Charbroil 06201297 Le manuel du propriétaire

Marque: Charbroil

Modèle: 06201297

Catégorie: Barbecues

Taper: Le manuel du propriétaire

04201101

42804192 (03-26-08)

06201297

El Dorado

Smoker

El Dorado

Smoker

For Outdoor

Use Only

WARNING

NEVER LEAVE FIRE UNATTENDED!

Do not allow small children near flame. Hot embers can

fly out in breezy conditions. Adequate fire extinguishing

material should be readily available.

WARNING

CARBON MONOXIDE HAZARD

Burning charcoal inside can kill you. It gives off carbon

monoxide, which has no odor. NEVER burn charcoal

inside homes, vehicles or tents.

Read and follow all safety statements, warnings,

assembly instructions and use & care directions before

attempting to assemble.

CAUTION

Some parts may contain sharp edges – especially as

noted in manual. Wear protective gloves if necessary.

WARNING

Do not use this unit on or near combustible surfaces or

structures such as wood decks, dry leaves or grass, vinyl

or wood siding, etc. SEE OWNER’S MANUAL FOR

IMPORTANT SAFETY INFORMATION.

CAUTION

THIS UNIT IS HEAVY!

DO NOT assemble without a helper.

WARNING

All surfaces can be hot during use. Use protection as

required to prevent burning.

3/8-16 X 2”

Bolt (qty=4)

3/8-16 X 3/4”

Bolt (qty=4)

3/8”

Nut (qty=8)

3/8” Lock

Washer (qty=12)

1/4-20 X 2”

Bolt (qty=4)

1/4-20 X 1/2”

Bolt (qty=1)

1/4-20 X 1/2”

Screw (qty=25)

1/4” Keps

Nut (qty=25)

1/4” Flat

Washer (qty=2)

Logo

Clip (qty=2)

Hitch

Pin (qty=2)

Handle

Washer (qty=3)

Tools required for assembly: Straight or Phillips screwdriver • Adjustable wrench

To insure your satisfaction

and for follow-up service,

online at:

www.grillregistration.com

STOP!

Missing a part?

Call us and we

will gladly ship

Call Our Help Line

the part you need.

HARDWARE LIST

Hardware shown, not actual size. You may have spare hardware after assembly is complete.

2 • 06201297

No need to go back to the store!

The store where you made your purchase

does not stock parts for this item. If you

need parts, whether they are missing or

damaged, call the Customer Service toll

free Help Line.

06201297 • 3

PARTS LIST

Attach Short Leg to Firebox using two 3/8-16 x 2” bolts, 3/8” lock washer, and 3/8” nuts.

Attach Long Leg to Smoker Chamber using two 3/8-16 x 2” bolts, 3/8” lock washer, and 3/8” nuts.

Lay Smoker Chamber on ground with Hinge side down.

Attach Firebox to Smoker Chamber using four 3/8-16 x 3/4” bolts, eight 3/8” lock washer (one at bolt head, another at

nut end), and four 3/8” Nut.

4 • 06201297

3/8-16 x 3/4”

Bolt

3/8” Lock

Washer

3/8” Lock

Washer

3/8”

Nut

Firebox

Smoker

Chamber

Hinge

Smo

ker

Chamber

3/8-16 x 2”

Bolt

3/8” Lock

Washer

3/8”

Nut

Short

Leg

Long

Leg

Firebox

06201297 • 5

Place Bottom Shelf between Firebox and Long Leg. Secure with two 1/4-20 x 2” screws and 1/4” keps nuts through

leg and two 1/4-20 x 1/2” screws and 1/4 keps nuts through Firebox.

Attach two Leg Gussets to Short Leg and Firebox using one 1/4-20 x 2” bolts and 1/4” keps nut through leg, and one

1/4-20 x 1/2” screw and 1/4” keps nut through Firebox for each gusset.

1/4-20 x 2”

Screw

1/4-20 x 2”

Screw

1/4-20 x 1/2”

Screw

1/4-20 x ½”

Screw

1/4”

Nut

1/4”

Nut

Leg

Gusset

Firebox

Bottom

Shelf

Long

Leg

Short

Leg

Axle

Rod

Wheel

Caster

Insert

Locking

Caster

Non-Locking

Caster

Hitch

Smoker

Chamber

Lift smoker and lay on Smoker Chamber top.

