RAIS Rina 90 Manuel utilisateur

1

English RAIS - Manual for RAIS Rina, RAIS Viva , RAIS Juno

USER MANUAL

MANUAL D’UTILISATEUR

GEBRUIKERSHANDLEIDING

RAIS Rina

RAIS Viva

RAIS Juno

N

O

R

D

I

S

K

M

I

L

J

Ø

M

Æ

R

K

N

I

N

G

5

7

8

0

5

EN 13240:2001+A2:2004

Raumheizer für feste Brennstoffe

Appliance fired by wood

Poêle pour combustibles solides

Produced at:

RAIS A/S, Industrivej 20, 9900 Frederikshavn, Danmark

Certification

110-0369/TG20196

VKF-NR:

22767

Typ FC

41x FC51x

15a B-VG

EC.NO: 131

AFSTAND TIL BRÆNDBART, BAGVÆG

ABSTAND ZU BRENNBAREN BAUTEILEN, HINTEN

DISTANCE TO COMBUSTIBLE BACK WALL

DIST. ENTRE COMPOSANTS COMBUSTIBLES, ARRIÈRE

AFSTAND TIL BRÆNDBART, SIDEVÆG

ABSTAND ZU BRENNBAREN BAUTEILEN, SEITE

DISTANCE TO COMBUSTIBLE SIDE WALL

DISTANCE ENTRE COMPOSANTS COMBUSTIBLES, COTÉ

AFSTAND TIL BRÆNDBART, MØBLERING

ABSTAND VORNE ZU BRENN

BAREN MÖBELN

DISTANCE TO FURNITURE AT THE FRONT

DISTANCE ENTRE COMPOSANTS COMBUSTIBLES, DEVANT

CO EMISSION (REL. 13% O

2)

CO EMISSION IN DEN VERBRENNUNGSPRODUKTEN (BEI 13%O

2)

EMISSION OF CO IN COMBUSTION PRODUCTS (AT 13%O

2)

EMISSION CO DANS LES PRODUITS COMBUSTIBLES (À 13%O

2)

NOMINEL EFFEKT / HEIZLEISTUNG /

THERMAL OUTPUT / PUISSANCE CALORIFIQUE:

RØGGASTEMPERATUR / ABGASTEMPERATUR /

FLUE GAS TEMPERATURE / TE

MPÉRATURE DES GAZ DE FUMÉE:

VIRKNINGSGRAD / ENERGIEEFFIZIENZ /

ENERGY EFFIENCY /EFFICACITÉ ÉNERGÉTIQUE:

DK: Brændsel (Brug kun anbefalede brændsler) Følg instrukserne i brugermanualen.

Anordningen er egnet til røggassamleledning og intervalfyring.

DE: Hinweis: Lesen und befolgen Sie die Bedienungsanleitung.

Zeitbrandfeuerstätte. Nur empfohlene Brennstoffe einsetzen.

UK: Fuel types (only recommended)

Follow the installation and

operating instruction manual. Intermittent operation.

F: Remarque: Veuillez lire et observer les instructions du mode d'emploi.

Foyer à durèe de combustion limitèe, homologué pour cheminée à

connexions multiples. Utiliser seulement les combustibles recommandés.

Hergestellt für /Produced for:

ATTIKA FEUER AG, Brunnmatt 16, CH-6330 Cham / RAIS A/S, Industrivej 20, DK-9900 F

rederikshavn

STØV / STAUB /

DUST / POUSSIÈRES:

