Nexgrill 720-0958AE Mode d'emploi

Marque: Nexgrill

Modèle: 720-0958AE

Catégorie: Barbecues

Taper: Mode d'emploi

Parrilla de gas para exteriores

Instrucciones de operación

Páginas 36-52

FOR OUTDOOR USE ONLY. NOT FOR COMMERCIAL USE.

POUR USAGE EXTÉRIEUR SEULEMENT. À USAGE NON COMMERCIAL.

PARA EXTERIOR SÓLAMENTE. NO PARA USO COMERCIAL.

Questions, problems, missing parts? For replacement part, contact call our customer service

department at 1- 866-984-7455 in USA and 1-800-648-5864 in Canada, language spoken: English,

French, Spanish 8 a.m.-5 p.m., PST. Monday-Friday. [email protected].

• This instruction manual contains important information necessary for the

proper assembly and safe use of the appliance.

• Read and follow all warnings and instructions before assembling and

using the appliance.

• Keep this manual for future reference.

19000757A0

720-0958AE

ITM. / ART. 1900635

2531-18

Outdoor gas grill

operating instruction

Pages 2 – 18

Gril à gaz extérieur

instructions d'opération

Pages 19-35

SERIAL # ____________________ MFG. DATE _____________________ PURCHASE DATE: _____________________

NUMÉRO DE SÉRIE _______________ DATE DE FABRICATION _______________ DATE D'ACHAT _______________

NÚM. DE SERIE ______________ FECHA DE MANUFACTURA ______________ FECHA DE COMPRA ______________

Table of Contents

• Ce manuel d’instructions contient d’importantes informations essentielles à un

assemblage approprié et sécuritaire de l’appareil.

• Lire et respecter tous les avertissements et toutes les instructions avant l’assemblage et

l’utilisation de l’appareil.

• Conserver ce manuel à titre de référence ultérieure.

Des questions, des problèmes, des pièces manquantes? Pour les pièces de rechange, contactez notre

service clientèle au 1-866-984-7455 aux États-Unis et 1-800-648-5864 au Canada. Langues parlées : anglais,

français, espagnol entre 8 h et 17 h, HNP, du lundi au vendredi. [email protected].

• El presente manual de instrucciones contiene información importante que lo ayudará a

armar el dispositivo correctamente y a utilizarlo de manera segura.

• Antes de armar y utilizar el dispositivo, lea y siga todas las advertencias e instrucciones.

• Conserve el presente manual para consultas futuras.

¿Consultas, problemas, piezas que faltan? Para obtener un reemplazo del product. Porfavor, llame al

Departamento de Servicio al Cliente al 1-866-984-7455 en los E.U. y 1-800-648-5864 en Canada. Lenguages

ablados : Ingles, Frances, y Espanol de 8 a.m.-5 p.m., PST. Lunes –Viernes. CostcoService@grillservices.com.

Injector has marking indicating size. For example, “0.92” on injector indicates the injector size is 0.92 mm.

Troubleshooting . . . . . . . . . . . . . . . . . . . . . . .

Ordering Parts . . . . . . . . . . . . . . . . . . . . . . . .

Grill Hints . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Grill Cooking Chart . . . . . . . . . . . . . . . . . . . . .

Grill Recipe Suggestion . . . . . . . . . . . . . . . . .

Limited Warranty . . . . . . . . . . . . . . . . . . . . . .

Exploded View . . . . . . . . . . . . . . . . . . . . . . . .

Part List . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Safety Instruction . . . . . . . . . . . . . . . . . . . . .

Gas Hook-Up . . . . . . . . . . . . . . . . . . . . . . . .

Installer Final Check List . . . . . . . . . . . . . . .

Leak Testing . . . . . . . . . . . . . . . . . . . . . . . .

Operating Instructions . . . . . . . . . . . . . . . . .

Lighting Instructions . . . . . . . . . . . . . . . . . . .

Component Identification . . . . . . . . . . . . . . .

Care and Maintenance. . . . . . . . . . . . . . . . .

Nexgrill Industries, Inc.

14050 Laurelwood Pl Chino, CA 91710 USA

2531-

Model 720-0958AE

Appliance category I

3+(28-30/37)

3B/P(30)

3B/P(37)

3B/P(50)

Type of gas Butane Propane Butane, Propane or their mixture

Gas pressure (mbar) 28-30 37 30 37 50

Main Burner Injector size (Ø mm) 0.92 0.92 0.84 0.81

Sear Side Burner Injector Size (Ø mm) 1.02 1.02 0.94 0.84

Nominal heat input (Hs) (kW) Total: 18.4

Gas consumption (g/h) (total)

Butane - Total: 1339

Propane - Total: 1315

Failure to comply with these instructions could result in a fire or explosion that could cause

serious bodily injury, death, or property damage.

Parts sealed by the manufacture shall not be altered by the user.

Your grill will be very hot. Never lean over the cooking area while using your grill. Do not

touch cooking surfaces, grill housing, lid or any other grill parts while the grill is in

operation, or until the gas grill has cooled down after use.

DANGER

1. Never operate this appliance unattended.

2. Never operate this appliance within 3.05 m / 10 ft. of any structure, combustible material or

other gas cylinder.

3. Never operate this appliance within 7.62 m / 25 ft. of any flammable liquid.

4. Do not fill cooking vessel beyond maximum fill line.

5. Heated liquids remain at scalding temperatures long after the cooking process. Never

touch cooking appliance until liquids have cooled to 46ºC / 115ºF or less.

6. This appliance is not intended for and should never be used as a heater.

7. If a fire should occur, keep away from the appliance and immediately call your fire

department. Do not attempt to extinguish an oil or grease fire with water.

8. The flexible hose for connector shall not exceed 1.5 meters.

9. Do not modify the appliance.

10. Use Outdoors only! Read the instruction before using the appliance.

11. Do not move the appliance during use.

12. Turn off the gas supply at the gas cylinder after use.

13. Accessible parts may be very hot. Keep young children away.

14. It is recommended to change the flexible hose when the conditions require it.

DANGER

If you smell gas:

• Shut off gas to the appliance.

• Extinguish any open flame.

• Open lid.

• If odor continues, keep away from the

appliance and immediately call your gas

supplier or your fire department.

WARNING

1. Do not store or use gasoline or other

flammable liquids or vapors in the

vicinity of this or any other appliance.

2. An LPG cylinder not connected for use

shall not be stored in the vicinity of this

or any other appliance.

Safety Instruction

WARNING

Do not try lighting this appliance without reading the

“LIGHTING INSTRUCTIONS” section of this manual.

CAUTION: Beware of Flashback

TESTED IN ACCORDANCE WITH EN 498:2012 & EN

484:1998 STANDARDS FOR OUTDOOR COOKING GAS

APPLIANCE. THIS GRILL IS FOR OUTDOOR USE ONLY.

CAUTION: Spiders and small insects occasionally

spin webs or make nests in the grill

burner tubes during transit and

warehousing. These webs can lead

to gas flow obstruction, which could

result in a fire in and around burner

tubes. This type of fire is known as

“FLASH-BACK” and can cause serious damage to your

grill and create an unsafe operating condition for the user.

Although an obstructed burner tube is not the only cause of

“FLASH-BACK”, it is the most common cause.

To reduce the chance of “FLASH-BACK”, you must clean

the burner tubes before assembling your grill, and at least

once a month in late summer or early fall when spiders are

most active. Also perform this burner tube cleaning

procedure if your grill has not been used for an extended

period of time. A clogged tube can be lead to a fire

beneath the grill.

NOTE: The normal flow of gas through the regulator and

hose assembly can create a humming noise. A low volume

of noise is perfectly normal and will not interfere with

operation of the grill. If humming noise is loud and

excessive you may need to purge air from the gas line or

reset the regulator excess gas flow device. This purging

procedure should be done every time a new LPG gas tank

is connected to your grill.

The size of saucepan suitable for the usage on the side

burner is between 18~22 cm in diameter.

