Ducane 31311001 Manuel utilisateur

Customer Service: 1-800-DUCANES

# 27010331

YOU MUST READ THIS OWNER’S GUIDE

BEFORE OPERATING YOUR GAS GRILL

m WARNING

1. Do not store or use gasoline or other

flammable liquids or vapors in the

vicinity of this or any other appliance.

2. An LP cylinder not connected for use

shall not be stored in the vicinity of this

or any other appliance.

m WARNING: Follow all leak-check

procedures carefully in this manual prior

to barbecue operation. Do this even if

the barbecue was dealer-assembled.

NOTICE TO INSTALLER: These instructions

must be left with the owner and the owner

should keep them for future use.

THIS GAS APPLIANCE IS DESIGNED FOR

OUTDOOR USE ONLY.

m WARNING: Do not try to light this

appliance without reading the “Lighting

Instructions” section of this manual.

27010331 10/15/08 LP

US ENGLISH

FOR HOUSEHOLD USE ONLY.

SAVE THESE INSTRUCTIONS FOR

FUTURE REFERENCE.

GUÍA DEL PROPIETARIO DEL ASADOR DE GAS LICUADO DE PROPANO - PG 31

GUIDE DE L’UTILISATEUR DU GRILL À GAZ PL - PG 45

LP GAS GRILL OWNER'S MANUAL

3100 & 4100

m DANGER

If you smell gas:

1. Shut off gas to the appliance.

2. Extinguish any open flames.

3. Open lid.

4. If odor continues, keep away from the

appliance and immediately call your gas

supplier or your fire department.

Leaking gas may cause a fire or explosion

which can cause serious bodily injury or

death, or damage to property.

Assembly, Ensamblaje, Montage pg.9

2 www.ducane.com

DANGERS AND WARNINGS

mDANGER

Failure to follow the Dangers, Warnings and Cautions contained in this Owner’s Manual may result in serious bodily injury or

death, or in a fire or an explosion causing damage to property.

mWARNING

m Do not store a spare or disconnected liquid propane cylinder under or near this barbecue.

m Improper assembly may be dangerous. Please carefully follow the assembly instructions in this manual.

m After a period of storage, and/or non-use, the Ducane

®

gas barbecue should be checked for gas leaks and burner obstructions

before use. See instructions in this manual for correct procedures.

m Do not operate the Ducane

®

gas barbecue if there is a gas leak present.

m Do not use a flame to check for gas leaks.

m Combustible materials should never be within 24 inches of the top, back or sides of your Ducane

®

gas barbecue.

m Do not put a barbecue cover or anything flammable on, or in the storage area under the barbecue.

m Your Ducane

®

gas barbecue should never be used by children. Accessible parts of the barbecue may be very hot. Keep young

children away while it is in use.

m You should exercise reasonable care when operating your Ducane

®

gas barbecue. It will be hot during cooking and should

never be left unattended or moved while in operation.

m Should the burners go out while in operation, turn all gas valves off. Open the lid and wait five minutes before attempting to

relight using the lighting instructions.

m Do not use charcoal or lava rock in your Ducane

®

gas barbecue.

m Never lean over open grill or place hands or fingers on the front edge of the cooking box.

m Should a grease fire occur, turn off all burners and leave lid closed until fire is out.

m Do not enlarge valve orifices or burner ports when cleaning the valves or burners.

m The Ducane

®

gas barbecue should be thoroughly cleaned on a regular basis.

m Liquid propane gas is not natural gas. The conversion or attempted use of natural gas in a liquid propane unit or liquid

propane gas in a natural gas unit is dangerous and will void your warranty.

m Do not attempt to disconnect any gas fitting while your barbecue is in operation.

m Use heat-resistant barbecue mitts or gloves when operating barbecue.

m Keep any electrical supply cord and the fuel supply hose away from any heated surfaces.

m Combustion by-products produced when using this product contain chemicals known to the state of California to cause

cancer, birth defects, or other reproductive harm.

m Do not use this barbecue unless all parts are in place. The unit must be properly assembled according to the instructions

outlined in the “Assembly Guide” section.

m Remove all packing material before use.

m Do not build this model of grill in any built-in or slide in construction. Ignoring this Warning could cause a fire or an explosion

that can damage property and cause serious bodily injury or death.

m Proposition 65 Warning: Handling the brass material on this product exposes you to lead, a chemical known to the state of

California to cause cancer, birth defects or other reproductive harm.

