Thermador PCG486GD Manuel utilisateur

Marque: Thermador

Modèle: PCG486GD

Catégorie: Barbecues

Taper: Manuel utilisateur

Ce manuel convient également à

PCG366G

Models /

Modèles /

Modelos:

PCG 30

PCG 36

PCG 48

For Thermador

Professional

Cooktops

CARE AND USE MANUAL

Des tables de cuisson Thermador Professional

MANUEL D’UTILISATION ET

D’ENTRETIEN

WARNING:

If the information in this manual is not

followed exactly, a fire or explosion may

result causing property damage, personal

injury or death.

— Do not store or use gasoline or other flam-

mable vapors and liquids in the vicinity of this

or any other appliance.

— WHAT TO DO IF YOU SMELL GAS

■ Do not try to light any appliance.

■ Do not touch any electrical switch.

■ Do not use any phone in your building.

■ Immediately call your gas supplier from a

neighbor’s phone. Follow the gas supplier’s

instructions.

■ If you cannot reach your gas supplier, call the

fire department.

— Installation and service must be performed

by a qualified installer, service agency or the

gas suppler.

AVERTISSEMENT

L’information fournie dans le présent

manuel doit être rigoureusement

respectée, sous peine d’un incendie ou

d’explosion susceptible d’entraîner des

dommages, des blessures ou la mort.

— N’entreposez pas et n’utilisez pas

d’essence ou autres produits inflammables

dans le voisinage de cette cuisinière ou de

tout autre appareil.

— SI VOUS SENTEZ UNE ODEUR DE GAZ

■ N’allumez aucun appareil.

■ Ne touchez pas aux interrupteurs

électriques.

■ N’utilisez pas les téléphones du bâtiment.

■ Appelez immédiatement votre compagnie

de gaz de chez un voisin. Suivez les in-

structions de la compagnie.

■ Si vous n’arrivez pas à contacter votre

compagnie de gaz, appelez les pompiers.

— L’installation et les réparations doivent être

réalisées par un installateur qualifié, un

centre de réparation agréé ou la compagnie

de gaz.

This Thermador Appliance is made by

BSH Home Appliances Corporation

5551 McFadden Ave.

Huntington Beach, CA 92649

Questions?

1-800-735-4328

www.thermador.com

We look forward to hearing from you!

Table of Contents

Introduction ..................................................................1

Gas Type Verification ..................................................1

SECTION ONE: General Safety Instructions

Electrical Requirement and Grounding Instructions ...... 2

Safety Precautions ...................................................3 – 4

SECTION TWO: Before You Begin

Before Using Your Cooktop for the First Time ............... 5

SECTION THREE: Description

Model & Parts Identification – PCG 48 .....................6

Model & Parts Identification – PCG 36 .....................6

Model & Parts Identification – PCG 30 .....................6

SECTION FOUR: Using the Cooktop

Sealed Burners ............................................................7

ExtraLow

Burners ......................................................8

Electronic Igniter ..........................................................9

Burner Cap Placement ................................................9

Flame Setting Guidelines ......................................... 10

Cookware Recommendations ..................................11

Specialty Cookware .................................................. 12

Surface Burner Cooking Recommendations .13 – 14

Using the Griddle .............................................. 15 – 16

Griddle Cooking Recommendations ....................... 16

SECTION FIVE: Care and Maintenance

Cooktop Cleaning Recommendations .................17 – 19

SECTION SIX: Before Calling For Service

Do-It-Yourself Maintenance..................................... 20

Before Calling For Service....................................... 21

Data Rating Plate...................................................... 21

Warranty ...............................................................22-23

INTRODUCTION

CAUTION

When connecting the unit to propane gas, make

certain the propane gas tank is equipped with

its own high-pressure regulator in addition to

the pressure regulator supplied with the range.

The pressure of the gas supplied to the appli-

ance regulator must not exceed 14" (34.9 milli-

bars) water column.

TESTED IN ACCORDANCE WITH ANSI

Z21.1, The STANDARD FOR HOUSEHOLD

COOKING GAS APPLIANCES. IN CANADA

TESTED IN ACCORDANCE WITH CAN/

CGA 1.1 - M81, STANDARD for DOMESTIC

GAS RANGES.

Check your local building codes for the proper

method of installation. In the absence of local

codes, this unit should be installed in accordance

with the National Fuel Gas Code No.

Z223.1 /

NFPA 54

current issue and the National

Electrical Code ANSI/NFPA No. 70 current issue

or the Can - B149 Installation Codes for Gas

Burning Appliances and C22.1 Canadian

Electrical Code Part 1.

It is the responsibility of the owner and the

installer to determine if additional requirements

apply in specific installations.

Cooktops are shipped by the factory to operate on

natural gas. Verify

that the type of gas being used at

the installation site matches the type of gas used by

the appliance.

If the location/job site requires a conversion from

one type of gas to another, contact the dealer where

the unit was purchased or contact Thermador. The

field conversion kit for this series of Professional

cooktops is Thermador Model PALPKITHC. Field

conversion must be done by qualified service

personnel only.

IMPORTANT

All Cooktops having less than 12" (305 mm)

horizontal clearance between combustible ma-

terials and the back edge of the Cooktop must

be installed with a Thermador Low Back Back-

guard. If more than 12" (305 mm) horizontal

clearance exists, a Thermador Island Trim may

be used instead of the backguard. Before using

the Cooktop, insure that it is equipped with the

appropriate Low Back Backguard or Island Trim.

