Makita DLM537 Manuel utilisateur

DLM537

EN Cordless Lawn Mower INSTRUCTION MANUAL 8

FR Tondeuse Sans Fil MANUEL D’INSTRUCTIONS 20

DE Akku Rasenmäher BETRIEBSANLEITUNG 33

IT Tosaerba a batteria ISTRUZIONI PER L’USO 46

NL Accugrasmaaier GEBRUIKSAANWIJZING 59

ES Cortadora de Cesped MANUAL DE

INSTRUCCIONES 72

PT Cortadora de Grama a Bateria MANUAL DE INSTRUÇÕES 85

DA Akku-plæneklipper BRUGSANVISNING 98

EL   110

TR  KULLANMA KILAVUZU 124

2

1

Fig.1

1

Fig.2

3

4

5

2

1

Fig.3

12

Fig.4

1

Fig.5

2

1

2

Fig.6

1

Fig.7

1

2

3

Fig.8

1

2

Fig.9

1

2

Fig.10

1

2

Fig.11

1

2

3

Fig.12

1

Fig.13

3

1

Fig.14

1

2

Fig.15

13

4

56

2

Fig.16

1 2

Fig.17

1

Fig.18

1

Fig.19

1

2

3

Fig.20

4

1

Fig.21

1

Fig.22

1

2

Fig.23

1

Fig.24

1

2

Fig.25

Fig.26

Fig.27

5

12 3

Fig.28

Fig.29

Fig.30

1

23

Fig.31

1

Fig.32

12

Fig.33

2

1

3

Fig.34

6

3

2

4

1

Fig.35

7

8ENGLISH

ENGLISH (Original instructions)

SPECIFICATIONS

Model: DLM537

Mowing width (blade diameter) 534 mm

No load speed Normal mode 2,800 min-1

Noise reduction mode 2,300 min-1

Part number of replacement

mower blade

Straight mower blade 191D52-7 / 191W87-2

Dimensions

(L x W x H)

L: 1,655 mm to 1,740 mm

W: 590 mm

H: 990 mm to 1,100 mm

Traveling speed 2.5 - 5.0 km/h

Rated voltage D.C. 36 V

Net weight

When straight mower blade is installed

42.6 - 46.4 kg

Protection degree IPX4

 

without notice.

 

 -

est combination, according to EPTA-Procedure 01/2014, are shown in the table.

Applicable battery cartridge

BL1815N / BL1820 / BL1820B / BL1830 / BL1830B / BL1840 / BL1840B / BL1850 / BL1850B / BL1860B

 

WARNING: Only use the battery cartridges listed above.



WARNING: Do not use a corded power supply such as battery adapter or portable power pack with

this machine.

Symbols





meaning before use.

Take particular care and attention.

Read instruction manual.



The distance between the tool and





blade under the mower. Blades continue to







storing the mower.

Electrical hazard. Contact with water can

cause electric shock.

Do not pour water.

Ni-MH

Li-ion



Due to the presence of hazardous com-

ponents in the equipment, waste electrical

and electronic equipment, accumulators



on the environment and human health.

Do not dispose of electrical and electronic

appliances or batteries with household

waste!

In accordance with the European Directive

on waste electrical and electronic equip-

ment and on accumulators and batteries

and waste accumulators and batteries,

as well as their adaptation to national law,

waste electrical equipment, batteries and



and delivered to a separate collection point

for municipal waste, operating in accor-

dance with the regulations on environmen-

tal protection.



crossed-out wheeled bin placed on the

equipment.

Guaranteed sound power level according

to EU Outdoor Noise Directive.

Sound power level according to Australia

NSW Noise Control Regulation.

9ENGLISH

Intended use

The machine is intended for lawn mowing.

Noise

-

ing to EN60335-2-77:

NOTE: The values have been measured with the

mower equipped with the straight mower blade.

Sound pressure level (LpA) : 81.2 dB(A)

Sound power level (LWA) : 92.2 dB (A)



NOTE: The declared noise emission value(s) has

been measured in accordance with a standard test



another.

NOTE: The declared noise emission value(s)



exposure.

WARNING: Wear ear protection.

