STOK STG1150HD Manuel utilisateur

Marque: STOK

Modèle: STG1150HD

Catégorie: Barbecues

Taper: Manuel utilisateur

Ce manuel convient également à

GridIron STG1050

LP GAS CYLINDER SOLD SEPARATELY

BOUTEILLE DE GPL VENDUE SÉPARÉMENT

EL TUBO DE GAS PL SE VENDE POR SEPARADO

FOR OUTDOOR USE ONLY

UTILISER À L’EXTÉRIEUR SEULEMENT

PARA USO EN EL EXTERIOR ÚNICAMENTE

OPERATOR’S MANUAL

MANUEL D’UTILISATION

MANUAL DEL OPERADOR

GridIron

™

Grill

GridIron

™

Grille

GridIron

™

Gril

STG1050

CONSERVER CE MANUEL POUR

FUTURE RÉFÉRENCE

GUARDE ESTE MANUAL PARA

FUTURAS CONSULTAS

SAVE THIS MANUAL FOR FUTURE REFERENCE

NOTE TO INSTALLER/ASSEMBLER: Give this Operator’s Manual to the consumer so the consumer may retain it for future

reference.

DANGER:

You WILL be KILLED or SERIOUSLY HURT if you do not follow the instructions in this operator’s manual.

Visit the STOK website at: www.stokgrills.com

REMARQUE À L’INTENTION DE L’INSTALLATEUR/

ASSEMBLEUR : Remettre ce manuel d’utilisation au propriétaire

du gril à titre de référence.

DANGER:

Le non-respect des instructions fournies dans ce manuel

d’utilisation entraînera des BLESSURES GRAVES, voire

MORTELLES.

Visitez le site Web de STOK à l’adresse suivante : www.stokgrills.com

AVISO PARA EL INSTALADOR/ARMADOR: Entregue este Manual

del Operador al consumidor, de modo que el consumidor pueda

conservarlo para referencia en el futuro.

PELIGRO:

El incumplimiento de las instrucciones en este manual del

operador puede CAUSARLE LA MUERTE O LESIONARLE

GRAVEMENTE.

Visite el sitio web de STOK en: www.stokgrills.com

2 — English

 Introduction ......................................................................................................................................................................2

 General Safety Rules .................................................................................................................................................... 3-4

 Specific Safety Rules ........................................................................................................................................................4

 Symbols ............................................................................................................................................................................ 5

 Features ............................................................................................................................................................................6

 Loose Parts ......................................................................................................................................................................7

 Tools Needed ....................................................................................................................................................................7

 Assembly .................................................................................................................................................................... 8-12

 Operation .................................................................................................................................................................. 13-15

 Maintenance ............................................................................................................................................................. 16-17

 Troubleshooting ..............................................................................................................................................................18

 Warranty .........................................................................................................................................................................19

 Parts Ordering/Service ..................................................................................................................................... Back Page

TABLE OF CONTENTS

INTRODUCTION

This grill has many features for making its use more pleasant and enjoyable. Safety, performance, and de-

pendability have been given top priority in the design of this product making it easy to maintain and operate.

This instruction manual contains important information necessary for the proper assembly and safe

use of the appliance. Read and follow all warnings and instructions before assembling and using the

appliance. Keep this manual for future reference.

DANGER:

If you smell gas:

• Shut off gas to the appliance

• Extinguish any open flame.

• Open firebox hood.

• If odor continues, keep away from the

appliance and immediately call your gas

supplier or your fire department.

Failure to follow these instructions could

result in fire or explosion which could cause

property damage, personal injury or death.

DANGER:

Always use outdoors. Using the grill indoors or within an

enclosed area can lead to carbon monoxide poisoning,

resulting in serious injury or death.

WARNING:

 Do not store or use gasoline or other flammable liquids

or vapors in the vicinity of this or any other appliance.

 An LP cylinder not connected for use shall not be

stored in the vicinity of this or any other appliance.

DANGER:

• Never operate this appliance unattended.

• Never operate this appliance within 25 ft.

(7.5 m) of any flammable liquid.

• If a fire should occur, keep away from the

appliance and immediately call your fire

department. Do not attempt to extinguish

an oil or a grease fire with water.

Failure to follow these instructions could

result in fire, explosion or burn hazard which

could cause property damage, personal

injury or death.

WARNING:

Improper assembly, adjustment, alteration, service, or

maintenance can cause property damage, injury, or

death. Read the Assembly, Operation, and Maintenance

instructions thoroughly before use, assembly, or servicing

of this product.

To register your STŌK

product, please

visit: http://register.stokgrills.com

3 — English

GENERAL SAFETY RULES

WARNING:

Read and understand all instructions. Failure to follow

all instructions listed below, may result in electric shock,

fire and/or serious personal injury.

READ ALL INSTRUCTIONS

 This appliance must be installed in accordance with the

latest local codes. In the absence of local codes, use the:

• United States:

- National Fuel Gas Code, ANSI Z223.1/NFPA 54

- LP gas Code, NFPA 58

• Canada:

- Natural Gas and Propane Installation Code, CSA

B149.1

- Propane Storage and Handling Code, CSA B149.2

 If an accessory is used on the grill that requires an external

electrical power source, the accessory when installed

must be electrically grounded in accordance with local

codes. In the absence of local codes, use the:

• United States: National Electrical Code, ANSI/NFPA 70

• Canada: Canadian Electrical Code, CSA C22.1

 This appliance is for outdoor use only, and shall not be

used in a building, garage, shed, balcony, or any other

enclosed area.

