Mi-T-M Propane Convection Heater Le manuel du propriétaire

Propane Convection Heater Manual 1

Propane

Convection Heater

OPERATOR'S MANUAL

MH-0080-CM10

MH-0200-CM10

CAUTION

RISK OF INJURY! READ ENTIRE MANUAL BEFORE OPERATING!

THIS MANUAL IS AN IMPORTANT PART OF THE PORTABLE HEATER

AND MUST REMAIN WITH THIS UNIT!

®

C US

247218

2 Propane Convection Heater Manual

TABLE OF CONTENTS

INTRODUCTION. .............................................................................................................................3

IMPORTANT SAFETY INSTRUCTIONS...................................................................................................4

WHAT TO DO IF THE SMELL OF GAS IS PRESENT:. ..................................................................... 6

! SAVE THESE INSTRUCTIONS !. ............................................................................................................6

HEATER FEATURES. ................................................................................................................................8

HEATER SPECIFICATIONS. .....................................................................................................................8

GENERAL SAFETY INFORMATION. .......................................................................................................9

IMPORTANT SAFETY INFORMATION. .......................................................................................... 10

PROPANE SUPPLY ......................................................................................................................11

MINIMUM CLEARANCES FROM COMBUSTIBLES:. ...................................................................11

ASSEMBLY. .............................................................................................................................................12

ASSEMBLING THE HEATER. ........................................................................................................12

CONNECTING TO GAS SUPPLY. ..................................................................................................12

THEORY OF OPERATION. ............................................................................................................12

PREPARING FOR OPERATION .....................................................................................................13

LIGHTING INSTRUCTIONS (MH-0080-CM10). .............................................................................13

RELIGHTING INSTRUCTIONS. .....................................................................................................13

SHUT-DOWN INSTRUCTIONS. .....................................................................................................13

LIGHTING INSTRUCTIONS (MH-0200-CM10). .............................................................................13

OPERATION. ...........................................................................................................................................13

RELIGHTING INSTRUCTIONS. .....................................................................................................14

SHUT-DOWN INSTRUCTIONS. .....................................................................................................14

VENTILATION . ..............................................................................................................................14

MAINTENANCE AND STORAGE. ..................................................................................................14

MAINTENANCE. .....................................................................................................................................15

TROUBLESHOOTING. ...........................................................................................................................16

STATEMENT OF WARRANTY. ...............................................................................................................17

WARNING: This product can expose you to

chemicals including Lead, which is known to

the State of California to cause cancer and birth

defects or other reproductive harm. For more

information go to www.P65Warnings.ca.gov

WARNING

NEVER LEAVE HEATER UNATTENDED WHILE BURNING OR WHILE CONNECTED TO A FUEL

SOURCE.

Propane Convection Heater Manual 3

IMPORTANT!

A "DANGER, WARNING or CAUTION" safety warning will be surrounded by a "SAFETY ALERT BOX". This

box is used to designate and emphasize Safety Warnings that must be followed when operating this heater.

Accompanying the safety warnings are "Signal Words" which designate the degree or level of hazard seri-

ousness. The "Signal Words" used in this manual are as follows:

DANGER: INDICATES AN IMMINENTLY HAZARDOUS SITUATION WHICH, IF NOT AVOIDED, WILL

RESULT IN DEATH OR SERIOUS INJURY.

WARNING: INDICATES A POTENTIALLY HAZARDOUS SITUATION WHICH, IF NOT AVOIDED,

COULD RESULT IN DEATH OR SERIOUS INJURY.

CAUTION: INDICATES A POTENTIALLY HAZARDOUS SITUATION WHICH, IF NOT AVOIDED MAY

RESULT IN MINOR OR MODERATE INJURY OR DAMAGE TO THE HEATER.

The symbols set below are "Safety Alert Symbols". These symbols are used to call attention to items or

procedures that could be dangerous to you or other persons using this equipment.

ALWAYS PROVIDE A COPY OF THIS MANUAL TO ANYONE USING THIS EQUIPMENT. READ ALL

INSTRUCTIONS IN THIS MANUAL AND ANY INSTRUCTIONS SUPPLIED BY MANUFACTURERS

OF SUPPORTING EQUIPMENT BEFORE OPERATING THE HEATER AND ESPECIALLY POINT OUT

THE "SAFETY WARNINGS" TO PREVENT THE POSSIBILITY OF PERSONAL INJURY TO THE OP-

ERATOR.

INTRODUCTION

Congratulations on the purchase of your new Mi-T-M® Heater! You can be assured your Mi-T-M® Heater

was constructed with the highest level of precision and accuracy. Each component has been rigorously

tested by technicians to ensure the quality, endurance and performance of this heater.

This operator's manual was compiled for your benet. By reading and following the simple safety, installa-

tion and operation, maintenance and troubleshooting steps described in this manual, you will receive years

of troublefree operation from your new heater. The contents of this manual are based on the latest product

information available at the time of publication. The Manufacturer reserves the right to make changes in

price, color, materials equipment, specications or models at any time without notice.

Once the unit has been uncrated, immediately write in the serial number of your unit in the provided below.

SERIAL NUMBER ________________________________

Inspect for signs of obvious or concealed freight damage. If damage does exist, le a claim with the trans-

portation company immediately. Be sure that all damaged parts are replaced and that the mechanical and

electrical problems are corrected prior to operation of the unit. If you require service, contact Mi-T-M

®

Cus-

tomer Service.

