Charbroil 07401407 Le manuel du propriétaire

07401407 • 80008949 • 05/23/08

This instruction manual contains important information

necessary for the proper assembly and safe use of the

appliance.

Read and follow all warnings and instructions before

assembling and using the appliance.

Follow all warnings and instructions when using the appliance.

Keep this manual for future reference.

Keep any electrical supply cord and the fuel supply hose away

from any heated surfaces.

Table of Contents

For Your Safety. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

Grill Service Center. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

Product Record Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

Installation Safety Precautions . . . . . . . . . . . . . . . . . . . . . . . . . . 2

Safety Symbols. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

Limited Warranty. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

Use and Care . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-8

Parts List. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9

Parts Diagram. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10

Assembly. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11-17

Table Top Use. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18

Transporting of Grill. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19-20

Troubleshooting. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21-22

Registration Card . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23

3

To insure your satisfaction

and for follow-up service,

register your grill

online at:

www.grillregistration.com

WARNING

Do not attempt to repair or alter the

hose/valve/regulator for any “assumed” defect. Any

modification to this assembly will void your warranty

and create the risk of a gas leak and fire. Use only

authorized replacement parts supplied by

manufacturer.

Manufacturer warrants to the original consumer-purchaser only that this product shall be free from defects in workmanship and materials after

correct assembly and under normal and reasonable home use for the periods indicated below beginning on the date of purchase.

The manufacturer reserves the right to require that defective parts be returned, postage and or freight pre-paid, by the consumer, for review and

examination.

Upon consumer supplying proof of purchase as provided herein, Manufacturer will repair or replace the parts listed below which are proven

defective during the applicable warranty period. Parts required to complete such repair or replacement shall be free of charge to you except for

shipping costs. The original consumer-purchaser will be responsible for all shipping charges of parts replaced under the terms of this

limited warranty.

This limited warranty is applicable in the United States and Canada only, is only available to the original owner of the product and is not

transferable. Manufacturer requires reasonable proof of your date of purchase. Therefore, you should retain your sales slip or invoice and register

your new product immediately. Defective or missing parts subject to this limited warranty will not be replaced without registration or proof of purchase.

Register online at http://www.charbroil.com or complete and return via mail the Product Registration Card located on the last page of the Use & Care

manual included with this product and retain your sales receipt for proof of purchase.

This limited warranty applies to the functionality of the product ONLY and does not cover cosmetic issues such as scratches, dents, corrosions

or discoloring by heat, abrasive and chemical cleaners or any tools used in the assembly or installation of the appliance, surface rust, or the

discoloration of stainless steel surfaces.

This limited warranty will not reimburse you for the cost of any inconvenience, food, personal injury or property damage.

If an original replacement part is not available, a comparable replacement part will be sent. You will be responsible for all shipping charges of

parts replaced under the terms of this limited warranty.

ITEMS MANUFACTURER WILL NOT PAY FOR:

1. Service calls to your home.

2. Repairs when your product is used for other than normal, single-family household or residential use.

3. Damage resulting from accident, alteration, misuse, abuse, fire, flood, acts of God, improper installation, installation not in accordance with

electrical or plumbing codes, or use of products not approved by the manufacturer.

4. Any food loss due to product failures.

5. Replacement parts or repair labor costs for units operated outside the United States or Canada.

6. Pickup and delivery of your product.

7. Repairs to parts or systems resulting from unauthorized modifications made to the product.

8. The removal and/or reinstallation of your product.

9. Shipping cost, standard or expedited, for warranty and replacement parts.

DISCLAIMER OF IMPLIED WARRANTIES; LIMITATION OF REMEDIES

Repair or replacement of defect parts is your exclusive remedy under the terms of this limited warranty. Manufacturer will not be responsible for

any consequential or incidental damages arising from the breach of either this limited warranty or any applicable warranty, or for failure or damage

resulting from acts of God, improper care and maintenance, grease fire, accident, alteration,

replacement of parts by anyone other than Manufacturer, misuse, transportation, commercial use, abuse, hostile environments (inclement weather,

acts of nature, animal tampering), improper installation or installation not in accordance with local codes or printed manufacturer instructions.