(Wash hands after handling this product.)

m Do not use an outdoor cooking gas appliance for purposes other than intended.

LIQUID PROPANE GAS UNITS ONLY:

m Use the regulator that is supplied with your Ducane

®

gas barbecue.

m Do not attempt to disconnect the gas regulator or any gas fitting while your barbecue is in operation.

m A dented or rusty liquid propane cylinder may be hazardous and should be checked by your liquid propane supplier. Do not

use a liquid propane cylinder with a damaged valve.

m Although your liquid propane cylinder may appear to be empty, gas may still be present, and the cylinder should be

transported and stored accordingly.

m Do not use in a building, garage or any other enclosed area.

m If you see, smell or hear the hiss of escaping gas from the liquid propane cylinder:

1. Move away from liquid propane cylinder.

2. Do not attempt to correct the problem yourself.

3. Call your fire department.

3

WARRANTY, GARANTÍA, GARANTIE

Ducane Products, Co. hereby warrants to the ORIGINAL PURCHASER of this Ducane

®

Stainless Series gas grill that it will be free of defects in material and workmanship from

the date of purchase as follows:

Five-Year Limited Warranty

 •Stainlesssteelprimarygrillburners

 •SideBurnerInserts

 •Stainlesssteelrotisserieburners

Three-Year Limited Warranty

 •PorcelainEnameledcookinggrates

Two-Year Limited Warranty

 •Rotisseriemotor

 •Ignitionsystem

 •Allremainingparts

The above warranty period(s) applies only to grills used in a non-commercial setting when

assembled and operated in accordance with the printed instructions accompanying the grill.

Ducane may require valid proof of your date of purchase. Please retain your receipt of purchase

or invoice as reasonable proof.

This Limited Warranty shall be limited to repair or replacement of parts that prove defective

under normal, non-commercial use and which, on examination shall indicate, to Ducane’s

satisfaction, that they are defective. Before returning any parts, please contact Ducane’s

Customer Service at 1-800-DUCANES (1-800-382-2637).

If Ducane confirms the defect and approves the claim, Ducane will elect to replace such parts

without charge. If you are required to return defective parts, transportation charges must be

paid by you. Ducane will return parts to purchaser, freight or postage prepaid.

This Limited Warranty does not cover failures or operating difficulties due to accident, abuse,

misuse, alteration, misapplication, vandalism, improper installation, use in a commercial

enterprise, improper maintenance, including but not limited to damage caused by insects within

burner tubes, as described in the owner’s manual.

Deterioration or damage due to severe weather conditions, such as hail, hurricanes,

earthquakes, or tornadoes is not covered by this Limited Warranty.

Deterioration or discoloration due to exposure to chemicals, either directly or in the

atmosphere, is not covered by this Limited Warranty.

There are no other express warrants except as set forth herein and any applicable implied

warranties of merchantability and fitness are limited in duration to the period of coverage of this

express written Limited Warranty. Some regions do not allow limitation on how long an implied

warranty lasts, so this limitation may not apply to you.

Ducane is not liable for any special, indirect or consequential damages. Some regions do not

allow the exclusion or limitation of incidental and consequential damages, so this limitation or

exclusion may not apply to you.

Ducane does not authorize any person or company to assume for it any other obligation or

liability in connection with the sale, installation, use, removal, return or replacement of its

equipment; and no such representations are binding on Ducane.

This Limited Warranty applies only to products sold at and purchased from a retail entity

excluding on-line auction services.

DUCANE PRODUCTS CO.

Customer Service Center

1890 Roselle Road, Suite 308

Schaumburg, IL 60195

USA

For replacement parts call:

1-800-446-1071

www.ducane.com

®

Ducane Products, Co., por el presente documento garantiza al COMPRADOR ORIGINAL

de esta parrilla a gas de la Serie Inoxidable de Ducane

®

que estará libre de defectos de

materiales y fabricación desde la fecha de adquisición así:

Garantía limitada de cinco años

 •Rejillasparacocciónenaceroinoxidable

 •Quemadoresprimariosdelaparrillaenaceroinoxidable

 •Insertosdequemadoreslaterales

 •Quemadoresparaasadorenaceroinoxidable

Garantía limitada de tres años

 •Rejillasparacocciónporcenlanizadas

Garantía limitada de dos años

 •Motordelasador

 •Sistemadeencendido

 •Todaslasdemáspartes

Los anteriores períodos de garantía sólo se aplican a parrillas usadas en ambientes no

comerciales cuando sean ensambladas y operadas de acuerdo con las instrucciones impresas

que acompañan la parrilla.