Slide Axle Rod through Long Leg. Attach Wheels using Hitch Pins shown A.

Insert Caster Inserts into ends of Small Leg.

Push Locking Caster into Caster Insert hole for front leg. Push Non-locking Caster into insert hole for rear

leg.

6 • 06201297

Stand smoker upright on its wheels.

Attach eight Grate Racks inside front and rear panels of Smoker Chamber using two 1/4-20 x 1/2”screws and 1/4”

keps nuts for each rack.

Lower Drip Pan into Smoker Chamber with feet towards Firebox end.

Place Fire Grate onto Ash Pan and place into Forebox.

1/4-20 x 1/2”

Screw

1/4”

Nut

Grate

Rack

Smoker

Cham

ber

Ash

Pan

Fire

Grate

Drip

Pan

Firebox

Smoker

Chamber

Feet

06201297 • 7

Assemble both Smoke Chamber and Firebox doors as follows.

Insert Door Damper through rear end of Door shown A.

Insert Door (long) Damper Rod through Door Damper openings on front side of Door to hold in place shown B. Lift

rod end over first louver to secure shown C. Damper should move freely from open to shut position.

Insert Handle over Handle Rod and secure using one 1/4-20 x 1/2” screw and handle washer shown C.

Attach Doors by placing on Firebox Door Pins.

Door

Damper

Door

Handle

Washer

1/4-20 x 1/2”

Screw

Handle

Rod

Door

Firebox

Door

Smoker

Chamber

Door

Note: Rod End

Lock Position

Door (long)

Damper Rod

8 • 06201297

Assemble Lid Handle by inserting handle end through center hole of Lid and secure using one 1/4-20 x 1/2” bolt and

1/4” keps nut.

Insert Lid Damper through cutouts on inner end of Lid.

Insert Lid (short) Damper Rod through Lid Damper openings on outer side of Lid to hold in place. Lift rod end over

first louver to secure. Damper should move freely from open to shut position.

Insert Handle over Handle Rod and secure using one 1/4-20 x 1/2”screw and handle washer.

Attach Logo Plate using two logo clips.

Attach Temperature Gauge securing with nut provided with Temperature Gauge..

Lid

Handle

Lid

Damper

1/4”

Nut

1/4-20 x 1/2”

Bolt

Lid

Temperature

Gauge

Logo

Plate

Logo

Clips

1/4-20 x 1/2”

Screw

Handle

Washer

Handle

Rod

Lid

Lid (short)

Damper

Rod

06201297 • 9

Position Lid over Smoker Chamber.

Secure Lid by sliding two Lid Stop through hinge holes locking both Lid and Smoker Chamber together. Secure

using one 1/4-20 x 1/2”screw and 1/4” flat washer on each Lid Stop.

Lid

Smoker

Chamber

Lid

Stop

1/4-20 x 1/2”

Screw

1/4” Flat

Washer

Cooking

Grates

Front

Shelf

Smoker

Chamber

Grease

Clip

Place Cooking Grates onto Smoker Chamber.

Assemble Front Shelf by inserting wire ends into four holes on front of Smoker Chamber. After inserting the

wire ends into the holes, tilt the shelf fully upright and push ends all the way into holes and then bring the

shelf down to the horizontal position.

Attach Grease Clip to bottom of Smoker Chamber shown A.

Preparing and Using Your Smoker

Before cooking with your Smoker, the following steps should be closely followed to both cure the finish and

season the interior steel. Failure to properly follow these steps may damage the finish and/or impart metallic

flavors to your first foods.

1. Brush all interior surfaces including grills and grates with vegetable cooking oil.

2. Build a small fire on the fire grate, being sure not to lay coals against the walls.

3. Close door. (Position Smoke Chamber dampers and Lid damper approximately at one quarter open.) This

burn should be sustained for at least two hours, the longer the better. Then, begin increasing temperature by

opening the dampers half-way and adding more charcoal. Your Smoker is now ready for use.

Rust can appear on the inside of your smoker. Maintaining a light coat of vegetable oil on interior surfaces will

aid in the protection of your unit. Exterior surfaces of smoker may need occasional touch up. We recommend

the use of a commercially available black high temperature spray paint. NEVER PAINT THE INTERIOR OF

THE UNIT !

