Empire Heating Systems DV210SGXNAT-1 Le manuel du propriétaire

Marque: Empire Heating Systems

Modèle: DV210SGXNAT-1

Taper: Le manuel du propriétaire

Ce manuel convient également à

DIRECT VENT

WALL FURNACE MODELS:

DV210SGXLP-1

DV210SGXNAT-1

DV215SGXLP-1

DV215SGXNAT-1

This appliance may be installed in an after-

market, permanently located, manufactured

home (USA only), or mobile home, where not

prohibited by state or local codes.

This appliance is only for use with the type

of gas indicated on the rating plate. This

appliance is not convertible for use with other



WARNING

FIRE OR EXPLOSION HAZARD

If the information in these instructions is



result causing property damage, personal

injury or loss of life.

— Do not store or use gasoline or other



vicinity of this or any other appliance.

— WHAT TO DO IF YOU SMELL GAS

 

 

do not use any phone in your building.

 

 

from a neighbor’s phone. Follow

the gas supplier’s instructions.

 



— Installation and service must be



service agency or the gas supplier.

INSTALLER:

Leave this manual with the appliance.

CONSUMER:

Retain this manual for future reference.

WARNING

If not installed, operated and maintained in

accordance with the manufacturer's instruc-

tions, this product could expose you to sub-

stances in fuel or from fuel combustion which

can cause death or serious illness.

INSTALLATION INSTRUCTIONS

AND OWNER'S MANUAL

Page 1

37173-5-1019Page 2

TABLE OF CONTENTS

Important Safety Information ......................................................................................................... 3

Safety Information for Users of Propane Gas ............................................................................... 4

Requirements for Massachusetts ................................................................................................. 5

Introduction ................................................................................................................................... 6

 ................................................................................................................................ 6

Gas Supply ................................................................................................................................... 7

Clearances ................................................................................................................................... 8

Installation Instructions .............................................................................................................. 8-9

Lighting Instructions ................................................................................................................... 10

Maintenance ............................................................................................................................... 12

Pilot Flame Characteristics ........................................................................................................ 13

Main Burner Flame Characteristics ............................................................................................ 13

Troubleshooting .......................................................................................................................... 13

Parts List .................................................................................................................................... 14

Parts View ................................................................................................................................... 15

Optional Blower Installation Instructions ............................................................................... 16-17

Master Parts Distributor List ........................................................................................................ 18

How to Order Repair Parts .......................................................................................................... 18

Warranty ...................................................................................................................................... 19

SECTION PAGE

37173-5-1019 Page 3

 



draperies.

 

of high surface temperatures and should stay away

to avoid burns or clothing ignition.

 

they are in the same room as the appliance.

 

placed on or near the appliance.

 

an appliance must be replaced prior to operating the

appliance.

 

 

 Installation and repair should be done by a QUALI-

FIED SERVICE PERSON. The appliance should

be inspected before use and at least annually by a



 -

cessive lint from carpeting, bedding materials, etc.

It is imperative that control compartments, burners,

and circulating air passageways of the appliance be

kept clean.

 put anything around the furnace that will



  keep the appliance area clear and free from





  examine venting system periodically and replace

damaged parts.

 examine burners periodically. Clean and replace

damaged parts.

 

during operation.

 use this heater if any part has been under



to inspect the heater and to replace any part of the

control system and any gas control which has been

under water.

THIS IS A HEATING APPLIANCE

DO NOT OPERATE THIS APPLIANCE WITHOUT FRONT PANEL INSTALLED.

IMPORTANT SAFETY INFORMATION

37173-5-1019Page 4

SAFETY INFORMATION FOR USERS OF PROPANE GAS

         

explosions. In its natural state, propane is odorless and

colorless. You may not know all the following safety precautions

which can protect both you and your family from an accident.

Read them carefully now, then review them point by point with

the members of your household. Someday when there may not

be a minute to lose, everyone's safety will depend on knowing

exactly what to do. If, after reading the following information,

you feel you still need more information, please contact your

gas supplier.

PROPANE GAS WARNING ODOR

If a gas leak happens, you should be able to smell

the gas because of the odorant put in the Propane Gas.

That's your signal to go into immediate action!

 

Do not do anything that could ignite the gas.

 

that IMMEDIATELY.