DK: 11 mg/Nm3 / DE: 11 mg/Nm3

UK: 11 mg/Nm3 / FR: 11 mg/Nm3

DK: 271°C / DE: 271°C

UK: 271°C / FR: 271°C

DK: 4 kW / DE: 4 kW

UK: 4.6 kW / FR: 4 kW

DK: 79% / DE: 79%

UK: 79% / FR: 79%

DK: BRÆNDE

DE: HOLZ

UK: WOOD

FR: BOIS

DK:150 mm/SE BRUGERVEJLEDNING

DE:150 mm/SIEHE BEDIENUNGSANLEITUNG

UK:150 mm/SEE USER MANUAL

FR:150 mm/CONSULTEZ LE GUIDE DE L'UTILISATEUR

DK:3

50 mm/SE BRUGERVEJLEDNING

DE:350 mm/SIEHE BEDIENUNGSANLEITUNG

UK:350 mm/SEE USER MANUAL

FR:350 mm/CONSULTEZ LE GUIDE DE L'UTILISATEUR

DK:700 mm/SE BRUGERVEJLEDNING

DE:700 mm/SIEHE BEDIENUNGSANLEITUNG

UK:700 mm/SEE USER MANUAL

FR:700 mm/CONSULTEZ LE GUIDE DE L'UTILISATEUR

DK: 0,1%

DE: 0,1% / 1250 mg/nm3

UK: 0,1%

FR: 0,1%

CE Label:

RINA 90

RINA 90 Classic

RINA SST

RINA SST Classic

14

RINA 90 / RINA 90 Classic / RINA SST / RINA SST Classic

UK - USER MANUAL ............................................................2-35

FR - MANUEL D’UTILISATEUR ...........................................36-65

FL - GEBRUIKERSHANDLEIDING ........................................66-94

DoP Declaration of Performance ................................................96

Rina 90/Rina SST

Manufacturer’s plate, Plaque signalétique, Merkplaatje

EN 13240:2001+A2:2004

Raumheizer für feste Brennstoffe

Appliance fired by wood

Poêle pour combustibles solides

Produced at:

RAIS A/S, Industrivej 20, 9900 Frederikshavn, Danmark

Certification

110-0369/TG20196

15a B-VG

EC.NO: 131

VKF-NR:

22767

Typ FC41x FC51x

AFSTAND TIL BRÆNDBART, BAGVÆG

ABSTAND ZU BRENNBAREN BAUTEILEN, HINTEN

DISTANCE TO COMBUSTIBLE BACK WALL

DIST. ENTRE COMPOSANTS COMBUSTIBLES, ARRIÈRE

AFSTAND TIL BRÆNDBART, SIDEVÆG

ABSTAND ZU BRENNBAREN BAUTEILEN, SEITE

DISTANCE TO COMBUSTIBLE SIDE WALL

DISTANCE ENTRE COMPOSANTS COMBUSTIBLES, COTÉ

AFSTAND TIL BRÆNDBART, MØBLERING

ABSTAND VORNE ZU BREN

NBAREN MÖBELN

DISTANCE TO FURNITURE AT THE FRONT

DISTANCE ENTRE COMPOSANTS COMBUSTIBLES, DEVANT

CO EMISSION (REL. 13% O

2)

CO EMISSION IN DEN VERBRENNUNGSPRODUKTEN (BEI 13%O

2)

EMISSION OF CO IN COMBUSTION PRODUCTS (AT 13%O

2)

EMISSION CO DANS LES PRODUITS COMBUSTIBLES (À 13%O

2)

NOMINEL EFFEKT / HEIZLEISTUNG /

THERMAL OUTPUT / PUISSANCE CALORIFIQUE:

RØGGASTEMPERATUR / ABGASTEMPERATUR /

FLUE GAS TEMPERATURE / T

EMPÉRATURE DES GAZ DE FUMÉE:

VIRKNINGSGRAD / ENERGIEEFFIZIENZ /

ENERGY EFFIENCY /EFFICACITÉ ÉNERGÉTIQUE:

DK: Brug kun anbefalede brændsler. Følg instrukserne i

brugermanualen. Anordningen er egnet til røggassamleledning og intervalfyring.

DE: Lesen und befolgen Sie die Bedienungsanleitung.

Zeitbrandfeuerstätte. Nur empfohlene Brennstoffe einsetzen.

UK: Fuel types (only recommended). Follow the instal

lation and

operating instruction manual. Intermittent operation.

F: Veuillez lire et observer les instructions du mode d'emploi.

Foyer à durèe de combustion limitèe, homologué pour cheminée à

connexions multiples. Utiliser seulement les combustibles recommandés.