WARNING: The noise emission during actual



value(s) depending on the ways in which the

tool is used especially what kind of workpiece is

processed.

WARNING: Be sure to identify safety mea-

sures to protect the operator that are based on an

estimation of exposure in the actual conditions of

use (taking account of all parts of the operating

cycle such as the times when the tool is switched



trigger time).

Vibration

The vibration total value (tri-axial vector sum) deter-

mined according to EN60335-2-77:

NOTE: The values have been measured with the

mower equipped with the straight mower blade.

Vibration emission (ah) : 2.5 m/s2 or less

2

NOTE: The declared vibration total value(s) has been

measured in accordance with a standard test method



NOTE:



WARNING: The vibration emission during



declared value(s) depending on the ways in which

the tool is used especially what kind of workpiece

is processed.

WARNING: Be sure to identify safety mea-

sures to protect the operator that are based on an

estimation of exposure in the actual conditions of

use (taking account of all parts of the operating

cycle such as the times when the tool is switched



trigger time).

EC Declaration of Conformity

For European countries only



to this instruction manual.

SAFETY WARNINGS

IMPORTANT SAFETY

INSTRUCTIONS

WARNING: Read all safety warnings and

all instructions. Failure to follow the warnings and





Save all warnings and instruc-

tions for future reference.

Training

1. Read the instructions carefully. Be familiar

with the controls and the proper use of the

mower.

2. Never allow children or people unfamiliar with

these instructions to use the mower. Local

regulations can restrict the age of the operator.

3. Never operate the mower while people, espe-

cially children, or pets are nearby.

4. Keep in mind that the operator or user is

responsible for accidents or hazards occurring

to other people or their property.

5. Children should be supervised to ensure that

they do not play with the mower.

6. Physical condition - Do not operate mower



any medication.

Preparation

1. While operating the mower, always wear sub-

stantial footwear and long trousers. Do not

operate the mower when barefoot or wearing

open sandals. Avoid wearing clothing or jew-



cords or ties. They can be caught in moving

parts.

2. Before use, always visually inspect the mower

for damaged, missing or misplaced guards or

shields.

3. Be sure the area is clear of other people before

mowing. Stop mower if anyone enters the area.

4. Do not insert the lock key into mower until it is

ready to be used.

5. Always wear protective goggles to protect

your eyes from injury when using power tools.

The goggles must comply with ANSI Z87.1 in

the USA, EN 166 in Europe, or AS/NZS 1336

in Australia/New Zealand. In Australia/New

Zealand, it is legally required to wear a face

shield to protect your face, too.

10 ENGLISH

It is an employer's responsibility to enforce

the use of appropriate safety protective equip-

ments by the tool operators and by other per-

sons in the immediate working area.

6. Check the blades or blade bolts carefully for

cracks or damage before operation. Replace

cracked or damaged blades or blade bolts

immediately.

7. Remove foreign matters such as rocks, wire,

bottles, bones and large sticks from the work

area before mowing to prevent personal injury

or damage to the mower.

8. Objects struck by the mower blade can cause

severe injuries to persons. The lawn should

always be carefully examined and cleared of

all objects prior to each mowing.

9. Watch for holes, ruts, bumps, rocks, or other

hidden objects. Uneven terrain could cause a slip

and fall accident. Tall grass can hide obstacles.

10. Do not insert or remove the lock key in the

rain.

11. Use personal protective equipment. Always

wear eye protection. Protective equipment such



hearing protection used for appropriate conditions



Operation

1. Do not overreach. Keep the balance at all

times. Always be sure of the footing on slopes.

Walk, never run.

2. Stop the mower and remove the lock key, and

make sure that all moving parts have come to

a complete stop:

- whenever you leave the mower,

- before clearing blockages or unclogging chute,

- before checking, cleaning or working on the

mower,

- after striking a foreign object. Inspect the

mower for damage and make repairs before

restarting and operating the mower,

- whenever the mower starts vibrating

abnormally.

3. Never operate the mower with defective

guards or shields, or without safety devices,



place.

4. Avoid using the mower in bad weather con-

ditions especially when there is a risk of

lightning.

5. Wear eye protection and stout shoes at all

times while operating the mower.

