Weber Summit Grill Center LP SS Literature Kit

YOU MUST READ THIS OWNER’S GUIDE

BEFORE OPERATING YOUR GAS GRILL.

m DANGER

If you smell gas:

1. Shut off gas to the appliance.

2. Extinguish any open flames.

3. Open lid.

4. If odor continues, keep away from the

appliance and immediately call your gas

supplier or your fire department.

Leaking gas may cause a fire or explosion

which can cause serious bodily injury,

death, or damage to property.

m WARNING:

1. Do not store or use gasoline or other

flammable liquids or vapors in the

vicinity of this or any other appliance.

2. An LP cylinder not connected for use

shall not be stored in the vicinity of this

or any other appliance.

m WARNING: Follow all leak-check

procedures carefully in this manual prior

to barbecue operation. Do this even if the

barbecue was dealer-assembled.

NOTICE TO INSTALLER: These instructions

must be left with the owner and the owner

should keep them for future use.

THIS GAS APPLIANCE IS DESIGNED FOR

OUTDOOR USE ONLY.

56567 09/01/11 LP

US - ENGLISH

#56567

m WARNING: Do not ignite this appliance

without first reading the BURNER

IGNITION sections of this manual.

SUMMIT

®

GRILL CENTER

Guía del Propietario de la Barbacoa de Gas Propano Licuado - Pg. 47

Mode d’emploi du Grill à gaz PL - Pg. 85

GAS GRILL

LP Gas Grill Owner’s Guide

ESNA

2

m DANGER

Failure to follow the Dangers, Warnings and Cautions contained in this Owner’s Manual may result in serious bodily injury or

death, or in a fire or an explosion causing damage to property.

m WARNINGS

m Do not store a spare or disconnected liquid propane

cylinder under or near this barbecue.

m Improper assembly may be dangerous. Please follow the

assembly instructions carefully.

m After a period of storage, and/or nonuse, the Weber

®

gas

barbecue should be checked for gas leaks and burner

obstructions before use. See instructions in this manual for

correct procedures.

m Do not operate the Weber

®

gas barbecue if there is a gas

leak present.

m Do not use a flame to check for gas leaks.

m Combustible materials should never be within 24 inches

(61 cm) of the back or sides of your Weber

®

gas barbecue.

m Do not put a barbecue cover or anything flammable on, or in

the storage area under the barbecue.

m Your Weber

®

gas barbecue should never be used by

children. Accessible parts of the barbecue may be very hot.

Keep young children away while it is in use.

m You should exercise reasonable care when operating your

Weber

®

gas barbecue. It will be hot during cooking or

cleaning and should never be left unattended, or moved

while in operation.

m Should the burners go out while in operation, turn all

gas valves off. Open the lid and wait five minutes before

attempting to relight, using the igniting instructions.

m Do not use charcoal or lava rock in your Weber

®

gas

barbecue.

m Never lean over open grill or place hands or fingers on the

front edge of the cookbox.

m Should a grease fire occur, turn off all burners and leave lid

closed until fire is out.

m Do not enlarge valve orifices or burner ports when cleaning

the valves or burners.

m The Weber

®

gas barbecue should be thoroughly cleaned on

a regular basis.

m Liquid propane gas is not natural gas. The conversion or

attempted use of natural gas in a liquid propane unit or

liquid propane gas in a natural gas unit is dangerous and

will void your warranty.

m Do not attempt to disconnect any gas fitting while your

barbecue is in operation.

m Use heat-resistant barbecue mitts or gloves when operating

barbecue.

m Keep any electrical supply cord and the fuel supply hose

away from any heated surfaces.

m Combustion byproducts produced when using this product

contain chemicals known to the state of California to cause

cancer, birth defects, or other reproductive harm.

m Do not use this barbecue unless all parts are in place. The

unit must be properly assembled according to the assembly

instructions.

m Do not build this model of grill in any built-in or slide-in

construction. Ignoring this Warning could cause a fire or

an explosion that can damage property and cause serious

bodily injury or death.

m Proposition 65 Warning: Handling the brass material on

this product exposes you to lead, a chemical known to the

state of California to cause cancer, birth defects or other

reproductive harm.

(Wash hands after handling this product.)

◆

LIQUID PROPANE GAS UNITS ONLY:

m Use the pressure regulator and hose assembly that is

supplied with your Weber

®

gas barbecue.

m Do not attempt to disconnect the gas regulator and hose

assembly or any gas fitting while your barbecue is in

operation.

m A dented or rusty liquid propane cylinder may be hazardous

and should be checked by your liquid propane supplier. Do

not use a liquid propane cylinder with a damaged valve.

m Although your liquid propane cylinder may appear to be

empty, gas may still be present, and the cylinder should be

transported and stored accordingly.

m If you see, smell or hear the hiss of escaping gas from the

liquid propane cylinder:

