Mi-T-M Propane Portable Heater Le manuel du propriétaire

Propane Portable Heater Manual 1

CAUTION

RISK OF INJURY! READ ENTIRE MANUAL BEFORE OPERATING!

THIS MANUAL IS AN IMPORTANT PART OF THE PORTABLE HEATER

AND MUST REMAIN WITH THIS UNIT!

Propane

Portable Heaters

OPERATOR'S MANUAL

MH-0060-LM10

MH-0150-LM10

MH-0150-LMT0

MH-0060-LM10, MH-0150-LM10 : USA & CANADA

MH-0150-LMT0 : USA ONLY

®

C US

247218

2 Propane Portable Heaters Manual

GENERAL HAZARD WARNING: FAILURE TO COMPLY WITH THE PRECAUTIONS AND

INSTRUCTIONS PROVIDED WITH THIS HEATER, CAN RESULT IN DEATH, OR SERIOUS

BODILY INJURY AND PROPERTY LOSS OR DAMAGE FROM HAZARDS OF FIRE,

EXPLOSION, BURN, ASPHYXIATION, CARBON MONOXIDE POISONING, AND / OR

ELECTRICAL SHOCK.

ONLY PERSONS WHO CAN UNDERSTAND AND FOLLOW THE INSTRUCTIONS SHOULD USE

OR SERVICE THIS HEATER.

IF YOU NEED ASSISTANCE OR HEATER INFORMATION SUCH AS AN INSTRUCTIONS

MANUAL, LABEL, ETC. CONTACT THE MANUFACTURER.

WARNING: FIRE, BURN, INHALATION, AND EXPLOSTION HAZARD. KEEP SOLID

COMBUSTIBLES, SUCH AS BUILDING MATERIALS, PAPER OR CARDBOARD, A SAFE

DISTANCE AWAY FROM THE HEATER AS RECOMMENDED BY THE INSTRUCTIONS. NEVER

USE THE HEATER IN SPACES WHICH DO OR MAY CONTAIN VOLATILE OR AIRBORNE

COMBUSTIBLES, OR PRODUCTS SUCH AS GASOLINE, SOLVENTS, PAINT THINNER, DUST

PARTICLES OR UNKNOWN CHEMICALS.

WARNING: NOT FOR HOME OR RECREATIONAL VEHICLE USE.

TABLE OF CONTENTS

INTRODUCTION. .............................................................................................................................3

IMPORTANT!. ..................................................................................................................................3

IMPORTANT SAFETY INSTRUCTIONS...................................................................................................4

PORTABLE HEATER FEATURES. ............................................................................................................9

PRODUCT FEATURES. ...................................................................................................................9

PROPANE INFORMATION. ..............................................................................................................9

PORTABLE HEATER SPECIFICATIONS. ...............................................................................................10

GENERAL SAFETY INFORMATION. .....................................................................................................11

IMPORTANT SAFETY INFORMATION. .......................................................................................... 12

OPERATION. ........................................................................................................................................... 14

REFILLING THE LP CYLINDER. .................................................................................................... 14

CHECKING FOR LEAKS. ..............................................................................................................15

VENTILATION. ...............................................................................................................................15

LIGHTING INSTRUCTIONS (MODELS MH-0060-LM10, MH-0150-LM10). ..................................15

LIGHTING INSTRUCTIONS (MODELS MH-0150-LMT0). .............................................................15

SHUTDOWN INSTRUCTIONS. ......................................................................................................16

TEST FIRING THE HEATER. .......................................................................................................... 16

STORAGE. .....................................................................................................................................16

MAINTENANCE. .....................................................................................................................................17

MAINTENANCE AND STORAGE. ..................................................................................................17

TROUBLESHOOTING. ...........................................................................................................................18

STATEMENT OF WARRANTY. ...............................................................................................................19

WARNING: This product can expose you to

chemicals including Lead, which is known to

the State of California to cause cancer and birth

defects or other reproductive harm. For more

information go to www.P65Warnings.ca.gov

WARNING

Propane Portable Heater Manual 3

IMPORTANT!

A "DANGER, WARNING or CAUTION" safety warning will be surrounded by a "SAFETY ALERT BOX". This

box is used to designate and emphasize Safety Warnings that must be followed when operating this heater.

Accompanying the safety warnings are "Signal Words" which designate the degree or level of hazard seri-

ousness. The "Signal Words" used in this manual are as follows:

DANGER: INDICATES AN IMMINENTLY HAZARDOUS SITUATION WHICH, IF NOT AVOIDED, WILL

RESULT IN DEATH OR SERIOUS INJURY.

WARNING: INDICATES A POTENTIALLY HAZARDOUS SITUATION WHICH, IF NOT AVOIDED,

COULD RESULT IN DEATH OR SERIOUS INJURY.

CAUTION: INDICATES A POTENTIALLY HAZARDOUS SITUATION WHICH, IF NOT AVOIDED MAY

RESULT IN MINOR OR MODERATE INJURY OR DAMAGE TO THE HEATER.

The symbols set below are "Safety Alert Symbols". These symbols are used to call attention to items or

procedures that could be dangerous to you or other persons using this equipment.

