Englander 25-IPS Manuel utilisateur

IMPERIALPELLETSTOVE



 



CAUTION

PLEASEREADTHISENTIREMANUALBEFOREINSTALLATIONANDUSEOFTHISPELLETFUEL‐BURNING

APPLIANCE.KEEPCHILDREN,FURNITURE,ANDALLCOMBUSTIBLESAWAYFROMANYHEATINGAPPLIANCE.



SAFETYNOTICE

FAILURETOFOLLOWTHESEINSTRUCTIONSCANRESULTINPROPERTYDAMAGE,BODILYINJURYOREVEN

DEATH.FORYOURSAFETYANDPROTECTION,FOLLOWTHEINSTALLATIONINSTRUCTIONSOUTLINEDIN

THISMANUAL.CONTACTYOURLOCALBUILDINGORFIREOFFICIALSABOUTRESTRICTIONSAND

INSTALLATIONINSPECTIONREQUIREMENTS(INCLUDINGPERMITS)INYOURAREA.



ManufacturedBy:

England’sStoveWorks,Inc.

POBox206

Monroe,VA24574

Rev.5/2015

SAVETHESEINSTRU CTIONS

INSTALLATION&OPERATION

MANUAL

25‐IP/55‐SHPIP/55‐TRPIP

25‐IPS/55‐SHPIPS/55‐TRPIPS

2

IMPORTANT! READ AND FOLLOW ALL INSTALLATION AND MAINTENANCE INSTRUCTIONS, INCLUDING CLEANING THE

UNIT AS SPECIFIED, AND REPLACING GASKETS ANNUALLY, AND PARTS AS NEEDED.

ENGLAND’S STOVE WORKS IS NOT RESPONSIBLE FOR ANY DAMAGE OR INJURY INCURRED DUE TO NEGLECT, OR DUE TO

UNSAFE INSTALLATION OR USAGE OF THIS PRODUCT. CALL TECHNICAL SUPPORT WITH ANY QUESTIONS.

IMPORTANT:IFYOUHAVEAPROBLEMWITHTHISUNIT,DONOTRETURNITTO

THEDEALER.CONTACTTECHNICALSUPPORT@1‐800‐245‐6489



MobileHomeUse:

Thisfreestandingpelletunitisapprovedformobilehomeordoublewide

installationwiththeoutsidecombustionairhook‐up.Seethe“Installation”

sectionofthismanualfordetailspertainingtomobilehomeinstallations.Mobile

homeinstallationmustbeinaccordancewiththeManufacturedHomeandSafety

Standard(HUD),CFR3280,Part24.



WARNING:



USEOFOUTSIDECOMBUSTIONAIRISMANDATORYWITHTHISUNIT.

DONOTOPERATEWITHTHEHOPPEROPEN;LIDMUSTBESHUTANDTIGHTLY

LATCHEDDURINGOPERATION.



Note:England’sStoveWorksdoesnotrecommendusingapelletstoveasyour

onlysourceofheat.



Retain for your files

Model Number

Date of Purchase

Date of Manufacture

Serial Number



3

IMPORTANT! READ AND FOLLOW ALL INSTALLATION AND MAINTENANCE INSTRUCTIONS, INCLUDING CLEANING THE

UNIT AS SPECIFIED, AND REPLACING GASKETS ANNUALLY, AND PARTS AS NEEDED.

ENGLAND’S STOVE WORKS IS NOT RESPONSIBLE FOR ANY DAMAGE OR INJURY INCURRED DUE TO NEGLECT, OR DUE TO

UNSAFE INSTALLATION OR USAGE OF THIS PRODUCT. CALL TECHNICAL SUPPORT WITH ANY QUESTIONS.

TABLEOFCONTENTS

Introduction

 Introduction.......................................4

Specifications

 HeatingSpecifications.......................5

 Dimensions........................................5

 EPACompliance.................................5

Installation

 InstallationOverview.........................6

 ClearancestoCombustibles..............7

 VentingIntroduction.........................8

 VentingGuidelines............................8

 AdditionalVentingInformation.........9

 ApprovedVentingMethods

 ThroughtheWall................10

 ThroughtheCeiling............11

 ExistingChimney................12

 MobileHome

Installation................13

 VentTerminationClearances..........14

 OutsideAirHookup.........................15

 FloorProtection...............................16

DailyOperation

 GettingStarted................................17

 LightingaFire.............................17‐18

 ControlBoardSettings....................19

 ErrorCodes......................................20

 PowerFailure...................................21

 ThermostatInstallation...................22

 ThermostatOperation................22‐23

 OptionalAccessories.......................23

Maintenance

 Daily

 ImportantNotes.................24

 DailyAshRemoval.........24‐25

 CleaningtheBurnPot.........25

 Bi‐weekly

 BaffleRemoval...................26

 Monthly

 ImportantNotes............26‐27

 ExhaustChamber...........27‐28

 VentingPipe.......................28



 Yearly



ImportantNotes.................29

 ExhaustBlower...................30

 ConvectionBlower.............30

 CradleRemoval..................31

 HopperFines......................31

 CheckingGaskets...............31

TroubleshootingGuide

 Troubleshooting.........................32‐33

ReplacingComponents

 AugerMotor....................................34

 ConvectionBlower..........................35

 CombustionBlower.........................35

 VacuumSwitch................................36

 Igniter..............................................36

 Gaskets............................................37

 Glass................................................38

 ControlBoard..................................39

 WiringDiagram...............................40

 HopperLidLatches..........................41

 DoorLatch

.......................................42

 Magnets..........................................42

 HopperLid.......................................42

 Fiberboard.......................................43

 Panels..............................................43

 Finish...............................................43

IllustratedPartsDetail

 ExplodedPartsDiagram..................44

 PartsList.....................................45‐46

OtherDetails

 AshPanLatches..........................46

Warranty

 SerialTagSample............................47

 WarrantyDetails........................48‐49

 ImportantNotice.............................50

 WarrantyReg.Form........................51

4

IMPORTANT! READ AND FOLLOW ALL INSTALLATION AND MAINTENANCE INSTRUCTIONS, INCLUDING CLEANING

THE UNIT AS SPECIFIED, AND REPLACING GASKETS ANNUALLY, AND PARTS AS NEEDED.

ENGLAND’S STOVE WORKS IS NOT RESPONSIBLE FOR ANY DAMAGE OR INJURY INCURRED DUE TO NEGLECT,

OR DUE TO UNSAFE INSTALLATION OR USAGE OF THIS PRODUCT. CALL TECHNICAL SUPPORT WITH ANY

QUESTIONS.

INTRODUCTION

ThankyouforpurchasingthisfineproductfromEngland’sStoveWorks!

England’sStoveWorkswasstarted,andisstillownedby,afamilythat

believesstronglyina“DoItYourself”spirit;that’sonereasonyoufoundthis

productatyourfavorite“DoItYourself”store.