Ducane puede solicitar una prueba válida de su fecha de adquisición. Por favor guarde su

recibo de compra o la factura como prueba razonable.

Esta Garantía Limitada se limitará a la reparación o reemplazo de partes que se pruebe que

estaban defectuosas bajo un uso normal y no comercial, y que, tras ser examinadas, indiquen

a satisfacción de Ducane que efectivamente están defectuosas. Antes de devolver cualquier

parte, por favor contacte al Servicio al Cliente de Ducane al 1-800-DUCANES (1-800-382-2637).

Si Ducane confirma el defecto y aprueba la reclamación, Ducane elegirá reemplazar dicha parte

sin ningún cargo. Si se le solicita que devuelva las partes defectuosas, los costos de transporte

deberán ser asumidos por usted. Ducane devolverá las partes al comprador con flete o timbre

pagado por anticipado.

Esta Garantía Limitada no cubre fallos o dificultades de operación debidos a accidentes,

abuso, mal uso, alteración, mal manejo, vandalismo, instalación inadecuada, uso en empresa

comercial, mantenimiento indebido, e incluye, pero no se limita, a daños causados por insectos

al interior de los tubos quemadores, como se describe en el manual del usuario.

El deterioro o daño debido a condiciones climáticas extremas, tales como granizo, huracanes,

terremotos o tornados no está cubierto por esta Garantía Limitada.

El deterioro o la decoloración debidos a la exposición a químicos, bien sea directamente o en la

atmósfera no están cubiertos por esta Garantía Limitada.

No hay ninguna otra garantía expresa salvo las que están contenidas en este documento,

y cualquier garantía implícita aplicable de comerciabilidad y adecuación está limitada a la

duración del período de cobertura de esta expresa Garantía Limitada. Algunas regiones no

admiten una limitación al tiempo de duración de una garantía implícita, de forma que esta

limitación no aplica para usted.

Ducane no es responsable por ningún daño especial, indirecto o resultante. Algunas regiones

no admiten la exclusión o limitación de daños incidentales o resultantes, de forma que esta

limitación podría no aplicar para usted.

Ducane no autoriza a ninguna persona o compañía a asumir en su nombre ninguna otra

obligación o responsabilidad en relación con la venta, instalación, uso, retiro, devolución o

reemplazo de este equipo; y ninguna de dichas representaciones obligan a Ducane.

Esta Garantía Limitada aplica únicamente a productos vendidos en y comprados de una

entidad detallista, excluyendo servicios de subasta en línea.

DUCANE PRODUCTS CO.

Customer Service Center

1890 Roselle Road, Suite 308

Schaumburg, IL 60195

USA

Para partes de repuesto llame a:

1-800-446-1071

www.ducane.com

®

Par la présente, Ducane Products, Co., garantie à l’ACHETEUR ORIGINAL du gril au gaz en

acier inoxydable Ducane

®

qu’elle sera sans vices de matériaux et de fabrication à partir de

la date d’achat, tel que suit:

Garantie Limitée de Cinq Ans

• Grildecuissonenacierinoxydable

• Brûleursprimaireenacierinoxydable

• Insertionsdubruleursducôté

• brûleursdetournebrocheenacierinoxydable

Garantie Limitée de trois Ans

• Grildecuissonémaillées

Garantie Limitée de deux ans

• Moteurdutournebroche

• systèmed’allumage

• Toutesautrespièces

La(Les) période(s) de garantie ci-haut mentionné s’applique seulement au grils personnel,

et non ceux qui sont utilisés dans un milieu commercial, quand assemblé et opéré selon les

instructions inclues avec le gril.

Ducane pourra exiger une preuve d’achat valable. Veuillez conserver votre preuve d’achat ou

votre facture comme preuve.

