage, and/or non-use, the Ducane

gas barbecue should be checked for gas leaks and burner obstructions

before use. See instructions in this manual for correct procedures.

 Do not operate the Ducane

gas barbecue if there is a gas leak present.

 Do not use a ﬂ ame to check for gas leaks.

 Combustible materials should never be within 24 inches of the top, bottom, back or sides of your Ducane

gas barbecue.

 Do not put a barbecue cover or anything ﬂ ammable on, or in the storage area under the barbecue.

 Your Ducane

gas barbecue should never be used by children. Accessible parts of the barbecue may be very hot. Keep young

children away while it is in use.

 You should exercise reasonable care when operating your Ducane

gas barbecue. It will be hot during cooking or cleaning and

should never be left unattended or moved while in operation.

 Should the burners go out while in operation, turn all gas valves off. Open the lid and wait ﬁ ve minutes before attempting to

relight using the lighting instructions.

 Do not use charcoal or lava rock in your Ducane

gas barbecue.

 Never lean over open grill or place hands or ﬁ ngers on the front edge of the cooking box.

 Should a grease ﬁ re occur, turn off all burners and leave lid closed until ﬁ re is out.

 Do not enlarge valve oriﬁ ces or burner ports when cleaning the valves or burners.

 The Ducane

gas barbecue should be thoroughly cleaned on a regular basis.

 Liquid propane gas is not natural gas. The conversion or attempted use of natural gas in a liquid propane unit or liquid

propane gas in a natural gas unit is dangerous and will void your warranty.

 Do not attempt to disconnect any gas ﬁ tting while your barbecue is in operation.

 Use heat-resistant barbecue mitts or gloves when operating barbecue.

 Keep any electrical supply cord and the fuel supply hose away from any heated surfaces.

 Combustion byproducts produced when using this product contain chemicals known to the state of California to cause cancer,

birth defects, or other reproductive harm.

 Do not use this barbecue unless all parts are in place. The unit must be properly assembled according to the instructions

outlined in the “Assembly Guide”.

LIQUID PROPANE GAS UNITS ONLY:

 Use the regulator that is supplied with your Ducane

gas barbecue.

 Do not attempt to disconnect the gas regulator or any gas ﬁ tting while your barbecue is in operation.

 A dented or rusty liquid propane cylinder may be hazardous and should be checked by your liquid propane supplier. Do not

use a liquid propane cylinder with a damaged valve.

 Although your liquid propane cylinder may appear to be empty, gas may still be present, and the cylinder should be

transported and stored accordingly.

 If you see, smell or hear the hiss of escaping gas from the liquid propane cylinder:

1. Move away from liquid propane cylinder.

2. Do not attempt to correct the problem yourself.

3. Call your ﬁ re department.

ASSEMBLY, ENSAMBLAJE, ASSEMBLAGE

11mm (7/16”)

3 BRNR. 5 BRNR.

CAUTION: Although we make every effort to ensure that the assembly process is as easy and as safe as possible, it is inherent

with fabricated steel parts that corners and edges can cause cuts if improperly handled during assembly procedures. Be careful

while handling any parts during assembly. IT IS STRONGLY RECOMMENDED THAT HANDS BE PROTECTED WITH A PAIR OF WORK

GLOVES.



WARNING: Care must be taken to ensure that this grill is assembled according to these instructions. Failure to assemble the

grill properly could create a fire hazard or cause burns or other bodily harm.

TOOLS NEEDED:



PRECAUCIÓN: Aunque hacemos todo lo posible para que el proceso de ensamblaje sea tan fácil y seguro, es imposible

evitar que, con las partes fabricadas de acero, las esquinas y los bordes causen cortes si no son usados apropiadamente

durante el proceso de ensamblaje. ES MUY RECOMENDABLE QUE LAS MANOS SEAN PROTEGIDAS POR GUANTES DE

TRABAJO.



ADVERTENCIA: Debe tener mucho cuidado para asegurar que esta parrilla sea ensamblada de acuerdo a las instrucciones.

No cumplir con el ensamblaje apropiado de la parrilla puede causar un peligro o quemaduras

u otro tipo de lesiones al cuerpo.

HERRAMIENTAS REQUERIDAS:



ATTENTION : Bien que nous fassions tous les efforts possibles pour s’assurer que le processus d’assemblage soit aussi

facile et sécuritaire que possible, il est inhérent que la fabrication de pièces métalliques laissent des coins et des bords

tranchants qui puissent causer des blessures lors de la manipulation incorrecte pendant les procédures d’assemblage. Soyez

prudent lors de la manipulation de toute pièce durant l’assemblage. IL EST FORTEMENT RECOMMANDÉ DE PORTER DES

GANTS POUR PROTÉGER VOS MAINS.



AVERTISSEMENT : Soyez attentif pour vous assurer que le gril est assemblé selon ces consignes. L’omission d’assembler

ce gril correctement pourrait poser un danger ou causer des brûlures ou tout autre blessure corporelle.

OUTILS NECESSAIRES:

4 www.ducane.com

ASSEMBLY, ENSAMBLAJE, ASSEMBLAGE

3 BRNR. 5 BRNR.

ASSEMBLY, ENSAMBLAJE, ASSEMBLAGE

CAUTION: Always remove the

warming rack when using the

rotisserie.



OBSERVACIÓN: Siempre

quite la rejilla de calentamiento

cuando esté usando el sistema

rotativo.



REMARQUE : Enlevez

toujours la grille de chauffage

lors de l’utilisation de la

rôtisserie.

6 www.ducane.com

ASSEMBLY, ENSAMBLAJE, ASSEMBLAGE



WARNING: The rotisserie motor must be

stored indoors when not in use. DO NOT leave it

mounted to the grill.

NOTE: The bolts to install the

stainless steel side shelf are

threaded into the grill cart on the right

side of the grill. Remove the bolts and re-install

when attaching the stainless steel side shelf.

3 4

BRNR.



CAUTION: Failure to install the Side Burner properly could

cause the unit to loosen and fall, causing bodily harm.

BRNR.



PRECAUCIÓN: El motor deber ser almacenado

dentro, cuando no esté en uso. NO LO DEJE

montado en la parrilla.

OBSERVACIÓN: Los tornillos utilizados para armar las mesas

de acero inoxidables están atornillados a la izquierda y derecha

del asador. Quite los tornillos y renstálese cuando valla armar

las mesas de acero inoxidable.



