Weber 7160001 Manuel utilisateur

YOU MUST READ THIS OWNER’S GUIDE

BEFORE OPERATING YOUR GAS GRILL.

m DANGER

If you smell gas:

1. Shut off gas to the appliance.

2. Extinguish any open flames.

3. Open lid.

4. If odor continues, keep away from the

appliance and immediately call your gas

supplier or your fire department.

Leaking gas may cause a fire or explosion

which can cause serious bodily injury,

death, or damage to property.

m WARNING:

1. Do not store or use gasoline or other

flammable liquids or vapors in the

vicinity of this or any other appliance.

2. An LP cylinder not connected for use

shall not be stored in the vicinity of this

or any other appliance.

m WARNING: Follow all leak-check

procedures carefully in this manual prior

to barbecue operation. Do this even if the

barbecue was dealer-assembled.

NOTICE TO INSTALLER: These instructions

must be left with the owner and the owner

should keep them for future use.

THIS GAS APPLIANCE IS DESIGNED FOR

OUTDOOR USE ONLY.

56575 09/17/10 LP

US - ENGLISH

#56575

m WARNING: Do not ignite this appliance

without first reading the BURNER

IGNITION sections of this manual.

460 - LP

Guía del propietario de la barbacoa empotrada de gas propano licuado - Pg. 35

Manuel de l’utilisateur du grill au gaz propane intégré - Pg. 69

GAS GRILL

Built-In LP Gas Grill Owner’s Guide

ESNA

2

m DANGER

Failure to follow the Dangers, Warnings and Cautions contained in this Owner’s Manual may result in serious bodily injury or

death, or in a fire or an explosion causing damage to property.

m WARNINGS

m Do not store a spare or disconnected liquid propane

cylinder under or near this barbecue.

m Improper assembly may be dangerous. Please follow the

assembly instructions carefully.

m After a period of storage, and/or nonuse, the Weber

®

gas

barbecue should be checked for gas leaks and burner

obstructions before use. See instructions in this manual for

correct procedures.

m Do not operate the Weber

®

gas barbecue if there is a gas

leak present.

m Do not use a flame to check for gas leaks.

m Combustible materials should never be within 24 inches (61

cm) of the back or sides of your Weber

®

gas barbecue.

m Do not put a barbecue cover or anything flammable on, or in

the storage area under the barbecue.

m Your Weber

®

gas barbecue should never be used by

children. Accessible parts of the barbecue may be very hot.

Keep young children away while it is in use.

m You should exercise reasonable care when operating your

Weber

®

gas barbecue. It will be hot during cooking or

cleaning and should never be left unattended, or moved

while in operation.

m Should the burners go out while in operation, turn all

gas valves off. Open the lid and wait five minutes before

attempting to relight, using the igniting instructions.

m Do not use charcoal or lava rock in your Weber

®

gas

barbecue.

m Never lean over open grill or place hands or fingers on the

front edge of the cookbox.

m Should a grease fire occur, turn off all burners and leave lid

closed until fire is out.

m Do not enlarge valve orifices or burner ports when cleaning

the valves or burners.

m The Weber

®

gas barbecue should be thoroughly cleaned on

a regular basis.

m Liquid propane gas is not natural gas. The conversion or

attempted use of natural gas in a liquid propane unit or

liquid propane gas in a natural gas unit is dangerous and

will void your warranty.

m Do not attempt to disconnect any gas fitting while your

barbecue is in operation.

m Use heat-resistant barbecue mitts or gloves when operating

barbecue.

m Keep any electrical supply cord and the fuel supply hose

away from any heated surfaces.

m Combustion byproducts produced when using this product

contain chemicals known to the state of California to cause

cancer, birth defects, or other reproductive harm.

m Do not use this barbecue unless all parts are in place. The

unit must be properly assembled according to the assembly

instructions.

m Proposition 65 Warning: Handling the brass material on

this product exposes you to lead, a chemical known to the

state of California to cause cancer, birth defects or other

reproductive harm.

(Wash hands after handling this product.)

◆

LIQUID PROPANE GAS UNITS ONLY

m Use the pressure regulator and hose assembly that is

supplied with your Weber

®

gas barbecue.

m Do not attempt to disconnect the gas regulator and hose

assembly or any gas fitting while your barbecue is in

operation.

m A dented or rusty liquid propane cylinder may be hazardous

and should be checked by your liquid propane supplier. Do

not use a liquid propane cylinder with a damaged valve.

m Although your liquid propane cylinder may appear to be

empty, gas may still be present, and the cylinder should be

transported and stored accordingly.

m If you see, smell or hear the hiss of escaping gas from the

liquid propane cylinder

1. Move away from liquid propane cylinder.

2. Do not attempt to correct the problem yourself.

3. Call your fire department.

◆

WARNINGS

WWW.WEbER.com

®

3

TAbLE oF coNTENTS

WARNINGS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2

TAbLE oF coNTENTS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3

EXPLoDED VIEW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4

EXPLoDED VIEW LIST . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5

WARRANTY . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .6

GENERAL INSTRUcTIoNS . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7

FOR INSTALLATION IN CANADA . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7

OPERATING. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7

STORAGE AND/OR NONUSE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7

NOTE: IF YOU HAVE PURCHASED A SIDEBURNER . . . . . . . . . . . . . . . . . . . . . 7

GAS INSTRUcTIoNS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .8

SAFE HANDLING TIPS FOR LIQUID PROPANE GAS CYLINDERS . . . . . . . . . . 8

IMPORTANT LP CYLINDER INFORMATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9

LEAK CHECK PREPARATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9

CHECK FOR GAS LEAKS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11

REFILLING THE LIQUID PROPANE CYLINDER . . . . . . . . . . . . . . . . . . . . . . . . . 13

LIGHT FEATURES . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .13

WEBER

®

GRILL OUT™ HANDLE LIGHT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13

LIGHTED CONTROL KNOBS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13

bEFoRE USING THE GRILL . . . . . . . . . . . . . . . . . . . . . . . . . . .14

FUEL LEVEL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14

SLIDE OUT GREASE TRAY AND DISPOSABLE DRIP PAN . . . . . . . . . . . . . . . . 14

HOSE INSPECTION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14

SNAP IGNITIoN oPERATIoN . . . . . . . . . . . . . . . . . . . . . . . . . .15

mAIN bURNER IGNITIoN & USAGE . . . . . . . . . . . . . . . . . . . . .16

MAIN BURNER IGNITION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16

TO EXTINGUISH . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16

MAIN BURNER MANUAL IGNITION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17