Hergestellt für /Produced for:

ATTIKA FEUER AG, Brunnmatt 16, CH-6330 Cham / RAIS A/S, Industrivej 20, DK-9900 Frederikshavn

STØV / STAUB /

DUST / POUSSIÈRES:

DK: 11 mg/Nm3 / DE: 11 mg/Nm3

UK: 11 mg/Nm3 / FR: 11 mg/Nm3

DK: 271°C / DE: 271°C

UK: 271°C / FR: 271°C

DK: 4 kW / DE: 4 kW

UK: 4.6 kW / FR: 4 kW

DK: 79% / DE: 79%

UK: 79% / FR: 79%

DK: BRÆNDE

DE: HOLZ

UK: WOOD

FR: BOIS

DK:100 mm/SE BRUGERVEJLEDNING

DE:100 mm/SIEHE BEDIENUNGSANLEITUNG

UK:100 mm/SEE USER MANUAL

FR:100 mm/CONSULTEZ LE GUIDE DE L'UTILISATEUR

DK:350 mm/SE BRUGERVEJLEDNING

D

E:350 mm/SIEHE BEDIENUNGSANLEITUNG

UK:350 mm/SEE USER MANUAL

FR:350 mm/CONSULTEZ LE GUIDE DE L'UTILISATEUR

DK:700 mm/SE BRUGERVEJLEDNING

DE:700 mm/SIEHE BEDIENUNGSANLEITUNG

UK:700 mm/SEE USER MANUAL

FR:700 mm/CONSULTEZ LE GUIDE DE L'UTILISATEUR

DK: 0,1%

DE: 0,1% / 1250 mg/nm3

UK: 0,1%

FR: 0,1%

CE Label:

VIVA 98

VIVA 98 Classic

VIVA 120

VIVA 120 Classic

JUNO

JUNO Classic

14

VIVA 98 / VIVA 98 Classic / VIVA 120 / VIVA 120 Classic / JUNO / JUNO Classic

EN 13240:2001+A2:2004

Raumheizer für feste Brennstoffe

Appliance fired by wood

Poêle pour combustibles solides

Produced at:

RAIS A/S, Industrivej 20, 9900 Frederikshavn, Danmark

Certification

110-0369/TG20196

VKF-NR:

22767

Typ FC

41x FC51x

15a B-VG

EC.NO: 131

AFSTAND TIL BRÆNDBART, BAGVÆG

ABSTAND ZU BRENNBAREN BAUTEILEN, HINTEN

DISTANCE TO COMBUSTIBLE BACK WALL

DIST. ENTRE COMPOSANTS COMBUSTIBLES, ARRIÈRE

AFSTAND TIL BRÆNDBART, SIDEVÆG

ABSTAND ZU BRENNBAREN BAUTEILEN, SEITE

DISTANCE TO COMBUSTIBLE SIDE WALL

DISTANCE ENTRE COMPOSANTS COMBUSTIBLES, COTÉ

AFSTAND TIL BRÆNDBART, MØBLERING

ABSTAND VORNE ZU BRENN

BAREN MÖBELN

DISTANCE TO FURNITURE AT THE FRONT

DISTANCE ENTRE COMPOSANTS COMBUSTIBLES, DEVANT

CO EMISSION (REL. 13% O

2)

CO EMISSION IN DEN VERBRENNUNGSPRODUKTEN (BEI 13%O

2)

EMISSION OF CO IN COMBUSTION PRODUCTS (AT 13%O

2)

EMISSION CO DANS LES PRODUITS COMBUSTIBLES (À 13%O

2)

NOMINEL EFFEKT / HEIZLEISTUNG /

THERMAL OUTPUT / PUISSANCE CALORIFIQUE:

RØGGASTEMPERATUR / ABGASTEMPERATUR /

FLUE GAS TEMPERATURE / TE

MPÉRATURE DES GAZ DE FUMÉE:

VIRKNINGSGRAD / ENERGIEEFFIZIENZ /

ENERGY EFFIENCY /EFFICACITÉ ÉNERGÉTIQUE:

DK: Brug kun anbefalede brændsler. Følg instrukserne i

brugermanualen. Anordningen er egnet til røggassamleledning og intervalfyring.

DE: Lesen und befolgen Sie die Bedienungsanleitung.

Zeitbrandfeuerstätte. Nur empfohlene Brennstoffe einsetzen.

UK: Fuel types (only recommended). Follow the install

ation and

operating instruction manual. Intermittent operation.