 Do not use or install this appliance in or on boats or

recreational vehicles.

 This grill must be located away from combustible surfaces

by no less than 36 in. (914 mm) from back of grill and

36 in. (914 mm) from sides of this grill.

 The grill shall not be used under overhead combustible

construction.

 The grill is not intended for and should never be used as

a heater.

 Keep area around this appliance free of combustible

materials, gasoline, and all other flammable vapors and

liquids.

 Do not restrict the flow of combustion and ventilation air.

 Keep ventilation openings of the cylinder enclosure free

and clear from debris.

 This grill is not intended for commercial use.

 Never move grill when using or still hot.

 Never use the grill indoors. Toxic fumes can accumulate.

 Always remove the LP gas cylinder (liquid propane also

called liquid petroleum gas) when the appliance is not in

use or before storing or lowering the unit.

 Do not alter the grill in any manner.

 Do not use this appliance unless it is fully and properly

assembled and all parts are securely fastened.

 Never attempt to light burner with the firebox hood

closed. A build up of non-ignited gas inside a closed grill

is hazardous.

 When in use, keep children and pets away at all times.

 Do not leave the grill unattended.

 Do not use charcoal, ceramic briquettes, or lava rock in

a gas grill.

 In the event of a grease fire, turn off the burner. Do not

attempt to extinguish with water. Use type BC dry chemical

fire extinguisher or smother with dirt, sand, or baking

soda.

 When cooking with oil or grease, have a type BC or ABC

fire extinguisher readily available.

 Keep any electrical cord and fuel supply hose away from

any heated surfaces.

 Do not store a spare LP gas cylinder under or near the

grill. If not followed exactly, a fire causing death or serious

injury may occur.

36 in.

Fig. 1

4 — English

SPECIFIC SAFETY RULES

 Use grill only with LP gas and the regulator/valve assembly

supplied.

 Check for leaks prior to grilling operations. Do this even

if this grill was assembled at the store.

 Do not operate the grill if there is a gas leak present.

 Never use a flame to check for gas leaks.

 Should the burner go out while grilling, turn off the gas

valve. Open the firebox hood and wait five minutes before

attempting to relight.

 Never lean over an open grill or place hands or fingers

on hot surfaces.

 Thoroughly clean the grill regularly.

 Do not block the ventilation holes in the sides or back of

the grill.

 Never attempt to use the appliance or any components

that have been damaged or exposed to an accidental

fire.

 Propane gas is not natural gas. Do not try to convert

this grill to natural gas as it will void the warranty and is

extremely dangerous.

 Place dust cap on cylinder valve outlet whenever the

cylinder is not in use. Only install the type of dust cap on

the cylinder valve outlet that is provided with the cylinder

valve. Other types of caps or plugs may result in leakage

of propane.

 Do not store or use gasoline or other flammable liquids

or vapors in the vicinity of the grill.

 Use heat-resistant mitts or gloves, and long-handled

utensils when operating this grill.

 When cooking, the grill must be on a level, stable

noncombustible surface in an area that is free of

combustible material. An asphalt surface (blacktop) may

not be acceptable for this purpose.

 Apartment Dwellers: Check with management to learn

requirements and fire codes of using a LP gas grill in your

apartment complex.



Save these instructions. Refer to them frequently and use

them to instruct others who may use this grill. If you loan

someone this grill, loan them these instructions also.

GENERAL SAFETY RULES

 If a leak is detected at any time, get away from the LP

gas cylinder and call the fire department.

 This grill is not intended to be used on a boat, in an RV,

camper trailer, or motor home.

 Do not use the grill until leak-tested.

 Periodically check and/or clean the burner/venturi tubes

for insects and insect nests. A clogged tube can lead to

a fire beneath the grill.

 LP gas cylinders must be stored outdoors out of

reach of children and must not be stored in a building,

garage, or any other closed in area.

 Do not operate the grill while under the influence of drugs,

alcohol, or any medication.

 Stay alert and exercise control. Watch what you are doing

and use common sense. Do not operate a grill when you

are tired.

 Propane cylinder use (1 lb. disposable):

• Use only cylinder marked “Propane Fuel”.

• Cylinder must be constructed and marked in accordance

with the specifications for LP gas cylinders of the U.S.

Department of Transportation (DOT) or the National

Standard of Canada, CAN/CSA-B339, Cylinders,

Spheres and Tubes for the Transportation of Dangerous

Goods.

• Size should be 4 in. diameter, 8 in. height, or 3 in.

diameter, 10 in. height.

• Save cylinder cap and reinstall when not in use.

• Cylinder supply system must be arranged for vapor

withdrawal. Gas cylinder must be upright in use.

5 — English

SYMBOLS

The following signal words and meanings are intended to explain the levels of risk associated with this product.

SYMBOL SIGNAL MEANING

DANGER:

Indicates an imminently hazardous situation, which, if not avoided, will result

in death or serious injury.

WARNING:

Indicates a potentially hazardous situation, which, if not avoided, could result

in death or serious injury.

CAUTION:

Indicates a potentially hazardous situation, which, if not avoided, may result in

minor or moderate injury.

NOTICE:

(Without Safety Alert Symbol) Indicates important information not related to an

injury hazard, such as a situation that may result in property damage.

