MALONE
R
MALONE
R
DownLoaderDownLoaderTM
J-STYLE FOLDING KAYAK CARRIER
12’ Safety LinesJawz Universal Adapters Mounting BoltsKayak Carriers Load Straps T-Knobs
60mm
70mm
Installation & Loading Instructions - Please Read Before Beginning
Veuillez lire les instructions avant d’entreprendre l’installation et le chargement
1
3
2
. Insert Mounting Bolt through one hole of a Jawz adapter.
Insert washer and loosely apply a T-knob. See image 2.
. Faites passer le boulon de fixation dans l’un des trous
d’un adaptateur Jawz puis vissez légèrement un bouton
en ‘‘T’’ à la base du boulon. (Figure 2)
. Prior to installation, insert a bolt into the mounting holes in
the bottom of the carriers. Push upward to open the two
mounting hole covers located in the Base pads.
. Insert a Mounting Bolt into one mounting hole from the top
side. Rotate and close the mounting hole cover.
See image 1.
. Insérez un boulon de fixation dans l’un des trous hexagonaux
situés sur le côté supérieur du support.
(Figure 1)
. Place the carrier onto the front cross bar with the boarding
ramp facing out. Swing the Jawz under the cross bar as
shown. See image 3.
. Placez le support sur la barre transversale avant, la rampe
de chargement vers l’extérieur. Faites passer l’adaptateur
Jawz sous la barre transversale, tel qu’indiqué. (Figure 3)
1
Mounting Bolt Washers
Base Pad
Covers
IMPORTANT WARNING: All vehicular transports are potentially hazardous. Any person(s) using Malone products are personally responsible for
following the given directions for use and/or installation and accepts full responsibility for any and all damages or injury of any kind including death,
which may result from their use and/or installation.
It is critical that all Malone racks and accessories be properly and securely attached to your vehicle. Improper attachment could result in a serious
accident, and could cause serious bodily injury or death to you or to others. You are responsible for securing the racks and accessories to your car,
checking the attachment’s prior to use, and periodically inspecting the products for adjustment, wear, and damage.
You must read and understand all of the instructions and cautions supplied with your Malone products(s) prior to installation or use. If you do not
understand all of the instructions and cautions, or, if you have no mechanical experience and are not thoroughly familiar with the installation
procedures, you should have the product installed by a professional installer.
MISE EN GARDE IMPORTANTE: Tout transport d’un chargement sur le toit d’un véhicule est potentiellement dangereux. Une personne qui
utilise les produits Malone doit suivre sans faute les instructions d’installation et d’utilisation fournies et assume l’entière responsabilité pour tout
dommage ou toute blessure, y compris un décès, pouvant résulter d’une telle installation ou utilisation.
Il est essentiel de xer correctement et solidement les supports et les accessoires à votre véhicule. Une mauvaise installation ou attache pourrait
provoquer un accident, entraîner des blessures corporelles graves à vous et aux autres et même causer la mort. Vous avez la responsabilité de
xer solidement les supports et les accessoires à votre véhicule, de vérier l’installation avant l’utilisation et d’inspecter périodiquement le produit
pour déceler tout signe d’usure ou de dommage ou tout problème d’ajustement.
Vous devez lire et comprendre les instructions et les mises en garde fournies avec les produits Malone avant l’installation et l’utilisation. Si vous
ne comprenez pas les instructions et les mises en garde ou si vous ne possédez pas d’expérience en mécanique et ne connaissez pas à fond les
procédures à suivre d’installation, vous devriez faire monter et poser le produit par un installateur professionnel.
MPG910 & MPG911
PROFILE SERIES
ROOF TOP BOXES
CARGO SERIES
ROOF TOP BOXES
MPG902
MPG910 Shown here
Important Note
Product Warranty & Registration Form
All information is condential and used exclusively by MALONE only.
MALONE
R
MALONE AUTO RACKS 81 County Rd. Ste 1, Westbrook, ME 04092
P: 207.774.9100 F: 207.615.0551
E: support@maloneautoracks.com W: www.maloneautoracks.com
Dear Customer,
Thank you for your purchase of a Malone Product.
In order to be eligible for the Malone Warranty program, we ask that you contact us online at the link provided
below: With-in 30 days of purchase. You can also mail this letter back to the address at the bottom.
• Online: https://maloneautoracks.com/product-registration.php
We will require the information below.
Here is the information collected:
First Name:
Last Name:
Address:
Address2:
City:
State:
Zip:
Country:
Email:
Phone:
Product Description/Name:
Product MPG#
Date Purchased:
Store Where Purchased:
Purchase Price:
Thank you for choosing Malone!
Note importante
Garantie du produit et formulaire d’enregistrement
Toutes les informations sont condentielles et utilisées exclusivement par MALONE uniquement.
MALONE
R
MALONE AUTO RACKS 81 County Rd. Ste 1, Westbrook, ME 04092
P: 207.774.9100 F: 207.615.0551
E: support@maloneautoracks.com W: www.maloneautoracks.com
Cher client,
Merci d’avoir acheté un produit Malone.
Pour vous assurer d’être admissible au programme de garantie de Malone, nous vous demandons, dans les 30
jours suivant l’achat, de nous contacter par courriel ou sur Internet à l’une ou l’autre des adresses ci-dessous.
Vous pouvez aussi nous retourner cette page à l’adresse postale indiquée tout au bas de celle-ci.
• Site Internet : https://maloneautoracks.com/product-registration.php
Nous vous demanderons de fournir les informations suivantes.
Voici quels sont les renseignements recueillis :
Prénom:
Nom de famille:
Adresse:
Adresse2:
Ville:
Province:
Code postal:
Pays:
Courriel:
Téléphone:
Nom/description du produit:
Numéro MPG du produit:
Date de l’achat:
Magasin où s’est fait l’achat:
Prix d’achat:
Merci d’avoir choisi Malone!