1. Move away from liquid propane cylinder.

2. Do not attempt to correct the problem yourself.

3. Call your fire department.

◆

WARNINGS

WWW.WEBER.COM

®

3

TABLE OF CONTENTS

WARNINGS ..........................................2

TABLE OF CONTENTS .................................3

EXPLODED VIEW .....................................4

WARRANTY ........................................14

GENERAL INSTRUCTIONS ............................14

FOR INSTALLATION IN CANADA ....................................14

OPERATING. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14

STORAGE AND/OR NONUSE ....................................... 14

GAS INSTRUCTIONS .................................15

SAFE HANDLING TIPS FOR LIQUID PROPANE GAS CYLINDERS .........15

IMPORTANT LP CYLINDER INFORMATION ...........................16

LEAK CHECK PREPARATION .......................................16

CHECK FOR GAS LEAKS ..........................................19

REFILLING THE LIQUID PROPANE CYLINDER .........................21

LIGHT FEATURES ...................................21

WEBER

®

GRILL OUT™ HANDLE LIGHT ..............................21

LIGHTED CONTROL KNOBS .......................................21

BEFORE USING THE GRILL ...........................22

FUEL LEVEL ....................................................22

SLIDE-OUT GREASE TRAY AND DISPOSABLE DRIP PAN ...............22

HOSE INSPECTION ..............................................22

SNAP IGNITION OPERATION ..........................23

MAIN BURNER IGNITION & USAGE .....................24

MAIN BURNER IGNITION ..........................................24

TO EXTINGUISH .................................................24

MAIN BURNER MANUAL IGNITION .................................25

TO EXTINGUISH .................................................25

GRILLING TIPS & HELPFUL HINTS .....................26

PREHEATING ...................................................26

COVERED COOKING .............................................26

DRIPPINGS AND GREASE ........................................26

FLAVORIZER

®

SYSTEM ...........................................26

SEAR STATION

®

.................................................26

COOKING METHODS .................................27

DIRECT COOKING ............................................... 27

INDIRECT COOKING .............................................27

SIDE BURNER IGNITION & USAGE .....................28

SIDE BURNER IGNITION ..........................................28

TO EXTINGUISH .................................................28

SIDE BURNER MANUAL IGNITION ..................................29

TO EXTINGUISH .................................................29

SIDE BURNER USAGE ............................................30

SEAR STATION

®

IGNITION & USAGE ....................31

SEAR STATION

®

BURNER IGNITION .................................31

TO EXTINGUISH .................................................31

SEAR STATION

®

BURNER MANUAL IGNITION ........................32

TO EXTINGUISH .................................................32

USING THE SEAR STATION

®

.......................................32

SMOKER BURNER IGNITION & USAGE ..................33

SMOKER BURNER IGNITION ....................................... 33

TO EXTINGUISH .................................................33

SMOKER BURNER MANUAL IGNITION ............................... 34

TO EXTINGUISH .................................................34

USING THE SMOKER .............................................35

CLEANING THE SMOKER .........................................35

ROTISSERIE BURNER IGNITION & USAGE ...............36

ROTISSERIE BURNER IGNITION .................................... 36

TO EXTINGUISH .................................................36

ROTISSERIE BURNER MANUAL IGNITION ............................ 37

TO EXTINGUISH .................................................37

IMPORTANT SAFEGUARDS ........................................38

OPERATING THE ROTISSERIE .....................................38

ROTISSERIE COOKING ...........................................39

ROTISSERIE MOTOR STORAGE ....................................39

ROTISSERIE SPIT STORAGE. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 39

TROUBLESHOOTING .................................40

SIDE BURNER TROUBLESHOOTING ....................40

SEAR STATION

®

TROUBLESHOOTING ...................41

ROTISSERIE TROUBLESHOOTING ......................41

GRILL OUT™ HANDLE LIGHT TROUBLESHOOTING .......41

MAINTENANCE .....................................42

CLEANING ...................................................... 42

WEBER

®

SPIDER/INSECT SCREENS ................................42

BURNER TUBE CLEANING ........................................42

REPLACING MAIN BURNERS ......................................43

SIDE BURNER MAINTENANCE .....................................45

ANNUAL MAINTENANCE ..........................................46

4

7

9

10

25

26

27

28

29

36

38

39

40

41

42

43

50

21

22

23

24

44

49

55

30

31

32

33

34

35

51

54

56

20

45

46

47

48

2

3

4

5

6

1

8

37

52

53

11

13

14

15

16

17