GRILLING

Wood is recommended, however charcoal or a combination of both may be used as the fuel source for grilling,

with the fuel source placed and ignited on the fire grate. Do not build too large of a fire. We recommend starting

a fire with no more than 4 pounds of charcoal (approximately 60 briquets) and adding more as needed during

cooking.

After allowing the fire to burn down, place the cooking grills in the smoker. Failure to read and follow

instructions for lighting charcoal may result in serious personal injury and/or property damage.

GRILL MAINTENANCE

Frequency of cleanup is determined by how much your smoker is used. Make sure coals are completely

extinguished before cleaning inside of smoker. Inside surfaces may be cleaned with a strong solution of

detergent and water applied with a scrub brush. Thoroughly rinse with water and allow to air dry before using

again.

SMOKING AND SLOW COOKING

If using the Smoker as a smoker or slow cooker, build your fire on top of the fire grate in the smoke chamber.

Either charcoal or wood may be used, but wood is the recommended fuel for it’s rate of burn and the flavor it

imparts to the food being cooked. Most seasoned hardwoods are good for smoking such as hickory, mesquite,

pecan, oak, and many other fruit woods. The firebox will accommodate most split fireplace size logs (12”). Bark

should be avoided or burned off first as it contains a high acid content and imparts an acid flavor. After allowing

the fire to burn down, close the doors and control the temperature and smoke with the dampers located on the

firebox and Lid. Smoke is contained within the chambers, which will reduce burn while imparting more smoke

flavor. Do not operate the Smoker with temperatures exceeding 450 degrees in the smoker chamber. Place the

food in the smoker chamber and monitor the temperature. Cooking and smoking are taking place using indirect

heat. There is no need to worry about a grease fire flare-up ruining the food. Do not place food within 6” of the

opening from the firebox into the smoker chamber. A general rule of thumb for cooking is about 1 hour per

pound for smoking large cuts of meat. Refer to a cook book for specific cuts of meats. Limit the number of

times you open the smoker chamber door as this will allow heat to escape and extend the cooking time.

HELPFUL HINTS

• If food seems to be getting too smoky or brown before the cooking time is finished, cover it loosely with heavy

duty aluminum foil.

• Remove the ash after each use.

• Covered side dishes can be warmed in smoker chamber.

• To prevent flare-ups, brush meat lightly with oil before grilling.

10 • 06201297

LIMITED WARRANTY

Manufacturer warrants to the original consumer-purchaser only that this product shall be free from defects in workmanship and materials after correct assembly

and under normal and reasonable home use for the periods indicated below beginning on the date of purchase.

The manufacturer reserves the right to require that defective parts be returned, postage and or freight pre-paid, by the consumer, for review and examination.

90 Day LIMITED Warranty

Upon consumer supplying proof of purchase as provided herein, Manufacturer will repair or replace the parts listed below which are proven defective during the

applicable warranty period. Parts required to complete such repair or replacement shall be free of charge to you except for shipping costs. The original consumer-

purchaser will be responsible for all shipping charges of parts replaced under the terms of this limited warranty.

This limited warranty is applicable in the United States and Canada only, is only available to the original owner of the product and is not transferable.

Manufacturer requires reasonable proof of your date of purchase. Therefore, you should retain your sales slip or invoice and register your new product immediately.

Defective or missing parts subject to this limited warranty will not be replaced without registration or proof of purchase. Register online at or

complete and return via mail the Product Registration Card located on the last page of the Use & Care manual included with this product and retain your sales receipt

for proof of purchase.

This limited warranty applies to the functionality of the product ONLY and does not cover cosmetic issues such as scratches, dents, corrosion or discoloring by

heat, abrasive and chemical cleaners or any tools used in the assembly or installation of the appliance, surface rust, or the discoloration of stainless steel surfaces.

The warranty for your grill covers manufacturing defects. Surface rust, corrosion, or powder paint chipping on metal parts that does not affect the structural integrity of

the product is not considered a defect in workmanship or material and is not covered by this warranty.

This limited warranty will not reimburse you for the cost of any inconvenience, food, personal injury or property damage.

If an original replacement part is not available, a comparable replacement part will be sent. You will be responsible for all shipping charges of parts replaced

under the terms of this limited warranty.

