DCS Cooktop CS-364GD Manuel utilisateur

Marque: DCS

Modèle: Cooktop CS-364GD

Catégorie: Barbecues

Taper: Manuel utilisateur

The Professional RGS Range

And Gas Cooktop

Use and Care Guide

MODELS:

RGS-305

RGS-366

RGS-364GL

RGS-364GD

RGS-484GG

RGS-485GD

RGS-486GL

RGS-486GD

CS-366

CS-364GL

CS-364GD

CS-484GG

CS-485GD

CS-486GL

CS-486GD

Thank you for selecting this DCS Professional Gas Range or Professional Cooktop.Because of this appliance’s

unique features we have developed this Use and Care Guide. It contains valuable information on how to

properly operate and maintain your new appliance for years of safe and enjoyable cooking.

To help serve you better, please fill out and submit your Ownership Registration Card by visiting our website

at www.dcsappliances.com and selecting “Customer Service”on the home page and then select “Ownership

Registration” or submit the enclosed Ownership Registration Card to the address below. In addition, keep

this guide handy,as it will help answer questions that may arise as you use your new appliance.

For your convenience,product questions can be answered by a DCS Customer Care Representative by phone:

1-888-281-5698, email: [email protected], or by mail:

WARNING

If the information in this manual is not followed exactly,a fire or explosion may

result causing property damage,personal injury or death. To reduce the risk of

injury to persons in the event of a rangetop grease fire, observe the following:

Turn burner off first. Smother flames with a close-fitting lid, cookie sheet, or

metal tray. Be careful to prevent burns. If the flames do not go out immediately

evacuate and call the fire department. Never pick up a flaming pan - you may

be burned. DO NOT USE WATER, including wet dishcloths or towels - a violent

steam explosion will result. Use an extinguisher ONLY if:

 You know you have a Class ABC extinguisher, and you already know how to

operate it.

 The fire is small and contained in the area where it started.

 The fire department is being called.

 You can fight the fire with your back to an exit.

WARNING

Do not store or use gasoline or other flammable vapors and liquids in the

vicinity of this or any other appliance.

FOR YOUR SAFETY

IF YOU SMELL GAS:

 Do not try to light any appliance.

 Do not touch any electrical switch; do not use any phone in your building.

 Immediately call your gas supplier from a neighbor’s phone. Follow the gas

upplier’s instructions.

 If you cannot reach your gas supplier, call the fire department.

 Installation and service must be performed by a qualified installer, service

agency or the gas supplier.

PLEASE RETAIN THIS MANUAL FOR FUTURE REFERENCE.

Fisher & Paykel Appliances, Inc.

Attention: DCS Customer Care

5900 Skylab Road

Huntington Beach, CA 92647

A MESSAGE TO OUR CUSTOMERS

TABLE OF CONTENTS

SAFETY PRACTICES......................................................................................................................................................3-5

MODEL IDENTIFICATION.........................................................................................................................................6-7

BEFORE USING YOUR APPLIANCE...................................................................................................................8-9

COOKTOP USE ............................................................................................................................................................10-13

Burner Use . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .10

Burner Efficiency and Flame Characteristics . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .11

Wok Ring . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .12-13

GRILL USE.......................................................................................................................................................................13-14

GRIDDLE USE...............................................................................................................................................................15-16

OVEN USE.......................................................................................................................................................................16-22

Regular Baking . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .17-18

Convection Baking . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .18-19

Broiling . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .19-20

High Altitude Baking . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .20

Slow Cooking / Low Temperature Cooking . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .21

CARE AND MAINTENANCE...............................................................................................................................22-27

Cleaning Range, Cooktop and Burners . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .22-24

Oven and Door Interior . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .25

Oven Light Bulb Replacement . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .26

PARTS LIST............................................................................................................................................................................27

HOW TO OBTAIN SERVICE........................................................................................................................................28

WARRANTY..........................................................................................................................................................................29

SAFETY PRACTICES AND PRECAUTIONS

When properly cared for, your new DCS Appliance is designed to be a safe, reliable cooking appliance.

When using this restaurant caliber appliance, use it with extreme care, as this type of appliance

provides intense heat and can increase the accident potential. Basic safety precautions must be

followed when using kitchen appliances, including the following:

 Read this Use and Care Manual thoroughly before using your new appliance. This will help to

reduce the risk of fire, electric shock, or injury to persons.

 Begin by insuring proper installation and servicing.Follow the installation instructions which came

with this appliance. Be sure to have a qualified technician install and ground this appliance before

using.

 Have the installer show you where the gas supply shut off valve is located so you will know how

and where to turn off the gas to the appliance.

 If you smell gas, the installer may not have done a proper job of checking for leaks. You can have a

small leak and therefore a faint gas smell if the connections are not completely tight. Finding a gas

leak is not a “do-it-yourself” procedure. Some leaks can only be found with the burner control in

the ON position; for your protection it must be done by a qualified service technician.