PROFILE SERIES
ROOF TOP BOXES
The all new Profile18 is offered in two color options with a low profile design that is perfect
when headed to the slopes. These units feature a patented quick attach mounting system,
abrasion and UV resistant ABS construction, centralized locking system and duel opening lid.
www.maloneautoracks.com
GREAT FOR WINTER SPORTS
Box Opening: Dual Side - Locking Points: 3 - Material: ABS (Gloss Black or Silver) - Cross Bar Spread: 25" - 40"
Volume: 18.0 cf - Length: 78.75" - Width: 32.3" - Height: 15.75" - Capacity: 165 lb - Mounting System: Quick Attach
The Profile18B comes with a rich
high gloss onyx black lid and matte black
reinforced bottom. This sophisticated design, when coupled with
it's technical features, successfully delivers a rock solid gear transport system.
TM
The
all
new
Profile18
Cargo Boxes
TM
P
ROFILE
18B
RoofTop Cargo Box
P
ROFILE
18S
RoofTop Cargo Box
TM
The Profile18S is offered in a pearl
silver that compliments nearly all vehicle colors.
This "low and wide" profile is the perfect mountain bound choice
for multiple skis and boards. Assembled in the USA with a Lifetime Warranty.
TM
M
M
M
M
M
M
LIFETIME
Cargo Carriers
24
TM
MPG911
MPG910
for
multiple
skis
and
boards.
The all new Profile18 is offered in two color options with a low profile design that is perfect
when headed to the slopes. These units feature a patented quick attach mounting system,
abrasion and UV resistant ABS construction, centralized locking system and duel opening lid.
www.maloneautoracks.com
GREAT FOR WINTER SPORTS
Box Opening: Dual Side - Locking Points: 3 - Material: ABS (Gloss Black or Silver) - Cross Bar Spread: 25" - 40"
Volume: 18.0 cf - Length: 78.75" - Width: 32.3" - Height: 15.75" - Capacity: 165 lb - Mounting System: Quick Attach
The Profile18B comes with a rich
high gloss onyx black lid and matte black
reinforced bottom. This sophisticated design, when coupled with
it's technical features, successfully delivers a rock solid gear transport system.
TM
The
all
new
Profile18
Cargo Boxes
TM
P
ROFILE
18B
RoofTop Cargo Box
P
ROFILE
18S
RoofTop Cargo Box
TM
The Profile18S is offered in a pearl
silver that compliments nearly all vehicle colors.
This "low and wide" profile is the perfect mountain bound choice
for multiple skis and boards. Assembled in the USA with a Lifetime Warranty.
TM
M
M
M
M
M
M
LIFETIME
Cargo Carriers
24
TM
MPG911
MPG910
for
multiple
skis
and
boards.
The all new Profile18 is offered in two color options with a low profile design that is perfect
when headed to the slopes. These units feature a patented quick attach mounting system,
abrasion and UV resistant ABS construction, centralized locking system and duel opening lid.
www.maloneautoracks.com
GREAT FOR WINTER SPORTS
Box Opening: Dual Side - Locking Points: 3 - Material: ABS (Gloss Black or Silver) - Cross Bar Spread: 25" - 40"
Volume: 18.0 cf - Length: 78.75" - Width: 32.3" - Height: 15.75" - Capacity: 165 lb - Mounting System: Quick Attach
The Profile18B comes with a rich
high gloss onyx black lid and matte black
reinforced bottom. This sophisticated design, when coupled with
it's technical features, successfully delivers a rock solid gear transport system.
TM
The
all
new
Profile18
Cargo Boxes
TM
P
ROFILE
18B
RoofTop Cargo Box
P
ROFILE
18S
RoofTop Cargo Box
TM
The Profile18S is offered in a pearl
silver that compliments nearly all vehicle colors.
This "low and wide" profile is the perfect mountain bound choice
for multiple skis and boards. Assembled in the USA with a Lifetime Warranty.
TM
M
M
M
M
M
M
LIFETIME
Cargo Carriers
24
TM
MPG911
MPG910
for
multiple
skis
and
boards.
x1
A B
C
WEGO SP | 1
x2 x2
Whats Included
Brand of Modula srl
Loc. Penisola 20/A
61026 Piandimeleto (PU) Italy
P +39 0722700070
F +39 0722 720017
W www.modulacs.com
Design and Manufacture Made in Italy
wego SP | installation instruction
Sicherheitsvoraussetzungen und Empfehlungen:
Nach einer anfänglichen kurzen Reise und in regelmäßigen Zeitab-
ständen, je nach Straßenkondition, müssen die Anschlussverschrau-
bungen und, ins besondere, die Befestigungen des Dachkoffers kon-
trolliert werden.
Das Fahrverhalten des Fahrzeugs (Seitenwindgefährdung, Kurven-
fahrt und Bremsverhalten) kann sich ändern wenn der Dachkoffer
montiert ist, besonders wenn geladen.
Für die Sicherheit der anderen Verkehrsteilnehmer und für Energie-
spargründe, sollte der Dachkoffer, bei Nichtgebrauch, abgenommen
werden.
Die Informationen des Fahrzeugherstellers, bezüglich der zulässigen
Dachladung, müssen befolgt werden.
Die zulässige Dachladung ist eine Kombination des Gewichts des Da-
chkoffers, Dachträger und tatsächlichen Ladung.
Der Dachkoffer muss in Fahrrichtung montiert werden ohne positive
Einfallswinkel, um erhöhte Hebekräfte zu vermeiden.
Achtung:
Es ist äußerst wichtig die Montage und Gebrauchsanweisungen kor-
rekterweise zu folgen.