Do not place heavy item on the side table. Maximum

weight is 5 kg. Be careful when you put the items on the

side table. Remove the items first before pulling down the

table.

Correct LPG Gas Tank Use

LPG gas grill models are designed for use with a standard

9 kg (20 lb.). Liquid Propane Gas tank, not included with

grill. Never connect your gas grill to an LPG gas tank that

exceeds this capacity.

Visually check the burner flames prior to each use. The

flames should look like this picture. If they do not, refer to

the burner main tenancy part of this manual.

304.8 mm

/ 12 in.

469.9 mm

/ 18.5 in.

• DO NOT use this appliance under overhead combustible

surfaces. This outdoors cooking gas appliance is not

intend to be installed in or on recreational vehicles

and/or boats.

• LPG gas tank must be stored outdoors in a well-

ventilated area and out of reach of children.

Disconnected LPG gas tanks must not be stored in a

building, garage or any other enclosed area.

• Do Not obstruct the flow of ventilation air around the gas

grill housing. Only use the regulator and the hose

assembly supplied with your gas grill. Replacement

regulators and hose assemblies must be those specified

in this manual.

• The regulator and hose assembly must be inspected

before each use of the grill. If there is excessive

abrasion or wear or if the hose is cut, it must be replaced

prior to the grill being put into operation. The

replacement hose assembly shall be that specified by

the manufacturer.

• Pressure regulator and hose assembly supplied with the

outdoor cooking gas appliance must be used. Never

substitute other types of regulator. Contact customer

service for manufacturer specified replacement parts.

• This outdoor cooking gas appliance is equipped with a

pressure regulator comply with the standard for

Pressure Regulating Valves for LPG Gas EN

16129:2013.

• Do not use briquettes of any kind in the grill.

• The grill is designed for optimum performance without

the use of briquettes. Do not place briquettes on the

radiant as this will block off the area for the grill burners

to vent. Adding briquettes can damage ignition

components and knobs, and void the warranty.

• Keep the back and side cart free and clear from debris.

Keep any electrical supply cord, or the rotisserie motor

cord away from the heated areas of the grill.

• Never use the grill in extremely windy conditions. If

located in a consistently windy area (oceanfront,

mountaintop, etc.) a windbreak will be required. Always

adhere to the specified clearance.

• Never use a dented or rusty propane tank.

• Keep any electrical supply cord and the fuel supply hose

away from any heated surface.

• While lighting, keep your face and hands as far away

from the grill as possible.

• Burner adjustment should only be performed after the

burner have cooled.

WARNING

Your grill will get very hot. Never lean over the cooking

area while using your grill. Do not touch cooking surfaces,

grill housing, lid or any other grill parts while the grill is in

operation, or until the gas grill has cooled down after use.

Failure to comply with these instructions may result in

serious bodily injury.

CAUTION: TO ENSURE CONTINUED PROTECTION

AGAINST RISK OF ELECTRIC SHOCK, CONNECT TO

PROPERLY GROUNDED OUTLETS ONLY, TO REDUCE

THE RISK OF ELECTRIC SHOCK, KEEP EXTENSION

CORD CONNECTION DRY AND OFF THE GROUND.

LPG-Gas Supply System

• If the information is not followed

exactly, a fire resulting in death

or serious injury could occur.

• A 9 kg (20 lb.) tank of approximately

304.8 mm (12 in.) diameter by 469.9 mm

(18.5 in.) high is the maximum size LPG gas tank to use.

• The tank supply system must be arranged for vapor

withdrawal.

• The LPG gas tank used must have a collar to protect the

tank valve.

• Place dust cap on cylinder valve outlet whenever the

cylinder is not in use. Only install the type of dust cap on

the cylinder valve outlet that is provided with the cylinder

valve. Other types of cap or plugs may result in leakage

of propane.

• Never connect an unregulated LPG gas tank to your gas

grill.

• This outdoor cooking gas appliance is equipped with a

high capacity hose/regulator assembly for connection to

a standard 9 kg (20 lb.) Liquid Propane cylinder.

• Have your LPG gas tank filled by a reputable propane

gas dealer and visually inspected and re-qualified at

each filling.

• Do not store a spare LPG gas cylinder under or near this

appliance.

• Never fill the cylinder beyond 80 percent full.

• Always keep LPG gas tanks in an upright position.

• Do not store or use gasoline or other flammable vapors

and liquids in the vicinity of this or any other appliance.

• Storage of an outdoor cooking gas appliance indoors is

permissible only if the cylinder is disconnected and

removed from the outdoor cooking gas appliance.

• When your gas grill is not in use the gas must be turned

off at LPG gas tank.

Proper Placement And Clearance Of Grill

• Never use your gas grill in a garage, porch, shed,

breezeway or any other enclosed area. Your gas grill is

to be used outdoors only.

• Do Not install this unit into combustible enclosures.

Minimum clearance from sides and back of unit to

combustible construction, 91.44 cm (36 in.) from sides

and 91.44 cm (36 in.) from back.

WARNING

Keep a spray bottle of soapy water near the gas supply

valve and check the connections before each use.

DO NOT USE ALUMINUM FOIL TO LINE THE GRILL

RACKS OR GRILL BOTTOM.

This can severely upset combustion airflow or trap

excessive heat in the control area.

SAFETY PRACTICES TO AVOID PERSONAL INJURY

When properly cared for your grill will provide safe, reliable

service for many years. However, extreme care must be used

as the grill produces intense heat that can increase accident

potential. When using this appliance basic safety practices

must be followed, including the following:

Do not repair or replace any part of the grill unless

specifically recommended in this manual. All other service

should be referred to a qualified technician.

This grill is not intended to be installed in or on recreational

vehicles or boats.

Children should not be left alone or unattended in an area

where the grill is being used. Do not allow them to sit, stand

or play in or around the grill at any time.

Do not store items of interest to children around or below the

grill.

Do not permit clothing, pot holders or other flammable

materials to come in contact with or too close to any grate,

burner or hot surface until it has cooled. The fabric could

ignite and cause personalinjury.

For personal safety, wear proper apparel. Loose fitting

garments or sleeves should never be worn while using this

appliance. Some synthetic fabrics are highly flammable and

should not be worn while cooking.

Only certain types of glass, heat-proof glass ceramic,

earthenware, or other glazed utensils are suitable for grill use.

These materials may break with sudden temperature

changes. Use only on low or medium heat settings in

accordance with the manufacturer’s guidelines.

Do not heat unopened food containers. A build-up of

pressure may cause the containers to burst.

Use a covered hand when opening the grill lid.

Never lean over an open grill.

When lighting a burner, pay close attention to what you are

doing. Make certain you are aware of which burner you are

lighting, so your body and clothing remain clear of open

flames.

WARNING

This outdoor cooking gas appliance is not intended to be

installed in or on boats. And other recreational vehicles.

When using the grill, do not touch the grill rack, burner grate

or immediate surroundings as these areas become

extremely hot and could cause burns. Use only dry

potholders. Moist or damp potholders on hot surfaces may

cause steam burns. Do not use a towel or bulky cloth in

place or potholders. Do not allow potholders to touch hot

portions of the grill rack.

Grease is flammable. Let hot grease cool before attempting

to handle it. Do not allow grease deposits to collect in the

grease tray at the bottom of the grill’s firebox. Clean the

grease tray often

Do not use aluminum foil to line the grill racks or grill bottom.

This can severely upset combustion air flow or trap

excessive heat in the control area.

For proper lighting and performance of the burners keep the

burner ports clean. It is necessary to clean them periodically

for optimum performance. The burners will only operate in

one position and must be mounted correctly for safe

operation.

Clean the grill with caution. To avoid steam burns, do not

use a wet sponge or cloth to clean the grill while it is hot.

Some cleaners produce toxic fumes or can ignite if applied

to a hot surface.

Turn off grill controls and make certain the grill is cool before

using any type of aerosol cleaner on or around the grill. The

chemical that produces the spraying action could, in the

presence of heat, ignite or cause metal parts to corrode.

Do not use the grill to cook excessively fatty meats or other

products which promote flare-ups.