PRECAUCIÓN:

De no instalar la Hornilla Lateral

apropiadamente puede causar que la unidad se afloje y

caiga causando lesiones al cuerpo.



AVERTISSEMENT : Le moteur de rôtisserie doit

être entreposé à l’intérieur lorsqu’il n’est pas

utilisé. NE le laissez PAS installé sur le gril.

REMARQUE: Les boulons pour l’installation des deux étagères

latérales en acier inoxydable sont vissés dans le chariot du

grill, sur les côtés gauche et droit du grill. Retirez ces boulons

puis ré-installez-les lorsque vous ﬁ xez les étagères latérales en

acier inoxydable.



AVERTISSEMENT :

L’omission d’installer le brûleur latéral

correctement pourrait occasionner un desserrage de l’unité

et le faire tomber, causant ainsi des blessures corporelles.

ASSEMBLY, ENSAMBLAJE, ASSEMBLAGE

Uncoil the NG supply hose and route the end out of the

access hole at the back panel of the cabinet.

Desenrolle la manguera de suministro de gas natural y

pase el extremo hacia afuera por el orificio de acceso

en el panel posterior del gabinete.

BRNR.

Déroulez le tuyau d’alimentation en gaz naturel et faites

passer le bout par l’ouverture d’accès située sur le

panneau arrière du cabinet.

8 www.ducane.com

Ducane Products, Co. hereby warrants to the ORIGINAL PURCHASER of this Ducane

Stain-

less Series gas grill that it will be free of defects in material and workmanship from the date of

purchase as follows:

Ten-Year Limited Warranty

• Stainless steel cabinetry and grill lid excluding discoloration and scratches

Five-Year Limited Warranty

• Stainless steel cooking grates

• Stainless steel primary grill burners

• Side Burner Inserts

• Stainless steel rotisserie burners

One-Year Limited Warranty

• Rotisserie motor

• Ignition system

• All remaining parts

The above warranty period(s) applies only to grills used in a non-commercial setting when assembled

and operated in accordance with the printed instructions accompanying the grill.

Ducane may require valid proof of your date of purchase. Please retain your receipt of purchase or

invoice as reasonable proof.

This Limited Warranty shall be limited to repair or replacement of parts that prove defective under

normal, non-commercial use and which, on examination shall indicate, to Ducane’s satisfaction, that

they are defective. Before returning any parts, please contact Ducane’s Customer Service at 1-800-

DUCANES (1-800-382-2637).

If Ducane conﬁ rms the defect and approves the claim, Ducane will elect to replace such parts without

charge. If you are required to return defective parts, transportation charges must be paid by you.

Ducane will return parts to purchaser, freight or postage prepaid.

This Limited Warranty does not cover failures or operating difﬁ culties due to accident, abuse, misuse,

alteration, misapplication, vandalism, improper installation, use in a commercial enterprise, improper

maintenance, including but not limited to damage caused by insects within burner tubes, as described

in the owner’s manual.

Deterioration or damage due to severe weather conditions, such as hail, hurricanes, earthquakes, or

tornadoes is not covered by this Limited Warranty.

Deterioration or discoloration due to exposure to chemicals, either directly or in the atmosphere, is

not covered by this Limited Warranty.

There are no other express warrants except as set forth herein and any applicable implied warranties

of merchantability and ﬁ tness are limited in duration to the period of coverage of this express written

Limited Warranty. Some regions do not allow limitation on how long an implied warranty lasts, so

this limitation may not apply to you.

Ducane is not liable for any special, indirect or consequential damages. Some regions do not allow the

exclusion or limitation of incidental and consequential damages, so this limitation or exclusion may

not apply to you.

Ducane does not authorize any person or company to assume for it any other obligation or liability in

connection with the sale, installation, use, removal, return or replacement of its equipment; and no

such representations are binding on Ducane.

This Limited Warranty applies only to products sold at and purchased from a retail entity excluding

on-line auction services.

Ducane Products Co.

1656 Fuldner Road

Barnwell, SC 29812

USA

www.ducane.com

Ducane Products, Co., por el presente documento garantiza al COMPRADOR ORIGINAL de esta

parrilla a gas de la Serie Inoxidable de Ducane

que estará libre de defectos de materiales y fabricación

desde la fecha de adquisición así

Garantía limitada de diez años

• Gabinete de acero inoxidable y tapa de la parrilla, excluyendo descoloración y rasguños

Garantía limitada de cinco años

• Rejillas para cocción en acero inoxidable

• Quemadores primarios de la parrilla en acero inoxidable

• Insertos de quemadores laterales

• Quemadores para asador en acero inoxidable

Garantía limitada de un año

• Motor del asador

• Sistema de encendido

• Todas las demás partes

Los anteriores períodos de garantía sólo se aplican a parrillas usadas en ambientes no comerciales

cuando sean ensambladas y operadas de acuerdo con las instrucciones impresas que acompañan la

parrilla.

Ducane puede solicitar una prueba válida de su fecha de adquisición. Por favor guarde su recibo de

compra o la factura como prueba razonable.

Esta Garantía Limitada se limitará a la reparación o reemplazo de partes que se pruebe que estaban

defectuosas bajo un uso normal y no comercial, y que, tras ser examinadas, indiquen a satisfacción de

Ducane que efectivamente están defectuosas. Antes de devolver cualquier parte, por favor contacte al

Servicio al Cliente de Ducane al 1-800-DUCANES (1-800-382-2637).

Si Ducane confirma el defecto y aprueba la reclamación, Ducane elegirá reemplazar dicha parte sin

ningún cargo. Si se le solicita que devuelva las partes defectuosas, los costos de transporte deberán

ser asumidos por usted. Ducane devolverá las partes al comprador con flete o timbre pagado por

anticipado.

Esta Garantía Limitada no cubre fallos o dificultades de operación debidos a accidentes, abuso,

mal uso, alteración, mal manejo, vandalismo, instalación inadecuada, uso en empresa comercial,

mantenimiento indebido, e incluye, pero no se limita, a daños causados por insectos al interior de los

tubos quemadores, como se describe en el manual del usuario.

El deterioro o daño debido a condiciones climáticas extremas, tales como granizo, huracanes,

terremotos o tornados no está cubierto por esta Garantía Limitada.

El deterioro o la decoloración debidos a la exposición a químicos, bien sea directamente o en la

atmósfera no están cubiertos por esta Garantía Limitada.

