Windsor Dominator 13 Le manuel du propriétaire

Marque: Windsor

Modèle: Dominator 13

Catégorie: Machine à plancher

Taper: Le manuel du propriétaire

your product

www.kaercher.com/welcome

86399050-D 03/04/20

Dominator 500 PSI 13 Gallon

English 02

From Serial Number (Ref No. 1*)

* See Serial number page or call

manufacturer.

Warranty Registration

Thank you for purchasing a Kärcher North America product. Warranty registration is quick

and easy. Your registration will allow us to serve you better over the lifetime of the product.

To register your product go to :

http://warranty.karcherna.com/

For customer assistance:

1-800-444-7654

86399050 Operators Manual - Dominator 500 PSI 13 gallon

Machine Data Label

Overview

The Dominator is an electric powered carpet extractor intended for commercial use. This appliance applies a

cleaning solution to the carpet and then vacuums the soiled water back into the recovery tank.

MODELS: 1.006-665.0 - NWWU2250H

Table of Contents

Machine Data Label . . . . . . . . . . . . . . . . . . . . . . . . . .2

Overview . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2

Table of Contents . . . . . . . . . . . . . . . . . . . . . . . . . . .3

How To Use This Manual . . . . . . . . . . . . . . . . . . . . .4

Safety

IMPORTANT SAFETY INSTRUCTIONS . . . . . . . . .5

HAZARD INTENSITY LEVEL . . . . . . . . . . . . . . . . . .7

Safety Labels . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .9

Grounding Instructions . . . . . . . . . . . . . . . . . . . . . .10

Operations

Technical Specifications . . . . . . . . . . . . . . . . . . . . .11

Controls. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .12

Machine Operation . . . . . . . . . . . . . . . . . . . . . . . . .13

Chemicals . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .13

Pre-Run Inspection . . . . . . . . . . . . . . . . . . . . . . . . .14

Equipment Set-up . . . . . . . . . . . . . . . . . . . . . . . . . .14

Heater Operation . . . . . . . . . . . . . . . . . . . . . . . . . .14

Maintenance

Periodic Maintenance . . . . . . . . . . . . . . . . . . . . . . .16

Daily/Regular Maintenance. . . . . . . . . . . . . . . . . . .16

Vacuum Motor Replacement . . . . . . . . . . . . . . . . .17

Solution Pump Replacement . . . . . . . . . . . . . . . . .18

Pressure Regulator . . . . . . . . . . . . . . . . . . . . . . . . .19

Maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .20

Troubleshooting . . . . . . . . . . . . . . . . . . . . . . . . . . .20

Suggested Spare Parts. . . . . . . . . . . . . . . . . . . . . .22

86399050 Operators Manual - Dominator 500 PSI 13 gallon

How To Use This Manual

This manual contains the following sections:

• How to Use This Manual

• Safety

• Operations

• Maintenance

The HOW TO USE THIS MANUAL section will tell you

how to find important information for ordering correct

repair parts.

Parts may be ordered from authorized dealers. When

placing an order for parts, the machine model and

machine serial number are important. Refer to the

MACHINE DATA box which is filled out during the

installation of your machine. The MACHINE DATA box

is located on the inside of the front cover of this manual.

Model:

Date of Purchase:

Serial Number:

Dealer:

Address:

Phone Number:

Sales Representative:

The model and serial number of your machine is

located on the back of the machine.

The SAFETY section contains important information

regarding hazardous or unsafe practices of the

machine. Levels of hazards are identified that could

result in product damage, personal injury, or severe

injury resulting in death.

The OPERATIONS section is to familiarize the operator

with the operation and function of the machine.

The MAINTENANCE section contains preventive main-

tenance to keep the machine and its components in

good working condition. They are listed in this general

order:

• Maintenance

• Lubrication

• Vacuum Motor Replacement

• Solution Pump Replacement

• Troubleshooting

NOTE: If a service or option kit is installed on your

machine, be sure to keep the KIT INSTRUCTIONS

which came with the kit. It contains replacement parts

numbers needed for ordering future parts.

NOTE: The manual part number is located on the

lower right corner of the front cover.

