Faber MAES3618SS1200B Guide d'installation

Faber
Marque
Faber
Modèle
MAES3618SS1200B
Taper
Guide d'installation

Ce manuel convient également à

MAES3018SS600-B
MAES3618SS600-B
Installation Instructions
Use and Care Information
Instructions d'installation
Utilisez et d'entretien
MAESTRALE 18"
MAES3618SS1200-B
MAES4218SS1200-B
MAES4818SS1200-B
2
READ AND SAVE THESE INSTRUCTIONS BEFORE YOU START
INSTALLING THIS RANGEHOOD
WARNING: - TO REDUCE THE RISK OF A RANGE TOP GREASE FIRE:
a) Never leave surface units unattended at high settings. Boilovers cause smoking and
greasy spillovers that may ignite. Heat oils slowly on low or medium setting.
A KV@XRSTQMGNNC.-VGDMBNNJHMF@SGHFGGD@SNQVGDMl@LADHMFENNCHD"QDODR
Suzette, Cherries Jubilee, Peppercorn Beef Flambé).
c) Clean ventilating fans frequently. Grease should not be allowed to accumulate on fan
NQkKSDQ
d) Use proper pan size. Always use cookware appropriate for the size of the surface element.
WARNING: - TO REDUCE THE RISK OF INJURY TO PERSONS IN THE EVENT OF A
RANGE TOP GREASE FIRE, OBSERVE THE FOLLOWING*:
@2,.3'$1%+ ,$2VHSG@BKNRDkSSHMFKHCBNNJHDRGDDSNQLDS@KSQ@XSGDMSTQMNEESGDATQMDQ
!$" 1$%4+3./1$5$-3!41-2(ESGDl@LDRCNMNSFNNTSHLLDCH@SDKX$5 "4 3$
AND CALL THE FIRE DEPARTMENT.
b) NEVER PICK UP A FLAMING PAN - You may be burned.
c) DO NOT USE WATER, including wet dishcloths or towels - a violent steam explosion will
result.
d) Use an extinguisher ONLY if:
1. You know you have a Class ABC extinguisher, and you already know how to operate it.
 3GDkQDHRRL@KK@MCBNMS@HMDCHMSGD@QD@VGDQDHSRS@QSDC
 3GDkQDCDO@QSLDMSHRADHMFB@KKDC
 8NTB@MkFGSSGDkQDVHSGXNTQA@BJSN@MDWHS
* Based on "Kitchen Firesafety Tips" published by NFPA
WARNING - TO REDUCE THE RISK OF FIRE OR ELECTRIC SHOCK, do not use this
fan with any solid-state speed control device.
WARNING - TO REDUCE THE RISK OF FIRE, ELECTRICAL SHOCK, OR INJURY TO
PERSONS, OBSERVE THE FOLLOWING:
1. Use this unit only in the manner intended by the manufacturer. If you have any
questions, contact the manufacturer.
2. Before servicing or cleaning unit, switch power off at service panel and lock the
service disconnecting means to prevent power from being switched on acciden-
tally. When the service disconnecting means cannot be locked, securely fasten a
prominent warning device, such as a tag, to the service panel.
CAUTION: For General Ventilating Use Only. Do Not Use To Exhaust Hazardous or
Explosive Materials and Vapors.
WARNING - TO REDUCE THE RISK OF FIRE, ELECTRICAL SHOCK, OR INJURY TO
PERSONS, OBSERVE THE FOLLOWING:
1. (MRS@KK@SHNM6NQJ MC$KDBSQHB@K6HQHMF,TRS!D#NMD!X0T@KHkDC/DQRNMR(M BBNQ-
dance With All Applicable Codes And Standards, Including Fire-Rated Construction.
