EGO LB5302-FC Manuel utilisateur

Español p. 47

Français p. 23

WARNING: To reduce the risk of injury, the user must read and understand the

Operator’s Manual before using this product. Save these instructions for future reference.

OPERATOR’S MANUAL

56-VOLT LITHIUM-ION

CORDLESS BLOWER

MODEL NUMBER LB5300/LB5300-FC

Notice: The Blower is intended for household or commercial use

56V LITHIUM-ION CORDLESS BLOWER — LB5300/LB5300-FC2

TABLE OF CONTENTS

Safety Guidelines .........................................4

Important Safety Instructions ............................5-10

Introduction .........................................10-11

Specications ..........................................11

Assembly ...........................................12-13

Description ............................................14

Operation ...........................................15-18

Maintenance ...........................................19

Troubleshooting .........................................20

Warranty ...........................................21-22

56V LITHIUM-ION CORDLESS BLOWER — LB5300/LB5300-FC 3

READ ALL INSTRUCTIONS!

WARNING:

Some dust created by power sanding, sawing, grinding, drilling

and other construction activities contains chemicals known to the state of California

to cause cancer, birth defects or other reproductive harm. Some examples of these

chemicals are:

 Lead from lead-based paints,

 Crystalline silica from bricks and cement and other masonry products, and

 Arsenic and chromium from chemically-treated lumber.

Your risk from these exposures varies, depending on how often you do this type of

work. To reduce your exposure to these chemical: work in a well ventilated area, and

work with approved safety equipment, such as those dust masks that are specially

designed to lter out microscopic particles.

56V LITHIUM-ION CORDLESS BLOWER — LB5300/LB5300-FC4

SAFETY GUIDELINES

SAFETY SYMBOLS

The purpose of safety symbols is to attract your attention to possible dangers. The

safety symbols and the explanations with them deserve your careful attention and

understanding. The symbol warnings do not, by themselves, eliminate any danger. The

instructions and warnings they give are no substitutes for proper accident prevention

measures.

WARNING:

Be sure to read and understand all safety instructions in this

Operator’s Manual, including all safety alert symbols such as “DANGER,” “WARNING,”

and “CAUTION” before using this tool. Failure to following all instructions listed below

may result in electric shock, re, and/or serious personal injury.

DAMAGE PREVENTION AND INFORMATION MESSAGES

These inform the user of important information and/or instructions that could lead

to equipment or other property damage if they are not followed. Each message is

preceded by the word “NOTICE”, as in the example below:

NOTICE: Equipment and/or property damage may result if these instructions are not

followed.

WARNING:

The operation of any power tools can result in

foreign objects being thrown into your eyes, which can result in severe

eye damage. Before beginning power tool operation, always wear

safety goggles or safety glasses with side shields and a full face shield

when needed. We recommend a Wide Vision Safety Mask for use over

eyeglasses or standard safety glasses with side shields. Always use eye

protection which is marked to comply with ANSI Z87.1.

56V LITHIUM-ION CORDLESS BLOWER — LB5300/LB5300-FC 5

IMPORTANT SAFETY INSTRUCTIONS

This page depicts and describes safety symbols that may appear on this product.

Read, understand, and follow all instructions on the machine before attempting to

assemble and operate.

Safety Alert Precautions that involve your safety.

Read Operator’s

Manual

To reduce the risk of injury, user must read

and understand operator’s manual before

using this product.

Long Hair

Failure to keep long hair away from the air

inlet could result in personal injury.

Loose Clothing

Failure to keep loose clothing from being

drawn into air intake vents could result in

personal injury.

Eye Protection

Always wear safety goggles or safety glasses

with side shields and a full face shield when

operating this product.

Blower Tube Do not operate without tube in place.

Keep Bystanders

Away

Keep all bystanders at least 50 ft. away.

Recycle Symbols

This product uses lithium-ion (Li-ion) batteries.

Local, state, or federal laws may prohibit

disposal of batteries in ordinary trash. Consult

your local waste authority for information

regarding available recycling and/or disposal

options.