18

19

12

SUMMIT_6Brn_Grill Center_LP_US_021511

EXPLODED VIEW • DIAGRAMA DE DESPIECE • VUE ECLATEE

WWW.WEBER.COM

®

5

EXPLODED VIEW • DIAGRAMA DE DESPIECE • VUE ECLATEE

1. Shroud Hardware

2. Shroud

3. Thermometer

4. Thermometer Bezel

5. Handle

6. Grill Out™ Handle Light

7. Warming Rack

8. Cooking Grate

9. Flavorizer

®

Bar

10. Burner Tube

11. Manifold

12. Control Panel Wiring Harness

13. Control Panel

14. Small Knob Bezel

15. Small Knob

16. Large Knob

1 7. Large Knob Bezel

18. Sear Station

®

Knob

19. Battery Housing

20. Water Baffle / Heat Shield

21. Disposable Drip Pan

22. Slide-Out Grease Tray

23. Catch Pan

24. Catch Pan Holder

25. Left Door

26. Door Handle

2 7. Right Door

28. Left Frame Panel

29. Bottom Panel

30. IR Burner Cover

31. Infrared Burner

32. IR Burner Box

33. IR Burner Igniter Wire

34. Thermocouple

35. IR Burner Hose

36. Rotisserie Spit Assembly

3 7. Cooking Grate

38. Smoker Box

39. Smoker Bar

40. Smoker Burner Tube

41. Sear Station

®

Burner

42. Cookbox

43. Bulkhead

44. Manifold Hose

45. Hose / Regulator

46. Side Burner Hose

4 7. Frame Support

48. Rotisserie Spit Storage Bracket

49. Back Panel

50. Right Frame Panel

51. Tank Scale

52. LED Tank Scale Assembly

53. Shelf Bracket

54. Tank Glide

55. Matchstick Holder

56. Adjustable Leg

Accesorios de la cubierta

Cubierta

Termómetro

Moldura decorativa del termómetro

Asa

Lámpara de asa GrillOut™

Rejilla para calentar

Parrilla de cocción

Barra Flavorizer

®

Tubo del quemador

Múltiple

Cableado prefabricado

del panel de control

Tablero de control

Moldura decorativa de la perilla pequeña

Perilla pequeña

Perilla grande

Moldura decorativa de la perilla grande

Perilla de la estación

de dorado Sear Station

®

Compartimiento de las baterías

Reflector de agua / Pantalla térmica

Bandeja de goteo desechable

Bandeja deslizante de grasa

Plato recolector

Soporte del plato recolector

Puerta izquierda

Asa de la puerta

Puerta derecha

Panel izquierdo del bastidor

Panel inferior

Tapa del quemador infrarrojo

Quemador infrarrojo

Caja del quemador infrarrojo

Cable de encendido

del quemador infrarrojo

Termopar

Manguera del quemador infrarrojo

Ensamble del espetón del asador giratorio

Parrilla de cocción

Caja del ahumador

Barra del ahumador

Tubo quemador del ahumador

Quemador de la estación

de dorado Sear Station

®

Caja de cocción

Tabique divisorio

Manguera del múltiple

Manguera / Regulador

Manguera del quemador lateral

Soporte del bastidor

Soporte de almacenaje

del espetón del asador giratorio

Panel posterior

Panel derecho del bastidor

Báscula del tanque

Ensamble de la báscula LED del tanque

Soporte del estante

Deslizadera del tanque

Portacerillos

Pata ajustable

Quincaillerie de l’étui

Etui

Thermomètre

Bec du thermomètre

Poignée

Eclairage de poignée Grill Out™

Grille de maintien au chaud

Grille de cuisson

Barre Flavorizer

®

Tube du brûleur

Collecteur

Harnais de câblage du

panneau de commandes

Panneau de commandes

Bec du petit bouton

Petit bouton

Grand bouton

Bec du grand bouton

Bouton Sear Station

®

Logement des piles

Baffle à eau / Protection anti-chaleur

Egouttoir jetable

Plateau amovible pour la

récupération des graisses

Egouttoir

Support pour égouttoir

Porte de gauche

Poignée de porte

Porte de droite

Panneau du cadre de gauche

Panneau inférieur

Cache du brûleur IR

Brûleur infrarouge

Boîtier du brûleur IR

Câble de l’allumeur du brûleur IR

Thermocouple

Tuyau du brûleur IR

Assemblage de la broche de la rôtissoire

Grille de cuisson

Boîtier du fumoir

Barre du fumoir

Tube du brûleur du fumoir

Brûleur de la Sear Station

®

Boîtier de cuisson

Tête du brûleur

Tuyau du collecteur

Tuyau / Régulateur

Tuyau du brûleur latéral

Support du cadre

Support du rangement de la

broche de la rôtissoire

Panneau arrière

Panneau du cadre de droite

Graduation de la bouteille

Assemblage LED de la

graduation de la bouteille

Support pour étagère

Glissière de la bouteille

Support pour allumette

Pied ajustable

6

11

12

13

14

15

5

6

7

8

9

2

3

4

1

10

SUMMIT_Grill Center Left Cabinet_121610

1. Rotisserie Motor

2. Rotisserie Bracket

3. Table

4. Shelf Bracket

5. Left Frame

6. Left End Skirt

7. Adjustable Leg

8. Paper Towel Holder

9. Door

10. Door Handle

11. Back Panel

12. Wire Shelf

13. Shelf Frame

14. Water Deflector

15. Bottom Panel

Motor del asador

Soporte del asador giratorio

Mesa

Soporte del estante

Bastidor izquierdo

Faldón del extremo izquierdo

Pata ajustable

Portatoallas de papel

Puerta

Asa de la puerta

Panel posterior

Estante de alambre

Bastidor del estante

Deflector de agua

Panel inferior

Moteur de la rôtissoire

Support de la rôtissoire

Tablette

Support pour étagère

Cadre de gauche

Jupe d’extrémité gauche

Pied ajustable

Support pour serviette en papier

Porte

Poignée de porte

Panneau arrière

Etagère métallique

Cadre de l’étagère

Déflecteur à eau

Panneau inférieur

EXPLODED VIEW • DIAGRAMA DE DESPIECE • VUE ECLATEE

WWW.WEBER.COM

®

7

EXPLODED VIEW • DIAGRAMA DE DESPIECE • VUE ECLATEE

1. Rotisserie Motor

2. Rotisserie Bracket

3. Table

4. Shelf Bracket

5. Left Frame

6. Adjustable Leg