2. 2TEkBHDMS@HQHRMDDCDCENQOQNODQBNLATRSHNM@MCDWG@TRSHMFNEF@RDRSGQNTFG
SGDlTDBGHLMDXNEETDKATQMHMFDPTHOLDMSSNOQDUDMSA@BJCQ@ESHMF%NKKNVSGD
heating equipment manufacturer's guideline and safety standards such as those
OTAKHRGDCAXSGD-@SHNM@K%HQD/QNSDBSHNM RRNBH@SHNM-%/@MCSGD LDQHB@M
2NBHDSXENQ'D@SHMF1DEQHFDQ@SHNM@MC HQ"NMCHSHNMHMF$MFHMDDQR 2'1 $@MC
the local code authorities.
3
ALL WALL AND FLOOR OPENINGS WHERE THE RANGEHOOD IS INSTALLED MUST
BE SEALED.
This rangehood requires at least 24" of clearance between the bottom of the rangehood and
the cooking surface or countertop. This hood has been approved by UL at this distance from
the cooktop. Overhead cabinets on both sides of this unit must be a minimum of 18" above the
cooking surface or countertop. Consult the cooktop or range installation instructions given by
the manufacturer before making any cutouts. MOBILE HOME INSTALLATION The installation
of this rangehood must conform to the Manufactured Home Construction and Safety Standards,
Title 24 CFR, Part 3280 (formerly Federal Standard for Mobile Home Construction and Safety,
Title 24, HUD, Part 280). See Electrical Requirements.
• Venting system MUST terminate outside the home.
• DO NOT terminate the ductwork in an attic or other enclosed space.
• DO NOT use 4" laundry-type wall caps.
• Flexible-type ductwork is not recommended.
• DO NOTNARSQTBSSGDkNVNEBNLATRSHNM@MCUDMSHK@SHNM@HQ
q%@HKTQDSNENKKNVUDMSHMFQDPTHQDLDMSRL@XQDRTKSHM@jQD
WARNING
!
Cold Weather installations
M@CCHSHNM@KA@BJCQ@ESC@LODQRGNTKCADHMRS@KKDCSNLHMHLHYDA@BJV@QCBNKC@HQkNV@MC@
nonmetallic thermal break should be installed to minimize conduction of outside temperatures as
part of the vent system. The damper should be on the cold air side of the thermal break. The break
should be as close as possible to where the vent system enters the heated portion of the house.
VENTING REQUIREMENTS
Determine which venting method is best for your application. Ductwork can extend either through the
wall or the roof.
3GDKDMFSGNESGDCTBSVNQJ@MCSGDMTLADQNEDKANVRRGNTKCADJDOSSN@LHMHLTLSNOQNUHCDDEjBHDMS
performance. The size of the ductwork should be uniform. Do not install two elbows together. Use
CTBSS@ODSNRD@K@KKINHMSRHMSGDCTBSVNQJRXRSDL4RDB@TKJHMFSNRD@KDWSDQHNQV@KKNQkNNQNODMHMF
around the cap.
Flexible ductwork is not recommended. Flexible ductwork creates back pressure and air turbulence
that greatly reduces performance.
,@JDRTQDSGDQDHROQNODQBKD@Q@MBDVHSGHMSGDV@KKNQkNNQENQDWG@TRSCTBSADENQDL@JHMFBTSNTSR
Do not cut a joist or stud unless absolutely necessary. If a joist or stud must be cut, then a supporting
frame must be constructed.
WARNING - To Reduce The Risk Of Fire, Use Only Metal Ductwork.
" 43(.-3NQDCTBDQHRJNEkQD@MCSNOQNODQKXDWG@TRS@HQADRTQDSNCTBS@HQNTSRHCDm#N