6. Operate the mower only in daylight or in good



7. Switch on the mower carefully according to

instructions and with feet well away from the

blade(s).

8. Take care against injury to feet and hands from

the mower blades.

9. Always ensure that the ventilation openings

are kept clear of debris.

10. Mow across the face of slopes, never up and

down. Exercise extreme caution when chang-

ing direction on slopes. Do not mow exces-

sively steep slopes.

11. Use extreme caution when reversing or pulling

the mower towards you.

12. Stop the blade(s) if the mower has to be tilted

for transportation when crossing surfaces

other than grass, and when transporting the

mower to and from the area to be used.

13. Do not tilt the mower when switching on the

motor, except if the mower has to be tilted

for starting. In this case, do not tilt it more

than absolutely necessary and lift only the

part, which is away from the operator. Always

ensure that both hands are in the operating

position before returning the mower to the

ground.

14. Do not put hands or feet near or under rotating

parts. Keep clear of the discharge opening at

all times.

15. Do not transport the mower while the mower is

turned on.

16. Avoid operating the mower in wet grass.

17. 

18. Don't grasp the exposed cutting blades or

cutting edges when picking up or holding the

mower.

19. Keep hands and feet away from rotating

blades. Caution - Blades coast after the mower



20. Stop operation immediately if you notice



remove the lock key. Then inspect the mower.

21. Never attempt to make cutting height adjust-

ments while mower is running if the mower

has cutting height adjustment feature.

22. Release switch lever and wait for blade rota-

tion to stop before crossing driveways, walks,

roads, and any gravel-covered areas. Also

remove the lock key if you leave the mower,

reach to pick up or remove something out of

your way, or for any other reason that may

distract you from what you are doing.

23. If the mower strikes a foreign object, follow

these steps:

- Stop the mower, release the switch lever and

wait until the blade comes to a complete stop.

- Remove the lock key and the battery

cartridge.

- Thoroughly inspect the mower for any

damage.

- Replace the blade if it is damaged in any way.

Repair any damage before restarting and con-

tinuing to operate the mower.

11 ENGLISH

24. Do not start the mower when standing in front

of the discharge opening.

25. If the mower starts to vibrate abnormally

(check immediately)

- inspect for damage,

- replace or repair any damaged parts,

- check for and tighten any loose parts.

26. Never direct discharged material toward

anyone. Avoid discharging material against a

wall or obstruction.

toward the operator. Stop the blade when crossing

gravel surfaces.

27. Do not pull the mower backwards unless

absolutely necessary.

to back the mower from a fence or other similar

obstruction, look down and behind before and

while moving backwards.

28. 

comes to a complete stop before removing the

grass catcher. Beware that the blades coast after



29. When you use the machine on muddy ground,

wet slope, or slippery place, pay attention to

your footing.

30. Avoid working in poor environment where

increased user fatigue is expected.

31. Do not use the machine in bad weather where

visibility is limited.



32. Do not submerge the machine into a puddle.

33. When wet leaves or dirt adhere to the suc-

tion mouth (ventilation window) due to rain,

remove them.

34. Do not use the machine in the snow.

35. 

clogged inside of the machine. Check the con-

dition of the machine regularly, and remove the

adhered grass as necessary.

36. When operating the machine, pay attention to

piping and wiring.

37. Do not use a corded power supply such as bat-

tery adapter or portable power pack with this

machine.



Maintenance and storage

1. Replace worn or damaged parts for safety.

Use only genuine replacement parts and

accessories.

2. Inspect and maintain the mower regularly.

3. When not in use, store the mower out of the

reach of children.

4.

Keep all nuts, bolts, and screws tight to be sure

the equipment is in safe working condition.

5. Check the grass basket frequently for wear or

deterioration. For storage, always make sure

the grass basket is empty. Replace a worn

grass basket with a new factory replacement

for safety.

6. Use only the manufacturer genuine blades



7. Be careful during adjustment of the mower





8. Check the blade mounting bolt at frequent

intervals for proper tightness.

9. Always allow the mower to cool down before

storing.

10. When servicing the blades be aware that, even



blades can still be moved.