No hay ninguna otra garantía expresa salvo las que están contenidas en este documento, y cualquier

garantía implícita aplicable de comerciabilidad y adecuación está limitada a la duración del período

de cobertura de esta expresa Garantía Limitada. Algunas regiones no admiten una limitación al

tiempo de duración de una garantía implícita, de forma que esta limitación no aplica para usted.

Ducane no es responsable por ningún daño especial, indirecto o resultante. Algunas regiones no

admiten la exclusión o limitación de daños incidentales o resultantes, de forma que esta limitación

podría no aplicar para usted.

Ducane no autoriza a ninguna persona o compañía a asumir en su nombre ninguna otra obligación

o responsabilidad en relación con la venta, instalación, uso, retiro, devolución o reemplazo de este

equipo; y ninguna de dichas representaciones obligan a Ducane.

Esta Garantía Limitada aplica únicamente a productos vendidos en y comprados de una entidad

detallista, excluyendo servicios de subasta en línea.

Ducane Products Co.

1656 Fuldner Road

Barnwell, SC 29812

USA

www.ducane.com

Par la présente, Ducane Products, Co., garantie à l’ACHETEUR ORIGINAL du gril au gaz en

acier inoxydable Ducane

qu’elle sera sans vices de matériaux et de fabrication à partir de la date

d’achat, tel que suit:

Garantie Limitée de Dix Ans

• Habillage et couvercle de gril en acier inoxydable à l’exception de décoloration et

d’égratignures.

Garantie Limitée de Cinq Ans

• Gril de cuisson en acier inoxydable

• Brûleurs primaire en acier inoxydable

• Insertions du bruleurs du côté

• brûleurs de tournebroche en acier inoxydable

Garantie Limitée d’un An

• Moteur du tournebroche

• système d’allumage

• Toutes autres pièces

La(Les) période(s) de garantie ci-haut mentionné s’applique seulement au grils personnel, et non

ceux qui sont utilisés dans un milieu commercial, quand assemblé et opéré selon les instructions

inclues avec le gril.

Ducane pourra exiger une preuve d’achat valable. Veuillez conserver votre preuve d’achat ou votre

facture comme preuve.

Cette garantie sera limitée à la réparation ou le remplacement de pièces qui s’avèrent être défectueux

sous des conditions d’utilisation normal, non-commercial, et qui, après exam indiquera, à la satisfac-

tion de Ducane’s, une défectuosité. Avant de retourner les pièces, veuillez contacter le service a

clientèle de Ducane au 1-800-DUCANES (1-800-382-2637).

ISi Ducane conﬁ rme la défectuosité et approuve la demande, Ducane choisira de remplacer ses pièces

sans frais. Si vous êtes obligé de retourner des pièces déféctueueses, vous devez assumer tous les frais

de transports, fret ou port-pré-payé.

Cette garantie limitée ne couvre pas les pannes ou les difﬁ cultés d’opération résultant d’accidents,

abus, emploi abusif ou mauvaise opération, vandalisme, mauvaise installation, utilisation commerci-

ale, mauvais entretien, incluant mais pas limitée aux dommages causés par les insectes dans les tubes

de brûleurs, tel que décrites dans le guide d’achat.

La détérioration ou les dommages dû aux conditions sévère de température, notamment, grêles,

ouragans, tremblements de terre , ou tornades ne sont pas couvert par cette garantie limitée.

La détérioration ou la décoloration dû à une exposition au produits chimique, directement ou dans

l’atmosphère, ne sont pas couverte par cette garantie limitée.

Il n’y a pas d’autres garantie expresse à part celles détaillées et n’importe quelle garantie tacite de

qualité marchande et de compatibilité applicable est limitée à la durée de la période de couverture de

cette garantie expresse limitée. Certaines régions ne permettent pas la limitation de garantie tacite,

donc la limitation ne pourrait vous être applicable.

Ducane n’est pas responsable des dommages, indirects ou conséquents. Certaines régions ne per-

mettent pas l’exclusion ou la limitation de dommages accessoires ou immatériels, donc, l’exclusion ou

la limitation ci-haut mentionnée ne pourrait vous être applicable.

Ducane n’autorise aucune personne ou entreprise, d’assumer à son nom, n’important quelle

obligation ou responsabilité reliée à la vente, l’installation, l’utilisation, l’enlèvement, le retour ou le

remplacement de son équipement; et ce, notamment, aucune répresentations de ce genre engage

Ducane.

Cette garantie limitée s’applique seulement aux produits vendu par, ou procuré chez, un détaillant,

excluant tous sites de vente aux enchères en-ligne..

Ducane Products Co.

1656 Fuldner Road

Barnwell, SC 29812

USA

www.ducane.com

WARRANTY, GARANTÍA, GARANTIE

IMPORTANT

We urge you to read this manual carefully and to follow the recommendations enclosed. This will help assure you of the most enjoyable and trouble-free operation of your new

Ducane

Gas Grill. We also advise you to keep this manual for future reference.

 WARNING: Your grill has been designed to operate using

only the gas speciﬁ ed on the rating plate. Do not attempt to

operate your grill on other gases. Failure to follow this warn-

ing could lead to a ﬁ re hazard and bodily harm, and will void

your warranty.

 CAUTION: FOR YOUR SAFETY Do not store any ﬂ ammable

materials in any cabinets beneath the grill burner box or in

the vicinity of your grill.

CALIFORNIA PROPOSITION 65

 WARNING: The burning of gas cooking fuel generates some

by-products which are on the list of substances known by

the State of California to cause cancer or reproductive harm.

California law requires businesses to warn customers of po-

tential exposure to such substances. To minimize exposure

to these substances always operate this unit according to

the use and care manual, ensuring you provide good ventila-

tion when cooking with gas.

SAFETY INFORMATION

INSTALLATION

Natural Gas Grills

Locating Your Grill

• Your Ducane

Gas Grill is manufactured for outdoor use only! Any grill, charcoal

or gas, produces carbon monoxide while in operation and the gas should not be

allowed to accumulate in a conﬁ ned area. Never operate this grill inside your home

or recreational vehicle or any enclosed area.

• When locating your grill, choose a safe outdoor location away from ﬂ ammable or

combustible surfaces and out of trafﬁ c paths. Ducane

strongly recommends a 24”

clearance to combustible surfaces.

• Consult your local codes for possible additional restrictions on location or operation

of your grill.

• As your grill uses gas, it requires air to burn properly. Do not locate your grill in

such manner or as to obstruct the ﬂ ow of combustion and ventilation air around the

grill.

• When possible, adjust your grills’ position to reduce the likelihood of wind blowing

onto it.