ITEMS MANUFACTURER WILL NOT PAY FOR:

1. Service calls to your home.

2. Repairs when your product is used for other than normal, single-family household or residential use.

3. Damage resulting from accident, alteration, misuse, abuse, fire, flood, acts of God, improper installation, installation not in accordance with electrical or plumbing

codes, or use of products not approved by the manufacturer.

4. Any food loss due to product failures.

5. Replacement parts or repair labor costs for units operated outside the United States or Canada.

6. Pickup and delivery of your product.

7. Repairs to parts or systems resulting from unauthorized modifications made to the product.

8. The removal and/or reinstallation of your product.

9. Shipping cost, standard or expedited, for warranty and replacement parts.

DISCLAIMER OF IMPLIED WARRANTIES; LIMITATION OF REMEDIES

Repair or replacement of defective parts is your exclusive remedy under the terms of this limited warranty. Manufacturer will not be responsible for any

consequential or incidental damages arising from the breach of either this limited warranty or any applicable implied warranty, or for failure or damage resulting from

acts of God, improper care and maintenance, grease fire, accident, alteration, replacement of parts by anyone other than Manufacturer, misuse, transportation,

commercial use, abuse, hostile environments (inclement weather, acts of nature, animal tampering), improper installation or installation not in accordance with local

codes or printed manufacturer instructions.

THIS LIMITED WARRANTY IS THE SOLE EXPRESS WARRANTY GIVEN BY THE MANUFACTURER. NO PRODUCT PERFORMANCE SPECIFICATION OR

DESCRIPTION WHEREVER APPEARING IS WARRANTED BY MANUFACTURER EXCEPT TO THE EXTENT SET FORTH IN THIS LIMITED WARRANTY. ANY

IMPLIED WARRANTY PROTECTION ARISING UNDER THE LAWS OF ANY STATE, INCLUDING IMPLIED WARRANTY OF MERCHANTABILITY OR FITNESS

FOR A PARTICULAR PURPOSE OR USE, IS HEREBY LIMITED IN DURATION TO THE DURATION OF THIS LIMITED WARRANTY.

Neither dealers nor the retail establishment selling this product has any authority to make any additional warranties or to promise remedies in

addition to or inconsistent with those stated above.

Manufacturer's maximum liability, in any event, shall not exceed the documented purchase price of the product paid by the original consumer. This warranty

only applies to units purchased from an authorized retailer and or re-seller.

NOTE: Some states do not allow an exclusion or limitation of incidental or consequential damages, so some of the above limitations or exclusions may not

apply to you. This limited warranty gives you specific legal rights as set for herein. You may also have other rights which vary from state to state. In the state of

California only, if refinishing or replacement of the product is not commercially practicable, the retailer selling this product or the Manufacturer will refund the purchase

price paid for the product, less the amount directly attributable to use by the original consumer-purchaser prior to discovery of the nonconformity. In addition, in the

state of California only, you may take the product to the retail establishment selling this product in order to obtain performance under this limited warranty.

If you wish to obtain performance of any obligation under this limited warranty, you should write to:

Char-Broil Consumer Relations

P. O. Box 1240

Columbus, GA 31902-1240

Consumer returns will not be accepted unless a valid Return Authorization is first acquired by calling 1-800-232-3398 and then clearly marked on the outside of the

package and the package is shipped freight/postage pre-paid to the address above.

www.charbroil.com

Certified Grill Parts And Accessories®, Char-Broil and Design®, Char-Broil (Gas Grill Briquettes)®, Char-Diamonds®, Cooking Zone and Design®, Diamond Flame®, Executive Chef®, Faststart®, Flare Fighter®, FlavorMaster®, Gas Grill

Silouette and Design®, H2O Smoker®, Lava Flame®, MasterFlame®, MasterFlame Precision Cooking System®, PowerSpark®, Quantum®, VIP®, PrecisionFlame and Design®, Sierra®, and TruFlame® are registered Trademarks of the W.C.

Bradley Company. Thermos® is a registered trademark of the Thermos Company and its affiliates.