7. Paper Towel Holder

8. Door

9. Door Handle

10. Back Panel

11. Wire Shelf

12. Shelf Frame

13. Water Deflector

14. Bottom Panel

10

11

12

13

14

5

6

7

8

2

3

4

1

9

SUMMIT_Grill Center Left Cabinet_LHR_051911

Motor del asador

Soporte del asador giratorio

Mesa

Soporte del estante

Bastidor izquierdo

Pata ajustable

Portatoallas de papel

Puerta

Asa de la puerta

Panel posterior

Estante de alambre

Bastidor del estante

Deflector de agua

Panel inferior

Moteur de la rôtissoire

Support de la rôtissoire

Tablette

Support pour étagère

Cadre de gauche

Pied ajustable

Support pour serviette en papier

Porte

Poignée de porte

Panneau arrière

Etagère métallique

Cadre de l’étagère

Déflecteur à eau

Panneau inférieur

8

EXPLODED VIEW • DIAGRAMA DE DESPIECE • VUE ECLATEE

14

15

18

20

17

16

19

6

7

8

9

10

3

2

4

5

1

13

12

11

SUMMIT_Grill Center SB Cabinet_122110

1. Side Burner Lid

2. Wok Ring

3. Side Burner Grate

4. Side Burner Inner Ring 1

5. Side Burner Outer Ring 2

6. Side Burner Head

7. Side Burner

8. Wire Shelf

9. Control Knob

10. Igniter

11. Shelf Frame

12. Door

13. Door Handle

14. Back Panel

15. Shelf Bracket

16. Water Deflector

1 7. Right Frame

18. Right Frame Skirt

19. Adjustable Leg

20. Bottom Panel

Tapa del quemador lateral

Aro para wok

Rejilla del quemador lateral

Aro interno 1 del quemador lateral

Aro interno 2 del quemador lateral

Cabezal del quemador lateral

Quemador lateral

Estante de alambre

Perilla de control

Encendedor

Bastidor del estante

Puerta

Asa de la puerta

Panel posterior

Soporte del estante

Deflector de agua

Bastidor derecho

Faldón del bastidor derecho

Pata ajustable

Panel inferior

Couvercle du brûleur latéral

Bague pour wok

Grille du brûleur latéral

Bague interne du brûleur latéral 1

Bague externe du brûleur latéral 2

Tête du brûleur latéral

Brûleur latéral

Etagère métallique

Bouton de commande

Allumeur

Cadre de l’étagère

Porte

Poignée de porte

Panneau arrière

Support pour étagère

Déflecteur à eau

Cadre de droite

Jupe du cadre de droite

Pied ajustable

Panneau inférieur

WWW.WEBER.COM

®

9

EXPLODED VIEW • DIAGRAMA DE DESPIECE • VUE ECLATEE

14

15

16

17

19

18

6

7

8

9

10

3

2

4

5

1

13

12

11

SUMMIT_Grill Center_Social_SB Cabinet_122110

1. Side Burner Lid

2. Wok Ring

3. Side Burner Grate

4. Side Burner Inner Ring 1

5. Side Burner Outer Ring 2

6. Side Burner Head

7. Side Burner

8. Side Burner Shelf

9. Control Knob

10. Igniter

11. Shelf Frame

12. Door

13. Door Handle

14. Back Panel

15. Shelf Bracket

16. Water Deflector

1 7. Right Frame

18. Adjustable Leg

19. Bottom Panel

Tapa del quemador lateral

Aro para wok

Rejilla del quemador lateral

Aro interno 1 del quemador lateral

Aro interno 2 del quemador lateral

Cabezal del quemador lateral

Quemador lateral

Estante del quemador lateral

Perilla de control

Encendedor

Bastidor del estante

Puerta

Asa de la puerta

Panel posterior

Soporte del estante

Deflector de agua

Bastidor derecho

Pata ajustable

Panel inferior

Couvercle du brûleur latéral

Bague pour wok

Grille du brûleur latéral

Bague interne du brûleur latéral 1

Bague externe du brûleur latéral 2

Tête du brûleur latéral

Brûleur latéral

Etagère du brûleur latéral

Bouton de commande

Allumeur

Cadre de l’étagère

Porte

Poignée de la porte

Panneau arrière

Support pour étagère

Déflecteur à eau

Cadre de droite

Pied ajustable

Panneau inférieur

10

EXPLODED VIEW • DIAGRAMA DE DESPIECE • VUE ECLATEE

7

8

9

10

11

3

4

2

1

6

SUMMIT_Grill Center Middle Cabinet_12161

0

5

1. Cooler Lid

2. Cooler

3. Corner Cabinet Top Panel

4. Left Back Panel

5. Door Assembly

6. Front Panel

7. Door Hinge Rod

8. Door

9. Right Back Panel

10. Trash Can

11. Bottom Panel

Tapa del enfriador

Enfriador

Panel superior del gabinete de esquina

Panel izquierdo posterior

Ensamble de la puerta

Panel frontal

Varilla de la bisagra de la puerta

Puerta

Panel derecho posterior

Bote de basura

Panel inferior

Couvercle du refroidisseur

Refroidisseur

Panneau supérieur du meuble de coin

Panneau arrière gauche

Assemblage de la porte

Panneau avant

Tige du gond de la porte

Porte

Panneau arrière droit

Corbeille

Panneau inférieur

WWW.WEBER.COM

®

11

EXPLODED VIEW • DIAGRAMA DE DESPIECE • VUE ECLATEE

7

8

9

10

11

3

4

2

1

6

SUMMIT_Grill Center Middle Cabinet2_12161

0

5

1. Cooler Lid

2. Cooler

3. Corner Cabinet Top Panel

4. Right Back Panel

5. Door Assembly

6. Front Panel

7. Door Hinge Rod

8. Door

9. Left Back Panel

10. Trash Can

11. Bottom Panel

Tapa del enfriador

Enfriador

Panel superior del gabinete de esquina

Panel derecho posterior

Ensamble de la puerta

Panel frontal

Varilla de la bisagra de la puerta

Puerta

Panel izquierdo posterior

Bote de basura

Panel inferior

Couvercle du refroidisseur

Refroidisseur

Panneau supérieur du meuble de coin

Panneau arrière droit

Assemblage de la porte

Panneau avant

Tige du gond de la porte

Porte

Panneau arrière gauche

Corbeille

Panneau inférieur

12

EXPLODED VIEW • DIAGRAMA DE DESPIECE • VUE ECLATEE

SUMMIT_Grill Center Social Center_121610

10

11

12

13

14

15

2

3

5

6

7

1

8

4

9

1. Condiment Holder