 CAUTION: Never operate your grill under any overhead com-

bustible construction.

 CAUTION: This grill is not intended to be installed in or at-

tached to a recreational vehicle. It is also not intended to be

installed in or on a boat.

 WARNING: For your safety, do not store or use gasoline or

other ﬂ ammable vapors and liquids in the vicinity of this

or any other appliance. Failure to follow this warning could

lead to a ﬁ re, explosion and bodily harm.

Assembly

Make sure your grill is assembled properly. Detailed assembly instructions are packed

with each grill giving speciﬁ c assembly procedures for each model. Follow these in-

structions carefully to ensure the correct and safe assembly of the grill.

 CAUTION: Although we take every effort to ensure that the

assembly process is as easy and as safe as possible, it is

inherent with fabricated steel parts that corners and edges

can cause cuts if improperly handled during assembly pro-

cedures. Be careful while handling any parts during assem-

bly. It is strongly recommended that you protect hands with

a pair of work gloves.

24”

Leveling

It is important for the proper operation of the grill that it be located on a level surface.

10 www.ducane.com

CONNECTION

Natural Gas Grills

Type of Gas

Your natural gas grill is factory built to operate using natural gas only. Never attempt

to operate your grill on gases other than the type speciﬁ ed on the grill rating plates.

Your grill operates at 7” of water column pressure. If replacement of the hose becomes

necessary, factory speciﬁ ed parts are required. See your local dealer.

For safety and design reasons, the conversion of a Ducane

grill from operation

using Natural gas to operation using LP gas requires the change out of the entire gas

supply system of the grill. If this becomes necessary, see your dealer for additional

information.

What is Natural Gas?

Natural gas, often called methane, is a safe modern fuel. Natural gas is supplied by

your local utility and should be readily available if your house is already heated with

gas.

Portable Installation

Limited portability can be afforded to the grill head when mounted on the portable

cart. All grill heads mounted on this portable cart and cabinet model grills so equipped

can be moved about 10 feet away from the main gas supply. Ducane recommends

moving the grill at least two (2) feet from the gas supply and any combustible surfaces.

After the gas supply has been run and checked for leaks in accordance to the assembly

instructions, you are ready to grill. To connect the hose to the gas supply, pull back

the outer ﬁ tting, insert the hose ﬁ tting all of the way, and release the outer ﬁ tting. This

process will produce a gas joint.

Follow special storage instructions located in the Helpful Hints section of this manual

for proper care of your grill and its gas hose.

Natural Gas Regulator

Flare Union

Swivel Connection

Install covers when hose is disconnected.

Shut Off Valve

Coat this pipe nipple with gas resistant pipe dope.

Socket

Male Connection

FLOW

Socket

Sleeve

Plug

Push plug until sleeve snapsf orward locking plug in socket. (This

turns on gas automatically.)

FLOW

Socket

Sleeve

Push Sleeve Back

When properly assembled the plug cannot be removed without pushing

the sleeve back. To disconnect, push sleeve back and pull out plug.

(This automatically shuts off gas.)

CONNECTION

Natural Gas Grills

NATURAL GAS INSTALLER’S GUIDE

This guide is a recommendation for natural gas installations. It advises the installer

as to the size tubing that is necessary on a natural gas installation depending

on how far the grill is located from the house. All tubing should be anticorrosive

tin-lined copper or an AGA-approved alternate. Operating pressure of the grill is 3”

water column pressure. This should be veriﬁ ed after the installation is complete.

Comparable sized black iron pipe is also acceptable for natural gas lines.

Distance Pipe Size

1 - 25 feet 3/8"

26 - 50 feet 1/2"

51- 100 feet 2/3" of the run 3/4" down to 1/2"

101 feet or more 3/4"

Gas Leaks Checks

Before operating your grill, check carefully to be certain that all connections are tight

and there are no gas leaks. Never use a match or ﬂ ame for leak detection. Use soapy

water or testing solution. Brush the solution on to connection points and look closely

for bubbles indicating escaping gas. If leaks are detected, shut off the main gas supply

valve and securely retighten connections, then repeat the leak test.

 CAUTION: The appliance and its individual shutoff valve

must be disconnected from the gas supply piping system

during any pressure testing of that system at test pressures

in excess of 1/2 psig (14” wc).

 CAUTION: The appliance must be isolated from the gas sup-

ply piping system by closing its individual manual shutoff

valve during any pressure testing of the gas supply piping

system at test pressures equal to or less than 1/2 psig (14”

wc).

 WARNING: Never use an open ﬂ ame when testing for gas

leaks! Use of an open ﬂ ame may result in serious bodily

injury or death, or in a ﬁ re or an explosion causing damage

to property.

IMPORTANT

Installation must conform with local codes or, in the absence of local codes,

with either the National Fuel Gas Code, ANSI Z223.1/NFPA 54, or CAN/

CGA-B149.1; Natural Gas and Propane Installation Code.

IMPORTANT

When connecting or replacing any gas pipe or ﬁ ttings, all joints must be

sealed with leak-proof sealing compound approved for use with natural and

propane gases. After making connections, check all joints for leaks using

soapy water and a brush.

12 www.ducane.com

NORMAL OPERATION

 WARNING: Your Ducane

grill was not designed to operate

with the Rotisserie Burner and the Main Burner(s) on at the

same time. Failure to follow this warning will lead to an over-

heating condition which would damage grill components

and cause bodily harm.

 WARNING: Keep any electrical supply cord and the fuel sup-

ply hose away from any heated surfaces.

Lighting Your Grill

 WARNING: Before each use of your grill it is important to

inspect the full length of the gas line hose. Your hose can be

accessed through the cabinet doors on a 24” Three Burner

Model, and through the cabinet drawer on the 32” Five

Burner Model. If it is evident there is excessive abrasion or

wear, or the hose is cut, the hose must be replaced with a

manufacturer recommended part prior to the appliance be-

ing put into operation.

Check your parts list or your authorized dealer for the proper replacement hose as-

sembly. It will be necessary to open the doors to fully inspect the hose.

 DANGER: Make sure that the lid is in the full open postion

any time you attempt to light your grill. Failure to open the

lid could lead to delayed ignition which may result in serious

bodily injury or death, or in a ﬁ re or an explosion causing

damage to property.

IMPORTANT

If an external electrical source is used it must be electrically grounded in

accordance with local codes and/or the National Electrical Code ANSI/NFPA

70, or the Canadian Electrical Code, CSA C22.1

Preheating Grill

It is extremely important that your grill be up to temperature before you begin

using it. After lighting, close the lid and preheat the grill on “high” for 10 minutes.