ALWAYS PROVIDE A COPY OF THIS MANUAL TO ANYONE USING THIS EQUIPMENT. READ ALL

INSTRUCTIONS IN THIS MANUAL AND ANY INSTRUCTIONS SUPPLIED BY MANUFACTURERS

OF SUPPORTING EQUIPMENT BEFORE OPERATING THE PORTABLE HEATER AND ESPECIALLY

POINT OUT THE "SAFETY WARNINGS" TO PREVENT THE POSSIBILITY OF PERSONAL INJURY

TO THE OPERATOR.

INTRODUCTION

Congratulations on the purchase of your new Mi-T-M® Portable Heater! You can be assured your Mi-T-M®

Portable Heater was constructed with the highest level of precision and accuracy. Each component has

been rigorously tested by technicians to ensure the quality, endurance and performance of this heater.

This operator's manual was compiled for your benet. By reading and following the simple safety, installa-

tion and operation, maintenance and troubleshooting steps described in this manual, you will receive years

of troublefree operation from your new Portable Heater. The contents of this manual are based on the latest

product information available at the time of publication. The Manufacturer reserves the right to make chang-

es in price, color, materials equipment, specications or models at any time without notice.

Once the unit has been uncrated, immediately write in the serial number of your unit in the space provided

below.

SERIAL NUMBER ________________________________

Inspect for signs of obvious or concealed freight damage. If damage does exist, le a claim with the trans-

portation company immediately. Be sure that all damaged parts are replaced and that the mechanical and

electrical problems are corrected prior to operation of the unit. If you require service, contact Mi-T-M

®

Cus-

tomer Service.

Mi-T-M

®

Corporation, 50 Mi-T-M Drive, Peosta, IA 52068

563-556-7484 / 800-553-9053 / Fax 563-556-1235

Monday - Friday 8:00 a.m. - 5:00 p.m. CST

Please have the following information available for all service calls:

1. Model Number

2. Serial Number

3. Date and Place of Purchase

4 Propane Portable Heaters Manual

Hazard Potential Consequence Prevention

RISK OF ELECTRIC

SHOCK OR

ELECTROCUTION

Serious injury or death could

occur if the portable heater is

not properly grounded. Your

heater is powered by electricity

and may cause electric shock or

electrocution if not used prop-

erly.

Electrical shock may occur if

portable heater is not operated

properly.

Serious injury or death may

occur if electrical repairs are at-

tempted by unqualied persons.

Serious injury could occur from

touching exposed metal parts.

These areas can remain hot for

some time after the heater is

turned off.

IMPORTANT SAFETY INSTRUCTIONS

Installation of this unit, including

all electrical connections, must

comply with all local, state and

national codes.

This product must be grounded.

Connect to a GFCI circuit breaker

when available. If the unit should

malfunction or breakdown,

grounding provides a path of least

resistance for electric current to re-

duce the risk of electric shock. Do

not ground to a gas supply line.

Improper connection of the

equipment-grounding conductor

can result in a risk of electrocu-

tion. Check with a qualied elec-

trician or service personnel if you

are in doubt as to whether the

system is properly grounded.

Always be certain the unit is re-

ceiving proper voltage. Specied

on the model plate of the heater.

Use only a three-prong, grunded

outlet and extension cord.

Keep all connections dry and

install the heater so that it is not

directly exposed to water spray,

rain, dripping water or wind.

Any electrical wiring or repairs

performed on this heater should

be done by Authorized Service

Personnel in accordance with Na-

tional and Local electrical codes.

Always unplug the heater when

not in use.

Never allow any part of your body

or other materials to make con-

tact with any exposed metal parts

on the heater.

READ ALL SAFETY WARNINGS BEFORE USING PORTABLE HEATER

RISK OF BURNS

NEVER LEAVE HEATER UNATTENDED WHILE BURNING, CONNECTED TO A POWER SOURCE,

OR WHILE CONNECTED TO A FUEL SOURCE

Propane Portable Heater Manual 5

Hazard Potential Consequence Prevention

RISK OF EXPLOSION OR

FIRE

Serious injury or death may

occur from normal electrical

sparks in motor and pressure

switch

Serious injury may occur if

the heater air inlet or outlet is

blocked.

Serious injury or death may oc-

cur if improper fuels are used.

Serious injury may occur if

heater is not placed on level

surface.

Always operate heater in a well

ventilated area free of ammable

vapors, combustible dust, gases

or other combustible materials.

Never place objects in front of air

inlet (rear) or air outlet (front) of

heater. Never use duct work in

front or at rear of heater. Keep all

combustible material away from

this heater.

The propane (LP) gas pressure

regulator and hose assembly

supplied with the heater must be

used without alteration

This heater is EXTREMELY HOT

while in operation.

Bulk fuel storage should be a

minimum of 25 ft. from heaters,

torches, portable generators, or

other sources of ignition. All fuel

storage should be in accordance

with federal, state, or local au-

thorities having jurisdiction.

Never move or handle heater

while still hot.

If equipped with a thermostat,

the heater may start at any time.

Always locate heater on a stable

and level surface.

Always keep away from children

and animals.

IMPORTANT SAFETY INSTRUCTIONS

NEVER LEAVE HEATER UNATTENDED WHILE BURNING, CONNECTED TO A POWER SOURCE,

OR WHILE CONNECTED TO A FUEL SOURCE

6 Propane Portable Heaters Manual

Hazard Potential Consequence Prevention

IMPORTANT SAFETY INSTRUCTIONS

RISK TO BREATHING Serious injury or death could

occur from failure to provide

proper ventilation according to

this manual.