2. Table

3. Shelf Bracket

4. Left Frame

5. Adjustable Leg

6. Shelf Frame

7. Shelf

8. Left Door

9. Left Door Handle

10. Back Panel

11. Right Frame

12. Right Frame Skirt

13. Right Door

14. Bottom Panel

15. Right Door Handle

Portacondimentos

Mesa

Soporte del estante

Bastidor derecho

Pata ajustable

Bastidor del estante

Estante

Puerta izquierda

Asa de la puerta izquierda

Panel posterior

Bastidor derecho

Faldón del bastidor derecho

Puerta derecha

Panel inferior

Asa de la puerta derecha

Support pour condiments

Tablette

Support pour étagère

Cadre de gauche

Pied ajustable

Cadre de l’étagère

Etagère

Porte de gauche

Poignée de la porte de gauche

Panneau arrière

Cadre de droite

Jupe du cadre de droite

Porte de droite

Panneau inférieur

Poignée de porte de droite

WWW.WEBER.COM

®

13

EXPLODED VIEW • DIAGRAMA DE DESPIECE • VUE ECLATEE

SUMMIT_Grill Center Social Center_LHR_051811

10

11

12

13

14

15

2

3

5

6

7

1

8

4

9

1. Condiment Holder

2. Table

3. Shelf Bracket

4. Right Frame

5. Adjustable Leg

6. Shelf Frame

7. Shelf

8. Right Door

9. Right Door Handle

10. Back Panel

11. Left Frame

12. Left End Skirt

13. Left Door

14. Bottom Panel

15. Left Door Handle

Portacondimentos

Mesa

Soporte del estante

Bastidor derecho

Pata ajustable

Bastidor del estante

Estante

Puerta derecha

Asa de la puerta derecha

Panel posterior

Bastidor derecho

Faldón del extremo izquierdo

Puerta izquierda

Panel inferior

Asa de la puerta izquierda

Support pour condiments

Tablette

Support pour étagère

Cadre de droite

Pied ajustable

Cadre de l’étagère

Etagère

Porte de droite

Poignée de porte de droite

Panneau arrière

Cadre de gauche

Jupe d’extrémité gauche

Porte de gauche

Panneau inférieur

Poignée de la porte de gauche

14

GENERAL INSTRUCTIONS

With the Weber

®

gas barbecue, you can grill, barbecue, roast, and bake with results that

are difficult to duplicate with indoor kitchen appliances. The closed lid and Flavorizer

®

bars produce that “outdoor” flavor in the food.

Liquid Propane (LP) gas supply is easy to use and gives you more cooking control than

charcoal fuel.

• Theseinstructionswillgiveyoutheminimumrequirementsforassemblingyour

Weber

®

gas barbecue. Please read the instructions carefully before using your

Weber

®

gas barbecue. Improper assembly can be dangerous.

• Notforusebychildren.

• Iftherearelocalcodesthatapplyto“built-in”gasgrills,youwillhavetoconformto

them. Installation must conform with local codes or, in the absence of local codes,

with either the National Fuel Gas Code, ANSI Z223.1/NFPA 54, Natural Gas and

Propane Installation Code, CSA B149.1, or Propane Storage and Handling Code,

B149.2 as applicable.

• ThepressureregulatorsuppliedwiththeWeber

®

gas barbecue must be used. This

regulator is set for 11 inches of water column (pressure).

• ThisWeber

®

gas barbecue is designed for use with liquid propane (LP) gas only. Do

not use with natural (piped in city) gas. The valves, orifices, hose, and regulator are

for LP gas only.

• Donotusewithcharcoalfuel.

• Checkthattheareaunderthecontrolpanelandthegreasetrayarefreefromdebris

that might obstruct the flow of combustion or ventilation air.

• TheareasaroundtheLPcylindermustbefreeandclearfromdebris.

• Replacementpressureregulatorsandhoseassembliesmustbethosespecifiedby

Weber-Stephen Products LLC.

◆

FOR INSTALLATION IN CANADA

These instructions, while generally acceptable, do not necessarily comply with the

Canadian Installation codes, particularly with piping above and below ground. In

Canada the installation of this appliance must comply with local codes and/or Standard

CSA-B149.2 (Propane Storage and Handling Code).

◆

OPERATING

m WARNING: Only use this barbecue outdoors in a well-

ventilated area. Do not use in a garage, building, breezeway

or any other enclosed area.

m WARNING: Keep the ventilation openings of the cylinder

enclosure free and clear of debris.

m WARNING: Your Weber

®

gas barbecue shall not be used

under overhead combustible construction.

m WARNING: Do not use the barbecue within 24 inches

(610 mm) of combustible materials, top, bottom, back or

sides of the grill.

m WARNING: The entire cooking box gets hot when in use. Do

not leave unattended.

m WARNING: Keep any electrical supply cord and the fuel

supply hose away from any heated surface.

m WARNING: Keep the cooking area clear of flammable vapors

and liquids such as gasoline, alcohol, etc., and combustible

materials.

m WARNING: Never store an extra (spare) LP cylinder under or

near the Weber

®

gas barbecue.

m WARNING: Keep the ventilation openings of the cylinder

enclosure free and clear of debris.

m WARNING: Turn off the gas at the LP gas supply cylinder

when the outdoor cooking gas appliance is not in use.

m WARNING: LP cylinders must be stored outdoors out of

the reach of children and must not be stored in a building,

garage, or any other enclosed area.

m WARNING: The LP cylinder used with your barbecue must

be with a listed OPD (Overfilling Prevention Device) and

a QCC1 or Type 1 (CGA810) cylinder connection. The

cylinder connection must be compatible with the barbecue

connection.