 If by some chance a burner goes out and gas escapes, open a window or a door to let the room air

out.Do not attempt to use the appliance or turn any electrical switch on or off until the gas has had

time to dissipate. Follow the instructions on page 1,“For Your Safety– if You Smell Gas”.

 This appliance has been factory assembled for natural or LP gas. It should be correctly adjusted

from the factory for the type of gas that is used.

 Do not repair or replace any part of this appliance unless it is specifically recommended in this

manual. All other servicing should be referred to a qualified technician.

 Children should not be left alone or unattended in an area where appliances are in use. They

should never be allowed to turn knobs, push buttons, sit or stand on any part of an appliance.

 Children in walkers, or children crawling can be attracted to the round oven door handle and may

grab and open the oven door. This can result in injury from the door being pulled open on a child,

or severe burns if the oven is in use and hot.

WARNING:

Do not store items of interest to children above or at the back of any appliance.

Children could be seriously injured if they should climb onto the appliance to

reach these items.

 Never store anything in the oven or on the cooktop. Flammable materials can catch fire, plastic

items may melt or ignite and other types of items could be ruined.

 Do not hang articles from any part of the appliance or place anything against the oven. Some

fabrics are quite flammable and may catch on fire.

 If the appliance is near a window be certain the curtains do not blow over or near the cooktop

burners; they could catch on fire.

 Do not use water on grease fires. Turn all burners OFF, then smother fire with a metal lid, baking

soda or use a dry chemical or foam-type fire extinguisher.

 Never let clothing, pot holders,or other flammable materials come in contact with, or get too close

to,any burner or burner grate until it has cooled. Fabric may ignite and result in personal injury.

 Be certain to use only dry pot holders: moist or damp pot holders on hot surfaces may cause burns

from steam. Do not use a towel or other bulky or frayed cloth in place of pot holders. Do not let

pot holders touch hot burners, or burner grates.

SAFETY PRACTICE AND PRECAUTIONS

 For personal safety, wear proper apparel. Loose fitting garments or hanging sleeves should never

be worn while using this appliance. Some synthetic fabrics are highly flammable and should not

be worn while cooking.

 Do not use aluminum foil to line any part of the oven or cooktop. Using a foil liner could result in

a fire hazard, or the obstruction of the flow of combustion and ventilation air. Foil is an excellent

heat insulator and heat will be trapped underneath it. This trapped heat can upset the cooking

performance and can damage the finish of the oven or the cooktop parts.

WARNING:

This appliance is for cooking. Based on safety considerations, never use the

oven or cooktop to warm or heat a room. Also, such use can damage the

cooktop or oven parts.

 When using the cooktop: Do not touch the burner grates or the immediate surrounding area.

Areas adjacent to the burners may become hot enough to cause burns.

 When using the oven: Do not touch the interior surfaces of the oven,the exterior area immediately

surrounding the door or the back trim. The drip tray handles directly above the oven door may be

hot if the oven has been operated with the door open,or if something has prevented the door from

sealing. Always use caution when pulling out the drip trays (GD & GL models only) when the oven

has been on,or is currently on. The drip trays get hot when the oven is on. Do not remove drip trays

until they are cool.

 Never leave the cooktop unattended when using high flame settings. When cooking with high

flame settings, boil overs may cause smoking and greasy spill overs may ignite. More importantly,

if the burner flames are smothered by a severe boil over which effects the igniter,unburned gas will

escape into the room.

 Only certain types of glass,heat-proof glass-ceramic,ceramic,earthen ware,or other glazed utensils

are suitable for cooktop use. This type of utensil may break with sudden temperature changes. Use

only on low or medium flames settings according to the manufacturer’s directions.

 Do not heat sealed food containers; a build up of pressure may cause the container to burst.

 During cooking,set the burner control so that the flame heats only the bottom of the pan and does

not extend beyond the bottom of the pan. This could heat and/or melt the handles. Also make

longer cooking time.

 Always use utensils that have flat bottoms large enough to cover the burner.The use of undersized

utensils will expose a portion of the flame to direct contact and may result in ignition of clothing.

 To minimize burns, ignition of flammable materials and unintentional spill overs, position handles

of utensils inward so they do not extend over adjacent work areas,cooking areas,or the edge of the

cooktop.

 Hold the handle of the pan to prevent movement of the utensil when stirring or turning food.

 Grease is flammable. Let hot grease cool before attempting to handle it. Avoid letting grease

deposits collect around the cooktop burners. Clean after each use or boil over.

 For proper lighting and performance of the cooktop burners, keep the burner ports clean. It may

be necessary to clean these when there is a boil spill or when the burner does not light, even

though the electronic igniters click.

