Need help? 1.888.398.8643
Do not return to place of purchase.
Replacement Parts
1.888.398.8643
1
OWNER’S MANUAL
Table of Contents
Important Safeguards ...........................................................Page 2
Expanded View and Hardware......................................................... 5
Assembly Instructions............................................................... 6
Installing LP Gas Tank............................................................... 9
Operating Instructions.............................................................. 10
Cleaning and Care ................................................................ 10
Product Registration ............................................................... 11
Replacement Parts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
Limited Warranty ................................................................. 11
Specifications.................................................................... 12
Troubleshooting .................................................................. 13
The use and installation of this product must conform to local codes. In absence of local codes, use the
latest edition of the National Fuel Gas Code, ANSI Z223.1/NFPA 54, or International Fuel Gas Code. This
appliance, when installed, must be electrically grounded in accordance with local codes, or in the absence
of local codes with the National Electrical Code, ANSI/NFPA 70, if applicable.
For installation in Canada - these instructions, while generally acceptable, do not necessarily comply with
the Canadian installation codes, particularly with piping above and below ground. In Canada the installation
of this appliance must comply with local codes and/or standard CAN/CGA B149.1 (installation code for
propane burning appliances and equipment).
THIS INSTRUCTION BOOKLET CONTAINS IMPORTANT SAFETY INFORMATION. PLEASE READ AND KEEP
FOR FUTURE REFERENCE.
If you are assembling this unit for someone else, give this manual to them to read and save for future reference.
WARNING: This product can expose you to chemicals, including carbon monoxide, soot, Diisononyl
Phthalate (DINP), lead and lead components which are known to the State of California to cause cancer,
birth defects, and other reproductive harm. Wash your hands after handling this product. For more
information go to www.P65Warnings.ca.gov.
Made from 75% Bagasse
(environmentally friendly sugar
cane pulp by-product)
CARBON MONOXIDE HAZARD
• This appliance can produce carbon monoxide which has
no odor.
• Using it in an enclosed space can kill you.
• Never use this appliance in an enclosed space such as a
camper, tent, car or home.
· DANGER
Patents Pending
Manufactured in China for: Mr. Bar-B-Q Products LLC
10 Hub Dr., Ste 101, Melville, NY 11747 • 1.888.398.8643 • MrBarBQProducts.com
© Mr. Bar-B-Q Products LLC
Endless Summer
®
is a Registered Trademark of Mr. Bar-B-Q Products LLC GAD19102ES-EF-OM-F101
WARNING
FOR OUTDOOR USE ONLY.
W Installation and service must be performed
by a qualified installer, service agency or
gas supplier.
WARNING
FOR YOUR SAFETY:
W If the information in this manual is not
followed exactly, a fire or explosion may
result causing property damage, personal
injury or loss of life.
W WHAT TO DO IF YOU SMELL GAS:
• Do NOT try lighting any appliance.
• Do NOT touch any electrical switch; do
NOT use any phone in your building.
• Immediately call your gas supplier from a
neighbor’s phone.
• Follow the gas supplier’s instructions.
• If you cannot reach your gas supplier, call
the fire department.
W Do Not Use For Cooking.
WARNING
FOR YOUR SAFETY:
W INSTALLER: Leave this manual with the
appliance.
W CONSUMER: Retain this manual for future
reference.
WARNING
FOR YOUR SAFETY:
Improper installation, adjustment,
alteration, service or maintenance can
cause injury or property damage.
Read the installation, operation and
maintenance instructions thoroughly before
installing or servicing this equipment.
DANGER
FIRE OR EXPLOSION HAZARD
If you smell gas:
• Shut off gas to appliance.
• Extinguish any open flame.
• If odor continues, leave the area
immediately.
• After leaving the area, call your gas
supplier or fire department.
Failure to follow these instructions could
result in fire or explosion, which could cause
property damage, personal injury, or death.