◆

STORAGE AND/OR NONUSE

• ThegasmustbeturnedoffattheliquidpropanecylinderwhentheWeber

®

gas

barbecue is not in use.

• LPcylindermustbestoredoutdoorsinawell-ventilatedareaoutofreachofchildren.

Disconnected LP cylinder must not be stored in a building, garage, or any other

enclosed area.

• Checkthattheareasunderthecontrolpanelandtheslide-outgreasetrayarefree

from debris that might obstruct the flow of combustion or ventilation air.

• Thespider/insectscreensshouldalsobecheckedforanyobstructions.(Referto

“MAINTENANCE/ANNUAL MAINTENANCE.”)

◆

WARRANTY

Weber-Stephen Products LLC (Weber) hereby warrants to the ORIGINAL PURCHASER of this

Weber

®

gas grill that it will be free of defects in material and workmanship from the date of purchase

as follows:

Aluminum castings: 25 years (2 years on paint; excludes fading)

Stainless steel shroud: 25 years

Porcelain-enameled shroud: 25 years

Stainless steel burner tubes: 10 years

Stainless steel cooking grates: 5 years no rust through or burn through

Stainless steel Flavorizer

®

bars: 5 years no rust through or burn through

Porcelain-enameled cast-iron cooking grates: 5 years no rust through or burn through

Porcelain-enameled cooking grates: 3 years no rust through or burn through

Porcelain-enameled Flavorizer

®

bars: 2 years no rust through or burn through

Infrared rotisserie burner: 2 years

All remaining parts: 2 years

when assembled and operated in accordance with the printed instructions accompanying it. Weber

may require reasonable proof of your date of purchase. THEREFORE, YOU SHOULD RETAIN YOUR

SALES SLIP OR INVOICE.

This Limited Warranty shall be limited to the repair or replacement of parts that prove defective under

normal use and service and which on examination shall indicate, to Weber’s satisfaction, they are

defective. Before returning any parts, contact the Customer Service Representative in your area

using the contact information on our website. If Weber confirms the defect and approves the claim,

Weber will elect to replace such parts without charge. If you are required to return defective parts,

transportation charges must be prepaid. Weber will return parts to the purchaser, freight or postage

prepaid.

This Limited Warranty does not cover any failures or operating difficulties due to accident, abuse,

misuse, alteration, misapplication, vandalism, improper installation or improper maintenance or

service, or failure to perform normal and routine maintenance, including but not limited to damage

caused by insects within the burner tubes, as set out in this owner’s manual.

Deterioration or damage due to severe weather conditions such as hail, hurricanes, earthquakes

or tornadoes, discoloration due to exposure to chemicals either directly or in the atmosphere, is not

covered by this Limited Warranty.

There are no other express warrants except as set forth herein and any applicable implied warranties

of merchantability and fitness are limited in duration to the period of coverage of this express written

Limited Warranty. Some regions do not allow limitation on how long an implied warranty lasts, so this

limitation may not apply to you.

Weber is not liable for any special, indirect or consequential damages. Some regions do not allow the

exclusion or limitation of incidental or consequential damages, so this limitation or exclusion may not

apply to you.

Weber does not authorize any person or company to assume for it any other obligation or liability in

connection with the sale, installation, use, removal, return, or replacement of its equipment; and no

such representations are binding on Weber.

This Warranty applies only to products sold at retail.

WEBER-STEPHEN PRODUCTS LLC

Customer Service Center

1890 Roselle Road, Suite 308

Schaumburg, IL 60195

USA

For replacement parts call:

1-800-446-1071

Visit www.weber.com

®

, select your country of origin, and register your grill today.

◆

WWW.WEBER.COM

®

15

GAS INSTRUCTIONS

SAFE HANDLING TIPS FOR LIQUID PROPANE GAS CYLINDERS

• LiquidPropane(LP)gasisapetroleumproductasaregasolineandnaturalgas.LP

gas is a gas at regular temperatures and pressures. Under moderate pressure, inside

a cylinder, LP gas is a liquid. As the pressure is released, the liquid readily vaporizes

and becomes gas.

• LPgashasanodorsimilartonaturalgas.Youshouldbeawareofthisodor.

• LPgasisheavierthanair.LeakingLPgasmaycollectinlowareasandprevent

dispersion.

• Tofill,taketheLPcylindertoapropanegasdealer,orlookup“gas-propane”inthe

phone book for other sources of LP gas.

m WARNING: We recommend that your LP cylinder be filled

at an authorized LP gas dealer, by a qualified attendant,

who fills the tank by weight. IMPROPER FILLING IS

DANGEROUS.

• AirmustberemovedfromanewLPcylinderbeforetheinitialfilling.YourLPdealeris

equipped to do this.

• TheLPcylindermustbeinstalled,transported,andstoredinanuprightposition.LP

cylinders should not be dropped or handled roughly.

• NeverstoreortransporttheLPcylinderwheretemperaturescanreach125°F(toohot

to hold by hand). For example: do not leave the LP cylinder in a car on a hot day.

Note: A refill will last about 18–20 hours of cooking time at normal use. The fuel scale,

a feature on some of our grills, will indicate the propane supply so you can refill the

cylinder before running out. You do not have to run out before you refill.