TO EXTINGUISH . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17

GRILLING TIPS & HELPFUL HINTS . . . . . . . . . . . . . . . . . . . . .18

PREHEATING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18

COVERED COOKING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18

DRIPPINGS AND GREASE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18

FLAVORIZER

®

SYSTEM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18

SEAR STATION

®

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18

cooKING mETHoDS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .19

DIRECT COOKING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19

INDIRECT COOKING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19

SEAR STATIoN

®

IGNITIoN & USAGE . . . . . . . . . . . . . . . . . . . .20

SEAR STATION

®

BURNER IGNITION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20

TO EXTINGUISH . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20

SEAR STATION

®

BURNER MANUAL IGNITION . . . . . . . . . . . . . . . . . . . . . . . . 21

TO EXTINGUISH . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21

USING THE SEAR STATION

®

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21

SmoKER bURNER IGNITIoN & USAGE . . . . . . . . . . . . . . . . . .22

SMOKER BURNER IGNITION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22

TO EXTINGUISH . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22

SMOKER BURNER MANUAL IGNITION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23

TO EXTINGUISH . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23

USING THE SMOKER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24

CLEANING THE SMOKER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24

RoTISSERIE bURNER IGNITIoN & USAGE . . . . . . . . . . . . . . .25

ROTISSERIE BURNER IGNITION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25

TO EXTINGUISH . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25

ROTISSERIE BURNER MANUAL IGNITION . . . . . . . . . . . . . . . . . . . . . . . . . . . . 26

TO EXTINGUISH . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 26

IMPORTANT SAFEGUARDS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 27

OPERATING THE ROTISSERIE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 27

ROTISSERIE COOKING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28

ROTISSERIE FORK STORAGE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28

TRoUbLESHooTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .29

SEAR STATIoN

®

TRoUbLESHooTING . . . . . . . . . . . . . . . . . . .30

RoTISSERIE TRoUbLESHooTING . . . . . . . . . . . . . . . . . . . . . .30

GRILL oUT™ HANDLE LIGHT TRoUbLESHooTING . . . . . . .30

mAINTENANcE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .31

CLEANING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 31

WEBER

®

SPIDER/INSECT SCREENS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 31

BURNER TUBE CLEANING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 31

REPLACING MAIN BURNERS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32

ANNUAL MAINTENANCE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 34

4

EXPLoDED VIEW

8

9

11

12

30

31

32

33

34

36

35

43

45

46

47

48

50

49

51

52

25

26

27

28

29

7

53

54

55

56

61

66

65

64

63

62

67

60

59

58

57

37

38

39

40

41

42

24

2

3

4

5

6

1

10

44

15

14

13

17

23

16

SUMMIT BI 460_LP_US_111710

18

19

20

21

22

WWW.WEbER.com

®

5

1. Shroud Hardware

2. Shroud

3. Thermometer

4. Thermometer Bezel

5. Handle

6. Grill Out™ Handle Light

7. Rotisserie Motor

8. Rotisserie Bracket

9. Warming Rack

10. Cooking Grates

11. Flavorizor

®

Bars

12. Burner Tubes

13. Left Side Vent

14. Left Filler Strip

15. Manifold

16. Control Panel Wiring Harness

17. Control Panel

18. Small Knob Bezel

19. Small Knob

20. Large Knob

21. Large Knob Bezel

22. Sear Station

®

Knob

23. Battery Housing

24. Water Baffle / Heat Shield

25. Disposable Drip Pan

26. Slide Out Grease Tray

27. Catch Pan

28. Catch Pan Holder

29. Left Door

30. Door Handles

31. Right Door

32. Front Filler Strip

33. Left Trim Piece

34. Left Frame Panel

35. Locking Caster

36. Front Wheel Alignment Panel

37. IR Burner Cover

38. Infrared Burner

39. IR Burner Box

40. IR Burner Igniter Wire

41. Thermocouple

42. IR Burner Hose

43. Rotisserie Spit Assembly

44. Smoker Box

45. Smoker Bar

46. Smoker Burner

47. Sear Station

®

Burner

48. Rear Filler Strip

49. Rear Vent

50. Rear Vent Bracket

51. Cookbox

52. Right Side Vent

53. Right Filler Strip

54. Manifold Hose

55. Bulkhead

56. Frame Support

57. Back Panel

58. Bottom Panel

59. Right Trim Piece

60. Right Frame Panel

61. Fuel Scale

62. Tank Stand

63. Tank Glides

64. Tank Stand Base

65. Matchstick Holder

66. Rear Wheel Alignment Panel

67. Caster

EXPLoDED VIEW LIST

6

WARRANTY

Weber-Stephen Products Co. (Weber) hereby warrants to the ORIGINAL PURCHASER of this Weber

®

gas grill that it will be free of defects in material and workmanship from the date of purchase as follows:

Aluminum castings: 25-years (2 years on paint; excludes fading)

Stainless steel shroud: 25-years

Porcelain-enameled shroud: 25-years

Stainless steel burners tubes: 10-years

Stainless steel cooking grates: 5-years no rust through or burn through

Stainless steel Flavorizer

®

bars: 5-years no rust through or burn through

Porcelain-enameled cast-iron cooking grates: 5-year no rust through or burn through

Porcelain-enameled cooking grates: 3-years no rust through or burn through

Porcelain-enameled Flavorizer

®

bars: 2-years no rust through or burn through

Infrared rotisserie burner: 2-years

All remaining parts: 2-years

when assembled and operated in accordance with the printed instructions accompanying it. Weber

may require reasonable proof of your date of purchase. THEREFORE, YOU SHOULD RETAIN YOUR

SALES SLIP OR INVOICE.