This preheating will ensure that the cooking grid is hot enough for proper grill-

ing.

 WARNING: Never leave a grill unattended to guard

against possible grease ﬁ res getting out of control. Grease

ﬁ res can be severe and cause grill damage, property dam-

age and bodily harm.

Open or Close Lid for Grilling

Cooking with the lid open or closed is a matter of personal preference. Cooking

with the lid closed is recommended if you enjoy cooking at maximum “searing”

temperatures. This method will also speed the cooking process, and will give you

a more robust, smoky, outdoor ﬂ avor. If you prefer cooking slower, with less ﬂ are

up, we suggest the lid-open method.

We recommend always cooking with your lid CLOSED if you are in a windy area

or colder climate. Your Ducane

gas grill has been designed and constructed to

give you maximum ﬂ exibility and cooking performance. Be creative, try different

cooking methods on your grill to determine what suits your needs best…there is

no “right” or “wrong” way to cook…just different individual styles.

 WARNING: Please remember that this is an outdoor

gas cooking appliance. Many areas of the grill generate

extreme heat. We have taken every precaution to protect

you from the contact areas. However, it is impossible to

isolate all high-temperature areas. Therefore, use good

judgment and a certain degree of caution when grilling on

this product. We suggest a covered, protected hand during

operation of grill. Do not move your grill when it is in opera-

tion or hot to the touch. Wait until your unit is turned off and

properly cooled down before moving from place to place.

Failure to follow this warning could result in personal injury.

Post-heating Grill

In order to assist cleaning your cook grid and to completely vaporize remaining juices,

post-heat grill for 10 minutes with the burners on “high” and the lid closed.

 CAUTION: Do not cover the cook grate during the post-heat-

ing period.

After the post-heating of your grill is completed turn the control knobs to the “OFF”

position.

For Natural Gas Grills and System Propane

It is also advisable to turn off the Natural Gas or System Propane gas supply at the

main cut-off valve when your grill is not in use.

NORMAL OPERATION

Main Burner Snap Ignition

Follow the simple steps listed below to light the Main Burner(s) of your grill:

1. Open the lid and make sure that all burners are in the “OFF” position.

2. Turn main gas supply on.

3. Push the control knob in and turn to “HIGH”. This action will spark the igniter and

light the pilot tube and then Main Burner.

4. If ignition does not occur within 5 seconds, turn control knob “OFF” and repeat

ignition step number 3.

5. Verify that each burner has ignited by visual inspection of a ﬂ ame.

 WARNING: If ignition still does not occur, turn control knob

OFF and wait 5 minutes before manually lighting the burner

with match. See Match Lighting instructions.

Match Lighting Your Grill Main Burners

Follow the simple steps listed below to match light the Main Burner(s) of grill, in the

event snap ignition fails:

 WARNING: (Make sure that 5 minutes have elapsed since

last attempt of lighting.) Make sure that the lid is in the

full open position any time you attempt to light your grill.

Failure to open the lid could lead to delayed ignition which

may result in serious bodily injury or death, or in a ﬁ re or an

explosion causing damage to property.

 WARNING: Do not lean over an open barbecue.

1. Open the lid and make sure that all burners are in the “OFF” position.

 DANGER: Failure to open the lid while igniting the main

burners, or not waiting 5 minutes to allow the gas to clear

if the side burner does not light, may result in an explosive

ﬂ ame-up which can cause bodily injury or death.

2. Turn main gas supply on.

3. Put match in the match holder and strike match.

4. Push in selected MAIN BURNER control knob and turn to “HIGH”.

5. Insert match holder and light match down through cooking grate to ignite the

selected Main Burner.

 WARNING: If the burner does not light, turn the selected

burner control knob to OFF and wait 5 minutes to let the gas

clear before trying again to light burner(s).

6. Verify selected Main Burner(s) has ignited by visual inspection of a ﬂ ame.

OFF / ARRET / APAGADO

MAIN BURNER

14 www.ducane.com

NORMAL OPERATION

SIDE BURNER

OFF / ARRET / APAGADO

Match Lighting Your Grill Side Burner

Follow the simple steps listed below to match light the Side Burner of grill, in the event

snap ignition fails:

1. Open the lid and make sure that all burners are in the “OFF” position.

 DANGER: Failure to open the lid while igniting the Side

Burner, or not waiting 5 minutes to allow the gas to clear if

the Side Burner does not light, may result in an explosive

ﬂ ame-up which can cause bodily injury or death.

2. Turn main gas supply on.

3. Put match in the match holder and strike match.

 WARNING: Do not lean over an open barbecue.

4.Push in Side Burner control knob and turn to “high”.

5.Insert match holder and lit match through trivet to ignite the Side Burner.

 WARNING: If burner does not light, turn the Side Burner

control knob to OFF and wait 5 minutes to let the gas clear

before trying again to light burner.

6.Verify Side Burner has ignited by visual inspection of a ﬂ ame.

Side Burner Snap Ignition

Follow the simple steps listed below to light the Side Burner (SB) of your grill:

 DANGER: Failure to open the lid while igniting the side

burner, or not waiting 5 minutes to allow the gas to clear

if the side burner does not light, may result in a explosive

ﬂ ame-up which can cause bodily injury or death.

1. Open the lid and make sure that all burners are in the “OFF” position.

2. Turn main gas supply on.

3. Push the SIDE BURNER control knob in and turn to “HIGH”. This action will spark

the igniter and light the Side Burner.

4. If ignition does not occur within 5 seconds, turn control knob “OFF” and repeat

ignition step number 3.

5. Verify Side Burner has ignited by visual inspection of a ﬂ ame.

 WARNING: If ignition still does not occur, turn control knob

OFF and wait 5 minutes before manually lighting the burner

with match. See Match Lighting instructions.

NORMAL OPERATION

ROTISSERIE BURNER

OFF / ARRET / APAGADO

Match Lighting Your Rotisserie Burner

Follow the simple steps listed below to match light the Rotisserie Burner of grill, in the

event electronic ignition fails:

1. Open the lid and make sure that all burners are in the “OFF” position.

 DANGER: Failure to open the lid while igniting the Rotisserie

Burner, or not waiting 5 minutes to allow the gas to clear if

the Rotisserie Burner does not light, may result in an explo-

sive ﬂ ame-up which can cause bodily injury or death.