not vent exhaust air into spaces within walls or ceilings or into attics, crawl spaces, or garages.
3. When cutting or drilling into wall or ceiling, do not damage electrical wiring and
other hidden utilities.
4. Ducted fans must always be vented to the outdoors.
4
• Electrical ground is required on this rangehood.
• If cold water pipe is interrupted by plastic, nonmetallic gaskets or other materials, DO
NOT use for grounding.
• DO NOT ground to a gas pipe.
• DO NOT have a fuse in the neutral or grounding circuit. A fuse in the neutral or
grounding circuit could result in electrical shock.
q"GDBJVHSG@PT@KHjDCDKDBSQHBH@MHEXNT@QDHMCNTAS@RSNVGDSGDQSGDQ@MFDGNNCHR
properly grounded.
q%@HKTQDSNENKKNVDKDBSQHB@KQDPTHQDLDMSRL@XQDRTKSHM@jQD
WARNING
5
1 MOTOR - RANGEHOOD DIMENSIONS
1 MOTOR - RANGEHOOD DIMENSIONS WITH OPTIONAL FULL CHIMNEY
1 MOTOR - RANGEHOOD DIMENSIONS WITH OPTIONAL TELESCOPIC CHIMNEY
6
2 MOTOR - RANGEHOOD DIMENSIONS
2 MOTOR - RANGEHOOD DIMENSIONS WITH OPTIONAL FULL CHIMNEY
2 MOTOR - RANGEHOOD DIMENSIONS WITH OPTIONAL TELESCOPIC CHIMNEY
7
2 MOTOR RANGEHOOD REAR INFORMATION
1 MOTOR RANGEHOOD REAR INFORMATION
8
MAIN PARTS 1 MOTOR RANGEHOOD
Components
Ref. Qty. Product Components
1 1 Hood Body, complete with: Con-
trols, Light, Filters, Blower.
10 1 Damper ø 5 7/8"
Ref. Qty. Installation Components
12a 2 Wall plug
14 6 Screws 3/16" x 1 15/16"
Qty. Documentation
1 Instruction Manual
10
1
12a
14
MAIN PARTS 2 MOTOR RANGEHOOD
Components
Ref. Qty. Product Components
1 1 Hood Body, complete with: Con-
trols, Light, Filters, Blower.
10 2 Damper ø 5 7/8"
Ref. Qty. Installation Components
12a 2 Wall plug
14 6 Screws 3/16" x 1 15/16"
Qty. Documentation
1 Instruction Manual
10
1
12a
14
9
Available Accessories
Parts needed
- 6" Round Metal ductwork .
Direct Connect Wiring Box sku # number: WIREBOX
30" Full Width Chimney Duct Cover - sku#FULL30
36" Full Width Chimney Duct Cover - sku#FULL36
42" Full Width Chimney Duct Cover - sku#FULL42
48" Full Width Chimney Duct Cover - sku#FULL48
Telescopic Chimney Duct Cover - TELEMAES
CFM Reducer Accessory Kit - CFMRED
Vent Grate Kit 30" - DUCTGRT30
Vent Grate Kit 36" - DUCTGRT36
6" Make-Up Air Damper - MUDAMPER6
8" Make-Up Air Damper - MUDAMPER8
Activated Charcoal Filter sku #; FILTER1
Min. 24"
10
Install Damper that is included with the
Hood before connecting to the ductwork.
One for 1 motor model.
Two for 2 motor model.
8VHKDQGVWRUHPRYH¿OWHUV7XUQWKHNQREWRWKHOHIWFRXQWHUFORFNZLVHWR
UHOHDVH¿OWHU5HSHDWZLWKRWKHU¿OWHU5HLQVWDOOWKH¿OWHUE\SODFLQJWKHEDFNHGJH
LQWKHFKDQQHODWUHDURIKRRG3XVK¿OWHULQWRSODFHWXUQWKHNQREWRWKHULJKW
FORFNZLVHWRDWWDFKWRUDQJHKRRG5HSHDWZLWKRWKHU¿OWHU
!@ElD%HKSDQ1DLNU@K
Removal / Déplacement
Removal