This Limited Warranty shall be limited to the repair or replacement of parts that prove defective under

normal use and service and which on examination shall indicate, to Weber’s satisfaction, they are

defective. Before returning any parts, contact the Customer Service Representative in your area

using the contact information on our website. If Weber confirms the defect and approves the claim,

Weber will elect to replace such parts without charge. If you are required to return defective parts,

transportation charges must be prepaid. Weber will return parts to the purchaser, freight or postage

prepaid.

This Limited Warranty does not cover any failures or operating difficulties due to accident, abuse,

misuse, alteration, misapplication, vandalism, improper installation or improper maintenance or

service, or failure to perform normal and routine maintenance, including but not limited to damage

caused by insects within the burner tubes, as set out in this owner’s manual.

Deterioration or damage due to severe weather conditions such as hail, hurricanes, earthquakes

or tornadoes, discoloration due to exposure to chemicals either directly or in the atmosphere, is not

covered by this Limited Warranty.

There are no other express warrants except as set forth herein and any applicable implied warranties

of merchantability and fitness are limited in duration to the period of coverage of this express written

Limited Warranty. Some regions do not allow limitation on how long an implied warranty lasts, so this

limitation may not apply to you.

Weber is not liable for any special, indirect or consequential damages. Some regions do not allow the

exclusion or limitation of incidental or consequential damages, so this limitation or exclusion may not

apply to you.

Weber does not authorize any person or company to assume for it any other obligation or liability in

connection with the sale, installation, use, removal, return, or replacement of its equipment; and no

such representations are binding on Weber.

This Warranty applies only to products sold at retail.

WEBER-STEPHEN PRODUCTS CO.

Customer Service Center

1890 Roselle Road, Suite 308

Schaumburg, IL 60195

USA

For replacement parts call:

1-800-446-1071

Visit www.weber.com

®

, select your country of origin, and register your grill today.

◆

WWW.WEbER.com

®

7

GENERAL INSTRUcTIoNS

With the Weber

®

gas barbecue you can grill, barbecue, roast and bake with results that

are difficult to duplicate with indoor kitchen appliances. The closed lid and Flavorizer

®

bars produce that “outdoor” flavor in the food.

Liquid Propane (LP) gas supply is easy to use and gives you more cooking control than

charcoal fuel.

• These instructions will give you the minimum requirements for assembling your

Weber

®

gas barbecue. Please read the instructions carefully before using your

Weber

®

gas barbecue. Improper assembly can be dangerous.

• Not for use by children.

• If there are local codes that apply to portable gas grills, you will have to conform to

them. Installation must conform with local codes or, in the absence of local codes,

with either the National Fuel Gas Code, ANSI Z223.1/NFPA 54, Natural Gas and

Propane Installation Code, CSA B149.1, or Propane Storage and Handling Code,

B149.2 as applicable.

• The pressure regulator supplied with the Weber

®

gas barbecue must be used. This

regulator is set for 11 inches of water column (pressure).

• This Weber

®

gas barbecue is designed for use with liquid propane (LP) gas only. Do

not use with natural (piped in city) gas. The valves, orifices, hose and regulator are for

LP gas only.

• Do not use with charcoal fuel.

• Check that the area under the control panel and the bottom tray are free from debris

that might obstruct the flow of combustion or ventilation air.

• The areas around the LP cylinder must be free and clear from debris.

• Replacement pressure regulators and hose assemblies must be those specified by

Weber-Stephen Products Co.

◆

FOR INSTALLATION IN CANADA

These instructions, while generally acceptable, do not necessarily comply with the

Canadian Installation codes, particularly with piping above and below ground. In

Canada the installation of this appliance must comply with local codes and/or Standard

CSA-B149.2 (Propane Storage and Handling Code).

◆

OPERATING

m WARNING: Only use this barbecue outdoors in a well-

ventilated area. Do not use in a garage, building, breezeway

or any other enclosed area.

m WARNING: Keep the ventilation openings of the cylinder

enclosure free and clear of debris.

m WARNING: Your Weber

®

gas barbecue shall not be used

under overhead combustible construction.

m WARNING: Do not use the barbecue within 24 inches (610

mm) of combustible materials, top, bottom, back or sides of

the grill.

m WARNING: The entire cooking box gets hot when in use. Do

not leave unattended.

m WARNING: Keep any electrical supply cord and the fuel

supply hose away from any heated surface.

m WARNING: Keep the cooking area clear of flammable vapors

and liquids such as gasoline, alcohol, etc., and combustible

materials.

m WARNING: Never store an extra (spare) LP cylinder under or

near the Weber

®

gas barbecue.

m WARNING: Keep the ventilation openings of the cylinder

enclosure free and clear of debris.

m WARNING: Turn off the gas at the LP gas supply cylinder

when the outdoor cooking gas appliance is not in use.

m WARNING: Never store an extra (spare) LP cylinder under or

near the Weber

®

gas barbecue.

m WARNING: LP cylinders must be stored outdoors out of

the reach of children and must not be stored in a building,

garage, or any other enclosed area.

m WARNING: The LP cylinder used with your barbecue must

be with a listed OPD (Overfilling Prevention Device) and

a QCC1 or Type 1 (CGA810) cylinder connection. The

cylinder connection must be compatible with the barbecue

connection.

◆

STORAGE AND/OR NONUSE

• The gas must be turned off at the liquid propane cylinder when the Weber® gas

barbecue is not in use.

• LP cylinder must be stored outdoors in a well-ventilated area out of reach of children.

Disconnected LP cylinder must not be stored in a building, garage or any other

enclosed area.

• Check that the areas under the control panel and the slide out bottom tray are free

from debris that might obstruct the flow of combustion or ventilation air.

• The Spider/Insect screens should also be checked for any obstructions. (Refer to

“MAINTENANCE/ANNUAL MAINTENANCE”).

◆

NOTE: IF YOU HAVE PURCHASED A SIDEBURNER

If you have purchased a Side Burner accessory with your Summit

®

gas grill, Weber

®

recommends that you read the SUMMIT

®

BUILT-IN SIDEBURNER INSTALLATION/

OWNER’S GUIDE before designing your “island” structure.