Befestigen und kontrollieren Sie die Befestigungsbaugruppen regel-
mäßig während der Reise.
Bewahren Sie diese Gebrauchsanleitung sicher auf.
Verstauen Sie die Ladung auf sichere und korrekte Weise.
Es ist wichtig die Ausrüstungen in einem guten betriebsfähigen Zu-
stand zu erhalten.
Requirements and recommendations:
After a short travel at rst and specic time periods, depending on
the road conditions, the bolt connections and the roof container xing
have to be checked.
The driving behavior of the vehicle changes (vulnerability to side
winds, cornering and breaking behavior) when the roof container is
mounted, especially when loaded.
By reasons of safety of other trafc participants and for matters of
energy saving, the roof container should be taken off during periods
of no use.
The information stated by the vehicle’s manufacturer, concerning the
permissible roof load, has to be followed.
Consider the weight of the container, since permissible roof load is a
combination of the actual load, adding the weight of the roof racks
and container.
The roof container has to be mounted in direction of the travel without
a positive angle of incidence, to avoid any increase in lifting forces.
Warning:
It is very important to follow the instructions of tting and use;
Tighten and check the xing devices correctly and regularly during
travel;
Keep this instruction manual safely;
Secure the roof container load correctly and safe;
It is important to maintain the equipment in good working order.
Produced and distributed under Sparco’s Ofcial Licence
by Modula Case Systems
COCS090210
CARGO SERIES
ROOF TOP BOXES
MALONE
R
Installation & Loading Instructions - Please Read Before Beginning
Veuillez lire les instructions avant d’entreprendre l’installation et le chargement
ROOF TOP BOXES
S
ERIES
C
ARGO
MPG902
MALONE
R
Mounting System: Quick Attach
Box Opening: Dual Side
Locking Points: 3
Material: ABS (Gloss Silver)
Cross Bar Spread: 25" - 40"
Volume: 16.25 cf
Length: 76.4"
Width: 27.9"
Height: 18.9"
Capacity: 165 lb
Cargo16
TM
MALONE
R
MPG903
Mounting System: Quick Attach
Box Opening: Dual Side
Locking Points: 3
Material: ABS (Gloss Silver)
Cross Bar Spread: 25" - 40"
Volume: 23.0 cf
Length: 92.5"
Width: 35.4"
Height: 18.9"
Capacity: 165 lb
TM
Cargo23
Cargo12
TM
Mounting System: Quick Attach
Box Opening: Single Side
Locking Points: 2
Material: Polyester (Gloss Grey)
Cross Bar Spread: 25" - 28"
Volume: 12.0 cf
Length: 55.1"
Width: 31.5"
Height: 17.3"
Capacity: 165 lb
MPG901
MALONE
R
2
Insert the key into the lock and turn clockwise to the unlocked position. Remove and
unpack the hardware kit. Note: The MPG901 only opens on the passenger side.
The MPG902 and MPG903 can be opened on either the driver or passenger side.
1
Setting the Cross Bar Spread
For the MPG901, adjust the vehicle’s
cross bars to between 25” and 28”.
Leave the bars loose for final roof top
box installation.
For the MPG902 or MPG903, adjust the vehicle’s cross bars to between 25” and 40”. Leave the
vehicle’s bars loose for final roof top box installation.
ALWAYS physically confirm the lid is securely
locked before transport. This can be done by
gently lifting up on both ends of the locked side.
The all new Profile18 is offered in two color options with a low profile design that is perfect
when headed to the slopes. These units feature a patented quick attach mounting system,
abrasion and UV resistant ABS construction, centralized locking system and duel opening lid.
www.maloneautoracks.com
GREAT FOR WINTER SPORTS
Box Opening: Dual Side - Locking Points: 3 - Material: ABS (Gloss Black or Silver) - Cross Bar Spread: 25" - 40"
Volume: 18.0 cf - Length: 78.75" - Width: 32.3" - Height: 15.75" - Capacity: 165 lb - Mounting System: Quick Attach
The Profile18B comes with a rich
high gloss onyx black lid and matte black
reinforced bottom. This sophisticated design, when coupled with
it's technical features, successfully delivers a rock solid gear transport system.
TM
The
all
new
Profile18
Cargo Boxes
TM
P
ROFILE
18B
RoofTop Cargo Box
P
ROFILE
18S
RoofTop Cargo Box
TM
The Profile18S is offered in a pearl
silver that compliments nearly all vehicle colors.
This "low and wide" profile is the perfect mountain bound choice
for multiple skis and boards. Assembled in the USA with a Lifetime Warranty.
TM
M
M
M
M
M
M
LIFETIME
Cargo Carriers
24
TM
MPG911
MPG910
for
multiple
skis
and
boards.
MPG910
in Matte Silver
The all new Profile18 is offered in two color options with a low profile design that is perfect
when headed to the slopes. These units feature a patented quick attach mounting system,
abrasion and UV resistant ABS construction, centralized locking system and duel opening lid.
www.maloneautoracks.com
GREAT FOR WINTER SPORTS
Box Opening: Dual Side - Locking Points: 3 - Material: ABS (Gloss Black or Silver) - Cross Bar Spread: 25" - 40"
Volume: 18.0 cf - Length: 78.75" - Width: 32.3" - Height: 15.75" - Capacity: 165 lb - Mounting System: Quick Attach
The Profile18B comes with a rich
high gloss onyx black lid and matte black
reinforced bottom. This sophisticated design, when coupled with
it's technical features, successfully delivers a rock solid gear transport system.
TM
The
all
new
Profile18
Cargo Boxes
TM
P
ROFILE
18B
RoofTop Cargo Box
P
ROFILE
18S
RoofTop Cargo Box
TM
The Profile18S is offered in a pearl
silver that compliments nearly all vehicle colors.
