Weber SP310 Manuel utilisateur

NATURAL GAS GRILL OWNER’S GUIDE

Thank you for purchasing a Weber

®

grill.

You’ve made a wise investment.

Now take a few minutes and protect it by

registering your product online at

www.weber.com.

®

GUÍA DEL PROPIETARIO DE LA BARBACOA DE GAS NATURAL - PG. 29

MODE D’EMPLOI DU GRILL À GAZ NATUREL - PG. 51

57206

US - ENGLISH

07/13/12

E210 · E310 · SP310

YOU MUST READ THIS OWNER’S GUIDE BEFORE

OPERATING YOUR GAS GRILL.

m DANGER

If you smell gas:

1) Shut off gas to the appliance.

2) Extinguish any open ames.

3) Open lid.

4) If odor continues, keep away from the appliance and

immediately call your gas supplier or your re department.

Leaking gas may cause a re or explosion which can cause

serious bodily injury, death, or damage to property.

m WARNING

1) Do not store or use gasoline or other ammable liquids or

vapors in the vicinity of this or any other appliance.

2) An LP cylinder not connected for use shall not be stored

in the vicinity of this or any other appliance.

m WARNING: Carefully follow

all leak-check procedures

in this Owner’s Guide prior

to grill operation. Do this

even if the grill was dealer-

assembled.

m WARNING: Do not ignite

this appliance without

rst reading the BURNER

IGNITION sections of this

Owner’s Guide.

THIS GAS APPLIANCE IS

DESIGNED FOR OUTDOOR

USE ONLY.

NOTICE TO INSTALLER:

These instructions must be left

with the owner, who should

keep them for future use.

2 WWW.WEBER.COM

®

WARNINGS

m DANGER

Failure to follow the DANGERS,

WARNINGS and CAUTIONS contained in

this Owner’s Guide may result in serious

bodily injury or death, or may result in a

re or an explosion causing damage to

property.

WARNINGS:

m Improper assembly of grill may be

dangerous. Please follow the assembly

instructions carefully.

m Do not use this grill unless all parts

are in place. The grill must be properly

assembled according to the assembly

instructions.

m Your Weber

®

gas grill should never be

used by children. Accessible parts of

the grill may be very hot. Keep young

children away while grill is in use.

m Exercise caution when using your

Weber

®

gas grill. It will be hot during

cooking or cleaning, and should never

be left unattended, or moved while in

operation.

m Do not use charcoal or lava rock in

your Weber

®

gas grill.

m While igniting the grill or cooking,

never lean over open grill.

m Never place hands or ngers on the

front edge of the cookbox when the

grill is hot or the lid is open.

m Do not attempt to disconnect any gas

tting while your grill is in operation.

m Use heat-resistant barbecue mitts or

gloves when operating grill.

m Keep the cooking area clear of

ammable vapors and liquids such

as gasoline, alcohol, etc., and

combustible materials.

m Should the burners go out while grill

is in operation, turn all gas valves off.

Open the lid and wait ve minutes

before attempting to relight grill, using

the igniting instructions.

m Do not use the grill within 24 inches of

combustible materials. This includes

the top, bottom, back or sides of the

grill.

m Do not build this model of grill in

any built-in or slide-in construction.

Ignoring this WARNING could cause a

re or an explosion that can damage

property and cause serious bodily

injury or death.

m Only use this grill outdoors in a well-

ventilated area. Do not use in a garage,

building, breezeway or any other

enclosed area.

m Your Weber

®

gas grill shall not be

used beneath overhead combustible

construction.

m Your Weber

®

gas grill is not intended

to be installed in or on recreational

vehicles and/or boats.

m Do not store an extra (spare) or

disconnected liquid propane cylinder

under or near this grill.

m After a period of storage and/

or nonuse, the Weber

®

gas grill

should be checked for gas leaks and

burner obstructions before use. See

instructions in this Owner’s Guide for

correct procedures.

m Do not operate the Weber

®

gas grill if

there is a gas leak present.

m Do not use a ame to check for gas

leaks.

m Do not put a grill cover or anything

ammable on, or in the storage

area under, the grill while grill is in

operation or is hot.

m Natural gas is not liquid propane gas.

The conversion or attempted use of

liquid propane gas in a natural gas unit

or natural gas in a liquid propane gas

unit is dangerous and will void your

warranty.

m Keep any electrical supply cord and

the fuel supply hose away from any

heated surfaces.

m Do not enlarge valve orices or burner

ports when cleaning the valves or

burners.

m The Weber

®

gas grill should be

thoroughly cleaned on a regular basis.

m Should a grease re occur, turn off all

burners and leave lid closed until re

is out.

ADDITIONAL WARNINGS

FOR STATE OF CALIFORNIA:

m Combustion byproducts produced

when using this product contain

chemicals known to the state of

California to cause cancer, birth

defects, or other reproductive harm.

m Proposition 65 Warning: Handling the

brass material on this product exposes

you to lead, a chemical known to the

state of California to cause cancer,

birth defects or other reproductive

harm. (Wash hands after handling this

product.)

WWW.WEBER.COM

®

3

WARRANTY TABLE OF CONTENTS

Weber-Stephen Products LLC (Weber) hereby warrants to the

ORIGINAL PURCHASER of this Weber

®

gas grill that it will be free

of defects in material and workmanship from the date of purchase

as follows:

Aluminum castings: 25 years

(2 years on paint; excludes fading)

Stainless steel shroud: 25 years

Porcelain-enameled shroud: 25 years

Stainless steel burner tubes: 10 years

Stainless steel cooking grates: 5 years no rust through or burn through

Stainless steel Flavorizer

®

bars: 5 years no rust through or burn through

Porcelain-enameled

cast-iron cooking grates: 5 years no rust through or burn through

Porcelain-enameled cooking grates: 3 years no rust through or burn through

Porcelain-enameled Flavorizer

®

bars: 2 years no rust through or burn through

Infrared rotisserie burner: 2 years

All remaining parts: 2 years

when assembled and operated in accordance with the printed

instructions accompanying it. Weber may require reasonable proof

of your date of purchase. THEREFORE, YOU SHOULD RETAIN

YOUR SALES SLIP OR INVOICE.

This Limited Warranty shall be limited to the repair or replacement

of parts that prove defective under normal use and service and

which on examination shall indicate, to Weber’s satisfaction, they

are defective. Before returning any parts, contact the Customer

Service Representative in your area using the contact information

on our website. If Weber conrms the defect and approves the

claim, Weber will elect to replace such parts without charge. If you

are required to return defective parts, transportation charges must

be prepaid. Weber will return parts to the purchaser, freight or

postage prepaid.