• Treat“empty”LPcylinderswiththesamecareaswhenfull.EvenwhentheLPtank

is empty of liquid, there still may be gas pressure in the cylinder. Always close the

cylinder valve before disconnecting.

m CAUTION: Place dust cap on cylinder valve outlet whenever

the cylinder is not in use. Only install the type of dust cap

on the cylinder valve outlet that is provided with the cylinder

valve. Other types of caps or plugs may result in leakage of

propane.

• DonotuseadamagedLPcylinder.AdentedorrustyLPcylinderoranLPcylinder

with a damaged valve may be hazardous and should be replaced with a new one

immediately.

• ThejointwherethehoseconnectstotheLPcylindermustbeleaktestedeachtime

the LP cylinder is reconnected. For example, test each time the LP cylinder is refilled.

• Besuretheregulatorismountedwiththesmallventholepointeddownwardsothatit

will not collect water. This vent should be free of dirt, grease, bugs, etc.

• ThegasconnectionssuppliedwithyourWeber

®

gas appliance have been designed

and tested to meet 100% CSA and ANSI requirements.

m WARNING: Replacement LP tanks must match the regulator

connection supplied with this Weber

®

gas appliance.

Liquid Propane Cylinder Requirements

• ChecktobesurethatcylindershaveaD.O.T.certification(1), and that they have been

date tested (2) is within five years of use. Your LP gas supplier can do this for you.

• AllLPtanksupplysystemsmustincludeacollartoprotectthecylindervalve.

• TheLPcylindermustbea20-lb.sizeapproximately18¼incheshighand12¼inches

in diameter.

• ThecylindermustbeconstructedandmarkedinaccordancewiththeSpecifications

for LP - Gas Cylinders of the U.S. Department of Transportation (D.O.T.) or the

National Standard of Canada, CAN/CSA-B339, Cylinders, Spheres and Tubes or

Transportation of Dangerous Goods; and Commission, as applicable.

Canadian Liquid Propane Cylinder Requirements

Note: Your retailer can help you match a replacement tank to your barbecue.

• TheLPcylindermustbeconstructedandmarkedinaccordancewiththe

specifications for LP gas cylinders, T.C.

◆

16

m DANGER

Do not use an open flame to check for gas leaks. Be sure

there are no sparks or open flames in the area while you

check for leaks. Sparks or flames will result in a fire or

explosion which can cause serious bodily injury or death,

and damage to property.

GAS INSTRUCTIONS

IMPORTANT LP CYLINDER INFORMATION

m DANGER

NEVER store a spare LP cylinder under or near Weber

®

gas

appliances. NEVER fill the tank beyond 80% full. Failure to

follow these statements exactly may result in a fire causing

death or serious injury.

Weber

®

gas appliances are equipped for a cylinder supply system designed for vapor

withdrawal.

m WARNING: Only use Weber

®

gas appliances outdoors in

a well-ventilated area. Do not use in a garage, building,

breezeway or any other enclosed area.

The proper filling methods for the filling of your cylinder are by weight or volume, as

described in NFPA 58. Please make sure your filling station fills your LP cylinder by

weight or volume. Ask your filling station to read purging and filling instructions on the LP

cylinder before attempting to fill.

◆

LEAK CHECK PREPARATION

Check That All Burner Valves Are Off

Valves are shipped in the OFF position, but you should check to be sure that they are

turned off. Check by pushing down and turning clockwise. If they do not turn, they are off.

If they do turn, continue turning them clockwise until they stop; then they are off.

The Liquid Propane Cylinder

All Weber

®

liquid propane gas grill regulators are equipped with a UL-Listed tank

connection as per the latest edition of ANSI Z21.58. This will require a liquid propane

tank that is similarly equipped with a Type 1 connection in the tank valve. This Type 1

coupling allows you to make a fast and totally safe hookup between your gas grill and

your liquid propane tank. It eliminates the chance of leaks due to a POL fitting that is

not properly tightened. Gas will not flow from the tank unless the Type 1 coupling is fully

engaged into the coupling.

m WARNING: Make sure that the LP cylinder valve is closed.

Close by turning valve clockwise.

3

1

2

4

5

TYPE 1 CONNECTIVE COUPLING

1 Type 1 valve

2 Hand wheel

3 External thread

4 Thermally sensitive nut

5 Propane regulator

WWW.WEBER.COM

®

17

A) Locate hose retention clip (1) on regulator hose. Secure into slot (2) on underside of

tank scale.

m WARNING: The hose must be secured to the tank scale

with the Hose Retention Clip. Failure to do so could cause

damage to the hose resulting in a fire or explosion which

can cause serious bodily injury or death, and damage to

property.

Some LP tanks have differing top collar assembles. (The top collar is the metal

protective ring around the valve.) One series of tanks mount with the valve facing front

(3). The other tanks mount with the valve facing away from the fuel scale (4). Weber

recommends the use of cylinder manufacturer’s Manchester and Worthington, with a

47.6 lb water capacity. Other cylinders may be acceptable for use with the appliance

provided they are compatible with the appliance retention means (see illustrations).

The LP cylinder is installed inside the base cabinet, on the tank scale (right side).

B) Open base cabinet doors.

C) Loosen cylinder lock wing nut. Swing cylinder lock up (5).

D) Turn the LP cylinder so the opening of the valve is either to the front or side of the

Weber

®

gas barbecue.

E) Lift tank up into position on the tank scale (6).

F) Swing the cylinder lock down. Tighten the wing nut.

Connect The Hose To The Cylinder

A) Remove the plastic dust cover from the valve.

B) Screw the regulator coupling onto the tank valve, clockwise, or to the right. Hand-

tighten only (7).