THIS LIMITED WARRANTY IS THE SOLE EXPRESS WARRANTY GIVEN BY THE MANUFACTURER. NO PRODUCT PERFORMANCE

SPECIFICATION OR DESCRIPTION WHEREVER APPEARING IS WARRANTED BY MANUFACTURER EXCEPT TO THE EXTENT SET FORTH

IN THIS LIMITED WARRANTY. ANY IMPLIED WARRANTY PROTECTION ARISING UNDER THE LAWS OF ANY STATE, INCLUDING IMPLIED

WARRANTY OF MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE OR USE, IS HEREBY LIMITED IN DURATION TO THE

DURATION OF THIS LIMITED WARRANTY.

Neither dealers nor the retail establishment selling this product has any authority to make any additional warranties or to promise

remedies in addition to or inconsistent with those stated above.

Manufacturer’s maximum liability, in any event, shall not exceed the documented purchase price of the product paid by the original consumer.

This warranty only applies to units purchased from an authorized retailer and or re-seller.

NOTE: Some states do not allow an exclusion or limitation of incidental or consequential damages, so some of the above limitations or

exclusions may not apply to you. This limited warranty gives you specific legal rights as set for herein. You may also have other rights which vary

from state to state. In the state of California only, if refinishing or replacement of the product is not commercially practicable, the retailer selling this

product or the Manufacturer will refund the purchase price paid for the product, less the amount directly attributable to use by the original consumer-

purchaser prior to discovery of the nonconformity. In addition, in the state of California only, you may take the product to the retail establishment

selling this product in order to obtain performance under this limited warranty.

If you wish to obtain performance of any obligation under this limited warranty, you should write to:

CharBroil Consumer Relations

P. O. Box 1240

Columbus, GA 31902-1240

Consumer returns will not be accepted unless a valid Return Authorization is first acquired by calling 1-800-241-7548 and then clearly marked

on the outside of the package and the package is shipped freight/postage pre-paid to the address above.

All Parts - 90 Days

LIMITED WARRANTY

4

Use and Care

LP (Liquefied Petroleum Gas)

• Is nontoxic, odorless and colorless when produced. For Your

Safety, LP gas has been given an odor (similar to rotten

cabbage) so that it can be smelled.

• LP gas is highly flammable and may ignite unexpectedly

when mixed with air.

Propane Cylinder Use (1 lb. Disposable)

• Use only cylinder marked “Propane Fuel”.

• Cylinder must be constructed and marked in accordance with

the specifications for LP-gas cylinders of the U.S. Department

of Transportation (DOT) or the National Standard of Canada,

CAN/CSA-B339, Cylinders, Spheres and Tubes for the

Transportation of Dangerous Goods.

• Size should be 4” diameter, 8” height, or 3” diameter, 10”

height.

• Save cylinder cap and reinstall when not in use.

• Cylinder supply system must be arranged for vapor

withdrawal. Gas cylinder must be upright in use.

Leak Testing (1 lb. Disposable)

• During leak test, keep grill away from open flames or sparks

and do not smoke. Grill must be leak tested outdoors in a well

ventilated area.

• Leak test must be repeated each time gas cylinder is replaced

or after storage.

Materials needed include clean paint brush and 50/50 soap and

water solution. Use mild soap and water. s Do not use

household cleaning agents. Damage to components can

result.

1. Be sure control knob on regulator is in "OFF" position.

2. Brush soapy solution onto connection between gas cylinder

and regulator at (A).

IMPORTANT!

s If growing bubbles appear, there is a leak. Retighten

connection and repeat steps 1 and 2.

If you cannot stop a leak, remove gas

cylinder from regulator and check for

damaged threads, dirt and debris on

regulator and gas cylinder. Also check to

see if anything is obstructing flow of gas at

regulator and gas cylinder openings.