WARNING
FOR YOUR SAFETY:
1. Do not store or use gasoline, or other
flammable vapors and liquids, in the vicinity
of this or any other appliance.
2. An LP-cylinder not connected for use shall
not be stored in the vicinity of this or any
other appliance.
DANGER
Do NOT leave this appliance unattended while
it is in operation.
“Donovan”
Outdoor LP GAS FIRE PIT
with
Model No.: GAD19102ES
2
Need help? 1.888.398.8643
Do not return to place of purchase.
Replacement Parts
1.888.398.8643
Important Safeguards
DANGER • FLAMMABLE GAS UNDER PRESSURE.
LEAKING LP-GAS MAY CAUSE A FIRE OR EXPLOSION IF IGNITED CAUSING
SERIOUS BODILY INJURY OR DEATH.
CONTACT LP GAS SUPPLIER FOR REPAIRS, OR DISPOSAL OF THIS
CYLINDER OR UNUSED LP-GAS.
WARNING • FOR OUTDOOR USE ONLY.*
DO NOT USE OR STORE CYLINDER IN A BUILDING,
GARAGE OR ENCLOSED AREA.
• Know the odor of LP-gas. If you hear, see or smell
leaking LP-gas, immediately get everyone away from
the cylinder and call the Fire Department. Do not attempt
repairs.
• Caution your LP-gas supplier to:
Be certain cylinder is purged of trapped air prior to
first filling.
Be certain not to over fill the cylinder.
Be certain cylinder requalification date is checked.
• LP-gas is heavier than air and may settle in low places
while dissipating.
• Contact with the liquid contents of cylinder will cause
freeze burns to the skin.
• Do not allow children to tamper or play with cylinder.
• When not connected for use, keep cylinder valve turned
off. Self contained appliances shall be limited to a
cylinder of 30 lb capacity or less.
• Do not use, store or transport cylinder where it would
be exposed to high temperatures. Relief valve may open
allowing a large amount of flammable gas to escape.
• When transporting, keep cylinder secured in
an upright position with cylinder valve turned off.
WHEN CONNECTING FOR USE:
• Use only in compliance with applicable codes.
• Read and follow manufacturer’s instructions.
• Consult manufacturer’s instructions concerning the
cylinder connection provided with your appliance.
• Be sure regulator vent is not pointing up.
• Turn off all valves on the appliance.
• Do not check for gas leaks with a match or open flame.
Apply soapy water at areas marked “X”. Open cylinder
valve. If bubble appears, close valve and have LP-gas
service person make needed repairs. Also, check
appliance valves and connections to make sure they do
not leak before lighting appliance.
• Light appliance(s) following manufacturer’s instructions.
• When appliance is not in use, keep the cylinder valve
closed.
WARNING:
DO NOT REMOVE, DEFACE, OR OBLITERATE THIS LABEL
*EXCEPT AS AUTHORIZED BY ANSI/NFPA 58.
DANGER. Do not store a spare LP cylinder under or near a barbecue grill, or other heat sources.
NEVER fill an LP cylinder beyond 80% full: a fire causing death or serious injury may occur.
2
3
LP Gas Outdoor Fire Pit
Model No.: GAD19102ES
W Do NOT use this outdoor fire pit without reading the entire owner’s
manual.
W This appliance is for outdoor use only, and should NOT be used in a
building, garage or any other enclosed area.
W Do NOT operate, light or use this appliance within ten feet (3.05 m) of
walls, structures or buildings.
W For residential use only. This outdoor fire pit is NOT for commercial use.
W Do NOT use this outdoor fire pit for indoor heating. TOXIC carbon
monoxide fumes can accumulate and cause asphyxiation.
W This outdoor fire pit is safety certified for use in the United States
and/or Canada only. Do NOT modify for use in any other location.
Modification will result in a safety hazard and will void your warranty.