H
I

H
I

H
I
11
Ducted Venting Options Installation
Horizontal
Vertical
6"
6"
Rear
6"
Ducting Methods
12
Rear Ducted Installation for 1 motor Rangehood


The Electrical Connector must be
UHPRYHG¿UVWEHIRUHFRQYHUWLQJWKH
hood to Rear Ducting mode.
For a rear ducting installation the
PRWRUQHHGVWREHXQVHFXUHGE\¿UVW
removing the 12 screws as shown.
2QFHWKHVFUHZVDUHUHPRYHG
extract the blower from the body
of the Hood and position it so the
transition opening is facing to the
UHDUZDOOIURPWKHEDFNUHPRYHDQG
URWDWHGHJUHHVWRWKHOHIWDQG
WKHQÀLSLWEDFNGHJUHHVDVVKRZQ
LQWKHGLDJUDP
Once the blower is in place re-install
the 12 screws to fasten the motor to
the Hood body.
Disconnect the Electrical Connector
by depressing the tabs with your
hand and also using light force on
RQHWDEZLWKDÀDWKHDGVFUHZGULYHU
Reconnect the Connector to the
blower.
13
Rear Ducted Installation for 2 motor Rangehood


The Electrical Connector must be
UHPRYHG¿UVWEHIRUHFRQYHUWLQJWKH
hood to Rear Ducting mode.
The Electrical Connector is always
on the left of left Motor Group.
For a rear ducting installation the
PRWRUQHHGVWREHXQVHFXUHGE\¿UVW
removing the 16 screws as shown.
2QFHWKHVFUHZVDUHUHPRYHG
extract the blower from the body
of the Hood and position it so the
transition opening is facing to the
UHDUZDOOIURPWKHEDFNUHPRYHDQG
URWDWHGHJUHHVWRWKHOHIWDQG
WKHQÀLSLWEDFNGHJUHHVDVVKRZQ
LQWKHGLDJUDP
Once the blower is in place re-install
the 16 screws to fasten the motor to
the Hood body.
'LVFRQQHFWWKH(OHFWULFDO&RQQHFWRU
one from the left motor goup and
RQHIURPWKHULJKWPRWRU*USRXSE\
depressing the tabs with your hand and
also using light force on one tab with a
ÀDWKHDGVFUHZGULYHU
Reconnect the Connector to the
blower.
Attention: The longhest cable with
connector is always for Left motor
*URXSDQGWKHVKRUWHVWFDEOHZLWK
connector is always for Right motor
Group.
Reconnect the Electrical Connector
on the left of left Motor Group.
14
RECIRCULATION INSTRUCTIONS
Note: It is recommended that pro-
fessional style cooking always be
vented to the outside; for recirculat-
ing Installations, some duct work is
required to exhaust the unit out of
the cabinet.
RECIRCULATING INSTALLATIONS
)RUUHFLUFXODWLQJLQVWDOODWLRQV&KDUFRDO)LOWHUVDUHQHFHVVDU\5HPRYHDOOJUHDVH¿OWHUV
DQGVHWDVLGH$WWDFKRQHFKDUFRDO¿OWHUWRHDFKHQGRIWKHEORZHU(DFKFKDUFRDO¿OWHU
DWWDFKHVWRWKHJULGRQWKHVLGHRIWKHEORZHU5RWDWHWKH¿OWHUFORFNZLVHWRLQVWDOODQG
FRXQWHUFORFNZLVHWRUHPRYH),*85(&5HSODFHDOOJUHDVH¿OWHUV
There are 2 ways to recirculate the Maestrale:
8VHWKH'XFWOHVV5HFLUFXODWLQJ.LW(sold separately)UHIHUWRLQVWDOODWLRQLQVWUXFWLRQV
LQVLGHWKH5HFLUFXODWLQJ.LWZKLFKLQFOXGHVFKDUFRDO¿OWHUV
'8&7*57
'8&7*57
6RPHGXFWZRUNPXVWEHLQVWDOOHGWRH[KDXVWWKHUDQJHKRRGEDFNLQWRWKHNLWFKHQ
HLWKHUDWWKHWRSRIWKHFDELQHW),*85($RUDWWKHIDFHRUVLGHRIWKHVRI¿W),*85(