Refer to the Installation Instructions accompa-

nying this appliance for more information.

ELECTRICAL REQUIREMENTS AND GROUNDING INSTRUCTIONS

CAUTION - ALL MODELS

In Case of an Electrical Failure

If for any reason a gas control knob is turned ON and there is no electric power to operate the

electronic igniters on the cooktop burners, turn OFF the gas control knob and wait 5 min-

utes for the gas to dissipate before lighting the cooktop burner manually.

To light the cooktop burners and grill manually, carefully hold a lighted match to the burner ports

and turn the gas control knob to HI. During a power failure, you can manually light the standard

cooktop burners and grill only, but each must be lit with a match.

DO NOT attempt to light the two left burners manually. These burners are equipped with

the ExtraLow® feature and cannot be lit manually.

See Pages 10 and 20 for additional information on manually lighting the burners.

Section 1: GENERAL SAFETY INSTRUCTIONS

PLEASE READ CAREFULLY

All Cooktop models require an electrical circuit rated

at 120 volts, 60 Hz., 10 Amps, except models with

electric griddle require 15 Amp circuits.

For personal safety, this appliance must be con-

nected to a properly grounded and polarized

electrical power supply.

Always disconnect the electrical plug from the wall

receptacle before servicing this unit.

See Installation Instructions for electrical

requirements and grounding instructions.

DO NOT UNDER ANY

CIRCUMSTANCES CUT OR REMOVE

THE SEPARATE GROUND WIRE OR

THE THIRD (GROUND) PRONG FROM

THE POWER CORD PLUG.

It is the personal responsibility and obligation of you,

the user, to have this appliance connected to the

electrical power supply in accordance with the Na-

tional Electrical Code and/or applicable local codes

and ordinances by a qualified electrician.

It is recommended that a dedicated circuit servicing

this appliance be provided.

CAUTION

Safety Precautions

Your new Thermador Professional

Cooktop has been designed to be

a safe, reliable appliance when

properly used and cared for. Read

all instructions in this Care and

Use Manual carefully before using

this cooktop.

WARNING: These

precautions will reduce the risk

of burns, electric shock, fire,

and injury to persons. Use

extreme care when using this

restaurant-caliber cooktop

as this appliance provides

intense heat.

When using kitchen appli-

ances, these basic safety pre-

cautions must be followed:

• Insure proper installation and

servicing. Follow the installation

instructions provided with this

product. Have the cooktop in-

stalled and electrically grounded

by a qualified technician.

• Have the installer show you

where the gas supply shut-off

valve is located so that you know

how and where to turn off the gas

to the cooktop.

• If you smell gas:

• Do not try to light any appli-

ance.

• Do not touch any electrical

switch.

• Do not use any phone in your

building.

• Immediately call your gas sup-

plier from a neighbor’s phone.

Follow the gas supplier’s in-

struction.

• If you cannot reach your gas

supplier, call the fire department.

• Installation and service must be

performed by a qualified in-

staller, service agency or the

gas supplier.

• In the event a burner goes out

and gas escapes, turn off the

burner and open a window or a

door. Do not attempt to use the

cooktop until the gas has had time

to dissipate. Wait at least 5 min-

utes before using the cooktop.

• Do not repair or replace any

part of the appliance unless

specifically recommended in this

manual. All other servicing should

be referred to a qualified techni-

cian.

• Children should not be left

alone or unattended in an area

where appliances are in use.

They should never be allowed to

sit or stand on any part of the ap-

pliance. If children are allowed to

use the appliance, they must be

closely supervised.

CAUTION: Do not

store items of interest to chil-

dren above or at the back of

the cooktop. If children should

climb onto the appliance to reach

these items, they could be seri-

ously injured.

• When children become old

enough to operate the appliance,

it is the legal responsibility of the

parents or legal guardians to en-

sure that they are instructed in

safe practices by qualified per-

sons.

• Never use any part of the

cooktop for storage. Flam-

mable materials can catch fire

and plastic items may melt or

ignite.

• If the cooktop is near a window,

be certain the curtains do not

blow over or near the cooktop

burners; they could catch on fire.

• Have an appropriate fire extin-

guisher available, nearby, highly

visible and easily accessible near

the appliance.

• DO NOT USE WATER ON

CAUTION

SAFETY PRACTICES TO AVOID PERSONAL INJURY

Section 1: GENERAL SAFETY INSTRUCTIONS

SAVE THESE INSTRUCTIONS

GREASE FIRES. Turn appliance

off and smother fire with baking

soda or use a dry chemical or

foam-type extinguisher.

• Never let clothing, pot hold-

ers, or other flammable materi-

als come in contact with or too

close to any element, burner or

burner grate until it has cooled.

Fabric may ignite and result in per-

sonal injury.

• Use only dry pot holders. Moist

or damp pot holders on hot sur-

faces may cause burns from

steam. Do not use a towel or other

bulky cloth in place of pot hold-

ers. Do not let pot holders touch

hot elements, hot burners, or

burner grates.

• For personal safety, wear

proper apparel. Loose fitting gar-

ments or hanging sleeves should

never be worn while using this ap-

pliance. Some synthetic fabrics

are highly flammable and should

not be worn while cooking.