 Do not use the grill for cooking excessively fatty meats or products which promote flare-ups. Do

not use cooking utensils on the grill.

 Clean the cooktop with caution. Avoid steam burns; do not use a wet sponge or cloth to clean the

cooktop while it is hot. Some cleaners produce noxious fumes if applied to a hot surface. Follow

directions provided by the cleaner manufacturer.

SAFETY PRACTICES AND PRECAUTIONS

 Be sure all the range and/or cooktop controls are turned off and the appliance is cool before using

any type of aerosol cleaner on or around the appliance. The chemical that produces the spraying

action could, in the presence of heat, ignite or cause metal parts to corrode.

 Place oven racks in desired position while the oven is cool. If a rack must be moved while the oven

is hot, do not let the pot holders contact the hot interior of the oven.

 Use care when opening the oven door; let hot air or steam escape before removing or replacing

foods.

 Do not rub, damage, move or remove the door gasket. It is essential for a good seal during baking.

Wash gasket with hot water only.

 Clean the ventilator hood and filters above the range or cooktop frequently so grease from cooking

vapors does not accumulate on them.

 Turn the ventilator OFF in case of fire or when intentionally “flaming” liquor or other spirits on the

cooktop. The blower, if in operation, could unsafely spread the flames.

 DO NOT obstruct the flow of combustion or ventilation air to the appliance. Be sure a fresh air

supply is available.

 For safety reasons and to avoid damage to the appliance, never sit, stand, or lean on the oven door

or cooking surface.

 Service should only be done by authorized technicians. Technicians must disconnect the power

supply before servicing this appliance.

WARNING:

California Proposition 65-The burning of gas cooking fuel generates some by-

products which are known by the State of California to cause cancer or

reproductive harm. California law requires businesses to warn customers of

potential exposure to such substances. To minimize exposure to these

substances,always operate this unit according to the instructions contained in

this booklet and provide good ventilation to the room when cooking with gas.

RECOMMENDATIONS ON HOOK-UP TO GAS SUPPLY:

A manual valve must be installed external to the appliance, in an accessible location from the front

for the purpose of shutting off the gas supply. The supply line must not protrude beyond the back of

the unit. Make sure the gas supply is turned off at the wall valve before connecting the appliance.

The gas supply connections should be made by a qualified technician and in accordance with local

codes or ordinances. In the absence of a local code,the installation must conform to the National Fuel

Gas Code ANSI 223.1-1988, latest edition.

NOTE: This product must be installed by a licensed plumber or gas fitter when

installed within the Commonwealth of Massachusetts.

NOTE: Alternate method of supplying

gas (mandatory for the State

of Massachusetts) installation

into the unit.

Installer supplied

shut-off valve

must be easily

accessible inside

cabinetry.

Gas Supply

MODEL IDENTIFICATION

48” RGS RANGE MODELS

RGS-484GG

36” RGS RANGE MODELS

30” RGS RANGE MODELS

RGS-366

RGS-486GL RGS-486GD

RGS-485GD

OVEN ON

HEATING

DOOR LOCKED

HEATING

RGS-305

RGS-364GL RGS-364GD

MODEL IDENTIFICATION

48” CS COOKTOP MODELS

CS-484GG

36” CS COOKTOP MODELS

CS-366

CS-486GL CS-486GD

CS-485GD

CS-364GL CS-364GD

BEFORE USING YOUR APPLIANCE

1) Remove all packaging material instructions (for insulation) from your appliance. If the installer has

not set up your appliance, do it now. Check that you have the following items:

COOKTOP:

 Griddle - (RGS-364GD, RGS-486GD, RGS-485GD, and RGS-484GG Models Only)

(CS-364GD, CS-486GD, CS-485GD, and CS-484GG Models Only)

 Grill racks, 2 pieces - (RGS-364GL, RGS-486GL & RGS-484GG Models Only)

(CS-364GL, CS-486GL & CS-484GG Models Only)

 5 burner head assemblies, burner caps and grates (RGS-305, RGS-485GD, and

CS-485GD Models Only)

 Radiant tray - to hold ceramic rods for grill - (RGS-364GL, RGS-486GL & RGS-484GG

Models Only) (CS-364GL, CS-486GL & CS-484GG Models Only)

 One removable drip tray (griddle and grill models have drip tray liners, for catching grease)

27” & 24” OVEN:

 Two removable side rails

 One two-piece broil pan

 Three oven racks

12” OVEN:

 Two oven racks

 Two removable side rails

 Do not use aluminum foil to cover the oven racks or to line the oven. Heat can be trapped beneath

the foil; this can cause damage to the oven and the food may not cook correctly.

2) Before baking or broiling:

One at a time, turn the oven and broiler burners on for 20 to 30 minutes each. This burns off the

manufacturing oils used by the factory. Turn the oven burner on to 450

F and the broiler burner on

to “BROIL”.Turn on the ventilator above your range while these burners are on, as there will be an

odor.