Weintentionallydesignandbuild

ourstovessothatanyhomeownercan

maintaintheirunitwithbasictools,andwe’realwaysmorethanhappyto

showyouhowtodothejobaseasilyandasinexpensivelyaspossible.

However,whileremainingsimple,ourstovesaredesignedtoperform

extremelyefficiently,helpingdelivermoreheat

fromlessfuel.

PleaselookatourvastHelpsectiononourwebsiteandcallourTechnical

SupportDepartmentat(800)245‐6489ifyouneedanyhelpwithyourunit.

Wearenearlyalwaysableto“walkyouthrough”anyinstallationissues,

repairs,problemsorotherquestionsthatyoumay

have.

Wishingyouyearsofefficient,qualityand“comfy”heating,

EVERYONEATENGLAND’SSTOVEWORKS

PleaseNote

:Whileinformationobtainedfromourwebsiteandthroughour

TechnicalSupportlineisalwaysfreeofcharge,therewillbeaservicecharge

incurredwithany“on‐site”repairsormaintenancethatwemayarrange.



Thismanualencompassesallversionsofthe25‐IP,including the55‐SHPIP,55‐SHPIPLand55‐TRPIP.Thisalso

appliestothestraightversionofthisunitwithmodelnumbers25‐IPS,55‐SHPIPSand55‐TRPIPS.However,for

simplicityofdescription,thestovewillbereferredtobythegeneric25‐IPdesignation.

5

IMPORTANT! READ AND FOLLOW ALL INSTALLATION AND MAINTENANCE INSTRUCTIONS, INCLUDING CLEANING

THE UNIT AS SPECIFIED, AND REPLACING GASKETS ANNUALLY, AND PARTS AS NEEDED.

ENGLAND’S STOVE WORKS IS NOT RESPONSIBLE FOR ANY DAMAGE OR INJURY INCURRED DUE TO NEGLECT,

OR DUE TO UNSAFE INSTALLATION OR USAGE OF THIS PRODUCT. CALL TECHNICAL SUPPORT WITH ANY

QUESTIONS.

SPECIFICATIONS

HeatingSpecifications

 HeatOutputRange**.................................................................... 14,108to35,023BTU/hr

 ApproximatePelletBurnRate**..........................................................0.945to2.346kg/hr

 MaximumBurnTime**..........................................................................................38hours

 ApproximateSquareFootageHeated***................................................up to2,200sq.ft.

 HopperCapacity...................................................................................................80pounds 



Dimensions



  

EPAandSafetyComplianceSpecification s

 EPACompliance.......................................................................................................Certified

 ParticulateEmissions......................................................................................1.78grams/hr

 Efficiency*......................................................................................................................78%

 TestedTo.................. UL1482‐00,ASTME1509,ULC/ORD‐C1482‐M1990&ULCS627‐00

Notesforthisunit:Picturemaynotmatchyourunitifyouhavethestraightversion.Clearances

aretheminimumforthisunitandmayneedtobeincreasedinthereartohavepropervent

clearances.Followallventingmanufacturerclearancesandlocalcodes.



*‐Thisunitwasnottestedforefficiency;theefficiencyshownisadefaultvaluenormallyattainedbysimilar,certifiedpelletburningappliances.

**‐Heatoutput,burnrateandmaximumburntimeareheavilydependentonthetypeofpelletsburnedinthestove;assuch,thesenumbersmayvary.

***

‐Themaximumheatingcapacityofthisunitcanvarygreatlybasedonclimate,constructionstyle,insulationandamyriadofotherfactors.Usethis

informationinconjunctionwithaBTUlosscalculationforyourhometodetermineifthisunitwillbesufficientforyourneeds.

6

IMPORTANT! READ AND FOLLOW ALL INSTALLATION AND MAINTENANCE INSTRUCTIONS, INCLUDING CLEANING

THE UNIT AS SPECIFIED, AND REPLACING GASKETS ANNUALLY, AND PARTS AS NEEDED.

ENGLAND’S STOVE WORKS IS NOT RESPONSIBLE FOR ANY DAMAGE OR INJURY INCURRED DUE TO NEGLECT,

OR DUE TO UNSAFE INSTALLATION OR USAGE OF THIS PRODUCT. CALL TECHNICAL SUPPORT WITH ANY

QUESTIONS.

INSTALLATION

InstallationOverview

Whenchoosingalocationforyournewstove,thereareamultitudeoffactors

thatshouldbetakenintoaccountbeforebeginningtheinstallation.

1. TrafficPatterns–Tohelppreventaccidents,thestoveshouldbeplacedina

locationwhereitisoutofthewayofnormaltravel

throughthehome.

2. HeatFlow–Whendecidingonalocationforthestove,considerthewayheat

movesthroughoutyourhome.Installthestovewhereyouneedtheheat;

basementinstallationsoftendonotallowsufficientheattoflowtotheupper

floorsandatopfloorinstallationwill

notallowanyheattoreachthefloors

below.Alwaysconsiderthatheatrisesandwilltakethepathofleast

resistancewhileitisstillhot.

3. ExhaustLocation–Outsidewallsaregenerallythebestplacetoinstalla stove,

sincetheyalloweasyexhaustandintakeair

installation(usingourDuraVent

AC‐3000Kit,AC‐33000ifCanada).Ifthereisnotafeasiblewaytoinstallthe

stoveonanoutsidewall,therearemethodsforventingthestoveupthrough

theroof,buttheytendtobemorecostlybecausetheyinvolvetheuseofmore



pelletventpipeandcanoftenmakeoutsideairinstallationmoredifficult.

4. WallConstruction–Locatingthestovesothattheexhaustsystemcanpass

betweenstudswillsimplifytheinstallationandeliminatetheneedtoreframe

anysectionsofthewalltoaccommodatethewallthimble.

WARNING

 Donotstoreorusegasolineorotherflammablevaporsandliquidsinthevicinityofthisoranyother

appliance.

 DoNotOverfire–Ifanyexternalpartstartstoglow,youareoverfiring.Reducefeedrate.Overfiringwill

voidyourwarranty.

 Complywithallminimumclearancestocombustiblesasspecified.Failuretocomplymayresultinahouse

fire.

 Testedandapprovedforwoodpelletsonly.Burninganyotherfuelwillvoidyourwarranty.



7

IMPORTANT! READ AND FOLLOW ALL INSTALLATION AND MAINTENANCE INSTRUCTIONS, INCLUDING CLEANING

THE UNIT AS SPECIFIED, AND REPLACING GASKETS ANNUALLY, AND PARTS AS NEEDED.