◆

8

GAS INSTRUcTIoNS

SAFE HANDLING TIPS FOR LIQUID PROPANE GAS CYLINDERS

• Liquid Propane (LP) gas is a petroleum product as are gasoline and natural gas. LP

gas is a gas at regular temperatures and pressures. Under moderate pressure, inside

a cylinder, LP gas is a liquid. As the pressure is released, the liquid readily vaporizes

and becomes gas.

• LP gas has an odor similar to natural gas. You should be aware of this odor.

• LP gas is heavier than air. Leaking LP gas may collect in low areas and prevent

dispersion.

• To fill, take the LP cylinder to a gas propane dealer, or look up “gas-propane” in the

phone book for other sources of LP gas.

m WARNING: We recommend that your LP cylinder be filled

at an authorized LP gas dealer, by a qualified attendant,

who fills the tank by weight. IMPROPER FILLING IS

DANGEROUS.

• Air must be removed from a new LP cylinder before the initial filling. Your LP dealer is

equipped to do this.

• The LP cylinder must be installed, transported and stored in an upright position. LP

cylinders should not be dropped or handled roughly.

• Never store or transport the LP cylinder where temperatures can reach 125° F (too

hot to hold by hand - for example: do not leave the LP cylinder in a car on a hot day).

Note: A refill will last about 18-20 hours of cooking time at normal use. The fuel scale, a

feature on some of our grills, will indicate the propane supply so you can refill before

running out. You do not have to run out before you refill.

• Treat “empty” LP cylinders with the same care as when full. Even when the LP tank

is empty of liquid there still may be gas pressure in the cylinder. Always close the

cylinder valve before disconnecting.

m CAUTION: Place dust cap on cylinder valve outlet whenever

the cylinder is not in use. Only install the type of dust cap

on the cylinder valve outlet that is provided with the cylinder

valve. Other types of caps or plugs may result in leakage of

propane.

• Do not use a damaged LP cylinder. Dented or rusty LP cylinders or LP cylinders

with a damaged valve may be hazardous and should be replaced with a new one

immediately.

• The joint where the hose connects to the LP cylinder must be leak tested each time

the LP cylinder is reconnected. For example, test each time the LP cylinder is refilled.

• Be sure the regulator is mounted with the small vent hole pointed downward so that it

will not collect water. This vent should be free of dirt, grease, bugs etc.

• The gas connections supplied with your Weber

®

gas appliance have been designed

and tested to meet 100% CSA and ANSI requirements.

m WARNING: Replacement LP tanks must match the regulator

connection supplied with this Weber

®

gas appliance.

Liquid Propane Cylinder Requirements

• Check to be sure cylinders have a D.O.T. certification (1), and date tested (2) is within

five years of use. Your LP gas supplier can do this for you.

• All LP tank supply systems must include a collar to protect the cylinder valve.

• The LP cylinder must be a 20-lb. size approximately 18¼ inches high, 12¼ inches in

diameter.

• The cylinder must be constructed and marked in accordance with the Specifications

for LP - Gas Cylinders of the U.S. Department of Transportation (D.O.T.) or the

National Standard of Canada, CAN/CSA-B339, Cylinders, Spheres and Tubes or

Transportation of Dangerous Goods; and Commission, as applicable.

Canadian Liquid Propane Cylinder Requirements

Note: Your retailer can help you match a replacement tank to your barbecue.

• The LP cylinder must be constructed and marked in accordance with the

specifications for LP gas cylinders, T.C.

◆

WWW.WEbER.com

®

9

m DANGER

Do not use an open flame to check for gas leaks. Be sure

there are no sparks or open flames in the area while you

check for leaks. Sparks or flames will result in a fire or

explosion which can cause serious bodily injury or death,

and damage to property.

GAS INSTRUcTIoNS

IMPORTANT LP CYLINDER INFORMATION

m DANGER

NEVER store a spare LP cylinder under or near Weber

®

gas

appliances. NEVER fill the tank beyond 80% full. Failure to

follow these statements exactly may result in a fire causing

death or serious injury.

Weber

®

gas appliances are equipped for a cylinder supply system designed for vapor

withdrawal.

m WARNING: Only use Weber

®

gas appliances outdoors in

a well-ventilated area. Do not use in a garage, building,

breezeway or any other enclosed area.

The proper filling methods for the filling of your cylinder are by weight or volume, as

described in NFPA 58. Please make sure your filling station fills your LP cylinder by

weight or volume. Ask your filling station to read purging and filling instructions on the LP

cylinder before attempting to fill.

◆

LEAK CHECK PREPARATION

Check That All Burner Valves Are Off

Valves are shipped in the OFF position, but you should check to be sure that they are

turned off. Check by pushing down and turning clockwise. If they do not turn, they are off.

If they do turn, continue turning them clockwise until they stop, then they are off.

The Liquid Propane Cylinder

All Weber

®

liquid propane gas grill regulators are equipped with a UL-Listed tank

connection as per the latest edition of ANSI Z21.58. This will require a liquid propane

tank that is similarly equipped with a Type 1 connection in the tank valve. This Type 1

coupling allows you to make a fast and totally safe hookup between your gas grill and

your liquid propane tank. It eliminates the chance of leaks due to a POL fitting that is

not properly tightened. Gas will not flow from the tank unless the Type 1 coupling is fully

engaged into the coupling.

m WARNING: Make sure that the LP cylinder valve is closed.

Close by turning valve clockwise.

3

1

2

4

5

TYPE 1 coNNEcTIVE coUPLING

1 Type 1 Valve

2 Hand Wheel

3 External Thread

4 Thermally Sensitive Nut

5 Propane Regulator

10

Some LP tanks have differing top collar assembles. (The top collar is the metal

protective ring around the valve.) One series of tanks mount with the valve facing front

(1). The other tanks mount with the valve facing away from the fuel scale (2). Weber

recommends the use of cylinder manufacturer’s Manchester and Worthington, with a

47.6 lb water capacity. Other cylinders may be acceptable for use with the appliance

provided they are compatible with the appliance retention means (see illustrations).

The LP cylinder is installed inside the tank enclosure, on the tank scale (right side).

A) Loosen cylinder lock wing nut. Swing cylinder lock up (3).