This "low and wide" profile is the perfect mountain bound choice
for multiple skis and boards. Assembled in the USA with a Lifetime Warranty.
TM
M
M
M
M
M
M
LIFETIME
Cargo Carriers
24
TM
MPG911
MPG910
for
multiple
skis
and
boards.
MPG911
in Gloss Black
MALONE
R
Installation & Loading Instructions - Please Read Before Beginning
Veuillez lire les instructions avant d’entreprendre l’installation et le chargement
ROOF TOP BOXES
S
ERIES
C
ARGO
MPG902
MALONE
R
Mounting System: Quick Attach
Box Opening: Dual Side
Locking Points: 3
Material: ABS (Gloss Silver)
Cross Bar Spread: 25" - 40"
Volume: 16.25 cf
Length: 76.4"
Width: 27.9"
Height: 18.9"
Capacity: 165 lb
Cargo16
TM
MALONE
R
MPG903
Mounting System: Quick Attach
Box Opening: Dual Side
Locking Points: 3
Material: ABS (Gloss Silver)
Cross Bar Spread: 25" - 40"
Volume: 23.0 cf
Length: 92.5"
Width: 35.4"
Height: 18.9"
Capacity: 165 lb
TM
Cargo23
Cargo12
TM
Mounting System: Quick Attach
Box Opening: Single Side
Locking Points: 2
Material: Polyester (Gloss Grey)
Cross Bar Spread: 25" - 28"
Volume: 12.0 cf
Length: 55.1"
Width: 31.5"
Height: 17.3"
Capacity: 165 lb
MPG901
MALONE
R
2
Insert the key into the lock and turn clockwise to the unlocked position. Remove and
unpack the hardware kit. Note: The MPG901 only opens on the passenger side.
The MPG902 and MPG903 can be opened on either the driver or passenger side.
1
Setting the Cross Bar Spread
For the MPG901, adjust the vehicle’s
cross bars to between 25” and 28”.
Leave the bars loose for final roof top
box installation.
For the MPG902 or MPG903, adjust the vehicle’s cross bars to between 25” and 40”. Leave the
vehicle’s bars loose for final roof top box installation.
ALWAYS physically confirm the lid is securely
locked before transport. This can be done by
gently lifting up on both ends of the locked side.
Matte silver
36”
PROFILE SERIES
ROOF TOP BOXES
The all new Profile18 is offered in two color options with a low profile design that is perfect
when headed to the slopes. These units feature a patented quick attach mounting system,
abrasion and UV resistant ABS construction, centralized locking system and duel opening lid.
www.maloneautoracks.com
GREAT FOR WINTER SPORTS
Box Opening: Dual Side - Locking Points: 3 - Material: ABS (Gloss Black or Silver) - Cross Bar Spread: 25" - 40"
Volume: 18.0 cf - Length: 78.75" - Width: 32.3" - Height: 15.75" - Capacity: 165 lb - Mounting System: Quick Attach
The Profile18B comes with a rich
high gloss onyx black lid and matte black
reinforced bottom. This sophisticated design, when coupled with
it's technical features, successfully delivers a rock solid gear transport system.
TM
The
all
new
Profile18
Cargo Boxes
TM
P
ROFILE
18B
RoofTop Cargo Box
P
ROFILE
18S
RoofTop Cargo Box
TM
The Profile18S is offered in a pearl
silver that compliments nearly all vehicle colors.
This "low and wide" profile is the perfect mountain bound choice
for multiple skis and boards. Assembled in the USA with a Lifetime Warranty.
TM
M
M
M
M
M
M
LIFETIME
Cargo Carriers
24
TM
MPG911
MPG910
for
multiple
skis
and
boards.
The all new Profile18 is offered in two color options with a low profile design that is perfect
when headed to the slopes. These units feature a patented quick attach mounting system,
abrasion and UV resistant ABS construction, centralized locking system and duel opening lid.
www.maloneautoracks.com
GREAT FOR WINTER SPORTS
Box Opening: Dual Side - Locking Points: 3 - Material: ABS (Gloss Black or Silver) - Cross Bar Spread: 25" - 40"
Volume: 18.0 cf - Length: 78.75" - Width: 32.3" - Height: 15.75" - Capacity: 165 lb - Mounting System: Quick Attach
The Profile18B comes with a rich
high gloss onyx black lid and matte black
reinforced bottom. This sophisticated design, when coupled with
it's technical features, successfully delivers a rock solid gear transport system.
TM
The
all
new
Profile18
Cargo Boxes
TM
P
ROFILE
18B
RoofTop Cargo Box
P
ROFILE
18S
RoofTop Cargo Box
TM
The Profile18S is offered in a pearl
silver that compliments nearly all vehicle colors.
This "low and wide" profile is the perfect mountain bound choice
for multiple skis and boards. Assembled in the USA with a Lifetime Warranty.
TM
M
M
M
M
M
M
LIFETIME
Cargo Carriers
24
TM
MPG911
MPG910
for
multiple
skis
and
boards.
x1
A B
C
WEGO SP | 1
x2 x2
Brand of Modula srl
Loc. Penisola 20/A
61026 Piandimeleto (PU) Italy
P +39 0722700070
F +39 0722 720017
W www.modulacs.com
Design and Manufacture Made in Italy
wego SP | installation instruction
Sicherheitsvoraussetzungen und Empfehlungen:
Nach einer anfänglichen kurzen Reise und in regelmäßigen Zeitab-
ständen, je nach Straßenkondition, müssen die Anschlussverschrau-
bungen und, ins besondere, die Befestigungen des Dachkoffers kon-
trolliert werden.
Das Fahrverhalten des Fahrzeugs (Seitenwindgefährdung, Kurven-
fahrt und Bremsverhalten) kann sich ändern wenn der Dachkoffer
montiert ist, besonders wenn geladen.
