Weber E320NG-2011 Le manuel du propriétaire

Marque: Weber

Modèle: E320NG-2011

Catégorie: Barbecues

Taper: Le manuel du propriétaire

Ce manuel convient également à

E330NG-2011

320/330

YOU MUST READ THiS OWNER'S GUIDE

BEFORE OPERATING YOUR GAS GRILL.

Z_ DANGER

if you smell gas:

1. Shut off gas to the appliance.

2. Extinguish any open flames.

3. Open lid.

4. if odor continues, keep away from the

appliance and immediately call your gas

supplier or your fire department.

Leaking gas may cause a fire or explosion

which can cause serious bodily injury or

death, or damage to property.

ik WARNING:

1. Do not store or use gasoline or other

flammable liquids or vapors in the

vicinity of this or any other appliance.

2. An LP cylinder not connected for use

shall not be stored in the vicinity of this

or any other appliance.

I [ z_ WARNING: Follow all leak-check

procedures carefully in this manual prior

to barbecue operation. Do this even if the

barbecue was dealer-assembled.

NOTICE TO iNSTALLER: These instructions

must be left with the owner and the owner

should keep them for future use.

_THIS GAS APPLIANCE iS DESIGNED FOR 1

OUTDOOR USE ONLY.

z_ WARNING: Do not ignite this appliance

without first reading the BURNER

iGNiTiON sections of this manual.

A#_ MEMBER

Nati0naiPROPANEGAS A_ciati0_

56511 09/17/10 NG

US ENGLISH

DANGER

Failure to follow the Dangers, Warnings and Cautions contained in this Owner's Manual may result in serious bodily injury or

death, or in a fire or an explosion causing damage to property.

WARNINGS

z_ Do not store a spare or disconnected liquid propane

cylinder under or near this barbecue.

z_ Improper assembly may be dangerous. Please follow the

assembly instructions carefully.

z_ After a period of storage, and/or nonuse, the Weber ®gas

barbecue should be checked for gas leaks and burner

obstructions before use. See instructions in this manual for

correct procedures.

z_ Do not operate the Weber _ gas barbecue if there is a gas

leak present.

z_ Do not use a flame to check for gas leaks.

z_ Combustible materials should never be within 24 inches (61

cm) of the back or sides of your Weber ®gas barbecue.

z_ Do not put a barbecue cover or anything flammable on, or in

the storage area under the barbecue.

z_ Your Weber ®gas barbecue should never be used by

children. Accessible parts of the barbecue may be very hot.

Keep young children away while it is in use.

Z_ You should exercise reasonable care when operating your

Weber ®gas barbecue, it will be hot during cooking or

cleaning and should never be left unattended, or moved

while in operation.

Z_ Should the burners go out while in operation, turn all

gas valves off. Open the lid and wait five minutes before

attempting to relight, using the igniting instructions.

z_ Do not use charcoal or lava rock in your Weber _ gas

barbecue.

Z_ Never lean over open grill or place hands or fingers on the

front edge of the cookbox.

Z_ Should a grease fire occur, turn off all burners and leave lid

closed until fire is out.

z_ Do not enlarge valve orifices or burner ports when cleaning

the valves or burners.

z_ The Weber ®gas barbecue should be thoroughly cleaned on

a regular basis.

Z_ Liquid propane gas is not natural gas. The conversion or

attempted use of natural gas in a liquid propane unit or

liquid propane gas in a natural gas unit is dangerous and

will void your warranty.

Z_ Do not attempt to disconnect any gas fitting while your

barbecue is in operation.

Z_ Use heat-resistant barbecue mitts or gloves when operating

barbecue.

Z_ Keep any electrical supply cord and the fuel supply hose

away from any heated surfaces.

Z_ Combustion byproducts produced when using this product

contain chemicals known to the state of California to cause

cancer, birth defects, or other reproductive harm.

Z_ Do not use this barbecue unless all parts are in place. The

unit must be properly assembled according to the assembly

instructions.

Z_ Do not build this model of grill in any built-in or slide in

construction, ignoring this Warning could cause a fire or

an explosion that can damage property and cause serious

bodily injury or death.

Z_ Proposition 65 Warning: Handling the brass material on

this product exposes you to lead, a chemical known to the

state of California to cause cancer, birth defects or other

reproductive harm.

(Wash hands after handling this product.)

LIQUID PROPANE GAS UNITS ONLY:

z_ Use the pressure regulator and hose assembly that is

supplied with your Weber ®gas barbecue.

z_ Do not attempt to disconnect the gas regulator and hose

assembly or any gas fitting while your barbecue is in

operation.

z_ A dented or rusty liquid propane cylinder may be hazardous

and should be checked by your liquid propane supplier. Do

not use a liquid propane cylinder with a damaged valve.

Z_ Although your liquid propane cylinder may appear to be

empty, gas may still be present, and the cylinder should be

transported and stored accordingly.

z_ if you see, smell or hear the hiss of escaping gas from the

liquid propane cylinder:

1. Move away from liquid propane cylinder.

2. Do not attempt to correct the problem yourself.

3. Call your fire department.

WARNINGS .......................................... 2

TABLE OF CONTENTS................................. 3

EXPLODED VIEW 320 ................................. 4

EXPLODED VIEW LiST 320 ............................. 5

EXPLODED VIEW 330 ................................. 6

EXPLODED VIEW LiST 330 ............................. 7

WARRANTY ......................................... 8

GENERAL iNSTRUCTIONS ............................. 9

CANADIAN iNSTALLATiON .......................................... 9

STORAGE ....................................................... 9

OPERATING ...................................................... 9

GAS SUPPLY TESTING ............................................. 9

GASiNSTRUCTIONS [MODEL 329_ ..................... 19

INSTALL GAS SUPPLY ............................................ 10

GASINSTRUCTIONS {MODEL 330) ..................... 11

INSTALL GAS SUPPLY ............................................ 11

GRiLLiNG TIPS & HELPFUL HINTS ..................... 19

PREHEATING ................................................... 19

COVERED COOKING ............................................. 19

DRiPPiNGS AND GREASE ........................................ 19

FLAVORIZE R®SYSTEM ........................................... 19

SEAR STATION ® ................................................. 19

SiDE BURNER iGNiTION & USAGE ..................... 20

SIDE BURNER IGNITION .......................................... 20

TO EXTINGUISH ................................................. 20

SIDE BURNER MANUAL IGNITION .................................. 21

TO EXTINGUISH ................................................. 21

TROUBLESHOOTING................................. 22

SiDE BURNER TROUBLESHOOTING .................... 22

MAINTENANCE ..................................... 23

CLEANING ...................................................... 23

WEBER ® SPIDER/INSECT SCREENS ................................ 23

BURNER TUBES CLEANING OR REPLACEMENT ...................... 24

ELECTRONIC IGNITION SYSTEM OPERATIONS ....................... 26

SIDE BURNER MAINTENANCE ..................................... 27

ANNUAL MAINTENANCE .......................................... 27

GASiNSTRUCTIONS ................................. 12

TYPE OF GAS ................................................... 12

WHAT IS NATURAL GAS? .......................................... 12

NATURAL GAS CONNECTION ...................................... 12

LEAK CHECK PREPARATION ....................................... 12

CHECK FOR GAS LEAKS .......................................... 13

BEFORE USING THE GRILL ........................... 15

SLIDE OUT GREASE TRAY AND DISPOSABLE DRIP PAN ................ 15

ELECTRONIC IGNITER INSPECTION ................................ 15

HOSE iNSPECTiON .............................................. 15

MAIN BURNER iGNITION & USAGE..................... 16

MAIN BURNER IGNITION .......................................... 16

TO EXTINGUISH ................................................. 16

MAIN BURNER MANUAL IGNITION ................................. 17

TO EXTINGUISH ................................................. 17

SEAR STATION ®iGNITION & USAGE [MODEL 330] ........ 18

SEAR STATION ®BURNER IGNITION ................................. 18

SEAR STATION ®BURNER MANUAL IGNITION ......................... 18

USING THE SEAR STATION ® ....................................... 18

Genesis_320 NG US 061110

12--

_ 36

Thermometer 17. Catch Pan Holder

Term6metro Soporte del plato recolector

Thermometre Support pour egouttoir

33.

2. Thermometer Bezel 18. Left Frame Panel 34.

Moldura decorativa del term6metro Panel izquierdo del bastidor

Collerette du thermometre Panneau du chb,ssis de gauche

Wind Deflector

Deflector de viento

Deflecteu r de vent

Control Knob

Perilla de control

Bouton de commande

3. Shroud 19. Front Frame Support 35. Manifold Hose

Cubierta Soporte delantero del bastidor Manguera del multiple

Etui Support du chb,ssis avant Tuyau du collecteur

4. Handle 20. Left Door 36. Bulkhead

Asa Puerta izquierda Tabique divisorio

Poignee Porte gauche T_te du brQleur

5. Warming Rack 21. Right Door 37. Hose

Rejilla de calentamiento Puerta derecha Manguera

Grille de maintien au chaud Porte droite Tuyau

6. SideTable 22. Door Handle 38.

Mesa lateral Asa de la puerta

Tablette lat@ale Poignee de la porte

Right Frame Panel

Panel derecho del bastidor

Panneau du chb,ssis droit

7. Cooking Grate 23. Shroud Hardware 39. Back Panel

Parrilla de coccJ6n Accesorios de la cubierta Panel trasero

Grille de cuisson Quincaillerie de retui Panneau arriere

8. Burner Tube 24. Side Burner 40. Bottom Panel

Tubo quemador Quemador lateral Panel inferior

Tube du brQleur BrQleur lateral Panneau inferieur

9. Flavorizer ®Bar 25. Side Burner Table 41. Caster

Barra Flavorizer _ Mesa del quemador lateral Rueda giratoria

Barre FlavorizeF e Tablette du brQleur lat@al Roulette

10.

11.

12.

Igniter 26. Side Burner Gas Line 42. Matehstick Holder

Encendedor Linea de gas del quemador lateral Portacerillos

Allumeur Conduite de gaz du brQleur lateral Porte-allumette

Cookbox 27. Manifold 43. Locking Caster

Caja de cocci6n Multiple Rueda giratoria con bloqueo

Boitier de cuisson Collecteur Roulette de verrouillage

Heat Deflector

Deflector de calor

Deflecteu r de chaleu r

28. Heat Shield

Pantalla contra el calor

Protection anti-chaleur

13. Slide Out GreaseTray 29. Wire Clips

Bandeja deslizante de grasa Grapas de alambre

Plateau de recup@ation des graisses amovible Pinces en fil de fer

14. Rear Frame Support

Soporte posterior del bastidor

Support de chb,ssis arriere

30. Control Panel

Tablero de control

Panneau de commande

15. Disposable Drip Pan 31. Igniter Button

Bandeja de goteo desechable Bot6n de encendido

Egouttoir jetable Bouton de rallumeur

16. Catch Pan 32. Igniter Module

Plato recolector M6dulo de encendido

Egouttoir Module de rallumeur

12--

Genesis_330 NG US 061110

Thermometer 17. Catch Pan Holder

Term6metro Soporte del plato recolector

Thermometre Support de I'egouttoir

33.