Cettegarantieseralimitéeàlaréparationouleremplacementdepiècesquis’avèrentêtre

défectueuxsousdesconditionsd’utilisationnormal,non-commercial,etqui,aprèsexam

indiquera,àlasatisfactiondeDucane’s,unedéfectuosité.Avantderetournerlespièces,veuillez

contacterleserviceaclientèledeDucaneau1-800-DUCANES(1-800-382-2637).

ISi Ducane confirme la défectuosité et approuve la demande, Ducane choisira de remplacer

sespiècessansfrais.Sivousêtesobligéderetournerdespiècesdéféctueueses,vousdevez

assumer tous les frais de transports, fret ou port-pré-payé.

Cette garantie limitée ne couvre pas les pannes ou les difficultés d’opération résultant

d’accidents, abus, emploi abusif ou mauvaise opération, vandalisme, mauvaise installation,

utilisation commerciale, mauvais entretien, incluant mais pas limitée aux dommages causés par

lesinsectesdanslestubesdebrûleurs,telquedécritesdansleguided’achat.

Ladétériorationoulesdommagesdûauxconditionssévèredetempérature,notamment,grêles,

ouragans, tremblements de terre , ou tornades ne sont pas couvert par cette garantie limitée.

Ladétériorationouladécolorationdûàuneexpositionauproduitschimique,directementou

dansl’atmosphère,nesontpascouverteparcettegarantielimitée.

Il n’y a pas d’autres garantie expresse à part celles détaillées et n’importe quelle garantie tacite

de qualité marchande et de compatibilité applicable est limitée à la durée de la période de

couverture de cette garantie expresse limitée. Certaines régions ne permettent pas la limitation

degarantietacite,donclalimitationnepourraitvousêtreapplicable.

Ducane n’est pas responsable des dommages, indirects ou conséquents. Certaines régions

ne permettent pas l’exclusion ou la limitation de dommages accessoires ou immatériels, donc,

l’exclusionoulalimitationci-hautmentionnéenepourraitvousêtreapplicable.

Ducane n’autorise aucune personne ou entreprise, d’assumer à son nom, n’important quelle

obligationouresponsabilitéreliéeàlavente,l’installation,l’utilisation,l’enlèvement,leretour

ou le remplacement de son équipement; et ce, notamment, aucune répresentations de ce genre

engage Ducane.

Cette garantie limitée s’applique seulement aux produits vendu par, ou procuré chez, un

détaillant,excluanttoussitesdeventeauxenchèresen-ligne.

DUCANE PRODUCTS CO.

Product Registration

P.O. Box 40530

Burlington, ON L7P 4W1

Para compras hechas en México

DUCANE PRODUCTS S.A. de C.V.

Marcella No. 338,

Colonia Americana

44160 México, C.P.

México

Para partes de repuesto llame a:

(52) (33) 3615-0736

www.ducane.com

®

Pourdespiècesderechange,appelezle:

1-800-265-2150

www.ducane.com

®

4 www.ducane.com

1.

2.

3.

6.

7.

8.

10.

9.

11.

12.

13.

14.

15.

16.

17.

18.

19.

20.

21.

22.

23.

24.

25.

26.

27.

28.

29.

4.

5.

Affinity_3100_LP_US

EXPLODED VIEW 3100

VIsIOn écLatéE, DIagrama DE DEsPIEcE

5

LIsta DEL DIagrama DE DEsPIEcE, LIstE DE La VIsIOn écLatéE

EXPLODED VIEW LIst 3100

Shroud Assembly1.

Warming Rack2.

Cooking Grates3.

Igniter Module4.

Igniter Heat Shield5.

Left Side Table6.

Grease Deflector7.

Cookbox8.

Rear Cross Brace9.

Left Side Panel10.

Front Upper Cross Brace11.

Igniter Electrode12.

Manifold Assembly13.

Control Panel14.

Control Knob15.

Door16.

Door Handle1 7.

Heat Distribution Plate18.

Burner Tube19.

Right Side Table20.

Tool Hook21.

Catch Pan22.

Heat Shield23.

Right Side Panel24.

Rear Panel25.

Front Lower Cross Brace26.

Base Panel27.

Caster28.

Locking Caster29.