Für die Sicherheit der anderen Verkehrsteilnehmer und für Energie-
spargründe, sollte der Dachkoffer, bei Nichtgebrauch, abgenommen
werden.
Die Informationen des Fahrzeugherstellers, bezüglich der zulässigen
Dachladung, müssen befolgt werden.
Die zulässige Dachladung ist eine Kombination des Gewichts des Da-
chkoffers, Dachträger und tatsächlichen Ladung.
Der Dachkoffer muss in Fahrrichtung montiert werden ohne positive
Einfallswinkel, um erhöhte Hebekräfte zu vermeiden.
Achtung:
Es ist äußerst wichtig die Montage und Gebrauchsanweisungen kor-
rekterweise zu folgen.
Befestigen und kontrollieren Sie die Befestigungsbaugruppen regel-
mäßig während der Reise.
Bewahren Sie diese Gebrauchsanleitung sicher auf.
Verstauen Sie die Ladung auf sichere und korrekte Weise.
Es ist wichtig die Ausrüstungen in einem guten betriebsfähigen Zu-
stand zu erhalten.
Requirements and recommendations:
After a short travel at rst and specic time periods, depending on
the road conditions, the bolt connections and the roof container xing
have to be checked.
The driving behavior of the vehicle changes (vulnerability to side
winds, cornering and breaking behavior) when the roof container is
mounted, especially when loaded.
By reasons of safety of other trafc participants and for matters of
energy saving, the roof container should be taken off during periods
of no use.
The information stated by the vehicle’s manufacturer, concerning the
permissible roof load, has to be followed.
Consider the weight of the container, since permissible roof load is a
combination of the actual load, adding the weight of the roof racks
and container.
The roof container has to be mounted in direction of the travel without
a positive angle of incidence, to avoid any increase in lifting forces.
Warning:
It is very important to follow the instructions of tting and use;
Tighten and check the xing devices correctly and regularly during
travel;
Keep this instruction manual safely;
Secure the roof container load correctly and safe;
It is important to maintain the equipment in good working order.
Produced and distributed under Sparco’s Ofcial Licence
by Modula Case Systems
COCS090210
CARGO SERIES
ROOF TOP BOXES
MALONE
R
Installation & Loading Instructions - Please Read Before Beginning
Veuillez lire les instructions avant d’entreprendre l’installation et le chargement
ROOF TOP BOXES
S
ERIES
C
ARGO
MPG902
MALONE
R
Mounting System: Quick Attach
Box Opening: Dual Side
Locking Points: 3
Material: ABS (Gloss Silver)
Cross Bar Spread: 25" - 40"
Volume: 16.25 cf
Length: 76.4"
Width: 27.9"
Height: 18.9"
Capacity: 165 lb
Cargo16
TM
MALONE
R
MPG903
Mounting System: Quick Attach
Box Opening: Dual Side
Locking Points: 3
Material: ABS (Gloss Silver)
Cross Bar Spread: 25" - 40"
Volume: 23.0 cf
Length: 92.5"
Width: 35.4"
Height: 18.9"
Capacity: 165 lb
TM
Cargo23
Cargo12
TM
Mounting System: Quick Attach
Box Opening: Single Side
Locking Points: 2
Material: Polyester (Gloss Grey)
Cross Bar Spread: 25" - 28"
Volume: 12.0 cf
Length: 55.1"
Width: 31.5"
Height: 17.3"
Capacity: 165 lb
MPG901
MALONE
R
2
Insert the key into the lock and turn clockwise to the unlocked position. Remove and
unpack the hardware kit. Note: The MPG901 only opens on the passenger side.
The MPG902 and MPG903 can be opened on either the driver or passenger side.
1
Setting the Cross Bar Spread
For the MPG901, adjust the vehicle’s
cross bars to between 25” and 28”.
Leave the bars loose for final roof top
box installation.
For the MPG902 or MPG903, adjust the vehicle’s cross bars to between 25” and 40”. Leave the
vehicle’s bars loose for final roof top box installation.
ALWAYS physically confirm the lid is securely
locked before transport. This can be done by
gently lifting up on both ends of the locked side.
The all new Profile18 is offered in two color options with a low profile design that is perfect
when headed to the slopes. These units feature a patented quick attach mounting system,
abrasion and UV resistant ABS construction, centralized locking system and duel opening lid.
www.maloneautoracks.com
GREAT FOR WINTER SPORTS
Box Opening: Dual Side - Locking Points: 3 - Material: ABS (Gloss Black or Silver) - Cross Bar Spread: 25" - 40"
Volume: 18.0 cf - Length: 78.75" - Width: 32.3" - Height: 15.75" - Capacity: 165 lb - Mounting System: Quick Attach
The Profile18B comes with a rich
high gloss onyx black lid and matte black
reinforced bottom. This sophisticated design, when coupled with
it's technical features, successfully delivers a rock solid gear transport system.
TM
The
all
new
Profile18
Cargo Boxes
TM
P
ROFILE
18B
RoofTop Cargo Box
P
ROFILE
18S
RoofTop Cargo Box
TM
The Profile18S is offered in a pearl
silver that compliments nearly all vehicle colors.
This "low and wide" profile is the perfect mountain bound choice
for multiple skis and boards. Assembled in the USA with a Lifetime Warranty.
TM
M
M
M
M
M
M
LIFETIME
Cargo Carriers
24
TM
MPG911
MPG910
for
multiple
skis
and
boards.