%,QVWDOODWOHDVWRIPHWDOGXFW¿J$DQG%DWWKHDLUH[LW5XQWKHGXFWYHUWLFDOO\
DQGVHFXUHLWDWWKHRSHQLQJFXWRXWDWWKHWRSRUVLGHRIWKHFDELQHWRUVRI¿W,QVWDOODWLRQ
of metal grill is recommended. This duct work must not terminate into a dead air space.
FILTER1 must be purchased to complete this type of installation.
upper
cabinet
upper
cabinet
rangehood rangehood
open space
HQFORVHGVRI¿W
cooking surface cooking surface
15
Installation for Mounting on the Wall
==
Min. 24"
Installation Instruction for mounting on the Wall
Draw a vertical line on the supporting wall
DVKLJKDVSUDFWLFDODWWKHFHQWHURIWKH
area in which the hood will be installed.
Draw a horizontal line at where the bottom
edge of the hood will be located as indicated
LQWKH¿JXUHWKDWLVDPLQLPXPRIDERYH
cooking surface
1
16
2
´
[
[
24”
24”
L
/ ´´
´´
16 13/16”
0DUNWKHZDOOZKHUHLQGLFDWHG13/16" above the horizontal line and at L distance on the left and
right of vertical line. The distance L change for all dimension of Hood.
,QVHUWWKHWZRZDOOSOXJVLQWKHKROHVDVVKRZQDQG¿[
Installation for 1 Motor Rangehood
Installation for 2 Motor Rangehood
´
[
[
24”
24”
L
/ ´´´
´´´
16 13/16”
0DUNWKHZDOOZKHUHLQGLFDWHG13/16" above the horizontal line and at L distance on the left and
right of vertical line. The distance L change for all dimension of Hood.
,QVHUWWKHWZRZDOOSOXJVLQWKHKROHVDVVKRZQDQG¿[
17
3
4
E
E
Hook the hood body onto the wall plugs. Use a level to insure that Fixing Bracket is
level and then fully secure the two screws.
5
´
[
[
[
Mark the wall where indicated.
'ULOOGLUHFWO\LQWR¡KROHVDWDOOWKHFHQWHUSRLQWVPDUNHG
Insert the purchased wall plugs in the holes.
Using thhe remaining screws to anchor the hood in holes.
,I\RXULQVWDOODWLRQXVHVWKHRSWLRQDOGXFWFRYHU¿WWKHFRYHUÀDQJHVRYHUWKHEUDFNHWV,I
LQVWDOODWLRQXVHVWKHWHOHVFRSLFFKLPQH\H[WHQVLRQ¿WWKHH[WHQVLRQRYHUWKHEUDFNHWV,QVWDOOWKH
XSSHUVHFWLRQ¿UVWWKHQ¿WWKHORZHUVHFWLRQRYHUWKHXSSHUVHFWLRQ6HDOH[WHQVLRQWRKRRGZLWK
clamps.
18
Installation Instruction for Mounting Under the Cabinet
Lift the hood to the cabinet.
[
Fix the Hood Body with 4 screws from the bottom.
´
[
[
[
Mark the wall where indicated.
'ULOOGLUHFWO\LQWR¡KROHVDWDOOWKHFHQWHU
points marked.
Insert the purchased wall plugs in the
holes.
Using two remaining screws to anchor
the hood in holes.
1
2
3
19
A: Distance from center of mounting bracket to centerline:
INSTALLATION CONTINUED
1. Attach the full-width duct cover to the top of the range hood with the screws provided. The duct
cover must be attached to the top of the range hood before mounting the range hood to the wall.
A: Distance from center of mounting bracket to centerline:
KRRG
KRRG
KRRG
KRRG
B: Mounting brackets
C: Top of hood
2. Install each bracket on the wall as shown. Make sure the screws and brackets are securely
fastened to the wall. IMPORTANT: Install only the brackets. Do not install the hood.