• Do not use aluminum foil as a

shield against food spills or drip-

pings around the burners or con-

trol panel area. This could ob-

struct the flow of combustion and

ventilation air. This can also dam-

age the finish of the cooktop.

WARNING: The ap-

pliance is for cooking food.

Based on safety considerations,

never use the Cooktop to warm

or heat a room or for other pur-

poses. Such uses can create a

burn or harmful by-product haz-

ard and can damage the Cooktop.

• When using the cooktop: DO

NOT TOUCH THE BURNER

GRATES OR THE IMMEDIATE

SURROUNDING AREAS adja-

cent to the burners, which may be-

come hot enough to cause burns.

• Never leave the cooktop un-

attended when using high flame

settings. Boil-overs cause smok-

ing and greasy spills that may ig-

nite. More importantly, if the

burner flames are smothered, un-

burned gas will escape into the

room. See inside the front cover

regarding gas leaks.

• Only certain types of glass,

heatproof glass-ceramic, ce-

ramic, earthenware or other

glazed utensils are suitable for

cooktop use. This type of utensil

may break with sudden tempera-

ture changes. Use only on low or

medium heat settings according

to the utensil manufacturer’s di-

rections.

• Do not heat unopened food

containers; a buildup of pressure

may cause the container to burst.

• During cooking, set the burner

control so that the flame heats

only the bottom of the pan and

does not extend beyond the

bottom of the pan.

• Use caution to insure that drafts

like those from forced air vents or

fans do not blow flammable ma-

terial toward the flames or push

the flames so that they extend be-

yond the edges of the pot.

• Always use utensils that have

flat bottoms, large enough to

cover the burner. The use of un-

dersized utensils can expose a

portion of the flame and may re-

sult in ignition of clothing.

• Bakeware, such as large cas-

serole pans, cookie sheets, etc.,

should never be used on the

cooktop.

• To minimize the risk of burns, ig-

nition of flammable materials and

unintentional spills, position

handles of utensils inward so

they do not extend over adjacent

work areas, cooking areas or the

edge of the cooktop.

• Hold the handle of the pan to

prevent movement of the utensil

when stirring or turning food.

• Do not use pots or pans on the

grill plate accessory.

• Do not use the grill plate ac-

cessory for cooking exces-

sively fatty meats or products

which promote flare-ups.

• The optional cutting board ac-

cessory must be removed

be-

fore operating the griddle.

• GREASE IS FLAMMABLE. Let

hot grease cool before attempt-

ing to handle it. Avoid letting

grease deposits collect. Clean af-

ter each use.

• For proper lighting and perfor-

mance of the burners, keep the

ports clean. It is necessary to

clean these when there is a boil

over or when the burner does not

light even though the electronic

igniters activate. See Page 17 for

cleaning Star Burner ports.

WARNING

After a spill or boil over, turn off

the burner and clean around

the burner and burner ports.

After cleaning, check for proper

operation.

• Clean the cooktop with cau-

tion. Avoid steam burns; do not

use a wet sponge or cloth to clean

the cooktop while it is hot. Some

cleaners produce noxious fumes

if applied to a hot surface. Follow

directions provided by the cleaner

manufacturer.

• Do NOT obstruct the flow of

combustion or ventilation air.

• Be sure all cooktop controls

are turned off and the cooktop

is cool before using any type of

aerosol cleaner on or around the

cooktop. The chemicals that pro-

duce the spraying action can, in

the presence of heat, ignite or

cause metal parts to corrode.

• Service should only be done by

authorized technicians. Techni-

cians must disconnect the power

supply before servicing this unit.

• To avoid a fire hazard, grease

accumulation must be pre-

vented by frequently cleaning

the ventilation hood and filters.

• In case of fire or when inten-

tionally “flaming” liquor or

other spirits on the cooktop,

follow hood manufacturer’s in-

structions.

• Install a smoke detector in or

near the kitchen.

•

IMPORTANT SAFETY NO-

TICE: The California Safe Drinking

Water and Toxic Enforcement Act re-

quires the Governor of California to

publish a list of substances known to

the state to cause cancer, birth de-

fects or other reproductive harm, and

requires businesses to warn custom-

ers of potential exposure to such sub-

stances.

The burning of gas cooking fuel can

generate some by-products, which

are on the list. To minimize expo-

sure to these substances, always

operate this unit according to the

instructions contained in this

booklet and provide good ventilation.

CAUTION

Section 1: GENERAL SAFETY INSTRUCTIONS

SAVE THESE INSTRUCTIONS

Before Using Your Cooktop for the First Time

Section 2: BEFORE YOU BEGIN

1. Check that you have all the items listed for your model, as shown in the table below.

2 . Record the Model and Serial number of your appliance as described on Page 21. This may be used for

any future contacts with your servicer or the factory. Enter this information on the Product Registration

Card included with this product; then mail it to the indicated address.

3. Optional Accessories: Grill Plate, Grill Cover, Griddle Cover, Cast Iron Wok Ring, Chopping Board for

built-in griddle area. A portable griddle and other accessories are available from your Thermador dealer.

4. Ensure that the burner caps are seated correctly on the burner bases. Turn on each burner to check for

proper flame color. See Page 10 for details.