2. Thermometer Bezel 18. Left Frame Panel 34.

Moldura decorativa del termdmetro Panel izquierdo del bastidor

Collerette du thermometre Panneau de ch&ssis gauche

3. Shroud 19. Front Frame Support 35.

Cubierta Soporte delantero del bastidor

Etui Support de ch&ssis avant

4. Handle 20. Left Door 36.

Asa Puerta izquierda

Poignee Porte gauche

Igniter Module

Mddulo de encendido

Module de I'allumeur

Wind Deflector

Deflector de viento

Deflecteu r de vent

Control Knob

Perilla de control

Bouton de commande

Sear Station ®Knob

Perilla de la estacidn de dorado Sear Station <e

Bouton Sear Station <e

5. Warming Rack 21. Right Door 37. Manifold Hose

Rejilla de calentamiento Puerta derecha Manguera del multiple

Grille de maintien au chaud Porte droite Tuyau du collecteur

6. SideTable 22. Door Handle 38. Bulkhead

Mesa lateral Asa de la puerta Tabique divisorio

Tablette lat@ale Poignee de porte T_te du br_leur

7. Cooking Grate 23. Shroud Hardware 39. Hose

Parrilla de coccJdn Accesorios de la cubierta Manguera

Grille de cuisson Quincaillerie de I'etui Tuyau

8. BurnerTube 24. Side Burner 40.

Tubo quemador Quemador lateral

Tube du brQleur BrQleur lateral

Right Frame Panel

Panel derecho del bastidor

Panneau de ch&ssis droit

9. Flavorizer ®Bar 25. Side Burner Table 41. Back Panel

Barra Flavorizer _ Mesa del quemador lateral Panel trasero

Barre FlavorizeF e Tablette du brQleur lat@al Panneau arriere

10.

11.

Igniter 26. Side Burner Gas Line 42. Bottom Panel

Encendedor Linea de gas del quemador lateral Panel inferior

Allumeur Conduite de gaz du brQleur lateral Panneau inferieur

Cookbox 27. Manifold 43. Caster

Caja de coccidn Multiple Rueda giratoria

Boitier de cuisson Collecteur Roulette

12. Heat Deflector 28. Heat Shield 44. Matchstick Holder

Deflector de calor Pantalla contra el calor Portacerillos

Deflecteu r de chaleu r Protection anti-chaleu r Porte-allu mette

13. Slide Out GreaseTray 29. Wire Clips

Bandeja deslizante de grasa Grapas de alambre

Plateau de recup@ation des graisses amovible Pinces de retenue des c&bles

45. Locking Caster

Rueda giratoria con bloqueo

Roulette & verrouillage

14. Rear Frame Support

Soporte posterior del bastidor

Support du ch&ssis arriere

30. Control Panel

Tablero de control

Panneau de commande

15. Disposable Drip Pan

Bandeja de goteo desechable

Egouttoir jetable

31. Sear Burner Heat Shield

Pantalla contra el calor del quemador para dorar

Protection anti-chaleur du brQleur Sear

16. Catch Pan 32. Igniter Button

Plato recolector Bot6n de encendido

Egouttoir Bouton de I'allumeur

Weber-Stephen Products Co. (Weber) hereby warrants to the ORIGINAL PURCHASER of this WebeP

gas grill that it will be free of defects in material and workmanship from the date of purchase as follows:

Aluminum castings: 25-years (2 years on paint: excludes fading)

Stainless steel shroud: 25-years

Porcelain-enameled shroud: 25-years

Stainless steel burners tubes: t0-years

Stainless steel cooking grates: 5-years no rust through or burn through

Stainless steel F]avorizer ® bars: 5-years no rust through or burn through

Porcelain-enameled cast-iron cooking grates: 5-year no rust through or burn through

Porcelain-enameled cooking grates: 3-years no rust through or burn through

Porcelain-enameled F]avorizer ® bars: 2-years no rust through or burn through

Infrared rotisserie burner: 2-years

NI remaining parts: 2-years

when assembled and operated in accordance with the printed instructions accompanying it. Weber

may require reasonable proof of your date of purchase. THEREFORE, YOU SHOULD RETAIN YOUR

SALES SLIP OR INVOICE.

This Limited Warranty shall be limited to the repair or replacement of parts that prove defective under

normal use and service and which on examination shall indicate, to Weber's satisfaction, they are

defective. Before returning any parts, contact the Customer Service Representative in your area

using the contact information on our website. If Weber confirms the defect and approves the claim,

Weber will elect to replace such parts without charge. If you are required to return defective parts,

transportation charges must be prepaid. Weber will return parts to the purchaser, freight or postage

prepaid.

This Limited Warranty does not cover any failures or operating difficulties due to accident, abuse,

misuse, alteration, misapplication, vandalism, improper installation or improper maintenance or

service, or failure to perform normal and routine maintenance, including but not limited to damage

caused by insects within the burner tubes, as set out in this owner's manual.

Deterioration or damage due to severe weather conditions such as hail, hurricanes, earthquakes

or tornadoes, discoloration due to exposure to chemicals either directly or in the atmosphere, is not

covered by this Limited Warranty.

There are no other express warrants except as set forth herein and any applicable implied warranties

of merchantability and fitness are limited in duration to the period of coverage of this express written

Limited Warranty. Some regions do not allow limitation on how long an implied warranty lasts, so this

limitation may not apply to you.

Weber is not liable for any special, indirect or consequential damages. Some regions do not allow the

exclusion or limitation of incidental or consequential damages, so this limitation or exclusion may not

apply to you.

Weber does not authorize any person or company to assume for it any other obligation or liability in

connection with the sale, installation, use, removal, return, or replacement of its equipment; and no

such representations are binding on Weber.

This Warranty applies only to products sold at retail.

WEBER-STEPHEN PRODUCTS CO.

Customer Service Center

1890 Roeelle Road, Suite 308

Schaumburg, IL 60195

USA

For replacement parts calh

1-800-446-1071

Visit www.weber.com ®,select your country of origin, and register your grill today. ®

Your Webeff _gas barbecue is a portable outdoor cooking appliance. With the Weber ¢

gas barbecue you can grill, barbecue, roast and bake with results that are difficult to

duplicate with indoor kitchen appliances.The closed lid and Flavorizer _ bars produce

that "outdoor" flavor in the food.