This Limited Warranty does not cover any failures or operating

difficulties due to accident, abuse, misuse, alteration,

misapplication, vandalism, improper installation or improper

maintenance or service, or failure to perform normal and routine

maintenance, including but not limited to damage caused by insects

within the burner tubes, as set out in this Owner’s Guide.

Deterioration or damage due to severe weather conditions such

as hail, hurricanes, earthquakes or tornadoes, discoloration due to

exposure to chemicals either directly or in the atmosphere, is not

covered by this Limited Warranty.

There are no other express warrants except as set forth herein and

any applicable implied warranties of merchantability and tness are

limited in duration to the period of coverage of this express written

Limited Warranty. Some regions do not allow limitation on how long

an implied warranty lasts, so this limitation may not apply to you.

Weber is not liable for any special, indirect or consequential

damages. Some regions do not allow the exclusion or limitation of

incidental or consequential damages, so this limitation or exclusion

may not apply to you.

Weber does not authorize any person or company to assume

for it any other obligation or liability in connection with the sale,

installation, use, removal, return, or replacement of its equipment;

and no such representations are binding on Weber.

This Warranty applies only to products sold at retail.

WEBER-STEPHEN PRODUCTS LLC

Customer Service Center

90 West Hillcrest Boulevard, Suite 308

Schaumburg, IL 60195

USA

For replacement parts, call:

1-800-446-1071

Visit www.weber.com

®

, select your country of origin, and

register your grill today.

The grills illustrated in this Owner's Guide may have slight

differences than the model purchased.

WARNINGS ............................................................ 2

WARRANTY ........................................................... 3

TABLE OF CONTENTS ................................................... 3

SPIRIT

®

E210 NG EXPLODED VIEW ........................................ 4

SPIRIT

®

E310 NG EXPLODED VIEW ........................................ 6

SPIRIT

®

SP310 NG EXPLODED VIEW ....................................... 8

IMPORTANT INFORMATION ABOUT NATURAL GAS ......................... 10

WHAT IS NATURAL GAS? ..................................................................................10

NATURAL GAS — THE BASICS .............................................................................10

PIPING SPECIFICATIONS ..................................................................................10

STORAGE AND/OR NONUSE ...............................................................................10

PRESSURE TESTING GAS SUPPLY .........................................................................10

CONNECTION TESTING ...................................................................................10

US INSTALLATION CODES .................................................................................10

CANADIAN INSTALLATION .................................................................................10

CONNECTING TO THE GAS SUPPLY ...................................... 11

ALMOST READY TO GRILL .................................................................................11

CONNECTING THE FLEXIBLE HOSE TO GAS SUPPLY ..........................................................11

PREPARING TO USE YOUR GRILL ........................................12

WHAT IS A LEAK CHECK? .................................................................................12

PARTIAL DISASSEMBLY OF YOUR GRILL FOR A LEAK CHECK ...................................................12

CHECKING FOR GAS LEAKS ...............................................................................13

GRILLING TIPS & HELPFUL HINTS ....................................... 14

TIPS & HINTS ............................................................................................14

PREHEATING ............................................................................................14

COVERED COOKING .....................................................................................14

FLAVORIZER

®

SYSTEM ....................................................................................14

DRIPPINGS AND GREASE .................................................................................14

SAFETY CHECKS BEFORE USING YOUR GRILL .............................15

SAFETY FIRST ...........................................................................................15

SLIDE-OUT GREASE TRAY .................................................................................15

CATCH PAN AND DISPOSABLE DRIP PAN ....................................................................15

HOSE INSPECTION .......................................................................................15

MAIN BURNER IGNITION & USAGE .......................................16

METHODS OF BURNER IGNITION ...........................................................................16

MAIN BURNER IGNITION ..................................................................................16

TO EXTINGUISH BURNER .................................................................................16

TROUBLESHOOTING ................................................... 18

GENERAL TROUBLESHOOTING ............................................................................18

ANNUAL MAINTENANCE ...............................................19

KEEPING YOUR WEBER

®

GAS GRILL IN TIP-TOP SHAPE ........................................................19

BURNER FLAME PATTERN .................................................................................19

WEBER

®

SPIDER/INSECT SCREENS ........................................................................19

BURNER TUBE PORTS ....................................................................................19

BURNER TUBE CLEANING OR REPLACEMENT. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .20