86399050 Operators Manual - Dominator 500 PSI 13 gallon

Safety

IMPORTANT SAFETY INSTRUCTIONS

When using this machine, basic precaution

must always be followed, including the following:

READ ALL INSTRUCTIONS BEFORE USING THIS MACHINE.

To reduce the risk of fire, electric shock, or injury:

Connect to a properly grounded outlet. See Grounding Instructions.

Do not leave the machine unattended. Unplug machine from outlet when not in use and before mainte-

nance or service.

Use only indoors. Do not use outdoors or expose to rain.

Do not allow machine to be used as a toy. Close attention is necessary when used by or near children.

Use only as described in this manual. Use only manufacturer's recommended components and attach-

ments.

Do not use damaged electrical cord or plug. Follow all instructions in this manual concerning grounding

the machine. If the machine is not working properly, has been dropped, damaged, left outdoors, or

dropped into water, return it to an authorized service center.

Do not pull or carry machine by electrical cord, use as a handle, close a door on cord, or pull cord around

sharp edges or corners.

Do not run machine over cord. Keep cord away from heated surfaces.

Do not unplug machine by pulling on cord. To unplug, grasp the electrical plug, not the electrical cord.

Do not handle the electrical plug or machine with wet hands.

Do not operate the machine with any openings blocked. Keep openings free of debris that may reduce

airflow.

This machine is intended for cleaning carpet only.

Do not vacuum anything that is burning or smoking, such as cigarettes, matches, or hot ashes.

This machine is not suitable for picking up health endangering dust.

Turn off all controls before unplugging.

Do not operate this machine near flammable fluids, dust or vapors.

Maintenance and repairs must be done by qualified personnel.

If foam or liquid comes out of machine, switch off immediately.

READ AND SAVE THESE INSTRUCTIONS

86399050 Operators Manual - Dominator 500 PSI 13 gallon

Safety

CONSIGNES IMPORTANTES DE SÉCURITÉ

Lors de l'utilisation d'un appareil électrique, il faut toujours observer des précau-

tions élémentaires,qui comprennent parmi celles-ci :

LISEZ BIEN L'ENSEMBLE DES CONSIGNES AVANT D'UTILISER CET

APPAREIL.

Cette machine est pour l’utilisation commerciale.

Pour réduire les risques d'incendie, d'électrocution ou de

blessure:

Raccordez l'appareil à une prise adéquatement reliée à la terre. Voir les Consignes de mise à la terre.

Ne laissez pas l'appareil sans surveillance lorsqu'il est branché. Débranchez l'appareil lorsqu'il n'est pas utilisé et

avant tout entretien.

Utilisez-le exclusivement dans des endroits fermés. Ne l'utilisez pas en plein air et ne le laissez pas sous la pluie.

Ne pas permettre aux enfants dejouer avec l'appareil. Durant la manoeuvre de la machine, prendre garde aux

personnes environnantes et notamment aux enfants.

Utilisez-le exclusivement de la manière décrite dans ce manuel. Utilisez exclusivement les composants et les

fixations recommandés par le fabricant.

N'utilisez pas l'appareil si le cordon ou la fiche est endommagé(e). Observez toutes les consignes figurant dans ce

manuel au sujet de la mise à la terre de l'appareil. Si l'appareil ne fonctionne pas correctement, s'il est tombé par

terre, s'il est endommagé, s'il a été laissé dehors ou s'il a été plongé dans l'eau, veuillez le renvoyer à un centre

d'entretien agréé.

Ne tirez pas sur le cordon, ne portez pas l'appareil par le cordon, n'utilisez pas le cordon comme poignée, ne

fermez pas une porte sur le cordon, ne tirez pas sur le cordon dans des angles ou des coins pointus.

Ne faites pas passer l'appareil par-dessus le cordon. Maintenez le cordon à l'écart de surfaces chauffées..

Ne débranchez pas l'appareil en tirant sur le cordon. Pour le débrancher, empoignez la fiche, non pas le cordon.

Ne manipulez pas la fiche ou l'appareil les mains mouillées.

Ne faites pas fonctionner l'appareil si des ouvertures sont bouchées. Dégagez des ouvertures tous débris suscep-

tibles d'entraver le passage de l'air.

Cette machine est destinée pour nettoyer le tapis seulement.