 

 







 







 Finally, 



  



NO ODOR DETECTED - ODOR FADE

Some people cannot smell well. Some people cannot smell the









the gas odor. People may not smell the gas odor or their minds are



it easier to smell.







in Propane Gas also are subject to oxidation. This fading can occur



The odorant in escaped gas can adsorb or absorb onto or into













go into action as instructed earlier.

SOME POINTS TO REMEMBER

 







Propane Gas Dealer.

 









       





area where the conditions are such that you may not detect



 

















Propane Gas Dealer. A periodic sniff

test of the Propane Gas is a good safety measure under any

condition.

 







 









-





completely empty.

37173-5-1019 Page 5

REQUIREMENTS FOR MASSACHUSETTS





        









1. INSTALLATION OF CARBON MONOXIDE DETECTORS. At

-



that a hard wired carbon monoxide detector with an alarm and







carbon monoxide detector with an alarm is installed on each









wired carbon monoxide detectors.

  -



the hard wired carbon monoxide detector with alarm and





  









detector with an alarm shall be installed.

2. APPROVED CARBON MONOXIDE DETECTORS. Each carbon







 -

manently mounted to the exterior of the building at a minimum

    





“GAS VENT DI-



4. INSPECTION. The state or local gas inspector of the side wall



      

carbon monoxide detectors and signage installed in accordance



  



1. The equipment listed in Chapter 10 entitled “Equip-

ment Not Required To Be Vented” in the most current



   

fueled equipment installed in a room or structure



in whole or in part for residential purposes.

  

VENTING SYSTEM PROVIDED. When the manufacturer of

-





by the manufacturer for installation of the equipment and



   



   



  

       





appliance or equipment at the completion of the installation.

37173-5-1019Page 6

INTRODUCTION

Introduction





wall furnace.

Instructions to Installer

        

installation.

 

with furnace.

3. Installer should show owner how to start and operate furnace.

WARNING

Any change to this furnace or its control can be dangerous.

This is a heating appliance and any panel, door or guard

removed for servicing an appliance must be replaced prior

to operating the appliance.

To Conserve Gas: Turn off pilot when heater is not in use.

General Information



  



installed on an outside wall according to these instructions.



in these instructions or use with a type of gas not shown on the



the change.

Important



and type of gas.

Notice



the room in which the unit is installed.

Installation in Residential Garages















         















Commonwealth of Massachusetts  



of Massachusetts.



 National Fuel Gas Code ANSI Z223.1/NFPA

54* Natural Gas and Propane Installation Code, CSA B149.1.

*Available from the American National Standards Institute, Inc., 11

West 42nd St., New York, N.Y. 10036.

High Altitudes

        













Installation on Rugs and Tile





be installed on a metal or wood panel extending the full width and

depth of the appliance.







37173-5-1019 Page 7

SPECIFICATIONS

INTRODUCTION (CONT'D)

Model DV-210 DV-215

  

Height  

Width  

Depth  

Gas Inlet  

Options for Above Furnaces

Blower DVB-1 DVB-1



Description Model Number

 DV822 DV822

  



Part Number Description Used On

TH358





DV2155GXLP-1

TH357





DV2155GXNAT-1



Part Number Description Used On

17081 Propane to Natural DV210SGXLP-1

17080 Natural to Propane DV210SGXNAT-1

17083 Propane to Natural DV215SGXLP-1

17082 Natural to Propane DV215SGXNAT-1





attached appliances. Instructions shall also indicate effects of an





WARNING

CARBON MONOXIDE POISONING HAZARD

Failure to follow the steps outlined below for each

appliance connected to the venting system being placed

into operation could result in carbon monoxide poisoning

or death.

The following steps shall be followed for each appliance

connected to the venting system being placed into

operation, while all other appliances connected to the

venting system are not in operation:

1. Seal any unused openings in the venting system.

2.        

      

Code, ANSI Z223.1/NFPA 54 or the Natural Gas and

Propane Installation Code, CSA B149.1 and these

instructions. Determine that there is no blockage or

     

which could cause an unsafe condition.

3. As far as practical, close all building doors and

windows and all doors between the space in which

the appliance(s) connected to the venting system are

located and other spaces of the building.

4. 

5. Turn on clothes dryers and any appliance not connected

to the venting system. Turn on any exhaust fans, such

as range hoods and bathroom exhausts, so they are

operating at maximum speed. Do operate a summer

exhaust fan.

6. Follow the lighting instructions. Place the appliance

being inspected into operation. Adjust the thermostat

so appliance is operating continuously.