This is a direct-red, forced heat-

er. It is primarily intended for use

for temporary heating of build-

ings under construction,alteration

or repair. Direct-red means that

all of the combustion products

of the heater enter the heated

space. This appliance does pro-

duce small amounts of carbon

monoxide. Carbon monoxide is

toxic. Humans can tolerate small

amounts of carbon monoxide,

and precautions should be taken

to provide proper ventilation.

Early signs of carbon monox-

ide poisoning resemble the u.

Symptoms of improper ventila-

tion are: * headache * dizziness

* burning of the nose and eyes *

nausea * dry mouth * sore throat

Use this heater only in well ven-

tilated areas! Provide at least a

three square foot (2,800 sq cm)

opening of outside air for every

100,000 BTU/hr of heater rating.

People with breathing problems

should consult a physician before

using the heater.

Carbon Monoxide Poisoning:

Early signs of carbon monox-

ide poisoning resemble u-like

symptoms such as headaches,

dizziness, and/or nausea. If you

have these symptoms, your heat-

ermay not be working properly.

Get fresh air at once! Have the

heater serviced. Some people are

more affected by carbon mon-

oxide than others. These include

pregnant women, those with

heart or lung problems,anemia,

or those under the inuence of

alcohol, or at high altitudes.

Never use this heater in living or

sleeping areas.

This is an unvented portable

heater. It uses air (oxygen) from

the area which it is used. Ample

combustion and ventilation must

be provided.

NEVER LEAVE HEATER UNATTENDED WHILE BURNING, CONNECTED TO A POWER SOURCE,

OR WHILE CONNECTED TO A FUEL SOURCE

Propane Portable Heater Manual 7

IMPORTANT SAFETY INSTRUCTIONS

! SAVE THESE INSTRUCTIONS !

FIRE, BURN, INHALATION, AND EXPLOSION HAZARD. KEEP COMBUSTIBLES, SUCH AS

BUILDING MATERIALS, PAPER OR CARDBOARD, A SAFE DISTANCE AWAY FROM THE

HEATER AS RECOMMENDED BY THESE INSTRUCTIONS. NEVER USE THE HEATER IN

SPACES WHICH CONTAIN PRODUCTS SUCH AS GASOLINE, SOLVENTS, PAINT THINNERS,

DUST PARTICLES, VOLATILE OR AIRBORNE COMBUSTIBLES, OR ANY UNKNOWN

CHEMICALS. THIS IS AN UNVENTED PORTABLE HEATER. IT USES AIR (OXYGEN) FROM THE

AREA IN WHICH IT IS USED. ADEQUATE COMBUSTION AND VENTILATION AIR MUST BE

PROVIDED. REFER TO VENTILATION.

WARNING: IF THE INFORMATION IN THIS MANUAL IS NOT FOLLOWED EXACTLY, A FIRE OR

EXPLOSION MAY RESULT CAUSING PROPERTY DAMAGE, PERSONAL INJURY OR LOSS OF

LIFE.

DO NOT STORE OR USE GASOLINE OR OTHER FLAMMABLE VAPORS AND LIQUIDS IN THE

VICINITY OF THIS OR ANY OTHER APPLIANCE.

AN LP CYLINDER NOT CONNECTED FOR USE SHALL NOT BE STORED IN THE VICINITY OF

THIS OR ANY OTHER APPLIANCE.

WHAT TO DO IF THE SMELL OF GAS IS PRESENT:

DO NOT attempt to light heater

Extinguish any open ame

Shut off gas to heater

If odor continues, contact your local gas supplier or re department.

Do not touch any electric switch, do not use any phone in your building

Immediately call your gas supplier from a neighbors phone. Follow the gas suppliers instructions

If you can not reach your gas supplier, call the re department

Service must be done by a qualied service agency or the gas supplier.

CALIFORNIA RESIDENTS: COMBUSTION BY-PRODUCTS PRODUCED WHEN USING THIS

PRODUCT CONTAIN CARBON MONOXIDE, A CHEMICAL KNOWN TO THE STATE OF

CALIFORNIA TO CAUSE CANCER AND BIRTH DEFECTS (OR OTHER REPRODUCTIVE HARM).

DO NOT OPERATE THIS HEATER UNTIL YOU HAVE READ, AND THOROUGHLY UNDERSTAND

THESE SAFETY AND OPERATING INSTRUCTION. FAILURE TO COMPLY WITH THE

PRECAUTIONS AND INSTRUCTIONS PROVIDED WITH THIS HEATER CAN RESULT IN DEATH,

SERIOUS BODILY INJURY, PROPERTY LOSS OR DAMAGE FROM THE HAZARDS OF FIRE,

EXPLOSION, BURNS, ASPHYXIATION OR CARBON MONOXIDE POISONING. ONLY PERSONS

WHO CAN READ AND UNDERSTAND THESE INSTRUCTIONS SHOULD USE OR SERVICE THIS

HEATER.

NEVER LEAVE HEATER UNATTENDED WHILE BURNING, CONNECTED TO A POWER SOURCE,

OR WHILE CONNECTED TO A FUEL SOURCE

8 Propane Portable Heaters Manual

WARNING

THE FOLLOWING PAGES CONTAIN OPERATING AND

MAINTENANCE INSTRUCTIONS.