B) Turn the LP cylinder so the opening of the valve is either to the front or rear of the

Weber

®

gas barbecue.

C) Lift tank up into position on the tank scale (4).

D) Swing the cylinder lock down. Tighten the wing nut.

Connect The Hose To The Cylinder

A) Remove the plastic dust cover from the valve.

B) Screw the regulator coupling onto the tank valve, clockwise, or to the right. Hand-

tighten only (5).

Note: This connection tightens clockwise and will not allow gas to flow unless the

connection is tight. The connection requires tightening by hand only.

m WARNING: Do not use a wrench to tighten the connection.

Using a wrench could damage the regulator coupling and

could cause a leak.

GAS INSTRUcTIoNS

1 2

3 3

5

4

WWW.WEbER.com

®

11

2

3

4

1

m WARNING: The gas connections of your Summit

®

gas grill

have been factory tested. We do however recommend that

you leak check all gas connections before operating your

Summit

®

gas grill.

Remove Control Panel

Parts required: Phillips screwdriver and a towel.

A) Remove the burner control knobs (1).

B) Open both doors and place a towel on top of the doors. This will protect the control

panel and tops of the doors from getting scratched on the next step.

C) Remove the screws from the underside of the control panel with a Phillips

screwdriver (2).

D) Tilt the conrol panel forward and lift up and away from the grill (3) (For Summit

®

models with LED features: Be careful not to break or disconnect the wires for the

control panel LED’s).

E) Place the control panel on the towel covering the door assemblies (4).

◆

GAS INSTRUcTIoNS

Note: All factory-made connections have been thoroughly checked for gas leaks. The

burners have been flame-tested. As a safety precaution however, you should recheck all

fittings for leaks before using your Weber® gas barbecue. Shipping and handling may

loosen or damage a gas fitting.

m WARNING: The gas connections of your gas grill have been

factory tested. We do however recommend that you leak

check all gas connections before operating your gas grill.

m WARNING: Perform these leak checks even if your barbecue

was dealer or store assembled.

If your grill has a side burner make sure the side burner is turned off.

Turn on gas supply at source.

m WARNING: Do not ignite burners when leak checking.

You will need: A soap and water solution and a rag or brush to apply it.

A) Mix soap and water.

B) Turn on gas supply (1).

C) Check for leaks by wetting the fitting with the soap and water solution and watching

for bubbles. If bubbles form, or if a bubble grows, there is a leak.

If there is a leak, turn off the gas and tighten the fitting. Turn the gas back on and

recheck with the soap and water solution. If leak does not stop do not use the

barbecue. Contact the customer service representative in your area using the

contact information on our web site. Log onto www.weber.com

®

.

D) When leak checking is complete, turn gas supply off at the source and rinse

connections with water.

Note: Since some leak test solutions, including soap and water, may be slightly

corrosive, all connections should be rinsed with water after checking for leaks.

m WARNING: You should check for gas leaks every time you

disconnect and reconnect a gas fitting.

CHECK FOR GAS LEAKS

m DANGER

Do not use an open flame to check for gas leaks. Be sure

there are no sparks or open flames in the area while you

check for leaks. Sparks or open flames will result in a fire or

explosion, which can cause serious bodily injury or death

and damage to property.

1

The grill illustrated

may have slight

differences than the

model purchased.

12

3

4

5

6

7

1

2

GAS INSTRUcTIoNS

Check

A) Main gas line to manifold connection (1).

B) Rotisserie (I.R. Burner) gas line connection (2).

C) Bulkhead and gas supply hose connection (3).

D) Corregated gas line to bulkhead connection (4).

m WARNING: If there is a leak at connection (1, 2, 3, or 4),

retighten the fitting with a wrench and recheck for leaks with

soap and water solution.

If a leak persists after re-tightening the fitting, turn off the

gas. DO NOT OPERATE THE GRILL. Contact the Customer

Service Representative in your area using the contact

information on our web site. Log onto www.weber.com

®

.

E) Hose to regulator connection (5).

F) Regulator to cylinder connection (6).

G) Valves to manifold connections (7).

m WARNING: If there is a leak at connections (5, 6 or 7 ), turn

off the gas. DO NOT OPERATE THE GRILL. Contact the

Customer Service Representative in your area using the

contact information on our web site.

Log onto www.weber.com

®

.

When leak checks are complete, turn gas supply off at the source and rinse connections

with water.

Reinstall Control Panel

Parts required: control panel, screws and burner control knobs.

A) Hook the top edge of the control panel onto the control panel brackets on either side

of the front of the cooking box.

B) Line up screws with screw holes on both the control panel bracket and the frame.

Tighten screws.

C) Place corresponding control knobs onto the valve stems.

◆

The grill illustrated may have slight

differences than the model purchased.

WWW.WEbER.com

®

13

WEBER

®

GRILL OUT™ HANDLE LIGHT

The Weber Grill Out™ Handle Light has a built-in “Tilt Sensor.” With the power button (1)

activated, the light will come on when the grill lid is open. The light will turn off when the

lid is closed. For daytime use, deactivate the sensor by pressing power button (1).

◆

1

LIGHTED CONTROL KNOBS

Your gas grill comes with control knobs that light up; allowing you to fine tune heat

settings, even in low light conditions.

Requires 3 “D” alkaline batteries. Do not mix old and new batteries or different types

of batteries (standard, alkaline or rechargeable). Battery housing is located inside the

cabinet on the left side.

To operate, activate power button.

◆

GAS INSTRUcTIoNS

REFILLING THE LIQUID PROPANE CYLINDER

We recommend that you refill the LP cylinder before it is completely empty.

Removal of the LP cylinder:

A) Close cylinder valve (turn clockwise) (1).

B) Unscrew regulator coupling by turning counterclockwise, by hand only (2).

C) Loosen cylinder lock wing nut and turn cylinder lock up out of the way (3).

D) Lift cylinder off.