Remove any obstruction that may be

found and repeat leak test. If threads are

damaged on either regulator or gas

cylinder, replace. Order new parts by

giving the serial, model number and name

of items needed to the Grill Service Center

at 1-800-241-7548.

A

WARNING

For Safe Use of Your Grill and to Avoid Serious

Injury:

• Do not let children operate or play near grill.

• Keep grill area clear and free from materials that burn (i.e.

gasoline, propane, or any other flammable liquid or gas).

• Do not block holes in bottom or back of grill.

• Check burner flames regularly.

• Never use regulator from this grill with any other LP

appliance.

• When cooking, the appliance must be on a level surface in

an area clear of combustible material.

• Use grill only in well-ventilated space. NEVER use in

enclosed space such as carport, garage, porch, covered

patio, or under an overhead structure of any kind.

• Do not use charcoal or ceramic briquets in a gas grill.

(Unless briquets are supplied with your grill.)

• This appliance is not intended for and should never be used

as a heater.

• Use grill at least 3 ft. from any wall or surface. Maintain

10 ft. clearance to objects that can catch fire or sources of

ignition such as pilot lights on water heaters, live electrical

appliances, etc..

• Apartment Dwellers:

Check with management to learn the requirements and fire

codes for using an LP gas grill in your apartment complex.

If allowed, use outside on the ground floor with a three (3)

foot clearance from walls or rails. Do not use on or under

balconies.

• NEVER attempt to light burner with lid closed. A

buildup of non-ignited gas inside a closed grill is

hazardous.

• Never operate grill with LP cylinder out of correct

position specified in assembly instructions.

3 ft. (1m) minimum

10 ft. recommended

5

CAUTION

If ignition does NOT occur in 5 seconds, turn the

burner controls OFF, wait 5 minutes and repeat the

lighting procedure. If the burner does not ignite with

the valve open, gas will continue to flow out of the

burner and could accidently ignite with risk of injury.

DANGER

• NEVER store a spare cylinder under or near the

appliance or in an enclosed area.

• Never fill a cylinder beyond 80% full.

• An overfilled or improperly stored cyclinder is a hazard

due to possible gas release from the safety relief valve.

This could cause an intense fire with risk of property

damage, serious injury or death.

• If you see, smell or hear gas escaping, immediately get

away from the LP cylinder/appliance and call your fire

department.

Safety Tips

sThe use of alcohol, prescription or nonprescription drugs

may impair the consumer’s ability to properly assemble or

safely operate the appliance.

sWhen grill is not in use, disconnect 1 lb. cylinder.

sNever move grill while in operation or still hot. Allow the

appliance to cool before moving or storing.

sUse only tools supplied or plastic tools.

sMaximum load for side shelves is 10 lbs.

sThe regulator may make a humming or whistling noise

during operation. This will not affect safety or use of grill.

sIf you have a grill problem see the Troubleshooting Section.

sLight burners. Check to make sure they are lit, close the lid

and warm up grill on high for 10 minutes. Curing of paint

and parts will produce an odor only on first lighting.

sGrill is not to be used as a heater.

sClean grill often, preferably after each cookout. If a bristle

brush is used to clean any of the grill cooking surfaces,

ensure no loose bristles remain on cooking surfaces prior to

grilling. It is not recommended to clean cooking surfaces

while grill is hot.

Ignitor Lighting

s Do not lean over grill while lighting.

1. Open lid during lighting. Make sure LP cylinder is properly

connected to regulator.

2. Turn LEFT knob to IGNITE.

3. Turn rotary ignitor knob (up to 5 times) to light. Be sure

burner lights and stays lit.

4. If ignition does NOT occur in 5 seconds, turn the burner

controls OFF, wait 5 minutes and repeat the lighting

procedure.

5. To ignite RIGHT burner, turn right knob to IGNITE and repeat

steps 3-4.

6. If IGNITOR does not work, follow match lighting instructions.

After Lighting: Turn knobs to HI position for warm-up. Do not

warm up grill with knobs on IGNITE. Knobs and handle will

become uncomfortably hot if left in IGNITE positions.