Some of the following symbols may be used on this product. Please study them and learn their meaning. Proper

interpretation of these symbols will allow you to operate the product better and safer.

SYMBOL NAME DESIGNATION/EXPLANATION

Safety Alert Indicates a potential personal injury hazard.

Read Operator’s

Manual

To reduce the risk of injury, user must read and understand operator’s

manual before using this product.

Hot Surface

To reduce the risk of injury or damage, avoid contact with any hot

surface.

CALIFORNIA PROPOSITION 65

WARNING:

1. Combustion by-products produced when using this product may contain chemicals known to the State of California

to cause cancer, birth defects, or other reproductive harm. To reduce the risk of exposure to these substances, always

use the grill in a well-ventilated area.

2. This product contains chemicals, including lead, lead compounds, and benzene (depending on the fuel type used),

known to the State of California to cause cancer, birth defects, or other reproductive harm. Wash hands after handling.

To minimize exposure to these substances, always operate this unit according to the Operator’s Manual, ensuring you

provide adequate ventilation when cooking with gas.

In Massachusetts: All gas products must be installed using a Massachusetts-licensed plumber or gasfitter. A “T” handle

type manual gas valve must be installed in the gas supply line to this appliance. This applies to permanently installed

natural gas and propane installation. This does not apply to propane portable installations using a 20 lb. tank.

6 — English

MATCH HOLDER STORAGE - Slots in the back of the grill

provide convenient storage for the match holder.

REMOVABLE GRATE INSERT - Remove the round

porcelain-coated, cast-iron grate insert when using the

pizza stone, vegetable tray, or other available inserts (sold

separately). When transporting be sure the cast-iron grate

is installed.

RUGGED WHEELS - The durable plastic wheels allow you

to move the grill across smooth and rough surfaces.

TEMPERATURE GAUGE - The temperature gauge

measures temperatures up to 700°F.

PRODUCT SPECIFICATIONS

BTU rating ...............................................................15,000

Total grill surface ............................................... 338 sq. in.

Grilling surface height ................................................ 31 in.

FEATURES

Fuel source .....................................Propane (not included)

Natural gas convertible ................................................. No

KNOW YOUR GRILL

See Figure 2.

The safe use of this grill requires an understanding of

the information on the grill and in this operator’s manual.

Before use of this grill, familiarize yourself with all operating

features and safety rules.

COLLAPSIBLE STAND - The stand can be collapsed for

storing or transporting the grill.

ELECTRIC IGNITOR - The electric ignitor uses a AAA

battery that lights the gas burner when pushed.

FIREBOX HOOD - The firebox hood can be locked for easy

transport.

Fig. 2

REMOVABLE

GRATE

INSERT

ELECTRIC

IGNITOR

RUGGED

WHEELS

FIREBOX

TEMPERATURE

GAUGE

COLLAPSIBLE

STAND

FIREBOX

HOOD

MATCH

HOLDER

STORAGE

CONTROL

KNOB

FIREBOX

HANDLE

GRATE

STAND

FRONT

HANDLE

7 — English

Fig. 3

The following tools (not included or drawn to scale) are needed for assembly and making adjustments:

PHILLIPS

SCREWDRIVER

TOOLS NEEDED

Fig. 4

LOOSE PARTS

A - Firebox handle .......................................................... 1

B - Grease cup ............................................................... 1

C - Grate insert ............................................................... 1

D - Grate ......................................................................... 1

E - Wheel ........................................................................ 2

F - Stand front handle .................................................... 1

G - Axle ........................................................................... 1

HARDWARE BLISTER PACK

AA - Wing nut ................................................................2

BB - Screw (wheel) ........................................................2

CC - AAA Battery ...........................................................1

DD - Washer ..................................................................4

EE - Screw (stand front handle) ....................................4

FF - Hitch pin ................................................................1

8 — English

ASSEMBLY

UNPACKING

This product requires assembly.

 Carefully lift grill from the carton and place it on a level

work surface.

WARNING:

Do not use this product if any parts on the Loose Parts List

are already assembled to your product when you unpack

it. Parts on this list are not assembled to the product by

the manufacturer and require customer installation. Use

of a product that may have been improperly assembled

could result in serious personal injury.

 Inspect the grill carefully to make sure no breakage or

damage occurred during shipping.

 Do not discard the packing material until you have

carefully inspected the grill, identified all loose parts, and

satisfactorily operated the grill.

NOTE: Some loose parts are located inside the grill

assembly beneath the firebox hood.

 If any parts are damaged or missing, please call

1-800-847-5993 for assistance.

WARNING:

If any parts are damaged or missing, do not operate

this grill until the parts are replaced. Use of this product

with damaged or missing parts could result in serious

personal injury.

CAUTION:

Some parts may contain sharp edges that may cause

personal injury. Wear protective gloves if necessary.

STEP 1: ATTACHING THE WHEELS

See Figure 5 - 6.

 With the grill out of the box and packaging removed,

place the grill right side up on flat surface.

 Locate the holes in the stand legs.

 Slide the axle (G) through the square hole in the left stand

leg and then through the round hole in the right stand leg.

 Install the hitch pin (FF) into the hole in the axle to secure

it in place.

 Raise the grill, slide washer (DD) and wheel (E) onto the

axle.

 Using a second washer (DD) and screw (BB), secure the

wheel to the stand. Securely tighten screw.