To fill, take the LP cylinder to a gas propane dealer, or look up “gas-propane” in the

phone book for other sources of LP gas.

m WARNING: We recommend that your LP cylinder be filled

at an authorized LP gas dealer, by a qualified attendant,

who fills the cylinder by weight. IMPROPER FILLING IS

DANGEROUS.

m CAUTION: Place dust cap on cylinder valve outlet whenever

the cylinder is not in use. Only install the type of dust cap

on the cylinder valve outlet that is provided with the cylinder

valve. Other types of caps or plugs may result in leakage of

propane.

◆

LIGHT FEATURES

2

1

3

14

bEFoRE USING THE GRILL

FUEL LEVEL

There are two ways to check the fuel level in your tank; electronically and manually.

To check the level using the Electronic Tank Scale, press the tank scale button, located

on the right of the control panel, for 2-3 seconds. The LED indicates the fuel level in the

tank.

To check the level using the Manual Tank Scale, view the color indicator level line,

located on the side of the tank scale.

A) Empty (1)

B) Medium (2)

C) Full (3)

◆

SLIDE OUT GREASE TRAY AND DISPOSABLE DRIP PAN

Your grill was built with a grease collection system. Check the slide out grease tray and

disposable drip pan for grease build-up each time you use your grill.

Remove excess grease with a plastic spatula; see illustration. When necessary, wash

the grease tray and drip pan with a soap and water solution, then rinse with clean water.

Replace the disposable drip pan as needed.

m WARNING: Check the slide out grease tray and disposable

drip pan for grease build-up before each use. Remove

excess grease to avoid a grease fire. A grease fire can cause

serious bodily injury or damage to property.

m CAUTION: Do not line the slide out grease tray with

aluminum foil.

◆

The grill illustrated may

have slight differences

than the model purchased.

HOSE INSPECTION

The hose should be inspected for any signs of cracking.

m WARNING: Check hose before each use of barbecue for

nicks, cracking, abrasions or cuts. If the hose is found to

be damaged in any way, do not use the barbecue. Replace

using only Weber

®

authorized replacement hose. Contact

the Customer Service Representative in your area using the

contact information on our web site.

Log onto www.weber.com

®

.

◆

1 32

WWW.WEbER.com

®

15

2

1

3

4

5

m Always open the lid before igniting the burners.

A) Each control knob has its own igniter electrode built in. To create a spark you must

push the control knob in (1) and turn to START/HI (2).

B) This action will generate gas flow and a spark to the burner lighting tube (3). You will

hear a “snap” from the igniter. You will also see a 3 - 5 orange flame coming from the

burner lighting tube at the left side of the burner (4).

C) Continue to hold the burner control knob in for two seconds after the “snap”.

This will allow gas to flow completely down the burner tube (5) and insure ignition.

D) Check that the burner is lit by looking through the cooking grates. You should see

a flame. If burner does not light on first try, push control knob in and turn to OFF.

Repeat lighting procedure a second time.

m WARNING: If the burner still does not light, turn the burner

control knob to OFF and wait five minutes to let the gas

clear before you try again or try to light with a match.

◆

SNAP IGNITIoN oPERATIoN

16

m DANGER

When the “excess gas flow control” feature is activated,

a small amount of gas is still flowing to the burners. After

turning off the cylinder and burner control knobs, wait at

least five minutes for the gas to clear before attempting to

light the grill. Failure to do so may result in an explosive

flare-up, which can cause serious bodily injury or death.

2 4

mAIN bURNER IGNITIoN & USAGE

1

2

4

5

3

MAIN BURNER IGNITION

Summary lighting instructions are inside the left hand cabinet door.

m DANGER

Failure to open the lid while igniting the barbecue’s burners,

or not waiting five minutes to allow the gas to clear if the

barbecue does not light, may result in an explosive flare-up

which can cause serious bodily injury or death.

Main Burner Snap Ignition

Note: Each control knob snap igniter creates a spark from the igniter electrode to the

burner lighting tube. You generate the energy for the spark by pushing in the control

knob and turning to START/HI. This will ignite each individual burner.

m WARNING: Check hose before each use of barbecue for

nicks, cracking, abrasions or cuts. If the hose is found to

be damaged in any way, do not use the barbecue. Replace

using only Weber

®

authorized replacement hose. Contact

the Customer Service Representative in your area using the

contact information on our web site.

Log onto www.weber.com

®

.

A) Open the lid (1).

B) Make sure all burner control knobs are turned off (2). (Push control knob in and turn

clockwise to ensure that it is in the OFF position.)

m WARNING: The burner control knobs must be in the OFF

position before turning on the liquid propane cylinder tank

valve. If they are not in the OFF position, when you turn on

the LP cylinder valve, the “excess gas flow control” feature

will activate, limiting the flow of gas from the LP cylinder. If

this should occur, turn off the LP cylinder valve and burner

control knobs. Start over.

The grill illustrated may have slight

differences than the model purchased.

C) Turn the cylinder on by turning the cylinder valve counterclockwise (3).

m WARNING: Do not lean over the open barbecue.

D) Push the control knob in and turn to START/HI until you hear the igniter snap (4),

continue to hold control knob in for two seconds. This action will spark the igniter,

the burner lighting tube and then main burner.

E) Check that the burner is lit by looking through the cooking grates (5). You should

see a flame. If burner does not light on first try, push control knob in and turn to OFF.

Repeat lighting procedure a second time.

m WARNING: If the burner still does not light, turn the burner

control knob to OFF and wait five minutes to let the gas

clear before you try again or try to light with a match.

◆

TO EXTINGUISH

Push in and turn each burner control knob clockwise to OFF position. Turn gas supply off

at the source.

◆

OFF START/HI MEDIUM LOW

WWW.WEbER.com

®

17

1

2

5

4

3

MAIN BURNER MANUAL IGNITION

m DANGER

Failure to open the lid while igniting the barbecue’s burners,

or not waiting five minutes to allow the gas to clear if the

barbecue does not light, may result in an explosive flare-up

which can cause serious bodily injury or death.

The grill illustrated may

have slight differences

than the model purchased.

A) Open the lid (1).

B) Make sure all burner control knobs are turned off (2). (Push each knob in and turn

clockwise to ensure they are in the OFF position.)

m WARNING: The burner control knobs must be in the OFF

position before turning on the liquid propane cylinder valve.