ENGLAND’S STOVE WORKS IS NOT RESPONSIBLE FOR ANY DAMAGE OR INJURY INCURRED DUE TO NEGLECT,

OR DUE TO UNSAFE INSTALLATION OR USAGE OF THIS PRODUCT. CALL TECHNICAL SUPPORT WITH ANY

QUESTIONS.

INSTALLATION



ClearancestoCombustibles



 



UnittoSide

Wall(A)

UnittoRear

Wall(B)

UnittoCorner

(C)

UnitTopto

Ceiling

Min.Ceiling

Height

6in. 6in. 3in. 9in. 60in.

152.4mm 152.4mm 76.2mm 228.6mm 1524mm

Alcoveinstallationnotrecommendedforthisunit

CAUTION

 UnitcanbeveryHOTwhileinoperation.Keepchildrenaway.

 Supervisechildreninthesameroomasthisappliance.

 Alertchildrenandadultstothehazardsofhightemperatures.

 DoNOToperatewithprotectivebarriersopenorremoved.

 Keepclothing,furniture,draperiesandothercombustiblesaway.

 InstallationMUSTcomplywithlocal,regional,stateandnationalcodesandregulations.

 Consultlocalbuilding,fireofficialsorauthoritieshavingjurisdictionaboutrestrictions,

installationinspection,andpermits.

DONOTCONNECTTOANYAIRDISTRIBUTIONDUCTORSYSTEM

8

IMPORTANT! READ AND FOLLOW ALL INSTALLATION AND MAINTENANCE INSTRUCTIONS, INCLUDING CLEANING

THE UNIT AS SPECIFIED, AND REPLACING GASKETS ANNUALLY, AND PARTS AS NEEDED.

ENGLAND’S STOVE WORKS IS NOT RESPONSIBLE FOR ANY DAMAGE OR INJURY INCURRED DUE TO NEGLECT,

OR DUE TO UNSAFE INSTALLATION OR USAGE OF THIS PRODUCT. CALL TECHNICAL SUPPORT WITH ANY

QUESTIONS.

INSTALLATION

VentingIntroduction

 Thispelletstoveoperatesonanegativedraftsystem,whichpullscombustionairthroughthe

burnpotandpushestheexhaustairthroughtheventpipeandoutofthebuilding.Thisunitmustbe

installedinaccordancewiththefollowingdetaileddescriptionsofventingtechniques;notinstallingthe

stoveinaccordancewiththedetailslistedherecanresultinpoorstoveperformance,property

damage,bodilyinjuryordeath.England’sStoveWorksisnotresponsibleforanydamageincurreddue

toapoororunsafeinstallation.

 Ifquestionsarisepertainingtothesafeinstallationofthestove,ourTechnicalSupportline

(800‐245‐6489)isavailable.Contactyourlocalcodeofficialtobecertainyourinstallationmeetslocal

andnationalfirecodesandifyou’reuncertainabouthowtosafelyinstallthestove,westrongly

recommendcontactingalocalNFIcertifiedinstallertoperformtheinstallation.

VentingGuidelines

 ALWAYSinstallventpipeinstrictadherencewiththeinstructionsandclearancesincludedwith

yourventingsystem.

 DONOTconnectthispelletstovetoachimneyfluewhichalsoservesanotherappliance.

 DONOTinstallafluepipedamperoranyotherrestrictivedeviceintheexhaustventingsystem

ofthisunit.

 USEanapprovedwallthimblewhenpassingthroughawallandaceilingsupport/firestopwhen

passingthroughaceiling.

 ONLYuse3.0”or4.0”TypeLorTypePLpipeapprovedforpelletstoveventing;DONOTuse

galvanizedorB‐Ventpipe.

 SEALeachjointofpelletventwithhightemperaturesilicone(Part#AC‐RTV3)topreventsmoke

spillageintothehome.

 AVOIDexcessivehorizontalrunsandelbows,asbothwillreducethedraftoftheventingsystem

andwillresultinpoorstoveperformance.

 INCLUDEasmuch

verticalpipeaspossibletopreventsmokefromtheunitfromenteringyour

homeintheeventofapoweroutage.

 INSPECTyourventingsystemoften,tobecertainitisclearoffly‐ashandotherrestrictions.

 CLEANtheventingsystemasdetailedinthemaintenancesectionof

thismanual.

WARNING

 INSTALLVENTATCLEARANCESSPECIFIEDBYTHEVENTMANUFACTURER.

 HOT!Donottouch!Severeburnsorclothingignitionmayresult.

 Glassandothersurfacesarehotduringoperation.

 Donotattempttotouchoropenthefrontorsidepanelsduringoperation.Thiscouldresultinsevere

burnsorinjury.

9

IMPORTANT! READ AND FOLLOW ALL INSTALLATION AND MAINTENANCE INSTRUCTIONS, INCLUDING CLEANING

THE UNIT AS SPECIFIED, AND REPLACING GASKETS ANNUALLY, AND PARTS AS NEEDED.

ENGLAND’S STOVE WORKS IS NOT RESPONSIBLE FOR ANY DAMAGE OR INJURY INCURRED DUE TO NEGLECT,

OR DUE TO UNSAFE INSTALLATION OR USAGE OF THIS PRODUCT. CALL TECHNICAL SUPPORT WITH ANY

QUESTIONS.

INSTALLATION

AdditionalVentingInformation

 Donotmixandmatchcomponentsfromdifferentpipemanufacturerswhenassemblingyour

ventingsystem(i.e.DoNOTuseventingpipefromonemanufacturerandathimblefrom

another).

 Werequireaminimumverticalriseof36in.(3ft.)ofpipetocreatenaturaldraftinthesystem,



whichhelpsevacuatesmokefromthestoveintheeventofapowerfailureorcombustion

blowerfailure.

 Ventingsystems15.0ft.orshortermaybecomposedentirelyof3.0in.pelletpipe;toreduce

frictionallosses,ventingsystemslongerthan15.0ft.shouldbecomposedof4.0in.

pelletpipe.

 Donotterminatetheventingsystemdirectlybeneathanycombustiblestructuresuchasa

porchordeck.

 FollowNFPA211ruleslistedbelowforventingsystemterminationlocationrelativetowindows

andotheropeningsinthedwelling.

o NFPA211(2006ed.)Section10.4Termination:10.4.5

(1)Theexitterminalofamechanicaldraftsystemotherthandirectventappliances

(sealedcombustionsystemappliances)shallbelocatedinaccordancewiththe

following:

 (a)Notlessthan3ft.(.91m)aboveanyforcedairinletlocatedwithin10ft.

(3.0m).

 (b)Notlessthan4ft.(1.2m)below,4ft.(1.2m)horizontallyfromor1ft.(305

mm)aboveanydoor,windoworgravityairinletintoanybuilding.

 (c)Notlessthan2ft.(0.61m)fromanadjacentbuildingandnotlessthan7ft.