Ne pas ramasser quelque chose qui brûle ou fume, comme des cigarettes, des allumettes ou des cendres

chaudes.

Cet appareil n'est pas conçu pour aspirer des poussières dangereuses.

Arrêtez toutes les commandes avant le débranchement.

Ne faites pas fonctionner cet appareil à proximité de fluides, de poussières ou de vapeurs inflammables.

Les travaux de maintenance et de réparation doivent absolument être effectués par du personnel qualifié.

Si de la mousse ou du liquide s'échappe de la machine, éteignez-la immédiatement.

CONSERVEZ CES CONSIGNES

86399050 Operators Manual - Dominator 500 PSI 13 gallon

Safety

The following symbols are used throughout this guide as indicated in their descriptions:

HAZARD INTENSITY LEVEL

There are three levels of hazard intensity identified by signal words -WARNING and CAUTION and FOR

SAFETY. The level of hazard intensity is determined by the following definitions:

WARNING - Hazards or unsafe practices which COULD result in severe personal injury or death.

CAUTION - Hazards or unsafe practices which could result in minor personal injury or product or

property damage.

FOR SAFETY: To Identify actions which must be followed for safe operation of equipment.

Report machine damage or faulty operation immediately. Do not use the machine if it is not in proper

operating condition. Following is information that signals some potentially dangerous conditions to the

operator or the equipment. Read this information carefully

. Know when these conditions can exist. Locate

all safety devices on the machine. Please take the necessary steps to train the machine operating

personnel.

FOR SAFETY:

DO NOT OPERATE MACHINE:

Unless Trained and Authorized.

Unless Operation Guide is Read and understood.

In Flammable or Explosive areas.

In areas with possible falling objects.

WHEN SERVICING MACHINE:

Avoid moving parts. Do not wear loose clothing; jackets, shirts, or sleeves when working on the

machine. Use only manufacturer approved replacement parts.

86399050 Operators Manual - Dominator 500 PSI 13 gallon

Safety

Les symboles ci-dessous sont utilisés à travers ce manuel comme illustré dans leurs descriptions :

DEGRÉS DE RISQUES EN CAS DE DANGER

Il existe trois degrés de risques identifiés par les termes signalétiques -AVERTISSEMENT et

ATTENTION et POUR VOTRE SÉCURITÉ. Le degré de risque est défini de la manière suivante :

AVERTISSEMENT - Dangers ou méthodes dangereuses qui POURRAIENT provoquer de graves

blessures ou entraîner la mort.

ATTENTION - Dangers ou méthodes dangereuses qui pourraient provoquer des blessures légères ou

une détérioration du produit ou des biens immobiliers.

POUR VOTRE SÉCURITÉ : ce signe permet d'identifier les mesures de précaution à prendre pour

assurer un bon fonctionnement du matériel.

Rendre compte immédiatement d'une défaillance ou d'une détérioration de la machine. Ne pas utiliser la

machine si celle-ci ne fonctionne pas correctement. Lire soigneusement les informations ci-dessous

signalant certains dangers potentiels pour l'opérateur de la machine. L'opérateur doit être absolument au

courant de ces dangers potentiels. Localiser tous les dispositifs de sécurité sur la machine. Il est

conseillé de prendre les mesures nécessaires pour former le personnel opérateur.

POUR VOTRE SÉCURITÉ :

NE PAS MANOEUVRER LA MACHINE :

Lorsqu'on n'est pas expérimenté ou qualifié.

Lorsque le guide d'utilisation n'est pas été lu ou compris.

Dans des zones inflammables ou explosives.

Dans des zones où des objets peuvent tomber.

LORS DE L'ENTRETIEN DE LA MACHINE :

Éviter les parties amovibles. Ne pas porter de vêtements amples, tels que des vestes, des

chemises ou des vêtements avec manches lors de l'utilisation de la machine. Utiliser les pièces

détachées homologuées.

86399050 Operators Manual - Dominator 500 PSI 13 gallon

Safety

Safety Labels

NOTE: These drawings indicate the location of safety labels on the machine. If at any time the labels become

illegible, promptly replace them.

LABEL CIRCUIT INTERRUPTER

86200570

LABEL WARNING

86244300

WARNING

AVERTISSEMENT

RISK OF FIRE OR EXPOSION. DO NOT

USE OR PICKUP FLAMMABLE LIQUIDS.