MPG910
argent mat
The all new Profile18 is offered in two color options with a low profile design that is perfect
when headed to the slopes. These units feature a patented quick attach mounting system,
abrasion and UV resistant ABS construction, centralized locking system and duel opening lid.
www.maloneautoracks.com
GREAT FOR WINTER SPORTS
Box Opening: Dual Side - Locking Points: 3 - Material: ABS (Gloss Black or Silver) - Cross Bar Spread: 25" - 40"
Volume: 18.0 cf - Length: 78.75" - Width: 32.3" - Height: 15.75" - Capacity: 165 lb - Mounting System: Quick Attach
The Profile18B comes with a rich
high gloss onyx black lid and matte black
reinforced bottom. This sophisticated design, when coupled with
it's technical features, successfully delivers a rock solid gear transport system.
TM
The
all
new
Profile18
Cargo Boxes
TM
P
ROFILE
18B
RoofTop Cargo Box
P
ROFILE
18S
RoofTop Cargo Box
TM
The Profile18S is offered in a pearl
silver that compliments nearly all vehicle colors.
This "low and wide" profile is the perfect mountain bound choice
for multiple skis and boards. Assembled in the USA with a Lifetime Warranty.
TM
M
M
M
M
M
M
LIFETIME
Cargo Carriers
24
TM
MPG911
MPG910
for
multiple
skis
and
boards.
MPG911
nior brillant
LISTE DE PIECES
Volume : 0,46 m3 Système de xation : Quick Attach
Longueur : 194 cm Ouverture de la boîte : Deux côtés
Largeur : 70,9 cm Points d’ancrage : 3
Hauteur : 48 cm Matériel : ABS argent mat
Capacité : 74,8 kg
Écart entre barres transversales : de 63,5 à 101,5 cm
Volume : 0,51 m3 - Longueur : 200 cm - Largeur : 82 cm - Hauteur : 40 cm - Système de xation : Quick Attach
Ouverture de la boîte : Deux côtés - Points d’ancrage : 3 - Matériel : ABS noir ou argent brillant
Capacité : 74,8 kg - Écart entre barres transversales : de 63,5 à 91,5 cm
Instructions et recommandations:
Après un court déplacement au début et ensuite à intervalles régu-
liers, selon les conditions de route, il faut vérier l’état des boulons
de montage et la xation du coffre de toit.
Le véhicule se comporte de façon différente (vulnérabilité aux
vents latéraux, virages et freinages) quand le coffre de toit est
installé, surtout lorsqu’il est chargé.
Pour des raisons de sécurité pour les autres usagers de la route
et d’économie d’énergie, il faut enlever le coffre de toit quand il ne
sert pas.
Il faut respecter les consignes du fabricant du véhicule en ce qui
concerne la charge maximale autorisée sur le toit du véhicule.
Il faut tenir compte du poids du coffre, car la charge maximale
autorisée représente le poids combiné de la charge plus le poids
du coffre et celui des supports de toit.
An d’éviter une augmentation de la force ascendante, le coffre
de toit doit être monté dans le sens du déplacement sans angle
d’incidence positif.
Mise en garde:
Il est très important de suivre les instructions d’installation
et d’utilisation;
Serrer correctement les dispositifs de xation et les vérier
régulièrement lors des déplacements;
Conserver ce mode d’emploi en lieu sûr;
Fixer le coffre de toit correctement et de façon sécuritaire;
Il est important de maintenir l’équipement en bon état de
fonctionnement.
x1
A B
C
WEGO SP | 1
x2 x2
x1
A B
C
WEGO SP | 1
x2 x2
WEGO SP | 2
1
2
450 30 MIN | 103 cm MAX
500 35 MIN | 103 cm MAX
MAX
MIN
MAX 100 mm MAX 100 mm
MIN 20 mm
MAX 50 mm
MIN 20 mm
MAX 50 mm
2.1
2.2
2.3
2.4
CLICK!
For the MPG902 adjust the vehicle’s cross bars to between 25” and 40”. Leave the vehicle’s bars loose for
nal roof top box installation.
WEGO SP | 2
1
2
450 30 MIN | 103 cm MAX
500 35 MIN | 103 cm MAX
MAX
MIN
MAX 100 mm MAX 100 mm
MIN 20 mm
MAX 50 mm
MIN 20 mm
MAX 50 mm
2.1
2.2
2.3
2.4
CLICK!
Pour le modèle MPG902, installer les barres transversales sur le véhicule avec un écart
entre elles de 63,5 à 101,5 cm (25 po à 40 po). Laisser les barres desserrées jusqu’à ce
que l’installation nale du coffre de toit soit terminée.
1
2
YES
NO
WEGO SP | 3
3
YES
NO
OUI
NON
OUI
NON
1/4 1/4
1/2
YES NO
WEGO SP | 4
4
5
4.1
4.2
YES
NO
OUI NON
OUI
NON
WEGO SP | 5
6
7
8
>100 cm
MALONE
R
Cargo & Usage Warnings:
. ALWAYS physically confirm the lid is securely
locked before transport. This can be done by
gently lifting up on both ends of the locked side.
. Avoid transporting abrasive chemicals or any
sharp object that can pierce the box.
. Never transport live animals.
. Lock the box and remove keys prior to transport.
. Caution should be applied when encountering
low clearance conditions.
. Use of this product for any other purpose than
vehicle roof top transport voids warranty.
Maintenance:
. Clean roof top box with a mild detergent that does not contain any abrasive chemicals.
. Periodically lubricate locks with a dry lubricant (graphite or similar).
. Protect box from exposure to wind, sun and natural elements.
. Always check attachment system prior to use.
. Periodically check roof top box frame, fittings and attachment system for reliability.