Match Lighting

1.

2. Insert lit match into match lighting hole. Turn gas on for

appropriate burner. Repeat on other burner.

Attach match to match lighting stick, light match.

Turn controls OFF and disconnect cylinder when not

in use.

WARNING

Match

Lighting

Hole

Match

Lighting

Hole

Back of grill

Match

lighting

stick

Normal

Hose

Kinked

Hose

Before Your First Cookout.

Leak test your grill. Light burners, check to make sure they are

lit, close the lid and warm up grill on HIGH for 10 minutes. Curing

of paint and parts will produce an odor only on first lighting.

Turning Grill Off

• Turn knobs to OFF position. Make sure knobs pop up. If it

does not, discontinue use and order new part.

• Disconnect 1 lb. Cylinder.

Hose Check

• Before each use, check to see if

hoses are cut, worn or kinked.

Replace damaged hoses before

using grill. Use only

valve/hose/regulator specified by

manufacturer.

6

General Grill Cleaning

• Do not mistake brown or black accumulation of grease and

smoke for paint. Interiors of gas grills are not painted at the

factory (and should never be painted). Apply a strong solution

of detergent and water or use a grill cleaner with scrub brush

on insides of grill lid and bottom. Rinse and allow to

completely air dry. Do not apply a caustic grill/oven cleaner

to painted surfaces.

• Side Shelves: Wash with warm soapy water and wipe dry.

s Do not use citrisol, abrasive cleaners, degreasers or a

concentrated grill cleaner on plastic side shelves. Damage to

and failure of shelves can result.

• Non-Stick Cooking Surface: Turn grill off before cleaning.

While still warm, pour a cup of water over cooking surface to

loosen grease and food particles and to speed cool-down.

Wipe cooking surface with a paper towel or sponge. Once

completely cool, cooking surface can be removed and washed

with warm soapy water or placed in dishwasher.

• Cooking Surface: If a bristle brush is used to clean any of the

grill cooking surfaces, ensure no loose bristles remain on

cooking surfaces prior to grilling. It is not recommended to

clean cooking surfaces while grill is hot.

CAUTION

• Putting out grease fires by closing the lid is not

possible. Grills are well ventilated for safety

reasons.

• Do not use water on a grease fire. Personal injury

may result. If a grease fire develops, turn knobs

and LP cylinder off.

• Do not leave grill unattended while preheating or

burning off food residue on HI. If grill has not been

regularly cleaned, a grease fire can occur that may

damage the product.

CAUTION

FACT: Sometimes spiders and other small insects climb

into the burner tubes attached to the burners. The

spiders spin webs, build nests and lay eggs. The

webs or nests can be very small, but they

are very strong and can block the flow

of gas. Clean burners prior to use after

storing, at the beginning of grilling season

or after a period of one month not being used.

NATURAL HAZARD • SPIDERS

Spider guards are on the air intakes in an effort to

reduce this problem, but it will not eliminate it! An

obstruction can result in a "flashback" (a fire in the

burner tubes). The grill may still light, but the obstruction

does not allow full gas flow to the burners.

IF YOU EXPERIENCE THE FOLLOWING:

1. Smell gas.

2. Burner(s) will not light.

3. A small yellow flame from burner (should be blue).

4. Fire coming from around or behind control knob.

STOP!

Immediately turn off gas at LP cylinder!

SOLUTION:

Wait for grill to cool.

Follow the “Cleaning the Burner Assembly” instructions.

Clean burners often. Use a 12” pipe cleaner to clean out

the burner tubes. You may also force a stream of water

from a hose nozzle through burner tubes to clean them.

Burner Flame Check

Light burner. Make sure burner stays

lit while rotating the control knob

from HIGH to LOW. Always check

flame prior to each use.