The Weber ¢ gas barbecue is portable so you can easily change its location in your yard

or on your patio. Portability means you can take your Weber ¢ gas barbecue with you if

you move.

The natural gas supply is easy to use and gives you more cooking control than charcoal

fuel.

o These instructions will give you the minimum requirements for assembling your

Webei _ gas barbecue. Please read the instructions carefully before using your

Weber ¢ gas barbecue. Improper assembly can be dangerous.

Not for use by children.

If there are local codes that apply to portable gas grills, you will have to conform to

them. Installation must conform with local codes or, in the absence of local codes,

with either the National Fuel Gas Code, ANSI Z223.1/NFPA 54, Natural Gas and

Propane Installation Code, CSA B149.1, or Propane Storage and Handling Code,

B149.2, or the Standard for Recreational Vehicles, ANSI A 119.2/NFPA 1192, and

CSA Z240 RV Series, Recreational Vehicle Code, as applicable.

This Webe_ gas barbecue is designed for natural (piped in city) gas only. Do not use

liquid propane (LP) bottled gas.The valves, orifices and hose are for natural gas only.

Do not use with charcoal fuel.

Check that the area under the control panel and the grease tray are free from debris

that might obstruct the flow of combustion or ventilation air.

CANADIAN INSTALLATION

These instructions, while generally acceptable, do not necessarily comply with the

Canadian Installation codes, particularly with piping above and below ground. In Canada

the installation of this appliance must comply with local codes and/or Standards CAN/

CGA-B149.1 (Installation Code for Natural Gas Burning Appliances and Equipment). ®

STORAGE AND/OR NONUSE

The gas must be turned off at the natural gas supply when the Weber _ gas barbecue

is not in use.

When the Weber _ gas barbecue is stored indoors, the gas supply must be

disconnected.

The Weber _ gas barbecue should be checked for gas leaks and any obstructions

in the burner tubes before using. (Refer to: "MAINTENANCE/ANNUAL

MAINTENANCE").

Check that the areas under the control panel and the slide out grease tray are free

from debris that might obstruct the flow of combustion or ventilation air.

The Spider/Insect screens should also be checked for any obstructions. (Refer to:

"MAINTENANCE/ANNUAL MAINTENANCE").

OPERATING

WARNING: Only use this barbecue outdoors in a well-

ventilated area. Do not use in a garage, building, breezeway

or any other enclosed area.

WARNING: Your Weber ®gas barbecue shall not be used

under overhead combustible construction.

WARNING: Your Weber ®gas barbecue is not intended to be

installed in or on recreational vehicles and/or boats.

WARNING: Do not use the barbecue within 24 inches of

combustible materials. This includes the top, bottom, back

or sides of the grill.

WARNING: The entire cookbo× gets hot when in use. Do not

leave unattended.

WARNING: Keep any electrical supply cord and the fuel

supply hose away from any heated surface.

WARNING: Keep the cooking area clear of flammable vapors

and liquids, such as gasoline, alcohol, etc., and combustible

materials.

GAS SUPPLY TESTING

Disconnect your Weber _ gas barbecue when the gas supply is being tested at high

pressures.This appliance and its individual shutoff valve must be disconnected

from the gas supply piping system during any pressure testing of that system at test

pressures in excess of 1/2 psig (3.5 kPa).

Turn off your Weber ¢ gas barbecue when the gas supply is being tested at low

pressures.This appliance must be isolated from the gas supply piping system by

closing its individual manual shutoff valve during any pressure testing of the gas

supply piping system at the pressure equal to or less than 1/2 psig (3.5 kPa). ®

INSTALL GAS SUPPLY

General Specifications For Piping

Note: Contact your local municipality for building codes regulating outdoor

gas barbecue installations. In absence of Local Codes, you must conform to

the latest edition of the National Fuel Gas Code: ANSI Z 223.1/NFPA 54, or CAN/

CGA-B14g. 1,Natural Gas and Propane Insta!lation Code. WE RECOMMEND THAT THIS

INSTALLATION BE DONE BY A PROFESSIONAL.

Some of the following are general requirements taken from the latest edition of the

National Fuel Gas Code: ANSI Z 223.1/NFPA 54, or CAN/CGA-B149.1, Natural Gas and

Propane Installation Code for complete specifications.

o This barbecue is designed to operate at 7" of water column pressure (.2526 psi).

A manual shut-off valve must be installed outdoors, immediately ahead of the quick

disconnect.

An additional manual shut-off valve indoors should be installed in the branch fuel line

in an accessible location near the supply line.

The quick disconnect connects to a 3/8" NPT thread from the gas source.The quick

disconnect fitting is a hand-operated device that automatically shuts off the flow of

gas from the source when the barbecue is disconnected.

The quick disconnect fitting can be installed horizontally, or pointing downward.

Installing the fitting with the open end pointing upward can result in collecting water

and debris.

The dust covers (supplied plastic plugs) help keep the open ends of the quick

disconnect fitting clean while disconnected.

Pipe compound should be used which is resistant to the action of natural gas when

connections are made.

The outdoor connector must be firmly attached to rigid, permanent construction.

z_ WARNING: Do not route the ten foot hose under a deck. The

hose must be visible.

Gas Line Piping

= For the correct size and length of gas line piping refer to the latest edition of the

National Fuel Gas Code: ANSI Z 223.1/NFPA 54, or CAN/CGA-B149.1, Natural Gas

and Propane Installation Code.

= Gas piping may be copper tubing, type K or L; polyethylene plastic tube, with a

minimum wall thickness of .062"; or standard weight (schedule 40) steel or wrought

iron pipe.

= Copper tubing must be tin-lined if the gas contains more than 0.3 grams of hydrogen

sulfide per 100 cubic feet of gas.

o Plastic tubing is suitable only for outdoor, underground use.

= Gas piping in contact with earth, or any other material which may corrode the piping,

must be protected against corrosion in an approved manner.