(2.1m)abovegradewhenlocatedadjacenttopublicwalkways.

 Distancebetweentheterminationopeningandgradeshouldbeaminimumof2ft.(24in.)

contingentonthegradesurfacebelowthetermination.Whendeterminingthetermination

heightabovegrade,considersnowdriftlinesandcombustiblessuchasgrassorleaf

accumulation.Inareas

wheresignificantsnowfallispossible,theterminationheightmustbe

sufficientlyhightokeeptheterminationfreeofsnowaccumulation.

 Donotusemakeshiftcompromisesduringinstallationorinstallanycomponentoftheunitor

ventingsysteminsuchamannerthatcouldresultinahazardousinstallation.

 Achimneyconnectorshallnotpassthroughanatticorroofspace,closetorsimilarconcealed

space,orafloor,orceiling.

 Wherepassagethroughawallorpartitionofcombustiblematerialisdesired,theinstallation

shallconformtoCAN/CSA‐B365.

WARNING:

VentingsystemsurfacesgetHOT,andcancauseburnsiftouched.Noncombustibleshielding

orguardsmayberequired.

10

IMPORTANT! READ AND FOLLOW ALL INSTALLATION AND MAINTENANCE INSTRUCTIONS, INCLUDING CLEANING

THE UNIT AS SPECIFIED, AND REPLACING GASKETS ANNUALLY, AND PARTS AS NEEDED.

ENGLAND’S STOVE WORKS IS NOT RESPONSIBLE FOR ANY DAMAGE OR INJURY INCURRED DUE TO NEGLECT,

OR DUE TO UNSAFE INSTALLATION OR USAGE OF THIS PRODUCT. CALL TECHNICAL SUPPORT WITH ANY

QUESTIONS.

INSTALLATION

ApprovedVentingMethod1:ThroughtheWall

 Generallythesimplestinstallationmethod,ventingthrough

thewallusingourAC‐3000kit,AC‐33000ifCanada(orsimilar

ventingsystem)isalsothepreferredventingmethod.It

minimizeshorizontalpipe,allowsthestovetobeinstalledclose

tothewallandkeepstheclean‐outteeontheoutsideofthe

house,foreaseofcleaning.

 Wheninstallinganyventingsystem,TypeLorTypePLpipe

mustbeusedandallclearancestocombustibles(listedbythe

pipemanufacturer)mustbestrictlyadheredto.

 Usethepipemanufacturer’sapprovedthimbleforpassing

throughacombustiblewall,andmaintainatleasttheminimum

clearancestocombustibles.

 Useanappliancecollarwherethepelletventconnectsto

theexhaustoutputofthepelletstoveandattachtheappliance

collartotheexhaustbloweroutputusingthreesheetmetalscrews.

 Securethepelletventtotheoutsideofthehouseusingawallstrapjustbelowthe90degree

elbow.

 SealeachpipeconnectionjointwithhightemperatureRTVSilicone,toensurethesystemisleak

free(Checkwiththespecificventingsystemmanufacturer’sinstructionsbeforedoingso).

 Ifthepelletventpipebeingusedisnota“TwistLock”system,three(3)sheetmetalscrewsare

requiredateachpipejoint.

 Connectthepelletstovetooutsidecombustionairusingthekitincludedwithyourstoveorusing

analternativemethod,asdescribedinthe“OutsideAir”section,onpage15.

Thisinstallationtype

canbemodifiedforbasement(Basementinstallationsshouldalwaysbe

performedbyaprofessionalinstaller)orotherinstallationswhereintheteeandverticalsectionofthe

pipewouldbeinsidethehomeandtheventingsystemwouldsimplypasshorizontallythroughthe

thimbleandthenterminate.

PleaseNote:

Installationdiagramsareforreferencepurposesonlyandarenotdrawntoscale,normeanttobeusedasplansforeach

individualinstallation.Pleasefollowallventingsystemrequirements,maintaintherequiredclearancestocombustibles,

andfollowalllocalcodes.

Forhighaltitudeinstallations

(above4,000ft.),theventpipe

shouldbeincreasedfrom3‐inch

(

3”

)

tofour‐inch

(

4”

)

.

11

IMPORTANT! READ AND FOLLOW ALL INSTALLATION AND MAINTENANCE INSTRUCTIONS, INCLUDING CLEANING

THE UNIT AS SPECIFIED, AND REPLACING GASKETS ANNUALLY, AND PARTS AS NEEDED.

ENGLAND’S STOVE WORKS IS NOT RESPONSIBLE FOR ANY DAMAGE OR INJURY INCURRED DUE TO NEGLECT,

OR DUE TO UNSAFE INSTALLATION OR USAGE OF THIS PRODUCT. CALL TECHNICAL SUPPORT WITH ANY

QUESTIONS.

INSTALLATION

ApprovedVentingMethod2:ThroughtheCeiling



 Ventingthroughtheceiling/roofmaybetheonlyfeasible

ventingoptioninsomecasesandisafactoryrecommended

installation.

 Wheninstallinganyventingsystem,TypeLorTypePLpipe

mustbeusedandallclearancestocombustibleslistedbythe

pipemanufacturermustbestrictlyadheredto.

 Usethepipemanufacturer’sapprovedceilingsupportfor

passingthroughacombustibleceiling,aswellastherequired

firestops,radiationshields,flashingandstormcollar.

 Becertaintofollowthemanufacturer’srequiredheightof

terminationabovetheroofline,andmaintainatleastthe

minimumclearancestocombustibles.

 Useanappliancecollarwherethepelletventconnectsto

theexhaustoutputofthepelletstoveandattachtheappliance

collartotheexhaustbloweroutputusingthreesheetmetal

screws.

 SealeachpipeconnectionjointwithhightemperatureRTVSilicone,toensurethesystemisleak

free(Checkwiththespecificpipemanufacturer’sinstructionsbeforedoingso).

 Ifthepelletventpipebeingusedisnota“TwistLock”system,three(3)sheetmetalscrewsare

requiredateachpipejoint.

 Connectthepelletstovetooutsidecombustionairusingthekitincludedwithyourstoveorusing

analternativemethod,asdescribedinthe“OutsideAir”section,onpage15.

 Thisventingmethodcanalsobemodifiedsothattheventingsystemrunshorizontallythroughthe

wallfromthestove,thentransitionstoverticalandterminatesabovetheroofline.Whenusingthis

modifiedversionofthisinstallationbecertaintocarefullyfollowtheventingsystem

manufacturer’sinstructionsdiligently.

Please Note:

Installation diagrams are for reference purposes only and are not drawn to scale, nor meant to be used as plans for each

individual installation. Please follow all venting system requirements, maintain the required clearances to combustibles,

and follow all local codes.

Forhighaltitudeinstallations

(above4,000ft.),theventpipe

shouldbeincreasedfrom3‐inch

(

3”

)

tofour‐inch

(

4”

)

.