7. 

at the draft hood relief opening after 5 minutes of main



8. If improper venting is observed during any of the

above tests, the venting system must be corrected in

accordance with National Fuel Gas Code, ANSI Z223.1/

NFPA 54 and/or Natural Gas and Propane Installation

Code, CSA B149.1.

9. After is has been determined that each appliance

connected

to the venting system properly vents when

tested as outlined above, return doors, windows,



burning appliance to their previous conditions of use.

37173-5-1019Page 8

GAS SUPPLY

Locating Gas Supply



wall. The gas line opening should be made at this time. Location





Recommended Gas Pipe Diameter

Pipe

Length

Schedule 40 Pipe

Inside Diameter

Tubing, Type L

Outside Diameter

Natural Propane Natural Propane

0-10 feet

0-3 meters



12.7 mm



9.5mm



12.7 mm



9.5 mm

10-40 feet

4-12 meters



12.7 mm



12.7mm



15.9 mm



12.7 mm

40-100 feet

13-30 meters



12.7 mm



12.7mm



19 mm



12.7 mm

100-150 feet

31-46 meters



19 mm



12.7 mm



22.2 mm



19 mm

NOTE:



NOTE: 

is always best to consult your local authority and installation code.



 

and Fittings

 

Than All-Metal Construction







NPT NIPPLE

Figure 1





Installing a New Main Gas Shut-Off









Compounds used on threaded joints of gas piping shall be resistant





















the National Fuel Gas Code that a drip line be installed near the gas



into the gas line that is capped on the bottom in which condensation

and foreign particles may collect.

Figure 2

Method of Installing a Tee Fitting Sediment Trap

Pressure Testing of the Gas Supply System

 



placed immediately upstream of the gas supply connection to

the appliance.

        

disconnected from the gas supply piping system during any

pressure testing of that system at test pressures in excess of



3. The appliance must be isolated from the gas supply piping system



testing of the gas supply piping system at test pressures equal



Attention!





Checking Manifold Pressure

         









    

        







        



37173-5-1019 Page 9

CLEARANCES

The furnace is to be located on an outside wall. Locate wall studs so

that wall opening will be located between wall studs. One wall stud

can be used for attachment of inside wall plate. The wall opening

required as shown in Figure 3      







Figure 3 for positioning the furnace on wall

and for locating gas line connection.

Figure 3

Installing Inside Wall Plate



inside wall plate in wall opening. The collar on the inside wall plate







contact with the air inlet tube. The barrier must not penetrate into the











Attaching Furnace To Inside Wall Plate











(64mm)

(13mm)

Figure 4

INSTALLATION INSTRUCTIONS

 

      

installation.

 



      



 

 





 



         



supplied by the manufacturer result in unsatisfactory performance.















CAUTION

The nearest point of the vent cap should be a minimum

      

regulator. In case of regulator malfunction, the six feet (1.8m)

distance will reduce the chance of gas entering the vent cap.

-







37173-5-1019Page 10

INSTALLATION INSTRUCTIONS (CONT'D)

Cutting Vent Tubes

This is the most important part of the installation. With the furnace

           



the following procedure.

 









collar of air drop assembly.

 











 



Installing The Vent Assembly

 



such as clapboard.

 









the entry of rainwater. Attach outside wall plate to exterior wall



 











4. Installation is completed.

Reassembly And Resealing Vent-Air Intake System



the following steps will assure proper reassembly and resealing of



 





 





clapboard.

 









the entry of rainwater. Attach outside wall plate to exterior wall



 











 

Installing a Vent Near a Window Ledge, Other Type of Projection

or on Siding (vinyl, aluminum, etc.)

          





















    

    



or discoloration. All joints can then be sealed and painted. The wall





DV-215. See Figure 5.

(51mmx102mm)

Figure 5

Figure 5a









See Figure 5a.

WARNING

When vinyl siding vent kit, DV-822 or 2" x 4" (51mm x 102mm)

framing is added to an existing installation (furnace is





both tubes. Refer to Parts List, page 14 to order tubes.

37173-5-1019 Page 11

WARNING



personal injury or loss of life.

TO TURN OFF GAS TO APPLIANCE

FOR YOUR SAFETY READ BEFORE LIGHTING

A. This appliance has a pilot which must be lighted by

hand. When lighting the pilot, follow these instructions

exactly.