 Repeat this process to secure the other wheel.

Fig. 5

Fig. 6

Fig. 7

WASHER

AXLE

SCREW

STEP 2: ATTACHING THE STAND FRONT

HANDLE

See Figure 7.

 Locate the handle mounts on the firebox.

 Align holes in stand front handle (F) with holes in mounts.

 Install front handle using phillips screws (EE). Securely

tighten screws.

SCREW

MOUNT

STAND

FRONT

HANDLE

SQUARE

HOLE

ROUND

HOLE

AXLE

HOLE

HITCH

9 — English

ASSEMBLY

STEP 3: OPENING THE STAND

See Figure 8 - 10.

 Grasp the stand front handle and raise the stand until it

rests on the wheels and frame support.

WARNING:

Use the stand front handle to raise the stand. Do not

raise by any part of the grill that is attached to the stand.

Failure to heed this warning can result in possible injury

and damage the grill.

 Step on the release lever and pull the stand front handle

toward you at the same time.

 Apply slight downward pressure on the stand until the

release lever closes over the center brace locking the unit

in place.

WARNING:

Failure to remove the LP gas cylinder or attempting

to move the grill while it is hot could result in serious

personal injury.

RELEASE

LEVER

Fig. 9

Fig. 8

CENTER

BRACE

Fig. 10

RELEASE

LEVER

STAND

FRONT

HANDLE

FOOT

BRACE

STAND

FRONT

HANDLE

RELEASE

LEVER

FRAME

SUPPORT

10 — English

ASSEMBLY

STEP 4: ATTACHING FIREBOX HANDLE

See Figures 11 - 12.

 Raise and open the stand.

 Lift the hood latch then raise firebox hood.

 Insert studs in firebox handle (A) through holes in firebox

hood.

 Install wing nuts (AA) and tighten securely.

STEP 5: INSTALLING THE GREASE CUP

See Figure 13.

 Slide the grease cup (B) into the cup holders on the bot-

tom of the grill.

NOTE: Clean the grease cup after each use. Do not remove

the grease cup until after the grill has cooled completely.

Do not transport the grill with a dirty grease cup.

Fig. 11

HOOD

LATCH

FIREBOX

HOOD

FIREBOX

Fig. 12

WING

NUT

FIREBOX

HANDLE

FIREBOX

HOOD

Fig. 13

GREASE

CUP

STUD

11 — English

LP GAS

CYLINDER

REGULATOR

Fig. 15

IGNITOR CAP

AAA

BATTERY

ASSEMBLY

STEP 6: INSTALLING BATTERY IN IGNITOR

See Figure 14.

 Turn the ignitor cap counterclockwise and lift cap from

the control panel.

 Slide a AAA battery (CC), negative (—) end first, into the

ignitor. Be sure spring is still in place inside the ignitor cap.

 Replace ignitor cap.

STEP 7: CONNECTING THE LP GAS CYLINDER

TO THE REGULATOR

See Figure 15.

 Remove cap from LP gas cylinder.

 Hold the LP gas cylinder firmly and insert into the

regulator.

 Turn the cylinder clockwise taking care not to cross thread

the connection. Do not use tools.

NOTE: The regulator will seal in the cylinder valve result-

ing in some resistance. An additional one-half to three-

quarters turn is required to complete the connection.

If you cannot complete the connection, disconnect and

repeat the above two steps. If you still cannot complete

the connection, DO NOT use this regulator!

 Inspect valve connections. Look for any damage or debris.

Remove any debris. Never attempt to use damaged or

plugged equipment. See your local LP Gas Dealer for

repairs.

STEP 8: TESTING VALVES AND REGULATOR

FOR LEAKS

See Figure 16.

Connections on the valve were tested at the factory to ensure

no gas leaks were present. However, shipping and handling

could loosen connections. As a safety precaution:

 Turn the control knob off.

NOTE: To lock the control knob in the off position, turn

the control knob to LOCK ( ).

 Make sure the LP cylinder is properly connected to the

LP gas cylinder valve.

If you hear a rushing sound, immediately remove the LP

gas cylinder. This sound means there is a major leak at

the connection. Correct the problem before proceeding.

 Using a clean paint brush and a 50/50 mixture of mild

soap and water, brush soapy solution over all the con-

nections and fittings on the grill.

Fig. 14

12 — English

ASSEMBLY

 “Growing” bubbles indicate a leak. Remove the LP gas

cylinder and recap the bottle.

NOTE: If leaks cannot be stopped, do not try to repair.

Call for replacement parts.

STEP 9: CLOSING STAND AND TRANSPORT-

ING THE GRILL

See Figures 17 - 18.

Never close the stand or attempt to move the grill unless the

grill is completely cool, the grease cup is empty, and the LP

gas cylinder is removed.

NOTE: Make sure the grate and removable insert are in

place and hood latch secured prior to closing the stand or

transporting the grill. This will help to keep all grates in place.

To close the stand:

 Grasp the stand front handle and step on the release

lever.

 Lift the stand front handle up and away from you.

 Apply slight forward pressure until the release lever clicks

into place and the unit rests on the wheels and frame

support.

 From this position, the GRIDIRON

™

grill can be moved

easily from place to place.

To lower a closed stand :

 Stand at the wheel side of the collapsible stand and grasp

the stand front handle.