STORAGE AND/OR NONUSE ...............................................................................24

ROUTINE MAINTENANCE ...............................................25

BEAUTIFUL—INSIDE AND OUT .............................................................................25

CLEANING THE OUTSIDE OF THE GRILL .....................................................................25

CLEANING THE INSIDE OF THE GRILL .......................................................................25

HOSE INSPECTION .......................................................................................25

MAINTAINING THE ELECTRONIC CROSSOVER

®

IGNITION SYSTEM ...............................................26

MEMO ...............................................................27

4 WWW.WEBER.COM

®

SPIRIT

®

E210 NG EXPLODED VIEW · DIAGRAMA DE DESPIECE · VUE ECLATEE

Spirit_E210_NG_US_042512

1

2

3

4

5

6

7

8

9

10

11

12

13

14

15

16

17

18

19

20

21

22

23

24

26

25

27

28

29

30

31

32

33

34

35

36

WWW.WEBER.COM

®

5

SPIRIT

®

E210 NG EXPLODED VIEW · DIAGRAMA DE DESPIECE · VUE ECLATEE

SPIRIT

®

E210 NG

EXPLODED VIEW LIST

1. Thermometer and Bezel

2. Logo Plate

3. Shroud Assembly

4. Warming Rack

5. Crossover

®

Burner Tube

6. Igniter Electrode

7. Burner Tube

8. Cookbox

9. Disposable Drip Pan

10. Left Frame Panel

11. Catch Pan

12. Catch Pan Holder

13. Matchstick Holder

14. Igniter Module

15. Control Knob

16. Igniter Button

17. Control Panel

18. Front Cross Brace

19. Door

20. Door Handle

21. Shroud Hardware

22. Cooking Grate

23. Flavorizer

®

Bar

24. Fold-Down Side Table

25. Fold-Down Assembly

26. Rear Cross Brace

27. Rear Panel

28. Manifold

29. Manifold Hose

30. Bulkhead

31. NG Hose

32. Right Frame Panel

33. Slide-Out Grease Tray

34. Bottom Panel

35. Caster

36. Locking Caster

SPIRIT

®

E210 NG

LISTA DEL DIAGRAMA DE DESPIECE

1. Termómetro y bisel

2. Placa del logotipo

3. Ensamblaje de la cubierta

4. Rejilla para calentar

5. Tubo del quemador Crossover

®

6. Electrodo de encendido

7. Tubo del quemador

8. Caja de cocción

9. Bandeja de goteo desechable

10. Panel izquierdo del bastidor

11. Plato recolector

12. Soporte del plato recolector

13. Portacerillos

14. Módulo de encendido

15. Perilla de control

16. Botón de encendido

17. Tablero de control

18. Refuerzo transversal delantero

19. Puerta

20. Asa de la puerta

21. Accesorios de la cubierta

22. Parrilla de cocción

23. Barra Flavorizer

®

24. Mesa lateral

25. Ensamble plegable

26. Refuerzo transversal posterior

27. Panel posterior

28. Múltiple

29. Manguera del múltiple

30. Bloque de conexiones

31. Manguera del gas natural

32. Panel derecho del bastidor

33. Bandeja deslizante de grasa

34. Panel inferior

35. Rueda giratoria

36. Rueda giratoria con bloqueo

SPIRIT

®

E210 NG

LISTE DE LA VUE ÉCLATÉE

1. Thermomètre et bec

2. Plaque du logo

3. Assemblage du châssis

4. Grille de maintien au chaud

5. Tube du brûleur Crossover

®

6. Électrode de l’allumeur

7. Tube du brûleur

8. Boîtier de cuisson

9. Égouttoir jetable

10. Panneau du châssis gauche

11. Égouttoir

12. Support de l’égouttoir

13. Porte-allumette

14. Module de l’allumeur

15. Bouton de commande

16. Bouton de l’allumeur

17. Panneau de commande

18. Croisillon avant

19. Porte

20. Poignée de porte

21. Quincaillerie du châssis

22. Grille de cuisson

23. Barre Flavorizer

®

24. Tablette latérale

25. Assemblage pliable

26. Croisillon arrière

27. Panneau arrière

28. Collecteur

29. Tuyau du collecteur

30. Cloison

31. Tuyau GN

32. Panneau du châssis droit

33. Plateau de récupération

des graisses amovible

34. Panneau inférieur

35. Roulette

36. Roulette à verrouillage

6 WWW.WEBER.COM

®

SPIRIT

®

E310 NG EXPLODED VIEW · DIAGRAMA DE DESPIECE · VUE ECLATEE

Spirit_E310_NG_US_042512

1

2

3

4

5

6

7

8

9

10

11

12

13

14

15

16

17

18

19

20

21

22

23

24

25

26

27

28

29

30

31

32

33

34

35

WWW.WEBER.COM

®

7

SPIRIT

®

E310 NG EXPLODED VIEW · DIAGRAMA DE DESPIECE · VUE ECLATEE

SPIRIT

®

E310 NG

EXPLODED VIEW LIST

1. Thermometer and Bezel

2. Logo Plate

3. Shroud Assembly

4. Warming Rack

5. Crossover

®

Burner Tube

6. Igniter Electrode

7. Burner Tube

8. Cookbox

9. Disposable Drip Pan

10. Left Frame Panel

11. Catch Pan

12. Catch Pan Holder

13. Matchstick Holder

14. Igniter Module

15. Control Knob

16. Igniter Button

17. Control Panel

18. Front Cross Brace

19. Door

20. Door Handle

21. Shroud Hardware

22. Cooking Grate

23. Flavorizer

®

Bar

24. Side Table

25. Rear Cross Brace

26. Rear Panel

27. Manifold

28. Manifold Hose

29. Bulkhead

30. NG Hose

31. Right Frame Panel

32. Slide-Out Grease Tray

33. Bottom Panel

34. Caster

35. Locking Caster

SPIRIT

®

E310 NG

LISTA DEL DIAGRAMA DE DESPIECE

1. Termómetro y bisel

2. Placa del logotipo

3. Ensamblaje de la cubierta

4. Rejilla para calentar

5. Tubo del quemador Crossover

®

6. Electrodo de encendido

7. Tubo del quemador

8. Caja de cocción

9. Bandeja de goteo desechable

10. Panel izquierdo del bastidor

11. Plato recolector

12. Soporte del plato recolector

13. Portacerillos

14. Módulo de encendido

15. Perilla de control

16. Botón de encendido

17. Tablero de control

18. Refuerzo transversal delantero

19. Puerta

20. Asa de la puerta

21. Accesorios de la cubierta

22. Parrilla de cocción

23. Barra Flavorizer

®

24. Mesa lateral

25. Refuerzo transversal posterior

26. Panel posterior

27. Múltiple

28. Manguera del múltiple

29. Bloque de conexiones

30. Manguera del gas natural

31. Panel derecho del bastidor

32. Bandeja deslizante de grasa

33. Panel inferior

34. Rueda giratoria

35. Rueda giratoria con bloqueo

SPIRIT

®

E310 NG

LISTE DE LA VUE ÉCLATÉE

1. Thermomètre et bec

2. Plaque du logo

3. Assemblage du châssis

4. Grille de maintien au chaud

5. Tube du brûleur Crossover

®

6. Électrode de l’allumeur

7. Tube du brûleur

8. Boîtier de cuisson

9. Égouttoir jetable

10. Panneau du châssis gauche

11. Égouttoir

12. Support de l’égouttoir

13. Porte-allumette

14. Module de l’allumeur

15. Bouton de commande

16. Bouton de l’allumeur

17. Panneau de commande