11. Never remove or tamper with safety devices.

Check their proper operation regularly. Never

do anything to interfere with the intended

function of a safety device or to reduce the

protection provided by a safety device.

12. Do not leave the machine unattended outdoors

in the rain.

13. Do not wash the machine with high pressure

water.

14. When washing the machine, be sure to remove

the battery and lock key and close the battery

cover, and pour water toward the bottom of the

machine to which the blade is attached.

15. When storing the machine, avoid direct sun-

light and rain, and store it in a place where it

does not get hot or humid.

16. Perform inspection or maintenance in a place

where rain can be avoided.

17. After using the machine, remove the adhered

dirt and dry the machine completely before

storing. Depending on the season or the area,

there is a risk of malfunction due to freezing.

Battery tool use and care

1. 

the manufacturer. A charger that is suitable for





2. -

nated battery packs.



3. When battery pack is not in use, keep it away

from other metal objects, like paper clips,

coins, keys, nails, screws or other small metal

objects, that can make a connection from one

terminal to another.-



4. Under abusive conditions, liquid may be

ejected from the battery; avoid contact. If con-



liquid contacts eyes, additionally seek medical

help.

irritation or burns.

5. Do not use a battery pack or tool that is dam-







6. 

excessive temperature.-



7. Follow all charging instructions and do not

charge the battery pack or tool outside the

-

tions.





12 ENGLISH

Electrical and battery safety

1. 



possible special disposal instructions.

2.

Do not open or mutilate the battery(ies). Released





3.

Do not charge battery in rain, or in wet locations.

4. Do not charge the battery outdoors.

5. Do not handle charger, including charger plug,

and charger terminals with wet hands.

6. Do not replace the battery in the rain.

7. Do not wet the terminal of battery with liquid

such as water, or submerge the battery. Do not

leave the battery in the rain, nor charge, use,

or store the battery in a damp or wet place. If

the terminal gets wet or liquid enters inside of bat-





8. Avoid dangerous envionment. Don't use the

tool in dump or wet locations or expose it to

rain. Water entering the tool will increase the

risk of electric shock.

9. If the battery cartridge gets wet, drain the

water inside and then wipe it with a dry cloth.

Dry the battery cartridge completely in a dry

place before use.

10. After removing the battery from the machine or

charger, be sure to attach the battery cover to

the battery and store it in a dry place.

11. Do not replace the battery with wet hands.

Service

1. 

repair person using only identical replacement

parts.

tool is maintained.

2. Never service damaged battery packs. Service



manufacturer or authorized service providers.

SAVE THESE INSTRUCTIONS.

WARNING: DO NOT let comfort or familiarity

with product (gained from repeated use) replace

strict adherence to safety rules for the subject

product.

MISUSE or failure to follow the safety rules stated

in this instruction manual may cause serious

personal injury.

Important safety instructions for

battery cartridge

1. Before using battery cartridge, read all instruc-

tions and cautionary markings on (1) battery

charger, (2) battery, and (3) product using

battery.

2. Do not disassemble or tamper with the battery

cartridge.

or explosion.

3. If operating time has become excessively

shorter, stop operating immediately. It may

result in a risk of overheating, possible burns

and even an explosion.

4.

If electrolyte gets into your eyes, rinse them out

with clear water and seek medical attention right

away. It may result in loss of your eyesight.

5. Do not short the battery cartridge:

(1) Do not touch the terminals with any con-

ductive material.

(2) Avoid storing battery cartridge in a con-

tainer with other metal objects such as

nails, coins, etc.

(3) Do not expose battery cartridge to water

or rain.

A battery short can cause a large current



breakdown.

6. Do not store and use the tool and battery car-

tridge in locations where the temperature may

reach or exceed 50 °C (122 °F).

7. Do not incinerate the battery cartridge even if

it is severely damaged or is completely worn



8. Do not nail, cut, crush, throw, drop the battery

cartridge, or hit against a hard object to the

battery cartridge.



9. Do not use a damaged battery.

10.

The contained lithium-ion batteries are subject to

the Dangerous Goods Legislation requirements.



forwarding agents, special requirement on pack-

aging and labeling must be observed.

For preparation of the item being shipped, consult-

ing an expert for hazardous material is required.



national regulations.





around in the packaging.