 Tilt the unit toward you and then slowly lower it to the

ground.

Fig. 16

REGULATOR

Fig. 18

Fig. 17

RELEASE

LEVER

STAND

FRONT

HANDLE

13 — English

OPERATION

WARNING:

Do not allow familiarity with grill to make you careless.

Remember that a careless fraction of a second is

sufficient to inflict severe injury.

WARNING:

Do not use any attachments or accessories not

recommended by the manufacturer of this grill. The use

of attachments or accessories not recommended can

result in serious personal injury.

SAFETY TIPS FOR USING THE GRILL

 Before turning the control knob on, check the LP gas

cylinder for tightness and perform a leak test.

 Trim excess fat from meat to reduce flare ups from drip-

pings.

 When grill is not in use, turn the control knob to LOCK

( ), and remove the LP gas cylinder.

 Do not move grill while cooking.

 To avoid burns and splatters, use long-handled utensils

and oven mitts.

 Do not use the grill if the grease cup is not clean and

properly installed.

 Once the grill has cooled, clean promptly.

 Do not let grease or hot material drip from the grill onto

the valve, hose, or regulator. Correct the problem before

use.

 If the regulator frosts, immediately turn off the grill and

cylinder valve. This indicates a problem with the LP gas

cylinder and it should not be used. Return the cylinder

to the supplier.

 Do not leave the grill unattended while preheating

or burning off food residue. If the grill has not been

regularly cleaned as instructed, a grease fire can occur.

 Never use water on a grease fire.

 Perform a burner flame check before each use (see the

Maintenance section).

GRILLING GUIDE

High — for preheating the grill, searing steaks and other cuts

of meat, burning off food residue from grate.

Medium — for most grilling, baking, and roasting.

Low — for cooking fish and other lean foods.

COOKING/GRILLING TIPS

 The best oils to use when grilling meats are high-temper-

ature oils (i.e., peanut, canola, safflower, and cottonseed

oils).

 Dry off meat prior to grilling. Dry meat browns; wet meat

steams.

 Grill with the firebox hood down.

 Keep grates clean. A clean grate is less likely to be sticky

and will last longer.

 Clean the firebox hood and inside the firebox often. A

grease build-up is a fire hazard and adds unwanted flavors

to your fresh food.

 Before lighting the burner, spray grates with non-stick

spray to prevent food from sticking.

 Always preheat the grill 10 - 15 minutes prior to use.

 Before you start grilling, organize the food by cooking tech-

nique, required cooking time, and grilling area required.

 Sauces containing sugars and fats can cause flare-ups

and burn your food. Apply these sauces only in the last

10 minutes of cooking.

 Marinades and rubs enhance the flavor of food. A dry rub

or liquid marinade can be used prior to cooking.

FOOD SAFETY

 Wash hands, utensils, and surfaces with hot soapy water

before and after handling raw meat.

 Keep raw meat separate from ready-to-eat foods.

 Use a clean platter and utensils when removing cooked

food from the grill.

 Cook meat and poultry thoroughly to kill bacteria.

 Use a meat thermometer to ensure proper internal tem-

perature of meat.

 USDA Recommended Safe Minimum Internal Tempera-

tures of Food:

• 145°F for beef, veal, lamb, steaks, and roast

• 145°F for fish

• 160°F for ground pork, beef, veal, and lamb

• 160°F for pork

• 160°F for egg dishes

• 165°F for turkey, chicken, and duck (whole, pieces,

and ground)

 Refrigerate prepared and leftover foods promptly.

WARNING:

If ignition does NOT occur within 5 seconds, turn the

control knob to OFF ( O ) and wait 5 minutes. Repeat lighting

procedures. If burner does NOT ignite with the cylinder

valve open, gas will continue to flow out of the burner and

could accidently ignite and result in serious personal injury.

14 — English

OPERATION

To ignite burner using match lighting:

 Open the firebox hood.

 Turn control knob to OFF ( O ).

NOTE: To lock the control knob in the off position, turn

the control knob to LOCK ( ).

 Make sure the LP gas cylinder is tightly connected to the

regulator and a leak test has been performed.

 Using the match holder included with this grill, place a

match between the circular wires.

 Light the match and place into lighting hole on the

bottom of the firebox.

 Push in the control knob and turn to .

 When burner is lit, turn the control knob to the desired

setting.

If burner fails to light, extinguish the match, turn the control

knob off, and wait five (5) minutes then repeat the step.

NOTE: Place burner on high and observe flame height

which should be approximately 1/2 in. If flame is too

high or too low, burner adjustment is required. See the

Maintenance section later in this manual.

NOTE: If a burner is accidentally extinguished, turn the

control knob off, wait five (5) minutes then start the ignition

process again.

IGNITING THE BURNER

See Figures 19 - 20.

NOTE: Never lean over the grill while lighting burner.

The first time you use your newly purchased grill, it is

recommended the grill run on the highest setting for

15 - 20 minutes.

To ignite burner using the electric ignitor:

 Open the firebox hood.

 Turn the control knob on the side shelf to OFF ( O ).

NOTE: To lock the control knob in the off position, turn

the control knob to LOCK ( ).

 Make sure the LP gas cylinder is tightly connected to the

regulator and a leak test has been performed.

 To light the burner, push in the control knob and turn

to .

 Press and hold the electric ignitor until the burner lights.

When burner is lit, turn the control knob to the desired

setting.