12

IMPORTANT! READ AND FOLLOW ALL INSTALLATION AND MAINTENANCE INSTRUCTIONS, INCLUDING CLEANING

THE UNIT AS SPECIFIED, AND REPLACING GASKETS ANNUALLY, AND PARTS AS NEEDED.

ENGLAND’S STOVE WORKS IS NOT RESPONSIBLE FOR ANY DAMAGE OR INJURY INCURRED DUE TO NEGLECT,

OR DUE TO UNSAFE INSTALLATION OR USAGE OF THIS PRODUCT. CALL TECHNICAL SUPPORT WITH ANY

QUESTIONS.

INSTALLATION

ApprovedVentingMethod3:ExistingChimneySystem

 Usinganexistingmasonryorfactorybuiltchimneyforventingistheonlyotheracceptablemethod

forventingthispelletunit.

 UseTypeLorTypePLventingpipeuntilenteringtheexisting

chimney.Usetheappropriatelysizedadapterwhen

transitioningfromthepelletventpipetothemasonryorfactory

builtthimbleandbecertainthattheadapterissealedtightlyto

boththepelletventingsystemandtheexistingchimney.

 Beforeusinganexistingchimney,becertainitisingood

condition(Achimneysweepinspectionishighlyrecommended).

Also,makesurethechimneymeetstheminimumstandards

listedinNFPA211(Achimneyprofessionalcanconfirmthisupon

inspection).

 Ifconnectingthisstovetoafactorybuiltchimney,itmay

ONLYbea6”flue,UL103HTventingsystem(ULCS629if

Canada).Connectiontoanyotherfactorybuiltchimneymay

resultinapoorlyoperatingordangerousstoveinstallation.

 Whenconnectingtoanexistingmasonrychimney,thecross‐sectionalareaofthefluemustbe

considered.Achimneywithafluelargerthan6”round(28.27sq.in.)mayrequirereliningwithan

approvedpelletstovechimneyliningsystem.

 Useanappliancecollarwherethepelletventconnectstotheexhaustoutputofthepelletstove

andattachtheappliancecollartotheexhaustbloweroutputusingthreesheetmetalscrews.

 SealeachpipeconnectionjointwithhightemperatureRTVSilicone,toensurethesystemisleak

free(Checkwiththespecific

pipemanufacturer’sinstructionsbeforedoingso).

 Ifthepelletventpipebeingusedisnota“TwistLock”system,three(3)sheetmetalscrewsare

requiredateachpipejoint.

 Connectthepelletstovetooutsidecombustionairusingthekitincludedwithyourstoveorusing

an

alternativemethod,asdescribedinthe“OutsideAir”section,onpage15.

PleaseNote:

Installationdiagramsareforreferencepurposesonlyandarenotdrawntoscale,normeanttobeusedasplansforeach

individualinstallation.Pleasefollowallventingsystemrequirements,maintaintherequiredclearancestocombustibles,

andfollowalllocalcodes.

Forhighaltitudeinstallations

(above4,000ft.),theventpipe

shouldbeincreasedfrom3‐inch

(

3”

)

tofour‐inch

(

4”

)

.

13

IMPORTANT! READ AND FOLLOW ALL INSTALLATION AND MAINTENANCE INSTRUCTIONS, INCLUDING CLEANING

THE UNIT AS SPECIFIED, AND REPLACING GASKETS ANNUALLY, AND PARTS AS NEEDED.

ENGLAND’S STOVE WORKS IS NOT RESPONSIBLE FOR ANY DAMAGE OR INJURY INCURRED DUE TO NEGLECT,

OR DUE TO UNSAFE INSTALLATION OR USAGE OF THIS PRODUCT. CALL TECHNICAL SUPPORT WITH ANY

QUESTIONS.

INSTALLATION

MobileHomeInstallation

 TheEngland’sStoveWorks,Inc.outsideairkitMUSTbeusedforinstallationofthisunitinamobile

home.Pleaseseethe“OutsideAir”sectiononpage15formoreinformationregardingoutsideair

connections.

 Theoutsideairinletmustbekeptclearofleaves,iceandotherdebris.Keepingtheoutsideairinlet

freeofrestrictioniscrucialtopreventingairstarvationandsmokespillage.

 ThepelletstoveMUSTbesecuredtothefloorofthemobilehomeusinglagboltsandtheholes

providedinthebottomofthebaseforthispurpose.Outdoor‐aired

spaceheatersmustbe

attachedtothestructure.

 ThepelletstoveMUSTbegroundedwith#8solidcoppergroundingwire(orequivalent),

terminatedateachendwithanNECapprovedgroundeddevice.

 CarefullyfollowallclearanceslistedintheappropriatesectionofthismanualANDfollowthe

ventingmanufacturer’s

minimumclearancerequirements.Similarly,becertaintheventingsystem

usedisapprovedformobilehomeuse.

 InstallationmustbeinaccordancewithManufacturersHome&SafetyStandard(HUD)CFR3280,

Part24aswellasanyapplicablelocalcodes.

 Usesiliconetocreateaneffectivevaporbarrieratthelocationwherethechimneyoroutsideair

ductingpassesthroughtotheexteriorofthestructure.



CAUTION

THESTRUCTURALINTEGRITYOFTHEMANUFACTUREDHOMEFLOOR,WALLANDCEILING/ROOFMUST

BEMAINTAINED.DONOTCUTTHROUGHFLOORJOISTS,WALLSTUDS,CEILINGTRUSSESORANY

OTHERSUPPORTINGMATERIALWHICHCOULDBEDETRIMENTALTOTHESTRUCTURALINTEGRITYOF

THEHOME.

WARNING:DONOTINSTALLINASLEEPINGROOM.

JoistShield/Firestop

MobileHomeApproved

TypeLorTypePLPellet

VentPipe

RoofFlashingandStorm

Collar

ChimneyCap/SparkArrestor

Forhighaltitudeinstallations

(above4,000ft.),theventpipe

shouldbeincreasedfrom3‐inch

(

3”

)

tofour‐inch

(

4”

)

.

14

IMPORTANT! READ AND FOLLOW ALL INSTALLATION AND MAINTENANCE INSTRUCTIONS, INCLUDING CLEANING

THE UNIT AS SPECIFIED, AND REPLACING GASKETS ANNUALLY, AND PARTS AS NEEDED.

ENGLAND’S STOVE WORKS IS NOT RESPONSIBLE FOR ANY DAMAGE OR INJURY INCURRED DUE TO NEGLECT,

OR DUE TO UNSAFE INSTALLATION OR USAGE OF THIS PRODUCT. CALL TECHNICAL SUPPORT WITH ANY

QUESTIONS.