If they are not in the OFF position, when you turn on the LP

cylinder valve, the “excess gas flow control” feature will

activate, limiting the flow of gas from the LP cylinder. If this

should occur, turn off the LP tank valve and burner control

knobs. Start over.

m DANGER

When the “excess gas flow control” feature is activated,

a small amount of gas is still flowing to the burners. After

turning off the cylinder and burner control knobs, wait at

least five minutes for the gas to clear before attempting to

light the barbecue. Failure to do so may result in an explosive

flare-up, which can cause serious bodily injury or death.

2 5

C) Turn the cylinder on by turning the cylinder valve counterclockwise (3).

D) Put match in the match holder and strike match.

m WARNING: Do not lean over open barbecue.

E) Insert match holder and lit match down through cooking grates and Flavorizer

®

bars

to ignite the selected burner (4).

F) Push the control knob in and turn to START/HI (5).

m WARNING: If the burner does not light, turn the burner

control knob to OFF and wait five minutes to let the gas

clear before you try again.

◆

TO EXTINGUISH

Push in and turn each burner control knob clockwise to OFF position. Turn gas supply off

at the source.

◆

mAIN bURNER IGNITIoN & USAGE

18

GRILLING TIPS & HELPFUL HINTS

Note: The temperature inside your cookbox for the first few uses, while surfaces are still

very reflective, may be hotter than those shown in your cookbook. Cooking conditions,

such as wind and weather, may require the adjustment of the burner controls to obtain

the correct cooking temperatures.

If burners go out during cooking, turn off all burners and wait five minutes before

relighting.

◆

PREHEATING

Your Weber

®

gas barbecue is an energy-efficient appliance. It operates at an economical

low BTU rate. Preheating the grill before grilling is important. Light your grill according

to the instructions in this Owner’s Manual. To preheat: after lighting turn all burners to

START/HI, close the lid, and heat until the temperature reaches between 500° and 550°

F (260° and 290° C), the recommended broiling temperature. This will take 10 to 15

minutes depending on conditions such as air temperature and wind.

◆

COVERED COOKING

All grilling is done with the lid down to provide uniform, evenly circulated heat. With the

lid closed, the gas grill cooks much like a convection oven. The thermometer in the lid

indicates the cooking temperature inside the grill. All preheating and grilling is done with

the lid down. No peeking — heat is lost every time you lift the lid.

◆

DRIPPINGS AND GREASE

The Flavorizer

®

bars are designed to “smoke” the correct amount of drippings for

flavorful cooking. Excess drippings and grease will accumulate in the catch pan under

the slide out grease tray. Disposable foil drip pans are available that fit the catch pan.

m WARNING: Check the slide out grease tray and catch pan

for grease build-up before each use. Remove excess grease

to avoid a grease fire in the slide out grease tray.

◆

• Always preheat the grill before cooking. Set all burners on HI heat and close lid; heat

for 10 minutes, or until thermometer registers 500°-550° F (260°-288°C).

• Sear meats and cook with the lid down for perfectly grilled food every time.

• Grilling times in recipes are based on 70°F (20°C) weather and little or no wind. Allow

more cooking time on cold or windy days, or at higher altitudes. Allow less cooking

time in extremely hot weather.

• Grilling times can vary because of the weather, or the amount, size and shape of the

food being grilled.

• The temperature of your gas grill may run hotter than normal for the first few uses.

• Grilling conditions may require the adjustment of the burner controls to attain the

correct cooking temperatures.

• In general, large pieces of meat will require more cooking time per pound than small

pieces of meat. Foods on a crowded cooking grate will require more cooking time

than just a few foods. Foods grilled in containers, such as baked beans, will require

more time if grilled in a deep casserole rather than a shallow baking pan.

• Trim excess fat from steaks, chops and roasts, leaving no more than a scant ¼ inch

(6.4mm) of fat. Less fat makes cleanup easier, and is a virtual guarantee against

unwanted flare-ups.

• Foods placed on the cooking grate directly above burners may require turning or

moving to a less hot area.

• Use tongs rather than a fork for turning and handling meats to avoid losing natural

juices. Use two spatulas for handling large whole fish.

• If an unwanted flare-up should occur, turn all burners off and move food to another

area of the cooking grate. Any flames will quickly subside. After flames subside, relight

the grill. NEVER USE WATER TO EXTINGUISH FLAMES ON A GAS GRILL.

• Some foods, such as a casserole or thin fish fillets, will require a container for grilling.

Disposable foil pans are very convenient, but any metal pan with ovenproof handles

can also be used.

• Always be sure the slide out grease tray and catch pan are clean and free from debris.

• Do not line the slide out grease tray with foil. This could prevent the grease from

flowing into the catch pan.

• Using a timer will help to alert you when “well-done” is about to become “over-

done.”

Note: If grill looses heat while cooking refer to the troubleshooting section of this

manual.

m WARNING: Do not move the Weber

®

gas barbecue when

operating or while barbecue is hot.

You can adjust the individual burners as desired. The control settings (1) are OFF,

START/HI, MEDIUM, or LOW.

OFF START/HI MEDIUM LOW

1

ARRÊTÉ

APAGADO

OFF ON

2

FLAVORIZER

®

SYSTEM

When meat juices drip from the food onto the specially angled Flavorizer

®

bars,

they create smoke that gives foods an irresistible barbecued flavor. Thanks to the

unique design of the burners, Flavorizer

®

bars and the flexible temperature controls,

uncontrolled flare-ups are virtually eliminated, because YOU control the flames. Because

of the special design of the Flavorizer

®

bars and burners, excess fats are directed

through the slide out grease tray into the grease catch pan.

◆

SEAR STATION

®

Your Weber

®

gas barbecue may include a sear burner for searing thin meats and

fish. The Sear Station

®

burner has an OFF, START/HI, or LOW control setting (2) that

works with the two adjacent main burners. With the sear and adjacent burners you can

effectively sear meats while using other cooking areas for cooking with moderate heat

(Refer to “SEAR STATION

®

IGNITION & USAGE (330 MODEL)” section).