= Underground piping must have a minimum of 18" cover.

Test Connections

All connections and joints must be thoroughly tested for leaks in accordance with local

codes and all listed procedures in the latest edition of the National Fuel Gas Code: ANSI

Z 223.1/NFPA 54, or CAN/CGA-B149.1.

This is a typical installation of a Weber ®natural gas barbecue.

Local codes may require different installations.

1 Gas Supply 2 Shut off

3 Quick-Disconnect 4 3/8" Pipe Nipple

5 Reducing Coupling 6 1/2" Pipe Nipple

7 Locking Shut Off 8 Do Not Use

DANGER

Do not use an open flame to check for gas leaks. Be sure

there are no sparks or open flames in the area while you

check for gas leaks. This will result in a fire or explosion

which can cause serious bodily injury or death and damage

to property. ÷

INSTALL GAS SUPPLY

General Specifications for Piping

Note: Contact your local municipality for building codes regulating outdoor

gas barbecue installations. In absence of Local Codes, you must conform to

the latest edition of the National Fuel Gas Code: ANSI Z 223.1/NFPA 54, or CAN/

CGA-B14g. 1,Natural Gas and Propane Insta!/ation Code. WE RECOMMEND THAT THIS

INSTALLATION BE DONE BY A PROFESSIONAL.

Some of the following are general requirements taken from the latest edition of the

National Fuel Gas Code: ANSI Z 223.1/NFPA 54, or CAN/CGA-B149.1, Natural Gas and

Propane Installation Code for complete specifications.

o This barbecue is designed to operate at 4.5" of water column pressure (.163 psi).

A manual shut-off valve must be installed outdoors, immediately ahead of the quick

disconnect.

An additional manual shut-off valve indoors should be installed in the branch fuel line

in an accessible location near the supply line.

The quick disconnect connects to a 1/2" NPT thread from the gas source.The quick

disconnect fitting is a hand-operated device that automatically shuts off the flow of

gas from the source when the barbecue is disconnected.

The quick disconnect fitting can be installed horizontally, or pointing downward.

Installing the fitting with the open end pointing upward can result in collecting water

and debris.

The dust covers (supplied plastic plugs) help keep the open ends of the quick

disconnect fitting clean while disconnected.

Pipe compound should be used which is resistant to the action of natural gas when

connections are made.

The outdoor connector must be firmly attached to rigid, permanent construction.

z_ WARNING: Do not route the 10 foot hose under a deck. The

hose must be visible.

Gas Line Piping

= For the correct size and length of gas line piping refer to the latest edition of the

National Fuel Gas Code: ANSI Z 223.1/NFPA 54, or CAN/CGA-B149.1, Natural Gas

and Propane Installation Code.

= Gas piping may be copper tubing, type K or L; polyethylene plastic tube, with a

minimum wall thickness of .062"; or standard weight (schedule 40) steel or wrought

iron pipe.

= Copper tubing must be tin-lined if the gas contains more than 0.3 grams of hydrogen

sulfide per 100 cubic feet of gas.

o Plastic tubing is suitable only for outdoor, underground use.

= Gas piping in contact with earth, or any other material which may corrode the piping,

must be protected against corrosion in an approved manner.

= Underground piping must have a minimum of 18" cover.

Test Connections

All connections and joints must be thoroughly tested for leaks in accordance with local

codes and all listed procedures in the latest edition of the National Fuel Gas Code: ANSI

Z 223.1/NFPA 54, or CAN/CGA-B149.1.

® % ®

This is a typical installation of a Weber e_natural gas barbecue.

Local codes may require different installations.

2 Shut off

3 Quick-Disconnect 4 1/2" Pipe Nipple

5 Locking Shut Off 6 Do Not Use

DANGER

Do not use an open flame to check for gas leaks. Be sure

there are no sparks or open flames in the area while you

check for gas leaks. This will result in a fire or explosion

which can cause serious bodily injury or death and damage

to property. ÷

TYPE OF GAS

Your natural gas grill is factory built to operate using natural gas only. Never attempt to

operate your grill on gases other than the type specified on the grill rating plates.

Your grill operates at 7" of water column pressure. If replacement o1 the hose becomes

necessary, factory specified parts are required. See your local dealer.

For safety and design reasons, the conversion of a Weber _ grill from operation using

Natural gas to operation using LP gas is not allowed.

WHAT IS NATURAL GAS?

Natural gas, often called methane, is a safe modern fuel. Natural gas is supplied by your

local utility and should be readily available if your house is already heated with gas. ®

NATURAL GAS CONNECTION

Uncoil the NG supply hose and route the end out the access hole at the back panel of

the cabinet (1).The 330 unit requires a 1/2" hose as opposed to the 3/8" hose for the

310 & 320. Weber e recommends moving the grill at least 24" from the gas supply and

any combustible surfaces. After the gas supply has been run and checked for leaks in

accordance to the assembly instructions, you are ready to grill. To connect the hose

to the gas supply, pull back the outer fitting, insert the hose fitting all of the way, and

release the outer fitting. This process will produce a gas joint. ®

LEAK CHECK PREPARATION

Check That All Burner Valves Are Off

Valves are shipped in the OFF position, but you should check to be sure that they are

turned off. Check by pushing in and turning clockwise. If they do not turn, they are off. If

they do turn continue turning them clockwise until they stop, then they are off.

Check The Flexible Hose To Manifold Connection

The natural gas hose was attached during the manuafacturing process. We do

recommend that the hose to gas manifold connnection be leak tested, following

guidelines in this Owner's Guide, prior to barbecue operation.