11. When disposing the battery cartridge, remove

it from the tool and dispose of it in a safe

place. Follow your local regulations relating to

disposal of battery.

12. Use the batteries only with the products

 Installing the batteries to

-



13. If the tool is not used for a long period of time,

the battery must be removed from the tool.

14. During and after use, the battery cartridge may

take on heat which can cause burns or low

temperature burns. Pay attention to the han-

dling of hot battery cartridges.

15. Do not touch the terminal of the tool imme-

diately after use as it may get hot enough to

cause burns.

16. Do not allow chips, dust, or soil stuck into the

terminals, holes, and grooves of the battery

cartridge.

-



17. Unless the tool supports the use near

high-voltage electrical power lines, do not use

the battery cartridge near high-voltage electri-

cal power lines.



13 ENGLISH

18. Keep the battery away from children.

SAVE THESE INSTRUCTIONS.

CAUTION: Only use genuine Makita batteries.

Use of non-genuine Makita batteries, or batteries that







charger.

Tips for maintaining maximum

battery life

1. Charge the battery cartridge before completely

discharged. Always stop tool operation and

charge the battery cartridge when you notice

less tool power.

2. Never recharge a fully charged battery car-

tridge. Overcharging shortens the battery

service life.

3. Charge the battery cartridge with room tem-

perature at 10 °C - 40 °C (50 °F - 104 °F). Let

a hot battery cartridge cool down before

charging it.

4. When not using the battery cartridge, remove

it from the tool or the charger.

5. Charge the battery cartridge if you do not use

it for a long period (more than six months).

ASSEMBLY

WARNING: Always be sure that the lock key

and battery cartridge are removed before carrying

out any work on the mower. Failure to remove the

-



WARNING: Never start the mower unless it is

completely assembled. Operation of the machine





Installing the handle

NOTICE: When installing handles, position the

cords so that they are not caught by anything

between the handles. If the cord is damaged, the

mower switch may not work.

1. Align the holes in the lower handle with the holes



Fig.1: 1. Lower handle 2. Bolt

Fig.2: 1. Holes for upper bolt

NOTE:







2. 

tightened in step 1 using box wrench 13.

3. Align the hole in the lower handle with the hole in

the upper handle, then insert the bolt from inside, and

then tighten the nut from outside with box wrench 13.

Perform the same procedure on the other side.

Fig.3: 1. Bolt 2. Lower handle 3. Nut 4. Hole

5. Upper handle

CAUTION: 

 Otherwise, the



4. Attach the holders to the handle.

Align the protrusions on the holder with the holes on the





Fig.4: 1. Cord 2. Holder

Removing the mulching plug

1. Open the rear cover.

Fig.5: 1. Rear cover

2. Remove the mulching plug while holding down the

lever.

Fig.6: 1. Lever 2. Mulching plug

Installing or removing the grass

basket

To install the grass basket, follow the steps below.

1. Open the rear cover.

Fig.7: 1. Rear cover

2. Hold the handle of the grass basket, and then





Fig.8: 1. Rod 2. Handle 3. Grass basket

To remove the grass basket, open the rear cover, and



Attaching the mulching plug

1. Open the rear cover, and then remove the grass

basket.

Fig.9: 1. Rear cover 2. Grass basket

2. Attach the mulching plug while holding down the

lever, and then release the lever to lock the mulching

plug.

Fig.10: 1. Lever 2. Mulching plug

14 ENGLISH

FUNCTIONAL DESCRIPTION

Installing or removing battery cartridge

CAUTION:



before installing or removing of the battery cartridge.

CAUTION:

Hold the machine and the battery car-









CAUTION: Make sure that you lock the battery

cover before use. 



CAUTION: Always install the battery cartridge

fully until the red indicator cannot be seen. If not,





CAUTION: Do not install the battery cartridge

forcibly.



NOTE:



To install the battery cartridge;

1.



Fig.11: 1.2. Locking lever

2. 

slot on the machine, and then slide the cartridge until it

locks in place with a little click.

Fig.12: (1)(2)

(3)

NOTE:



3. 

as far as it will go.

Fig.13: 1.