◆

WWW.WEbER.com

®

19

The most important thing to know about grilling is which cooking method to use for a

specific food, Direct or Indirect. The difference is simple: place the food directly over the

fire, or arrange the fire on either side of it. Using the right method is the shortest route to

great results—and the best way to ensure doneness safety.

◆

DIRECT COOKING

The Direct Method, similar to broiling, means the food is cooked directly over the heat

source. For even cooking, food should be turned once halfway through the grilling time.

Use the Direct method for foods that take less than 25 minutes to cook: steaks, chops,

kabobs, sausages, vegetables, and more.

Direct cooking is also necessary to sear meats. Searing creates that wonderful crisp,

caramelized texture where the food hits the grate. It also adds great color and flavor to

the entire surface. Steaks, chops, chicken breasts, and larger cuts of meat all benefit

from searing.

To sear meats, place them over Direct High heat for 2 to 5 minutes per side. Smaller

pieces require less searing time. Usually after searing you finish cooking the food at a

lower temperature. You can finish cooking fast-cooking foods by the Direct method; use

the Indirect method for longer-cooking foods.

To set up your gas grill for Direct cooking, preheat the grill with all burners on HI. Place

food on the cooking grate, and then adjust all burners to the temperature noted in the

recipe. Close the lid of the grill and lift it only to turn food or to test for doneness at the

end of the recommended cooking time.

◆

INDIRECT COOKING

The Indirect Method is similar to roasting, but with the added benefits of that grilled

texture, flavor, and appearance you can’t get from an oven. To set up for Indirect cooking,

gas burners are lit on either side of the food but not directly beneath it. Heat rises,

reflects off the lid and inside surfaces of the grill, and circulates to slowly cook the food

evenly on all sides, much like a convection oven, so there’s no need to turn the food.

Use the Indirect method for foods that require 25 minutes or more of grilling time or that

are so delicate that direct exposure to the flame would dry them out or scorch them.

Examples include roasts, ribs, whole chickens, turkeys, and other large cuts of meat, as

well as delicate fish fillets.

To set up your gas grill for Indirect cooking, preheat the grill with all burners on HI. Then

adjust the burners on each side of the food to the temperature noted in the recipe and

turn off the burner(s) directly below the food. For best results, place roasts, poultry,

or large cuts of meat on a roasting rack set inside a disposable heavy-gauge foil pan.

For longer cooking times, add water to the foil pan to keep drippings from burning. The

drippings can be used to make gravies or sauces.

◆

cooKING mETHoDS

4 bURNER

DIREcT mETHoD

Food is placed on the area of the cooking grates directly over the lit burners.

4 bURNER

INDIREcT mETHoD

Food is placed on the area of the cooking grates between the lit burners.

20

SEAR STATIoN

®

IGNITIoN & USAGE

1

75

2

6

4

3

The grill illustrated may

have slight differences

than the model purchased.

2 6

m DANGER

When the “excess gas flow control” feature is activated,

a small amount of gas is still flowing to the burners. After

turning off the cylinder and burner control knobs, wait at

least five minutes for the gas to clear before attempting to

light the grill. Failure to do so may result in an explosive

flare-up, which can cause serious bodily injury or death.

C) Turn the cylinder on by turning the cylinder valve counterclockwise (3).

m WARNING: Do not lean over the open barbecue.

D) Ignite each adjacent Sear Station

®

main burner (4). Push the control knob in and

turn to START/HI until you hear the igniter snap - continue to hold control knob in

for two seconds. This action will spark the igniter, the burner lighting tube and then

main burner.

E) Check that the burner is lit by looking through the cooking grates (5). You should

see a flame. If burner does not light on first try, push control knob in and turn to OFF.

Repeat lighting procedure a second time.

Sear Station

®

Burner Lighting: Ignition By An Adjacent Ignited Main Burner

F) Turn Sear Station

®

burner control knob to the ON position (6).

G) Verify burner ignition by visual inspection of a flame (7).

m WARNING: If ignition does not occur in 5 seconds, turn

burner control OFF, wait five minutes, and repeat steps F &

G, or see “SEAR STATION

®

BURNER MANUAL IGNITION”

instructions.

m WARNING: If the burner still does not light, turn the burner

control knob to OFF and wait five minutes to let the gas

clear before you try again or try to light with a match.

Note: See “MAINTENANCE” for burner removal and cleaning

procedure.

◆

TO EXTINGUISH

Push in and turn each burner control knob clockwise to OFF position. Turn gas supply off

at the source.

◆

SEAR STATION

®

BURNER IGNITION

Summary lighting instructions are inside the left hand cabinet door.

m DANGER

Failure to open the lid while igniting the barbecue’s burners,

or not waiting five minutes to allow the gas to clear if the

barbecue does not light, may result in an explosive flare-up

which can cause serious bodily injury or death.

The Sear Station

®

burner has an on or off control setting. To ignite the Sear Station

®

burner you must first ignite the two adjacent main burners.

Adjacent Main Burner Snap Ignition

Note: Each main burner control knob snap igniter creates a spark from the igniter

electrode to the burner lighting tube. You generate the energy for the spark by pushing

in the control knob and turning to START/HI. This will ignite each individual burner.

m WARNING: Check hose before each use of barbecue for

nicks, cracking, abrasions or cuts. If the hose is found to

be damaged in any way, do not use the barbecue. Replace

using only Weber

®

authorized replacement hose. Contact

the Customer Service Representative in your area using the

contact information on our web site.

Log onto www.weber.com

®

.

A) Open the lid (1).

B) Make sure all burner control knobs are turned off (2). (Push control knob in and turn

clockwise to ensure that it is in the OFF position.)

m WARNING: The burner control knobs must be in the OFF

position before turning on the liquid propane cylinder tank

valve. If they are not in the OFF position, when you turn on

the LP cylinder valve, the “excess gas flow control” feature

will activate, limiting the flow of gas from the LP cylinder. If

this should occur, turn off the LP cylinder valve and burner

control knobs. Start over.

ARRÊTÉ

APAGADO

OFF ON

La page charge ...

Weber 7160001 Manuel utilisateur

Ce manuel convient également à

Weber 7160001 Manuel utilisateur

dans d''autres langues

Documents connexes

Autres documents