To perform leak checks: Slide back the collar of the quick disconnect (2). Push male

fitting of the hose into the quick disconnect, and maintain pressure. Slide the collar

closed (3). If it does not engage or lock, repeat procedure. Gas will not flow unless the

quick disconnect is properly engaged. ®

1 Swivel Connection

2 Install covers when hose is disconnected

3 Shut Off Valve

4 Coat this pipe nipple with gas resistant pipe dope

5 Socket

6 Male Connection

1 Socket

2 Sleeve

3 Push Sleeve Back

4 Plug

Push plug until sleeve snaps forward locking plug in socket.

(This turns on gas automatically.)

When properly assembled the plug cannot be removed without pushing the sleeve back.

To disconnect, push sleeve back and pull out plug.

(This automatically shuts off gas.)

Remove Control Knobs & Control Panel For LeakTesting

You will need: Phillips screwdriver.

A) Remove control knobs, igniter button, retention nut, and battery (1).

B) Remove screws from wind deflector with a Phillips screwdriver (2).

C) Tilt end of wind deflector down and slide wind deflector away to remove (3).

D) Let igniter module dangle from wires. Do not disconnect (4).

E) Remove screws from underside of control panel with Phillips screwdriver (5).

F) Lift control panel up slightly, tilt up front edge and gently lift up (6).

G) Replace control panel and wind deflector when leak check is completed. ÷

CHECK FOR GAS LEAKS

DANGER

Do not use an open flame to check for gas leaks. Be sure

there are no sparks or open flames in the area while you

check for leaks. Sparks or open flames will result in a fire or

explosion, which can cause serious bodily injury or death

and damage to property.

Note: All factory-made connections have been thoroughly checked for gas leaks. The

burners have been flame-tested. As a safety precaution however, you should recheck all

fittings for leaks before using your Weber- gas barbecue. Shipping and handling may

loosen or damage a gas fitting.

WARNING: The gas connections of your gas grill have been

factory tested. We do however recommend that you leak

check all gas connections before operating your gas grill.

WARNING: Perform these leak checks even if your barbecue

was dealer or store assembled.

If your grill has a side burner make sure the side burner is turned off.

Turn on gas supply at source.

WARNING: Do not ignite burners when leak checking.

You will need: A soap and water solution and a rag or brush to apply it.

A) Mix soap and water.

B) Turn on gas supply (1).

C) Check for leaks by wetting the fitting with the soap and water solution and watching

for bubbles. If bubbles form, or if a bubble grows, there is a leak.

if there is a leak, turn off the gas and tighten the fitting. Turn the gas back on and

recheck with the soap and water solution. If leak does not stop do not use the

barbecue. Contact the customer service representative in your area using the

contact information on our web site. Log onto www.weber.com ®.

D) When leak checking is complete, turn gas supply off at the source and rinse

connections with water.

Note: Since some leak test solutions, including soap and water, may be slightly

corrosive, a!l connections should be rinsed with water after checking for leaks.

WARNING: You should check for gas leaks every time you

disconnect and reconnect a gas fitting.

Check:

A) Flexible Hose to bulkhead connection (1).

B) Main gas line to bulkhead connection (2).

C) Main gas line to manifold connections (3).

D) Side burner gas line to manifold connection (4).

E) Side burner pipe fitting to side burner cup (5).

F) Side burner pipe fitting to side burner valve connections (6).

z_ WARNING: If there is a leak at connection (1,2, 3, 4, 5, or 6),

retighten the fitting with a wrench and recheck for leaks with

soap and water solution. If a leak persists after re=tightening

the fitting, turn OFF the gas. DO NOT OPERATE THE GRILL.

Contact the Customer Service Representative Jn your area

using the contact information on our web site.

Log onto www.weber.com ®.

G) Side burner quick disconnect connection (7).

H) Flexible Hose to Quick Disconnect connection (8).

I) Valves to manifold connections (9).

WARNING: If there is a leak at connections (7, 8, or 9), turn

OFF the gas. DO NOT OPERATE THE GRILL. Contact the

Customer Service Representative in your area using the

contact information on our web site.

Log onto www.weber.com ®.

When leak checks are complete, turn gas supply OFF at the source and rinse

connections with water.

ReinstalJ ControJ Panel

You will need: Phillips screwdriver.

J) Position top edge of control panel on tabs of frame. Push down into position.

K) Reinstall igniter module.

L) Slide both shorter wind deflector tabs toward inside edge of control panel while you

slide longer tab over outside edge. Seek previous illustrations for reference.

M) Line up screws with screw holes on both control panel bracket and frame.

N) Tighten screws.

O) Place corresponding control knobs onto valve stems. ®

The grill illustrated may

have slight differences

than the model purchased.

SLIDE OUT GREASE TRAY AND DISPOSABLE DRIP PAN

Your grill was built with a grease collection system. Check the slide out grease tray and

disposable drip pan for grease build-up each time you use your grill.

Remove excess grease with a plastic spatula; see illustration. When necessary, wash

the grease tray and drip pan with a soap and water solution, then rinse with clean water.

Replace the disposable drip pan as needed.

z_ WARNING: Check the slide out grease tray and disposable

drip pan for grease build=up before each use. Remove

excess grease to avoid a grease fire. A grease fire can cause

serious bodily injury or damage to property.

CAUTION: Do not line the slide out grease tray with

aluminum foil.

ELECTRONIC IGNITER INSPECTION

Verify that your AA battery (alkaline only) is in good condition and that it is installed

correctly (1). Some batteries have a plastic protective wrap around them.This plastic

must be removed. Do not confuse this plastic with the battery label. ®

HOSE INSPECTION

The hose should be inspected for any signs of cracking.

WARNING: Check hose before each use of barbecue for

nicks, cracking, abrasions or cuts. If the hose is found to

be damaged in any way, do not use the barbecue. Replace

using only Weber ®authorized replacement hose. Contact

the Customer Service Representative in your area using the

contact information on our web site.

Log onto www.weber.com ®.

MAIN BURNER IGNITION

Summary lighting instructions are inside the left hand cabinet door.