B. BEFORE LIGHTING smell all around the appliance area





WHAT TO DO IF YOU SMELL GAS

 Do not try to light any appliance.

 

do not use any phone in your building.

 Immediately call your gas supplier from a

neighbor's phone. Follow the gas supplier's

instructions.

 If you cannot reach your gas supplier, call the



C. Use only your hand to push in or turn the gas

control knob. Never use tools. If the knob will not







D. Do not use this appliance if any part has been



technician to inspect the appliance and to replace

any part of the control system and any gas control

which has been under water.

 



 

 -

wise 

 

LIGHTING INSTRUCTIONS

1. 

2. Turn off all electric power to the appliance

 

 

 

to OFF.

NOTE:



 

         





        

combustion chamber.

7. Find pilot - follow metal tube

from gas control. The pilot is

 

 

 

           











 

     

technician or gas supplier.

 







 





        



14. CAUTION:

closed during operation.

LIGHTING INSTRUCTIONS

PILOT

BURNER

THERMOPILE

37173-5-1019Page 12

These heaters are specially designed for use on self generating



circuits.

Installing the ON/OFF Device









following the installation instructions supplied with it. In the absence







System Check

          



 

heater OFF.

 

heater ON.

           

heater ON.



1. Disconnect the thermopile and pilot supply line at the pilot burner.

        

suggested.

 

 





 

      





Cleaning The Pilot Burner









part of the pilot.

Cleaning the Combustion Chamber and Main Burner





hose. The main burner may be cleaned by forcing water into the

ports and the throat of the burner. The burner should be blown dry

or heated to dry all water out before reinstalling.





occur at the pilot. This is a substitute for a match which requires









with the pilot on.





under this condition.

To Conserve Gas: Turn off pilot when heater is not in use.

TO ON/OFF DEVICE

Figure 6

MAINTENANCE

37173-5-1019 Page 13

1. Lit match goes out as it enters lighter port.

a. Certain wind conditions will blow out match. Ignite



b. Open nearby door or window and relight pilot.

 

a. See Lighting Instructions. Relight Pilot.

  





  



 

  

  

4. Pilot and main burner go out during normal operation.

  

  

  

  

  

  





 

  



  

Parts List on Page 14.

TROUBLESHOOTING











Figure 8









second row of main burner ports.

Figure 7

PILOT FLAME CHARACTERISTICS

MAIN BURNER FLAME CHARACTERISTICS

37173-5-1019Page 14



PARTS LIST

Index

No.

Part

No.

Description

1 TH100 WALL MOUNTING PLATE

2 TH104 

3 TH015 AIR DROP ASSEMBLY - DV210

3 TH018 AIR DROP ASSEMBLY - DV215

4 11757 OUTER CASING - DV210

4 11758 OUTER CASING - DV215

5 TH338 INNER CASING - DV210

5 TH337 INNER CASING - DV215

6 TH008 FRONT PANEL - DV210

6 TH009 FRONT PANEL - DV215

7 TH024 COMBUSTION CHAMBER - DV210

7 TH027 COMBUSTION CHAMBER - DV215

8 M155 

9 DV781 OBSERVATION HOLE COVER

10 DV064 COVER PLATE - OBSERVATION HOLE

11 R206 NUT FOR ORIFICE FITTING

12 P8654 BURNER ORIFICE - DV210 NATURAL

12 P8650 BURNER ORIFICE - DV215 NATURAL

12 P8665 BURNER ORIFICE - DV210 PROPANE

12 P8658 BURNER ORIFICE - DV215 PROPANE

13 P104 ORIFICE FITTING

14 R1055 ELECTRODE AND WIRE

15 P103 MANIFOLD

16 R12791 GAS VALVE 7000 MVRLC - NATURAL

16 R12792 GAS VALVE 7000 MVRLC - PROPANE

17 R12796 

17 R12795 PILOT BURNER WITH ORIFICE - NATURAL

18 TH335 PILOT SHIELD

19 M151 

20 TH133 

20 TH134 

21 TH365 

22 40994

-



23 R1054 THERMOPILE - GENERATOR

24 R2708 

25 TH289 

26 TH275 BURNER - DV210

26 24644 BURNER - DV215

27 TH109 

28 TH107 

29 TH331 OUTSIDE MOUNTING PLATE

30 TH334 VENT CAP

31 TH123 

 R1081 ORIFICE FOR PILOT - NATURAL

 R1089 ORIFICE FOR PILOT - PROPANE

 TH300 

 TH281 

 TH351 



Index

No.