Do not operate the grill under unprotected combustible

constructions. Use only in well ventilated areas. Do not use

in buildings, garages, sheds, breezeways or other such

enclosed areas.

Keep the area surrounding the grill free from combustible

materials including, fluids, trash, and vapors such as

gasoline or charcoal lighter fluid. Do not obstruct the flow of

combustion and ventilation air.

NEVER CONNECT AN UNREGULATED GAS SUPPLY

LINE TO THE APPLIANCE. USE THE REGULATOR/HOSE

ASSEMBLY SUPPLIED.

This is a liquid petroleum gas configured grill. Do not attempt

to use a natural gas supply unless the grill has been

reconfigured for natural gas use.

Total gas consumption (per hour) of this stainless steel gas

grill with all burners on :

Main burner 14 kW (48,000 BTU/hr.)

Sear burner 4.4 kW (15,000 BTU/hr.)

Total 18.4 kW (63,000 BTU/hr.)

Gas Hook-Up

LPG TANK REQUIREMENT

A dented or rusty LPG tank may be hazardous and should be

checked by your LPG supplier. Never use a cylinder with a

damaged valve.

LPG GAS HOOK-UP

Ensure that the black plastic grommets on the LPG cylinder

valve are in place and that the hose does not come into

contact with the grease tray or the grill head.

CONNECTION

Your stainless steel grill is equipped with gas supply orifices

for use only with liquid propane gas. It is also equipped with a

high capacity hose/regulator assembly for connection to a

suitable gas cylinder. Please refer to page 5 “LPG-gas supply

system” for more details. Below are the steps for cylinder

connection:

1. Make sure tank valve is in its full off position (turn

clockwise to stop).

2. Make sure all burner valves are in their off position.

3. Inspect valve connections, port, and regulator assembly.

Look for any damage or debris. Remove any debris.

Inspect hose for damage. Never attempt to use

damaged or obstructed equipment. See your local LPG

gas dealer for repair.

4. When connecting regulator assembly to the valve, hand

tighten the quick coupling nut clockwise to a complete

stop. Do not use a wrench to tighten. Use of a wrench

may damage the quick coupling nut and result in a

hazardous condition.

5. Open the tank valve fully (counterclockwise). Apply the

soap solution with a clean brush to all gas connections.

See below. If growing bubbles appear in the solution

the connections are not properly sealed. Check each

fitting and tighten or repair as necessary.

6. If you have a gas connection leak you cannot repair,

turn gas OFF at supply tank, disconnect fuel line from

your grill and call 1- 866-984-7455 in USA and 1-800-

648-5864 in Canada or your gas supplier for repair

assistance.

7. Also apply soapy solution to the tank seams. See below.

If growing bubbles appear, shut tank OFF and do not

use or move it! Contact an LPG gas supplier or your fire

department for assistance.

To disconnect LPG gas cylinder:

1. Turn the burner valves off.

2. Turn the tank valve off fully (turn clockwise to stop).

3. Detach the regulator assembly from the tank valve by

turning the quick coupling nut counterclockwise.

Installer Final Check List

USER, PLEASE RETAIN THIS MANUAL FOR FUTURE

REFERENCE.

PROPANE CYLINDER CAUTIONS

a) Do Not store a spare LPG-gas cylinder under or

near this appliance.

b) NEVER fill the cylinder beyond 80 percent full.

c) If the information in “a” and “b” is not followed

exactly, a fire or explosion causing death or serious

injury may occur.

✓ Minimum clearance from sides and back of unit to

combustible construction, 91,44 cm (36”) from

sides and 91,44 cm (36”) from back

✓ All internal packaging removed.

✓ Knobs turn freely.

✓ Burners are tight and sitting properly on orifices.

✓ Pressure regulator connected and set. Gas

connections to grill using hose & regulator

assembly provided (pre-set for 11” water column).

✓ Unit tested and free of leaks.

✓ User informed of gas supply shut off valve location

GENERAL

Although all gas connections on the grill are leak tested at

the factory prior to shipment, a complete gas leak test check

must be performed at the installation site due to possible

mishandling in shipment, or excessive pressure

unknowingly being applied to the unit. Periodically check the

whole system for leaks following the procedures listed

below. If the smell of gas is detected at anytime you should

immediately check the entire system for leaks.

It's recommended to use the regulator complied with EN

16129:2013.

The flexible hose should approved by EN 16436:2014.

As of category I

3B/P(30)

, the gas type and outlet pressure of

the regulator is: butane/propane 30 mbar;

Category I

3+(28-30/37)

, should be: butane 28-30 mbar or

propane 37 mbar; I

3B/P(37)

, butane/propane 37 mbar; I

3B/P(50)

butane/propane 50 mbar.

BEFORE TESTING

Make sure that all packing material is removed from the grill

including tie-down straps.

DO NOT SMOKE WHILE LEAK TESTING.

NEVER PERFORM LEAK TEST WITH AN OPEN FLAME.

Make a soap solution of one part liquid detergent and one

part water. You will need a spray bottle, brush, or rag to

apply the solution to the fittings. For the initial leak test,

make sure the LPG cylinder is 80% full.

TO TEST

1. Make sure the control valves are in the “○” position,

and turn on the gas supply.

2. Check all connections from the LPG gas regulator and

supply valve up to and including the connection to the

manifold pipe assembly (the pipe that goes to the

burners). Soap bubbles will appear where a leak is

present.

3. If a leak is present, immediately turn off the gas supply

and tighten the leaky fittings.

4. Turn the gas back on and recheck.

5. Should the gas continue to leak from any of the fittings,

turn off the gas supply and contact Customer Service at

1- 866-984-7455 in USA and 1-800-648-5864 in

Canada, language spoken: English, Spanish, French 8

a.m.-5 p.m., PST. Monday-Friday.

Only those parts recommended by the manufacturer should

be used on the grill.

Substitution will void the warranty. Do not use the grill until

all connections have been checked and do not leak.

ALWAYS CHECK FOR LEAKS AFTER EVERY

LPG TANK CHANGE

Check all gas supply fittings for leaks before

each use. It is handy to keep a spray bottle of

soapy water near the shut-off valve of the gas

supply line. Spray all the fittings. Bubbles

indicate leaks.

CAUTIONS

Place dust cap on cylinder valve outlet when the

cylinder is not in use. Only install the type of dust

cap on the cylinder valve outlet that is provided

with the cylinder valve. Other types of caps or

plugs may result in leakage of LPG.

The gas must be turned off at the supply cylinder

when the unit is not in use.

If the appliance is stored indoors the cylinder

must be disconnected and removed from the

appliance. Cylinders must be stored outdoors in

a well-ventilated area out of the reach of children.

Your grill is ready to use!

GAS FLOW CHECK

Each grill burner is tested and adjusted at the factory prior

to shipment; however, variations in the local gas supply may

make it necessary to adjust the burners. The flames of the

burners should be visually checked.

Flames should be blue and stable with no yellow tips,

excessive noise or lifting. If any of these conditions exist,

check to see if the air shutter or burner ports are blocked by

dirt, debris, spider webs, etc. If you have any questions

regarding flame stability, please call customer service 1-

866-984-7455 in USA and 1-800-648-5864 in Canada,

language spoken: English, Spanish, French 8 a.m.-5 p.m.,

PST. Monday-Friday.

Leak Testing

GENERAL USE OF THE GRILL

Each main burner is rated at 3.5 kW (12,000 BTU/hr.). The

main grill burners encompass the entire cooking area and

are side ported to minimize blockage from falling grease

and debris. The knobs are located on the lower center

portion of the control panel. Each knob is labeled on the

control panel.

USING THE GRILL

Grilling requires high heat for searing and proper browning.

Most foods are cooked at the heat setting for the entire

cooking time. However, when grilling large pieces of meat or

poultry, it may be necessary to turn the heat to the lower

setting after the initial browning. This cooks the food through

without burning the outside. Foods cooked for a long time or

foods basted with a sugary marinade may need the lower

heat setting near the end of the cooking time.