Mi-T-M

®

Corporation, 50 Mi-T-M Drive, Peosta, IA 52068

563-556-7484 / 800-553-9053 / Fax 563-556-1235

Monday - Friday 8:00 a.m. - 5:00 p.m. CST

Please have the following information available for all service calls:

1. Model Number

2. Serial Number

3. Date and Place of Purchase

4 Propane Convection Heater Manual

Hazard Potential Consequence Prevention

RISK OF EXPLOSION OR

FIRE

Serious injury or death may

occur from normal electrical

sparks in motor and pressure

switch

Serious injury may occur if

the heater air inlet or outlet is

blocked.

Serious injury or death may oc-

cur if improper fuels are used, if

heater is running while relling.

Serious injury may occur if

heater is not placed on level

surface.

Serious injury could occur from

touching exposed metal parts.

These areas can remain hot for

some time after the heater is

turned off.

Always operate heater in a well

ventilated area free of ammable

vapors, combustible dust, gases

or other combustible materials.

Never place objects in front of air

inlet (rear) or air outlet (front) of

heater. Never use duct work in

front or at rear of heater. Keep all

combustible material away from

this heater.

Never use fuels such as gasoline,

benzene, paint thinners, or other

oil compounds in this heater. This

heater is EXTREMELY HOT while

in operation.

Never transport heater with fuel

in its tank.

Bulk fuel storage should be a

minimun of 25 ft. from heaters,

torches, portable generators, or

other sources of ignition. All fuel

storage should be in accordance

with federal, state, or local au-

thorities having jurisdiction.

Never move or handle heater

while still hot.

If equipped with a thermostat,

the heater may start at any time.

Always locate heater on a stable

and level surface

Keep away from children and

animals.

Never allow any part of your

body or other materials to make

contact with any exposed metal

parts on the heater.

IMPORTANT SAFETY INSTRUCTIONS

RISK OF BURNS

Propane Convection Heater Manual 5

Hazard Potential Consequence Prevention

IMPORTANT SAFETY INSTRUCTIONS

RISK TO BREATHING Serious injury or death could

occur from failure to provide

proper ventilation according to

this manual..

This is a direct-red heater. It

is primarily intended for use for

temporary heating of buildings

under construction,alteration or

repair. Direct-red means that

all of the combustion products

of the heater enter the heated

space. This appliance does pro-

duce small amounts of carbon

monoxide. Carbon monoxide is

toxic. Humans can tolerate small

amounts of carbon monoxide,

and precautions should be taken

to provide proper ventilation..

Early signs of carbon monox-

ide poisoning resemble the u.

Symptoms of improper ventila-

tion are: * headache * dizziness

* burning of the nose and eyes *

nausea * dry mouth * sore throat

Use this heater only in well ven-

tilated areas! Provide at least a

three square foot (2,800 sq cm)

opening of outside air for every

100,000 BTU/hr of heater rating.

People with breathing problems

should consult a physician before

using the heater.

Carbon Monoxide Poisoning:

Early signs of carbon monox-

ide poisoning resemble u-like

symptoms such as headaches,

dizziness, and/or nausea. If you

have these symptoms, your heat-

er may not be working properly.

Get fresh air at once! Have the

heater serviced. Some people are

more affected by carbon mon-

oxide than others. These include

pregnant women, those with

heart or lung problems,anemia,

or those under the inuence of

alcohol, or at high altitudes.

Never use this heater in living or

sleeping areas.

NEVER LEAVE HEATER UNATTENDED WHILE BURNING OR WHILE CONNECTED TO A FUEL

SOURCE.

6 Propane Convection Heater Manual

IMPORTANT SAFETY INSTRUCTIONS

! SAVE THESE INSTRUCTIONS !

FIRE, BURN, INHALATION, AND EXPLOSION HAZARD. KEEP COMBUSTIBLES, SUCH AS

BUILDING MATERIALS, PAPER OR CARDBOARD, A SAFE DISTANCE AWAY FROM THE

HEATER AS RECOMMENDED BY THESE INSTRUCTIONS. NEVER USE THE HEATER IN

SPACES WHICH CONTAIN PRODUCTS SUCH AS GASOLINE, SOLVENTS, PAINT THINNERS,

DUST PARTICLES, VOLATILE OR AIRBORNE COMBUSTIBLES, OR ANY UNKNOWN

CHEMICALS. THIS IS AN UNVENTED PORTABLE HEATER. IT USES AIR (OXYGEN) FROM THE

AREA IN WHICH IT IS USED. ADEQUATE COMBUSTION AND VENTILATION AIR MUST BE

PROVIDED. REFER TO VENTILATION.

WARNING: IF THE INFORMATION IN THIS MANUAL IS NOT FOLLOWED EXACTLY, A FIRE OR

EXPLOSION MAY RESULT CAUSING PROPERTY DAMAGE, PERSONAL INJURY OR LOSS OF

LIFE.

DO NOT STORE OR USE GASOLINE OR OTHER FLAMMABLE VAPORS AND LIQUIDS IN THE

VICINITY OF THIS OR ANY OTHER APPLIANCE.

AN LP CYLINDER NOT CONNECTED FOR USE SHALL NOT BE STORED IN THE VICINITY OF

THIS OR ANY OTHER APPLIANCE.

WHAT TO DO IF THE SMELL OF GAS IS PRESENT:

DO NOT attempt to light heater

Extinguish any open ame

Shut off gas to heater

If odor continues, contact your local gas supplier or re department.

Do not touch any electric switch, do not use any phone in your building

Immediately call your gas supplier from a neighbors phone. Follow the gas suppliers instructions

If you can not reach your gas supplier, call the re department

Service must be done by a qualied service agency or the gas supplier.