If burner fails to light within five (5) seconds, release the

electric ignitor. Turn the control knob off and wait five (5)

minutes then repeat the step.

NOTE: Place burner on high and observe flame height

which should be approximately 1/2 in. If the flame is

too high or too low, burner adjustment is required. See

Maintenance section later in this manual.

NOTE: If a burner is accidentally extinguished, turn the

control knob off, wait five (5) minutes then start the ignition

process again.

Fig. 19

CONTROL

KNOB

ELECTRIC

IGNITOR

LIGHTING

HOLE

Fig. 20

MATCH

HOLDER

15 — English

OPERATION

WARNING:

Never use an accessory if the porcelain coating is

damaged or chipped. Use with a damaged coating could

result in serious personal injury if ingested.

USING THE GRILL AND ACCESSORIES

To use the grate:

 Turn on the grill and close the firebox hood. Preheat the

grill for 10 - 15 minutes.

 Open the firebox hood and place the food on clean grates

then replace the firebox hood. Cooking time will vary

depending on personal preference.

NOTE: When grilling fish, the meat is typically done when

it flakes easily with a fork. If any part of the meat is glossy

in appearance, it is not done.

 When finished cooking, turn the control knob off.

NOTE: To lock the control knob in the off position, turn

the control knob to LOCK ( ).

 After the grill has cooled, clean grates and grease cup.

16 — English

MAINTENANCE

Clean burner tubes using one of the following three ways:

1. Bend a stiff wire into a small hook. Run the hook

through the burner tube several times.

2. Use a narrow bottle brush with flexible handle and

run through burner tubes several times. DO NOT

use a wire brush.

3. Wear eye protection then use an air hose to force

air into the burner tube and out through the burner

port. Clean any clogged port with an opened paper

clip.

WARNING:

When servicing, use only identical replacement parts.

Use of any other parts could create a hazard or cause

product damage.

GENERAL MAINTENANCE

When cleaning the inside of the firebox hood and grill bottom,

use a strong solution of detergent and water with a scrub

brush to clean. Rinse thoroughly and allow to air dry. NEVER

use a caustic grill cleaner on painted or cooking surfaces.

All plastic parts, stainless-steel and painted surfaces, should

be cleaned with warm soapy water and wiped dry. Cook-

ing surfaces should be cleaned with a bristle brush only.

Check that no loose bristles remain on the cooking grates

prior to using.

Cooking grates:

 Clean before and after each use with a stiff wire brush.

Port shields:

 Scrape any build-up off the port shields using a wire

brush.

Grease:

 After use, allow the grease in the cup to cool then empty

into the garbage.

 Empty after each use to avoid spillage and flare ups.

CLEANING BURNER ASSEMBLY AND CHECK-

ING VENTURI FOR INSECTS

See Figures 21 - 22.

DANGER:

Failure to clean the burner assembly and check the

venturi as described can result in a fire or explosion

resulting in serious injury or death.

Burner should be cleaned when the grill has been idle for

some time. In some parts of the country, spiders and other

insects can spin webs, build nests, and lay eggs in the ven-

turi blocking gas flow and causing fire in the tubes known

as “flashback”. Flashback can damage the grill and even

cause injury.

 Turn control knob to OFF ( O ). Allow grill to cool com-

pletely.

NOTE: To lock the control knob in the off position, turn

the control knob to LOCK ( ).

 Remove the LP gas cylinder.

 Pull electrode wire from the electronic ignitor.

 Remove the wing nuts securing the burner to the firebox.

 Lift burner up and away from the gas valve openings.

Fig. 21

Fig. 22

BURNER

TUBE

ELECTRODE

GAS VALVE

ORIFICE

WING

NUT

BURNER

FIREBOX

PORT SHIELD

17 — English

MAINTENANCE

 Once burner tube is clear of debris, use a wire brush to

remove food and dirt from the outer surface of the tubes.

 Check burner for damage. Normal wear and corrosion

may cause some holes to enlarge. Replace burner if this

happens.

NOTE: Burner tube must reengage valve opening.

 Verify that the gas valve orifice is correctly positioned

inside burner inlet.

 Attach the electrode to the burner and carefully replace

the burner.

 Slide burner into the grill and secure burner using wing

nuts.

 Reattach electrode wires to the electronic ignitor.

BURNER FLAME CHECK

See Figure 23.

 Open the firebox hood and allow grill to cool completely.

 Turn control knob to OFF ( O ).

NOTE: To lock the control knob in the off position, turn

the control knob to LOCK ( ).

 Remove grates.

 Light burner and turn the control knob from high to low.

A smaller flame should been seen on low while the high

positions flame should be approximately 1/2 in. in height.

 If only a low flame is seen, you may need to reset

the gas regulator safety device as described in the

Operation section.

Fig. 23

LOW

HIGH

IGNITOR CHECK

Remove LP gas cylinder completely. Press and hold the

ignitor. “Click” should be heard and a spark seen between

the burner and electrode. If no spark, see the Troubleshoot-

ing section later in this manual.

VALVE CHECK

Remove LP gas cylinder completely. Control knob locks in

place when turned off. To check valves: push in knobs and

release. If knobs don’t spring back, replace the valve

assembly before using grill.

STORING THE GRILL

See Figure 24.

 Turn the control knob to OFF ( O ).

NOTE: To lock the control knob in the off position, turn

the control knob to LOCK ( ).