56V LITHIUM-ION CORDLESS BLOWER — LB5300/LB5300-FC6

IPX4

Ingress Protection

Degree

Protection from splashing water

V Volt Voltage

A Amperes Current

Hz Hertz Frequency (cycles per second)

W Watt Power

min Minutes Time

CFM

Cubic Feet Per

Minute

Air volume

MPH Miles Per Hour Air velocity

Alternating Current Type of current

Direct Current Type or a characteristic of current

n

0

No Load Speed Rotational speed, at no load

... /min Per Minute

Revolutions, strokes, surface speed, orbits,

etc., per minute

When using an electrical appliance, basic precautions should always be followed,

including the following:

READ ALL INSTRUCTIONS BEFORE USING THIS PRODUCT!

WARNING:

To ensure safety and reliability, all repairs should be performed by a

qualied service technician.

WARNING:

To reduce risk of re, electric shock, or injury:

 Know your power blower. Read the instruction manual carefully. Learn

the blower’s applications and limitations, as well as the specic potential

hazards related to this blower. Following this rule will reduce the risk of electric

shock, re, or serious injury.

 Do not allow the blower to be used as a toy. Close attention is necessary when

used by or near children.

56V LITHIUM-ION CORDLESS BLOWER — LB5300/LB5300-FC 7

 Use only as described in this manual. Use only manufacturer’s

recommended attachments.

 If the blower is not working as it should, has been dropped, damaged, left

outdoors, or dropped into water, return it to a service center.

 Do not handle the charger, including charger plug, or charger terminals

with wet hands.

 Do not put any object into any openings. Do not use with any opening

blocked; keep openings free of dust, lint, hair, and anything that may

reduce air ow.

 Keep hair, loose clothing, ngers, and all parts of body away from openings

and moving parts. Loose clothes, jewelry, or long hair can be drawn into air

vents.

 Secure long hair above shoulder level to prevent entanglement in moving

parts.

 Use extra care when cleaning on stairs.

 Do not charge the battery pack outdoors.

 Use only the charger supplied by the manufacturer to recharge.

 Do not leave blower unattended when the battery is inserted. Remove the

battery when the blower is not in use and before servicing.

 Do not operate blowers in explosive atmospheres, such as in the presence

of ammable liquids, gases, or dust. Blowers create sparks which may ignite

the dust or fumes.

 Use the battery operated blower only with specically designated battery

pack. Use of any other batteries may create a risk of re.

 Use only with battery packs and chargers listed below.

BATTERY PACK CHARGER

BA1120, BA1120-FC,

BA1400, BA1400-FC,

BA2240, BA2240-FC,

BA2800, BA2800-FC,

BA4200, BA4200-FC

CH2100, CH2100-FC,

CH5500, CH5500-FC

56V LITHIUM-ION CORDLESS BLOWER — LB5300/LB5300-FC8

 Stay alert, watch what you are doing and use common sense when

operating a power blower. Do not use the blower while tired, upset, or

under the inuence of drugs, alcohol, or medication. A moment of inattention

while operating blowers may result in serious personal injury.

 Avoid accidental starting. Be sure that the switch is in the locked or off

position before inserting the battery pack. Carrying blowers with your nger

on the switch or inserting the battery pack into a blower with the switch on invites

accidents.

 Use safety equipment. Always wear eye protection. Dust mask, non-skid safety

shoes, hard hat, or hearing protection must be used for appropriate conditions.

 Do not use on a ladder, rooftop, tree, or other unstable support. Stable footing

on a solid surface enables better control of the blower in unexpected situations.

 Always take care of your feet, children, or pets around you when removing the

battery pack from blower. Serious injury could result if the battery pack falls.

NEVER remove the battery pack when in a high position.

 Do not use the blower if switch does not turn it on or off. A blower that

cannot be controlled with the switch is dangerous and must be repaired.

 Disconnect the battery pack from the blower before making any

adjustments, changing accessories, or storing the blower. Such preventive

safety measures reduce the risk of starting the blower accidentally.

 Turn off all controls before removing the battery.

 DO NOT attempt to clear clogs from the unit without rst removing the battery.

 Check for misalignment or binding of moving parts, breakage of parts, and

any other condition that may affect the blower’s operation. If damaged,

have the blower serviced before using. Many accidents are caused by poorly

maintained blowers.

 Keep the blower and its handle dry, clean and free from oil and grease. Always

use a clean cloth when cleaning. Never use brake uids, gasoline, petroleum-based

products, or any strong solvents to clean your blower. Following this rule will reduce

the risk of loss of control and deterioration of the enclosure plastic.