Cleaning The Burner Assembly

1. Turn gas off at control knobs and LP cylinder.

2. Remove cooking grids and vaporizer tents.

3. Remove pal nuts on burners. Unscrew electrode and move

to the side to remove burner. NOTE: Do not pull electrode

out.

4. Under grill remove grease tray. Clean with soap and water.

5. Wipe ceramic electrode with rubbing alcohol and cloth.

6. Clean burners exterior with soap and water. Lay burners on

flat surface, insert garden hose (preferably with nozzle), into

burner tubes forcing water through tubes. Make sure water

comes out of every porthole. Open clogged portholes with a

thin wire. Shake out excess water and examine porthole.

Due to normal wear and corrosion some portholes may

become enlarged, if so replace burner. If any horizontal

cracks appear from porthole to porthole or large holes (other

than portholes) are found replace burner.

7. If grill is to be stored, coat burners lightly with cooking oil.

Wrap in protective cover to keep insects out. If not storing

use following steps.

VERY IMPORTANT: Burner tubes must engage valve

openings as shown (A).

8. Reattach burners and electrodes.

9. Reposition cooking grids and vaporizer tents. Place clean

grease tray into grill bottom.

10. Before cooking again on grill,

perform a “Leak Test” and

“Burner Flame Check”.

Burner

Tube

Valve

A

Burner tubes correctly

engaged in valves

7

Food Safety

Food safety is a very important part of enjoying the outdoor

cooking experience. To keep food safe from harmful bacteria,

follow these four basic steps:

Clean: Wash hands, utensils, and surfaces with hot soapy water

before and after handling raw meat and poultry.

Separate: Separate raw meats and poultry from ready-to-eat

foods to avoid cross contamination. Use a clean platter and

utensils when removing cooked foods.

Cook: Cook meat and poultry thoroughly to kill bacteria. Use a

thermometer to ensure proper internal food temperatures.

Chill: Refrigerate prepared foods and leftovers promptly.

For more information call: USDA Meat and Poultry Hotline at

1-800-535-4555 In Washington, DC (202) 720-3333, 10:00 am-

4:00 pm EST.

How To Tell If Meat Is Grilled Thoroughly

• Meat and poultry cooked on a grill often browns very fast on the

outside. Use a meat thermometer to be sure food has reached

a safe internal temperature, and cut into food to check for

visual signs of doneness.

• Whole poultry should reach 180° F; breasts, 170° F. Juices

should run clear and flesh should not be pink.

• Hamburgers made of any ground meat or poultry should reach

160° F, and be brown in the middle with no pink juices. Beef,

veal and lamb steaks, roasts and chops can be cooked to 145°

F. All cuts of pork should reach 160° F.

• NEVER partially grill meat or poultry and finish cooking later.

Cook food completely to destroy harmful bacteria.

• When reheating takeout foods or fully cooked meats like hot

dogs, grill to 165° F, or until steaming hot.

Storing Your Grill

• Clean cooking surface and grease container.

• When LP cylinder is connected to grill, store outdoors in well-

ventilated space and out of reach of children.

• Cover grill if stored outdoors.

• Store grill indoors ONLY if LP cylinder is turned off and

disconnected, removed from grill and stored outdoors in well-

ventilated space and out of reach of children.

• Leak test the grill after removing from storage and follow

Cleaning Burner Assembly instructions before starting grill.

• Keep grill area clear and free from combustible materials (i.e.

gasoline, propane or other flammable liquid or gas).

• Do not block holes in bottom or back of grill.

Non-Stick Cooking Surface Use and Care.

• Use only plastic tools.

• Do not cut food on surface.

• Do not put pots or pans on surface.

• Do not leave lid down for more than 10 minutes without food

on the grill. Non-stick surface may be damaged.

8

9

NOTE: Some grill parts shown in the assembly steps may differ slightly in appearance from

those on your particular model. However, the method of assembly remains the same.