Ensamble de la tapa

Rejilla de calentamiento

Parrillas de cocción

Módulo de encendido

Pantalla contra el calor del encendedor

Mesa lateral izquierda

Deflector de grasa

Caja de cocción

Riostra trasera

Panel izquierdo del bastidor

Riostra delantera superior

Electrodo de encendido

Ensamblaje del múltiple

Tablero de control

Perilla de control

Puerta

Asa de la puerta

Plato de distribución del calor

Tubo quemador

Mesa lateral derecha

Gancho de utensilios

Plato recolector

Pantalla contra el calor

Panel del lado derecho

Panel trasero

Riostra delantera inferior

Panel de la base

Rueda giratoria

Rueda giratoria con bloqueo

Assemblage du châssis

Grille de maintien au chaud

Grilles de cuisson

Module de l’allumeur

Protection anti-chaleur de l’allumeur

Plan de travail gauche

Déflecteur de graisse

Cuve

Renfort latéral arrière

Panneau latéral gauche

Renfort latéral supérieur avant

Electrode de l’allumeur

Ensemble du collecteur

Panneau de commande

Bouton de commande

Porte

Poignée de la porte

Plaque de diffusion de la chaleur

Tube du brûleur

Plan de travail droit

Crochet porte-ustensiles

Egouttoir

Protection anti-chaleur

Panneau latéral droit

Panneau arrière

Renfort latéral inférieur avant

Panneau de base

Roulette

Roulette avec système de verrouillage

6 www.ducane.com

EXPLODED VIEW 4100

VIsIOn écLatéE, DIagrama DE DEsPIEcE

Affinity_4100_LP_US

18.

19.

20.

21.

22.

23.

24.

25.

26.

27.

28.

29.

1.

2.

3.

6.

7.

8.

10.

9.

11.

12.

13.

14.

15.

16.

17.

4.

5.

7

LIsta DEL DIagrama DE DEsPIEcE, LIstE DE La VIsIOn écLatéE

EXPLODED VIEW LIst 4100

Shroud Assembly1.

Warming Rack2.

Cooking Grates3.

Igniter Module4.

Igniter Heat Shield5.

Left Side Table6.

Grease Deflector7.

Cookbox8.

Rear Cross Brace9.

Left Side Panel10.

Front Upper Cross Brace11.

Igniter Electrode12.

Manifold Assembly13.

Control Panel14.

Control Knob15.

Door16.

Door Handle1 7.

Heat Distribution Plate18.

Burner Tube19.

Right Side Table20.

Tool Hook21.

Catch Pan22.

Heat Shield23.

Right Side Panel24.

Rear Panel25.

Front Lower Cross Brace26.

Base Panel27.

Caster28.

Locking Caster29.

Ensamble de la tapa

Rejilla de calentamiento

Parrillas de cocción

Módulo de encendido

Pantalla contra el calor del encendedor

Mesa lateral izquierda

Deflector de grasa

Caja de cocción

Riostra trasera

Panel izquierdo del bastidor

Riostra delantera superior

Electrodo de encendido

Ensamblaje del múltiple

Tablero de control

Perilla de control

Puerta

Asa de la puerta

Plato de distribución del calor

Tubo quemador

Mesa lateral derecha

Gancho de utensilios

Plato recolector

Pantalla contra el calor

Panel del lado derecho

Panel trasero

Riostra delantera inferior

Panel de la base

Rueda giratoria

Rueda giratoria con bloqueo

Assemblage du châssis

Grille de maintien au chaud

Grilles de cuisson

Module de l’allumeur

Protection anti-chaleur de l’allumeur

Plan de travail gauche

Déflecteur de graisse

Cuve

Renfort latéral arrière

Panneau latéral gauche

Renfort latéral supérieur avant

Electrode de l’allumeur

Ensemble du collecteur

Panneau de commande

Bouton de commande

Porte

Poignée de la porte

Plaque de diffusion de la chaleur

Tube du brûleur

Plan de travail droit

Crochet porte-ustensiles

Egouttoir

Protection anti-chaleur

Panneau latéral droit

Panneau arrière

Renfort latéral inférieur avant

Panneau de base

Roulette

Roulette avec système de verrouillage

8 www.ducane.com

PARTS LIST, LISTA DE PIEZAS, LISTE DES PIÉCES

0

1

2

1

0

1

2

3100

4100

3100

4100

3

2

16

4

24

4

12

28

4

1

2

1

4

2

16

4

24

4

12

28

4

2

4

1

A

D

B

D

L

R

1

0

1

0

1

3100

4100

9

ASSEMBLY, ENSAMBLAJE, ASSEMBLAGE

m CAUTION: Although we take every effort to ensure that the assembly process is as easy and as safe as possible, it is inherent

with fabricated steel parts that corners and edges can cause cuts if improperly handled during assembly procedures. Be careful

while handling any parts during assembly. It is strongly recommended that you protect hands with a pair of work gloves.