Z_ DANGER

Failure to open the lid while igniting the barbecue's burners,

or not waiting five minutes to allow the gas to clear if the

barbecue does not light, may result in an explosive flare-up

which can cause serious bodily injury or death.

Electronic ignition System

Note:Each control knob operates anindividual bume_ TheElectronic Ignition System

ignites a burner witha spark from the igniter electrode inside the Gas CatcherTM

ignition chambe_Yougeneratethe energy forthe spark by pushing the electronic

ignition button.Youwill hear itcricking.

Z_ WARNING: Check hose before each use of barbecue for

nicks, cracking, abrasions or cuts. If the hose is found to

be damaged in any way, do not use the barbecue. Replace

using only Weber ® authorized replacement hose. Contact

the Customer Service Representative in your area using the

contact information on our web site.

Log onto www.weber.com ®.

A) Open the lid (1).

B) Makesure all burner control knobsare turned off (2).(Push control knob in andturn

clockwise to ensurethat it is in the OFF position.)

C) Turn the gas supply valve on(3).

Z_ WARNING: Do not lean over the open barbecue.

D) Pushcontrol knob in and turn to START/HI(4).

E) Pushand hold the electronicignition button.Youwill hear itclicking (5).

F) Check that the burner is litby looking throughthe cooking grates.Youshould see a

flame (6).

Z_ WARNING: if the burner does not light in five seconds, stop,

turn the control knob to OFF and wait five minutes to let the

gas clear before you try again or try to light with a match.

G) To light remainingburnersfollow steps Dthrough R ®

TO EXTINGUISH

Push in and turn each burner control knob clockwise to the OFF position.Turn gas

supply off at the source. ®

ARRETE

÷ + + +

OFF START/Hi MEDIUM LOW

ELECTRONIC

iGNiTER

The grill illustrated may have slight

differences than the model purchased.

MAIN BURNER MANUAL IGNITION

_ DANGER

Failure to open the lid while igniting the barbecue's burners,

or not waiting five minutes to allow the gas to clear if the

barbecue does not light, may result in an explosive flare-up

which can cause serious bodily injury or death.

A) Open the lid (1).

B) Make sure all burner control knobs are turned off (2). (Push control knob in and turn

clockwise to ensure that it is in the OFF position.)

C) Turn the gas supply valve on (3).

D) Put match in the match holder and strike match.

E) Insert match holder with lit match down through cooking grates and Flavorizer _ bars

to ignite the selected burner (4).

z_ WARNING: Do not lean over open barbecue.

F) Push control knob in and turn to START/HI (5).

G) Check that the burner is lit by looking through the cooking grates. You should see a

flame (6).

WARNING: If the burner does not light in five seconds, stop,

turn the control knob to OFF and wait five minutes to let the

gas clear before you try again or try to light with a match.

H) To light remaining burners follow steps D through G.

TO EXTINGUISH

Push in and turn each burner control knob clockwise to the OFF position.Turn gas

supply off at the source. ®

The grill illustrated may have slight

differences than the model purchased.

SEAR STATION _ BURNER iGNiTiON

The 330 model includes a sear burner. The sear burner also operates as an individual

burner. Therefore, ignition of the sear burner is the same as ignition of the main burner.

To ignite the sear burner refer to "MAIN BURNER iGNiTION'.' ÷

SEAR STATION e BURNER MANUAL IGNiTiON

To manually ignite the sear burner refer to "MAIN BURNER MANUAL IGNITION': ÷

USING THE SEAR STATION ®

Your Weber ¢ gas barbecue includes a sear burner for searing meats such as steak,

poultry parts, fish, and chops.

Searing is a direct grilling technique which browns the surface of the food at a high

temperature. By searing or browning both sides of the meat you will create a more

desirable flavor by caramelizing the food surface. Searing will also enhance appearance

of the meat with sear marks from the cooking grates. This along with the contrast of

textures and flavors can make food more interesting to the palate.

The Sear Station ®burner has an OFF, START/HI, and LOW control setting that works

with the Left and Center burners. With the sear and adjacent burners you can effectively

sear meats while using the Right burner cooking area for grilling with moderate heat.

Before searing you should turn all of the main burners on HI for 15 minutes to preheat

the grill. Always grill with the lid closed to allow for maximum heat and to avoid flare ups.

Once the grill is preheated, turn the Right burner off or down. Leave the Left and Center

burners on HI and ignite the Sear Station ®burner.

Place the meat directly over the Sear Station ®.You will sear each side anywhere from

1 to 4 minutes, depending on the type of meat and thickness. You may turn the food a

quarter turn to make crossing sear marks (1) before you sear the other side in the same

manner.

Once you are done searing you can finish grilling by moving the meat to a more

moderate heat over the Right burner to achieve the desired doneness.

As you gain experience in using your Sear Station ®, we encourage you to experiment

with different searing times to find results that work best for your taste. ¢

OFF O APAGAOOO mmm=(

ARRETE

÷ ÷ ÷

OFF START/Hm LOW

o Always preheat the grill before cooking. Set all burners on HI heat and close lid; heat

for 10 minutes, or until thermometer registers 5000-550 ° F (260°-288°C).

Sear meats and cook with the lid down for perfectly grilled food every time.

Grilling times in recipes are based on 70°F (20°C) weather and little or no wind. Allow

more cooking time on cold or windy days, or at higher altitudes. Allow less cooking

time in extremely hot weather.

Grilling times can vary because of the weather, orthe amount, size and shape of the

food being grilled.

The temperature of your gas grill may run hotter than normal for the first few uses.

Grilling conditions may require the adjustment of the burner controls to attain the

correct cooking temperatures.

In general, large pieces of meat will require more cooking time per pound than small

pieces of meat. Foods on a crowded cooking grate will require more cooking time

than just a few foods. Foods grilled in containers, such as baked beans, will require

more time if grilled in a deep casserole rather than a shallow baking pan.