18. Croisillon avant

19. Porte

20. Poignée de porte

21. Quincaillerie du châssis

22. Grille de cuisson

23. Barre Flavorizer

®

24. Tablette latérale

25. Croisillon arrière

26. Panneau arrière

27. Collecteur

28. Tuyau du collecteur

29. Cloison

30. Tuyau GN

31. Panneau du châssis droit

32. Plateau de récupération

des graisses amovible

33. Panneau inférieur

34. Roulette

35. Roulette à verrouillage

8 WWW.WEBER.COM

®

SPIRIT

®

SP310 NG EXPLODED VIEW · DIAGRAMA DE DESPIECE · VUE ECLATEE

Spirit_SP310_NG_US_042512

1

2

3

4

5

6

7

8

9

10

11

12

13

14

15

16

17

18

19

20

21

22

23

24

25

26

27

28

29

30

31

32

33

34

35

36

WWW.WEBER.COM

®

9

SPIRIT

®

SP310 NG EXPLODED VIEW · DIAGRAMA DE DESPIECE · VUE ECLATEE

SPIRIT

®

SP310 NG

EXPLODED VIEW LIST

1. Thermometer and Bezel

2. Logo Plate

3. Shroud Assembly

4. Warming Rack

5. Crossover

®

Burner Tube

6. Igniter Electrode

7. Burner Tube

8. Cookbox

9. Disposable Drip Pan

10. Left Frame Panel

11. Condiment Basket

12. Catch Pan

13. Catch Pan Holder

14. Matchstick Holder

15. Igniter Module

16. Control Knob

17. Igniter Button

18. Control Panel

19. Front Cross Brace

20. Door

21. Door Handle

22. Shroud Hardware

23. Cooking Grate

24. Flavorizer

®

Bar

25. Side Table

26. Rear Cross Brace

27. Rear Panel

28. Manifold

29. Manifold Hose

30. Bulkhead

31. NG Hose

32. Right Frame Panel

33. Slide-Out Grease Tray

34. Bottom Panel

35. Caster

36. Locking Caster

SPIRIT

®

SP310 NG

LISTA DEL DIAGRAMA DE DESPIECE

1. Termómetro y bisel

2. Placa del logotipo

3. Ensamblaje de la cubierta

4. Rejilla para calentar

5. Tubo del quemador Crossover

®

6. Electrodo de encendido

7. Tubo del quemador

8. Caja de cocción

9. Bandeja de goteo desechable

10. Panel izquierdo del bastidor

11. Cesta para los condimentos

12. Plato recolector

13. Soporte del plato recolector

14. Portacerillos

15. Módulo de encendido

16. Perilla de control

17. Botón de encendido

18. Tablero de control

19. Refuerzo transversal delantero

20. Puerta

21. Asa de la puerta

22. Accesorios de la cubierta

23. Parrilla de cocción

24. Barra Flavorizer

®

25. Mesa lateral

26. Refuerzo transversal posterior

27. Panel posterior

28. Múltiple

29. Manguera del múltiple

30. Bloque de conexiones

31. Manguera del gas natural

32. Panel derecho del bastidor

33. Bandeja deslizante de grasa

34. Panel inferior

35. Rueda giratoria

36. Rueda giratoria con bloqueo

SPIRIT

®

SP310 NG

LISTE DE LA VUE ÉCLATÉE

1. Thermomètre et bec

2. Plaque du logo

3. Assemblage du châssis

4. Grille de maintien au chaud

5. Tube du brûleur Crossover

®

6. Électrode de l’allumeur

7. Tube du brûleur

8. Boîtier de cuisson

9. Égouttoir jetable

10. Panneau du châssis gauche

11. Panier à condiments

12. Égouttoir

13. Support pour égouttoir

14. Porte-allumette

15. Module de l’allumeur

16. Bouton de commande

17. Bouton de l’allumeur

18. Panneau de commande

19. Croisillon avant

20. Porte

21. Poignée de porte

22. Quincaillerie du châssis

23. Grille de cuisson

24. Barre Flavorizer

®

25. Tablette latérale

26. Croisillon arrière

27. Panneau arrière

28. Collecteur

29. Tuyau du collecteur

30. Cloison

31. Tuyau GN

32. Panneau du châssis droit

33. Plateau de récupération

des graisses amovible

34. Panneau inférieur

35. Roulette

36. Roulette à verrouillage

10 WWW.WEBER.COM

®

IMPORTANT INFORMATION ABOUT NATURAL GAS

TYPICAL PIPE INSTALLATION

3 4 5 6 7

2

1

8

This is a typical installation of a Weber

®

natural gas grill. Local codes may require different installations.

INSIDE HOUSE OUTSIDE HOUSE

1 Gas supply 3 Quick-disconnect 6 1/2" pipe nipple

2 Shutoff 4 3/8" pipe nipple 7 Locking shutoff

5 Reducing coupling 8 Do not use

WHAT IS NATURAL GAS?

Natural gas (NG) is often

called methane. Natural

gas is supplied by your local

utility and should be readily

available if your house is

already heated with gas.

NATURAL GAS — THE BASICS

There are various guidelines and safety factors that

you need to keep in mind when using natural gas (NG).

Carefully follow these instructions before using your

Weber

®

gas grill.

• Yournaturalgasgrillisfactorybuilttooperateusing

natural gas only. Never attempt to operate your grill on

gases other than the type specied on the grill rating

plates.

• ThisWeber

®

gas grill is designed for natural gas

only. Do not use liquid propane (LP) bottled gas. The

valves, orices and hose are for natural gas only.

• BeforeusinganNGgrill,youneedtomakesurethat

the branch supply line from your house to your grill is

properly installed.

• Notforusebychildren.

PIPING SPECIFICATIONS

Contact your local municipality for building codes

regulating outdoor gas grill installations. In the absence of

local codes, installation must conform to the latest edition

of the National Fuel Gas Code: ANSI Z223.1/NFPA 54, or

CAN/CGA-B149.1, Natural Gas and Propane Installation

Code. WE RECOMMEND THAT THIS INSTALLATION BE

DONE BY A PROFESSIONAL.

Following are some general requirements taken from the

code(s).

• Thisgrillisdesignedtooperateat7"ofwatercolumn

pressure (.2526 psi).

• Amanualshutoffvalvemustbeinstalledoutdoors,

immediately prior to the quick-disconnect.

• Anadditionalmanualshutoffvalveshouldbeinstalled

indoors in the branch fuel line, in an accessible

location near the supply line.

• Thequick-disconnectconnectstoa3/8"NPTthread

from the gas source. The quick disconnect tting

is a hand-operated device that automatically shuts

off the ow of gas from the source when the grill is

disconnected.

• Thequick-disconnectttingcanbeinstalled

horizontally or pointing downward, but never pointing

upward. Installing it with the open end pointing upward

can result in water and debris collecting in the quick-

disconnect tting.

• Thedustcovers(plasticplugssuppliedwithyourgrill)

help keep the open ends of the quick-disconnect tting

clean while disconnected.

• Whenmakingconnections,onlyusepipecompound

that is resistant to the action of natural gas.

• Theoutdoorconnectormustbermlyattachedto

rigid, permanent construction.

m WARNING: Do not route the ten-foot

hose under a deck. The hose must be

visible.