RISQUE D’INCENDIE OU D'EXPLOSION.

NE PAS UTILISER OU RAMASSER DE

LIQUIDES IMFLAMMABLES.

WARNING!

FOR YOUR PROTECTION USE A

GROUND FAULT CIRCUIT INTERRUPTER

AVERTISSEMENT!

POUR VOTRE PROTECTION, UTILISEZ

UN DISJONCTEUR DE FUITE À LA TERRE.

86399050 Operators Manual - Dominator 500 PSI 13 gallon

Safety

Grounding Instructions

THIS PRODUCT IS FOR COMMERCIAL

USE ONL

ELECTRICAL:

In the USA this machine operates on a standard 15

amp 115V, 60 hz, A.C. power circuit. The amp, hertz,

and voltage are listed on the data label found on each

machine. Using voltages above or below those

indicated on the data label will cause serious damage

to the motors.

EXTENSION CORDS:

If an extension cord is used, the wire size must be at

least one size larger than the power cord on the

machine, and must be limited to 50 feet (15.5m) in

length.

GROUNDING INSTRUCTIONS:

This appliance must be grounded. If it should malfunc-

tion or break down, grounding provides a path of least

resistance for electric current to reduce the risk of

electric shock. This appliance is equipped with a cord

having an equipment-grounding conductor and

grounding plug. The plug must be inserted into an

appropriate outlet that is properly installed and

grounded in accordance with all local codes and ordi-

nances.

This appliance is for use on a nominal 120-volt circuit,

and has a grounded plug that looks like the plug in "Fig.

A". A temporary adapter that looks like the adapter in

"Fig. C" may be used to connect this plug to a 2-pole

receptacle as shown in "Fig. B", if a properly grounded

outlet is not available. The temporary adapter should

be used only until a properly grounded outlet (Fig. A)

can be installed by a qualified electrician. The green

colored rigid ear, lug, or wire extending from the

adapter must be connected to a permanent ground

such as a properly grounded outlet box cover.

Whenever the adapter is used, it must be held in place

by a metal screw.

Improper connection of the equipment-grounding

conductor can result in a risk of electric shock.

Check with a qualified electrician or service person

if you are in doubt as to whether the outlet is

properly grounded. Do not modify the plug

provided with the appliance - if it will not fit the

outlet, have a proper outlet installed by a qualified

electrician.

Le raccordement incorrect du conducteur de terre

d'équipement peut entraîner des risques d'électro-

cution. Vérifiez auprès d'un électricien qualifié ou

d'un responsable de l'entretien si vous avez

quelque doute que ce soit quant au raccordement à

la terre de votre prise murale. Ne modifiez pas la

fiche fournie avec l'appareil : si elle ne correspond

pas à la prise murale, faites installer une prise

adéquate par un électricien qualifié.

86399050 Operators Manual - Dominator 500 PSI 13 gallon

Operations

Technical Specifications

MODEL ITEM MEASURE

ALL

Electrical 115 Volt, 60 hz, 15A

Solution Pump 500 psi

Solution Capacity 13 Gal

Recovery Capacity 11 Gal

Height 43 inches

Length 30 inches

Width 22 inches

10066650

Vacuum Motor Dual 2 Stage

Weight- Empty 134 lbs

Weight-Full Solution 239 lbs

Power cord 2 X 25 feet

Heater 1850 watts

10066660

Vacuum Motor Single 3 Stage

Weight- Empty 115 lbs

Weight-Full Solution 220 lbs

Power cord 1 X 25 feet

10066690

Vacuum Motor Single 3 Stage

Weight- Empty 117 lbs

Weight-Full Solution 222 lbs

Power cord 1 X 40 feet in-line GFCI

86399050 Operators Manual - Dominator 500 PSI 13 gallon

Operations

Controls

1. Vacuum Accessory Tool Hook-up

2. Solution Pump Switch

3. Vacuum 1 Switch

4. Vacuum 2 Switch (Dual Vacuum Units Only)

5. Heater Switch with On Light (Units w/Heat Only)

6. Pressure Gauge

7. Adjustable Pressure Relief Valve

8. Heater Temperature Light (Units w/Heat Only)

9. Breaker for Vacuum 2 (Dual Vacuum Units Only)

10. Breaker for Vacuum 1

11. Solution Accessory Tool Hook-up

86399050 Operators Manual - Dominator 500 PSI 13 gallon

With Heat

Operations

Machine Operation

Care must be exercised in the use of all chemicals.