2. Turn main gas supply on.

3. Remove warming rack. NOTE: Always remove the warming rack when using the

rotisserie.

4. Put match in the match holder and strike match.

 WARNING: Do not lean over an open barbecue.

5. Push the ROTISSERIE BURNER control knob in and turn to “high”. Continue to

hold the ROTISSERIE BURNER control knob in until 20 seconds after the burner

has ignited. Then release the ROTISSERIE BURNER control knob.

6. Hold match holder and lit match to the middle of the Rotisserie Burner to ignite.

 WARNING: If burner does not light, turn the selected burner

control knob to OFF and wait 5 minutes to let the gas clear

before trying again to light burner(s).

7. Verify Rotisserie Burner has ignited by visual inspection of a ﬂ ame. (The burner will

glow red.)

 WARNING: Never leave a grill unattended. This will guard

against possible grease ﬁ res getting out of control. Grease

ﬁ res can be severe and cause grill damage, property dam-

age and bodily harm.

 WARNING: Please remember that this is an outdoor gas

cooking appliance. Many areas of the grill generate extreme

heat. We have taken every precaution to protect you from

the contact areas. However, it is impossible to isolate all

high-temperature areas. Therefore, use good judgment and

a certain degree of caution when grilling on this product. We

suggest a covered, protected hand during operation of grill.

Do not move your grill when it is in operation or hot to the

touch. Wait until your unit is turned off and properly cooled

down before moving from place to place. Failure to follow

this warning could result in personal injury.

Rotisserie Burner Electronic Ignition

Follow the simple steps listed below to light the Rotisserie Burner of your grill:

 DANGER: Failure to open the lid while igniting the Rotisserie

Burner, or not waiting 5 minutes to allow the gas to clear if

the Rotisserie Burner does not light, may result in a explo-

sive ﬂ ame-up which can cause bodily injury or death.

 CAUTION: The Rotisserie Burner ﬂ ame may be difﬁ cult to

see on a bright sunny day.

1. Open the lid and make sure that all burners are in the “OFF” position.

2. Turn main gas supply on.

3. Remove warming rack. NOTE: Always remove the warming rack when using the

rotisserie.

4. Push the ROTISSERIE BURNER control knob in and turn to “HIGH”. Continue to

hold the ROTISSERIE BURNER control knob in until 20 seconds after the burner

has ignited. Then release the ROTISSERIE BURNER control knob.

5. Push the electronic ignition button in and hold until the Rotisserie Burner is

completely ignited. You will be able to both hear and see a spark in front of the

Rotisserie Burner.

6. If ignition does not occur within 5 seconds, turn control knob “OFF” and repeat

ignition step numbers 3 and 4.

7. Verify Rotisserie Burner has ignited by visual inspection of a ﬂ ame. (The burner will

glow red.)

 WARNING: If ignition still does not occur, turn control knob

OFF and wait 5 minutes before manually lighting the burner

with match. See Match Lighting instructions.

16 www.ducane.com

NORMAL OPERATION

 WARNING: Setup the rotisserie with food before lighting

Rotisserie Burner.

Operating the Rotisserie

1. Remove rotisserie shaft from grill.

2. Loosen and remove right side bearing, the counterbalance and right side spit fork.

3. Push the rotisserie shaft through the center of the food.

4. Slide the right side spit fork back onto the shaft. Insert the tines of both spit forks

into the food. The food should be centered on the shaft. Tighten spit fork thumb

screws.

5. Place left side bearing (welded in place) groove into the left side spit rod mount cut-

out.

6. Place the right side bearing onto the spit rod and insert the pointed end of the spit

rod into the rotisserie motor.

7. Line up both the groove on the right side bearing with the right side spit rod mount

cut-out, and slide the motor over the motor mounting bracket ﬂ ange and push

down. Note: The thumbscrew is only tightened when the rotisserie is not in use. Do

not tighten the thumbscrew when using so that the spit rod can rotate freely.

8. The rotisserie shaft should rotate so that the heavy side of the meat or poultry

rotates down to the bottom. Large cuts of meat may require the removal of the cook

grates to allow full rotation of the spit rod. Note: Remount the food and/or use the

counterbalance if necessary for better balance on the spit rod. The counterbalance

can be mounted after Step 5 above.

9. Plug the motor in and turn it on.

10.Follow Lighting Instructions.

Cooking with the Rotisserie

• When using the rotisserie, the lid must be closed except when basting.

• Meats (except poultry and ground meat) should be brought to room temperature

before cooking. (20 to 30 minutes should be adequate for most foods. If frozen

defrost completely before cooking.)

• Tie meat or poultry with a string, if necessary, to make the shape as uniform as pos-

sible before putting it on the spit.

• Remove cooking grates and warming rack to allow food to turn freely.

• Follow Lighting Instructions for Rotisserie Burner under Lighting Your Grill sec-

tion.

• Set Rotisserie Burner on “med-high” based on outside air temperatures.

• Place food within area of burner.

• If you wish to save drippings for gravy, place a drip pan directly under the food on

top of the heat distribution plates.

• Food preparation steps are the same for rotisserie cooking as for regular cooking.

NOTE: When using the Rotisserie Burner, grill thermometer will not reﬂ ect the

temperature inside the cooking box.

Using the Rotisserie

WARNINGS:

Read all instructions before using your rotisserie.

 This rotisserie is for outdoor use only.

 Remove motor and store in a dry place when not in use.

 Do not touch hot surfaces. Use barbecue mitts.

 This rotisserie is not for use by children.

 To protect against electrical hazards do not immerse cord,

plugs, or motor in water or other liquids.

 Unplug the motor from outlet when not in use or before

cleaning.

 Do not use rotisserie for other than intended use.

 Make sure motor is OFF before placing it on the motor

bracket.

 Do not operate the rotisserie motor with a damaged cord or

plug.

 Do not operate the rotisserie motor if it should malfunction.

 The rotisserie motor is equipped with a three prong (ground-

ing) power cord for your protection against shock hazard.

 The power cord should be plugged directly into a properly

grounded three prong receptacle. If use of an extension cord

is required, be sure that it is a minimum 16 AWG, 3 wire well

insulated cord, marked for outdoor use only and properly

grounded.

 When using an extension cord, make sure it is not in contact

with a hot or sharp surface.

 Outdoor extension cords should be marked with the letters

“W-A” and a tag stating “Suitable for use with outdoor appli-

ances”.

 Do not cut or remove the grounding prong from the rotis-

serie motor power cord.