F: Veuillez lire et observer les instructions du mode d'emploi.

Foyer à durèe de combustion limitèe, homologué pour cheminée à

connexions multiples. Utiliser seulement les combustibles recommandés.

Hergestellt für /Produced for:

ATTIKA FEUER AG, Brunnmatt 16, CH-6330 Cham / RAIS A/S, Industrivej 20, DK-9900 Frederikshavn

STØV / STAUB /

DUST / POUSSIÈRES:

DK: 11 mg/Nm3 / DE: 11 mg/Nm3

UK: 11 mg/Nm3 / FR: 11 mg/Nm3

DK: 271°C / DE: 271°C

UK: 271°C / FR: 271°C

DK: 4 kW / DE: 4 kW

UK: 4.6 kW / FR: 4 kW

DK: 79% / DE: 79%

UK: 79% / FR: 79%

DK: BRÆNDE

DE: HOLZ

UK: WOOD

FR: BOIS

DK:100 mm/SE BRUGERVEJLEDNING

DE:100 mm/SIEHE BEDIENUNGSANLEITUNG

UK:100 mm/SEE USER MANUAL

FR:100 mm/CONSULTEZ LE GUIDE DE L'UTILISATEUR

DK:400 mm/SE BRUGERVEJLEDNING

DE:

400 mm/SIEHE BEDIENUNGSANLEITUNG

UK:400 mm/SEE USER MANUAL

FR:400 mm/CONSULTEZ LE GUIDE DE L'UTILISATEUR

DK:650 mm/SE BRUGERVEJLEDNING

DE:650 mm/SIEHE BEDIENUNGSANLEITUNG

UK:650 mm/SEE USER MANUAL

FR:650 mm/CONSULTEZ LE GUIDE DE L'UTILISATEUR

DK: 0,1%

DE: 0,1% / 1250 mg/Nm3

UK: 0,1%

FR: 0,1%

CE Label:

VIVA 98 G

VIVA 98 G Classic

VIVA 120 G

VIVA 120 G Classic

JUNO G

JUNO G Classic

14

VIVA 98 G / VIVA 98 G Classic / VIVA 120 G / VIVA 120 G Classic / JUNO G / JUNO G Classic

Viva 98G / Viva 120G / Juno G

Manufacturer’s plate, Plaque signalétique, Merkplaatje

Viva 98 / Viva 120 / Juno

Manufacturer’s plate, Plaque signalétique, Merkplaatje

Using the wood burning stove

Utilisation du poêle

Gebruik van de kachel

Adjustment of the air damper

Réglage du volet d’air

Insellen van de klep

Position 1

Stand 1

Position 2

Stand 2

Position 3

Stand 3

The oven is wrapped in packaging that is recyclable. This must

be disposed of according to national rules regarding the dis-

posal of waste.

The glass can not be reused.

The glass should be discarded along with the residual waste

from

ceramics and porcelain.

Pyrex glass has a higher melting temperature and therefore can

not be reused.

If discarded you make an important positive contribution to

the environment.

FIRE ENVIRONMENTALLY FRIENDLY!

5 Eco-friendly advices for sensible heating

- common sense both environmentally and economically.

1. Effective lighting. Use dry brushwood, kindling and possible a piece of news

paper. Open the air damper, so plenty of air is fed to the stove and the gases

from the heated wood can burn rapidly.

2. Light the ﬁre with only little wood at a time - this gives the best combustion.

Remember plenty of air for every time new wood is added.

3. When the ﬂames are diminished, adjust the air damper so that the air supply

is reduced

4. When only glowing embers remain, air ﬂow can be reduced further, so heat-

ing demand is just covered. With a lower air supply the charcoal will burn

slower and the heat loss through the chimney is reduced.

5. Use only dry wood - ie wood with a humidity of 15 to 22 percent.

We cannot be held responsible for any misprints.