BEFORE USING YOUR ELECTRIC GRIDDLE THE FIRST TIME

Clean the surface with hot soapy water. Rinse thoroughly with clear water. Check adjustment of griddle

plate, for slight tilt forward. See INSTALLATION MANUAL. The griddle is now ready to use.

* Backguard or Island Trim must be ordered separately. These are not included with the cooktop.

Description

36” with Griddle

36” 6-Burner

48” with Griddle

Star Burner caps

Burner Grates

Center Grate

Control Knobs

Coated Aluminum

Griddle

Product

Registration Card

Backguard

Installation

Instructions

Care and Use

Manual

664

233

30” 4-Burner

MODEL AND PARTS IDENTIFICATION FOR 36" AND 30" MODELS

1 – 12” Low Back or Island Trim

(ordered separately)

2 – Burner Grates & Burners

3 – Griddle

4 – Control Knobs, ExtraLow

Burners

5 – Control Knob, Griddle

Thermostat

6 – Control Knobs, Standard

Burners

7 – Center Grate - shown in top view

Key

4 Burners and Griddle

6 Burners

4 Burners and Griddle

Section 3: DESCRIPTION

MODEL AND PARTS IDENTIFICATION FOR 48" MODEL

Key

1 – 12” Low Back or Island Trim

(ordered separately)

2 – Burner Grates & Burners

3 – Griddle

4 – Control Knobs, Standard

Burners

5 – Control Knob, Griddle

Thermostat

6 – Control Knobs, ExtraLow®

Burners

6 Burners and Griddle

4 Burners and Center Grate

Sealed Burners

Using The Cooktop

Section 4: USING THE COOKTOP

The cooktop features four or six gas surface

burners; each rated at 18,000 BTU/HR (15,000

BTU/ HR using Propane). The burners are

mounted on top of unique-shaped pedestals.

This makes the burner assemblies accessible

for easy cleaning. On all models, the two left

burners have the exclusive ExtraLow feature,

the remaining burners are standard. Each

burner has its own control knob.

Star Brass Burner Base

CONTROL KNOBS

The control knobs for two gas burners, one in

front and one in the rear, are located directly in

front of and below the pair of burners on the

control panel.

The symbol above each control knob identifies

either the burner position on the cooktop or the

griddle control, depending upon your model.

BTU for Standard Burners

• HI is equivalent to 18,000 BTU/HR

(15,000 BTU / HR using Propane).

• SIM is equivalent to 2,100 BTU / HR.

BTU for ExtraLow® Burners

• HI is equivalent to 18,000 BTU/HR

(15,000 BTU / HR using Propane).

• SIM is equivalent to 3,000 BTU / HR.

• XLO is equivalent to 370 BTU / HR.

Standard Burner Control Knob

Bezel

Knob

Setting Indicator

OPERATION OF THE BURNERS

• Press in on the knob and turn it counter-

clockwise to the setting on the knob.

• The igniter for the selected burner clicks and

sparks.

• After burner ignition, the igniter stops clicking.

• Rotate the knob to any flame setting between

HI and SIM.

• The blue signal light, between the burner

knobs, will light when adjacent burners are lit.

The light will remain on until the adjacent

burners are turned off.

LEFT REAR LEFT FRONT

Burner: Burner:

CENTER REAR CENTER FRONT

Burner: Burner:

RIGHT REAR RIGHT FRONT

Burner: Burner:

GRIDDLE:

ExtraLow® Burners

The controls for the two left burners, front and

rear, have flame settings even lower than the

standard SIM settings.

Section 4: USING THE COOKTOP

ExtraLow Burner Control Knob

Setting Indicator

ExtraLow

Range

The drawing shows that the control knob has

an additional range between the SIM and XLO

settings. When the knob is set within this

range, the flame cycles off and on. By varying

the length of time the flame is off and on, the

heat is reduced even further to cook delicate

foods. For example, these very low settings are

suitable for simmering and poaching, melting

chocolate and butter, holding cooked foods at

temperatures without scorching or burning, etc.

Operation of the ExtraLow Burners

• XLO, the very lowest setting, is achieved by

cycling the flame ON for approximately 8

seconds and OFF for 52 seconds of each

minute.

• When the knob is set just below the SIM setting,

the flame will cycle ON for approximately 52

seconds and OFF for 8 seconds of each

minute.

• To vary the amount of low heat to suit the food

and quantity, the control can be set anywhere

within the SIM and XLO range marked on the

knob.

ExtraLow Techniques

• The type and quantity of food affects which

setting to use.

• The pan selected affects the setting. Its size,

type, material, and whether a lid is used, all

affect the consistency of the cooking

temperature.

• To maintain a low or simmer heat, bring food

to a rolling boil. Stir well, then cover the pan

and lower the heat to a setting just below SIM.

• Check periodically to see if the control knob

should be turned to another setting.

• If an over-size pan is used, the simmer action

may occur mainly in the center of the pan. To

equalize the temperature throughout the food,

stir the food around the outer edges of the pan

into the food in the center.

• It is normal to stir food occasionally while

simmering. This is especially important when

simmering for several hours, such as for a

homemade spaghetti sauce or beans.

• When lowering the flame setting, adjust it in

small steps.

• If the setting is too low to hold a simmer, bring

the food back to a boil before re-setting to a

higher heat.

• It is normal not to see simmer bubbles

immediately after the food has been stirred.