 Remove LP gas cylinder.

 Place dust cap on cylinder valve outlet whenever the

cylinder is not in use. Only install the type of dust cap on

the cylinder valve outlet that is provided with the cylinder

valve. Other types of caps or plugs may result in leakage

of propane.

 Once cooled, clean grill thoroughly.

 Store in dry location. If storing outside, cover grill with

one of the variety of grill covers offered by STOK or other

grill cover manufacturers.

Fig. 24

18 — English

TROUBLESHOOTING

PROBLEM CAUSE SOLUTION

Smell of gas Regulator, or valve leaking. Remove LP cylinder immediately

and check for damaged regulator or

valve. Perform leak test, see Testing

Valves and Regulator for Leaks in the

Assembly section.

Flame flashback beneath control panel Fire in burner tube due to blockage. See Cleaning Burner Assembly and

Checking Venturi for Insects in the

Maintenance section.

Gas leak detected from cylinder,

regulator, or other connection

Improper installation and loose

connections.

Mechanical failure due to rusting or

mishandling.

Tighten fittings and see Testing Valves

and Regulator for Leaks in the

Assembly section.

Replace LP gas cylinder.

Grease fire or continuous excessive

flames above cooking surface

Grease build up in burner area. Turn off control knob. Leave firebox

hood open allowing flames to extinguish.

Once cool, clean grill thoroughly.

Burner will not light LP gas cylinder is empty.

Burner not connected to control knob.

Venturi blocked.

Ignitor wire is loose, dirty, or not

connected.

Dead battery in ignitor.

Replace LP gas cylinder.

Make sure valves are inside the burner

tubes.

See Testing Valves and Regulator for

Leaks in the Assembly section.

Reconnect burner electrode wires or

replace the ignitor wire assembly. Clean

wires and/or electrode with rubbing

alcohol and a clean swab. Tighten all

connections.

Replace the battery in the ignitor.

Decreasing heat or popping sound LP gas cylinder is empty.

Venturi blocked.

Replace LP gas cylinder.

See Cleaning Burner Assembly and

Checking Venturi for Insects in the

Maintenance section

Hot spots on cooking surface Venturi blocked. See Cleaning Burner Assembly and

Checking Venturi for Insects in the

Maintenance section

Yellow flame Venturi or burner may be blocked. See Cleaning Burner Assembly and

Checking Venturi for Insects in the

Maintenance section

Inside of firebox hood appears to be

peeling

This is a build up of grease. Clean with a soft bristle brush or

scraper.

19 — English

WARRANTY

STŌŌK

GAS GRILL LIMITED WARRANTY

Thank you for purchasing a STŌŌŌK

brand grill. Below is our limited gas grill product warranty. Before submitting a warranty

claim, we suggest you read the Operator’s Manual that came with your grill. You may discover an easy and simple solution

to your problem. If you cannot find the manual, a replacement can be obtained by calling the number below, or by down-

loading one from our web site at the address below.

What the Warranty Covers:

• Stainless Steel Burner: 10 years against manufacturing and material defects

• All other Grill Parts and Components: 2 years against manufacturing and material defects

The warranty period begins on the date of purchase. The warranty applies only to grills purchased from an authorized retailer

in the U.S. or Canada and extends only to the original purchaser and is not transferable.

Although we encourage you to register your gas grill, you do not need to do so in order to submit a warranty claim. Registering

your grill, however, will NOT serve as a substitute for a sales receipt. We cannot honor any warranty claims without a valid

sales receipt which shows date and place of purchase. If STŌŌŌK approves the claim, you may be required to return any

defective part, which STŌŌK will repair or replace without charge. If a part is not repairable and no longer available, the part

may be replaced with a similar part of equal function. Repair or replacement of parts does not extend the warranty period.

Repair or replacement of parts is your exclusive remedy under this limited warranty.

What the Warranty Doesn’t Cover:

The limited warranty does not cover damage caused by any of the following:

• Failure to assemble, use, or maintain the grill in accordance with the assembly instructions and Operator’s Manual or

any other misuse or abuse or failure to follow local codes

• Commercial, institutional, apartment complex, or other community use

• Gas cylinders or tanks

• Unauthorized modification or repair of the grill or use of unauthorized parts

• Acts of God such as fire, flood, hurricanes, lightning, wind, and hail

• Flare-up fires or accidents

• Cleaners other than those recommended in the Operator’s Manual or exposure to other chemicals either directly or in

the atmosphere (do not store your grill near a pool)

• Food loss or incidental, consequential, or special damages

• Scratches, dents, discoloration, surface rust, or other cosmetic issues or damages caused by tools during assembly

• Normal wear and tear

• Any consumable accessories provided with your grill such as grilling tools, brushes, or cleaners

• Postage, pickup, delivery or other transportation costs

• The cost to remove or install any parts or components or other labor charges

THIS LIMITED WARRANTY IS THE SOLE EXPRESS WARRANTY PROVIDED BY STŌŌŌK. EXCEPT TO THE EXTENT PRO-

HIBITED BY LAW, ANY IMPLIED WARRANTY OF MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE IS

LIMITED TO THE DURATION OF THE ABOVE WARRANTY. NO RETAILER OR OTHER PARTY HAS ANY AUTHORITY TO

CREATE ANY OTHER WARRANTY OR ADD TO OR VARY THIS LIMITED WARRANTY. ONE WORLD TECHNOLOGIES,

INC.’S MAXIMUM LIABILITY IN ANY EVENT UNDER THIS WARRANTY WILL NOT EXCEED THE PURCHASE PRICE PAID

BY THE ORIGINAL PURCHASER.