VENTTERMINATIONCLEARANCES

A)MIN.4‐FTCLEARANCEBELOWORBESIDEANYDOORORWINDOWTHATOPENS.

B)MIN.1‐FTCLEARANCEABOVEANYDOORORWINDOWTHATOPENS.

C)MIN.2‐FTCLEARANCEFROMANYADJACENTBUILDING.

D)MIN.7‐FTCLEARANCEFROMANYGRADEWHENADJACENTTOPUBLICWALKWAYS.

E)MIN.2‐FTCLEARANCEABOVEANYGRASS,PLANTS,OROTHERCOMBUSTIBLEMATERIALS.

F)MIN.3‐FTCLEARANCEFROMAFORCEDAIRINTAKEOFANYAPPLIANCE.

G)MIN.2‐FTCLEARANCEBELOWEAVESOROVERHANG.

H)MIN.1‐FTCLEARANCEHORIZONTALLYFROMCOMBUSTIBLEWALL.

I)V

ENTSINSTALLEDWITHMECHANICALEXHAUSTERSSHALLTERMINATENOTLESSTHAN 

12

IN

.



(305

MM

)

ABOVETHE

HIGHESTPOINTWHERETHEYPASSTHROUGHTHEROOFSURFACE

.





NotesonterminationofPelletVentPipefrom

NFPA211(2006ed.)Section10.4Termination:10.4.5



(Seealso“INSTALLATION”sectionofmanualANDadditionalnotesabove):

- Not less than three (3) feet above any forced air inlet located within ten (10) feet.

- Not less than four (4) feet below, four (4) feet horizontally from, or one (1) foot above any door,

window or gravity air inlet into any building.

- Not less than two (2) feet from an adjacent building, and not less than seven (7) feet above

grade where located adjacent to public walkways.

The exhaust exit shall be arranged so that the flue gases are not directed so that it will affect people,

overheat combustible structures, or enter buildings. Forced draft systems and all parts of induced

draft systems under positive pressure during operation shall be installed gastight or to prevent

leakage of combustion products into a building. Through-the-wall vents shall not terminate over

public walkways, or where condensate or vapor could create hazards or a nuisance.

Be sure to follow local codes and all manufacturer’s instructions (including exhaust pipe).

Consult a professional installer and/or call Technical Support if you have any questions.

15

IMPORTANT! READ AND FOLLOW ALL INSTALLATION AND MAINTENANCE INSTRUCTIONS, INCLUDING CLEANING

THE UNIT AS SPECIFIED, AND REPLACING GASKETS ANNUALLY, AND PARTS AS NEEDED.

ENGLAND’S STOVE WORKS IS NOT RESPONSIBLE FOR ANY DAMAGE OR INJURY INCURRED DUE TO NEGLECT,

OR DUE TO UNSAFE INSTALLATION OR USAGE OF THIS PRODUCT. CALL TECHNICAL SUPPORT WITH ANY

QUESTIONS.

OUTSIDEAIRHOOK‐UP

 Theuseofoutsidecombustionairismandatoryonthispelletstove.

 Theoutside airconnectionpipeprotrudesfromthelowerrearcenterofthestove;

usetheincludedoutsideairkittoattachyourstovetooutsidecombustionair.

Instructionsandallthepartsneededtomakethe

outsideairconnectiontoyour

pelletstoveareincludedwiththeoutsideairkit.

 Ifitisnotfeasibletousetheincludedoutsideairhookupkitinyourstove

installation,othermaterialsmaybeused,providedthefollowingrulesarefollowed:

 Thepipeusedforoutsideair

hookupmustbemetal,withaminimum

thicknessof.0209in.(25gaugemildsteel)orgreaterandaninsidediameter

ofapproximately2.0in.

 Allpipe jointsandconnectionsshouldbesealedwithpipeclampsorother

mechanicalmeans,toinsurealeakfreeoutsideairconnection.

 Long

runsofpipeandexcessiveelbowsforoutsideairshouldbeavoided.Due

tofrictionalresistanceinpipe,anyexcessiveoutsideairpipingcanresultin

poorstoveperformance.

 Ascreenorotherprotectiondevicemustbefittedovertheoutsideair

terminationpointtopreventrain,debrisand

nuisanceanimalsfromentering

thepipingsystem.

 Increasetheoutsideairpipesizeto3.0in.diameterpipeiftheoutsideair

connectionismorethan6ft.inlength,morethantwo(2)elbowsareusedorif

thestoveisinstalledinabasement.

 Theoutside air

connectionsystemshouldbeinspectedatleastannuallytobecertain

itisfreefromblockage.



Caution

NEVERdrawoutsidecombustionairfrom:

1.Wall,floororceilingcavity.

2.Enclosedspacesuchasanattic,garageorcrawlspace.

16

IMPORTANT! READ AND FOLLOW ALL INSTALLATION AND MAINTENANCE INSTRUCTIONS, INCLUDING CLEANING

THE UNIT AS SPECIFIED, AND REPLACING GASKETS ANNUALLY, AND PARTS AS NEEDED.

ENGLAND’S STOVE WORKS IS NOT RESPONSIBLE FOR ANY DAMAGE OR INJURY INCURRED DUE TO NEGLECT,

OR DUE TO UNSAFE INSTALLATION OR USAGE OF THIS PRODUCT. CALL TECHNICAL SUPPORT WITH ANY

QUESTIONS.

FLOORPROTECTION

 Thispelletstoverequiresanon‐combustiblefloorprotectorifthestoveistobeinstalledona

combustiblefloor.Ifthefloorthestoveistobeinstalledonisalreadynon‐combustible(i.e.a

concretefloorinabasement)andhasanRvalueequaltoorhigherthan.2,nofloorprotectionis

needed(althoughadecorativefloorprotectorcanstillbeusedforaestheticreasons).

 PrefabricatedfloorprotectorswhichareULlisted(ULCifCanada)orequivalentcanbepurchased

orafloorprotectorcanbebuiltfromstandardmaterials:twosheetsof.5”thickcementboard

coveredwithceramictilewouldbeasuitablefloorprotectorwhichmeetsthe.2R‐value

requirement.

 Whenusinganyfloorprotector,considerthatthisstoveisnotonlyheavybutwillinduceheating

andcoolingcyclesonthefloorprotectorwhichcandamagetileandloosenmortarandgroutjoints.

AhearthrugisNOTanapprovedsubstituteforaproperhearthpad.

 FortheUS:Thefloorprotectormustextendatleast6in.(152.4mm)fromthefront&sidesand4

in.(101.6mm)fromtherear.

 ForCanada:Thefloorprotectormustextendatleast18.0in.(457.2mm)fromthefrontoftheunit,

8.0in.(203.2mm)fromthesidesoftheunitand4.0in.(101.6mm)fromtherear.

 InCanada,itisrequiredthatthenon‐combustiblefloorprotectorisunderneathandextends2in.