CALIFORNIA RESIDENTS: COMBUSTION BY-PRODUCTS PRODUCED WHEN USING THIS

PRODUCT CONTAIN CARBON MONOXIDE, A CHEMICAL KNOWN TO THE STATE OF

CALIFORNIA TO CAUSE CANCER AND BIRTH DEFECTS (OR OTHER REPRODUCTIVE HARM).

DO NOT OPERATE THIS HEATER UNTIL YOU HAVE READ, AND THOROUGHLY UNDERSTAND

THESE SAFETY AND OPERATING INSTRUCTION. FAILURE TO COMPLY WITH THE

PRECAUTIONS AND INSTRUCTIONS PROVIDED WITH THIS HEATER CAN RESULT IN DEATH,

SERIOUS BODILY INJURY, PROPERTY LOSS OR DAMAGE FROM THE HAZARDS OF FIRE,

EXPLOSION, BURNS, ASPHYXIATION OR CARBON MONOXIDE POISONING. ONLY PERSONS

WHO CAN READ AND UNDERSTAND THESE INSTRUCTIONS SHOULD USE OR SERVICE THIS

HEATER.

NEVER LEAVE HEATER UNATTENDED WHILE BURNING OR WHILE CONNECTED TO A FUEL

SOURCE.

Propane Convection Heater Manual 7

WARNING

THE FOLLOWING PAGES CONTAIN OPERATING AND

MAINTENANCE INSTRUCTIONS.

DO NOT ATTEMPT TO OPERATE THIS HEATER UNTIL YOU

HAVE READ AND UNDERSTOOD ALL SAFETY PRECAUTIONS

AND INSTRUCTIONS LISTED IN THIS MANUAL.

INCORRECT OPERATION OF THIS UNIT CAN CAUSE SERIOUS

INJURY!!

DO NOT ALTER OR MODIFY THIS EQUIPMENT

IN ANY MANNER!

NEVER LEAVE HEATER UNATTENDED WHILE BURNING OR

WHILE CONNECTED TO A FUEL SOURCE.

8 Propane Convection Heater Manual

HEATER FEATURES

Upper Shell

Thermo couple

Spark Plug

Lower Shell

Cap

Safety Valve

Control Valve

Ignitor

Regulator Hose Assembly

Knob

HEATER SPECIFICATIONS

Model MH-0080-CM10 MH-0200-CM10

Rating BTU/Hr 60,000-80,000 70,000-200,000

Fuel Comsumption

Lbs/Hr

2.76 to 3.7 3.25 to 9.25

Supply Pressure 20-200 psi 20-200 psi

Manifold Pressure 10.5" to 8.5" W.C. 5.0" to 4.0" W.C.

Spark Gap .195 0.130

Size (L x W x H) 15.7" x 15.7" x 21.8" 16" x 16" x 26.4"

Net Weight (Lbs) 11.5 14.3

NEVER LEAVE HEATER UNATTENDED WHILE BURNING OR WHILE CONNECTED TO A FUEL

SOURCE.

Propane Convection Heater Manual 9

WARNING: IMPROPER USE OF THIS HEATER CAN RESULT IN SERIOUS INJURY OR DEATH FROM

BURNS, FIRE, EXPLOSION, ELECTRICAL SHOCK AND /OR CARBON MONOXIDE POISONING.

This heater is designed and approved for use as a construction heater in accordance with the standard

for Gas-Fired Construction Heaters ANS Z83.7 * CSA 2.14-2017. CHECK WITH YOUR LOCAL FIRE

SAFETY AUTHORITY IF YOU HAVE ANY QUESTIONS ABOUT APPLICATIONS. Other standards govern

the use of fuel gasses and heating products for specic uses. Your local authority can advise you about

these.

WARNING: NOT FOR USE WITH DUCTWORK.

WARNING: NOT FOR HOME OR RECREATIONAL VEHICLE USE. THE HOSE ASSEMBLY SHALL BE

PROTECTED FROM TRAFFIC, BUILDING MATERIAL AND CONTACT WITH HOT SURFACES

BOTH DURING USE AND WHILE IN STORAGE.

IMPORTANT: Read this User's Manual carefully and completely before attempting to operate or service this

heater. Improper use of the heater can cause serious injury or death from re, explosion and carbon monox-

ide poisoning.

Every possible circumstance that may involve a hazard cannot be anticipated. The warnings in this manual

and attached to the unit are therefore not all-inclusive. If a procedure, work method or operating technique

not specically recommended by the manufacturer is used, you must be sure it is safe for you and others.

You should also insure that equipment will not be damaged or made unsafe by the operating or maintenance

method you choose. CHECK WITH YOUR LOCAL FIRE SAFETY AUTHORITY IF YOU HAVE ANY QUES-

TIONS ABOUT APPLICATIONS. This heater is designed and approved for use as a construction heater under

ANSI Z83.7-2011/CSA 2.14-2011.

Other standards govern the use of fuel gases and heat producing products in specic applications. Your lo-

cal authority can advise you of these.

You must provide the propane gas and cylinder(s). Use this heater only with a propane vapor withdrawal

supply system. Refer to Chapter 5 of the Standard for Storage and Handling of Liqueed Petroleum Gas ,

ANSI/NFPA 58. Your local library or re department will have this booklet.

WARNING: AIR QUALITY HAZARD

• Do not use this heater for heating human living quarters

• Use of direct-red heaters in the construction environment can result in exposure to levels of CO,

CO

2

, and NO

2

considered to be hazardous to health and potentially life threatening

• Do not use in unventilated areas

• Know the signs of CO and CO

2

poisoning • Headaches, stinging eyes • Dizziness, disorientation •

Difculty breathing, feels of being suffocated

• Proper ventilation air exchange (OSHA 29 CFR 1926.57) to support combustions and maintain ac-

ceptable air quality shall be provided in accordance with OSHA 29 CFR Part 1926.154, ANSI A10.10

Safety Requirements for Temporary and Portable Space Heating Devices and Equipment used in the

Construction Industry or the Natural Gas and Propane Installation Codes CSA B149.1

• Periodically monitor levels of CO, CO

2

and NO

2

existing at the construction site – at the minimum at

the start of the shift and after 4 hours.