NOTE: This grill is designed to grill efficiently without the

use of lava rocks or briquettes of any kind. Heat is radiated

by the stainless steel flame tamers positioned above each

burner.

Operating Instructions

NOTE: The hot grill sears the food, sealing in the juices. The

more thoroughly the grill is preheated, the faster the meat

browns and the darker the grill marks.

DO NOT LEAVE THE GRILL UNATTENDED WHILE

COOKING.

WARNING: IMPORTANT!

USING THE SEAR BURNER

Inspect the gas supply hose prior to turning the gas “ON”. If

there is evidence of cuts, wear or abrasion, it must be

replaced prior to use. Do not use the sear burner if the odor

of gas is present.

Lighting Instructions

WARNING: IMPORTANT!

BEFORE LIGHTING

Inspect the gas supply hose prior to turning the gas “ON”. If

there is evidence of cuts, wear, or abrasion, it must be

replaced prior to use. Do not use the grill if the odor of gas is

present. Only the pressure regulator and hose assembly

supplied with the unit should be used.

Never substitute regulators and hose assembly for those

supplied with the grill. If a replacement is necessary, contact

the manufacturer for proper replacement. The replacement

must be that specified in the manual.

TO LIGHT THE MAIN BURNER

Make sure all knobs are OFF then turn on the gas supply

from the LPG (Liquid Propane) tank. Always keep your face

and body as far from the grill as possible when lighting.

To light your main burner, push and turn main burner

control knob to , at the same time, press and hold

electronic ignition button to light the burner. Once the burner

is lit, release the electronic ignition button and knob. If the

burner does not light wait 5 minutes for any excess gas to

dissipate and then retry.

TO LIGHT THE SEAR BURNER AND ROTISSIERE

BURNER

To light the sear burner and rear burner, remove any

cooking utensils from the burner grate. Push and turn the

control knob to , at the same time, press and hold

electronic ignition button to light the burner . Once the

burner is lit, release the electronic ignition button and knob.

If the burner does not light, turn the control knob to “○”. If

the smell of gas is detected and the igniter is not functioning,

immediately turn the control knob “○”. Allow 5 minutes for

any accumulated gas to dissipate. If the sear burner and

rear burner igniter are not functioning, see the following

section for match lighting.

WARNING

Always keep your face and body as far away from the

burner as possible when lighting.

CAUTIONS

Place dust cap on cylinder valve outlet when the

cylinder is not in use. Only install the type of dust cap

on the cylinder valve outlet that is provided with the

cylinder valve. Other types of caps or plugs may

result in leakage of propane.

The gas must be turned off at the supply cylinder

when the unit is not in use.

If the appliance is stored indoors the cylinder must be

disconnected and removed from the appliance.

Cylinders must be stored outdoors in a well-ventilated

area out of the reach of children.

Each burner is adjusted prior to shipment;

however, variations in the local gas supply may

make minor adjustments necessary.

Keep a spray bottle of soapy water near the gas

supply valve and check the connections before

each use.

Do not attempt to light the grill if odor of gas is

present. Call for service 1- 866-984-7455 in USA

and 1-800-648-5864 in Canada,, language spoken:

English, Spanish, French 8 a.m.-5 p.m., PST.

Monday-Friday.

Match Light

1. If the burner will not light after several attempts

then the burner can be match lit, before using the

match allow 5 minutes for any accumulated gas to

dissipate.

2. Clip a match on one end of the lighting rod.

3. Light match.

4. Hold lighting rod and insert lighted match right

next to the burner ports or ceramic file.

5. Push and turn the designated control knob to .

6. Burner should ignite immediately.

Main burner

Sear burner

Sear Burner

Main Burner

Control Knob, Label

Push In

Component Identification

Note: Remove all packaging, including straps, before using the grill

CAUTION

1. Keep outdoor cooking gas appliance area clear and

free from combustible materials, gasoline and other

flammable vapors and liquids.

2. Do not obstruct the flow of combustible and ventilation

air.

3. Keep the ventilation openings of the cylinder enclosure

free and clear from debris.

Care and Maintenance

STAINLESS STEEL

There are many different stainless steel cleaners available.

Always use the mildest cleaning procedure first, scrubbing

in the direction of the grain. Do not use steel wool as it will

scratch the surface. To touch up noticeable scratches in the

stainless steel, sand very lightly with dry 100 grit emery

paper in the direction of the grain. Specks of grease can

gather on the surfaces of the stainless steel and bake on to

the surface and give the appearance of rust. For removal

use a mild abrasive pad in conjunction with a stainless steel

cleaner.

GRILL GRATE

The easiest way to clean the grill is immediately after

cooking is completed and after turning off the flame. Wear a

barbeque mitt to protect your hand from the heat and steam.

Dip a barbeque brush in water and scrub the hot grill. Dip

the brush frequently in the bowl of water. Steam, created as

water contacts the hot grill, assists the cleaning process by

softening any food particles. If the grill is allowed to cool

before cleaning, cleaning will be more difficult.

ENSURE THAT THE GAS SUPPLY AND THE KNOBS

ARE IN THE “○” POSITION. MAKE SURE THE RANGE

TOP BURNER IS COOL BEFORE REMOVAL.

GRILL BURNERS

Extreme care should be taken when moving a burner as it

must be correctly centered on the orifice before any attempt

is made to relight the grill. Frequency of cleaning will

depend on how often you use the grill.

MAIN BURNER CLEANING

Ensure the gas supply is off and the knobs are in the “○”

position. Make sure the grill is cool. Clean the exterior of the

burner with a wire brush. Clear stubborn scale with a metal

scraper. Clear any clogged ports with a straightened paper

clip. Never use a wooden toothpick as it may break off and

clog the port. Please note if insects or other obstructions are

blocking the flow of gas through the burner, and if so you

will need to call our customer service line 1- 866-984-7455

in USA and 1-800-648-5864 in Canada, language spoken:

English, Spanish, French 8 a.m.-5 p.m., PST. Monday-

Friday.

GREASE TRAY CLEANING

The grease tray should be emptied and wiped down

periodically and wash with a mild detergent and warm water

solution. A small amount of sand may be placed in bottom

of grease tray to absorb the grease. Check the grease tray

frequently, do not allow excess grease to accumulate and

overflow out of the grease tray.

Warning: If you wish to replace main burner, we

strongly recommend that you hire a professionally

trained technician to replace it. Please understand that

we will not be responsible for any liability, personal

injury, or property damage resulting from an

improperly assembled burner.

HOW TO REPLACE MAIN BURNER

Step 1. Remove the main burner “R” pin on the back wall of

fire box by using needle nose pliers. Use a flathead

screwdriver to remove burner pin cover, then remove the

burner on the front wall of fire box, as shown below.

Step 2. Insert the burner onto the orifice and secure the

burner pin cover on the burner, as shown below, make sure

burner hole aim at orifice .

Step 3. Secure the main burner on the back wall of fire box

with “R” Pin.

SPIDER AND INSECT WARNING

Checking and cleaning burner/ venturi tubes for insects and

insect nests. A clogged tube can lead to a fire beneath the

grill.

Although an obstructed burner tube is not the only cause of

“FLASH-BACK”, it is the most common cause.

To reduce the chance of “FLASH-BACK”, you must clean the

burner tubes before assembling your grill, and at least once a

month in late summer or early fall when spiders are most

active. Also perform this burner tube cleaning procedure if

your grill has not been used for an extended period of time.

WHEN TO LOOK FOR SPIDERS

You should inspect the burners at least once a year or

immediately after any of the following conditions occur:

1. The smell of gas in conjunction with the burner flames

appearing yellow.

2. The grill does not reach temperature.

3. The grill heats unevenly.

4. The burners make popping noises.

BEFORE CALLING FOR SERVICE

If the grill does not function properly, use the following check

list before contacting your dealer for service. You may save

the cost of a service call.