Part

No.

Description

37173-5-1019 Page 15

PARTS VIEW

37173-5-1019Page 16

DVB-1 For Direct Vent Wall Furnaces DV210 and DV215

INSTALLING OPTIONAL BLOWER DVB-1. The blower must be



-



engages a tab on the bottom of the inner casing and is secured by

one screw in front.

BLOWER

MOUNTING

TAB

Figure 1

Attaching Switch Box

 

combustion chamber door.

 



 

and combustion chamber door.

 

OPTIONAL BLOWER INSTALLATION INSTRUCTIONS

Wiring

        

















        

wire connected to the receptacle mounting screw. With this wire

   





local codes require this type of protection.

CAUTION

Label all wires prior to disconnection when servicing controls.

Wiring errors can cause improper and dangerous operation.

Verify proper operation after servicing.

NOTICE: Unplugging of blower accessory will not stop the heater



depressing slightly. Do not force.

37173-5-1019 Page 17

Index No. Part No. Description

1 R-1268 Wire Assembly

2 R-896 

3 R-1156 Fan Control

4 DV-806 Switch Box

5 DV-807 

6 TH-111 

7 R-1410 

8 R-285 Motor

9 R-587 Motor Cushion

10 TH-341 Blower Cushion

11 TH-356 Motor Support Assembly

12 R-319 Blower Wheel

13 TH-135 Blower Housing Assembly

14 R-315 Cord Set

DVB-1 For Direct Vent Wall Furnaces DV210 and DV215

OPTIONAL BLOWER INSTALLATION INSTRUCTIONS

Oiling the Motor





Do not use machine oil.

Cleaning the Blower Wheel









the entire blower and clean each blade of the wheel with a tooth

brush as often as necessary.

37173-5-1019Page 18





nature of the problem with the unit.





-



MASTER PARTS DISTRIBUTOR LIST

Parts Not Under Warranty

-

service person or dealer should order parts through the distributor. Parts can be shipped directly to the

service person/dealer.

Warranty Parts

 for

warranty parts.



not-



Appliance Model Number Part Description

Appliance Serial Number Part Number







HOW TO ORDER REPAIR PARTS

Dey Distributing





Phone: 651-490-9191

Toll Free: 800-397-1339

Website: www.deydistributing.com

Parts: Heater, Hearth and Grills

F. W. Webb Company

200 Locust Street



Phone: 860-722-2433

Toll Free: 800-243-9360

Fax: 860-293-0479

Toll Free Fax: 800-274-2004

Websites: 

Parts: Heater, Hearth and Grills

East Coast Energy Products

10 East Route 36



Phone: 732-870-8809

Toll Free: 800-755-8809

Fax: 732-870-8811

Website: www.eastcoastenergy.com

Parts: Heater, Hearth and Grills

37173-5-1019 Page 19

WARRANTY

Empire Comfort Systems Inc. warranties this space heating product to be free from defects at the time of purchase and for the periods



accordance with the instructions in the owner’s manual. This warranty applies to the original purchaser only and is not transferable. All



Limited Ten-Year Parts Warranty – Combustion Chamber

 

 

Limited One-Year Parts Warranty – Remote Controls, Accessories, and Parts

 

 

Duties Of The Owner

 

 

 

What Is Not Covered

 

 

 

 

 

 

How To Get Service

 

 

 

 

 

 

“Consumer Relations” in the subject line.

Your Rights Under State Law

 

37173-5-1019Page 20

www.empirecomfort.com

Empire Comfort Systems Inc.

Belleville, IL











La page est en cours de chargement...

Empire Heating Systems DV210SGXNAT-1 Le manuel du propriétaire

Marque: Empire Heating Systems

Modèle: DV210SGXNAT-1

Taper: Le manuel du propriétaire

Ce manuel convient également à

Télécharger le PDF

rapport

dans d''autres langues

English: Empire Heating Systems DV210SGXNAT-1 Owner's manual
español: Empire Heating Systems DV210SGXNAT-1 El manual del propietario

Empire Heating Systems DV210SGXNAT-1 Le manuel du propriétaire

Ce manuel convient également à

Empire Heating Systems DV210SGXNAT-1 Le manuel du propriétaire

dans d''autres langues

Documents connexes

Autres documents