• There may be bubbling when the flame cycles

ON and no bubbles when the flame is OFF.

Even when the flame is OFF, there will be

steam and a slight quiver on the liquid’s

surface.

WARNING

To prevent burns, do not touch burner caps or

grates while hot. Turn the cooktop off and allow

the burners to cool.

Section 4: USING THE COOKTOP

CAUTION

Do not touch the burners when the

igniters are sparking.

Igniter

Each burner has its own electronic igniter that

sparks when the burner is turned on. Each

burner should light in 4 seconds or less. If a

burner does not light, check to see that the

burner cap is positioned correctly on the burner

base.

If a burner fails to ignite, refer to “Before Calling

For Service” on page 21.

Star® Burner Components

Ports

Burner

Cap

Brass

Burner

Base

Igniter

Burner Cap Placement

The burner caps must be properly placed on the

burner bases for the cooktop to function properly.

If a burner cap is not properly placed, one or more

of the following problems may occur:

• Burner flames are too high.

• Flames shoot out of the burners.

• Burners do not ignite.

• Burner flames light unevenly.

• Burner emits gas odor

WARNING

To prevent flare-ups and avoid creation of harmful

by-products, do not use the cooktop without all

burner caps and all burner grates properly

positioned.

Checking Burner Cap Placement

• Check to make sure there is no gap between the

burner cap and burner base. See figure “Burner

Cap Placement” to see the correct and incorrect

placements of the burner cap.

• You may gently try to move the burner cap from

side to side to check if it is properly placed. If

properly placed, the cap will click from side to

side as the prongs hit the groove ridge.

Correct Burner

Cap Placement

Incorrect Burner

Cap Placement

Flame Color

Secondary Cone

Primary

Light Blue

Dark Blue

Section 4: USING THE COOKTOP

FLAME DESCRIPTION

• The burner flame color should be blue with

no yellow on the tips. It is not uncommon to

see orange in the flame color; this indicates

the burning of airborne impurities in the gas

and will disappear with use.

• With propane (LP) gas, slight yellow tips on

the primary cone are normal.

• The flame should burn completely around the

burner cap. If it doesn’t, check that the cap is

positioned correctly on the base and that the

ports are not blocked.

• The flame should be stable with no excessive

noise or fluttering.

WARNING:

The burning of gas cooking fuel can create

small amounts of Carbon Monoxide, Benzene,

Formaldehyde and Soot. To minimize expo-

sure to these substances, the burners should

be adjusted by a certified installer or agency to

ensure proper combustion. Ensure proper

ventilation with an open window or use a

ventilation fan or hood when cooking with Gas.

Always operate the unit according to the

instructions in this manual.

AUTOMATIC RE-IGNITION

If any one or more burners blow out, the

electronic igniter automatically activates to re-

light the flame. Do not touch the burners when

the igniters are active.

Important:

• For proper combustion do not use the cooktop

without the burner grates in place.

• There is a slight sound associated with gas

combustion and ignition. This is a normal

condition.

• On cooktops using propane gas (LP), a slight

“pop” sound may be heard at the burner ports

a few seconds after the burner has been turned

off.

POWER FAILURE

• In the event of a power failure, only the

standard burners can be manually lit. It is

necessary to light each one individually. If the

cooktop is being used when the power failure

occurs, turn all knobs to the OFF position.

• The standard burners can be lit by holding a

match at the ports and turning the control knob

to the position. Wait until the flame is

burning all around the burner cap before

adjusting the flame to the desired height.

• The ExtraLow burners cannot be used during

a power failure. Be sure to turn them off.

• If an ExtraLow burner is on when a power

failure occurs, it cannot be turned back on until

the knob is first turned off.

• The griddle cannot be used during a power

failure.

• If you smell gas, refer to safety precautions in

the front of this manual.

WARNING

In the event of a power failure, all knobs are to

be turned to the OFF Position. Only the

standard burners can be lit manually.

FLAME HEIGHT

• The correct flame height depends on 1) size

and material of pan being used; 2) food being

cooked; and 3) amount of liquid in the pan.

• Never extend the flame beyond the base of

the pan.

• Use a low or medium flame for pan materials

that conduct the heat slowly, such as

porcelain coated steel or glass-ceramic.

Section 4: USING THE COOKTOP

Cookware Recommendations

• Balance is important for stability and even cooking.

The handle must not be heavier than the pan and

tilt it unevenly. A pan must sit level on the grate

without rocking or wobbling.

• Food packaged in aluminum foil should not be

placed directly on the burner grate. Aluminum foil

can melt during cooking.

• Do not let plastic, paper or cloth come in contact

with a hot burner grate. They may melt or catch

fire.

• Never let a pan boil dry. This can damage your

pan and the cooking surface.

Balanced Pan

Base Diameter

Covered Pan

WARNING:

To avoid risk of serious injury, damage to appliance or cookware, please observe the following:

(51 mm)

• Bakeware, such as large casserole pans, cookie

sheets, etc. should never be used on the cooktop.

• Placement of large stock pots should be staggered

when used on the cooktop.

• Select the base diameter to match the diameter

of the flame. The diameter of the flame should be

the same size as the pan base or slightly smaller.

Oversize or under size pans sacrifice cooking

performance. A 5

/2" (140 mm) base size is

generally the smallest recommended.