3) Place the oven racks in the proper position before turning on the oven. For correct rack position

check your recipe. The most frequently used position is number 2 (the food product must be in the

center of the oven for airflow). The rack positions are numbered from the bottom as in the floors of

a building.

BEFORE USING YOUR APPLIANCE

TO INSERT THE OVEN RACKS:

1) Hold the rack with the back safety rail in the up

position and towards the rear of the oven. Slip it

into the oven so the rack slides are between the

rack and the rack guides.

2) As you slide the rack into the oven,tip the front of

the rack up slightly, so that the safety stops on the

back of the rack clear the rack slides. The safety

stops keep the rack from sliding out of the oven

when pulled forward. See Fig. 01

TO REMOVE OR REPOSITION THE RACKS:

1) Pull the rack forward.

2) Lift the front of the rack up so the safety stops

clear the rack slides.

3) Pull the rack forward.

Rack Positions

Rack

slide

Fig. 01

Rack

guide

Safety stop

COOKTOP USE

BURNERS

Your new professional gas range is equipped with

burners typical of those used in restaurants. These

burners are designed for maximum cleanability and

controllability. The large cap spreads the simmer heat out

to avoid too much heat being concentrated on the center

of the pan. The simmer flame is always on when the

burner is in use. The burner should never be operated if

the cap is not in place. All the cooktop burners have

electronic spark ignition to eliminate continuously

burning pilots; when the burner is on and the flame is

blown out, it will relight.

SIMMERING

Your new professional cooktop has exceptionally low

simmering capabilities. The large cap serves as a heat

diffuser to spread out the heat to avoid having a center

hotspot. Keep in mind that because of the high heat

capacity of the burner, and the mass of the cast iron

burner grates (they retain heat longer than lighter,

conventional grates) some foods may continue to cook

by retained heat after the burner has been turned off.

Should a strong draft or boil over extinguish the simmer

flame it will relight automatically as the main burner

would.

ELECTRONIC IGNITERS

If a burner does not ignite,

listen for the clicking sound.

If the igniter is not clicking,

TURN OFF THE BURNER.First,

clean the electrode. Next,

check the circuit breaker for

a blown fuse or a tripped

circuit breaker. If the igniter

still fails to operate, see

page 28,“Before Calling For

Service”.To light the burner

manually, see page 26

“Power Failure”.

NOTE: If you are using propane gas, a slight pop or flash

may occur at the burner ports a few seconds after

the burner has been turned “off”. This “extinction

pop” is normal for propane gas.

Simmer

Flame

Cap

Brass

Port

Ring

RGS-305 COOKTOP SECTION SHOWN

Fig. 02

Fig. 03

Burner Max. Simmer/Low

Location Btu/hr Btu/hr

305 Nat 36”/48” Nat* LP Nat LP

1 16,000 17,500 14,000 500-1,200 500-1,200

2 16,000 17,500 14,000 500-1,200 500-1,200

3 17,500 17,500** 14,000 500-1,200 500-1,200

4 16,000 17,500 14,000 500-1,200 500-1,200

5 16,000 17,500 14,000 500-1,200 500-1,200

*Note - All burners on 36 & 48 models (except 485 models) rated at

17,500 Btu/hr for Nat. &14,000 Btu/hr for LP.

**485 model only. No location #3 on 36 & other 48 models.

Igniter (Keep Clean)

BURNER EFFICIENCY AND FLAME

CHARACTERISTICS

It is necessary to keep the burner ports and the

igniters clean for proper lighting and efficient

performance of the cooktop burners. The

burner flame should burn completely around

the burner with no excessive noise or lifting.The

flame should be blue in color and stable with no

yellow tips. An improper air-gas mixture may

cause either a burner flutter or a yellow tipped

flame. A technician should adjust the flame.

During initial use, foreign particles in the gas

line,or dust in the air around the appliance may

cause an orange flame.This will disappear with

use.

FLAME HEIGHT

The correct height of the flame mainly depends on the size of the bottom of the cooking utensil, the

material of the cooking utensil, the amount and type of food and the amount of liquid in the utensil.

Following are some basic rules for selecting flame height.

 For safety reasons the flame must never extend beyond the bottom of the cooking utensil. Never

allow flames to curl up the side of the pan (see fig. 04).This will discolor or damage the utensil.

 Utensils which conduct heat slowly (such as glass-ceramic) should be used with medium to low

flame. If you are cooking with a large amount of liquid, a slightly larger flame can be used.

SEALED TOP BURNERS

The sealed top burners must be kept clean. Cleaning of the sealed top burners should include the

igniter. The cooktop burners have an infinite number of heat settings and there are no fixed positions

on the control knobs between HI and LO. To turn the cooktop burner on, push in on the control knob

and turn it counterclockwise to the “LITE”position. An audible clicking sound will be heard. When the

gas has been ignited by the electronic spark igniter, turn the knob to the desired setting. (The clicking

sound will stop as soon as the burner is lit).