W Apartment dwellers: Check with management to learn the requirements
and fire codes for using a liquid propane (LP) gas outdoor fire pit in your
apartment complex. If allowed, use outside on the ground floor with a
ten foot (3.05 m) clearance from any structure. Do NOT use on or under
balconies.
W This outdoor fire pit, from the factory, is for use with LP gas only. The
conversion to or attempted use of natural gas in this outdoor fire pit is
dangerous, may cause bodily harm and will void your warranty.
W LP gas characteristics:
a. LP gas is flammable and hazardous if handled improperly. Become
aware of the characteristics before using any LP gas product.
b. LP gas is explosive under pressure, heavier than air, and settles/
pools in low areas.
c. LP gas in its natural state has no odor. For your safety, an odorant is
added that smells like rotten cabbage.
d. Contact with LP gas can cause freeze burns to skin.
W LP gas tank needed to operate. Only tanks marked “propane” may be
used.
a. The LP gas cylinder must be constructed and marked in accordance
with the U.S. Department of Transportation (D.O.T.) Specifications for
LP-Gas Cylinders, or the Standard for Cylinders, Spheres and Tubes
for the Transportation of Dangerous Goods and Commission, CAN/
CSA-B339 as applicable.
b. LP gas tank must be arranged for vapor withdrawal.
c. The LP gas tank must have a listed overfilling prevention device
(OPD) and a QCCI or Type I (CGA810) LP gas tank connection.
d. The LP gas tank must have a tank collar to protect the tank valve.
e. Never use an LP gas tank with a damaged body, valve, collar or
footing.
f. Dented or rusted LP gas tanks may be hazardous and should be
checked by your LP gas supplier prior to use.
g. The LP gas tank should not be dropped or handled roughly.
h. Tanks must be stored outdoors, out of the reach of children and
must not be stored in a building, garage or any other enclosed area.
Your LP gas tank must never be stored where temperatures can
reach over 125°F.
i. Do NOT insert any tool or foreign object into the valve outlet or
safety relief valve. You may damage the valve and cause a leak.
Leaking propane may result in explosion, fire, severe personal injury
or death.
j. Never keep an LP gas tank in a hot car or trunk. Heat will cause the
gas pressure to increase, which may open the relief valve and allow
gas to escape.
k. Place dust cap on cylinder valve outlet whenever the cylinder is not
in use. Only install the type of dust cap on the cylinder valve outlet
that is provided with the cylinder valve. Other types of caps or plugs
may result in leakage of propane.
l. Do NOT store a spare LP gas tank under or near this appliance.
m. Never fill the cylinder beyond 80 percent full.
n. A fire causing serious injury or damage to property may occur if the
above is not followed exactly.
W Your outdoor fire pit has been checked at all factory connections
for leaks. Recheck all connections as described in the “Operating
Instructions” section, as shipping can loosen connections.
W Check for leaks even if your unit was assembled for you by someone
else.
W Do NOT operate if a gas leak is present. Gas leaks may cause a fire or
explosion.
W You must follow all instructions in the “Checking for Leaks” section
before operating. To prevent a fire or explosion when testing for a leak:
a. Always perform a leak test before lighting this outdoor fire pit and
each time the tank is connected for use.
b. No smoking. Do NOT use or permit sources of ignition in the area
while conducting a leak test.
c. Conduct the leak test outdoors in a well-ventilated area.
d. Do NOT use matches, lighters or a flame to check for leaks.
e. The use of alcohol, prescription or non-prescription drugs may
impair the consumer’s ability to properly assemble or safely operate
the appliance.
f. Strong odors, colds, sinus congestion, etc. may prevent the
detection of propane. Use caution and common sense when testing
for leaks.
g. Do NOT use this outdoor fire pit until any and all leaks are corrected.
If you are unable to stop a leak, disconnect the LP gas supply. Call a
gas appliance serviceman or your local LP gas supplier.
W Do NOT store or use gasoline or other flammable liquids or vapors
within 25 feet (7.62 m) of this appliance.