DO NOT ATTEMPT TO OPERATE THIS PORTABLE HEATER

UNTIL YOU HAVE READ AND UNDERSTOOD ALL SAFETY

PRECAUTIONS AND INSTRUCTIONS LISTED IN THIS MANUAL.

INCORRECT OPERATION OF THIS UNIT CAN CAUSE SERIOUS

INJURY!!

DO NOT ALTER OR MODIFY THIS EQUIPMENT

IN ANY MANNER!

NEVER LEAVE HEATER UNATTENDED WHILE BURNING OR

WHILE CONNECTED TO A FUEL SOURCE

Propane Portable Heater Manual 9

PORTABLE HEATER FEATURES

PRODUCT FEATURES

• Portable, stable and fully assembled.

• Wind resistant and rain protected.

• Continuous spark ignition or piezo spark ignition.

• 100% safety shut-off system.

• Adjustable input ratings.

• Adjustable Height Controller.

PROPANE INFORMATION

The Propane (LP) cylinder must also be equipped with the following:

• A collar to protect the gas valve.

• A shut-off valve terminating a LP cylinder valve outlet as specied in the American National Standard

for Compressed Gas Cylinder Valve Outlets and Inlet Connections.

• A safety relief valve having direct communications with the vapor space of the LP cylinder.

• An arrangement of vapor withdrawal.

Gas Valve Knob

Base

Height Controller

Guard

Inner Shell

Outer Shell

Model Shown: MH-0150-LM10

NEVER LEAVE HEATER UNATTENDED WHILE BURNING, CONNECTED TO A POWER SOURCE,

OR WHILE CONNECTED TO A FUEL SOURCE

10 Propane Portable Heaters Manual

PORTABLE HEATER SPECIFICATIONS

Model MH-0060-LM10 MH-0150-LM10 MH-0150-LMT0

Rating BTU/Hr 40-50-60,000 120,000-150,000 150,000

Fuel Comsumption

Lbs/Hr

1.9 / 2.3 / 2.8 lbs per hr 5.5 / 6.2 / 6.9 lbs per hr 6.9 lbs per hr

Electrical Input 120V, 60 Hz 120V, 60 Hz 120V, 60 Hz

Manifold Pressure 11" W.C. 8.3" W.C. 8.3" W.C.

Amps 0.6 1.02 1.02

Size (L x W x H) 18.1" x 7.1" x 13.0" 25.1" x 8.7" x 15.4" 25.1" x 8.7" x 15.4"

Net Weight (Lbs) 11.2 17.6 19.8

NEVER LEAVE HEATER UNATTENDED WHILE BURNING, CONNECTED TO A POWER SOURCE,

OR WHILE CONNECTED TO A FUEL SOURCE

Propane Portable Heater Manual 11

WARNING: IMPROPER USE OF THIS HEATER CAN RESULT IN SERIOUS INJURY OR DEATH FROM

BURNS, FIRE, EXPLOSION, ELECTRICAL SHOCK AND /OR CARBON MONOXIDE POISONING.

This heater is designed and approved for use as a construction heater in accordance with the standard

for Gas-Fired Construction Heaters ANS Z83.7 * CSA 2.14-2017. CHECK WITH YOUR LOCAL FIRE

SAFETY AUTHORITY IF YOU HAVE ANY QUESTIONS ABOUT APPLICATIONS. Other standards govern

the use of fuel gasses and heating products for specic uses. Your local authority can advise you about

these.

WARNING: NOT FOR USE WITH DUCTWORK.

WARNING: NOT FOR HOME OR RECREATIONAL VEHICLE USE. THE HOSE ASSEMBLY SHALL BE

PROTECTED FROM TRAFFIC, BUILDING MATERIAL AND CONTACT WITH HOT SURFACES

BOTH DURING USE AND WHILE IN STORAGE.

IMPORTANT: Read this User's Manual carefully and completely before attempting to operate or service this

heater. Improper use of the heater can cause serious injury or death from re, explosion and carbon monox-

ide poisoning.

Every possible circumstance that may involve a hazard cannot be anticipated. The warnings in this manual

and attached to the unit are therefore not all-inclusive. If a procedure, work method or operating technique

not specically recommended by the manufacturer is used, you must be sure it is safe for you and others.

You should also insure that equipment will not be damaged or made unsafe by the operating or maintenance

method you choose. CHECK WITH YOUR LOCAL FIRE SAFETY AUTHORITY IF YOU HAVE ANY QUES-

TIONS ABOUT APPLICATIONS.

Other standards govern the use of fuel gases and heat producing products in specic applications. Your lo-

cal authority can advise you of these.You must provide the propane gas and cylinder(s). Use this heater only

with a propane vapor withdrawal supply system. Refer to Chapter 5 of the Standard for Storage and Han-

dling of Liqueed Petroleum Gas , ANSI/NFPA 58. Your local library or re department will have this booklet.