PREHEATING: The grill lid should be in a closed position

during the preheat time period. It is necessary to preheat the

grill before cooking certain foods, depending on the type of

food and the cooking temperature. Food that requires a high

cooking temperature needs a pre-heat

period of five minutes; food that requires a lower cooking

temperature needs only a period of two to three minutes.

COOKING TEMPERATURES

High setting-Use this setting for fast warm-up, for searing

steaks and chops, and grilling.

Low setting-Use this setting for all roasting, baking, and when

cooking very lean cuts such as fish.

These temperatures vary with the outside temperature and

the amount of wind.

Cooking with in-direct Heat: You can cook poultry and large

cuts of meat slowly to perfection on one side of the grill by

indirect heat from the burner on the other side. Heat from the

lit burner circulates gently throughout the grill, cooking the

meat or poultry without any direct flame touching it. This

method greatly reduces flare-ups when cooking extra fatty

cuts, because there is no direct flame to light the fats and

juices that drip down during cooking.

CAUTION: If burners go out during operation, close gas

supply at source, and turn all gas valves off. Open lid and

wait five minutes before attempting to relight (this allows

accumulated gas fumes to clear).

CAUTION: Should a grease fire occur, close gas supply at

source, turn off all burners and leave lid closed until fire is out.

CAUTION: DO NOT attempt to disconnect any gas fitting

while your grill is in operation. As with all appliances, proper

care and maintenance will keep them in top operating

condition and prolong their life. Your gas gill is no exception.

CAUTION: Side burner lid will get hot if used when lid is

closed.

PROBLEM SOLUTION

When attempting to light my grill, it will

not light immediately.

Make sure you have a spark while you are trying to light the burner (if no

spark) . Check if the battery is installed properly.

Ensure that the wire is connected to the electrode assembly.

Clean wire (s) and / or electrode with rubbing alcohol and a clean swab. Wipe

with a clean cloth.

Check to see if the other burners operate. If so. Check the gas orifice on the

malfunctioning burner for an obstruction.

Rotisserie burner will not light when the

igniter button is pushed.

Check to see if debris is blocking the electrode.

Check to see if there is a spark that jumps to the burner from the electrode. If no

spark is seen, check the battery located inside the igniter box. To open turn

counter

Does the infrared back burner light when attempting to light with a match ? If not,

check to ensure the gas is on.

Regulator makes noise. Vent hose on the regulator may be plugged or regulator may be faulty. Ensure

the vent hole on the regulator is not obstructed. Clear the hole, close the gas

control valves. Wait ten minutes and re-start.

Check your flames for proper performance. If the flames are not correct,

replace regulator.

Full size cover does not fit the grill. Cover may be incorrect for your grill. It may be a tight fit.

Ensure the cover is the correct length for your grill.

Measure it left to right. Compare to the grill’s measurement.

Compare the location and size of the hood portion of the cover to your grill.

Spread the cover and allow it to relax, preferably in warm sunlight or in a warm

room.

For grill with a side shelf bunch the cover like a sock, put on left to right.

Troubleshooting

PROBLEM SOLUTION

Rotisserie motor will not turn Ensure the motor is connected to a properly grounded power supply.

Ensure the on / off switch is in the on position.

Ensure that the spit is fully inserted into the rotisserie motor.

Ensure that the load does not exceed the 18 kg (40 pounds) operational

capacity.

Ensure that there is no encumbrance or drag.

Grill only heats to 93-149°C

/ 200-300°F.

Check to see if the fuel hose is bent or kinked.

Make sure the grill area is clear of dust.

Make sure the burner and orifices are clean.

Check for spiders and insects.

The regulator has a safety device that restricts the flow of gas in the event of a

leak. This safety device can be triggered without a gas leak. To reset the

safety device, turn off all burners and close the LPG tank valve. Disconnect the

regulator from the LPG tank and wait one minute. Reconnect the regulator to

the LPG tank and slowly open the LPG tank valve until the valve is fully open.

Light all burners and observe the temperature.

Grill takes a long time to preheat.

Normal preheat 260-316°C / 500-600°F, takes about 10-15 min. Cold weather

and wind may effect your preheat time.

If you are using volcanic rock or briquettes they can increase the preheat time

and maximum temperature.

Burner flames are not light blue. Too much or not enough air for the flame.

Elevation is the principal cause, however cold weather can affect the mixture.

Burner adjustment may be required.

Grill is in a windy location.

Ordering Parts

HOW TO ORDER REPLACEMENT PARTS

To make sure you obtain the correct replacement part (s) for

your gas grill, please refer to the parts list on page 54. The

following information is required to assure getting the correct

part. Please note the shipping cost for the delivery of any

replacement parts will be on yourself.

• Gas grills model number (see data sticker on grill).

• Part number of replacement part needed.

• Description of replacement part needed.

• Quantity of parts needed.

To obtain replacement parts, contact our customer service

hotline, 1- 866-984-7455 in USA and 1-800-648-5864 in

Canada, language spoken: English, Spanish, French 8

a.m.-5 p.m., PST. Monday-Friday.

IMPORTANT

Use only factory authorized parts. The use of any part that

is not factory authorized can be dangerous. This will also

void your warranty.

Keep this assembly and operating instruction manual for

convenient referral, and for replacement parts ordering.

Grill Hints

The doneness of meat, whether rare, medium, or well done,

is affected to a large degree by the thickness of the cut.

Expert chefs say it is impossible to have a rare doneness

with a thin cut of meat.

The cooking time is affected by the kind of meat, the size and

shape of the cut, the temperature of the meat when cooking

begins, and the degree of doneness desired.

When defrosting meats it is recommended that it be done

overnight in the refrigerator as opposed to a microwave. This

in general yields a juicier cut of meat.

Use a spatula instead of tongs or a fork to turn the meat, as

a spatula will not puncture the meat and let the juices run out.

To get the juiciest meats, add seasoning or salt after the

cooking is finished on each side and turn the meat only once

(juices are lost when the meat is turned several times). Turn

the meat just after the juices begin to bubble to the surface.

Trim any excess fat from the meat before cooking. To

prevent steaks or chops from curling during cooking, slit the

fat around the edges at 50.8 mm (2-in.) intervals.

DO NOT LEAVE THE GRILL UNATTENDED WHILE

COOKING.

FOOD

WEIGHT OR

THICKNESS

HEAT

SETTING

APPROXIMATE

TIME

SPECIAL INSTRUCTIONS

AND TIPS

Vegetables

Slice. Dot with butter or margarine. Wrap in

heavy -duty foil. Grill, turning occasionally.

Fresh Beets

Carrots

Turnips

Medium 12 to 20 minutes

Grill, turning once. Brush occasionally with

melted butter or margarine.

Onion

1.3mm / 1/2 in.

slices

Medium 8 to 20 minutes

Season with Italian dressing, butter, or

margarine.

Potatoes Sweet

White

Whole

170 to 226g

/ 6 to 8 oz

Medium

High

40 to 60 minutes

45 to 60 minutes

Wrap individually in heavy - duty foil. Grill,

rotating occasionally.

Frozen Asparagus

Peas Green beans

Sprouts

Medium 15 to 30 minutes

Dot with butter or margarine.

Wrap in heavy -duty foil. Grill, turning

occasionally.

French fries Medium 15 to 30 minutes

Place in aluminum foil pan.

Grill, stirring occasionally

Meats

Beef

Hamburgers

1-2 cm

/ 1/2 - 3/4 in.

Medium 10 to 18 minutes

Grill, turning once when juices rise to the

surfaces.

Do not leave hamburgers unattended since a

flare-up could occur quickly. Cook to internal

temperature of 160 degrees

Tenderloin High 8 to 15 minutes

Rare 2.5 cm / 1 in. High 8 to 14 minutes

Trim edges. Grill, turning onceMedium

1.3 cm / 1/2 in.

2.5 cm / 1 in.

2.5 - 3.8 cm

/ 1-1/2 in.

High

Medium

to High

11 to 18 minutes

12 to 22 minutes

16 to 27 minutes

Well - done

2.5 cm / 1 in.

2.5 - 3.8 cm

/ 1-1/2 in.