WARNING:

When turning on any cooktop burner, be sure to stop at the “LITE” position

before turning the burner to a flame setting for cooking. If the burner is not lit

and it is turned beyond the “LITE”position,to HI,MEDIUM, or LO,there could be

a burst of flame when the burner does light. This could cause burns or damage

to the surrounding countertop.

COOKTOP USE

Proper Flame Height

Fig. 04

BURNER GRATES

The burner grates are heavy cast iron. They were

designed in sections to make them easier to remove

and clean. (See fig. 05 & 06)

COOKWARE

For best results we recommend using professional

cookware.This type of utensil can be found at your finer

department stores, specialty cooking shops, or

restaurant supply stores. If using regular cookware, be

very careful if the pans have plastic handles, as these

large professional size burners can flame up on the

outside of the pan and melt or bubble the handles.

CONTROL KNOBS

The control knobs are readily associated with the

burners they control. The cooktop control knobs are

labeled and in front of the burners. The oven control is

placed slightly lower than the other control knobs. This

is due to the physical size of the commercial type

thermostats used on the product (see fig. 07).

WOK RING

A Wok ring is provided with your new DCS appliance.

The ring is cast iron, and has a porcelain enamel finish.

It can be used with the DCS model CW wok and most

commercially available woks. To use the ring,place it on

the grate over the desired burner. The vertical tabs on

the ring should be aligned with the main fingers of the

grate. The small protrusions on the bottom surface of

the ring should straddle the grate fingers to prevent the

ring from rotating during cooking. See fig. 08 page 13.

The bottom of the wok should be supported and

retained by the vertical tabs of the ring.

For best performance on 305 & 485 model ranges, the

ring and wok should be used on the center burner, as it

has the highest output on the top section. On 36” and

48”ranges and cooktops,the ring and wok may be used

on any surface burner. To clean the wok ring, place it in

the dishwasher after use. Stubborn food deposits may

be removed by soaking to loosen the soil,then washing

as usual.

COOKTOP USE

Fig. 05 (36” & 48” models)

Fig. 06 (305 & 485 models)

Fig. 07

GRILL

The grill grates are reversible (see fig.09). Place the side

with the two grooved tabs towards the rear of the

cooktop. The grill grates are made of durable porcelain

enameled cast iron. One side of the grate is ridged (side

A) and should be used for foods where you want the fat

to run off, such as steak or hamburger patties. The

ridges are slopped so the fat runs toward the front of

the grill and can easily run down to the cooler area of

the drip tray and away from the intense heat of the

burner. The other side of the grate (side B) is designed

for foods that need more support while cooking, such

as fish. Food cooked on the grill section achieves the

same flavor as food cooked on an outdoor grill. The

intense radiant heat from the ceramic rods caramelizes

the fats and juices that are brought to the surface of the

food, giving it the barbecued flavor.

NOTE: This gas grill may cook slightly faster than you are used to, thus preheat and grilling

times should be adjusted accordingly.

COOKTOP USE

GRILL USE

Fig. 09

Fig. 08

Top View of

Wok Ring

Side A

Rear

Front

Side B

GRILL USE

CERAMIC RODS

The layer of ceramic rods, under the grill racks, will last for many years with proper care. They are

shipped from the factory pre-assembled on the radiant tray, ready to be set in place into the fire box,

under the grill racks. Be sure to remove any packaging material from the radiant tray and rods before

using the grill. Burned food particles and ash can be emptied off the radiant tray when cool by gently

shaking over a waste receptacle. Chipping or cracking of the ceramic rods may occur as they may get

brittle with age, depending on frequency of use. This is normal and does not affect the cooking. Do

not replace the radiant tray/ceramic rods with alternates. Contact DCS for genuine factory-direct

replacement parts.

USE OF THE GRILL

Before starting to cook on the grill, be sure the drip tray and liners are in place and that you have the

grill racks turned to the side you want for cooking. Preheat the grill for 10 minutes with the control

knob set on HI. When the grill is preheated, turn the knob down to medium to low, place the food on

the grill. Cook it to the doneness desired. During cooking, it may be necessary to adjust the heat

setting. The control knob may be set to any position between HI and LO. For proper searing and

browning,the grill requires high to medium heat. When cooking,you will use medium to low heat the

entire cooking time. With large pieces of meat or poultry,you may need to turn the heat to low setting

after the food has been seared. This lower heat setting will allow the food to cook through without

burning the outside. When using a sugary marinade or barbecue sauce, it may be necessary to turn

the heat setting down near the end of the cooking time. Do not leave the grill unattended while it is

turned on. When you are finished cooking, allow the grill and the drip trays to cool before cleaning

them. They should be cleaned each time they are used.