• Professional quality pans with metal handles are

recommended because plastic handles can melt

or blister if the flame extends up the side of the

pan. Professional quality pans are found at res-

taurant supply stores and gourmet specialty

shops. All cookware should have these charac-

teristics: good heat conductivity, good balance,

correctly sized base diameter, a heavy, flat base,

and a proper fitting lid.

• For best cooking results, the flame should be

contained under the bottom of the pan.

• Aluminum and copper are pan materials that

conduct the heat quickly and evenly. These met-

als are sometimes attached to the base or in the

core between stainless steel.

Flat Base Pan

• A properly fitting lid will shorten cooking time and

make it possible to use lower heat settings.

• A heavy, flat base is more apt to remain flat when

heated. Pan bases that are warped, dented, ridged

or too lightweight will heat unevenly. Heat and cool

pans gradually to avoid sudden temperature

changes which tend to distort cookware. Do not

add cold water to a hot pan.

Section 4: USING THE COOKTOP

Flat-bottom Wok Pan

Specialty Cookware

COOKING

Recommendations

Suggestions for Using the Recommendations

Use the recommendations on Pages 13 and 14 as a

guide. The settings you use will vary depending on

the pans selected and the starting temperature of

the food.

In the recommendations, the “Finish Setting” has

been separated for the standard and ExtraLow

burners. There may or may not be a change between

the two burner settings.

The ExtraLow setting can be either a cooking or a

holding setting.

Raise or lower the flame setting gradually. Allow time

for the pan and the food to adjust to the new setting.

Round-Bottom Wok

in Support Ring

• Woks – Either flat based or round bottom woks

with the accessory ring can be used on models

without a built-in wok burner. Round bottom woks

must be used with a support ring. The porcelain-

coated cast iron wok support ring must be

purchased separately.

• Canners and Stock Pots – Select one with a base

diameter that extends no more than 2 inches

(51mm) beyond the grate.

Standard Size Water Bath Canner

21 to 22 quarts (19.95 to 20.9 liters),

with an 11 to 12 inch base (27.9 to 30.5 cm)

and

a 9 to 11 inch depth (22.9 to 27.9 cm).

Standard Size Pressure Canner

8 to 22 quarts (7.6 to 20.9 liters), with an

8 to 11 inch base (20.3 to 27.9 cm) and

a 6

-1

/2" to 12 inch depth (16.5 - 30.5 cm).

Canning Tips:

• A flat base pan is preferred to one with a con-

cave, convex or rippled base.

• When using two canners at the same time, use

staggered burners. Do not block air to the burn-

ers. A flame needs the right amount of air for

complete combustion.

• Use a cover on a canner when bringing the

contents to a boil.

• Once the contents have reached a boil on HI, use

the lowest flame possible to maintain the boil or

pressure.

• Canning produces a large amount of steam.

Take precautions to prevent burns.

Section 4: USING THE COOKTOP

Surface Burner Cooking Recommendations

BEVERAGES MED – heat milk SIM – finish heating

XLO

– keep warm, cover*

Cocoa

BREADS MED – preheat skillet SIM to MED – cook Same as for Standard

French Toast, Pancakes, Burners

Grilled Sandwiches

BUTTER SIM – to start melting Allow 5 to 10

Melting minutes to melt

CEREALS HI – cover, bring SIM to MED – Same as for Standard

Cornmeal, Grits, water to a boil, add finish cooking Burners

Oatmeal cereal according to package

directions XLO – to hold, cover*

CHOCOLATE XLO – may be stirred XLO – Allow 10 to 15

Melting to hasten melting minutes to melt

XLO – to hold*

DESSERTS SIM to MED – cook SIM to MED Same as for Standard

Candy following recipe Burners

Pudding and Pie Filling SIM to MED SIM – SIM Same as for Standard

Mix cook according to Burners

package directions

Pudding SIM to MED SIM – SIM Same as for Standard

Bring milk to a boil Burners

EGGS MED HI – cover eggs XLO – cook 3 to 4

Cooked in Shell with water, add lid, minutes for soft cooked;

bring to boil or 15 to 20 minutes for

hard cooked

Fried, Scrambled SIM to MED – melt SIM – finish cooking Same as for Standard

butter, add eggs Burners

XLO – to hold for a

short period*

Poached HI – bring water to SIM to MED – finish Same as for Standard

the boiliong point, cooking Burners

add eggs

MEAT, FISH, POULTRY MED HI – until meat starts SIM to MED – finish Same as for Standard

Bacon, Sausage Patties to sizzle cooking Burners

Braising: Swiss Steak, MED HI – melt fat, then XLO – Simmer until tender

Pot Roast, Stew Meat brown on MED HI,

add liquid, cover

Quick Frying: Breakfast MED HI – preheat MED HI – fry quickly Same as for Standard

Steaks skillet Burners

Frying: Chicken MED HI – heat oil, then SIM – cover, finish Same as for Standard

brown on MED cooking Burners

Deep Frying: Shrimp MED HI – heat oil MED to MED HI – to Same as for Standard

maintain temperature Burners

Pan Frying: Lamb Chops,

MED HI – preheat MED – brown meat Same as for Standard

Thin Steaks, Hamburgers,

skillet Burners

Link Sausage XLO – to hold

Poaching: Chicken, MED HI – cover, bring XLO – to finish cooking

whole or pieces, Fish liquids to a boil

Food Start Setting Finish Setting Finish Setting

Standard Burners ExtraLow (XLO) Burners

Section 4: USING THE COOKTOP

Surface Burner Cooking Recommendations

* It is recommended that these foods be stirred occasionally.