Medium

18 to 30 minutes

16 to 35 minutes

Lamb

Chop & Steaks

Rare

2.5 cm / 1 in.

2.5 - 3.8 cm

/ 1-1/2 in.

Medium

High

10 to 15 minutes

14 to 18 minutes

Trim edges. Grill, turning once.

Medium

2.5 cm / 1 in.

2.5 - 3.8 cm

/ 1-1/2 in.

Medium

High

13 to 20 minutes

18 to 25 minutes

Pork

Chops

2.5 cm / 1 in.

Medium

20 to 30 minutes

Trim edges. Grill, turning once. Cook to

desired doneness.

Well -done

2.5 - 3.8 cm

/ 1-1/2 in.

Medium 30 to 40 minutes

Grill Cooking Chart

FOOD

WEIGHT OR

THICKNESS

HEAT

SETTING

APPROXIMATE

TIME

SPECIAL INSTRUCTIONS

AND TIPS

Ribs Medium

30 to 40

minutes

Grill, turning occasionally.

During last few minutes brush with barbecue

sauce. Turn several times.

Ham steaks

(precooked)

2.5 cm / 1 in.

slices

High 4 to 8 minutes

Trim edges. Grill, turning once.

Hot dogs Low 5 to 10 minutes Slit skin. Grill, turning once.

Poultry

900 to 1400 g

/ 2 to 3 lb

Low

Medium

Up to 1 hour

Place skin side up. Grill, turning and

brushing frequently with melted butter,

margarine, oil or marinade.

Breasts

well –done

Medium

30 to 45

minutes Marinate as desired.

Fish and

Seafood

Halibut

Salmon

Swordfish

2 to 2.5 cm

/ 3/4 to 1 in.

Medium

High

8 to 15 minutes

Grill, turning once. Brush with melted butter,

margarine or oil to keep moist.

Whole

Catfish

Rainbow trout

113 to 226 g

/ 4 to 8 oz

Medium

High

12 to 20

minutes

Grill, turning once. Brush with melted butter,

margarine or oil. Brush with melted butter

and lemon juice.

Grill Recipe Suggestion

BBQ SALMON

2 large salmon steaks

2 tbs. Oil

Salt & pepper

2 oz. thin bacon slices

2 tbs. Butter

1 tbs. Lemon juice

Spring of parsley

Lemon wedges

Preheat the BBQ. Brush the steaks with

oil and season with salt and pepper.

Place on BBQ grill and cook for 10

minutes, turning steaks over halfway

cooking time.

Meanwhile, fry the bacon in a pan on

the side burner. Drain on paper towels.

Melt the butter in a small saucepan

taking care not to discolor it. Arrange

the fish and bacon on serving plates.

Pour the butter over and sprinkle with

lemon juice. Garnish with parsley

springs and lemon wedges. Serve with

boiled potatoes tossed in butter and

sprinkled with chopped parsley and a

crisp lettuce salad.

Note: Substitute catfish, halibut or cod

for salmon.

BAKED CHILI CORN

6 medium ears corn, husked

3 tbs. Butter or margarine, melted

Dash ground cumin

Dash ground coriander

About ½ hour before cooking, turn the

butter on for grill. Place each corn on a

heavy-duty foil. In a bowl, combine

remaining ingredients. Mix well. Brush

1-1/2 tsp. Butter mixture over each ear.

Close foil and fold up ends to seal.

Place on grill. Cook, turning packets

occasionally 10 to 12 minutes or until

cooked through.

TANGY SEAFOOD KABOBS

1 lb. Large shrimp, shelled & deveined

¾ lbs. sea scallops

2/3 c. chili sauce

¼ c. cider vinegar

butter and sprinkled with chopped

parsley and a crisp lettuce salad

In medium bowl, combine shrimp and

scallops. In small bowl combine chili

sauce and next six ingredients. Pour

over seafood. Toss to coat. Cover,

refrigerate 2 hours.

3 tbs. chopped parsley

1 tbs. vegetable oil

1 tbs. Worcestershire sauce

½ tsp. prepared horseradish

1 cove garlic, minced

1 20 oz. Can pineapple chunks in juice,

drained half hour before cooking, turn

the burner to the grill on full. Drain

seafood reserving marinade. On each

of twelve 10” skewers, thread 2 shrimps

and 2 scallops, alternating with

pineapple chunks. Place skewers on

grill. Cook 7-10 minutes, often basting

and turning.

PORK CHOPS

4 Pork chops

Marinade

1 large onion

2 tbs. lemon juice or vinegar

2 tbs. oil

½ tsp. powdered mustard

2 tsp. Worcestershire sauce

½ tsp. freshly ground black pepper

1 tsp. sugar

½ tsp. paprika

1 clove garlic

Peel, grate onion, and add rest of the

ingredients except the pork chops. Mix

well. Pour over chops and marinate one

hour in a cool place. Turn the BBQ grill

on full. Heat 10 minutes.

BBQ the chops brushing with the

marinade occasionally. Serve with

mixed salad, dressed with vinaigrette

flavored with fresh dill.

BARBECUED LONDON BROIL

4 to 6 servings

¾ c. Italian dressing

1 tsp. Worcestershire sauce

1 tsp. dry mustard

¼ tsp. thyme, crushed

1 medium onion, sliced

1 pound flank steak, scored

2 tbs. butter, melted

Combine first 4 ingredients, add onion

and marinade flank steak with it.

Refrigerate at least 4 hours or overnight.

Remove steak and grill on your

preheated BBQ grill. Grill 5 to 7 minutes

on each side basting frequently with the

marinade. In the meantime sauté

onions from the marinade in butter in a

skillet on your side burner for 3 minutes.

To serve, slice steak diagonally into

thin slices, sprinkle onions over top.

Garnish with vegetable kabobs.

BARBECUED POTATOES and

CHEESE

1-1/2 cups shredded cheddar cheese

1 can (10-3/4 oz.) condensed cream of

mushroom soup

1/3 cup milk

2 tbs. barbecue sauce

¼ tsp. oregano

¼ tsp. salt

1/8 tsp. pepper

4 cups thinly sliced potatoes (4

medium-sized potatoes)

Preheat grill. Combine cheese,

condensed soup, milk, BBQ sauce,

oregano, salt and pepper in a large

mixing bowl. Stir in potatoes until well

coated. Turn into well buttered1-1/2

quart rectangular baking dish. Cover

dish with aluminum foil. Bake covered

25 minutes on medium with the lid of

your BBQ grill closed. Remove foil and

continue baking 15 minutes longer or

until potatoes are tender. Let stand 5

minutes before serving.

VEGETABLE KABOBS

3 medium-sized zucchini

12 cherry tomatoes

12 fresh mushrooms

Grated Parmesan cheese

Parboil whole zucchini 5 minutes on

your side burner or until just tender.

Drain and cut into ½ inch slices. Thread

zucchini, tomatoes and mushrooms

alternately on each of six skewers.

Brush with marinade made of Italian

dressing, Worcestershire sauce,

mustard and thyme. Grill 5 to 7 minutes

turning and basting occasionally.

Sprinkle liberally with Parmesan

cheese.

FAJITAS

1-1/2 lb. flank steak or boned chicken

breasts

2 tbs. oil

½ cup limejuice

½ tsp. salt

½ tsp. celery salt

¼ tsp. garlic powder

½ tsp. pepper

¼ tsp. oregano

¼ tsp. cumin

Flour tortillas lemon

Pound flank steak to ¼ inch thickness

or flatten chicken breasts. Mix oil, lime

juice and seasonings in a zip lock bag.

Add meat and shake bag to coat the

meat. Refrigerate overnight or at least 6

to 8 hours. Wrap tortillas in foil.

Remove meat from marinade. Cook on

a preheated gas grill for 5 to 8 minutes

on each side. While meat is cooking,

heat tortillas on grill. Slice meat across

grain in thin slices. Place on hot platter.

Squeeze lemon juice over. Wrap meat

and any of the following toppings in

tortillas: chopped tomatoes, guacamole,

sour cream, taco sauce.