• Forthecorrectsizeandlengthofgaslinepiping,refer

to the latest edition of the National Fuel Gas Code:

ANSI Z 223.1/NFPA 54, or CAN/CGA-B149.1, Natural

Gas and Propane Installation Code.

• Gaspipingmaybecoppertubing,typeKorL;

polyethylene plastic tube, with a minimum wall

thickness of .062"; or standard weight (schedule 40)

steel or wrought-iron pipe.

• Coppertubingmustbetinlinedifthegascontains

more than 0.3 grams of hydrogen sulde per 100

cubic feet of gas.

• Plastictubingissuitableonlyforoutdoor,underground

use.

• Gaspipingincontactwithearth,oranyothermaterial

which may corrode the piping, must be protected

against corrosion in an approved manner.

• Undergroundpipingmusthaveaminimumof18"

cover.

STORAGE AND/OR NONUSE

For grills that have been stored or left unused for a while,

it is important to follow these guidelines:

• Thegasmustbeturnedoffatthenaturalgassupply

when the Weber

®

gas grill is not in use.

• IfstoringtheWeber

®

gas grill indoors, rst

DISCONNECT the gas supply.

• TheWeber

®

gas grill should be checked for gas leaks

and any obstructions in the burner tubes before it is

used. (Refer to “ANNUAL MAINTENANCE.”)

• Checkthattheareasunderthecontrolpanelandthe

slide-out grease tray are free from debris that might

obstruct the ow of combustion or ventilation air.

• Thespider/insectscreensshouldalsobe

checked for any obstructions. (Refer to “ANNUAL

MAINTENANCE.”)

PRESSURE TESTING GAS SUPPLY

• DisconnectyourWeber

®

gas grill when the gas supply

is being tested at high pressures. This appliance and

its individual shutoff valve must be disconnected from

the gas supply piping system during any pressure

testing of that system at test pressures in excess of

1/2 psig (>3.5 kPa).

• TurnoffyourWeber

®

gas grill when the gas supply is

being tested at low pressures. This appliance must

be isolated from the gas supply piping system by

closing its individual manual shutoff valve during any

pressure testing of the gas supply piping system at test

pressures equal to or less than 1/2 psig (≤3.5 kPa).

CONNECTION TESTING

All connections and joints must be thoroughly tested

for leaks in accordance with local codes and all listed

procedures in the latest edition of the National Fuel Gas

Code: ANSI Z223.1/NFPA 54, or CAN/CGA-B149.1.

US INSTALLATION CODES

Installation must conform with local codes or, in the

absence of local codes, with either the National Fuel Gas

Code, ANSI Z223.1/NFPA 54, Natural Gas and Propane

Installation Code, CSA B149.1; or Propane Storage and

Handling Code, B149.2; or the Standard for Recreational

Vehicles, ANSI A 119.2/NFPA 1192, and CSA Z240 RV

Series, Recreational Vehicle Code, as applicable.

CANADIAN INSTALLATION

These instructions, while generally acceptable, do not

necessarily comply with the Canadian Installation codes,

particularly with piping above and below ground. In

Canada, the installation of this appliance must comply

with local codes and/or Standards CAN/CGA-B149.1

(Installation Code for Natural Gas Burning Appliances and

Equipment).

WWW.WEBER.COM

®

11

CONNECTING TO THE GAS SUPPLY

ALMOST READY TO GRILL

A quick-disconnect device

connects your grill to the gas

supply. After you have made

the connection, a leak check

will need to be performed.

CONNECTING THE FLEXIBLE HOSE TO

GAS SUPPLY

A) Starting from inside the cabinet, route the exible gas

hose out of the opening in the rear panel (1).

B) Slide the collar of the quick-disconnect back (2).

C) Push male tting of the hose into the quick-disconnect

and maintain pressure. Slide the collar closed (3). If it

does not engage or lock, repeat procedure.

This procedure will produce a gas joint. Gas will not ow

unless the quick-disconnect is properly engaged. To

disconnect the hose, push collar back and pull out the

plug. (This automatically shuts off gas.)

The natural gas hose was attached during the

manufacturing process. We recommend that the

hose-to-gas manifold connection be leak tested, following

guidelines in this Owner’s Guide, prior to grill operation.

Note: Do not turn on gas source until you have performed

a leak check. Refer to “CHECKING FOR GAS LEAKS.”

1

2

3

NATURAL GAS HOSE CONNECTION

1 2 3 4 5 6

1 Shutoff valve 4 Dust covers

2 Pipe nipple 5 Male connection

3 Socket 6 Swivel connection

12 WWW.WEBER.COM

®

PREPARING TO USE YOUR GRILL

1

2

5

43

PARTIAL DISASSEMBLY OF YOUR GRILL

FOR A LEAK CHECK

In order to do the leak check, you need to have access

to the gas valves, which will require some simple grill

disassembly.

Conrm that Grill Is Off

A) Turn gas supply off at source.

B) Check that ALL burner control knobs are in the off (

)

position (1). Control knobs are shipped in the off ( )

position, but you should check to be sure that they

are turned off. Check by pushing control knobs in and

turning them clockwise. If they do not turn, they are

off. If they do turn, continue turning them clockwise

until they stop; then they are off. If your grill has a side

burner, make sure the side burner control knob is

turned off.

Remove Control Panel

You will need: A Phillips screwdriver.

A) Disconnect the two wires from the igniter button

located on the underside of the control panel (2).

NOTE: Pull from terminals at ends of wires.

B) Remove control knobs (3).

C) Remove the screws from the front of the control panel

with a Phillips screwdriver (4).

D) Carefully lift control panel up and then pull forward

away from frame (5).

Your grill is now ready for a leak check. Proceed to

“CHECKING FOR GAS LEAKS.”

WHAT IS A LEAK CHECK?

The fuel system in your grill

features many connections

and fittings. A leak check is a

reliable way to make sure that

no gas is escaping from any of

the connections or fittings.

Although all factory-made

connections have been

thoroughly checked for

gas leaks, it’s important to

perform a leak check before

using your grill for the first

time, as well as anytime you

disconnect and reconnect

a fitting and each time you

perform routine maintenance.

Safety must be considered when you are

deciding where to place and operate your

grill. Be sure to read the following warnings

before installing or using your grill.