Note: This connection tightens clockwise and will not allow gas to flow unless the

connection is tight. The connection requires tightening by hand only.

m WARNING: Do not use a wrench to tighten the connection.

Using a wrench could damage the regulator coupling and

could cause a leak.

GAS INSTRUCTIONS

6

1

2

3 4

5 5

7

18

1

2

3

4

m WARNING: The gas connections of your Summit

®

gas grill

have been factory tested. We do however recommend that

you leak check all gas connections before operating your

Summit

®

gas grill.

Remove Control Panel

Parts required: Phillips screwdriver and a towel.

A) Remove the burner control knobs (1).

B) Open both doors and place a towel on top of the doors. This will protect the control

panel and tops of the doors from getting scratched on the next step.

C) Remove the screws from the underside of the control panel with a Phillips

screwdriver (2).

D) Tilt the conrol panel forward and lift up and away from the grill (3) (For Summit

®

models with LED features: Be careful not to break or disconnect the wires for the

control panel LED’s).

E) Place the control panel on the towel covering the door assemblies (4).

GAS INSTRUCTIONS

The grill illustrated

may have slight

differences than the

model purchased.

WWW.WEBER.COM

®

19

Note: All factory-made connections have been thoroughly checked for gas leaks. The

burners have been flame-tested. As a safety precaution, however, you should recheck

all fittings for leaks before using your Weber® gas barbecue. Shipping and handling

may loosen or damage a gas fitting.

m WARNING: The gas connections of your gas grill have been

factory tested. We do however recommend that you leak

check all gas connections before operating your gas grill.

m WARNING: Perform these leak checks even if your barbecue

was dealer or store assembled.

If your grill has a side burner, make sure the side burner is turned off.

Turn on gas supply at source.

m WARNING: Do not ignite burners when leak checking.

You will need: A soap and water solution and a rag or brush to apply it.

A) Mix soap and water.

B) Turn on gas supply (1).

C) Check for leaks by wetting the fitting with the soap and water solution and watching

for bubbles. If bubbles form, or if a bubble grows, there is a leak.

If there is a leak, turn off the gas and tighten the fitting. Turn the gas back on and

recheck with the soap and water solution. If leak does not stop, do not use the

barbecue. Contact the Customer Service representative in your area using the

contact information on our web site. Log onto www.weber.com

®

.

D) When leak checking is complete, turn gas supply off at the source and rinse

connections with water.

Note: Since some leak test solutions, including soap and water, may be slightly

corrosive, all connections should be rinsed with water after checking for leaks.

m WARNING: You should check for gas leaks every time you

disconnect and reconnect a gas fitting.

CHECK FOR GAS LEAKS

m DANGER

Do not use an open flame to check for gas leaks. Be sure

there are no sparks or open flames in the area while you

check for leaks. Sparks or open flames will result in a fire or

explosion, which can cause serious bodily injury or death

and damage to property.

Remove Side Burner Cabinet Back Panel and

Side Burner Cabinet Water Deflector

Tools required: Phillips screwdriver.

A) Facing the back of the unit, remove screws that secure back panel of side burner

cabinet with a Phillips screwdriver (1).

B) Remove back panel and set aside (2).

C) Facing the front of the unit, open side burner cabinet door and remove screw

securing side burner cabinet water deflector (3).

D) Facing the back of the unit, push water deflector forward to allow rear edge to drop

down. Pivot down on an angle and remove from side burner cabinet (4).

◆

GAS INSTRUCTIONS

1

2

4

2

3

1

20

4

1

2

3

4

5

8

67

The grill illustrated may

have slight differences

than the model purchased.

Check

A) Main gas line to manifold connection (1).

B) Rotisserie (I.R. Burner) gas line connection (2).

C) Bulkhead and gas supply hose connection (3).

D) Side burner hose to bulkhead connection (4).

m WARNING: If there is a leak at connection (1, 2, 3, or 4),

re-tighten the fitting with a wrench and recheck for leaks

with soap and water solution. If a leak persists after re-

tightening the fitting, turn off the gas. DO NOT OPERATE

THE GRILL. Contact the Customer Service Representative in

your area using the contact information on our web site. Log

onto www.weber.com

®

.

E) Side burner hose to quick disconnect connection, side burner line to valve and

orifice connections (5).

F) Hose to regulator connection (6).

G) Regulator to cylinder connection (7).

H) Valves to manifold connections (8).

m WARNING: If there is a leak at connections (5, 6, 7, or 8),

turn off the gas. DO NOT OPERATE THE GRILL. Contact

the Customer Service Representative in your area using the

contact information on our web site.

Log onto www.weber.com

®

.

When leak checks are complete, turn gas supply off at the source and rinse connections

with water.

Reinstall Control Panel

Parts required: control panel, screws and burner control knobs.

A) Hook the top edge of the control panel onto the control panel brackets on either side

of the front of the cooking box.

B) Line up screws with screw holes on both the control panel bracket and the frame.

Tighten screws.

C) Place corresponding control knobs onto the valve stems.

Reinstall Side Burner Cabinet Water Deflector

Tools required: Phillips screwdriver.

A) Push front edge of water deflector up on an angle into side burner cabinet. The front

edge rests on the lip on the underside of the table. Pivot rear edge of deflector up

and rest on rear lip of table.

B) Replace screw securing side burner cabinet water deflector.

◆

GAS INSTRUCTIONS

La page est en cours de chargement...

Weber Summit Grill Center LP SS Literature Kit

Ce manuel convient également à

Weber Summit Grill Center LP SS Literature Kit

dans d''autres langues

Documents connexes

Autres documents