4. 

latched with the locking lever.

To remove the battery cartridge;

1.



2. 

while sliding the button on the front of the cartridge.

3. 

4. 

Switching the battery cartridges

Fig.14: 1.









NOTE:





selection switch.

Machine / battery protection system

-









Overload protection









the application that caused the machine to become

overloaded. Then turn the machine on to restart.

Overheat protection







cool before turning the machine on again.

Overdischarge protection











Indicating the remaining battery capacity

Only for battery cartridges with the indicator

Fig.15: 1. Indicator lamps 2. Check button

-



light up for a few seconds.

Indicator lamps Remaining

capacity

Lighted  Blinking

75% to 100%

50% to 75%

25% to 50%

0% to 25%

Charge the







malfunctioned.

NOTE: Depending on the conditions of use and the





NOTE:



15 ENGLISH

Control panel

The control panel has the main power switch, the mode switch-



Fig.16: 1.2. Mode switching

lamp 3. Main power lamp 4. Check button

5. Mode switching button 6. Main power

switch

Main power switch

WARNING: 

switch when not in use.

To turn on the machine, press the main power switch.



machine, press the main power switch again.

NOTE: If the main power lamp lights up in red or

blinks in red or green, refer to the instructions for



NOTE:

function. To avoid unintentional start up, the main



switch lever and drive lever (if equipped) are not

pulled for a certain period after the main power switch

is turned on.

Mode switching button



mode switching button. When the machine is turned on,



press the mode switching button, the machine shifts to

the noise reduction mode and the mode switching lamp





mode switching button again, the machine returns to

the normal mode.

Indicating the remaining battery

capacity







Battery indicator status

Remaining battery

capacity

On 

50% - 100%

20% - 50%

0% - 20%

NOTE:

-



conditions.

NOTE:



Switch action

WARNING: Before installing the battery car-

tridge, always check to see that the switch lever

actuates properly and returns to the original posi-

tion when released. Operating the machine with a





NOTE: The mower does not start without pressing the

switch button even the switch lever is pulled.

NOTE:



Increase the mowing height in this case.









Service Center.

1. 



2. 



3. Press the main power switch.

4. 

down the switch button. Release the switch button as

soon as the motor starts running.

Fig.17: 1. Switch button 2. Switch lever

NOTE:



5. While holding the switch lever, push the drive lever

forward and hold it to drive the rear wheels.

Fig.18: 1. Drive lever

NOTE:

the drive lever forward and hold it without pulling the

switch lever.

6. Release the drive lever and the switch lever to

stop the machine.

16 ENGLISH

Adjusting the mowing height

WARNING: Never put your hand or leg under

the mower body when adjusting the mowing

height.

WARNING: Always make sure that the lever





between 20 mm and 100 mm.







Fig.19: 1.

The table below shows the relationship between the

-

ing height.

Number Mowing height

120 mm

226 mm

332 mm

439 mm

547 mm

655 mm

763 mm

874 mm

986 mm

10 100 mm

Hold the front grip or the lower handle with one hand,



the other hand.

Fig.20: 1.2. Lower

handle 3. Front grip

NOTE:







NOTE:-



Grass level indicator

Grass level indicator shows the volume of mowed

grass. When the grass basket is not full, the indicator



Fig.21: 1. Grass level indicator

When the grass basket is almost full, the indicator does





Fig.22: 1. Grass level indicator

NOTE: This indicator is a rough guide. Depending on

the conditions of inside of the basket, this indicator



Adjusting the handle height

CAUTION: Before removing the bolts, hold







1. Remove the upper bolts of the lower handle using

box wrench 13, and then loosen the lower bolts.

Fig.23: 1. Upper bolt 2. Lower bolt

2. 



Adjusting the traveling speed

Fig.24: 1. Speed lever





and to increase the speed, turn the lever forward.

Using mulching plug



the ground without gathering the cut grass in the grass

-

ing plug, be sure to remove the grass basket.

NOTICE: When using the machine with the

mulching plug, make sure that the total length of

grass is 30 mm or more, or the cut length is 15

mm or less.

Fig.25: (1) 30 mm or more (2) 15 mm or less

Using the rear discharge



grass to the ground from the rear side of the machine

without gathering the cut grass in the grass basket.