• Provide ventilation air exchange, either natural or mechanical, as required to maintain acceptable

indoor air quality

• Ensure that the ow of combustion and ventilation air exchanges cannot become obstructed

• As the building “tightens up” during the construction phase ventilation may need to be increased

USA 8-Hr Time weighted average (OSHA 29 CFR 1926.55 App A)

GENERAL SAFETY INFORMATION

NEVER LEAVE HEATER UNATTENDED WHILE BURNING OR WHILE CONNECTED TO A FUEL

SOURCE.

CO 50 ppm

CO

2

5000 ppm

NO

2

10 Propane Convection Heater Manual

NEVER LEAVE HEATER UNATTENDED WHILE BURNING OR WHILE CONNECTED TO A FUEL

SOURCE.

USA – Ceiling Limit (Short Term Exposure Limit = 15 minutes)

Canada 8-hr time weighted average WorkSafe BC OHS Guidelines Part 5.1 and Ontario Work¬places Reg

833

Canada STEL (15 minutes Reg 833/1 hour WSBC) WorkSafe BC OHS Guidelines Part 5.1 and Ontario Work-

places Reg 833

Note: Installation of this appliance at altitudes above 2000 ft (610 m) shall be in accordance with local codes, or in the ab-

sence of local codes, the National Fuel Gas Code, ANSI Z223.1/NFPA 54, or National Standard of Canada, Natural Gas and

Propane Installation Code, CSA B149.1.

IMPORTANT SAFETY INFORMATION

1. Check the heater thoroughly for damage before each use. DO NOT operate a damaged heater.

2. DO NOT modify this heater or operate a heater that has been modied from it’s original state.

3. For outdoor use, and indoor use only in well ventilated areas. For this heater, consult Ventilation on Page

13 of this manual. For additional heaters, provide more ventilation.

4. Provide at least 3 square feet of opening for ventilation per 100,000 BTU of rated operation.

5. NEVER use heater in occupied dwellings.

6. NEVER use heater in a tent.

7. Operate heater in a manner that will not directly expose it to water, rain or dripping water.

8. Keep heater area free from combustible materials such as gasoline, paint thinners and other ammable

vapors and liquids. Dust is combustible. Do not use heater in areas of high dust concentration prior to

each use of the heater. If there is excessive abrasion or wear, or if the hose is cut, replace it with the proper

assembly shown in the parts list, prior to using the heater.

9. Operate only on level and stable surfaces.

10. NEVER leave heater unattended.

11. Keep children and animals away from heater.

12. Never operate heater while unattended or sleeping.

13. Before connecting the heater to the propane cylinder, make sure that the heater regulator knob is in the

OFF position.

14. NEVER handle an operating or hot heater, as severe burns may result. All exposed surfaces may become

very hot during operation. Always allow at least 15 minutes of cooling time before handling the heater.

15. Always disconnect and remove the heater from the cylinder after use.

16. Locate LP cylinder at least 6 feet from the heater and do not discharge the heater towards any LP cylinder

unless it is at least 20 feet from the heater

GENERAL SAFETY INFORMATION

CO

2

NO

2

5 ppm

CO 25 ppm

CO

2

5000 ppm

NO

2

3 ppm (Reg 833)

CO 100 ppm

CO

2

15,000 ppm (WSCB)

30,000 ppm (Reg 833)

NO

2

1.0 ppm (WorkSafeBC)

5.0 ppm (Reg 833)

Propane Convection Heater Manual 11

GENERAL SAFETY INFORMATION

PROPANE SUPPLY

The chart on this page, shows the minimum number of 100 lb. cylinders required in cold weather. Your

local LP dealer will help you select the proper supply system. The amount of LP gas used by this heater

varies. The two factors that will determine this are as follows:

The amount of gas in the tank.

The temperature of the cylinder and surrounding area.

WARNING: EXTREMELY HOT DURING OPERATION. DO NOT TOUCH ANY METAL COMPONENTS

WHILE IN OPERATION. KEEP GASOLINE AND ANY OTHER FLAMMABLE LIQUIDS AWAY

FROM HEATER.

WARNING: BE SURE TO READ AND UNDERSTAND ALL OF THE SAFETY INFORMATION IN THIS

MANUAL BEFORE LIGHTING THIS HEATER.

CAUTION: HEATER HAS HIGH SURFACE TEMPERATURES. BE SURE TO KEEP CHILDREN, PETS

AND CLOTHING AWAY FROM THE HEATER. BE SURE TO KEEP BURNER AND HEATER

REGULATOR CLEAN AND FREE FROM ANY DEBRIS. MAINTAIN SAFE DISTANCES FROM

HEATER AS SHOWN.

You must provide the propane gas and cylinder(s). Use this heater only with a propane vapor withdrawal

supply system. Refer to Chapter 5 of the Standard for Storage and Handling of Liqueed Petroleum Gas,

ANSI/NFPA 58. Your local library or re department will have this booklet.

LP Characteristics - Flammable, explosive under pressure, heavier than air, and pools in low areas.

In its natural state, propane has no odor, but for your safety an odorant that smells like rotten cabbage

has been added.

Contact of LP gas with the skin can cause freeze burns.