WARNING: AIR QUALITY HAZARD

• Do not use this heater for heating human living quarters

• Use of direct-red heaters in the construction environment can result in exposure to levels of CO,

CO

2

, and NO

2

considered to be hazardous to health and potentially life threatening

• Do not use in unventilated areas

• Know the signs of CO and CO

2

poisoning • Headaches, stinging eyes • Dizziness, disorientation •

Difculty breathing, feels of being suffocated

• Proper ventilation air exchange (OSHA 29 CFR 1926.57) to support combustions and maintain ac-

ceptable air quality shall be provided in accordance with OSHA 29 CFR Part 1926.154, ANSI A10.10

Safety Requirements for Temporary and Portable Space Heating Devices and Equipment used in the

Construction Industry or the Natural Gas and Propane Installation Codes CSA B149.1

• Periodically monitor levels of CO, CO

2

and NO

2

existing at the construction site – at the minimum at

the start of the shift and after 4 hours.

• Provide ventilation air exchange, either natural or mechanical, as required to maintain acceptable

indoor air quality

• Ensure that the ow of combustion and ventilation air exchanges cannot become obstructed

• As the building “tightens up” during the construction phase ventilation may need to be increased

GENERAL SAFETY INFORMATION

NEVER LEAVE HEATER UNATTENDED WHILE BURNING, CONNECTED TO A POWER SOURCE,

OR WHILE CONNECTED TO A FUEL SOURCE

12 Propane Portable Heaters Manual

GENERAL SAFETY INFORMATION

USA 8-Hr Time weighted average (OSHA 29 CFR 1926.55 App A)

USA – Ceiling Limit (Short Term Exposure Limit = 15 minutes)

Canada 8-hr time weighted average WorkSafe BC OHS Guidelines Part 5.1 and Ontario Work¬places Reg

833

Canada STEL (15 minutes Reg 833/1 hour WSBC) WorkSafe BC OHS Guidelines Part 5.1 and Ontario Work-

places Reg 833

Note: Installation of this appliance at altitudes above 2000 ft (610 m) shall be in accordance with local codes, or in the ab-

sence of local codes, the National Fuel Gas Code, ANSI Z223.1/NFPA 54, or National Standard of Canada, Natural Gas and

Propane Installation Code, CSA B149.1.

IMPORTANT SAFETY INFORMATION

1. Children should be kept away.

2. Always maintain proper clearance from combustible materials.

3. Minimum clearance should be: Sides - 24” Top - 36” Front - 72”

4. Heater must be placed on level and solid footing.

5. Never place anything, including clothes or other ammable items on heater.

6. Do not modify heater, or operate a heater that has been modied.

7. Adequate clearance for accessibility, combustion and ventilation (air supply) must be maintained at all times

when heater is operating.

8. Service and repair should be performed by a qualied service person. The heater should be inspected

before each use, and at least annually by a qualied person. More frequent cleaning may be required as

necessary. Do not service heater while hot or operating.

9. Never connect heater to an unregulated gas supply.

10. Use only the electrical/power cord specied. Electrical and grounding connection must comply with National

Electrical Code - ANSI/NFPA 70 (USA) and CSA C22.1 Canadian Electrical Code, Part 1 (Canada).

11. To prevent injury, always wear gloves when handling heater. Never handle an operating or hot heater, as

severe burns may result.

NEVER LEAVE HEATER UNATTENDED WHILE BURNING, CONNECTED TO A POWER SOURCE,

OR WHILE CONNECTED TO A FUEL SOURCE

CO 50 ppm

CO

2

5000 ppm

NO

2

CO

2

NO

2

5 ppm

CO 25 ppm

CO

2

5000 ppm

NO

2

3 ppm (Reg 833)

CO 100 ppm

CO

2

15,000 ppm (WSCB)

30,000 ppm (Reg 833)

NO

2

1.0 ppm (WorkSafeBC)

5.0 ppm (Reg 833)

Propane Portable Heater Manual 13

GENERAL SAFETY INFORMATION

12. Use heater in accordance with all local codes. In the absence of local codes, refer to The National Fuel

Code, ANSI Z223.1

13. This heater is shipped from the factory for use with LP (propane) gas only. Do not convert to any other

gas. Installation must conform to local codes, or in their absence, with the standard for the Storage and

Handling of Liqueed Petroleum Gases ANSI/NFPA 58.

14. Use only the regulator and hose assembly provided with this heater. Inspect the regulator/hose assembly

prior to each use of the heater. If there is excessive abrasion or wear, or if the hose is cut, replace it with

the proper assembly shown in the parts list, prior to using the heater.

15. Gas supply connections should be checked by using a 50/50 soap and water solution. Never use a ame

to check for gas leaks.

16. Locate LP cylinder at least 6 feet from the heater, and do not direct heater discharge towards the LP cylinder

unless it is at least 20 feet from the heater.

17. The electrical connection and grounding must comply with the National Electrical Code, ANSI/NFPA 70.

Use only a properly grounded three (3) prong receptacle.

18. Do not restrict air inlet or outlet areas of the heater.

NEVER LEAVE HEATER UNATTENDED WHILE BURNING, CONNECTED TO A POWER SOURCE,

OR WHILE CONNECTED TO A FUEL SOURCE

14 Propane Portable Heaters Manual

OPERATION

REFILLING THE LP CYLINDER

ALL NEW LP CYLINDERS MUST BE PURGED BEFORE THE FIRST FILLING.