PARTS LIST – Model No. 07401407

Certified Grill Parts And Accessories®, Char-Broil and Design®, Char-Broil (Gas Grill Briquettes)®, Char-Diamonds®, Cooking Zone and Design®, Diamond Flame®, Executive Chef®, Faststart®, Flare Fighter®, FlavorMaster®, Gas Grill

Silouette and Design®, H2O Smoker®, Lava Flame®, MasterFlame®, MasterFlame Precision Cooking System®, PowerSpark®, Quantum®, VIP®, PrecisionFlame and Design®, Sierra®, and TruFlame® are registered Trademarks of the W.C.

Bradley Company. Thermos® is a registered trademark of the Thermos Company and its affiliates.

Artisan Collection by Char-Broil ™, C3 and Design™, Char-Broil and Design™, Flame Design™, FlavorTents™, Grill 2 Go™, Grillin’ Stick™, Keeper of the Flame™, Keepers of the Flame™, Natural Grip™, Outdoor Cooking Collection and

Design™, Patio Bistro™, PrecisionFlame™, Pro-Check™, QuickSet Grills and Design™, SmokerTents™, The Big Easy™, The Minute Grill™, The Edge™, The Tuscan Collection™, and The Urban Grill™ are Trademarks of the W.C. Bradley

Company. Universal Grill Parts and Design™ is a trademark of the Thermos Company and its affiliates.

TEC™ is a registered trademark of TEC INFRA-RED GRILLS. US patents pending.

Protected under one or more of the following U.S. Patents: 4,598,692; 4,624,240; 4,747,391; 4,747,391; 4,817,583; 4,924,846; 4,989,579; 5,003,960; 5,076,256; 5,076,257; 5,090,398; 5,109,834; 5,224,676; 5,277,106; 5,421,319; 5,441,226;

5,452,707; 5,458,309; 5,566,606; 5,566,606; 5,579,755; 5,582,094; 5,613,486; 5,649,475; 5,706,797; 5,711,663; 5,765,543; 5,931,149; 5,996,573; 6,095,132; 6,135,104; 6,173,644B1; 6,279,566; 6,397,731; 6,418,923; 6,439,222; 6,523,461;

D282,619; D339,714; D341,292; D343,337; D358,059; D361,466; D364,535; D372,637; D373,701; D377,735; D383,035; D397,910; D405,643; D405,643; D406,005; D406,009; D413,043; D413,229; D413,229; D414,982; D415,388; D416,164;

D416,441; D416,441; D417,587; D422,516; D423,274; D423,876; D428,303; D435,396; D436,004; D438,059; D438,060; D438,427; D439,110; D442,505; D443,179; D443,354; D447,384; D447,385; D447,909; D448,610; D448,614; D448,615;

Tools required for assembly:

Adjustable Wrench - Not Provided Philips Screwdriver - Not Provided

Estimated assembly time:

20-30 minutes

•

KEY PART NUMBER DESCRIPTION QUANTITY

A

80001823 VAPORIZER BAR 2

B

55710134 WHEEL KIT 1

C

55710135 CONDIMENT BASKET KIT 1

D

80001841 RETAINER STRAP, VELCRO, 1 POUND TANK 1

E

55710136 LEG SUPPORT KIT 1

F

80001889 HOSE / REGULATOR ASSEMBLY, 1 POUND TANK 1

G

80005445 LID, FORMED, SILVER PORCELAIN 1

H

55710138 HANDLE KIT 1

I

80005448 LIGHT ASSEMBLY, HANDLE 1

J

55710139 LOWER CASTING KIT 1

K 55710152 SNAP LOCK, CRADLE KIT 2

L 55710154 SIDE HANDLE KIT 2

M

55710155 SIDE LEG SUPPORT KIT 2

N

55710156 LEFT LEG EXTENTION KIT 1

O

55710157 RIGHT LEG EXTENTION KIT 1

P

80001812 MATCH HOLDER AND CHAIN ASSEMBLY 1

Q

80001818 GRIDDLE

1

R

80001819 COOKING GRATE

2

S

55710140 BURNER KIT 2

T

55710141 VALVE MANIFOLD KIT 1

U

55710142 IGNITOR KIT 1

V

55710410 CONTROL PANEL W/ HEAT SHIELD, CHARBROIL 1

W

80001809 RIGHT SIDE SHELF ASSEMBLY 1

X 55710153 PULL HANDLE KIT 1

Y

80001815 LEFT SIDE SHELF ASSEMBLY 1

Z

80002497 GREASE TRAY ASSEMBLY 1

AA

55710145 CRADLE KIT 1

BB

55710146 LEFT LEG KIT 1

CC

80001813 HUBCAP, LEG 4

DD

55710147 RIGHT LEG KIT 1

EE 55710151 SNAP LOCK, LEG KIT 1

FF

80001826 KNOB, CONTROL 2

GG

80005457 KNOB, ROTARY IGNITOR 1

HH

55710411 LOGO PLATE KIT, CHARBROIL 1

II

80005477 SPACER, BOTTOM CASTING 2

…

80005464 BLISTER PACK / SNAP 1

…

80008949 ASSEMBLY MANUAL, CHAR-BROIL, GRILL-2-GO 1

…

80008950 CARTON, CHAR-BROIL, GRILL-2-GO 1

10

A

B

PARTS DIAGRAM – Model No. 07401407

HH

G

I

H

Q

R

F

Y

S

P

E

W

L

J

X

M

K

O

Z

N

M

U

V

GG

FF

T

AA

DD

CC

C

C - D

C

EE

BB

CC

II

K

L

CC

S

ASSEMBLY

2

1

1) Unfold legs to make leg assembly stand.

2) Push both stabilizer bars down to lock leg in place.

1) Remove all packaging materials from grill components at each step.

2) Remove all parts from box.

3) On leg assembly unlock transportation lock by releasing lever.

Leg

Assembly

Transportation

Lock

Stabilizer bar

Push down to

lock

Leg

Assembly

Leg

Assembly

Stabilizer bar

Push down to

lock

11

4

3

1) Insert round end of retainer strap through Hole “1” and pull all the way down.

2) Take round end of retainer strap up through Hole “2” and pull all the way up.

3) Insert round end of retainer strap through Hole “3” and close strap.

1) Attach condiment basket to right leg, using (4) 10-24 x 3/4” carriage bolts and (4) 10-24 lock nuts.

2) Insert utility bar onto condiment basket. Press down fully to engage.

#10-24 x 3/4”

Carriage bolt

Qty: 4

#10-24

Lock nut

Qty: 4

#10-24

Lock nut

#10-24 x 3/4”

Carriage bolt

Right Leg

Utility Bar

Condiment

Basket

Condiment

Basket

Condiment

Basket

Utility Bar

Retainer strap

Nylon closure straps

facing away from Grill

Hole 1

Hole 3

Hole 2

Hole 3

12

6

5

1) Take tabletop grill and insert right side of grill under red latch.

2) Press down on left side of tabletop grill over red latch to lock.

Pull up on side handles to ensure proper engagement

Control panel should be facing side fo cradle with 3 notches.

1) Insert wheel axle through axle guides in leg.

2) Insert spacers through axles on both sides.

3) Insert (2) wheels.

4) Insert retainer pin into axle on outside of wheel to secure wheel in place. Repeat on opposite wheel.

Spacer

Qty: 2

Retainer Pin

Qty: 2

Spacer

Wheel

guides

Wheel

Retainer Pin

Press down

Table Top Grill

Side with

3 notches

Leg Assembly

Tab to be Under

Red Latch

13

8

7

1) Attach grill lid to tabletop grill using (2) hinge pins and cotter pins.

1) Attach handle to grill lid using (4) #10-24 x 3/8” screws.

Use ONLY hand driven Philips Screw Driver. Do not over tighten screws.

#10-24 x 3/8”

Screw

Qty: 4

Handle

#10-24 x 3/8”

Screw

Grill Lid

Cotter Pin

Qty: 2

Hinge Pin

Qty: 2

Table Top

Grill

Cotter Pin

Lid

Hinge Pin

14

10

9

1) Insert hook end on handle light into right side of handle, push down on other side to lock handle light in place.