 Do not let cord hang over any sharp edge or hot surface.

 Do not expose to rain.

 To reduce the risk of electric shock, keep extension cord

connection dry and off the ground.

 A short power cord is supplied to reduce the risk of tripping

over the cord. Extension cords may be used, but caution

must be taken to prevent tripping over the cord.

In absence of local codes the rotisserie motor must be

grounded electrically in accordance with the National Elec-

trical Code, ANSI/NFPA 70, or Canadian Electrical Code, CSA

C22.1.

HELPFUL HINTS

Flare Ups

Any time you cook fatty foods over an open ﬂ ame, you can expect ﬂ are ups. Flare ups

are caused by the ﬂ ash which occurs when the natural juices fall on the heat distribu-

tion plates. Controlled ﬂ are ups give foods their delicious outdoor ﬂ avor and appear-

ance. Excessive ﬂ are ups may occur when your grill is not level or when cooking fatty

foods such as spare ribs and chicken parts, especially if the cooking temperature is set

too high. These ﬂ are ups should be controlled or your food will burn, although it will

not burn nearly as much as you might think even in the direct ﬂ ame.

 WARNING: Do not spray or pour any liquid into the cooking

box to control ﬂ are ups. Doing so will void your warranty

and may damage the grill.

To help control ﬂ are ups, we suggest using leaner cuts of meats and trimming excess

fat from the meats to be grilled. Also, your grill should be level. If ﬂ are ups do occur,

use the “Low” control setting and relocate the meat on the cooking grid until the ﬂ are

ups have subsided.

1. To prevent food from sticking to the grid, preheat the cooking surface with the hood

down for 10 minutes. Place the meat product on the grid and allow it to remain

there for at least half of the suggested grilling time.

2. It is unnecessary to keep ﬂ ipping meat products— allow them to sear and seal in

their juices, then halfway through the cooking period, with a spatula, ﬂ ip the meat

product onto its other side. When grilling chicken, always place the meat side on the

grill ﬁ rst.

3. A light coating of oil applied to any of the meat products prior to grilling will also

help. The use of a commercial spray cooking product is also helpful. This spray

should only be used prior to lighting your grill but never during the cooking period.

Use of spray cooking product can leave a black stain on areas of your cook grate.

This is not harmful and does not affect cooking; however, if this becomes an appear-

ance problem, the best way to remove the discoloration is by placing the cook grate

in a self-cleaning oven during the clean cycle.

When Using the Rotisserie

 WARNING: The rotisserie motor must be stored indoors

when not in use. Do not leave it mounted on the grill.

1. When using the rotisserie, the hood must be closed except when basting.

2. Important: Always light rotisserie burner with the hood in the full open position.

3. It is important to evenly balance the meat on the spit rod. This can be difﬁ cult

especially with a turkey. Proper balancing will lead to more even cooking and

prolong the life of the rotis motor.

4. Pliers may be used to tighten thumb screws on meat forks when larger cuts of

meat are being rotissed.

5. Use twine to secure the meat on the spit rod, especially fowl or other cuts of meat

that require tying.

Rotisserie Bracket (Motor Bracket Side)

When mounting the spit rod motor onto the motor bracket (right side burner box),

the ears of the motor bracket must be fully inserted into the spit motor slots.

Accomplish this by sliding the spit motor down to the stops of the spit motor bracket.

The spit rod should not be making surface contact with the slot in the spit motor

bracket. See Assembly Guide for more information.

Shelf/Shelves

Do not use shelf or shelves as a cutting board. Clean with soap and water.

Moving Portable Grills

When your grill is not in use and you wish to relocate it, we recommend you push the

grill by the side shelf.

 CAUTION: If your grill is portable and you are using a gas

tank, make sure you turn the appliance control knobs ﬁ rst,

and then the gas supply tank. On permanent installations, it

is strongly recommended that the inline ﬁ eld installed cutoff

valve also be turned off when the grill is not in use.

Storing Natural Gas Grills

After you have ﬁ nished cooking and have cleaned your grill, (see Maintenance section

– for cleaning), turn your grill off at your appliance control knob. It is strongly recom-

mended that the inline ﬁ eld installed cutoff valve also be turned off when the grill is

not in use.

When the portable grill is to be stored indoors, the connection between the hose and

the gas supply line must be broken. While the special ﬁ tting will stop the gas ﬂ ow when

the hose connection is removed, it is highly recommended you turn the gas supply off

prior to disconnecting the hose assembly. To protect the gas ﬁ tting, it is necessary to

insert the plastic plug (supplied with 10’ hose package) into the female quick connect.

The male end of the hose must be protected by placing the plastic cap (supplied with

10’ hose package) over the brass ﬁ tting on the end of the hose.

Gas Valve Oriﬁ ce

 WARNING: Any alteration made to the oriﬁ ce(s) such as drill-

ing it out, will void your warranty and may result in serious

bodily injury or death, or in a ﬁ re or an explosion causing

damage to property.

18 www.ducane.com

TROUBLESHOOTING

PROBLEM CHECK and CURE IMPORTANT

IGNITION SYSTEM

Be sure that there is gas ﬂ ow to the burners by attempting to match light your burners.

If match lighting is successful, the problem lies somewhere in the ignition system and

will need to be checked.

MAIN GRILLING BURNERS

 CAUTION: Always turn the gas supply off at the main gas

cut off before proceeding with any troubleshooting proce-

dures.

If, for any reason, the snap ignition fails to ignite the main grilling burner(s), repeat the

lighting procedures described on the grill control panel.

 WARNING: The hood must be in the full open position any

time you attempt to light your grill. Failure to open the

hood could lead to delayed ignition resulting in bodily

harm.

After shutting off the main gas supply, remove the cook grate and heat distribution

plates. Turn snap igniter counter clockwise and check if the electrode is sparking to the

igniter tube. Try the snap igniter several times.

If the main burner(s) still fails to ignite, make

sure that there is gas ﬂ owing to the burner(s)

by attempting to match light the burner(s).

If the burners will match light, then proceed

with the ignition checkout.

If for any reason the igniter system is still

inoperative, follow match lighting instructions.

ROTISSERIE BURNER ELECTRONIC

IGNITION

With a fresh battery installed, push electronic ignition button and check if there is a

spark between the two electrode tips. There needs to be a 1/8” to 3/16” gap between

the electrode tips. If the gap is lesser or greater, carefully bend the electrode tips until

you have the correct gap of 1/8” to 3/16”(A).