3

English RAIS - Manual for RAIS Rina, RAIS Viva , RAIS Juno

RAIS Rina - RAIS Viva - RAIS Juno

Revision: 6

Date : 11th November 2013

INTRODUCTION .................................................................................................................................. 4

WARRANTY ......................................................................................................................................... 4

SPECIFICATIONS .................................................................................................................................. 5

INSTALLATION INSTRUCTIONS .............................................................................................................. 6

CONVECTION ...................................................................................................................................... 7

CHIMNEY ........................................................................................................................................ 7-8

INSTALLATION ................................................................................................................................... 8-9

CHANGE OF CHIMNEY CONNECTION ................................................................................................ 10

INSTALLATION DISTANCE IN CASE OF COMBUSTIBLE WALL .......................................................... 11-16

NORMAL SET-UP - CORNER SETTING - RINA ....................................................................................... 12

NORMAL SET-UP - CORNER SETTING - VIVA / JUNO .......................................................................... 13

CORNER SETTING 45° - RINA ............................................................................................................ 14

CORNER SETTING 45° - VIVA / JUNO ................................................................................................. 15

360° SWIVEL BASE - VIVA / JUNO ...................................................................................................... 16

INSTALLATION DISTANCE IN CASE OF NON-COMBUSTIBLE WALL ...................................................... 17

FOR THE INSTALLER ........................................................................................................................... 18

OPERATING INSTRUCTIONS ................................................................................................................ 19

FUEL ........................................................................................................................................... 19-20

DRYING AND STORAGE .................................................................................................................... 21

REGULATION OF COMBUSTION AIR .................................................................................................. 21

ROOM VENTILATION AND STOVES .................................................................................................... 21

USING THE WOOD BURNING STOVE ................................................................................................ 22

ADJUSTMENT OF AIR DAMPER ......................................................................................................... 22

CONTROL ......................................................................................................................................... 22

FIRST USAGE .................................................................................................................................... 22

LIGHTING AND FUELLING ................................................................................................................... 23

CLEANING AND CARE ..................................................................................................................... 25

CLEANING OF THE FLUE WAYS .......................................................................................................... 25

INTERRUPTION OF OPERATION ......................................................................................................... 26

ACCESSORIES AND SPARE PARTS ....................................................................................................... 27

SPARE PART DIAGRAMS RAIS RINA 90 .............................................................................................. 27

SPARE PART DIAGRAMS RAIS VIVA 98 WITH SIDE GLASS ................................................................... 28

SPARE PART DIAGRAMS RAIS VIVA 98 WITHOUT SIDE GLASS ............................................................ 29

SPARE PART DIAGRAMS RAIS VIVA 120 WITH SIDE GLASS ................................................................. 30

SPARE PART DIAGRAMS RAIS VIVA 120 WITHOUT SIDE GLASS .......................................................... 31

SPARE PART DIAGRAMS RAIS JUNO WHIT SIDE GLASS ....................................................................... 32

SPARE PART DIAGRAMS RAIS JUNO WHITOUT SIDE GLASS ................................................................ 33

INSTALLATION OF SOAPSTONE - RINA ................................................................................................ 34

4

English RAIS - Manual for RAIS Rina, RAIS Viva, RAIS Juno

Introduction

Thank you for purchasing a RAIS wood burning stove. These appliances have been ap-

proved by SCA/HETAS Ltd as intermittent operating appliances for burning wood logs

only.

A RAIS wood burning stove is more than just a heat source: it also shows that you care

about design and quality in your home.

To make the most of your wood burning stove it is important that you read the manual

thoroughly, before installing and using it.

In the case of warranty coverage, and for general queries regarding your wood burning

stove, it is important that you know the stove’s production number. We therefore recom-

mend that you note down the number in the table below. The production number is

located on the back of the stove at the bottom.

Warranty

Your RAIS wood burning stove comes with a 5 year warranty. The warranty, however,

does not cover heat-insulating materials, glass and seals.

Any alterations made to the stove will void the warranty.