WARNING: PURGING AND FILLING OF LP CYLINDERS MUST BE PERFORMED BY PERSONNEL

WHO HAVE BEEN THOROUGHLY TRAINED IN ACCEPTED LP GAS INDUSTRY PROCEDURES.

FAILURE TO FOLLOW THESE INSTRUCTIONS MAY RESULT IN EXPLOSION, FIRE, SEVERE

PERSONAL INJURY OR DEATH.

1. Turn heater gas valve knob and LP cylinder valve to OFF position.

2. LP cylinder valve equipped with old style tting has LEFTHANDED THREADS. Turn tting CLOCKWISE to

loosen. Protect this tting when disconnected from LP cylinder.

3. Have your LP cylinder lled by your local Propane gas supplier.

4. Some LP cylinders have a bleed-off valve. This valve should be inspected for leaks after each lling of the

LP cylinder. Turn the valve clockwise to close.

5. Fasten full Propane tank and connect proper tting to LP cylinder valve by turning COUNTERCLOCKWISE.

6. With heater gas valve knob still in OFF position, turn ON LP cylinder valve and check for leaks with soap

solution.

CAUTION: PROPANE IS SAFE TO USE WHEN PROPERLY HANDLED. CARELESS HANDLING OF

THE LP CYLINDER COULD RESULT IN A FIRE AND/OR AN EXPLOSION. THEREFORE:

7. Always keep LP cylinder securely fastened and in an upright position.

8. Avoid tipping the LP cylinder on its side when connected to

a regulator, since this may cause damage to the diaphragm

in the regulator.

9. Handle valves with care.

10. Never connect an unregulated LP cylinder to a construction

heater.

11. Do not subject LP cylinder to excessive heat.

12. Tightly close the gas shutoff valve on the LP cylinder after

each use.

13. All ttings must be protected when disconnected from the

LP cylinder.

14. Never store an LP cylinder inside a building or in the vicinity

of any gas burning appliance.

CAUTION: THE DISCONNECTED TANK MUST NEVER

BE STORED IN A BUILDING, GARAGE OR ANY

OTHER ENCLOSED AREA.

15. Do not restrict inlet or outlet of heater. Heater is never to be used with ductwork.

Average Temp. (°F) MH-0060-LM10

20 or 100 lb cylinder

MH-150-LM10

100 lb. cylinder

MH-150-LMT0

100 lb. cylinder

32° 1 2 2

20° 1 2 2

10° 1 3 3

0° 1 3 3

-10° 2 Use larger tank Use larger tank

-20° 2 Use larger tank Use larger tank

Hose

Regulator

Supply Valve

Propane

Tank

NEVER LEAVE HEATER UNATTENDED WHILE BURNING, CONNECTED TO A POWER SOURCE,

OR WHILE CONNECTED TO A FUEL SOURCE

Propane Portable Heater Manual 15

CHECKING FOR LEAKS

To check for leaks, make up a 50/50 solution of dish soap and water. Apply this solution to all gas con-

nections. If bubbles appear, there is a leak. If a leak is found, turn off the gas supply, and re-connect the

leaking connection. If the leak persists after several tries, contact Mi-T-M Customer Service at 800-553-

9053.

The installation of this heater must meet all local codes and/or gas utility requirements. In the absence of

local codes, the National Fuel Code ANSI Z223.1 should be followed.

The minimum clearances to any combustible construction materials must be maintained at all times.

VENTILATION

Always provide a fresh air opening in the heated space of at least three square feet (2,800 sq. cm.) for

each 100,000 BTU/Hr of heater output. For example, a MH-0150-LM10 will require:

a two-car garage door open 6 inches, or

a single car garage open 9 inches, or

two thirty two inch wide windows open 15 inches.

LIGHTING INSTRUCTIONS (MODELS MH-0060-LM10, MH-0150-LM10)

1. Connect power cord to a properly grounded three (3) prong 120V, 60 Hz, extension cord.

EXTENSION CORD WIRE REQUIREMENTS:

6 to 10 feet (1.8 to 3 meters) long, use 18 AWG conductor.

11 to 100 feet (3.4 to 30.53 meters) long, use 16 AWG conductor.

101 to 200 feet (30.8 to 61 meters) long, use 14 AWG conductor.

2. Connect heater to a proper LP cylinder.

3. Turn gas valve clockwise to OFF position.

4. Wait ve (5) minutes for any gas to clear. Smell for gas; if you do not smell gas, go to Step 5.

5. Push in and turn gas control knob counterclockwise to LOW/IGN position. This will light the burner. If

needed, keep pressing control knob until the burner lights.

6. Keep the valve knob depressed for at least 30 seconds after lighting the burner. After 30 seconds, release

valve knob.

7. If burner does not stay lit, repeat lighting procedure.

8. When burner stays lit, turn gas valve knob counterclockwise to desired setting.

LIGHTING INSTRUCTIONS (MODELS MH-0150-LMT0)

The theory of operation for the 150T thermostat is the incoming power is controlled by the thermostat, which

uses a resistance temperature detector (RTD ) to open and close a circuit to shut off the incoming power to

the circuit board. The circuit board controls a solenoid valve to control the gas ow to the nozzle and power

to the fan. [This is possible for this heater because it does not use a thermocouple to rectify ame presence.

Flame presence is rectied through the igniter.