FAJITAS

1-1/2 lb. flank steak or boned chicken

breasts

2 tbs. oil

½ cup limejuice

½ tsp. salt

½ tsp. celery salt

¼ tsp. garlic powder

½ tsp. pepper

¼ tsp. oregano

¼ tsp. cumin

Flour tortillas lemon

Pound flank steak to ¼ inch thickness

or flatten chicken breasts. Mix oil, lime

juice and seasonings in a zip lock bag.

Add meat and shake bag to coat the

meat. Refrigerate overnight or at least 6

to 8 hours. Wrap tortillas in foil. Remove

meat from marinade. Cook on a

preheated gas grill for 5 to 8 minutes on

each side. While meat is cooking, heat

tortillas on grill. Slice meat across grain

in thin slices. Place on hot platter.

Squeeze lemon juice over. Wrap meat

and any of the following toppings in

tortillas: chopped tomatoes, guacamole,

sour cream, taco sauce.

BEEF AND LAMB KABOBS

Serve 4

½ lb. boneless sirloin or beef cut into 1”

cubes

½ lb. boneless loin of lamb cut into 1”

cubes

2/3 c. water, divided

¼ c. chopped onion

2 tbs. soy sauce

¼ c. vegetable oil, divided

1 tbs. dark brown sugar

1 tbs. fresh lemon juice

2 cloves garlic, minced

¼ tsp. ground cumin

¼ tsp. ground coriander

¼ tsp. ground turmeric

1/8 tsp. ground red pepper

1/8 tsp. ground ginger

1 red pepper cut into chunks

1 large banana, cut into chunks

8 small mushrooms

1/3 c. smooth peanut butter

About ½ hour before cooking, turn the

butter on for grill. Place each corn on a

heavy-duty foil. In a bowl, combine

remaining ingredients. Mix well. Brush

1-1/2 tsp. Butter mixture over each ear.

Close foil and fold up ends to seal.

Place on grill. Cook, turning packets

occasionally 10 to 12 minutes or until

cooked through. Bring marinade to boil

on the side burner in a saucepan. Add

remaining 1/3 c. water and peanut

butter. Stir to blend. Heat through. If

sauce gets too thick, add 1 tbs. water.

Serve sauce with kabobs.

EGGPLANT CAVIAR

1 large eggplant

2 tbs. olive oil

2 tbs. wine vinegar

2 tbs. finely chopped onion

½ clove garlic, minced

1 medium tomato, chopped salt and

pepper

Roast eggplant on gas grill over

medium flame, turning occasionally until

thoroughly cooked. This may take 30

minutes. Remove from grill and cool for

handling. Strip off the skin and chop

eggplant finely. Add all the seasonings.

Chill thoroughly and serve on toast.

CHICKEN TANDOORI STYLE

8 large chicken thighs or drumsticks

1 c. plain nonfat yogurt

½ c. lemon juice

2 tsp. salt

½ tsp. cayenne

½ tsp. black pepper

½ tsp. crushed garlic

½ tsp. grated ginger

1 tbs. corn oil

Combine all the ingredients in a large

mixing bowl and marinate the chicken

for 8 hours in the refrigerator. Drain the

chicken and spread on the spit running

the rod on the fleshier side of the bone.

Roast using the rotisserie burner. Cook

on medium high heat for 40 minutes

basting occasionally with the remainder

of the marinade mixture. Serve with

sliced onions and lemon wedges.

SPARE RIBS

Marinade:

1 c. soy sauce

½ c. honey

½ c. vinegar

½ c. dry sherry

2 tsp. chopped garlic

2 tsp. sugar

1 c. water

1 chicken bouillon cube

1 can beer for basting sauce

Marinade ribs for 3 hours. Use

marinade for basting by adding beer to

it. Place pan under the ribs and baste

frequently. To cook ribs select lean,

meaty ribs and accordion pleat them

with your spit. Slide four prong meat

hook down the length of spit and tighten.

At the beginning of the rack and to its

center, penetrate the second rib with

the pointed end of the spit and push it

between the meat. Skip a couple and

continue the process until the entire

rack is accordion pleated. Fasten the

second meat hook into the rack. Turn

your rotisserie burner on high. Roast for

50 minutes or until done.

PORK ROAST

Apple cider vinegar basting sauce:

1 c. apple cider vinegar

6 oz. water

½ stick butter

Salt, pepper, parsley and garlic

seasoning

2 oz. lemon juice

10 lbs. pork roast

Time: 1-1/2 hours to 2 hours

Bring pork to room temperature before

placing it on the spit rod. Place on the

rod and test for balance. Light rotisserie

burner. Turn control knob to high. Use

the above basting sauce for rotissing.

TURKEY

12 lb. turkey

Beer basting sauce:

1 can beer

12 oz. water

1 stick butter

1 tsp. salt

1 tsp. pepper

½ tsp. garlic flakes

1 tsp. parsley

Thaw the bird completely. Wash inside

out. Securely tie the legs and wings.

Light rotisserie burner. Turn to high.

Combine all the ingredients for basting

sauce in a shallow pan. Place it under

the turkey 15 to 20 minutes. Cook for

approximately 3 hours. The basting

sauce combined with turkey drippings

makes a delicious gravy.

The manufacturer warrants to the original consumer-purchaser only that this product (Model #720-0958AE) shall be free from defects in

workmanship and materials after correct assembly and under normal and reasonable home use for the periods indicated below beginning on

the date of purchase. The manufacturer reserves the right to require photographic evidence of damage, or that defective parts be returned,

postage and/or freight pre-paid by the consumer, for review and examination. Nexgrill’s obligation is limited to repair, replacement, or

depreciated value, at the option of Nexgrill.

• TUBE BURNERS: 10 year LIMITED warranty against perforation.

• COOKING GRIDS and FLAME TAMERS: 1 year LIMITED warranty; does not cover dropping, chipping, scratching, or surface damage.

• STAINLESS STEEL PARTS: 1 year LIMITED warranty against perforation; does not cover cosmetic issues like surface corrosion, scratches

and rust.

• ALL OTHER PARTS: 1 year LIMITED warranty (Includes, but not limited to, valves, frame, housing, cart, control panel, igniter, regulator,

hoses) *Does not cover chipping, scratching, cracking surface corrosion, scratches or rust.

Upon consumer supplying proof of purchase as provided herein, Manufacturer will repair or replace the parts which are proven defective

during the applicable warranty period. Parts required to complete such repair or replacement shall be free of charge to you except for shipping

costs, as long as the purchaser is within the warranty period from the original date of purchase. The original consumer-purchaser will be

responsible for all shipping charges of parts replaced under the terms of this limited warranty. This limited warranty is applicable in the United

States and Canada only, is only available to the original owner of the product and is not transferable. Manufacturer requires reasonable proof

of your date of purchase. Therefore, you should retain your sales receipt and/or invoice. If the unit was received as a gift,please ask the gift-

giver to send in the receipt on your behalf, to the below address. Defective or missing parts subject to this limited warranty will not be replaced

without registration or proof of purchase. This limited warranty applies to the functionality of the product ONLY and does not cover cosmetic

issues such as scratches, dents, corrosions or discoloring by heat, abrasive and chemical cleaners or any tools used in the assembly or

installation of the appliance, surface rust, or the discoloration of stainless steel surfaces. Surface rust, corrosion, or powder paint chipping on

metal parts that does not affect the structural integrity of the product is not considered a defect in workmanship or material and is not covered

by this warranty. This limited warranty will not reimburse you for the cost of any inconvenience, food, personal injury or property damage. If

an original replacement part is not available, a comparable replacement part will be sent. You will be responsible for all shipping charges of

parts replaced under the terms of this limited warranty.

MANUFACTURER WILL NOT PAY FOR:

• Service calls to your home.

• Repairs when your product is used for other than normal, single-family household or residential use.

• Damage resulting from accident, alteration, misuse, lack of maintenance/cleaning, abuse, fire, flood, acts of God, improper installation,

and installation not in accordance with electrical or plumbing codes or misuse of product.