W Do NOT use in an explosive atmosphere. Keep outdoor fire pit area clear
and free from combustible materials, gasoline and other flammable
vapors and liquids.
W This outdoor fire pit is NOT to be operated by children.
W This outdoor fire pit is NOT to be used in or on boats or recreational
vehicles.
W Do NOT connect to a remote gas supply.
W Never attempt to attach this outdoor fire pit to the self-contained LP gas
system of a camper trailer, motor home or house.
W Always use in accordance with all applicable local, state and national
codes. Contact your local fire department for details on outdoor burning.
W When using this outdoor fire pit, exercise the same precautions you
would with any open fire.
W Do NOT burn solid fuels such as: wood, charcoal briquettes, lump
charcoal, manufactured logs, driftwood, trash, leaves, paper, cardboard,
plywood, painted/stained/pressure treated wood in this outdoor fire pit.
W It is essential to keep the outdoor fire pit’s valve compartment, burners,
and circulating air passages clean. Inspect outdoor fire pit before each
use.
W Do NOT use this outdoor fire pit until it is COMPLETELY assembled and
all parts are securely fastened and tightened.
W Do NOT use this outdoor fire pit near automobiles, trucks, vans or
recreational vehicles.
W Do NOT use this outdoor fire pit under any overhang or near any
unprotected combustible constructions. Avoid using near or under
overhanging trees and shrubs.
W Always use this outdoor fire pit on a hard, level, non-combustible
surface such as concrete, rock or stone. An asphalt or blacktop surface
may not be acceppit for this purpose.
W Do NOT use this outdoor fire pit for cooking.
W DANGER: Failure to follow the dangers, warnings and cautions in this manual may result in serious bodily injury or death, or in a fire or an explosion
causing damage to property.
W WARNINGS:
Important Safeguards
Need help? 1.888.398.8643
Do not return to place of purchase.
Replacement Parts
1.888.398.8643
4
W Do NOT use this appliance if any part has been under water.
Immediately call a qualified service technician to inspect the appliance
and to replace any part or control system and any gas control which
has been under water.
W Do NOT wear flammable or loose clothing when operating this outdoor
fire pit.
W Do NOT use in windy conditions.
W Never lean over this outdoor fire pit when lighting or when in use.
W Do NOT use this outdoor fire pit unless burner is securely in place.
W Keep all electrical cords away from this outdoor fire pit during use.
W Certain areas of this outdoor fire pit when in use will become too
hot to touch. To avoid burns, do NOT touch hot surfaces until the unit
has completely cooled (about 45 minutes), unless you are wearing
protective gear (such as insulated pot holders or heat-resistant gloves/
mittens).
W Do NOT leave a lit outdoor fire pit unattended, especially around children
and pets.
W Children and adults should be alerted to the hazards of high surface
temperatures and should stay away to avoid burns or clothing ignition.
W Young children should be carefully supervised when they are in the area
of the appliance.
W Do NOT hang or place clothing or other flammable material on or near
this appliance.
W Any guard or other protective device removed for servicing the
appliance must be replaced prior to operating the appliance.
W If applicable, protective cover must be removed when burner is in
operation.
W Do NOT attempt to move outdoor fire pit when in use. Allow the outdoor
fire pit to cool before moving or storing.
W This outdoor fire pit should be thoroughly cleaned and inspected on
a regular basis. Clean and inspect the hose before each use of the
appliance. If there is evidence of abrasion, wear, cuts, or leaks, the hose
must be replaced prior to the appliance being operated.
W This outdoor fire pit should be inspected at least annually by a qualified
service person. Depending on amount of use, more frequent cleaning
may be required. Do NOT operate until all parts have been repaired or
replaced.
W Use only the regulator and hose assembly provided. Use only the
replacement regulator and hose assembly specified by Mr. Bar-B-Q
Products LLC.
W Use only Mr. Bar-B-Q Products LLC factory-authorized parts. The use of
any part that is not factory-authorized can be dangerous and will void
your warranty.