WARNINGS:

m Only use this grill outdoors in a well-

ventilated area. Do not use in a garage,

building, breezeway or any other

enclosed area.

m Your Weber

®

gas grill shall not be

used beneath overhead combustible

construction.

m Your Weber

®

gas grill is not intended

to be installed in or on recreational

vehicles and/or boats.

m Do not use the grill within 24 inches of

combustible materials. This includes

the top, bottom, back or sides of the

grill.

m Keep the cooking area clear of

ammable vapors and liquids such

as gasoline, alcohol, etc., and

combustible materials.

m The entire cookbox gets hot when in

use. Do not touch.

m Do not move the Weber

®

gas grill when

operating or while grill is hot.

WWW.WEBER.COM

®

13

PREPARING TO USE YOUR GRILL

m DANGER

Do not use an open ame to check for

gas leaks. Be sure there are no sparks or

open ames in the area while you check

for leaks. Sparks or open ames will

result in a re or explosion, which can

cause serious bodily injury or death and

damage to property.

m WARNING: The gas connections of

your gas grill have been factory tested.

We do, however, recommend that you

leak check all gas connections before

operating your gas grill.

m WARNING: Perform these leak checks

even if your grill was dealer or store

assembled.

m WARNING: You should check for gas

leaks every time you disconnect and

reconnect a gas tting.

NOTE: All factory-made connections have been

thoroughly checked for gas leaks and the burners have

been ame-tested. As a safety precaution, however,

you should check all ttings for leaks before using your

Weber® gas grill. Shipping and handling may loosen or

damage a gas tting.

4

2

3

1

6

5

CHECKING FOR GAS LEAKS

You will need: A spray bottle or brush or rag and a soap

and water solution. (You can make your own soap and

water solution by mixing 20% liquid soap with 80% water;

or, you can purchase leak check solution in the plumbing

section of any hardware store.)

A) Turn gas supply on at source (1).

m WARNING: Do not ignite burners when

leak checking.

B) To check for leaks, wet ttings with the soap and water

solution, using a spray bottle, brush or rag. If bubbles

form, or if a bubble grows, there is a leak. Apply the

soap and water solution to the following connections:

a) Flexible hose-to-bulkhead connection (2).

b) Corrugated manifold hose-to-bulkhead

connection(3).

c) Corrugated manifold hose-to-manifold

connection(4).

m WARNING: If there is a leak at

connections (2, 3 or 4), turn off the

gas, tighten the tting with a wrench,

and recheck for leaks with soap and

water solution. If a leak persists

after tightening the tting, turn off

the gas. DO NOT OPERATE THE

GRILL. Contact the Customer Service

Representative in your area using the

contact information on our web site.

Log onto www.weber.com

®

.

d) Flexible hose-to-quick-disconnect connection (5).

e) Valves-to-manifold connections (6).

m WARNING: If there is a leak at

connections (5 or 6), turn off the

gas. DO NOT OPERATE THE GRILL.

Contact the Customer Service

Representative in your area using the

contact information on our web site.

Log onto www.weber.com

®

.

C) When leak checking is complete, turn gas supply off at

the source and rinse connections with water.

NOTE: Since some leak test solutions, including soap and

water, may be slightly corrosive, all connections should be

rinsed with water after checking for leaks.

Reinstall Control Panel

You will need: A Phillips screwdriver.

A) Align valve stems with holes in control panel. Position

top edge of control panel on tabs of frame assembly.

Push control panel down into position.

B) Fasten control panel with screws.

C) Place control knobs onto valve stems.

D) Connect the wires to the igniter button.

m WARNING: Make sure that all parts

are assembled and hardware is fully

tightened before operating the grill.

Your actions, if you fail to follow this

product warning, may cause a re,

an explosion, or structural failure

resulting in serious personal injury or

death as well as damage to property.

Now that the grill has been leak checked and gas supply

has been installed and checked for leaks in accordance

with the instructions, you are ready to grill.

14 WWW.WEBER.COM

®

GRILLING TIPS & HELPFUL HINTS

PREHEATING

Preheating the grill before grilling is important. To

preheat: Light your grill according to the instructions in

the Owner’s Guide; then turn all burners to start/high ( )

position, close the lid, and preheat until the temperature

reaches between 500° and 550°F (260° and 290°C), the

recommended broiling temperature. This will take 10 to 15

minutes depending on conditions such as air temperature

and wind. After preheating, you can adjust the individual

burners as desired.

m WARNING: Should the burners go out

while grill is in operation, turn all gas

valves off. Open the lid and wait ve

minutes before attempting to relight

grill, using the igniting instructions.

COVERED COOKING

All grilling is done with the lid down to provide uniform,

evenly circulated heat. With the lid closed, the gas grill

cooks much like a convection oven. The thermometer in

the lid indicates the cooking temperature inside the grill.

All preheating and grilling is done with the lid down. No

peeking — heat is lost every time you lift the lid.

FLAVORIZER

®

SYSTEM

The closed lid and Flavorizer

®

bars produce that

“outdoor” avor in the food. When meat juices drip from

the food onto the specially angled Flavorizer

®

bars, they

create smoke that gives foods an irresistible barbecued

avor. Thanks to the unique design of the burners, the

Flavorizer

®

bars, and the exible temperature controls,

uncontrolled are-ups are virtually eliminated, because

YOU control the ames.

DRIPPINGS AND GREASE

Because of the special design of the Flavorizer

®

bars

and burners, excess fats are directed down the slide-out

grease tray and into the catch pan. Disposable drip pans

that t the catch pan are available.

TIPS & HINTS

•Alwayspreheatthegrillbefore

cooking. Set all burners

on high heat and close lid;

preheat for 10 minutes, or

until thermometer registers

500°–550°F (260° – 290°C).

•Thetemperatureofyourgas

grill may run hotter than

normal for the first few uses.

•Recipegrillingtimesarebased

on outside temperatures of

70°F (20°C) and little or no

wind. Allow for more cooking

time on cold or windy days, or

at higher altitudes. Allow for

less cooking time in extremely

hot weather.

•Grillingconditionsmay

require adjustment of the

burner controls to attain the

correct cooking temperatures.

•Searmeatsandcookwiththe

lid down for perfectly grilled

food every time.

•Crowdingfoodontoacooking

grate means more time will

be required to cook the food.

•Trimexcessfatfromsteaks,

chops, and roasts, leaving

no more than a scant ¼ inch

(6.4mm) of fat. Less fat

makes cleanup easier, and is

a virtual guarantee against

unwanted flare-ups.

•Ingeneral,largepieces

of meat will require more

cooking time per pound than

small pieces of meat.