(50.8mm.)oneithersideofanyhorizontalventingrunsAND/ORisdirectlyunderneathanyvertical

ventingpipe.



4”

(U.S.A.)

17

IMPORTANT! READ AND FOLLOW ALL INSTALLATION AND MAINTENANCE INSTRUCTIONS, INCLUDING CLEANING

THE UNIT AS SPECIFIED, AND REPLACING GASKETS ANNUALLY, AND PARTS AS NEEDED.

ENGLAND’S STOVE WORKS IS NOT RESPONSIBLE FOR ANY DAMAGE OR INJURY INCURRED DUE TO NEGLECT,

OR DUE TO UNSAFE INSTALLATION OR USAGE OF THIS PRODUCT. CALL TECHNICAL SUPPORT WITH ANY

QUESTIONS.

DAILYOPERATION

GettingStarted

 Checktoseethatthehopperiscleanandfreefromforeignmaterials.Besuretoconnectthis unittoa

workingoutlet;werecommendusingasurgeprotectortohelpprotecttheelectroniccomponentsfrom

damage.

 BEFOREyourfirstfire,dryrunyourunit(nopellet fuel

inthehopper)fortwentyminutes;pressingthe“ON”

buttonwiththeunitpluggedinwillinitiatethedryrun.

 Oncethe“ON”buttonispressed,youshouldimmediatelyheartheexhaustblowerstartand

operatecontinuously.Afterafewseconds,theletters“SU”willappearinthetwo

displaywindows

ofthecontrolboard.

 Afteraboutthreetofiveminutes,lookfortheredglowoftheigniterintheigniterportoftheburn

pottobecertainitisoperatingnormally.

 Holdthehopperlidswitch(See“IllustratedPartsDiagram”pg.44)downwith

yourfingerandcheck

toseethattheaugeristurning.Releasethehopperlidswitchandbecertainthattheaugerstops

turning.DONOTPUTYOURFINGERSINTHEHOPPERORNEARTHEROTATINGAUGER.

 Afterabouttwentyminutes,thecontrolboardshoulddisplay“E‐2”in

thetwodisplaywindows(More

informationonErrorCodescanbefoundintheErrorCodesectionofthismanual).

 Atthispoint,thedryruniscompleteandyourpelletheatingapplianceisreadyfornormaloperation.

LightingaFire



 Inorderforthisstovetooperate,thehoppermustfirstbefilledwithpelletfuel.Liftthehopperlidusing

theflush‐mounthandleandpourthepelletfueldirectlyintothehopper.

 WerecommendusingonlypelletsmanufacturedbyPFICertifiedfacilities,sincepelletsbearing

the

PFIstampofapprovalwillbelowinashandmoisture,highinBTU’s,anduniforminsize and

quality.

 Thispelletstovewillperformequallywellusingsoftwoodandhardwoodpellets,andalthoughtheashmay

differslightlyinappearanceortexture,bothtypesof pelle tswillburncleanly

andefficientlyinthisstove.

 Thispelletstoveisequippedwithanautomatic pelletignitionsystem;theonlyuserinputrequiredtolight

thestoveisasimplepressofthe“On”button.

 Shortlyafterpressingthe“On”button,theletters“SU”willappearinthe

heatrangeandblowerspeed

windowsofthecontrolboard.Thisindicatesthestovehasenteredthestart‐upsequenceandisoperating

normally.

18

IMPORTANT! READ AND FOLLOW ALL INSTALLATION AND MAINTENANCE INSTRUCTIONS, INCLUDING CLEANING

THE UNIT AS SPECIFIED, AND REPLACING GASKETS ANNUALLY, AND PARTS AS NEEDED.

ENGLAND’S STOVE WORKS IS NOT RESPONSIBLE FOR ANY DAMAGE OR INJURY INCURRED DUE TO NEGLECT,

OR DUE TO UNSAFE INSTALLATION OR USAGE OF THIS PRODUCT. CALL TECHNICAL SUPPORT WITH ANY

QUESTIONS.

 Thefuelfeedrateandcombustionairduringstart‐upisdeterminedbythecontrolboard,sothestovemay

bestartedonanyheatrange.

 Afterapproximatelyfifteenminutes,thefireshouldbeburningbrightlyandthe“SU”should

disappearfromthecontrolboard.Atthispoint,thestovehasbegunnormaloperationandthe

displaywindowsonthecontrolboardwillremainempty,unlesstheHeatRangeorBlowerSpeedis

adjusted.



 Itisnormalfortheunittosmokeduringthefirstfire,aspaintsandoilscure.Thisshoulddissipate

withinthefirsthour.Openadoorand/orwindowduringthefirstfiretoventilatethearea.



DailyOperationNotes

 Onlyhighquality,¼”(.25in.)diameterwoodpellets,shouldbeusedinthisstove.Usinglowgrade

woodpelletswithhighashcontentORwoodpelletswithahighmoisturecontentcancausethe

burnpottofillwithashatamorerapidpaceandcancauseintervalsbetweenperiodic

maintenancetobecomesignificantlyshorter.Pleasereadthe“Maintenance”sectionofthis

manualthoroughlytounderstandhowfuelselectionaffectsstoveoperation,maintenanceand

cleaning.

 Variationintheflameheightisnormal;notallwoodpelletfuelisuniforminsize,whichcanaffect

thewaypelletsarefedintotheburnpot.Althoughtheflameheightmayincreaseanddecrease

duringoperation,thereisnolossofefficiency.

 Alwaysstorewoodpelletfuelinadrylocation;storingwoodpelletfuelinadrylocationensures

thefuelwillremainpelletizedandlowinmoisturecontent.Also,becertainthatallwoodpellet

fuelisstoredatasafedistancefromthepelletheater;storingfuelincloseproximitytothestove

canresultinafire.

Thispelletburningroomheaterisequippedwithaspeciallydesignedburnpotwhichcomes

preinstalledfromthefactory.

Thisburnpotelevatestheburningpelletsanddeliversairatthe

precisely‐requiredlocations.Pelletsmustonlybeburnedinthefactoryburnpot;nomodifications

shouldbemadetothisburnpotandnoadditionalgratesorotherfireelevatorsshouldbeused.

CAUTION

NEVERUSEGASOLINE,GASOLINE‐TYPELANTERNFUEL,KEROSENE,CHARCOALLIGHTERFLUID,ORSIMILAR

LIQUIDSTOSTARTOR“FRESHENUP”AFIREINTHISHEATER.KEEPALLSUCHLIQUIDSWELLAWAYFROMTHE

HEATERWHILEINUSE.ADDITIONALLY,NEVERAPPLYFIRE‐STARTERTOANYHOTSURFACEOREMBERSINTHE

STOVE.DONOTUSECHEMICALSORFLUIDSTOSTARTTHEFIRE.