1. Follow all safety, installation and ventilation instructions in this manual.

2. Position the heater on a stable and level surface, and be sure that no drafts blow into the inlet or outlet of

the heater.

3. Plug the power cord of the heater into a three hole grounded extension cord. Be sure that the extension

cord is at least 6 feet long, and is UL listed.

Up to 50 feet long, use 18 AWG rated cord.

OPERATION

NEVER LEAVE HEATER UNATTENDED WHILE BURNING, CONNECTED TO A POWER SOURCE,

OR WHILE CONNECTED TO A FUEL SOURCE

16 Propane Portable Heaters Manual

51 to 100 feet long, use 16 AWG rated cord.

101 to 200 feet long, use 14 AWG rated cord.

4. Following the extension cord requirements, plug the extension cord into a 120 volt/60 herts, three hole

grounded outlet.

5. Open gas supply valve slowly.

6. Rotate on/off switch to the ON position. Set thermostat to desired temperature. Thermostat setting may

be too low if heater does not start. Select a highter temperature and start heater.

SHUTDOWN INSTRUCTIONS

To shut off heater:

1. Turn gas valve knob clockwise to OFF position.

2. Turn gas supply OFF by turning LP cylinder valve clockwise to close.

3. Disconnect the power cord.

TEST FIRING THE HEATER

Test re your construction heater following the lighting instructions applicable to the gas control system

employed.

Leak test all gas connections with 50/50 soap and water solution prior to start-up. Soap bubbles indi-

cate a gas leak. DO NOT use a match or ame to test for gas leaks.

NOTE: Heater surface temperature must be cold before initiating service, cleaning or storage.

STORAGE

Always disconnect the heater from the LP cylinder before putting the heater into storage. If for any

reason the heater is to be stored indoors, the tank MUST be disconnected from the LP cylinder, and the

cylinder stored outdoors in a well-ventilated area, out of the reach of children, and in accordance with

the Standard for Storage and Handling of Liqueed Gases, ANSI/NFPA 58 - latest edition. The plastic

valve plug or valve cover supplied with the cylinder must be re-installed on the valve to protect the tting

from damage.

WARNING: NEVER STORE AN LP CYLINDER INSIDE OF A BUILDING, OR NEAR ANY OTHER GAS

OR OIL BURNING APPLIANCES.

NOTE: Installation and repair of this heater should be done by a qualied service person.

OPERATION

NEVER LEAVE HEATER UNATTENDED WHILE BURNING, CONNECTED TO A POWER SOURCE,

OR WHILE CONNECTED TO A FUEL SOURCE

Propane Portable Heater Manual 17

MAINTENANCE AND STORAGE

Inspect your heater before each use. Check all connections for leaks, following the procedure outlined in

this manual. Check the Regulator Hose for any cracks, breaks or wear. If the hose is damaged replace it

with the correct manufacturers part.

After use, always disconnect the heater from the cylinder, and store the heater separately from the tank.

Be sure to close the tank valve after use, and before storage.

Always store the propane cylinder outdoors, but not in an enclosed area. Never store the cylinder near

high heat, direct sunlight or open ames. Never store the cylinder indoors. The cylinder should be stored

outdoors in accordance with chapter 5 of the Standard for Storage and Handling of Liqueed Petroleum

Gasses (ANSI/INFPA 58).

Always keep your heater clean, inside and out.

Have heater inspected anually by a qualied service technician.

Place the plastic covers over the ttings the heater was supplied with when putting heater away for the

season.

Always store the heater in a clean, dry and safe place.

MAINTENANCE

NEVER LEAVE HEATER UNATTENDED WHILE BURNING, CONNECTED TO A POWER SOURCE,

OR WHILE CONNECTED TO A FUEL SOURCE

MH-0060-LM10, MH-0150-LM10

MH-0150-LMT0

18 Propane Portable Heaters Manual

TROUBLESHOOTING

SYMPTOM

Fan does not turn when electricity

is connected

Heater will not re (ignite)

Heater stops running by itself

PROBABLE CAUSE

1. No electric power to heater

2. Blades of fan in contact with

heater housing

3. Fan blades bent

4. Fan motor defective

1. No spark at module

2. Incorrect spark gap

3. Corroded electrode

1. Temperature inside heater is

too high, causing thermal switch

to shut down operation

2. Damaged control valve

3. Dust or debris accumulated in

heater

REMEDY

1. Check current at outlet. If volt-

age is correct, inspect extension

and power cords for cuts, frays or

breaks

2. Check housing for damage. Be

sure there ar no dents in the hous-

ing obstructing the fan

3. Straighten all fan blades

4. Replace Motor Assembly

1. Inspect module wire. Re-attach,

or tighten if loose. Inspect Spark

module, and replace if necessary.

Inspect all other electrical compo-

nents

2. Set plug gap to 0.16” (4mm)

3. Replace spark plug (Multi-

Bracket Assembly)

1. If heater input or output is

restricted, the inside temperature

can become too hot. Keep the

areas in front and behind heater

clear of obstructions

2. Replace control valve (Valve

Assembly)

3. Clean inside of heater

NEVER LEAVE HEATER UNATTENDED WHILE BURNING, CONNECTED TO A POWER SOURCE,

OR WHILE CONNECTED TO A FUEL SOURCE

Propane Portable Heater Manual 19

STATEMENT OF WARRANTY

Mi-T-M warrants this heater to the original retail purchaser only, to be free from defects in material and

workmanship for a period of

one (1) year from the date of initial purchase.