Heater is manufactured for use with LP gas only. DO NOT attempt to convert to any other gas. Such

modications are dangerous, and will void warranty.

When heater is not in use, LP supply must be turned OFF.

Be sure that the propane cylinder is located on a level and stable surface.

Do not use this heater in a basement or below ground level. Propane is heavier than air, and will always

seek the lowest level. If you suspect a leak, shut off the valve at the propane cylinder immediately. Do

not use a ame to check for leaks! Use a 50/50 solution of dish soap and water to check for leaks. Re-

pair any leaks before attempting to re-light the heater.

Check the “O” ring on the heater inlet fuel connector for damage before each use. Replace if damaged

or worn.

MINIMUM CLEARANCES FROM COMBUSTIBLES:

MH-0080-CM10 MH-0200-CM10

Top 6 feet 8 feet

Sides 4 feet 4 feet

Average Temp. (°F) MH-0080-CM10 100 lb cylinder MH-200-CM10 100 lb. cylinder

32° 1 2

20° 1 2

10° 2 3

0° 2 3

-10° 2 3

-20° 2 3

NEVER LEAVE HEATER UNATTENDED WHILE BURNING OR WHILE CONNECTED TO A FUEL

SOURCE.

12 Propane Convection Heater Manual

ASSEMBLING THE HEATER

1. Remove heater from carton

2. Slide upper housing straight up and off of lower housing, and remove all

of the packed items from inside heater.

3. Remove all packaging protecting heater during shipping. Retain plastic

caps covering inlet and regulator hose for storage

4. Save carton and packing materials for later storage.

5. Inspect heater closely for any damage that may have occurred during

shipping. If there is any damage, return the heater to the place of purchase.

6. Attach 4 (four) of the phillips head screws to the bottom row of holes in

the lower housing.

7. Slide upper housing over lower housing, lining up the four remaining screw

holes. Insert 4 (four) phillips head screws and tighten securely.

WANRING: NEVER ATTEMPT TO LIGHT A HEATER UNTIL IT

IS FULLY ASSEMBLED.

CONNECTING TO GAS SUPPLY

IMPORTANT! Always use a propane cylinder that has a connection

device that is compatible with the hose and regulator assembly

supplied.

1. To connect hose and regulator assembly, rotate tting on hose/

regulator COUNTERCLOCKWISE into threads on tank valve (see

Figure 5). Be sure to tighten rmly.

Important: Be sure to position the regulator so that the regulator is horizon-

tal, also as shown .

2. To connect to heater inlet, rotate clockwise and tighten rmly

with a wrench.

3. Check all connections for leaks, using a 50/50 solution of dishsoap

and water. Bubbles at the connections show a leak. Correct all

leaks before lighting heater. NEVER USE AN OPEN FLAME TO

CHECK FOR LEAKS.

ASSEMBLY

Phillips screws

Support Sc

rews

in place

Regulator Hose

Assembly

Phillips and Support

Screws, Knob

Lower Shell

Gas Valve Stem

Phillips Screws

(use bottom holes)

Upper Shell

Supply Valve

Regulator

Hose

Propane Tank

Connector

Inlet

Hose

NEVER LEAVE HEATER UNATTENDED WHILE BURNING OR WHILE CONNECTED TO A FUEL

SOURCE.

Propane Convection Heater Manual 13

THEORY OF OPERATION

Fuel Supply System Fuel is supplied under pressure from the fuel cylinder to the heater by the hose/

regulator assembly. The regulator maintains a constant ow of fuel to the heater.

System of Ignition As the fuel is sprayed into the combustion chamber, through a supply nozzle, the

Piezo ignitor ignites the ne mixture of fuel and air.

Automatic Control System If the ame should extinguish, the Automatic Control Valve shuts down the

heater.

WARNING: REVIEW AND UNDERSTAND ALL OF THE WARNINGS IN THE SAFETY INFORMATION

SECTION OF THIS MANUAL.

WARNING: DUE TO VERY HIGH SURFACE TEMPERATURES, IT IS IMPORTANT TO KEEP

CHILDREN, FURNITURE AND CLOTHING AWAY FROM THE HEATER. KEEP CONTROL AND

BURNER AREA FREE FROM DIRT AND DEBRIS.

WARNING: EXTREMELY HOT WHILE IN OPERATION. DO NOT TOUCH HEATER WHILE

OPERATING. KEEP CHILDREN, FURNITURE, CLOTHING, GASOLINE AND OTHER

FLAMMABLE LIQUIDS AND VAPORS AWAY FROM HEATER.

NOTE: Once the gas connection has been made, air may be trapped in the gas line. Before lighting the heater it will be neces-

sary to purge any air trapped in the line. Once this is done the heater will light and operate normally. Purging the gas line

will be necessary every time the gas cylinder is replaced.

PREPARING FOR OPERATION

1. Check the heater for possible shipping damage. If any is found, immediately notify your local dealer.

2. Follow all Safety Information in this manual.

LIGHTING INSTRUCTIONS (MH-0080-CM10)

1. Stop! Read all of the Safety Information provided with this heater

2. Turn valve on propane cylinder counterclockwise until fully open

3. Press in Control Knob and turn counterclockwise to LOW/IGN position

4. If burner does not ignite, turn Control Knob to OFF position and repeat the ignition procedure

5. Keep Control Knob pressed in for approximately 15 seconds before releasing.

6. If the ame goes out, wait 5 minutes, and repeat the ignition and lighting steps

7. After heater ignites, turn Control Knob to desired heat setting.

RELIGHTING INSTRUCTIONS

1. Rotate valve on cylinder clockwise to close it, and wait ve (5) minutes.

2. Relight following the LIGHTING INSTRUCTIONS.

SHUT-DOWN INSTRUCTIONS

1. Turn Control Knob to the OFF position

2. Rotate valve on cylinder clockwise to close it

LIGHTING INSTRUCTIONS (MH-0200-CM10)

WARNING: BEFORE LIGHTING HEATER, TURN MAIN BURNER VALVE TO LIGHT POSITION. READ

SAFETY WARNING: INFORMATION BEFORE STARTING THE HEATER.