DONOTBURNGARBAGEORFLAMMABLEFLUIDSSUCHASGASOLINE,NAPHTHAORENGINEOIL.

19

IMPORTANT! READ AND FOLLOW ALL INSTALLATION AND MAINTENANCE INSTRUCTIONS, INCLUDING CLEANING

THE UNIT AS SPECIFIED, AND REPLACING GASKETS ANNUALLY, AND PARTS AS NEEDED.

ENGLAND’S STOVE WORKS IS NOT RESPONSIBLE FOR ANY DAMAGE OR INJURY INCURRED DUE TO NEGLECT,

OR DUE TO UNSAFE INSTALLATION OR USAGE OF THIS PRODUCT. CALL TECHNICAL SUPPORT WITH ANY

QUESTIONS.

CONTROLBOARDSETTINGS

Thecontrolboardonthisstoveallowstheusertoadjusttheheatoutputandconvectionblowerspeed,

turntheunitonandoff,andtestcomponentsforfunction(moreondiagnosticmodelater).

 Thelowerbuttonsonthecontrolboard(LowFuelFeed,LowBurnAir,andAiron

Temp)arenot

meanttobeadjustedduringnormaloperationoftheunit.Thesebuttonsarefactorypresetand

shouldnotbeadjustedbytheuser.

 Toenergizetheunitandinitiateafire,pressthe“On”button.TheLEDabovethebuttonshould

turngreenandthecontrolboardshoulddisplay“SU”shortlyafterpressingthebutton.

 Toshuttheunitdown,pressthe“Off”button.TheLEDabovethebuttonshouldturnredandthe

boardshoulddisplay“Sd”shortlyafterpressingthebutton.Thisinitiatestheshutdownsequence,

andthestovewillremaininshutdownmodeuntilithascooleddown.

 Toincreasetheheatoutputofthestove,pressthe“Up”heatrangebutton.Thenumberinthe

heatrangedisplaywindowwillincrease,signifyingthatthecontrolboardisnowadjustingtheheat

outputtoyourdesiredlevel.Theblowerspeedwillincreasethesameamountastheheatrange,

becausethestoveisdesignedtooperatewiththeblowerspeedgreaterthanorequaltotheheat

range.Pressingthe“Down”arrowwilldecreasetheheatrangeandblowerspeed.

 Toincreasetheblowerspeedwithoutincreasingtheheatrange,presstheBlowerSpeed“Up”

arrowuntilthedesiredblowerspeedisshowninthedisplaywindow.Pressingthe“Down”arrow

willdecreasetheblowerspeed;however,thecontrolboardwillnotallowtheblowerspeedtobe

setlowerthantheheatrange.

Caution

Thisunitismeanttooperateonlywiththeashpanandmainviewingdoorclosed.

Smokespillageandaninefficient,lazyburnwillresultfromattemptingtooperatethe

stovewitheitherdooropen.

Inaddition,usingfuelotherthanwoodpelletscancreateanunsafesituationandcan

alsogenerateexcesscarbonmonoxide.Carbonmonoxideisanodorless,colorlessgas

whichcanbedeadly.Besuretoburnonlywoodpellets.

Theuseofacarbonmonoxidedetectorisstronglyrecommended.

20

IMPORTANT! READ AND FOLLOW ALL INSTALLATION AND MAINTENANCE INSTRUCTIONS, INCLUDING CLEANING

THE UNIT AS SPECIFIED, AND REPLACING GASKETS ANNUALLY, AND PARTS AS NEEDED.

ENGLAND’S STOVE WORKS IS NOT RESPONSIBLE FOR ANY DAMAGE OR INJURY INCURRED DUE TO NEGLECT,

OR DUE TO UNSAFE INSTALLATION OR USAGE OF THIS PRODUCT. CALL TECHNICAL SUPPORT WITH ANY

QUESTIONS.

ERRORCODES

Errorcodes,or“E‐Codes,”arealphanumericcodesthatwillappearintheHeatRangeandBlower

SpeedwindowsoftheControlBoardiftheunitexperiencesanabnormalcondition.Errorcodesare

thecontrolboard’swayoftellingtheuserthatsomethingisn’toperatingcorrectlywithinthestove,

andthat

theunitshouldbecarefullyinspectedbeforereigniting.Seethe“Trouble‐ShootingGuide,”

page32,foradditionalinformationonerrorcodes.

 E‐0

 Whenthisisdisplayedinthecontrolboardwindows(typicallywhenrestartingafteran“E‐

Code”shutdown),itmeanstherearecurrentlynoerrorsandthestovewillbeginnormal

operation.

 E‐1

 Thiserrorcodeisnotusedonthisstove.Ifitisdisplayedinthecontrolboardwindows,

pleasecontactTechnicalSupportandtheywilldiagnosethecauseofthefalsecode.

 E‐2

 Whenthiscodeisdisplayedinthecontrolboardwindowitindicatesafailuretolight.

Althoughthestovemayhaveignitedthepellets,thecontrolboarddidnotregisterahigh

enoughtemperaturetodeterminethefirewaslit.Ifafirewasignited,waitfortheunitto

cool,cleantheburnpotandrestarttheunit.

 E‐3

 Thiserrorcodeindicatesthepresetmaximumallowableexhausttemperaturewas

exceeded.Commonlyreferredtoas“Over‐Firing,”theE‐3codemeanssomethinginthe

stoveiscausingtheexhaustgastobehotterthanexpected.

 E‐4

 Thiscodeisdisplayedbasedonadropintheexhausttemperature.Thiscodemeansthe

fireor“proofofflame”hasbeenlost.Itusuallyresultsfromthehopperbeingempty.

Ifanerrorcodecontinuestodisplay,iftheerrorcodeseemsunexplainable,orifyou

haveanyotherquestionsabouterrorcodesandwhattheymean,pleasecontact

TechnicalSupportat(800)245‐6489.





HopperLidSafetySwitch‐Thisunitisalsoequippedwithahopperlidsafetyswitch(Part#

AC‐HLSB)whichisdirectlyconnectedtotheaugermotor.Intheeventthehopperlidisleft

openwhilethestoveisinoperation,thehopperlidswitchwillpreventtheaugerfrom



turning.Thisistopreventbyproductsofcombustionfromenteringthehomethroughthe

openhopperlidandalsotosimplypreventoperationwiththehopperlidopen.Improper

hopperlidsafetyswitchoperationwillresultinanaugerthatwillnotturnandthereforea

stovethatwillnot

burn.NEVERplaceyourhandoranyobjectneartheaugerwhilethestove

isconnectedtopower. 

La page charge ...

Englander 25-IPS Manuel utilisateur

Ce manuel convient également à

Englander 25-IPS Manuel utilisateur

dans d''autres langues

Documents connexes

Autres documents