 Always wear safety glasses with side shields. Everyday glasses have only

impact resistant lenses. They are NOT safety glasses. Following this rule will

reduce the risk of eye injury.

56V LITHIUM-ION CORDLESS BLOWER — LB5300/LB5300-FC 9

 Always wear eye protection with side shields marked to comply with ANSI

Z87.1 along with hearing protec tion when operating this equipment.

 Protect your lungs. Wear a face or dust mask if the operation is dusty.

Following this rule will reduce the risk of serious personal injury.

 Protect your hearing. Wear hearing protection during extended periods of

operation. Following this rule will reduce the risk of serious personal injury.

 Battery powered blowers do not have to be plugged into an electrical

outlet; therefore, they are always in operating condition. Be aware of

possible hazards when not using your battery powered blower or when

changing accessories. Following this rule will reduce the risk of electric shock,

re, or serious personal injury.

 Wear heavy long pants, long sleeves and boots. Avoid loose garments or

jewelry that could get caught in moving parts of the machine or its motor.

 Do not operate the equipment while barefoot or when wearing sandals or

similar lightweight footwear. Wear protective footwear that will protect your

feet and improve your footing on slippery surfaces.

 Do not incinerate the appliance even if it is severely damaged. The batteries

can explode in a re.

 Batteries can explode in the presence of a source of ignition, such as a

pilot light. To reduce the risk of serious personal injury, never use any cordless

product in the presence of open ame. An exploded battery can propel debris and

chemicals. If exposed, ush with water immediately.

 Keep rm footing and balance. Do not overreach. Overreaching can result in

loss of balance.

 Check the work area before each use. Remove all objects such as rocks,

broken glass, nails, wire, or string which can be thrown by or become entangled

in the machine.

 Do not point the blower tube in the direction of people or pets.

 Never run the unit without the proper equipment attached. Always ensure

that the blower tube is installed.

 When not in use, the blower should be stored indoors in a dry, secure place

out of the reach of children.

56V LITHIUM-ION CORDLESS BLOWER — LB5300/LB5300-FC10

 Keep all bystanders, children, and pets at least 50 ft. away.

 Blower service must be performed only by qualied repair personnel.

Service or maintenance performed by unqualied personnel may result in a risk of

injury.

 When servicing a blower, use only identical replacement parts. Follow

instructions in the Maintenance section of this manual. Use of unauthorized parts

or failure to follow Maintenance Instructions may create a risk of shock or injury.

 Never use the blower near res or hot ashes. Use near res or ashes can

spread res and result in serious injury and/or property damage.

 Never use blower to spread chemicals, fertilizers, or any other toxic

substances. Spreading these substances could result in serious injury to the

operator or bystanders.

 Never place the blower on any surface, except a hard, clean surface when

the engine is running. Gravel, sand, and other debris can be picked up by the air

inlet and thrown at the operator or bystanders, causing possible serious injuries.

 Do not expose a battery pack or tool to re or excessive temperature.

Exposure to re or temperature above 212 °F (100°C) may cause explosion.

 Save these instructions. Refer to them frequently and use them to instruct

others who may use this tool. If you loan this tool to someone else, also loan these

instructions to them to prevent misuse of the product and possible injury.

SAVE THESE INSTRUCTIONS!

INTRODUCTION

Congratulations on your selection of the new 56V Lithium-ion powered blower. It

has been designed, engineered and manufactured to give you the best possible

dependability and performance.

Should you experience any problem you cannot easily remedy, please contact EGO

customer service center 1-855-EGO-5656.

This manual contains important information on to the safe assembly, operation and

maintenance of your product Read it carefully before using the product. Keep this

manual handy so you can refer to it at any time.

56V LITHIUM-ION CORDLESS BLOWER — LB5300/LB5300-FC 11

SERIAL NUMBER _____________________ DATE OF PURCHASE _________________

YOU SHOULD RECORD BOTH SERIAL NUMBER AND DATE OF PURCHASE AND KEEP THEM IN A

SAFE PLACE FOR FUTURE REFERENCE

SPECIFICATIONS

Voltage

56V

No Load Speed

Boost: 23000 RPM

High:18000 RPM

Low:10000 RPM

Air Volume

Boost: 530 CFM

High: 400 CFM

Low: 260 CFM

Air Velocity

Boost: 110 MPH

High: 85 MPH

Low: 50 MPH

Approx. Run Time

(with EGO BA1400/BA1400-FC 56V

Battery 2.5Ah)