m PRECAUCIÓN: Aunque hacemos todo el esfuerzo posible en asegurarnos de que el proceso de ensamblaje sea lo más fácil y

seguro posible, es inherente a las partes fabricadas de acero que las esquinas y bordes pueden causar cortaduras si son mal

manipuladas durante los procedimientos de ensamblaje. Tenga cuidado al manipular cualquier parte durante el ensamblaje.

Enfáticamente le recomendamos protegerse las manos con un par de guantes de trabajo.

m ATTENTION: Bien que nous prenions toutes les mesures nécessaires afin de garantir que le processus de montage soit aussi

simpleetsûrquepossible,ilestinhérentauxpiècesfabriquéesenacierquelescoinsetlesextrémitéspuissentprovoquer

des coupures en cas de mauvaise manipulation au cours des procédures d’assemblage. Soyez prudent lors de toute

manipulationdepièceaucoursdumontage.Nousvousrecommandonsfortementdeprotégervosmainsavecunepairede

gants de travail.

PARTS LIST, LISTA DE PIEZAS, LISTE DES PIÉCES

3100

4100

1

3

1

4

10 www.ducane.com

2

1

ASSEMBLY, ENSAMBLAJE, ASSEMBLAGE

m Front

m Frente

m Avant

L

11

A

B

ASSEMBLY, ENSAMBLAJE, ASSEMBLAGE

Note: Do not fully tighten fasteners. Hand tight only until all components are installed.

Nota: No apriete los sujetadores del todo. Sólo apriete a mano hasta tanto estén instalados todos los componentes

Remarque: Neserrezpaslesfixationscomplètement.Serrezàlamainuniquementjusqu’àcequelatotalité

des éléments soit installée.

R

3

4

12 www.ducane.com

D

ASSEMBLY, ENSAMBLAJE, ASSEMBLAGE

5

3100

5

4100

6

13

ASSEMBLY, ENSAMBLAJE, ASSEMBLAGE

9

7 8

14 www.ducane.com

11

3100

11

4100

ASSEMBLY, ENSAMBLAJE, ASSEMBLAGE

10

15

ASSEMBLY, ENSAMBLAJE, ASSEMBLAGE

12

13

3100

13

4100

16 www.ducane.com

16

14 15

ASSEMBLY, ENSAMBLAJE, ASSEMBLAGE

17

ASSEMBLY, ENSAMBLAJE, ASSEMBLAGE

Note! Fully tighten all fasteners at this time.

¡Nota! Apriete completamente todos los

sujetadores ahora.

Remarque! Serrez la totalité des fixations

maintenant.

18

19 20

3100, 41003100, 4100

18 www.ducane.com

2322

ASSEMBLY, ENSAMBLAJE, ASSEMBLAGE

m Connect all wires to the ignition box in any

order. Depending on your model, one terminal

will not be used and will not have a wire

connection (A).

m Conecte todos los alambres en la caja de

ignición, en cualquier orden. Dependiendo en

le modelo de su asador, uno de los orificios

podrá ser inactivo y no necesitara la conexión

de un alambre (A).

m Raccordez tous les câbles au boîtier

d’allumage sans vous soucier de l’ordre selon

lequel vous effectuez les branchements. Selon

lemodèle,unterminalneserapasutiliséetne

disposera d’aucun branchement de câble (A).

(A)

3100 4100

21

AA

19

IMPORTANT

We urge you to read this manual carefully and to follow the recommendations enclosed.