Date: Distributor:

5

English RAIS - Manual for RAIS Rina, RAIS Viva , RAIS Juno

Speciﬁcations

Rais Rina 90

Rais Viva 98

Rais Viva 98 G

Rais Viva 120

Rais Viva 120 G

Rais Juno

Rais Juno G

Nominal output (kW):

4.6 4.6 4.6 4.6

Min./Max. output (kW):

2-6 2-6 2-6 2-6

Heating area (m

2

):

30-90 30-90 30-90 30-90

Stove’s width/depth/height (mm):

461-410-900 Ø440-980 Ø440-1200 Ø470-1660

Combustion chamber’s width/depth/height (mm):

295-225-393

320-225-393

295-225-393

320-225-393

295-225-393

320-225-393

Recommended amount of wood when fuelling (kg):

(Distributed on 2-3 logs of wood of approx. 25 cm)

1,2 1,2 1,2 1,2

Min.uptake / min. draught (Pascal):

-12 -12 -12 -12

Weight (kg):

105 98 104 356

Efﬁciency (%):

79 79 79 79

CO-emission at 13% O

2

(%) 0.10 0.10 0.10 0.10

Particles after NS3058/3059 (g/kg):

1.39 1.39 1.39 1.39

Dust measured according to Din+ (mg/Nm³):

11 11 11 11

Smoke gas mass ﬂow (g/s):

4 4 4 4

Smoke gas temperature (°C):

271 271 271 271

Intermittent operation:

Refuelling should be undertaken within 3 hours

6

English RAIS - Manual for RAIS Rina, RAIS Viva, RAIS Juno

Installation instructions

The following pages give instructions for the safe and proper installation of this heating

appliance in the UK. These instructions cover the basic principles of installation, although

detail may need slight modiﬁcation to suit particular local site conditions. In all cases the

installation must comply with current UK Building Regulations, Local Authority Byelaws

and other speciﬁcations or regulations as they affect the installation of the stove. Please

note that it is a legal requirement under England and Wales Building Regulations that

the installation of the stove is either carried out under Local Authority Building Control

approval or is installed by a Competent Person registered with a Government approved

Competent Persons Scheme. HETAS Ltd operate such a Scheme and a listing of their Reg-

istered Competent Persons can be found on their website at www.hetas.co.uk.

It should be noted that the current Building Regulations requirements are given in Ap-

proved Document J. These requirements may also be met by adopting the relevant recom-

mendations given in British Standards BS 8303 and BS EN 15287-1.

WARNING: Health and Safety Advice Notice

The installation of this heating appliance is governed by the Health and Safety at Work

Act 1974. It is the responsibility of the installer to ensure that all requirements of this Act

are met during the installation works. Attention is drawn in particular to the following:

Handling:

The appliance is a heavy item and adequate facilities must be available for loading,

unloading and site handling.

Fire Cement:

Some types of ﬁre cement are caustic and should not be allowed to come into con-

tact with the skin. Protective gloves should be worn when handling ﬁre cement. In

case of contact with the skin wash immediately with plenty of water.

Asbestos:

This stove contains no asbestos. If there is a possibility of disturbing any asbestos in

the course of installation then please seek specialist guidance and use appropriate

protective equipment.

Metal Parts:

When installing or servicing this stove care should be taken to avoid the possibility

of personal injury.

Important Warning –Preparatory Work and Safety Checks:

• This stove must not be installed into a chimney that serves any other heating appli-

ance.

• It’s recommendet not have an extractor fan ﬁtted in the same room as the stove as

this can cause the stove to emit fumes into the room.

• If this appliance is installed into an existing chimney, the chimney must ﬁrst be swept

and examined for soundness and suitability before the appliance is installed (see also

section headed “Chimney”).

7

English RAIS - Manual for RAIS Rina, RAIS Viva , RAIS Juno

Convection

RAIS stoves are convection stoves. This means that the stove’s back and side panels are

not over-heated. Convection means that there is a circulation of air, which ensures that

the heat is distributed more evenly throughout the entire room. The cold air is sucked in

at the base of the stove up through the convection channel, which runs along the stove’s

combustion chamber. The heated air pours out at the top of the stove, which ensures a

circulation of warm air throughout the room.

The stoves are equipped with a “cold” lever – RAIS special feature – which means you

could almost do away with gloves. Be aware, however, that all exterior surfaces become

hot during use - so take extreme care.

Chimney

The chimney is the driving force which makes the stove function. In order for the stove to

perform satisfactorily the chimney height must be sufﬁcient to ensure the correct draught

of 14 to 18 Pa so as to clear the products of combustion and prevent problems of smoke

emanating into the room when ﬁring.