NOTE: The longer you preheat the grill, the darker the grill marks.

EXCESSIVE FLARE UPS AND FLAMING

Occasionally grease drippings ignite. These drippings will create minor puffs of flame for a second or

two. This is normal when cooking on a grill. You may find it handy to have a spray bottle filled with

water to lightly spray the flare-up. If the flame becomes excessive, remove the food from the grill.

Lower the heat setting. Replace the food when the flare-up subsides. To prevent flare-ups from

happening, trim the fat from around the edges of steaks and chops, use hamburger that is lean,

remove the fat that is on poultry, etc. When turning any kind of meat or poultry, the melted fat will

drop onto the ceramic rods and it may create a flare-up. If this happens, use a long handled spatula to

move the food to another area.

GRILLING HINTS

When grilling, the ventilation fan must be set on “HI” to remove smoke and odors. The fan can be

turned to “LO” after cooking is complete to remove any leftover smoke. The doneness of meat is

affected by the thickness of the cut. It is impossible to cook a thin piece of meat to a rare doneness. A

steak should be at least 1-inch thick to have it turn out rare and juicy. The cooking time is affected by

the temperature of the meat when you start to cook it, the size and shape of the cut and the kind of

meat you are cooking. The degree of doneness desired also affects the time.

When turning the meat over, always use a spatula or tongs as it will not puncture the meat allowing

the juices to run out. This will help to keep the meat juicy. Turn the meat only once, as juices are lost

when the meat is repeatedly turned. Be sure to trim any excess fat from meat or poultry. To prevent

steaks or chops from curling while they are being cooked,slit the fat around the edges at about 2-inch

intervals. To test for doneness, make a small cut in the center of the meat.

GRIDDLE USE

The built-in griddle on your cooktop is made

from Type 304 stainless steel, highly polished to

provide a smooth cooking surface.It is normal for

it to darken with use as oils cook onto the surface

to provide a stick resistant base or “seasoning”.

Since the griddle is made from stainless steel,the

surface will not rust. The griddle burner is

thermostatically controlled and cycles on and off

to maintain the set temperature. The “Heating”

light indicates that the burner is “on”.The griddle

assembly is not to be removed for cleaning and is

held in place by two front screws and one rear

screw. These are mainly there to keep the griddle

from shifting in transit and positioning, thus

avoiding breakage of any ignition components.

Once the unit is in position, the rear shipping

screw can be removed. It is located beneath the

griddle flue cover which is removed by lifting off

(be careful not to scratch your backguard during

removal of the cover). Remove the center

shipping screw. The two outer screws are

leveling screws. They can be turned to level the

griddle or to provide a forward slope to help

grease and oils to drain away from the food

being cooked. After using the griddle a few

times, you will be able to judge the slope best for

the foods you are cooking and your personal

preference.

BEFORE USING THE GRIDDLE FOR THE FIRST TIME OR TO RE-SEASON

1) Clean the griddle thoroughly with hot, soapy water to remove any protective coating.

2) Rinse with a mixture of 1 quart water and 1 cup white vinegar. Dry thoroughly.

3) Pour 1 teaspoon vegetable oil into the center of the griddle (do not use corn oil as it gets sticky).

Rub the oil over the entire surface of the griddle using a heavy cloth.

4) Turn the control knob to a Medium setting (350ºF).Turn the heat Off when the oil begins to smoke.

Allow the griddle to cool.

5) Repeat Step 3. Be sure to cover the entire surface with the oil.

6) Repeat Step 4. Allow the griddle to cool.Wipe the entire surface of the griddle using a heavy cloth.

Apply a very thin layer of vegetable oil.The griddle is now ready to use. If the griddle is not used for

a period of time, re-season it occasionally.

NOTE: It is normal for the griddle to darken with use.

Shipping Screw

(remove)

Outer Leveling

Screws (2)

Griddle Flue

Cover

Fig. 10

USE OF THE GRIDDLE

Before starting to cook on the griddle, be sure the drip tray and liners are in place. Preheat griddle for

15 minutes with the control knob set to the temperature suggested on the cooking chart. When the

griddle is preheated, the HEATING light will turn off. Place the food on the griddle and cook to desired

doneness.

NOTE: When the griddle is properly seasoned it can be used without any additional

shortening. However, it can be used for flavor. A light mist of non-stick vegetable

spray, applied before cooking to a cool griddle, makes delicate foods easier to turn.

GRIDDLE COOKING CHART

OVEN BURNERS

Your new professional RGS range is equipped with bake and broil oven burners. The oven broiler

burner is 19,000 Btu/hr on RGS models.

The oven baking burner is 30,000 Btu/hr., 12” oven is 18,000 Btu/hr.