Simmering: Stewed HI – cover, bring liquid XLO – to simmer slowly

Chicken, Corned Beef, to a boil XLO – to hold, cover*

Tongue, etc.

PASTAS HI – bring water to a MED to MED HI – to Same as for Standard

Macaroni, Noodles, boil, add pasta

maintain a rolling boil

Burners

Spaghetti

POPCORN (use a heavy, HI – cover, heat until MED HI – finish Same as for Standard

flat bottom pan) kernels start to pop popping Burners

PRESSURE COOKER MED HI to HI – build SIM to MED – Same as for Standard

Meat up pressure maintain pressure Burners

Vegetables HI – build up pressure SIM to MED – Same as for Standard

maintain pressure Burners

RICE HI – cover, bring SIM – to maintain Same as for Standard

water and rice to a boil low boil Burners

Cover and cook until XLO – to hold, cover

water is absorbed.

SAUCES MED HI – cook SIM – to maintain XLO – simmer to thicken

Tomato Base meat/vegetables, simmer sauce, uncovered

follow recipe

White, Cream, Bernaise MED – melt fat, SIM – finish cooking XLO – to hold, cover*

follow recipe

Hollandaise XLO XLO – to hold, lowest

setting for short period,

stir frequently

SOUPS, STOCK HI – cover, bring SIM – to maintain Simmer

liquid to a boil simmer XLO – to hold, cover*

VEGETABLES HI – cover, bring SIM to MED – cook Same as for Standard

Fresh water and vegetables 10 minutes, or until Burners

to a boil tender XLO – to hold, cover

Frozen HI – cover, bring SIM to MED – cook Same as for Standard

water and vegetables according to Burners

to a boil package directions

Deep Frying HI – heat oil MED to MED HI – Same as for Standard

maintain frying Burners

temperature

In Pouch HI – bring water and SIM to MED – cook Same as for Standard

pouch to a boil according to Burners

package directions

Saute MED HI – heat oil or SIM to MED – Same as for Standard

melt butter, add cook to desired Burners

vegetables doneness

Stir Fry HI – heat oil, add MED to MED HI – Same as for Standard

vegetables finish cooking Burners

Food Start Setting Finish Setting Finish Setting

Standard Burners ExtraLow (XLO) Burners

DESCRIPTION

(Available on some models)

The built-in griddle is made of restaurant-quality

aluminum that is coated with a non-stick coating. This

produces a surface with even heat that is easy to

clean. A maple chopping block, stainless steel cover,

and coated-aluminum grill plate are available as

accessories and are purchased separately. The

maple chopping block and stainless steel cover are

sized to fit on top of the surface when the griddle is

not being used. The coated-aluminum grill plate

accessory is designed to replace the griddle plate.

See the instructions that come with the grill plate

accessory for more details.

The maple chopping block and stainless steel cover

must be removed before turning the griddle on.

• The electric griddle element is rated 120 volts AC,

1,600 watts.

PREPARING THE GRIDDLE

The griddle must be tilted slightly forward for

optimum performance. See Installation Manual for

procedure to check and adjust griddle for proper tilt

of griddle plate. During installation, the installer is

responsible for leveling the product. The griddle plate

should be washed with warm soapy water then

rinsed with clear water prior to use.The griddle may

be used without any butter, margarine or oil.

However, a very small amount may be used to flavor

foods.

Any utensil may be used on the griddle surface.

Care should be taken that the surface is not gouged

when utensils are used.

• The griddle is electronically controlled with tem-

peratures marked on the knob from 150°F to

500°F.

• There are no fixed settings on the knob

• Press and turn the knob clockwise to the tem-

perature setting.

About the Griddle

CONTROL KNOB

Griddle Control Knob

Griddle Grease Tray

• Push the tray under the front edge of the griddle

overhang to catch grease or food residue.

• Clean the tray after every use. When removing

the tray, use care when tipping it so that the

contents do not spill (see illustration).

• After cooling, pour the grease into a grease

resistant container for disposal.

To remove tray,

slide back and lift

Griddle Grease Tray

CAUTION:

The griddle element is hot after use. Allow

sufficient time for griddle components to

cool before cleaning.

Section 4: USING THE COOKTOP

Griddle

Cooking on the Griddle

1. Check that the grease tray is tucked under the

griddle plate overhang.

2. Turn the knob to the cooking temperature to preheat

the griddle.

3. Preheat 10 to 12 minutes or until the light indicator

goes off.