•Somefoods,suchasa

casserole or thin fish fillets,

will require a container for

grilling. Disposable foil pans

are very convenient, but any

metal pan with ovenproof

handles can also be used.

•Foodsincontainers,such

as baked beans, will require

more time if grilled in a deep

casserole than in a shallow

baking pan.

•Foodsplacedonthecooking

grate directly above burners

may require turning or moving

to a less hot area.

•Usetongsratherthanafork

for turning and handling

meats to avoid losing natural

juices.Usetwospatulasfor

handling large whole fish.

•Alwaysbesuretheslide-out

grease tray and catch pan are

clean and free from debris.

•Donotlinetheslide-out

grease tray with foil. This

could prevent the grease from

flowing into the catch pan.

•Ifanunwantedflare-up

should occur, turn all burners

off and move food to another

area of the cooking grate. Any

flames will quickly subside.

After flames subside, relight

thegrill.NEVERUSEWATER

TOEXTINGUISHFLAMESON

AGASGRILL.

•Usingatimerwillhelptoalert

you when “well done” is about

to become “overdone.”

WWW.WEBER.COM

®

15

SAFETY CHECKS BEFORE USING YOUR GRILL

When you are getting ready to grill, your

rst thought should always be safety.

Following are a few safety checks that

you should perform each time you grill.

SLIDE-OUT GREASE TRAY

Your grill was built with a grease collection system,

which funnels grease away from food and into removable

containers.

Check the slide-out grease tray for grease build-up each

time you use your grill. Remove excess grease with a

plastic scraper (1). Wash the grease tray with a soap and

water solution and rinse with water.

m CAUTION: Do not line the slide-out

grease tray with aluminum foil.

CATCH PAN AND DISPOSABLE DRIP PAN

Grease from the slide-out grease tray funnels into a

catch pan. Cleaning the catch pan is just as important as

cleaning the slide-out grease tray.

Check the catch pan for grease build-up each time you

use your grill. Remove excess grease with a plastic

scraper (2). Wash the catch pan with warm, soapy water

and rinse with water. To keep the catch pan cleaner

longer, you can line the catch pan with a Weber

®

disposable drip pan or with aluminum foil.

m WARNING: Check the slide-out grease

tray and catch pan for grease build-

up before each use. Remove excess

grease to avoid a grease re. A grease

re can cause serious bodily injury or

damage to property.

HOSE INSPECTION

The hose should be inspected routinely for any signs of

cracking (3).

m WARNING: Check hose before each

use of grill for nicks, cracking,

abrasions or cuts. If the hose is found

to be damaged in any way, do not use

the grill. Replace using only Weber

®

authorized replacement hose. Contact

the Customer Service Representative

in your area using the contact

information on our web site.

Log onto www.weber.com

®

.

SAFETY FIRST

It’ssensibleandsmarttoget

in the habit of performing

a few safety checks before

grilling.

2

3

1

2

4

3

16 WWW.WEBER.COM

®

Summary lighting instructions are inside

the cabinet door.

MAIN BURNER IGNITION & USAGE

2

5

1

4

3

MAIN BURNER IGNITION

Electronic Crossover

®

Ignition System

The electronic Crossover

®

ignition system ignites burner

1 with a spark from the igniter electrode inside the Gas

Catcher™ ignition chamber. You generate the energy for

the spark by pushing the igniter button. You will hear the

igniter clicking. Burner(s) 2 (and 3) can be lit after burner1

is lit.

A) Open the grill lid (1).

m DANGER

Failure to open the lid before igniting

the grill’s burners, or not waiting ve

minutes to allow the gas to clear if the

grill does not light, may result in an

explosive are-up which can cause

serious bodily injury or death.

B) Make sure ALL burner control knobs are turned off

(2). Check by pushing control knobs in and turning

them clockwise until they stop.

C) Turn the gas supply valve on (3).

D) Push burner 1 control knob in and turn it

counterclockwise to start/high ( ) position (4).

IMPORTANT: Always ignite burner 1 rst. The other

burner(s) ignite from burner 1.

E) Push and hold in the igniter button (5). You will hear

the igniter clicking.

F) Check that burner 1 is lit by looking through the

cooking grates. You should see a ame.

m WARNING: Do not lean over the open

grill.

m WARNING: If burner 1 fails to ignite

within ve seconds, stop, turn the

burner control knob to off and wait

ve minutes to allow the gas to clear

before you try again or light with a

match.

G) After burner 1 is lit, you can turn on burner 2 (and

burner 3).

TO EXTINGUISH BURNER

Push each burner control knob in and turn it clockwise to

the off ( ) position. Turn gas supply off at the source.

METHODS OF BURNER

IGNITION

There are two ways to ignite

burner 1. The first is by using

the electronic Crossover

®

ignition system built into your

grill. The second is with a

match.

Next are the steps for igniting

your grill using the electronic

Crossover

®

ignition system.

On the following page are

steps for igniting your grill

with a match.

Some batteries have a plastic

protective wrap around them.

This plastic must be removed

before you attempt to ignite

your grill with the electronic

Crossover

®

ignition system.

Do not confuse this plastic

with the battery label.

WWW.WEBER.COM

®

17

MAIN BURNER IGNITION

Lighting with a Match

A) Open the grill lid (1).

m DANGER

Failure to open the lid before igniting

the grill’s burners, or not waiting ve

minutes to allow the gas to clear if the

grill does not light, may result in an

explosive are-up which can cause

serious bodily injury or death.

B) Make sure ALL burner control knobs are turned off

(2). Check by pushing control knobs in and turning

them clockwise until they stop.

C) Turn the gas supply valve on (3).

D) Put match in the matchstick holder and strike match.

Insert matchstick holder with lit match down through

the cooking grates, past the Flavorizer

®

bars and next

to burner1 (4).

E) Push burner 1 control knob in and turn it

counterclockwise to start/high ( ) position (5).

IMPORTANT: Always ignite burner 1 rst. The other

burner(s) ignite from burner 1.

F) Check that burner 1 is lit by looking through the

cooking grates. You should see a ame.

m WARNING: Do not lean over the open

grill.

m WARNING: If burner 1 fails to ignite

within ve seconds, stop, turn the

burner control knob to off and wait

ve minutes to allow the gas to clear

before you try again.

G) After burner 1 is lit, you can turn on burner 2 (and

burner 3).

TO EXTINGUISH BURNER

Push each burner control knob in and turn it clockwise to

the off ( ) position. Turn gas supply off at the source.