NOTE: A chimney height of not less than 4.5 metres measured vertically from the outlet

of the stove to the top of the chimney should be satisfactory. Alternatively the calcula-

tion procedure given in BS 5854:1980 may be used as the basis for deciding whether a

particular chimney design will provide sufﬁcient draught.

The outlet from the chimney should be above the roof of the building in accordance with

the provisions of Building Regulations Approved Document J.

If installation is into an existing chimney then it must be sound and have no cracks or

other faults which might allow fumes into the house. Older properties, especially, may

have chimney faults or the cross section may be too large i.e. more than 230 mm x 230

mm. Remedial action should be taken, if required, seeking expert advice, if necessary. If it

is found necessary to line the chimney then a ﬂue liner suitable for solid fuel must be used

in accordance with Building Regulations Approved Document J.

Any existing chimney must be clear of obstruction and have been swept clean immedi-

ately before installation of the stove. If the stove is ﬁtted in place of an open ﬁre then the

chimney should be swept one month after installation to clear any soot falls which may

have occurred due to the difference in combustion between the stove and the open ﬁre.

If there is no existing chimney then either a prefabricated block chimney in accordance

with Building Regulations Approved Document J or a twin walled insulated stainless steel

ﬂue to BS 1856-1can be used. These chimneys must be ﬁtted in accordance with the

manufacturer’s instructions and Building Regulations.

8

English RAIS - Manual for RAIS Rina, RAIS Viva, RAIS Juno

A single wall metal ﬂuepipe is suitable for connecting the stove to the chimney but is not

suitable for using for the complete chimney. The chimney and connecting ﬂuepipe must

have a minimum diameter of 150 mm and its dimension should be not less than the size

of the outlet socket of the stove which is 150 mm in diameter. Any bend in the chimney

or connecting ﬂuepipe should not exceed 45°. 90°bends should not be used.

Combustible material should not be located where the heat dissipating through the walls

of ﬁreplaces or ﬂues could ignite it. Therefore when installing the stove in the presence

of combustible materials due account must be taken of the guidance on the separation

of combustible material given in Building Regulations Approved Document J and also in

these stove instructions.

If it is found that there is excessive draught in the chimney then either an adjustable ﬂue

damper or alternatively a draught stabiliser should be ﬁtted. The adjustable ﬂue damper

should not close off the ﬂue entirely but should in its closed position leave a minimum

continuous opening free area of at least 20 % of the total cross sectional area of the ﬂue

or ﬂuepipe.

Adequate provision e.g. easily accessible soot door or doors must be provided for sweep-

ing the chimney and connecting ﬂuepipe.

You should also familiarise yourself with the draught conditions for chimneys with 2 ﬂues.

The ﬂue outlet spigot is eiter 150 (6”) mm in diameter, or 129 (5”) mm in diameter.

For strong draughts, the chimney or ﬂue should be ﬁtted with a draught stabiliser. In

which case, it is important to ensure that there is a free ﬂow-through area of minimum

20 cm² when the regulating gate is shut. Otherwise, the fuel energy may not be used

optimally. If, at any time, you are unsure about the condition of the chimney, you should

contact a chimney sweep.

Remember that access to the access door should be kept clear.

Installation

When installing the wood burning stove, there are some rules which MUST be followed:

The stove must be set up and installed in accordance with all current national and local

rules and regulations. Local authorities and a chimney specialist should be contacted prior

to set up.

It is prohibited to carry out unauthorised alterations to the stove.

9

English RAIS - Manual for RAIS Rina, RAIS Viva , RAIS Juno

There must be plenty of fresh air in the room where the stove is being installed, in order

to ensure proper combustion. Note that any mechanical exhaust ventilation - e.g. an

extraction hood - may reduce the air supply. Any air grates must be placed in such a man-

ner, that the air supply is not blocked.

The ﬂoor structure must be able to carry the weight of the wood burning stove, as well as

the weight of a chimney, if necessary.

When you choose where to set up your RAIS wood burning stove, you should consider

the heat distribution to the other rooms. This will enable you to get the best use out of

your stove.

The stove should be set up at a safe distance from inﬂammable materials.