-

charge, be sure to remove the grass basket and mulch-

ing plug, and close the rear cover.

Electronic function

The machine is equipped with the electronic functions



• Constant speed control of blade rotation

Electronic speed control for obtaining constant



rotating speed is kept constant even under load

condition.

• Electric brake

This machine is equipped with an electric brake.



the mower blades after releasing the switch lever,

have the machine serviced at Makita Authorized

Service Center.

17 ENGLISH

OPERATION

Mowing

WARNING: Before mowing, clear away sticks

and stones from mowing area. Furthermore, clear

away any weeds from mowing area in advance.

WARNING:

Always wear the safety goggles or safety

glasses with side shields when operating the mower.

CAUTION:

If the cut grass or foreign object

blocks up inside of the mower body, be sure to

remove the lock key and battery cartridge and wear

gloves before removing the grass or foreign object.

NOTICE: Use this machine for mowing lawn only.

Do not mow weeds with this machine.

Fig.26





Fig.27

The center lines of the front wheels are guidelines to mowing

width. Using the center lines as guidelines, mow in strips. Overlap



Fig.28:

1. Mowing width 2. Overlapping area 3. Center line

Change the mowing direction each time to prevent the



Fig.29







NOTICE:

Using the mower with the grass basket full

prevents smooth blade rotation and places an extra

load on the motor, which may cause breakdown.

Mowing a long-grass lawn







Fig.30

NOTE: Mowing long grass to a short length all at





Emptying the grass basket

WARNING:

To reduce a risk of accident, regu-

larly check the grass basket for any damage or weak-

ened strength. Replace the grass basket if necessary.

1. Release the switch lever and drive lever.

2. 

3. Open the rear cover and take out the grass basket



Fig.31: 1. Rear cover 2. Handle 3. Grass basket

4. 

MAINTENANCE

WARNING: Always be sure that the lock

key and battery cartridge are removed from the

mower before storing or carrying the mower or

attempting to perform inspection or maintenance.

WARNING: Always remove the lock key when

the mower is not in use. Store the lock key in a

safe place out of reach of children.

WARNING: Wear gloves when performing

inspection or maintenance.

WARNING: Always wear the safety goggles or

safety glasses with side shields when performing

inspection or maintenance.

NOTICE: Never use gasoline, benzine, thinner,

alcohol or the like. Discoloration, deformation or

cracks may result.

To maintain product SAFETY and RELIABILITY,







Maintenance

1. 



2. Put the mower on its side and clean grass clip-

pings accumulated on the underside of mower deck.

3. Pour water toward the bottom of the machine to

which the blade is attached.

NOTICE: Do not wash the machine with high

pressure water.

4. Check all nuts, bolts, knobs, screws, fasteners etc.

for tightness.

5. Inspect moving parts for damage, breakage, and

wear. Damaged or missing parts should be repaired or

replaced.

6. Store the mower in a safe place out of the reach of

children.

NOTICE: Do not pour water to the area shown in



a malfunction of the machine.

Fig.32: 1. Area where water should not be poured

Carrying the mower





Fig.33: 1. Front grip 2. Rear grip

Storing



Don't store the mower and charger in locations where



18 ENGLISH

Removing or installing the mower

blade

WARNING: The blade coasts for a few sec-

onds after releasing the switch. Do not start any

operation until the blade comes to a complete

stop.

WARNING: Always remove the lock key and

battery cartridge when removing or installing the

blade. Failure to remove the lock key and battery

cartridge may cause a serious injury.

WARNING: Always wear gloves when han-

dling the blade.

Removing the mower blade

1. Put the mower on its side so that the mowing



2. To lock the blade, insert the pin supplied with the



3. Turn the bolt counterclockwise with box wrench

17.

Fig.34: 1. Mower blade 2. Pin 3. Box wrench

4. Remove the bolt, and then mower blade.

Fig.35: 1. Blade support 2. Mower blade 3. Bolt

4. Protrusion

NOTICE: When installing the mower blade, make



in the holes in the mower blade.

Installing the mower blade

WARNING: Install the mower blade carefully.