Trim excess fat from steaks, chops and roasts, leaving no more than a scant _Ainch

(6.4mm) of fat. Less fat makes cleanup easier, and is a virtual guarantee against

unwanted flare-ups.

Foods placed on the cooking grate directly above burners may require turning or

moving to a less hot area.

Use tongs rather than a fork for turning and handling meats to avoid losing natural

juices. Use two spatulas for handling large whole fish.

If an unwanted flare-up should occur, turn all burners off and move food to another

area of the cooking grate. Any flames will quickly subside. After flames subside, relight

the grill. NEVER USE WATER TO EXTINGUISH FLAMES ON A GAS GRILL.

Some foods, such as a casserole or thin fish fillets, will require a container for grilling.

Disposable foil pans are very convenient, but any metal pan with ovenproof handles

can also be used.

Always be sure the slide out grease tray and catch pan are clean and free from debris.

Do not line the slide out grease tray with foil. This could prevent the grease from

flowing into the catch pan.

Using a timer will help to alert you when "well-done" is about to become "over-

done."

Note: If grill looses heat while cooking refer to the troubleshooting section of this

manual.

& WARNING: Do not move the Weber _ gas barbecue when

operating or while barbecue is hot.

You can adjust the individual burners as desired.The control settings (1) are OFF,

START/HI, MEDIUM, or LOW.

ARRI_TI_

+ + + +

[_ OFF START/HI MEDIUM LOW

Note: The temperature inside your cookbox for the first few uses, while surfaces are still

very reflective, may be hotter than those shown in your cookbook. Cooking conditions,

such as wind and weather, may require the adjustment of the burner controls to obtain

the correct cooking temperatures.

If burners go out during cooking, turn off all burners and wait five minutes before

reNighting.

PREHEATING

Your Webei _ gas barbecue is an energy-efficient appliance. It operates at an economical

low BTU rate. Preheating the grill before grilling is important. Light your grill according

to the instructions in this Owner's Manual. To preheat: after lighting turn all burners to

START/HI, close the lid, and heat until the temperature reaches between 500° and 550°

F (260 ° and 290 ° C), the recommended broiling temperature. This will take 10 to 15

minutes depending on conditions such as air temperature and wind.

COVERED COOKING

All grilling is done with the lid down to provide uniform, evenly circulated heat. With the

lid closed, the gas grill cooks much like a convection oven.The thermometer in the lid

indicates the cooking temperature inside the grill. All preheating and grilling is done with

the lid down. No peeking -- heat is lost every time you lift the lid.

DRIPPINGS AND GREASE

The Flavorizer _ bars are designed to "smoke" the correct amount of drippings for

flavorful cooking. Excess drippings and grease will accumulate in the catch pan under

the slide out grease tray. Disposable foil drip pans are available that fit the catch pan.

z_ WARNING: Check the slide out grease tray and catch pan

for grease build-up before each use. Remove excess grease

to avoid a grease fire in the slide out grease tray.

FLAVORIZER®SYSTEM

When meat juices drip from the food onto the specially angled Flavorizer ¢ bars,

they create smoke that gives foods an irresistible barbecued flavor. Thanks to the

unique design of the burners, Flavorizer ¢ bars and the flexible temperature controls,

uncontrolled flare-ups are virtually eliminated, because YOU control the flames. Because

of the special design of the Flavorizer ¢ bars and burners, excess fats are directed

through the slide out grease tray into the grease catch pan.

SEAR STATION ®

Your Weber _ gas barbecue may include a sear burner for searing thin meats and

fish. The Sear Station ®burner has an OFF, START/HI, or LOW control setting (2) that

works with the two adjacent main burners. With the sear and adjacent burners you can

effectively sear meats while using other cooking areas for cooking with moderate heat

(Refer to "SEAR STATION ® IGNITION & USAGE (330 MODEL)" section). ®

OFF O APAGADOO mmm=(

ARRETI_

÷ ÷ ÷

[_} OFF START/HI LOW

SIDE BURNER IGNITION

DANGER

Failure to open the lid while igniting the side burner, or not

waiting five minutes to allow the gas to clear if the side

burner does not light, may result in an explosive flare=up

which can cause serious bodily injury or death.

WARNING: Check hose before each use of barbecue for

nicks, cracking, abrasions or cuts. If the hose is found to

be damaged in any way, do not use the barbecue. Replace

using only Weber ®authorized replacement hose. Contact

the Customer Service Representative in your area using the

contact information on our web site.

Log onto www.weber.com ®.

A) Open the side burner lid (1).

B) Check that the side burner valve is turned off (2) (Push control knob in and turn

clockwise to ensure that it is in the OFF position), turn all burners not being used to

the OFF position (push in and turn clockwise).

C) Turn the gas supply valve on (3).

D) Push down and turn the side burner control valve to START/HI (4).

E) Press the igniter button several times so it clicks each time until you see a flame (5).

z_ CAUTION: Side burner flame may be difficult to see on a

bright sunny day.

WARNING: If the side burner does not light in five seconds:

a) Turn off the side burner control valve, main burners

and gas supply at source.

b) Wait five minutes to let the gas clear before you try

again, or try lighting with a match (refer to "SIDE

BURNER MANUAL IGNITION").

TO EXTINGUISH

Push down and turn side burner control knob to the OFF position. Be sure the burner is

off and cool before closing the side burner lid. ®

%,,

OFF

START/HI

_== LOW

The grill illustrated may

have slight differences

than the model purchased.

ii_i iiii

La page charge ...

Weber E320NG-2011 Le manuel du propriétaire

Marque: Weber

Modèle: E320NG-2011

Catégorie: Barbecues

Taper: Le manuel du propriétaire

Ce manuel convient également à

E330NG-2011

Télécharger le PDF

rapport

dans d''autres langues

English: Weber E320NG-2011 Owner's manual
español: Weber E320NG-2011 El manual del propietario

Documents connexes

Autres documents

Genesis EP -310/320 Le manuel du propriétaire