1

2

4

3

5

MAIN BURNER IGNITION & USAGE

18 WWW.WEBER.COM

®

TROUBLESHOOTING

GENERAL TROUBLESHOOTING

PROBLEMS SOLUTIONS

Burner does not ignite when you push the igniter

button.

Be sure that there is gas ow to the burners by attempting to match light your burners. Refer to “MAIN BURNER

IGNITION—Lighting with a Match.” If match lighting is successful, the problem lies in the ignition system. Refer to

“MAINTAINING THE ELECTRONIC CROSSOVER

®

IGNITION SYSTEM.”

Be sure that wires are correctly inserted into terminals on igniter module. Check that the wires are connected to

terminals on igniter button under the control panel. Refer to “IGNITER MODULE WIRE GUIDE.”

If a new battery is installed, conrm that battery’s plastic wrapping has been removed. Verify that the battery is in good

condition and has been installed correctly. Refer to “MAINTAINING THE ELECTRONIC CROSSOVER

®

IGNITION

SYSTEM.”

Burner does not ignite, or ame is low in

high (

) position.

Fuel hose could be bent or kinked. Straighten fuel hose.

Burner ame pattern is erratic.

Flame is low when burner is on high (

) position.

Flames do not run the whole length of the

burnertube.

Clean burner ports that run down the entire length of burner tube. Refer to “ANNUAL MAINTENANCE.”

Burners burn with a yellow or orange ame, in

conjunction with the smell of gas.

Inspect spider/insect screens for possible obstructions. (Blockage of holes.) Clean spider/insect screens.

Refer to “ANNUAL MAINTENANCE.”

Experiencing are-ups.

m CAUTION: Do not line the slide-out

grease tray with aluminum foil.

Grill must be preheated with all burners on high for 10 to 15 minutes.

Clean the cooking grates and Flavorizer

®

bars thoroughly to remove grease. Refer to “ROUTINE MAINTENANCE.”

The slide-out grease tray may be dirty and is not allowing grease to ow into catch pan. Clean slide-out grease tray.

Inside of lid appears to be “peeling.”

(Resembles paint peeling.)

The inside of the lid is porcelain enamel or stainless steel. It is not painted. It cannot “peel.” What you are seeing is

baked-on grease that has turned to carbon and is aking off. THIS IS NOT A DEFECT. Clean thoroughly. Refer to

“ROUTINE MAINTENANCE.”

If problems cannot be corrected by using these methods, please contact the Customer Service Representative in your area using the contact information on our

web site. Log onto www.weber.com

®

.

WWW.WEBER.COM

®

19

ANNUAL MAINTENANCE

KEEPING YOUR

WEBER

®

GAS GRILL IN

TIP-TOP SHAPE

m DANGER

Failure to correct any problems described

on this page may result in a re, which

can cause serious bodily injury or death,

and cause damage to property.

To keep your Weber

®

gas grill performing as safely and

efficiently as on day one, we strongly recommend that you

inspect and clean the spider/insect screens and burner

tubes at least once a year. Below is important information

about these two areas of the grill that should undergo

annual maintenance.

If you observe an incorrect ame pattern or blocked

burner ports, proceed to the “BURNER TUBE

CLEANING OR REPLACEMENT” instructions on the

following pages.

BURNER FLAME PATTERN

The burner tubes in your Weber

®

gas grill were factory

set for the correct air and gas mixture. The correct ame

pattern is shown in illustration and described below:

• Burnertube(1)

• Tipsoccasionallyickeryellow(2)

• Lightblue(3)

• Darkblue (4)

Check burner ame pattern. If the ames do not match the

above description, it could be an indication that the spider/

insect screens have become dirty or blocked.

WEBER

®

SPIDER/INSECT SCREENS

The combustion air openings of the burner tubes (5) are

tted with stainless steel screens to help prevent spiders

and other insects from spinning webs and building nests

inside the venturi section (6) of the burner tubes. These

nests can obstruct the normal gas ow, and can cause gas

to ow back out of the combustion air openings (7). This

could result in a re in and around the burner valves, under

the control panel, causing serious damage to your grill.

NOTE: If a spider/insect screen becomes damaged or

cannot be cleaned, please contact the Customer Service

Representative in your area using the contact information

on our web site. Log onto www.weber.com®.

BURNER TUBE PORTS

Over time, from repeated use of the grill, the burner

tube ports will become dirty. Blocked and dirty ports can

restrict full gas ow. Following are ways to determine

whether burner tubes are dirty or blocked.

• Gasissmelledinconjunctionwithburneramesthat

appear yellow and lazy

• Grilldoesnotreachdesiredtemperature

• Grillheatsunevenly

• Oneormoreoftheburnersdonotignite

6

5

7

2

3

4

1

20 WWW.WEBER.COM

®

ANNUAL MAINTENANCE

9

8

7

5

43

6

1

2

BURNER TUBE CLEANING

OR REPLACEMENT

Conrm that Grill Is Off

A) Turn gas supply off at source and disconnect gas

tting.

B) Check that all burner control knobs are in the off

( )position. Check by pushing control knobs in and

turning them clockwise until they stop. If they do not

turn, they are already off. If they do turn, continue

turning them clockwise until they stop; then they are

off. If your grill has a side burner, make sure the side

burner control knob is turned off.

Remove Control Panel

You will need: A Phillips screwdriver.

A) Open cabinet door. Remove igniter wires from wire

clips on the inside left panel (1). Disconnect wires

from igniter module inside the cabinet(2).

NOTE: Do not disconnect by pulling on wires; pull

from terminals at ends of wires.

B) Remove cookbox components(3).

C) Remove control knobs(4).

D) Remove screws from the front of the control panel

with a Phillips screwdriver(5).

E) Carefully lift control panel up and then pull forward and

away from cookbox(6).

Remove Manifold

Youwillneed:APhillipsscrewdriver,two7/16"wrenches.

A) With the Phillips screwdriver, remove two screws

and two washers attaching manifold to front cross

brace(7).

B) Usingtwo7/16"wrenches,removetwoboltsandtwo

nuts attaching manifold to cookbox (8). Pull manifold

forward and away from burner tubes (9). Manifold will

remain attached to corrugated gas line(s). Be careful

not to let manifold scratch frame or door or kink the

attached corrugated gas line(s).

La page charge ...

Weber SP310 Manuel utilisateur

Ce manuel convient également à

Weber SP310 Manuel utilisateur

dans d''autres langues

Documents connexes