1. Fully open the valve on the propane tank, and set burner valve to LIGHT position, then wait 15 seconds

before Step 2.

OPERATION

NEVER LEAVE HEATER UNATTENDED WHILE BURNING OR WHILE CONNECTED TO A FUEL

SOURCE.

14 Propane Convection Heater Manual

2. Depress the red button on the safety shut-off valve, admitting gas to the burner. Then push and release the

ignition button until the burner lights.

3. When the burner lights, continue to keep the red button depressed for 30 seconds, then release.

4. If burner goes out, wait 5 minutes and repeat lighting procedure.

5. When burner lights, open burner valve to ON position, to operate heater. Partially close valve to regulate

heat output.

Note: Adjusting burn rate too low can cause soot. Watch for and avoid a yellow ame.

RELIGHTING INSTRUCTIONS

1. Rotate valve on cylinder clockwise to close it, and wait ve (5) minutes.

2. Relight following the LIGHTING INSTRUCTIONS.

SHUT-DOWN INSTRUCTIONS

1. Turn Control Knob to the OFF position

2. Rotate valve on cylinder clockwise to close it

WARNING: NEVER ATTEMPT TO SERVICE THIS HEATER WHILE

IT IS STILL OPERATING, OR HOT OR CONNECTED TO THE GAS SUPPLY. SEVERE BURNS

CAN RESULT.

VENTILATION

For these heaters, provide a minimum of 2.5 square feet of space for the MH-0080-CM10, or a minimum

of 6 square feet of space for the MH-0200-CM10 by opening a window or door to provide fresh, outside

air. Provide at least 3 square feet of opening for ventilation per 50,000 BTU of rated operation.

OPERATION

NEVER LEAVE HEATER UNATTENDED WHILE BURNING OR WHILE CONNECTED TO A FUEL

SOURCE.

Propane Convection Heater Manual 15

MAINTENANCE

MAINTENANCE AND STORAGE

Inspect your heater before each use. Check all connections for leaks, following the procedure outlined in

this manual. Check the Regulator Hose for any cracks, breaks or wear. If the hose is damaged replace it

with the correct manufacturers part.

After use, always disconnect the heater from the cylinder, and store the heater separately from the tank.

Be sure to close the tank valve after use, and before storage.

Always store the propane cylinder outdoors, but not in an enclosed area. Never store the cylinder near

high heat, direct sunlight or open ames. Never store the cylinder indoors. The cylinder should be stored

outdoors in accordance with chapter 5 of the Standard for Storage and Handling of Liqueed Petroleum

Gasses (ANSI/INFPA 58).

Always keep your heater clean, inside and out.

Have heater inspected anually by a qualied service technician.

Place the plastic covers over the ttings the heater was supplied with when putting heater away for the

season.

Always store the heater in a clean, dry and safe place.

NEVER LEAVE HEATER UNATTENDED WHILE BURNING OR WHILE CONNECTED TO A FUEL

SOURCE.

16 Propane Convection Heater Manual

TROUBLESHOOTING

SYMPTOM

Burner fails to ignite

Heater will not re (ignite)

Heater stops running by itself

PROBABLE CAUSE

1. Valve on supply cylinder closed

2. Cylinder excess ow check

valve closed

3. Burner nozzle blockage

4. Ignition system not sparking

1. Not enough time for thermo-

couple to warm up

2. Gas pressure too low

3. Thermocouple needs replacing,

or loose

4. Control valve damaged

1. Cylinder valve not fully open

2. Clogged burner oriface

3. Gas pressure too low

4. Fuel supply too low

REMEDY

1. Open cylinder valve

2. Cose cylinder valve,wait one

minute, and re-open slowly

3. Replace Burner Nozzle

4. Inspect igniter wires for dam-

age, be sure spark gap is .195”

1. Keep Control Valve depressed

for at least 45 seconds

2. Check cylinders for adequate

gas

3. Replace or tighten themocou-

ple connection

4. Replace Control Valve

1. Be sure cylinder valve is fully

opened

2. Replace burner

3. Be sure regulator is operating

properly

4. Replace low fuel supply with

new, full cylinder

NEVER LEAVE HEATER UNATTENDED WHILE BURNING OR WHILE CONNECTED TO A FUEL

SOURCE.

Propane Convection Heater Manual 17

STATEMENT OF WARRANTY

Mi-T-M warrants this heater to the original retail purchaser only, to be free from defects in material and

workmanship for a period of

one (1) year from the date of initial purchase.

This product must be properly installed, maintained and operated in accordance with the instructions

provided. Mi-T-M requires reasonable proof of your date of purchase from an authorized retailer or dis-

tributor. Therefore, you should keep your sales slip, invoice, or cancelled check from the original pur-

chase.

EXCLUSIONS

1. This Limited Warranty shall be limited to the repair or replacement of parts, which prove defective Mi-

T-M shall determine at its reasonable discretion. This warranty does not include wear items: lters, vanes,

nozzles, and rotors.

2. This Limited Warranty does not cover any failures or operating difculties due to normal wear and tear,

accident, abuse, misuse, alteration, misapplication, improper installation or improper maintenance and

service by you or any third party. Failure to perform normal and routine maintenance on the heater, shipping

damage, damage related to insects, birds, or animals of any kind, and damage due to weather conditions

are also not covered.