It has a top/bottom facing.

WARNING: 

to secure the blade.

WARNING: Make sure that the mower blade



tightened securely.

WARNING: When you replace the blades,

always follow the instructions provided in this

manual.

NOTICE: After installing the mower blades,

remove the pin from the mower body.

To install the mower blades, perform the removal proce-

dure in reverse.

TROUBLESHOOTING





replacement parts for repairs.

State of abnormality Probable cause (malfunction) Remedy

Mower does not start.  

 



 



correct position.

-



switch.

Motor stops running after a little use.  



Cutting height is too low. Increase the cutting height.

Cut grass is clogged in the mower. Remove the clogged grass from the mower.

Motor does not reach maximum

RPM.

 

manual.

 









Mower blade does not rotate:















Abnormal vibration:







Replace the blade.

19 ENGLISH

OPTIONAL

ACCESSORIES

CAUTION: These accessories or attachments

are recommended for use with your Makita



other accessories or attachments might present a risk

-

ment for its stated purpose.

-



Center.

• Mower blade

 

NOTE:





20 FRANÇAIS

FRANÇAIS (Instructions originales)

SPÉCIFICATIONS

Modèle : DLM537

Largeur de tonte (diamètre de la lame) 534 mm

Vitesse à vide Mode normal 2 800 min-1

Mode de réduction du bruit 2 300 min-1

Numéro de référence de la lame

de tondeuse de remplacement

Lame de tondeuse droite 191D52-7 / 191W87-2

Dimensions

(L x l x H)

L : 1 655 mm à 1 740 mm

l : 590 mm

H : 990 mm à 1 100 mm

Vitesse de déplacement 2,5 - 5,0 km/h

Tension nominale 36 VCC

Poids net Avec la lame de tondeuse

droite installée

42,6 - 46,4 kg

Degré de protection IPX4

 



 

 

plus lourde, conformément à la procédure EPTA 01/2014, sont indiquées dans le tableau.

Batterie applicable

BL1815N / BL1820 / BL1820B / BL1830 / BL1830B / BL1840 / BL1840B / BL1850 / BL1850B / BL1860B

• Certaines batteries répertoriées ci-dessus peuvent ne pas être disponibles selon la région où vous résidez.

AVERTISSEMENT : N’utilisez que les batteries répertoriées ci-dessus. L’utilisation de n’importe quelle

autre batterie peut provoquer des blessures et/ou un incendie.

AVERTISSEMENT : N’utilisez pas de source d’alimentation câblée comme un adaptateur de batterie

ou un support d’alimentation portable avec cette machine.-

rait gêner le fonctionnement et provoquer des blessures corporelles.

Symboles



d’être utilisés pour l’appareil. Veillez à comprendre leur



Veuillez être prudent et rester attentif.

Lire le mode d’emploi.





La distance entre l’outil et les personnes

présentes doit être d’au moins 15 m.



près de la lame sous la tondeuse. Les

lames continuent de tourner une fois le

moteur coupé.

Retirez la clé de sécurité avant d’inspec-



laisser sans surveillance ou de ranger la

tondeuse.

Risque électrique. Le contact avec l’eau

présente un risque d’électrocution.

Ne pas verser d’eau.

Ni-MH

Li-ion



uniquement

En raison de la présence de composants

dangereux dans l’équipement, les déchets

d’équipements électriques et électro-

niques, les accumulateurs et les batteries

peuvent avoir un impact négatif sur l’envi-

ronnement et la santé humaine.



électroniques ou les batteries avec les

ordures ménagères !

Conformément à la directive européenne

relative aux déchets d’équipements élec-

triques et électroniques et aux déchets

d’accumulateurs et de batteries, ainsi qu’à

son adaptation à la législation nationale,

les déchets d’équipements électriques,

les batteries et les accumulateurs doivent

être collectés séparément et déposés

dans un point de collecte distinct pour

déchets urbains, conformément aux régle-

mentations en matière de protection de

l’environnement.

-

belle à roulettes barrée sur l’équipement.

La page charge ...

Makita DLM537 Manuel utilisateur

Makita DLM537 Manuel utilisateur

dans d''autres langues

Documents connexes

Autres documents