Chemicals are poisonous and can pose a health

risk. Read and follow manufacturers instructions

regarding dangers and correct usages.

ll faut être prudent en utilisant des produits

chimiques. Les produits chimiques sont toxiques

et peuvent présenter un risque pour la santé. Lisez

et suivez les instructions du fabricant concernant

les dangers et les usages corrects.

The internal parts of the pump used in the machine

are suitable for use with most carpet cleaning

chemicals. But they are susceptible to chemical

attack from some cleaning substances, such as

hydrocarbon solvents and chlorinated bleaches.

These non-compatible materials are not of the type

used for carpet cleaning.

Les pièces internes de la pompe utilisée dans la

machine peuvent être utilisées avec la plupart des

produits chimiques de nettoyage des tapis. Mais

elles sont sensibles à l'attaque chimique de

certains produits de nettoyage, tels que les

solvants hydrocarbonés et les décolorants chlorés.

Ces matériaux non compatibles ne sont pas du

type utilisé pour le nettoyage des tapis.

Chemicals

Suitable Chemicals

• Alkalis

• Detergents

• Hydroxides

• Soaps

• Vinegar

Non-Compatible

• Aldehydes

• Aromatics Hydrocarbons

• SP Butyls

• Carbon Tetrachloride

• Clorox*

• Chlorinated Bleaches

• Chlorinated Hydrocarbons

• Lysol*

• Methyl Ethel Ketone (MEK)

• Perchorethylene (perc)

• Phenolics

• Trichlorethylene

• D-Limonene

*Registered Trademarks

Only use chemicals approved for use with this

machine. Use of non-compatible chemicals may cause

machine damage and will not be covered under the

warranty. Carefully read ingredients on manufacturer’s

label before using any product in this machine.

Do not let pump run dry.

Ne pas laisser la pompe fonctionner à sec.

Do not let pump run unattended.

Ne pas laisser la pompe fonctionner sans surveil-

lance.

86399050 Operators Manual - Dominator 500 PSI 13 gallon

Operations

Pre-Run Inspection

1. Check all fittings and connectors for proper

assembly.

2. Check all hoses for leaks. Repair or replace any

damaged hoses.

3. Check power cord(s) for any damage. If damaged,

replace.

Equipment Set-up

1. Plug power cord from machine into properly

grounded wall outlet.

2. Turn vacuum motor switch on and off to make sure

there is electrical power at machine.

3. Using a clean container, fill the solution tank with

clean hot water. Do not use water over 130°F. Mix

in a non-foaming cleaning concentrate for use in

hot water extraction machines, following the manu-

facturer's instructions printed on container.

4. Connect priming hose to solution fitting on

machine. Turn on pump and run for 30 seconds or

until a steady flow of water is coming out of priming

hose. Turn off pump and disconnect priming hose.

5. Connect vacuum hose to machine. Slide the swivel

cuff over the outlet on the tank.

6. Connect the hose to your machine and wand. Pull

back the knurled collar on the quick disconnect

coupler and push onto the connection on the

chassis. To avoid leaks, check to be that a positive

connection was made.

NOTE: When using a powder cleaner, pre-mix with

hot water in a clean container before adding to the

solution tank.

7. Turn pump and vacuum switch(es) to the on

position.

Heater Operation

NOTE: Units with Heat Only

The solution fittings on the machine will become

extremely hot during operation. Allow sufficient

time to cool, or run solution through the machine

with the heater turned off before disconnecting or

performing any maintenance on the heater.

Les pièces de fixation de la machine deviennent

très chaudes pendant le fonctionnement. Prévoyez

suffisamment de temps pour refroidir, ou laissez

couler la solution à travers la machine avec le

réchauffeur éteint avant de débrancher ou

d'effectuer toute opération d'entretien sur le

réchauffeur.

1. Plug the two power cords into separate grounded

circuits. The heater draws 15 amps of current.