Note that some states, provinces, or other jurisdictions do not allow exclusion or limitation of incidental or consequential

damages or limits on how long an implied warranty lasts. Some of the above limitations therefore may not apply to you.

This limited warranty gives you specific legal rights. You also may have other rights that vary from jurisdiction to jurisdiction.

How to Obtain Warranty Service:

Before returning any parts or components, please contact Customer Service at the number shown below. Please have

available the grill’s serial number (located on leg stand) and a copy of your sales receipt showing your date and place of

purchase. The call must be made within the warranty period.

Returns will not be accepted without a valid return authorization number (RAN) from Customer Service. You will be

responsible for paying shipping charges, and you must return the defective part to STŌŌŌK freight/postage prepaid with the

RAN shown on the outside of the package. Returns that do not meet these requirements will be refused. We will return a

replacement part to you freight/postage prepaid.

STŌŌŌK Customer Service (toll free, U.S. and Canada): 1-800-847-5993

STŌŌK web site address: www.stokgrills.com

2 — Français

 Introduction ......................................................................................................................................................................2

 Règles de sécurité générales ....................................................................................................................................... 3-4

 Règles de sécurité particulières .......................................................................................................................................4

 Symboles .......................................................................................................................................................................... 5

 Caractéristiques ...............................................................................................................................................................6

 Pièces détachées .............................................................................................................................................................7

 Outils nécessaire ..............................................................................................................................................................7

 Assemblage ................................................................................................................................................................ 8-12

 Utilisation .................................................................................................................................................................. 13-15

 Entretien ................................................................................................................................................................... 16-17

 Recherche de pannes .....................................................................................................................................................18

 Garantie ..........................................................................................................................................................................19

 Commande de pièces/réparation ................................................................................................................... Páge arrière

TABLE DES MATIÈRES

INTRODUCTION

Cet parrilla offre de nombreuses fonctions destinées à rendre son utilisation plaisante et plus satisfaisante. Lors

de la conception de ce produit, l’accent a été mis sur la sécurité, les performances et la fiabilité, afin d’en faire

un outil facile à utiliser et à entretenir.

Ce manuel d’utilisation contient des renseignements importants nécessaires pour l’assemblage efficace et

l’utilisation sécuritaire de l’appareil. Lire et suivre les avertissements et instructions avant d’assembler et d’utiliser

l’appareil. Conserver ce manuel pour référence ultérieure.

Pour enregistrer votre produit de STŌK

, s’il

vous plaît la visite: http://register.stokgrills.com

DANGER :

Si une odeur de gaz se dégage :

• Fermer l’alimentation en gaz de l’appareil.

• Éteindre le feu.

• Ouvrir le couvercle de la boîte à feu.

• Si l’odeur persiste, s’éloigner du gril et appeler

immédiatement le fournisseur de gaz ou le

service des incendies.

Le non-respect de ces instructions peut

causer un incendie ou une explosion, ce qui

peut entraîner des dommages matériels, des

blessures ou la mort.

DANGER :

Toujours utiliser à l’extérieur. L’utilisation du gril à l’intérieur

ou dans un espace confiné crée des risques d’intoxication

au monoxyde de carbone, pouvant entraîner de sérieux

problèmes de santé, voire une issue fatale.

AVERTISSEMENT :

 Ne pas entreposer ou utiliser d’essence ou d’autres gaz

ou liquides inflammables à proximité du gril ou d’un autre

appareil.

 Ne pas entreposer une bouteille de GPL qui n’est pas

branchée aux fins d’utilisation à proximité du gril ou d’un

autre appareil.

DANGER :

• Ne jamais faire fonctionner cet appareil s’il est

laissé sans surveillance.

• Ne jamais faire fonctionner cet appareil à

l’intérieur d’une distance de 7,5 m (25 pi) d’un

liquide inflammable.

• En cas d’incendie, s’éloigner de l’appareil

et appeler les pompiers immédiatement. Ne

jamais tenter d’éteindre un feu d’huile ou de

graisse avec de l’eau.

Le non-respect de ces instructions peut causer

un incendie, une explosion ou des brûlures, ce

qui peut entraîner des dommages matériels, des

blessures ou la mort.

AVERTISSEMENT :

Un assemblage, une modification, un ajustement, un

service ou un entretien inadéquats peuvent causer la mort,

des lésions corporelles ou des dommages matériels. Lire

attentivement les instructions d’assemblage, d’utilisation

et d’entretien décrites dans le présent manuel avant

d’assembler ou d’employer le gril ou d’en faire l’entretien.

La page charge ...

STOK STG1150HD Manuel utilisateur

Marque: STOK

Modèle: STG1150HD

Catégorie: Barbecues

Taper: Manuel utilisateur

Ce manuel convient également à

GridIron STG1050

Télécharger le PDF

rapport

dans d''autres langues

English: STOK STG1150HD User manual
español: STOK STG1150HD Manual de usuario

STOK STG1150HD Manuel utilisateur

Ce manuel convient également à

STOK STG1150HD Manuel utilisateur

dans d''autres langues

Documents connexes

Autres documents