• Any food loss due to product failures.

• Replacement parts or repair labor costs for units operated outside the United States or Canada.

• Pickup and delivery of your product.

• Postage fees or photo processing fees for photos sent in as documentation.

• Repairs to parts or systems resulting from unauthorized modifications made to the product.

• The removal and/or reinstallation of your product.

• Shipping cost, standard or expedited, for warranty/non warranty and replacement parts.

DISCLAIMER OF IMPLIED WARRANTIES; LIMITATION OF REMEDIES

Repair or replacement of defective parts is your exclusive remedyunder the terms of this limited warranty. Manufacturer will not be

responsible for any consequential or incidental damages arising from the breach of either this limited warranty or any applicable implied

warranty, or for failure or damage resulting from acts of God, improper care and maintenance, grease fire, accident, alteration, replacement of

parts by anyone other than manufacturer, misuse, transportation, commercial use, abuse, hostile environments (inclement weather, acts of

nature, animal tampering), improper installation or installation not in accordance with local codes or printed manufacturer instructions.

THIS LIMITED WARRANTY IS THE SOLE EXPRESS WARRANTY GIVEN BY THE MANUFACTURER. NO PRODUCT PERFORMANCE

SPECIFICATION OR DESCRIPTION WHEREVER APPEARING IS WARRANTED BY MANUFACTURER EXCEPT TO THE EXTENT SET

FORTH IN THIS LIMITED WARRANTY. ANY IMPLIED WARRANTY PROTECTION ARISING UNDER THE LAWS OF ANY STATE,

INCLUDING IMPLIED WARRANTY OF MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE OR USE, IS HEREBY LIMITED

IN DURATION TO THE DURATION OF THIS LIMITED WARRANTY.

Neither dealers nor the retail establishment selling this product has any authority to make any additional warranties or to promise remedies in

addition to or inconsistent with those stated above. Manufacturer's maximum liability, in any event, shall not exceed the documented purchase

price of the product paid by the original consumer. This warranty only applies to units purchased from an authorized retailerand or re-seller.

NOTE: Some states do not allow an exclusion or limitation of incidental or consequential damages, so some of the above limitations or

exclusions may not apply to you; this limited warranty gives you specific legal rights as set for herein. You may also have other rights which

vary from state to state.

If you wish to obtain performance of any obligation under this limited warranty, you should write to:

Nexgrill Customer Relations

14050 Laurelwood PI

Chino, CA 91710

All consumer returns, parts orders, general questions, and troubleshooting assistance can be acquired by calling

1-866-984-7455 in USA and 1-800-648-5864 in Canada, language spoken: English, Spanish, French 8 a.m.-5 p.m., PST.

Monday-Friday.

LIMITED WARRANTY

Dépannage . . . . . . . . . . . . . . . . . . . . . . . . .

Commande de pièces . . . . . . . . . . . . . . . . .

Conseils relatifs au gril . . . . . . . . . . . . . . . .

Aide-mémoire pour la cuisson. . . . . . . . . . .

Suggestion de recettes pour grillades. . . . .

Garantie limitée. . . . . . . . . . . . . . . . . . . . . .

Vue éclatée . . . . . . . . . . . . . . . . . . . . . . . . .

Liste des pièces . . . . . . . . . . . . . . . . . . . . .

Mesures de sécurité . . . . . . . . . . . . . . . . . .

Raccordement au gaz . . . . . . . . . . . . . . . .

Liste de contrôle finale de l’installateur . . . .

Test de fuite. . . . . . . . . . . . . . . . . . . . . . . . .

Consignes d'utilisation. . . . . . . . . . . . . . . . .

Consignes pour l'allumage du gril. . . . . . . .

Composante d'identification. . . . . . . . . . . . .

Nettoyage et entretien. . . . . . . . . . . . . . . . .

Table des matières

L'injecteur comporte une indication de taille. Par exemple, "0.92" indique que la taille de la buse d'injection est de 0,92 mm.

Nexgrill Industries, Inc.

14050 Laurelwood Pl Chino, CA 91710 USA

2531-18

Modèle 720-0958AE

Appareil catégorie I

3+(28-30/37)

3B/P(30)

3B/P(37)

3B/P(50)

Type de gaz Butane Propane Butane, propane ou leur mélange

La pression du gaz (mbar) 28-30 37 30 37 50

Taille de l'injecteur du brûleur principal (Ø mm) 0.92 0.92 0.84 0.81

Taille de l'injecteur du brûleur pour saisir (Ø mm) 1.02 1.02 0.94 0.84

Apport de chaleur nominale (Hs) (kW) Total: 18.4

La consommation de gaz (g/h) (total)

Butane - Total: 1339

Propane - Total: 1315

Mesures de sécurité

DANGER

1. Ne jamais utiliser cet appareil sans surveillance.

2. Ne jamais utiliser cet appareil dans les 3,05 m d’une structure, de matériel combustible ou

autre bouteille de gaz.

3. Ne jamais utiliser cet appareil dans les 7,62 m de liquides inflammables.

4. Ne jamais remplir le compartiment de cuisson au-delà de la ligne maximum de remplissage.

5. Les liquides chauffés restent à des températures de cuisson longtemps après la cuisson.

Ne jamais toucher l’appareil de cuisson tant que les liquides ne se sont pas refroidis à une

température de 46 ºC ou moins.

6. Cet appareil n’est pas destiné à servir d’élément chauffant et ne doit pas être utilisé en tant

que tel.

7. Si un incendie se déclenche, tenez-vous à l'écart de l'appareil et contactez immédiatement

le service des pompiers. Ne pas essayer d’éteindre un incendie d’huile ou de graisse avec

de l’eau.

8. Le tuyau souple pour connecteur ne doit pas dépasser 1,5 mètre.

9. Ne modifiez pas l'appareil.

10. Utilisez uniquement en plein air! Lisez les instructions avant d 'utiliser l' appareil.

11. Ne pas déplacer l 'appareil pendant l' utilisation.

12. Fermer le robinet du récipient de gaz après usage.

13. Les pièces accessibles peuvent être très chaudes. Garder les jeunes enfants loin.

14. Il est recommandé de changer le tuyau flexible lorsque les conditions le nécessitent.

La non-conformité aux présentes consignes peut déclencher un incendie ou une explosion

qui sont susceptibles d’entraîner des lésions corporelles graves voire la mort ou des

dommages matériels.

Les pièces scellées par le fabricant ne doivent pas être modifiées par l'utilisateur.

Votre gril deviendra très chaud. Ne vous penchez jamais au-dessus de l'aire de cuisson

pendant l'utilisation de votre gril. Ne touchez pas aux surfaces de cuisson, au boîtier du

gril, au couvercle ou à toute autre pièce pendant l’utilisation du gril et tant qu'il n’a pas

refroidi après l'usage.

DANGER

Si vous sentez une odeur de gaz:

• Coupez l'alimentation du gaz à l'appareil.

• Éteignez toute flamme nue.

• Soulevez le couvercle.

• Si l'odeur persiste, tenez-vous à l'écart

de l'appareil et contactez immédiatement

votre fournisseur de gaz ou le service

des pompiers.

AVERTISSEMENT

1. Ne pas entreposer ou utiliser de

l'essence ou tout autre liquide ou vapeur

inflammable près de cet appareil ou de

tout autre appareil.

2. Une bouteille de gaz de pétrole liquéfié

qui n'est pas branchée pour utilisation ne

doit pas être entreposée près de cet

appareil ou de tout autre appareil.

La page charge ...

Nexgrill 720-0958AE Mode d'emploi

Marque: Nexgrill

Modèle: 720-0958AE

Catégorie: Barbecues

Taper: Mode d'emploi

Télécharger le PDF

rapport

dans d''autres langues

English: Nexgrill 720-0958AE Operating instructions
español: Nexgrill 720-0958AE Instrucciones de operación

Nexgrill 720-0958AE Mode d'emploi

Nexgrill 720-0958AE Mode d'emploi

dans d''autres langues

Documents connexes

Autres documents