2) To remove handle light, slide red button on left side of handle light, pull handle light up.

1) Remove (2) battery covers from handle light by loosening (2) screws.

2) Insert (4) AA batteries (NOT INCLUDED), 2 per battery compartment as indicated on handle light.

3) Replace covers and secure screws that were loosened earlier.

Handle Light

AA Bateries

Battery Cover

Handle Light

Handle

Handle Light

Handle

Red Button

15

12

11

1) Open grill lid, unfold left non-locking side-shelf and griddle.

2) Unfold right locking side-shelf halfway and push towards hinge. Unfold completely and pull shelf outside to engage table

top grill handle.

3) Insert round end of vaporizer bar inside front hole of table top grill (See Fig C). Rest rear end of vaporizer bar over

support rib on backside of table top grill. (See Fig B).

4) Attach leg support to back of grill using (2) #10-24x1/2” screws and (2) #10-24 lock nuts. (See Fig. D)

5) Insert (2) cooking grates.

6) Insert Grease tray.

Note: To remove grease tray, rear lock tabs must be dis-engaged. (See Fig A)

1) Attach (2) control knobs and (1) rotary ignitor knob by aligning holes with control panel as shown.

2) Remove (4) clear protectors from shelf supports.

Control Knob

Rotary Ignitor

Knob

Control Knob

Rotary Ignitor

Knob

Control Knob

Qty: 2

Rotary Ignitor Knob

Qty: 1

Clear

Protectors

#10-24 x1/2”

Screw

Qty: 2

#10-24

Lock Nut

Qty: 2

Leg Support

Rear Lock

Lower Casting

Grease Tray

Griddle

Left Side

Shelf

Grease Tray

Cooking Grate

Vaporizer Bar

Front of Grill

Right Side

Shelf

Back Side

of Grill

Vaporizer Bar

#10-24 x 1/2”

Screw

#10-24

Nuts

16

14

13

(If Desired)

1) Paper towel (NOT PROVIDED) can be placed on left leg of grill, by inserting it over top tab provided on left leg, and

pushing onto bottom tab, securing it.

2) Car Flags (NOT PROVIDED) can be attached to right side-shelf, by inserting bottom tab of flag into slot provided on right

side-shelf and securing it.

3) Hooks are provided on Condiment basket for purpose of attaching small trash bags (NOT PROVIDED).

1) Close grill Lid

2) Insert hose regulator support wires into holes provided in end of left side-shelf.

3) Remove yellow cap from gas inlet.

4) Bring hose connector to the rear of Tabletop grill.

5) Pull back outer ring of hose connector and push connector onto back of gas inlet. Release outer ring.

Note: Perform leak test as described in Care & Use section before operation.

Outer

Ring

Yellow

Cap

Right Side Shelf

Gas Inlet

Left Side Shelf

Hose

Paper Towel

Roll

Top Tab

Bottom Tab

Flag

Trash Flag

17

Table Top Use

Table Top

Remove grill from base to use in table top mode.

NOTE: Maximum shelf load should not exceed 10 lbs.

If using a longer 1 lb. cylinder, make sure left side shelf hangs over surface edge.

18

Transporting of Grill

Before moving grill after use:

• Cool grill down. Remove tank, regulator/hose

assembly, flag, trash bag and paper towel (if

attached) from grill.

• Empty Grease Tray.

• Fold griddle and shelves, close lid.

• Unlock red latches, lift grill from base.

• Fold legs and lock.

• Replace grill on base. Ensure red latches are

locked.

19

Transporting of Grill

• Open lid, unfold right shelf.

• Pull right shelf out until it locks in place.

• Close lid.

• Use handle to transport grill.

20

La page est en cours de chargement...

Charbroil 07401407 Le manuel du propriétaire

Charbroil 07401407 Le manuel du propriétaire

dans d''autres langues

Documents connexes

Autres documents