ELECTRIC GLOW IGNITER

The oven bake and broil burners are equipped with an electric glow igniter and safety system which

lights the gas. There will be a delay of 30 to 90 seconds after the control knob has been turned on to

when you actually hear the burner come on. The burner will ignite within 4 seconds after the gas

reaches the burner.

OVEN

Your large new oven can be used in three cooking modes: convection bake, regular bake or broil. To

help you decide which way to cook your food,read this information first.Remember, this is a new oven

and the thermostat has been checked for accuracy.Your old oven may have had a thermostat that over

the years got a little hot or a little cold. Check your recipes for the correct time and temperature and

don’t use the old time or temperature you were using to compensate for your old oven being off tem-

perature. Models RGS-484GG, RGS-486GL, RGS-485GD, and RGS-486GD have two ovens. The oven on

the right side is the convection oven. The smaller oven, on the left side, can be used in standard bake

only. This oven is ideal for baking small amounts of food, when you don’t want to heat the large oven.

GRIDDLE USE

Eggs

Bacon, Ham, Pork Chops

Pancakes, French Toast

Sausage, Grilled Cheese Sandwiches

FOOD TEMPERATURE

225ºF to 250ºF

300ºF to 325ºF

325ºF to 350ºF

350ºF to 375ºF

400ºF to 425ºF

Hash Brown Potatoes

OVEN USE

SETTING THE OVEN

Decide if you are going to use BAKE or CONVECTION BAKE. These cooking modes are for baking,

roasting or warming using one,two or three racks.If you are going to use regular Bake,simply turn the

control knob to the temperature used in the recipe. To use Convection Bake, push the Convection

Switch (located on the control panel) and turn the control knob to the temperature desired. Models

RGS-484GG,RGS-485GD,RGS-486GL and RGS-486GD have two ovens. The oven on the left side can be

used for regular bake only; simply turn the control knob to the temperature desired.

PREHEATING

Preheating takes about 10 to 15 minutes depending on the temperature set. Preheating is usually

necessary for foods baked at high temperature for a short period of time, i.e. drop cookies. The oven

heating light will turn off when the oven has reached temperature.

CONDENSATION

During any cooking process there is a certain amount of moisture that evaporates from the food. The

amount of moisture that condenses on the oven depends on the moisture content of the food. The

moisture will condense on any surface that is cooler than the inside of the oven, such as the control

panel or the top of the door.

OVEN RACKS

Models RGS-484GG, RGS-485GD, RGS-486GL and RGS-486GD have two ovens. The oven on the right

side has (2) standard and (1) broil locator rack and 4 rack positions. The left side oven has 2 oven racks

and 4 rack positions.

CAUTION:

Aluminum foil should never be used to cover the oven racks or to line the oven

bottom. The trapped heat can damage the porcelain and the heated air can-

not adequately reach the food being baked.

REGULAR BAKING

Bake is baking with hot air; there is no fan. The air movement comes from natural convection. As the

air heats, it moves to the top of the oven. This oven mode is the same as you have been using for

baking on one or two racks.

Foods Suitable for Bake

 Appetizers  Pies, Cakes  Breads  Poultry  Roasts

 Desserts Main Dishes  Oven Meals (1 to 2 racks)

To get the best results

 Follow the recipe amounts and ingredients, including the size and shape of the baking utensil

recommended in the recipe.

 Do not open the open door “just to peek”, use the interior oven light and look through the window.

 Do not use the oven for storage,especially when baking in the oven. Extra utensils,not being used

for baking, can affect the food product, the baking time, the browning and end result.

 If you are using glass utensils, lower the temperature 25ºF.

 Use a minute timer, set for the minimum time suggested in the recipe.

OVEN USE

Baking rack position

One or two racks can be used simultaneously during bake. Place the rack(s) in the desired position

before turning the oven on.Store any unused racks out of the oven. Rack position 2 (second from bot-

tom) will probably be used the most for single rack baking. If you are using two racks simultaneously,

be sure to check the food on the bottom rack sooner than the minimum time.The food on the lower

rack position may cook slightly faster than the food on the upper rack, particularly if you are using

large baking utensils. If you are using two racks simultaneously, be sure to stagger the baking utensils

so that one is not directly above the other and the heated air can circulate freely around each pan.

Allow at least 1”of space between the oven walls and the pans. If using large or commercial size bak-

ing utensils, the food may take a few extra minutes as the air cannot circulate as freely as it does with

a smaller pan.When using commercial size baking utensils,use only one rack as the heat does not have

the room to circulate.