Artisan Collection by Char-Broil ™, C3 and Design™, Char-Broil and Design™, Flame Design™, FlavorTents™, Grill 2 Go™, Grillin’ Stick™, Keeper of the Flame™, Keepers of the Flame™, Natural Grip™, Outdoor Cooking Collection and

Design™, Patio Bistro™, PrecisionFlame™, Pro-Check™, QuickSet Grills and Design™, SmokerTents™, The Big Easy™, The Minute Grill™, The Edge™, The Tuscan Collection™, and The Urban Grill™ are Trademarks of the W.C. Bradley

Company. Universal Grill Parts and Design™ is a trademark of the Thermos Company and its affiliates.

TEC™ is a registered trademark of TEC INFRA-RED GRILLS. US patents pending.

Protected under one or more of the following U.S. Patents: 4,598,692; 4,624,240; 4,747,391; 4,747,391; 4,817,583; 4,924,846; 4,989,579; 5,003,960; 5,076,256; 5,076,257; 5,090,398; 5,109,834; 5,224,676; 5,277,106; 5,421,319; 5,441,226;

5,452,707; 5,458,309; 5,566,606; 5,566,606; 5,579,755; 5,582,094; 5,613,486; 5,649,475; 5,706,797; 5,711,663; 5,765,543; 5,931,149; 5,996,573; 6,095,132; 6,135,104; 6,173,644B1; 6,279,566; 6,397,731; 6,418,923; 6,439,222; 6,523,461;

D282,619; D339,714; D341,292; D343,337; D358,059; D361,466; D364,535; D372,637; D373,701; D377,735; D383,035; D397,910; D405,643; D405,643; D406,005; D406,009; D413,043; D413,229; D413,229; D414,982; D415,388; D416,164;

D416,441; D416,441; D417,587; D422,516; D423,274; D423,876; D428,303; D435,396; D436,004; D438,059; D438,060; D438,427; D439,110; D442,505; D443,179; D443,354; D447,384; D447,385; D447,909; D448,610; D448,614; D448,615;

06201297 • 11

Which product are your registering?

¿Qué producto está registrando?

Quel produit enregistrez-vous?

1. Gas Grill/Parrilla a gas/Gril au gaz

2. Electric Grill/Parrilla eléctrica/Gril électrique

3. Smoker/Ahumador/Fumoir

4. Charcoal Grill/Parrilla a carbón/Barbecue au charbon

5. Charcoal Smoker/Ahumador a carbón/Fumoir au charbon

6. Outdoor Fireplace/Chimenea para exteriores/Foyer extérieur

7. Cooker/Fryer / Cocina/freidora / Cuiseur/Friteuse

8. Other/Otro/Autre

Your Gender/Sexo/Sexe :

1. Male/Masculino/Masculin

2. Female/Femenino/Féminin

IMPORTANT!/¡IMPORTANTE!/IMPORTANT!

Write Serial Number and Model Number in spaces below.

Escriba en los espacios de abajo el número de serie y el número

de modelo.

Inscrivez le numéro de série et le numéro de modèle dans les

espaces ci-dessous.

Date of Purchase/Fecha de compra/Date de l’achat

Store Name/Nombre de la tienda/Nom du magasin

Purchase Price/Precio de compra/Prix d’achat

E-mail Address/Dirección de correo electrónico/Adresse électronique

If you voluntarily provide us with your email address, you give us permission to use your email address to send you offers that may interest you.

(Example: your name @ your host.com) (Ejemplo: su nombre@su host.com) (Exemple : votre nom@votre hôte.com)

Phone Number/Número telefónico/Numéro de téléphone

.00

Si nos informa voluntariamente su dirección de correo electrónico, nos da permiso para usarlo a fin de enviarle ofertas que pueden interesarle.

Si vous choisissez de nous fournir votre adresse électronique, vous nous donnez la permission de l’utiliser pour vous faire part d’offreusscseppétcibialeless s

City/Ciudad/Ville

de vous intéresser.

State/Estado/Province

Zip Code/Código zip/Code postal

Apt Number/N de apart./N d’appt.

O O

Address Dirección Adresse(number and street)/ (número y calle)/ (numéro et rue)

First Name/Nombre/Prénom

Please register your product online at:

(If you register online, you do not need to send in this registration card.)

Initial/Inicial/Initiale Last Name/Apellido/Nom de famille

www.grillregistration.com