2. Turn the solution pump ON. Fully prime the

solution system before turning heater on.

3. Turn the heater switch on. The red light on the

heater switch will be on when the heater switch is

on. The red heater temperature light will be on

when the heater is active and will turn off when the

heater reaches maximum temperature.

On initial start-up the heater will take a few minutes to

reach operating temperature.

When turning the pump and heater OFF, make certain

that you turn the heater off FIRST.

86399050 Operators Manual - Dominator 500 PSI 13 gallon

Operations

Always use defoamer if foaming occurs. Foam will

suspend large particles that may damage

vacuum(s) as well as allow liquid into the vacuum

motor(s) without activating the float shutoff.

Utilisez toujours des anti-mousses, en cas de

formation de mousse. La mousse suspendra les

grosses particules qui peuvent endommager l'aspi-

rateur et laissera le liquide s'écouler dans le moteur

de l'aspirateur sans entraîner l'arrêt du flotteur.

1. Prior to cleaning, make certain that the nozzle is

functioning properly.

a. To check, hold the wand about one foot above

the surface to be cleaned and open the wand

valve. A full spray should be observed from the

nozzle.

b. If the nozzle is not showing a full spray pattern,

adjust nozzle for proper pattern, clean, or replace

nozzle.

2. Normally, chemical is applied on the push stroke of

the wand when cleaning. Vacuuming is done on

the pull stroke. For heavily soiled carpets the wand

may be used in a scrubbing manner, applying

chemical in both the push and pull stroke.

3. When cleaning, keep the working opening (wand

mouth) flat on the surface being cleaned. Keep the

wand moving when the valve is open.

4. The shutoff float inside the vacuum tank will

impede the vacuum flow when the vacuum tank is

full. When this occurs, empty the vacuum tank by

opening the dump valve and dispose of the waste

in a proper manner.

5. Once the vacuum tank has been emptied, you may

once again proceed with cleaning

86399050 Operators Manual - Dominator 500 PSI 13 gallon

Maintenance

Periodic Maintenance

Twice a month, flush a white vinegar solution (one

quart vinegar to two gallons of water) or anti-browning

solution (mixed as directed) through the machine. This

will prevent build-up of alkaline residue in the system.

Periodically inspect all hoses, electrical cables and

connections on your machine. Frayed or cracked hoses

should be repaired or replaced to eliminate vacuum or

solution pressure loss. The electrical cable must be

well insulated and cable connector screw kept tight. If

the cable insulation is broken or frayed, repair or

replace immediately. Don't take chances with electrical

fire or shock.

Daily/Regular Maintenance

Before making any repairs or adjustments to the

machine, disconnect the power cords from the

electrical source.

Retirez le cordon d'alimentation de la machine de la

source électrique avant de procéder à des répara-

tions ou des ajustements de la machine.

1. Empty unused cleaning solution from the solution

tank.

2. Inspect and clean filter screen in solution tank.

3. Flush pumping system with 1 to 2 gallons of clean

water.

4. After each use, rinse tank with fresh water. Periodi-

cally inspect the recovery tank and decontaminate

if necessary, using a Hospital Grade Virucide or a

10-1 bleach to water solution. Waste water should

be disposed of properly.

Do not allow machine to freeze.

SERVICE SCHEDULE DAILY WEEKLY QUARTERLY

Check machine for cord damage *

Check recovery dome and gasket for damage and cleanliness *

Check hoses for wear, blockages, or damage *

Check handles, switches, and knobs for damage *

Run one gallon of water through solution system *

Clean out recovery tank and check float valve to make sure it moves freely *

Clean out solution tank and remove and clean vacuum intake screen *

Clean outside of all tanks and check for damage *

Run vacuum motor for at least one minute to allow motor to dry *

Store with dome off tank to allow the tank to dry *

Check all gaskets for wear and leakage *

Check pump pressure; observe spray pattern and check with gauge if

necessary

Check and clean solution screen *

Check cables for fraying *

Check overall performance of machine *

Check vacuum motor carbon brushes *

86399050 Operators Manual - Dominator 500 PSI 13 gallon

Maintenance

Only qualified maintenance personnel are to

perform the following repairs.

Seul le personnel d'entretien qualifié peut effectuer

des réparations.