Optional Duct Cover Installation
A: Ceiling
B: Brackets
Optional Telescopic Chimney Extension Installation
,IDFKLPQH\H[WHQVLRQLVXVHGDWWDFKWKHH[WHQVLRQEUDFNHWVDVVKRZQ0DNHVXUHWKDWWKH
screws are securely fastened to the wall.
A: Ceiling
B: Brackets
C: Top of hood
20
Direct Connect Wiring Box
Accessory sku # WIREBOX
SXUFKDVHGVHSDUDWHO\
ELECTRICAL INSTALLATION WITH CONNECTION CABLE
ELECTRICAL INSTALLATION WITH
OPTIONAL WIRING BOX
For Permanent wiring Installation-Use only
with Listed rangehood Wiring Box kit
VNX:,5(%2;PDQXIDFWXUHGE\)DEHU
Max. 33 7/16”
GROUNDING INSTRUCTIONS This appliance must
EHJURXQGHG,Q WKH HYHQW RI DQHOHFWULFDOVKRUWFLUFXLW
grounding reduces the risk of electric shock by providing
an escape wire for the electric current. This appliance
is equipped with a cord having a grounding wire with a
grounding plug. The plug must be plugged into an outlet
that is properly installed and grounded.
WARNING - Improper grounding can result in a risk of
electric shock.
&RQVXOWDTXDOL¿HGHOHFWULFLDQLIWKHJURXQGLQJLQVWUXFWLRQV
DUHQRW FRPSOHWHO\ XQGHUVWRRGRU LI GRXEW H[LVWVDV WR
whether the appliance is properly grounded.
Do not use an extension cord. If the power supply cord
LVWRRVKRUWKDYHDTXDOL¿HGHOHFWULFLDQLQVWDOODQRXWOHW
near the appliance.
5HSODFHWKH¿OWHUVUHPRYHGSUHYLRXVO\
La page charge ...
La page charge ...
La page charge ...
La page charge ...
La page charge ...
La page charge ...
La page charge ...
La page charge ...
La page charge ...
La page charge ...
La page charge ...
La page charge ...
La page charge ...
La page charge ...
La page charge ...
La page charge ...
La page charge ...
La page charge ...
La page charge ...
La page charge ...
La page charge ...
La page charge ...
La page charge ...
La page charge ...
La page charge ...
La page charge ...
La page charge ...
La page charge ...
  • Page 1 1
  • Page 2 2
  • Page 3 3
  • Page 4 4
  • Page 5 5
  • Page 6 6
  • Page 7 7
  • Page 8 8
  • Page 9 9
  • Page 10 10
  • Page 11 11
  • Page 12 12
  • Page 13 13
  • Page 14 14
  • Page 15 15
  • Page 16 16
  • Page 17 17
  • Page 18 18
  • Page 19 19
  • Page 20 20
  • Page 21 21
  • Page 22 22
  • Page 23 23
  • Page 24 24
  • Page 25 25
  • Page 26 26
  • Page 27 27
  • Page 28 28
  • Page 29 29
  • Page 30 30
  • Page 31 31
  • Page 32 32
  • Page 33 33
  • Page 34 34
  • Page 35 35
  • Page 36 36
  • Page 37 37
  • Page 38 38
  • Page 39 39
  • Page 40 40
  • Page 41 41
  • Page 42 42
  • Page 43 43
  • Page 44 44
  • Page 45 45
  • Page 46 46
  • Page 47 47
  • Page 48 48

Faber MAES3618SS1200B Guide d'installation

Faber
Marque
Faber
Modèle
MAES3618SS1200B
Taper
Guide d'installation
Ce manuel convient également à
Télécharger le PDF
rapport

dans d''autres langues

Documents connexes

Autres documents