3. In addition, the Limited Warranty does not cover damage to the nish, such as scratches, dents,

discoloration, rust or other weather damage, after purchase.

All transportation costs for the return of the damaged product or parts will be the responsibility of the

purchaser. Upon receipt of damaged item, Mi-T-M will examine the item and determine if defective. Mi-

T-M will repair or replace and return the item, freight pre-paid. If Mi-T-M nds the item to be in normal

operating condition, or not defective, the item will be returned freight collect.

This Limited Warranty is in lieu of all other express warranties. Mi-T-M disclaims all warranties for prod-

ucts that are purchased from sellers other than authorized retailers or distributors.

AFTER THE PERIOD OF THE ONE (1) YEAR EXPRESS WARRANTY EXPIRES, Mi-T-M DISCLAIMS ANY

AND ALL IMPLIED WARRANTIES, INCLUDING WITHOUT LIMITATION THE IMPLIED WARRANTIES

OF MERCHANTABILITY AND FITNESS FOR A PARTICULAR APPLICATION. FURTHER, Mi-T-M SHALL

HAVE NO LIABILITY WHATSOEVER TO PURCHASER OR ANY THIRD PARTY FOR ANY SPECIAL, INDI-

RECT, PUNITIVE, INCIDENTAL, OR CONSEQUENTIAL DAMAGES.

Mi-T-M assumes no responsibility for any defects caused by third parties. This Limited Warranty gives

the purchaser specic legal rights; a purchaser may have other rights depending upon where he or she

lives. Some states do not allow the exclusion or limitation of special, incidental or consequential damag-

es, or limitations on how long a warranty lasts, so the above exclusion and limitations may not apply to

you. Mi-T-M does not authorize any person or company to assume for it any other obligation or liability in

connection with the sale, installation, use, removal, return, or replacement of its equipment, and no such

representations are binding on Mi-T-M. Always be sure to specify model number and serial number when

making any claim with Mi-T-M.

For Service or Warranty Consideration, contact

Mi-T-M® Corporation, 50 Mi-T-M Drive, Peosta, IA 52068

563-556-7484 / 800-553-9053 / Fax 563-556-1235

Monday - Friday 8:00 a.m. - 5:00 p.m. CST

18 Propane Convection Heater Manual

TABLE OF CONTENTS

IMPORTANT!. ..........................................................................................................................................19

IMPORTANTES CONSIGNES DE SECURITE. ...................................................................................20

!GARDER CES INSTRUCTIONS!. ..........................................................................................................22

IDENTIFICATION DU PRODUIT. ............................................................................................................24

SPÉCIFICATIONS. ..................................................................................................................................24

CONSIGNES GÉNÉRALES DE SÉCURITÉ ...........................................................................................25

IMPORTANTES CONSIGNES DE SECURITE. ............................................................................26

ALIMENTATION EN GAZ PROPANE. .......................................................................................... 27

DISTANCE MINIMUM DES COMBUSTIBLES. ..............................................................................27

ASSEMBLAGE. .......................................................................................................................................28

ASSEMBLAGE DU RADIATEUR. ................................................................................................... 28

RACCORDEMENT À UNE ALIMENTATION EN GAZ. ....................................................................29

PRÉPARATION À L’UTILISATION. .................................................................................................29

FONCTIONNEMENT. ..............................................................................................................................29

INSTRUCTIONS POUR L’ALLUMAGE - (MH-0080-CM10). ..........................................................30

INSTRUCTIONS POUR LE RALLUMAGE. ....................................................................................30

INSTRUCTIONS D’ARRÊT. ............................................................................................................30

INSTRUCTIONS POUR L’ALLUMAGE (MH-0200-CM10) .............................................................30

PRÉPARATION À L’UTILISATION. .................................................................................................30

INSTRUCTIONS POUR LE RALLUMAGE. ....................................................................................30

INSTRUCTIONS D’ARRÊT. ............................................................................................................30

VENTILATION. ...............................................................................................................................31

ENTRETIEN ET ENTREPOSAGE. .................................................................................................. 31

ENTRETIEN. ............................................................................................................................................31

DÉPANNAGE. .........................................................................................................................................32

AVERTISSEMENT: Ce produit peut vous

exposer à des produits chimiques, tel que le

plomb, qui est reconnu par l’état de la Californie

comme étant une cause de cancer, d'anomalies

congénitales et d'autres problèmes liés à la

reproduction. Pour plus de renseignements,

aller à www.P65Warnings.ca.gov

AVERTISSEMENT

Propane Convection Heater Manual 19

IMPORTANT!

Les avertissements de sécurité "DANGER, AVERTISSEMENTou ATTENTION" seront entourés par un

"ENCADRE ALERTE SECURITE". Cet encadré est utilisé pour indiquer et souligner les avertissements de

sécurité qui doivent être suivis en actionnant ce compresseur d'air. En plus des avertissements de sécurité,

des "mots d'alerte" sont utilisés pour indiquer le degré ou niveau de risque. Les "mots d'alerte" utilisés dans ce

manuel sont comme suit:

DANGER: INDIQUE UNE SITUATION AU DANGER IMMINENT QUI, SI ELLE N'EST PAS ÉVITÉE,

ENTRAINERA LA MORT OU DES BLESSURES GRAVES.

AVERTISSEMENT: INDIQUE UNE SITUATION POTENTIELLEMENT DANGEREUSE QUI, SI ELLE

N'EST PAS ÉVITÉE, POURRAIT ENTRAÎNER LA MORT OU DES BLESSURES GRAVES.