See the manufacturer’s plate on the wood burning stove

10

English RAIS - Manual for RAIS Rina, RAIS Viva, RAIS Juno

Change of chimney connection

The stove is delivered ready for top outlet, but may be changed to back outlet in the fol-

lowing way:

Strike out the knock out plate at the rear of stove.

Remove the blanking plate and the packing, and

position them in the hovle at the top. Ensure that the

packing is positioned correctly. Screw all elements

together with the three M6 nuts.

Mount the ﬂue collar, which is found in a bag in the

stove, and the clamp for the upper smoke conductor

with three M6x20 cylinder screws and M6 nuts.

Mount the parts in reverse order.

11

English RAIS - Manual for RAIS Rina, RAIS Viva , RAIS Juno

Installation distance in case of combustible wall

To ﬁnd out whether the wall next to where the stove is going to be installed is ﬂammable,

you should contact your building contractor or the local building authorities.

The hearth should be able to accommodate the weight of the stove. The chimney must

be independently supported by wall brackets or a ceiling support plate. The weight of the

stove is indicated in the brochure.

The stove should always be installed on a non-combustible hearth of a size and construc-

tion that is in accordance with the provisions of the current UK Building Regulations Ap-

proved Document J.

If the stove is to be installed on a wooden ﬂoor, it must be covered with a non-combusti-

ble material at least 12 mm thick, in accordance with UK Building Regulations Approved

Document J, to at distance of 300 mm in front of the stove and 150 mm to each side

measuring from the door of the combustion chamber.

The clearance distances to combustible material beneath, surrounding or upon the hearth

and walls adjacent to the hearth should comply with the guidance on the separation of

combustible material given in UK Building Regulations Approved Document J and also in

these stove instructions.

12

English RAIS - Manual for RAIS Rina, RAIS Viva, RAIS Juno

Normal set-up - corner setting

Rais Rina

A. Distance to furniture 700 mm

Distance to ﬂammable materials:

B. - in front (ﬂoor) 300 mm

C. - to the side (ﬂoor) 150 mm

D. - to the rear (wall) 150 mm

E. - to the side of the wall 350 mm











13

English RAIS - Manual for RAIS Rina, RAIS Viva , RAIS Juno

Normal set-up - corner setting

Rais Viva/Rais Juno Rais Viva G/Rais Juno G

A. Distance to furniture 700 mm 650 mm

Distance to ﬂammable materials:

B. - in front (ﬂoor) 300 mm 300 mm

C. - to the side (ﬂoor) 150 mm 150 mm

D. - to the rear (wall) 100 mm 100 mm

E. - to the side of the wall 350 mm 400 mm













14

English RAIS - Manual for RAIS Rina, RAIS Viva, RAIS Juno

Corner setting 45°

Rais Rina

A. Distance to furniture 700 mm

Distance to ﬂammable materials:

B. - in front (ﬂoor) 300 mm

C. - to the side (ﬂoor) 150 mm

D. - to the rear (wall) 150 mm

E. - to the side of the wall 350 mm



 







15

English RAIS - Manual for RAIS Rina, RAIS Viva , RAIS Juno

Corner setting 45°

Rais Viva/Rais Juno Rais Viva G/Rais Juno G

A. Distance to furniture 700 mm 650 mm

Distance to ﬂammable materials:

B. - in front (ﬂoor) 300 mm 300 mm

C. - to the side (ﬂoor) 150 mm 150 mm

D. - to the rear (wall) 100 mm 250 mm

E. - to the side of the wall 350 mm 400 mm













16

English RAIS - Manual for RAIS Rina, RAIS Viva, RAIS Juno





360° swivel base

Rais Viva/Rais Juno Rais Viva G/Rais Juno G

A. Distance to furniture 700 mm 650 mm

Distance to ﬂammable materials:

B. - to the side (ﬂoor) 300 mm 300 mm

17

English RAIS - Manual for RAIS Rina, RAIS Viva , RAIS Juno









Installation distance in case of non-combustible wall

We recommend a minimum distance to non-combustible material of 50 mm (F) for

cleaning considerations.

It should always be possible to access the access door.

La page charge ...

RAIS Rina 90 Manuel utilisateur

Ce manuel convient également à

RAIS Rina 90 Manuel utilisateur

dans d''autres langues

Documents connexes

Autres documents