Vacuum Motor Replacement

1. Turn off all switches and unplug machine.

2. Remove hardware under front of machine to

access component compartment.

3. Remove vacuum motor cover and disconnect

motor wires.

4. Remove the vacuum motor.

5. Reverse process to install vacuum motor

86399050 Operators Manual - Dominator 500 PSI 13 gallon

Maintenance

Solution Pump Replacement

Only qualified maintenance personnel are to perform the following repairs.

Seul le personnel d'entretien qualifié peut effectuer des réparations.

8.756-049.0

Seal and O-Ring Kit

8.756-049.0

86399050 Operators Manual - Dominator 500 PSI 13 gallon

Maintenance

Only qualified maintenance personnel are to perform the following repairs.

Seul le personnel d'entretien qualifié peut effectuer des réparations.

Pressure Regulator

For best results with the pressure regulator, we recommend that you clean and lubricate the piston and u-cup with

Super-lube lubricant monthly or when pressure drop seems excessive.

1. Turn unit off before lubricating.

2. Remove cap, spring and spring retainer plate.

3. With fingertips remove piston and u-cup.

4. Wipe piston and u-cup clean of any film or scale.

5. Lubricate the piston and u-cup with Super-lube.

6. Reassemble regulator.

7. With pump ON, re-adjust pressure regulator for normal operation.

Lubricate U-Cup with Super-lube Monthly.

86399050 Operators Manual - Dominator 500 PSI 13 gallon

Maintenance

Troubleshooting

PROBLEM CAUSE SOLUTION

Loss of Power

Unit not plugged in Connect unit to 3 prong grounded outlet.

Dead electrical circuit Check building circuit breaker or fuse box.

Faulty power cord Replace

Electrical shock

Receptacle not grounded Contact an electrician to check building's wiring

Internal wiring problem

Have a trained service technician check

machine's wiring

Vac motor speed

varies or doesn't run

Vacuum circuit breaker tripped Reset Breaker

Faulty vacuum motor Replace

Faulty switch Replace

Loss of vacuum

Loose vacuum dome Center and seal dome over tank

Crack in dome of poor joint

Replace or repair using acrylic plastic cement

only

Lint or dirt clogging vacuum screen With power off clean screen

Loose cuffs on vacuum hose Tighten cuffs turning counterclockwise

Vac motor seals leaking Replace

Floor tool vac chamber clogged Wash out with hose. Pick lint out with a wire

Vacuum hose damaged Replace

Recovery tank full / Float ball stuck in

the up position

Turn off power, drain recovery tank.

Pump runs no solution

Pump inlet screen plugged Clean inlet screen

Pump not primed Prime pump with priming hose

Internal or external solution line

damaged and leaking

Replace

Pump runs, loss of

pressure

Internal pump components wearing out Replace, see pump kit components

Check valves in pump head for particles

or cuts in seals

Take piston from BPR and lubricate with Super-

lube. If problem still exists change BPR kit

Pump will not run

Faulty switch Replace

Loose wiring Repair or replace

Solution hose fitting

hard to connect

Corrosion on fittings.

Clean with steel wool. Soak in acetic acid (white

vinegar). Lubricate lightly with silicone base

lubricant.

Carpet not getting

clean

Severe soil conditions

Make several passes at right angles to each

other. Use a pre-spray.

Carpet too wet Over saturation

Adjust solution pressure to lower settings. Make

several passes without spray

Carpet browning

Leaving carpet too wet Check for loss of vac pressure

Too much chemical Check label for correct solution concentration

Solution not flowing

properly

Solution hose connection Check for positive connection

Faulty pump Repair or replace

Faulty floor tool valve / Nozzle Repair or replace

Faulty pump switch Repair

86399050 Operators Manual - Dominator 500 PSI 13 gallon

La page charge ...

Windsor Dominator 13 Le manuel du propriétaire

Marque: Windsor

Modèle: Dominator 13

Catégorie: Machine à plancher

Taper: Le manuel du propriétaire

Télécharger le PDF

rapport

dans d''autres langues

English: Windsor Dominator 13 Owner's manual

Windsor Dominator 13 Le manuel du propriétaire

Windsor Dominator 13 Le manuel du propriétaire

dans d''autres langues

Documents connexes

Autres documents