Warranty Registration:
All Malone Roof Top Boxes must be registered for warranty support. To register your purchase,
1. Go to www.maloneautoracks.com and follow the homepage icon for Warranty Registration.
OR
2. Fill out the Warranty Registration form attached and submit by fax or mail (see form).
Malone Auto Racks, 81 County Road, Westbrook, ME 04092
Tel: 207-774-9100 Email: technical @maloneautoracks.com
MALONE
R
MALONE AUTO RACKS 81 County Rd. Ste 1, Westbrook, ME 04092
P: 207.774.9100 F: 207.615.0551
E: support@maloneautoracks.com W: www.maloneautoracks.com
MALONE
R
Cargo & Usage Warnings:
. ALWAYS physically confirm the lid is securely
locked before transport. This can be done by
gently lifting up on both ends of the locked side.
. Avoid transporting abrasive chemicals or any
sharp object that can pierce the box.
. Never transport live animals.
. Lock the box and remove keys prior to transport.
. Caution should be applied when encountering
low clearance conditions.
. Use of this product for any other purpose than
vehicle roof top transport voids warranty.
Maintenance:
. Clean roof top box with a mild detergent that does not contain any abrasive chemicals.
. Periodically lubricate locks with a dry lubricant (graphite or similar).
. Protect box from exposure to wind, sun and natural elements.
. Always check attachment system prior to use.
. Periodically check roof top box frame, fittings and attachment system for reliability.
Warranty Registration:
All Malone Roof Top Boxes must be registered for warranty support. To register your purchase,
1. Go to www.maloneautoracks.com and follow the homepage icon for Warranty Registration.
OR
2. Fill out the Warranty Registration form attached and submit by fax or mail (see form).
Malone Auto Racks, 81 County Road, Westbrook, ME 04092
Tel: 207-774-9100 Email: technical @maloneautoracks.com
MALONE
R
MALONE AUTO RACKS 81 County Rd. Ste 1, Westbrook, ME 04092
P: 207.774.9100 F: 207.615.0551
E: support@maloneautoracks.com W: www.maloneautoracks.com
Mises en garde concernant la charge et l’utilisation:
● TOUJOURS vérier le verrouillage adéquat du couvercle
avant le transport. Cette vérication peut se faire en soulevant
doucement les deux bouts du côté verrouillé.
● Éviter de transporter des produits chimiques abrasifs ou des
objets pointus pouvant percer le coffre.
● Ne jamais transporter d’animaux vivants dans le coffre.
● Verrouiller le coffre et retirer les clefs avant le transport.
● Faire preuve de prudence en s’approchant d’un passage à
hauteur limitée.
● Toute utilisation de ce produit à une n autre que pour un transport sur le toit
d’un véhicule annule la garantie.
Entretien:
● Nettoyer le coffre de toit avec un détergent doux ne contenant pas de produits chimiques abrasifs.
● Lubrier périodiquement les verrous avec un lubriant sec (graphite ou produit similaire).
● Remiser le coffre à l’abri du vent, du soleil et des autres éléments naturels. Toujours vérier le système de
xation avant l’utilisation.
● Vérier périodiquement le cadre, les accessoires et le système de xation pour s’assurer de leur abilité.
Enregistrement de la garantie:
Tous les coffres de toit Malone doivent être enregistrés pour obtenir le support de garantie. Pour enregistrer votre achat:
1. Se rendre sur www.maloneautoracks.com et se servir de l’icône de page d’accueil pour l’enregistrement de la
garantie.
OU
2. Remplir le formulaire d’enregistrement de garantie et l’envoyer par fax ou par la poste (voir détails sur le formulaire).
MALONE AUTO RACKS 81 County Rd. Ste 1, Westbrook, ME 04092
P: 207.774.9100 F: 207.615.0551
E: support@maloneautoracks.com W: www.maloneautoracks.com
Limited Lifetime Warranty
The Malone Auto Racks (Malone) Limited Lifetime Warranty covers certain Malone-brand products that have been specically
identied for inclusion in the program and is effective for as long as the original retail purchaser owns the product. This warranty is
terminated when the original retail purchaser sells or otherwise transfers the product to any other person or entity.
Subject to the limitations and exclusions described in this warranty, Malone will remedy defects in materials and/or workmanship
by repairing or replacing, at its option, a defective product without charge for parts or labor. Malone may elect, at its option, not to
repair or replace a defective product but rather issue to the original retail purchaser a refund equal to the purchase price paid for the
product, or credit to be used toward the purchase of a replacement Malone product.
This warranty does not cover, and no warranty is given for defects or problems caused by normal wear and tear, which includes,
but is not limited to, surface (aesthetic) metal corrosion, scratches, dents, deformities, accidents, unlawful vehicle operation, or any
modication of a product not performed or authorized in writing by Malone.
In addition, this warranty does not cover problems resulting from conditions beyond Malone’s control including, but not limited to,
theft, misuse, overloading, or failure to assemble, mount or use the product in accordance with Malone’s written instructions or
guidelines included with the product provided to the original retail purchaser.
No warranty is given for Malone products purchased outside of the continental United States, Canada and Mexico.
If the product is believed to be defective, the original retail purchaser should contact the Malone dealer from whom it was purchased,
who will give the original retail purchaser instructions on how to proceed. If the original retail purchaser is unable to contact the
Malone dealer, or the dealer is not able to remedy the defect, the original retail purchaser should contact Malone by email at
In the event that the product must be returned to Malone, a technician at the email address above will provide the original purchaser
with return shipping instructions. The original purchaser will be responsible for the cost of mailing the product to Malone. In order
to be eligible to receive any remedy under this warranty, a copy of the original purchase receipt, a description of the defect and a
return address must be provided.
Disclaimer of Liability
Repair or replacement of a defective product, or the issue of a refund or credit (as determined by Malone) is the original retail
purchaser’s sole and exclusive remedy under this warranty. Damage to original purchaser’s vehicle, cargo, or property, and/ or to
any other person or property is not covered by this warranty.