This product must be properly installed, maintained and operated in accordance with the instructions

provided. Mi-T-M requires reasonable proof of your date of purchase from an authorized retailer or dis-

tributor. Therefore, you should keep your sales slip, invoice, or cancelled check from the original pur-

chase.

EXCLUSIONS

1. This Limited Warranty shall be limited to the repair or replacement of parts, which prove defective Mi-

T-M shall determine at its reasonable discretion. This warranty does not include wear items: lters, vanes,

nozzles, and rotors.

2. This Limited Warranty does not cover any failures or operating difculties due to normal wear and tear,

accident, abuse, misuse, alteration, misapplication, improper installation or improper maintenance and

service by you or any third party. Failure to perform normal and routine maintenance on the heater, shipping

damage, damage related to insects, birds, or animals of any kind, and damage due to weather conditions

are also not covered.

3. In addition, the Limited Warranty does not cover damage to the nish, such as scratches, dents,

discoloration, rust or other weather damage, after purchase.

All transportation costs for the return of the damaged product or parts will be the responsibility of the

purchaser. Upon receipt of damaged item, Mi-T-M will examine the item and determine if defective. Mi-

T-M will repair or replace and return the item, freight pre-paid. If Mi-T-M nds the item to be in normal

operating condition, or not defective, the item will be returned freight collect.

This Limited Warranty is in lieu of all other express warranties. Mi-T-M disclaims all warranties for prod-

ucts that are purchased from sellers other than authorized retailers or distributors.

AFTER THE PERIOD OF THE ONE (1) YEAR EXPRESS WARRANTY EXPIRES, Mi-T-M DISCLAIMS ANY

AND ALL IMPLIED WARRANTIES, INCLUDING WITHOUT LIMITATION THE IMPLIED WARRANTIES

OF MERCHANTABILITY AND FITNESS FOR A PARTICULAR APPLICATION. FURTHER, Mi-T-M SHALL

HAVE NO LIABILITY WHATSOEVER TO PURCHASER OR ANY THIRD PARTY FOR ANY SPECIAL, INDI-

RECT, PUNITIVE, INCIDENTAL, OR CONSEQUENTIAL DAMAGES.

Mi-T-M assumes no responsibility for any defects caused by third parties. This Limited Warranty gives

the purchaser specic legal rights; a purchaser may have other rights depending upon where he or she

lives. Some states do not allow the exclusion or limitation of special, incidental or consequential damag-

es, or limitations on how long a warranty lasts, so the above exclusion and limitations may not apply to

you. Mi-T-M does not authorize any person or company to assume for it any other obligation or liability in

connection with the sale, installation, use, removal, return, or replacement of its equipment, and no such

representations are binding on Mi-T-M. Always be sure to specify model number and serial number when

making any claim with Mi-T-M.

For Service or Warranty Consideration, contact

Mi-T-M® Corporation, 50 Mi-T-M Drive, Peosta, IA 52068

563-556-7484 / 800-553-9053 / Fax 563-556-1235

Monday - Friday 8:00 a.m. - 5:00 p.m. CST

20 Propane Portable Heaters Manual

AVERTISSEMENT: Ce produit peut vous

exposer à des produits chimiques, tel que le

plomb, qui est reconnu par l’état de la Californie

comme étant une cause de cancer, d'anomalies

congénitales et d'autres problèmes liés à la

reproduction. Pour plus de renseignements,

aller à www.P65Warnings.ca.gov

AVERTISSEMENT

TABLE OF CONTENTS

IMPORTANT! ...........................................................................................................................................21

IMPORTANTES CONSIGNES DE SECURITE. ...................................................................................22

!GARDER CES INSTRUCTIONS!. ..........................................................................................................25

CARACTÉRISTIQUES. ...........................................................................................................................27

CARACTÉRISTIQUES DU PRODUIT. ............................................................................................27

INFORMATIONS SUR LE PROPANE. ............................................................................................27

SPÉCIFICATIONS. ..................................................................................................................................28

INFORMATIONS GÉNÉRALES SUR LA SÉCURITÉ. ............................................................................ 29

INFORMATIONS IMPORTANTES SUR LA SÉCURITÉ. .................................................................30

FONCTIONNEMENT. .............................................................................................................................. 32

REMPLISSAGE DU RÉSERVOIR DE GAZ PROPANE. .................................................................. 32

VÉRIFICATION DES FUITES. .........................................................................................................33

VENTILATION. ...............................................................................................................................33

INSTRUCTIONS POUR L’ALLUMAGE (MH-0060-LM10, MH-0150-LM10). ................................. 33

INSTRUCTIONS POUR L’ALLUMAGE (MH-0150-LMT0). .............................................................33

INSTRUCTIONS POUR L’ARRÊT. .................................................................................................34

VÉRIFICATION DE LA MISE EN FEU DU RADIATEUR. ................................................................. 34

ENTREPOSAGE. ...........................................................................................................................34

ENTRETIEN. ............................................................................................................................................35

ENTRETIEN ET ENTREPOSAGE. .................................................................................................. 35

DÉPANNAGE. .........................................................................................................................................36

La page est en cours de chargement...