This will help assure you of the most enjoyable and trouble-free operation of your new

Ducane

®

Gas Grill. We also advise you to keep this manual for future reference.

m WARNING: Your grill has been designed to operate using

only the gas specified on the rating plate. Do not attempt

to operate your grill on other gases. Failure to follow this

warning could lead to a fire hazard and bodily harm, and

will void your warranty.

m CAUTION: FOR YOUR SAFETY- Do not store any flammable

materials in any cabinets beneath the grill burner box or in

the vicinity of your grill.

m WARNING: Be sure to have your LP (propane) tank filled

by a reputable propane dealer. An incorrectly filled or

an overfilled LP tank can be dangerous. The overfilled

condition combined with the warming of the LP tank (a

hot summer day, tank left in the sun) can cause LP gas to

be released by the pressure relief valve on the tank since

the temperature increase causes the propane to expand.

LP gas released from the tank is flammable and can be

explosive.

m WARNING: (a) Do not store a spare gas supply cylinder under

or near this appliance; (b) Never fill the cylinder beyond 80

percent full; and (c) If the information in “(a)” and “(b)” is not

followed exactly, a fire causing death or serious injury may

occur.

m WARNING: Keep any electrical supply cord and the fuel

supply hose away from any heated surfaces.

m Do not build this model of grill in any built-in or slide in

construction. Ignoring this Warning could cause a fire or

an explosion that can damage property and cause serious

bodily injury or death.

CALIFORNIA PROPOSITION 65

m WARNING: The burning of gas cooking fuel generates

some by-products which are on the list of substances

known by the State of California to cause cancer or

reproductive harm. California law requires businesses to

warn customers of potential exposure to such substances.

To minimize exposure to these substances always operate

this unit according to the use and care manual, ensuring

you provide good ventilation when cooking with gas.

LOCATION OF YOUR GRILL

• YourDucane

®

Gas Grill is manufactured for outdoor use only! Any grill, charcoal

or gas, produces carbon monoxide while in operation and the gas should not be

allowed to accumulate in a confined area. Never operate this grill inside a building

or any enclosed area such as your home, garage or recreational vehicle.

• Whenlocatingyourgrill,chooseasafeoutdoorlocationawayfromflammableor

combustible surfaces and out of traffic paths. Ducane

®

strongly recommends a

24" clearance to combustible surfaces and 120" (10 feet) to any fuel containers or

propane cylinders.

• Consultyourlocalcodesforpossibleadditionalrestrictionsonlocationor

operation of your grill.

• Asyourgrillusesgas,itrequiresairtoburnproperly.Donotlocateyourgrillin

such manner to obstruct the flow of circulation and ventilation air around the grill.

• Whenpossible,adjustyourgrills’positiontoreducethelikelihoodofwindblowing

onto it.

m CAUTION: Never operate your grill under any overhead

combustible construction.

m CAUTION: This grill is not intended to be installed in or

attached to a recreational vehicle. It is also not intended to

be installed in or on a boat.

m WARNING: For your safety, do not store or use gasoline or

other flammable vapors and liquids in the vicinity of this

or any other appliance. Failure to follow this warning could

lead to a fire, explosion and bodily harm.

ASSEMBLY

Make sure your grill is assembled properly. Detailed assembly instructions are packed

with each grill giving specific assembly procedures for each model. Follow these

instructions carefully to ensure the correct and safe assembly of the grill.

LEVELING

It is important for the proper operation of the grill that it be located on a level surface.

SAFETY INFORMATION

INSTALLATION — Liquid Propane Gas Grills

20 www.ducane.com

TYPE OF GAS

• YourLPgrillisfactorybuilttooperateusingliquidpropaneonly.Neverattemptto

operate your grill on gases other than the type specified on the grill rating plate.

• Theregulatorsuppliedwithyourliquidpropanegasgrillissetfor11"water

column pressure and is for use with propane gas only. This regulator and the

factory-supplied hose assembly must be used when operating your grill with a 20

lb.LPgascylinder.

• Ifreplacementofthehoseand/orregulatorbecomesnecessary,factory-specified

parts are required.

• Forsafetyanddesignreasons,theconversionofaDucane

®

grill from operation

usingLPgastooperationusingnaturalgasrequiresthechangeoutoftheentire

gas supply system of the grill. If this becomes necessary, see your dealer for

additional information.