10 min.(Boost)

22 min. (High speed)

75 min. (Low speed)

Recommended Operating Temperature 5°F-104°F(-15°C-40°C)

Recommended Storage Temperature -4°F-158°F(-20°C-70°C)

Blower Weight (Without battery pack,

with tube)

4.81 lb. (2.18 kg)

56V LITHIUM-ION CORDLESS BLOWER — LB5300/LB5300-FC12

ASSEMBLY

WARNING:

If any parts are damaged or missing, do not operate this product

until the parts are replaced. Use of this product with damaged or missing parts could

result in serious personal injury.

WARNING:

Do not attempt to modify this product or create accessories not

recommended for use with this blower. Any such alteration or modication is misuse

and could result in a hazardous condition leading to possible serious personal injury.

UNPACKING

 Carefully remove the product and any accessories from the box. Make sure that

all items listed in the packing list are included.

WARNING:

Do not use this product if any parts on the packing list are already

assembled to your product when you unpack it. Parts on this list are not assembled to

the product by the manufacturer and require customer installation. Use of a product

that may have been improperly assembled could result in serious personal injury.

 Inspect the tool carefully to make sure no breakage or damage occurred during

shipping.

 Do not discard the packing material until you have carefully inspected and

satisfactorily operated the tool.

 If any parts are damaged or missing, please return the product to the place of

purchase.

LIST OF PARTS

PART NAME QUANTITY

Blower 1

Blower tube 1

Operator’s manual 1

56V LITHIUM-ION CORDLESS BLOWER — LB5300/LB5300-FC 13

ASSEMBLING THE BLOWER TUBE

WARNING:

To prevent accidental starting that could cause serious personal

injury, always remove the battery pack from the tool when assembling parts.

1. Align the groove in the tube

with the knob on the blower

housing. Push the tube onto the

blower housing until the latch

snaps into place (Fig. 1 & 2).

2. To remove the tube, press and

hold the tube-release button

to disengage the latch, then

pull the tube straight from the

blower (Fig. 3).

1

2

3

56V LITHIUM-ION CORDLESS BLOWER — LB5300/LB5300-FC14

DESCRIPTION

KNOW YOUR BLOWER (Fig. 4)

The safe use of this product requires and understanding of the information on the tool and

in this instruction manual as well as knowledge of the project you are attempting. Before

use of this product, familiarize yourself with all operating features and safety rules.

Tube Release Button

Electric Contacts

Latch

Battery Release

Button

Overmold

Handle

Boost Button

Air-Velocity

Adjustment Knob

Ejection

Mechanism

Trigger

Air Inlet

Blower Tube

Air Outlet

4

Shoulder-Strap

Mount

Trigger Starts or stops the blower.

Boost Button Amplies the air velocity to the maximum, regardless of

adjustment knob setting.

Air-Velocity

Adjustment Knob

Increases or reduces the air velocity of the blower.

Battery-Release Button Releases the battery pack from the blower.

Latch Locks the battery pack when installing it on the blower.

Shoulder Strap Mount For use with a shoulder strap.

Overmold Handle Ergonomic handle with overmold improves comfort

and grip.

56V LITHIUM-ION CORDLESS BLOWER — LB5300/LB5300-FC 15

OPERATION

WARNING:

Do not allow familiarity with this product to make you careless.

Remember that a careless fraction of a second is sufcient to inict serious injury.

WARNING:

Always wear eye protection with side shields marked to comply with

ANSI Z87.1, along with hearing protection. Failure to do so could result in objects being

thrown into your eyes and other possible serious injuries.

WARNING:

Do not use any attachments or accessories not recommended by the

manufacturer of this product. The use of attachments or accessories not recommended

can result in serious personal injury.

Before each use, inspect the entire product for damaged, missing, or loose parts, such

as screws, nuts, bolts, caps,etc. Tighten securely all fasteners and caps and do not

operate this product until all missing or damaged parts are replaced.

APPLICATION

You may use this product for the purposes listed below:

 Clearing hard surfaces such as driveways and walkways

 Keeping decks and driveways free from leaves and pine needles

56V LITHIUM-ION CORDLESS BLOWER — LB5300/LB5300-FC16

TO INSTALL/REMOVE BATTERY PACK (Fig. 5)

CHARGE BEFORE FIRST USE.