ATTENTION: INDIQUE UNE SITUATION POTENTIELLEMENT DANGEREUSE, QUI, SI ELLE N'EST

PAS ÉVITÉE, PEUT ENTRAÎNER DES BLESSURES MINEURES OU PEU GRAVES ET DES

DÉGATS AU COMPRESSEUR.

Les symboles placés à gauche de ce paragraphe sont des "symboles d'alerte de sécurité". Ces symboles

sont utilisés pour souligner les points ou les procédures qui pourraient être dangeureuses pour vous ou tout

autre personne utilisant cet équipement.

Fournissez toujours une copie de ce manuel à toute personne utilisant cet équipement. Lisez toutes les

instructions dans ce manuel et toutes instructions fournies par les fabricants d'équipement de support avant

d'utiliser ce compresseur d'air et attirer spécialement l'attention aux "Avertissements de Sécurité" pour

éviter la possibilité de blessures pour l'utilisateur.

INTRODUCTION

Félicitations de l'achat de votre nouveau le radiateur! Vous pouvez être assuré que votre nouveau le radia-

teur a été construit avec le plus haut niveau de précision et de abilité. Chaque composant a été rigou-

reusement testé par des techniciens pour assurer la qualité, la durabilité et la performance de le radiateur.

Ce manuel opérateur a été dressé pour que vous en retiriez le meilleur parti. Par la lecture et l'application

des mesures simples de sécurité, d'installation et d'opération, d'entretien et de dépannage décrites dans ce

manuel, votre nouveau le radiateur fonctionnera sans faille pendant de nombreuses années. Le contenu de

ce manuel est basé sur la dernière information disponible du produit au moment de la publication. Mi-T-M

®

se réserve le droit d'effectuer des changements de prix, de couleur, de matériaux, d'équipement, de caracté-

ristiques ou de modèles à tout moment sans communication préalable.

Une fois l'appareil déballé, écrivez immédiatement le numéro de série de votre appareil dans l'espace çi-

dessous.

NUMERO DE SERIE_________________________________

Assurez-vous qu'il n'y a pas de signes de dommages évidents ou cachés suite au transport. En cas de dommage,

remplissez immédiatement une réclamation avec la compagnie de transport. Assurez-vous que toutes les

pièces endommagées sont remplacees et les problémes mécaniques et électriques corrigés avant l'utilisation

de l'appareil. Si vous avez besoin d'assistance, entrez en contact avec votre service clientèle.

Mi-T-M

®

Corporation, 50 Mi-T-M Drive, Peosta, IA 52068

563-556-7484 / 800-553-9053 / Fax 563-556-1235

du lundi au vendredi de 8h00 à 17h, CST (heure centrale)

Veuillez avoir les informations suivantes disponibles pour toute intervention:

1. Numéro de modèle

2. Numéro de série

3. Date et lieu d'achat

20 Propane Convection Heater Manual

Hazard Potential Consequence Prevention

RISQUE D'EXPLOSION OU

D'INCENDIE

Des étincelles électriques dans

le moteur et l’interrupteur de

pression peuvent être la cause

de blessures graves ou la mort

Des blessures graves peuvent

survenir si la prise ou la sortie

d’air du chauffage est obstruée

Des blessures graves, voire la

mort, peuvent survenir si le bon

carburant n’est pas utilisé ou si

le chauffage fonctionne durant

le ravitaillement.

Des blessures graves peuvent

survenir si le chauffage n’est

pas placé sur une surface

plane et s’il n’est pas maintenu

à l’écart des enfants et des

animaux.

Le fait de toucher les surfaces

de métal exposées peut causer

de graves blessure. Ces sur-

faces peuvent rester chaudes

pendant un certain temps après

l'arrêt du chauffage.

N’utiliser ce chauffage que dans

un endroit bien ventilé libre de

vapeurs inammables, de pous-

sière combustible ou de toute

autre matière combustible.

Ne jamais placer d’objets devant

la prise d’air (à l’arrière) ou la sor-

tie d’air(à l’avant). N’utiliser ja-

mais de système de canalisation

d’air à l’avant ou à l’arrière du

chauffage. Eloigner du chauffage

toutes les matières combustibles.

Ne jamais utiliser de carburants

tels que l’essence, le benzène,

les diluants de peinture ou

autres composés d’huile dans

ce chauffage. Ce chauffage est

extrêmement CHAUD lors de son

fonctionnement.

Ne jamais transporter le

chauffage avec du carburant

dans son réservoir.

L’entreposage de carburant en

gros doit être maintenu à une

distance d’un minimum de 25

pieds (7m60) des chauffages,

torches, groupes électrogènes

portables ou toutes autres

sources d’inammation. Tout

entreposage de carburant doit

être conforme aux réglementa-

tions des autorités locales, d’état

ou fédérale ayant juridiction.

Ne jamais déplacer ou manipuler

le chauffage lorsqu’il est encore

chaud.

Le chauffage peut démarrer à

tout moment s’il est équipé d’un

thermostat.

Toujours placer le chauffage sur

une surface stable et plane à

l’écart des enfants et des ani-

maux.

Ne jamais laisser aucune partie

de votre corps ou autres maté-

riaux entrer en contact avec les

surfaces de métal exposées de

votre chauffage.

IMPORTANTES CONSIGNES DE SECURITE

RISQUE DE BRULURES

La page est en cours de chargement...

Mi-T-M Propane Convection Heater Le manuel du propriétaire

Ce manuel convient également à

Mi-T-M Propane Convection Heater Le manuel du propriétaire

dans d''autres langues

Documents connexes

Autres documents