HANDLING LIQUID PROPANE GAS

Propane gas should be handled and stored with care. We suggest asking your propane

gas dealer, when having your tank filled, for a short course in handling, care and storage

of propane gas tanks. Most dealers will be glad to instruct you on how to store and

handle your tank. Make sure your tank is never stored inside! Keep it outside in a well-

ventilated area in an upright position away from your gas grill.

PORTABLE INSTALLATION

Complete portability is afforded to the grill head when mounted on the portable cart.

When so installed, it is necessary to use a 20 lb. capacity liquid propane tank. Use no

other size. The tank retainer is designed to accommodate only this size tank.

TYPE 1 CONNECTIVE COUPLING

AllDucaneliquidpropanegasgrillregulatorsareequippedwithaUL-listedtank

connection as per the latest edition of ANSI Z21.58. This will require a liquid propane

tank that is similarly equipped with a Type 1 connection in the tank valve. This Type 1

coupling allows you to make a fast and totally safe hookup between your gas grill and

yourliquidpropanetank.IteliminatesthechanceofleaksduetoaPOLfittingthatis

not properly tightened. Gas will not flow from the tank unless the Type 1 coupling is fully

engaged into the coupling.

m WARNING: The Type 1 connective coupling supplied with

your grill must not be replaced with a different type of

grill/tank connection system. Removal will result in loss

of warranty and, if improperly done, may result in serious

bodily injury or death, or in a fire or an explosion causing

damage to property.

m WARNING: Do not let the regulator hose loop up towards

the bottom of the burner box.

TYPE 1 CONNECTIVE COUPLING

1 Type 1 Valve

2 Hand Wheel

3 External Thread

4 Thermally Sensitive Nut

5 Propane Regulator

IMPORTANT

If there are local codes that apply to portable gas grills, you will have to conform to

them. Installation must conform with local codes or, in the absence of local codes,

witheithertheNationalFuelGasCode,ANSIZ223.1/NFPA54,NaturalGasand

Propane Installation Code, CSA B149.1, or Propane Storage and Handling Code,

B149.2.

• Checkthattheareaunderthecontrolpanelandthebottomtrayarefreefrom

debris that might obstruct the flow of combustion or ventilation air.

• TheareasaroundtheLPcylindermustbefreeandclearfromdebris.

CHECKING GAS LEAKS

Before operating your grill and after refueling, check carefully to be certain that all

connections are tight and there are no gas leaks. The easiest way to do this is to mix

up a little soapy water, like you would for washing dishes. Turn on the gas and brush

a little of the mixture around fittings. If new bubbles form, you have a leak!

TYPE OF LIQUID PROPANE TANK

ForLPgasgrills,theLPgassupplycylindertobeusedmustbeconstructedand

markedinaccordancewiththespecificationsforLPGasCylindersoftheUS

DepartmentofTransportation(DOT)ortheNationalStandardofCanada,CAN/

CSA-B339 Cylinders, Spheres and Tubes for the Transportation of Dangerous Goods.

This tank must be provided with a shut-off valve terminating in a liquid propane gas tank

valve outlet. The valve must be equipped with a Type 1 connection complying with the

latest edition of ANSI Z21.58.

INSTALLING LIQUID PROPANE TANK

ThePropanetankisinstalledinsidethebasecabinet.Lifttheliquidpropanetank

through the front doors into the cabinet. Rest the tank into the base opening. Position

the valve opening facing out to the rear of the grill.

Ducane recommends the use of cylinder manufacturer’s Manchester and Worthington,

with a 47.6 lb water capacity. Other cylinders may be acceptable for use with the

appliance provided they are compatible with the appliance retention means (see

illustration).

CONNECTION — Liquid Propane Gas Grills

IMPORTANT

The liquid propane tank supply system must:

1) Have a safety relief device having direct communication with the vapor space

of the tank.

2) Be arranged for vapor withdrawal.

3) Include a collar on the tank to protect the tank valve.

4 ) Be equipped with a listed overfilling protection device (OPD). The tank should

be 12 inches in diameter and 18½ inches tall.

5 ) Must be provided with a cylinder connection device compatible with the

connection for outdoor cooking appliances.

La page charge ...

Ducane 31311001 Manuel utilisateur

Ce manuel convient également à

Ducane 31311001 Manuel utilisateur

dans d''autres langues

Documents connexes