WARNING:

Always remove the battery pack from the product when you are

assembling parts, making adjustments, cleaning, or when not in use. Removing the

battery pack will prevent accidental starting that could cause serious personal injury.

TO INSTALL

 Align the ribs of the battery pack with the mounting slots in the blower’s

battery port.

 Press the battery pack down until it snaps into position.

TO REMOVE

WARNING:

Always take care to note the location of your feet, children, or pets

when pressing the battery-release button. Serious injury could result if the battery pack

falls. NEVER remove the battery pack when in a high location.

 Press the battery-release button; the battery pack will disengage from the latch

and the ejection mechanism will assist with removal.

 Remove the battery pack from the blower.

5

Battery Release Button

Mounting Slot

56V LITHIUM-ION CORDLESS BLOWER — LB5300/LB5300-FC 17

STARTING/STOPPING THE BLOWER (Fig. 6)

 To start the blower, depress the trigger. The blower will begin to run.

 To stop the blower, release the trigger.

ADJUSTING THE AIR VELOCITY (Fig. 6)

6

Air Velocity Adjusting Knob

Boost Button

Trigger

The blower is equipped with stepless speed regulation to control the air speed.

To increase the air velocity, turn the air velocity adjusting knob clockwise when the

blower runs; to reduce the air velocity, turn the knob counterclockwise.

To enhance the air velocity, press the boost button to temporarily amplify the air

speed to the maximum. The blower will resume the previous speed when this button

is released.

56V LITHIUM-ION CORDLESS BLOWER — LB5300/LB5300-FC18

OPERATING THE BLOWER

 To keep from scattering debris, blow around the outer edges of a debris pile.

Never blow directly into the center of a pile.

 To reduce sound levels, limit the number of pieces of equipment used at any

one time.

 Use rakes and brooms to loosen debris before blowing. In dusty conditions,

slightly dampen surfaces if water is available.

 Conserve water by using power blowers instead of hoses for many lawn and

garden applications, including areas such as gutters, screens, patios, grills,

porches, and gardens.

 Watch out for children, pets, open windows, or freshly washed cars, and blow

debris safely away.

 After using blowers or other equipment, clean up! Dispose of debris properly.

56V LITHIUM-ION CORDLESS BLOWER — LB5300/LB5300-FC 19

MAINTENANCE

WARNING:

When servicing, use only identical replacement parts. Use of any

other parts may create a hazard or cause product damage. To ensure safety and

reliability, all repairs should be performed by a qualied service technician.

WARNING:

To avoid serious personal injury, always remove the battery pack

from the product when cleaning or performing any maintenance.

GENERAL MAINTENANCE

Avoid using solvents when cleaning plastic parts. Most plastics are susceptible to

damage from various types of commercial solvents and may be damaged by their use.

Use clean cloths to remove dirt, dust, oil, grease, etc.

WARNING:

Do not at any time let brake uids, gasoline, petroleum-based

products, penetrating oils, etc., come in contact with plastic parts. Chemicals can

damage, weaken or destroy plastic which may result in serious personal injury.

STORAGE

 Clean all foreign material from the air inlets of the blower.

 Store indoors in a place that is inaccessible to children. Keep away from corrosive

agents, such as garden chemicals and de-icing salts.

56V LITHIUM-ION CORDLESS BLOWER — LB5300/LB5300-FC20

TROUBLESHOOTING

PROBLEM CAUSE SOLUTION

Blower doesn’t work.

 The battery pack is not

attached to the blower.

 No electrical contact

between the blower

and battery

 The battery pack is

depleted.

 The battery pack or

blower is too hot.

 Attach the battery pack

to the blower.

 Remove battery, check

contacts and reinstall

the battery pack.

 Charge the battery

pack.

 Cool the battery pack

and blower until the

temperature drops

below 152°F (67°C).

The air velocity

decreases obviously.

 Excessive wearing of

motor fan.

 The air inlet is blocked

by debris.

 Contact EGO service

center for repair.

 Remove the battery

pack, clear the debris.

La page charge ...

EGO LB5302-FC Manuel utilisateur

Ce manuel convient également à

EGO LB5302-FC Manuel utilisateur

dans d''autres langues

Documents connexes

Autres documents