CONVECTION BAKING

Convection Baking is baking with the fan at the back of the oven circulating the hot air in a continuous

pattern around the food. This circulating hot air heats and browns the surface of the food more

effectively than in a standard oven. This allows most foods to be cooked at lower oven temperatures

or in less time, if baked at the regular temperature. The air is recirculated and reheated. Uncovered,

longer cooking foods such as large pieces of meat or other foods that can be cooked in low sided

baking utensils or air leavened foods, are where you will see the most savings in cooking time. Using

multiple racks (3) at the same time will achieve a good time saving, as you can cook more food at the

same time.The number of recipes requiring preheating of the oven is reduced considerably because

the heat reaches the food faster as the hot air circulates around the food.

Foods Suitable for Convection

 Appetizers  Breads  Oven Meals (1 to 3 racks)

 Cookies  Main Dishes  Roasts

 Pies  Poultry

 Air Leavened Foods (Angel Food Cake, soufflés, cream puffs, meringue shells)

Converting Recipes to Convection Baking

Low sided baking utensils will give the best results as the hot air can reach all sides of the food easier.

The oven temperature can be left the same as the recipe and the food cooked a shorter period of time.

The temperature can be lowered 25ºF and the food will probably take the same length of time to cook

as the recipe states. If you find that food is adequately browned on the outside, but not done in the

center, lower the temperature another 25ºF and add to the baking time. When reducing the

temperature always check the food for doneness, a minute to two before the minimum time stated in

the recipe,as time can always be added. Some recipes will cook faster than others. There is no way to

predict exactly how long each recipe will take when you convert it to convection. Convection will be

easier to use after you have used it a few times as you will begin to understand the way it bakes.

Selecting Utensils for Convection Baking

Cooking by convection does not require any specially designed baking utensils. You probably have

many utensils in your kitchen that are suitable to use. When choosing a baking utensil, consider the

material, the size and the shape, as they all affect the baking time, the palatability and the appearance

of the finished product. Metal bakeware (aluminum,steel and cast iron) all result in the fastest cooking

time and the best end product. Aluminum pans work best for all types of baked goods. For the best

browning,use a pan with a dark or dull finish that absorbs heat, when baking pies and breads. A shiny

finish works best for cakes and cookies, since it reflects some of the heat and provides a more tender

surface. Cookie sheets with only one lip will give the best results, as the heated air can circulate all

around the sides of the food. For roasting, use the bottom of the broil pan and elevate the meat on a

OVEN USE

metal roasting rack. Glass-ceramic or glass utensils do not conduct heat as well as metal, but they can

be used. Use them for foods that do not require a dark brown crust or crisping, such as soufflés.

Baked items cook more quickly and evenly if they are individually smaller in size, i.e. two or three small

foods do better than one large piece. When single food items are baked,always center the food on the

rack. If several foods are being baked, space them evenly on the rack or racks.

To get the best results:

 Follow the first three recommendations above.

 Metal utensils give better results, in convection, than do glass baking utensils. If you use glass, it

usually is not necessary to lower the temperature an additional 25ºF.

 Use a minute timer, set for less than the minimum time suggested in the recipe, the first time you

use a recipe in the convection mode.Be sure to note the new baking time on your recipe,for future

reference.

 Be sure to read the basic information on convection before using the oven for the first time.

See page 17.

 Keep in mind that convection baking results vary, depending on type of product. In many cases,

standard bake yields superior results over convection.

Convection baking rack position

One to three racks can be used simultaneously during

convection baking. Place the rack/s in the desired

position before turning the oven on. Store the unused

racks out of the oven. Rack position 2 (second from

bottom) will probably be used the most for single rack

baking. When baking on more than one rack, you do

not need to stagger the pans. However, allow at least

1-inch of space between the oven walls and the pans so

the heated air can circulate.

BROIL

Broiling is cooking by intense infrared radiation sup-

plied by the broil burner located at the top of the oven.

Since broiling is cooking by radiant heat, it is not neces-

sary to use the convection fan in the broil mode.Your new oven is equipped with an oven rack fitted

especially with a broil pan locator formed into the center grid support. To use this locator, place the

oven rack in the desired position with the locator rod to the top.

Foods Suitable for Broil

 Top Browning: Casseroles, Breads

 Appetizers  Meats  Poultry  Fish

Setting the Oven for Broiling

Turn the control knob clockwise to the broil setting

(see fig. 10 &11).

Preheating

The broiler does not need to be preheated for most broiling. To increase browning or for very thin

food, preheat the broiler 5 to 8 minutes.

OFF

150˚

300˚

450˚

BROIL

Fig. 11

BROIL

OFF

450

300

150

La page charge ...

DCS Cooktop CS-364GD Manuel utilisateur

Marque: DCS

Modèle: Cooktop CS-364GD

Catégorie: Barbecues

Taper: Manuel utilisateur

Télécharger le PDF

rapport

dans d''autres langues

English: DCS Cooktop CS-364GD User manual

DCS Cooktop CS-364GD Manuel utilisateur

DCS Cooktop CS-364GD Manuel utilisateur

dans d''autres langues

Documents connexes

Autres documents