This warranty is expressly made in lieu of any and all other warranties, express or implied, including the warranties of merchantability
and tness of a particular purpose
Malone’s sole liability to any purchaser is limited to the remedy set forth above. In no event will Malone be liable for any direct,
indirect, consequential, incidental, special, exemplary, or punitive damages , or, for any other damages of any kind or nature
(including but not limited to, lost prots, lost income or lost sales).
Some states do not allow the exclusion or limitation of incidental or consequential damages, so the above limitations may not be
applicable.
In addition, all vehicular transports are potentially hazardous. Any person(s) using Malone products are personally responsible for
following the given directions for use and/or installation and accepts full responsibility for any and all damages or injury of any kind
including death, which may result from their use and/or installation.
MALONE
R
MALONE AUTO RACKS 81 County Rd. Ste 1, Westbrook, ME 04092
P: 207.774.9100 F: 207.615.0551
E: support@maloneautoracks.com W: www.maloneautoracks.com
MALONE
R
Garantie à vie limitée
La garantie à vie limitée de Malone Auto Racks (Malone) couvre certains produits de marque Malone expressément désignés pour
être inclus dans ce programme et est valide tant que l’acheteur original est propriétaire du produit. Cette garantie prend n lorsque
l’acheteur original vend ou cède le produit à une autre personne ou entité.
Sous réserve des restrictions et exclusions prévues dans la garantie, Malone corrigera toute défectuosité matérielle et/ou tout défaut
de fabrication en réparant ou en remplaçant, à sa discrétion, un produit défectueux sans frais pour ce qui est des pièces et de la
main-d’oeuvre. Malone peut décider, à son choix, de ne pas réparer ou remplacer un produit défectueux, mais plutôt d’accorder à
l’acheteur original un remboursement d’un montant égal au prix d’achat pour le produit ou encore un crédit pour l’achat d’un produit
de remplacement de marque Malone.
La présente garantie ne couvre pas les défauts et les problèmes résultant d’une usure normale et aucune garantie n’est offerte à cet
égard, notamment en cas de corrosion du métal en surface (esthétique), d’égratignures, de bosses, de déformations, d’accident,
d’une utilisation illégale du véhicule ou de toute modication du produit qui n’est pas effectuée ou autorisée par écrit par Malone.
En outre, la garantie ne couvre pas les problèmes résultant de circonstances échappant au contrôle de Malone, y compris,
notamment, résultant d’un vol, d’un usage abusif ou d’une surcharge ou encore d’un assemblage, d’une installation ou d’une
utilisation du produit ne respectant pas les instructions écrites de Malone fournies à l’achat à l’acheteur original.
Aucune garantie n’est offerte pour des produits Malone achetés à l’extérieur du territoire continental des États-Unis, du Canada ou
du Mexique.
Si le produit semble défectueux, l’acheteur original doit contacter le détaillant Malone où il a fait son achat et celui-ci lui fournira
des renseignements sur la démarche à suivre. Si l’acheteur original ne réussit pas à contacter le détaillant Malone ou encore si le
détaillant est incapable de remédier à la défectuosité, l’acheteur original doit communiquer directement avec Malone par courriel à
l’adresse suivante : [email protected].
Dans le cas où le produit doit être retourné à Malone, un technicien contacté à l’adresse courriel ci-dessus fournira à l’acheteur
original les instructions à suivre pour l’expédition du produit. L’acheteur original devra assumer les frais d’expédition à Malone.
Pour qu’une demande soit admissible aux termes de la présente garantie, il faut envoyer à Malone une copie du reçu de l’acheteur
original, une description de la défectuosité et une adresse de retour.
Exonération de responsabilité
La réparation ou le remplacement du produit défectueux ou encore la remise d’un remboursement ou d’un crédit (tel que déterminé
par Malone) constitue le seul et exclusif dédommagement offert à l’acheteur original aux termes de la présente garantie. Les
dommages causés au véhicule de l’acheteur original, à un chargement, à ses biens et/ou à toute autre personne ou tout autre bien
ne sont pas couverts par cette garantie.
Cette garantie est octroyée expressément an de remplacer toute autre garantie expresse ou implicite, y compris toute garantie de
qualité marchande ou de conformité pour un usage particulier.
L’unique responsabilité de Malone envers l’acheteur se limite aux dédommagements indiqués ci-dessus. Malone ne pourra en
aucun cas être tenu responsable des dommages directs, indirects, consécutifs, spéciaux, exemplaires ou punitifs ou de tout autre
dommage de quelque nature que ce soit (y compris notamment une perte de prots, de revenus ou de ventes).
L’exclusion ou la limitation des dommages indirects ou consécutifs n’étant pas permise à certains endroits, les limitations indiquées
ci-dessus peuvent ne pas s’appliquer.
En outre, tous les transports par véhicule comportent des risques potentiels. Toute personne utilisant un produit Malone est donc
personnellement responsable de suivre les instructions fournies pour son utilisation et/ou son installation et accepte l’entière
responsabilité pour tout dommage ou toute blessure de quelque nature que ce soit, y compris un décès, pouvant résulter de son
utilisation et/ou son installation.
-
1
-
2
-
3
-
4
-
5
-
6
-
7
-
8
-
9
-
10
-
11
-
12
-
13
-
14
dans d''autres langues
- English: Malone MPG911 User manual
Documents connexes
-
Malone MPG216 Manuel utilisateur
-
Malone MPG901 Manuel utilisateur
-
Malone MPG155 Manuel utilisateur
-
Malone MPG452 Manuel utilisateur
-
Malone MPG187 Manuel utilisateur
-
Malone MPG201 Manuel utilisateur
-
Malone MPG119M Manuel utilisateur
-
Malone MPG113MD Manuel utilisateur
-
Malone BIGFOOT Installation & Loading Instructions
-
Malone MPG462G2 Manuel utilisateur