Verify that the battery is in good condition

and installed correctly. If so, try a new

battery.

If for any reason the igniter system is still

inoperative, follow match lighting instructions.

BURNERS WITH POOR FLAME

Check to be sure burner ports, shutter, end of the burner (venturi) and oriﬁ ce(s) are

free of any obstructions. Also, if your grill has been stored over a prolonged period of

time, check to make sure no spiderwebs have been formed in the shutter end of the

burner (venturi) or over oriﬁ ces.

If you still have a poor ﬂ ame, please contact

dealer for futher assistance or call Customer

Service

If problems cannot be corrected by using these methods, please contact the Customer Service Representative in your area using the contact information on our

web site. Log onto www.ducane.com.

MAINTENANCE

Yes, you paid a lot of money for your grill, but even an expensive grill doesn’t clean

and maintain itself, and you want it to look good and function properly. That’s why

this section of your manual is so important. This section gives you the information

necessary to help you keep your grill looking new and working properly. Reading and

following the instructions in this section will make your grill investment pay off for

many years.

90-Day Grill Maintenance Schedule

It is recommended that every 90 days the following maintenance procedure is fol-

lowed, but it is absolutely necessary to perform this maintenance at least once a year.

By doing so you will extend the life of your gas grill.

Cleaning the Hood

The exterior of the hood should be maintained with a stainless steel cleaner. The inside

of the hood may be cleaned with a solution of warm water and liquid detergent to

remove any grease build-up.

IMPORTANT

• Keep appliance area clear and free from combustible materials, gasoline and other

ﬂ ammable vapors and liquids at all times.

• Do not locate your grill in such a manner or otherwise obstruct the ﬂ ow of combus-

tion and ventilation air around the grill.

• As part of the normal maintenance schedule, check to be sure that all ventilation

openings are free and clear from debris.

Cleaning the Stainless Steel Cook Grate

To keep your grill operating properly, the stainless steel cook grate should be cleaned

regularly.

1. The stainless steel cook grate can be easily cleaned after the post-heating period.

As soon as the 10 minutes post-heating is completed, turn the gas off. Open the lid

with a covered hand and with the use of a brass brush, rub the grid surface.

The Ducane

stainless steel cook grate has been constructed of strong, sturdy stainless

steel. You will ﬁ nd this cooking surface to be extremely durable while providing more

heat directly to your cooking surface for faster, more economical cooking.

Cleaning the Heat Distribution Plates

Your stainless steel heat distribution plates should also be brushed down with the use of

a brass long-handled brush.

Cleaning the Burner Box

Clean when cook grate and heat distribution plates are removed from burner box.

Clean out any ash or deposits from burner box using warm soapy water and a soft

cloth. Allow to dry before replacing all parts.

A small amount of grease may accumulate on the bottom of the burner box. It can be

scraped up and discarded with a ﬂ at-blade putty knife. Use a soap and water solution

to clean after you have scraped.

Prolonged grilling with the hood in the down position may cause a grease build up in-

side the hood that will begin to ﬂ ake (this is not paint). If this develops, clean the inside

of the hood with a warm water and soap solution. Be careful not to get the burner wet.

Preserve Your Cabinet, Control Panel and Shelf/Shelves

Your cabinet, control panel and shelves are made from stainless steel. To keep the

stainless steel looking its best is a simple matter. Clean it with soap and water, rinse with

clear water and wipe dry. It’s that easy. We recommend the use of a diluted liquid dish-

washing detergent and water solution. For stubborn particles, the use of a non-metallic

brush can be used. Do not use a wire brush on your cooking shelf.

 CAUTION: Do not use a wire brush or abrasive cleaners on

the lid, cabinet and shelves of your grill as this will scratch

the surface.

 CAUTION: When cleaning surfaces be sure to rub in the

direction of the grain to preserve the look of your stainless

steel.

Grease Fires

The recommendations in the Maintenance section, concerning cleaning our grill, and

in the Normal Operation section concerning preheating and post-heating your grill are

extremely important for two reasons:

1. Keep your grill cooking at its best by keeping the cooking surfaces and heat trans-

mitting components clean. Keeping your grill clean is the best way of keeping your

grill cooking properly.

2. For safety reasons. A dirty grill is susceptible to grease ﬁ res.

Depending on the amount of cooking, the types of food cooked, the amount of pre-

heating and post-heating and the amount of cleaning performed on a grill, any grill

can be susceptible to a grease ﬁ re. A build up of meat fats, cooking marinades, basting

sauces, salts, etc. can ignite and cause a severe grease ﬁ re.

If a grease ﬁ re were to occur on a Ducane

grill, ﬂ ames would probably be seen under

the burner box. A severe grease ﬁ re could lead to a burned hose or regulator which

would allow gas to feed the ﬁ re and, obviously, make the ﬁ re worse.

Any type of ﬁ re requires that the grill components (hose, regulators, LP tanks, etc...)

involved be checked for continued safe operation. If a leak is suspected, the gas supply

system (hose, manifold, tank, ﬁ ttings, etc...) must be leak tested, using a soapy water

solution, to verify the source of the leak. If no leak is found, then the problem was most

likely a grease ﬁ re.

A grease ﬁ re can be severe enough to damage your grill and/or cause property damage

and/or cause bodily harm. Ducane does not want this to happen and neither do you.

Follow our cleaning recommendations to avoid grease ﬁ res.

 WARNING: Check the grease tray for grease build-up before

each use. Remove excess grease to avoid a grease ﬁ re.

20 www.ducane.com

ANNUAL MAINTENANCE

Inspection and Cleaning of the Spider/Insect Screens

To inspect the Spider/Insect screens.

1. Turn “OFF” gas at source.

2. Remove the cooking grate and the heat distribution plates, exposing the burner

tubes.

3. Remove the two(2) screws and washers holding each

valve to the control panel and control knob bezel.

4. Loosen the control panel by removing two(2) screws

on each end.

5. Pull control panel away from grill a few inches.

Disconnect wire from the electronic igniter for the

rotisserie burner.

La page charge ...

Ducane 30400043 Le manuel du propriétaire

Marque: Ducane

Modèle: 30400043

Catégorie: Barbecues

Taper: Le manuel du propriétaire

Ce manuel convient également à

Télécharger le PDF

rapport

dans d''autres langues

English: Ducane 30400043 Owner's manual

Ducane 30400043 Le manuel du propriétaire

Ce manuel convient également à

Ducane 30400043 Le manuel du propriétaire

dans d''autres langues

Documents connexes