4. Add butter, margarine, oil or shortening if desired.

Section 4: USING THE COOKTOP

GRIDDLE COOKING RECOMMENDATIONS

FOOD

SETTING

Eggs

Bacon, Breakfast Sausage

Toasted Sandwiches

Boneless Chicken Breasts

Boneless Pork Chops,

1" thick

Steaks, 1" thick

Ground Beef Patties (6 ounces)

Hot Dogs

Ham Slices, 1/2" thick

Pancakes, French Toast

Potatoes, Hash Browns

325°F to 350°F (160°C to 180°C)

375°F to 400°F (190°C to 200°C)

350°F to 375°F (180°C to 190°C)

375°F to 400°F (190°C to 200°C)

400°F to 425°F (200°C to 220°C)

375°F to 400°F (190°C to 200°C)

350°F to 375°F (180°C to 190°C)

375°F to 400°F (190°C to 200°C)

NOTICE:

Griddle / Grill performance may vary if there is an

excessive amount of airflow in the vicinity of the

appliance. The excessive airflow could be from an

air-conditioning register or ceiling fan blowing at the

cooktop. This could create longer than normal heat-

up time or it could cause the Griddle / Grill

temperature to be higher or lower than the knob

setting.

Note:

Having a properly installed ventilation hood is not

considered a source of excessive airflow.

Section 5: CARE AND MAINTENANCE

Care and Maintenance

CAUTION

Avoid cleaning any part of the cooktop while it

is hot. Do not clean any removable part of the

cooktop in a self-cleaning oven.

ABOUT

THESE RECOMMENDATIONS

• Always start by selecting the mildest cleaner

according to the kind of soil and the material

soiled. To prevent marring the stainless steel

finish, always apply the cleaners in the direction

of the polish lines. Rinse and dry immediately to

avoid water marks.

• Use clean applicators, i.e. soft cloths, sponges,

paper towels, soap-filled pads, for cleaning and

scouring.

• The use of brand names in these recommenda-

tions is intended only to indicate a type of cleaner.

This does not constitute an endorsement. The

omission of any brand name cleaner does not

imply its inadequacy.

• The brands listed are suggested as examples of

a type of cleaner, such as non-abrasive, mild

abrasive, powder, creme, etc. Use all products in

accordance with the manufacturer’s instructions.

Cooktop Part / Material Suggested Cleaners Important Reminders

COOKTOP CLEANING RECOMMENDATIONS

• Hot sudsy water; rinse and dry

thoroughly.

• Mild Abrasive Cleansers: Bon

Ami

, Cameo

aluminum and

stainless steel cleaner,

Wright's

all purpose brass

polish.

• Liquid cleaners: Kleen King

• Stiff nylon bristle tooth brush

to clean port openings.

• After cleaning, re-assemble

the burner cap to the burner

base correctly. Make sure the

cap is completely seated when

positioned on the

base.

• Hot sudsy water; rinse and dry

immediately.

Control Knobs

Metal

Bezels

Chrome

• Do not soak knobs.

• Do not force knobs onto

wrong valve shaft.

• Do not scratch or gouge the

port features of the brass

burner base.

Brass Burner Base

And Cast Iron Cap

Burner

Cap

Burner

Base

Section 5: CARE AND MAINTENANCE

Cooktop Cleaning Recommendations

• The grates are heavy; use

care when lifting. Place on

a protected surface.

• Blisters/

crazing/

chips are

common due to the extreme

temperatures on grate

fingers and rapid

temperature changes.

• Acidic and sugar-laden spills

deteriorate the enamel.

Remove soil immediately.

• Abrasive cleaners, used too

vigorously or too often can

eventually mar the enamel.

• Nonabrasive cleaners: Hot

water and detergent,

Fantastic

, Formula 409

Rinse and dry immediately.

• Mild abrasive cleaners: Bon

Ami

and Soft Scrub

• Abrasive cleaners for stubborn

stains: soap-filled steel wool

pad.

• Lestoil

or other degreaser.

Grates: /

Porcelain Enamel

on Cast Iron

• Stainless steel resists most

food stains and pit marks

provided the surface is kept

clean and protected.

• Never allow food stains or

salt to remain on stainless

steel for any length of time.

• Rub lightly in the direction

of polish lines.

• Chlorine or chlorine

compounds in some

cleaners are corrosive to

stainless steel. Check

ingredients on label.

• Nonabrasive Cleaners: Hot

water and detergent,

ammonia, Fantastic

Formula

409

. Rinse and dry

immediately.

• Cleaner Polish: Stainless Steel

Magic

to protect the finish

from staining and pitting;

enhances appearance.

• Hard water spots: Household

vinegar.

•

Mild Abrasive Cleaners: Siege

Stainless Steel and Aluminum

Cleaner, Kleen King

Stainless

Steel liquid cleaner, Wright's

All Purpose Brass Polish.

• Heat discoloration: Cameo

Barkeepers Friend

, Zud

Wright’s

All Purpose Brass

Polish.

Cooktop Part / Material Suggested Cleaners Important Reminders

Exterior Finish/Back Guard

Stainless Steel

Griddle Grease Tray

Aluminum with non-stick

coating

• Clean the grease tray(s) after

each use.

• May be placed in dishwasher.

• Wash in detergent and hot

water; rinse and dry.

• Stubborn soil: Soft Scrub

• Empty grease tray after

each use.

• Remove tray after grease

has cooled. Be careful not

to fill the tray so full that

tipping to remove it spills the

grease.

Lift and slide

back

La page charge ...

Thermador PCG486GD Manuel utilisateur

Marque: Thermador

Modèle: PCG486GD

Catégorie: Barbecues

Taper: Manuel utilisateur

Ce manuel convient également à

PCG366G

Télécharger le PDF

rapport

dans d''autres langues

English: Thermador PCG486GD User manual

Documents connexes

Autres documents

Bosch Appliances PGL985UC Manuel utilisateur