W Use only Mr. Bar-B-Q Products LLC factory-authorized fire glass /lava
rock. The use of any fire glass/lava rock that is not factory-authorized
can be dangerous and will void your warranty.
W Do NOT operate this appliance without reading “Operating Instructions”
in this manual.
W Storage of this outdoor fire pit indoors is permissible only if the tank
is disconnected, removed from the outdoor fire pit and properly stored
outdoors.
W Do NOT attempt to disconnect the gas regulator from the tank or any
gas fitting while the outdoor fire pit is in use.
W If the outdoor fire pit is not in use, the gas must be turned off at the
supply tank.
W CAUTION: The gas pressure regulator provided with this appliance must
be used. This regulator is set for an outlet pressure of 11 inches water
column.
W The minimum inlet gas pressure for this outdoor fire pit is 11 inches of
water column, for the purpose of input adjustment.
W The maximum inlet gas pressure for this outdoor fire pit is 11 inches of
water column.
W Before pressure testing, close LP gas tank valve and disconnect gas
regulator. The gas supply piping system must test at pressures equal to
or less than ½ psi (3.5 kPa).
W Do NOT sit or stand on the mantle or any part of this appliance.
W Do NOT throw anything onto the fire when the unit is in operation.
W Fire glass/lava rock are very hot. Keep children or pets at a safe
distance from this appliance.
W The opening of the tank collar should face toward the door side for easy
access.
W Do NOT store any combustible materials in the base enclosure.
W Use protective gloves when assembling this product.
W Do NOT force parts together as this can result in personal injury or
damage to the product.
W Death, serious injury or damage to property may occur if the above is
not followed exactly.
Important Safeguards
5
LP Gas Outdoor Fire Pit
Model No.: GAD19102ES
Tools Required for Assembly (Not Included)
#2 Phillips Head Screwdriver 1 pc
Hardware
A
Screw
M5x12 Black Nickel Plated Truss Head
22 pcs
B
Screw
M6X12 Black Nickel Plated Step Head
1 pc
C
Screw
M5x25 Black Nickel Plated Truss Head
4 pcs
D
Screw
M4x8 Black Nickel Plated Truss Head
1 pc
E
AA Battery 1 pc
Parts List
1
Bronze Fire Glass
GLS-BRN
2
Table Insert
58-23-817
3
Firebowl Assembly*
58-24-161
4
Igniter Cover*
58-23-896
5
Burner*
58-24-162
6
Mantel*
58-24-163
7
Heat Shield A*
58-24-164
8
Support Brackets*
58-24-165
9
Heat Shield B*
58-24-166
10
Dome*
58-24-167
11
Side Heat Shield (4)*
58-24-168
12
Upper Panel (4)
58-24-169
13
Lower Panel (3)
58-24-170
14
Lower Burner Assembly*
58-24-171
15
Heat Shield C*
58-24-172
16
Side Heat Shield Bracket
(4)*
58-24-173
17
Upper Post (3)*
58-24-174
18
Upper Post B*
58-24-175
19
Lower Heat Shield*
58-24-178
20
LP Gas Tank Heat Shield*
58-24-179
21
Battery Cap*
58-23-897
22
Control Knob (2)*
58-23-139
23
Control Panel Assembly*
58-24-180
24
Regulator Hose
Assembly*
58-24-181
25
Lighting Hook
58-23-956
26
LP Gas Tank Prevent Bar
58-24-182
27
Base*
58-24-183
28
LP Gas Tank Retainer
Bolt*
58-24-062
29
Door*
58-24-184
30
Door Knob*
58-24-185
31
Leg A (2)
58-24-186
32
Leg B
58-24-187
33
Leg C
58-24-188
34
Magnet*
58-23-804
35
Foot (4)*
58-24-147
36
Cover
58-24-189
37
Lava Rock (not required
and sold separately)**
58-24-190
* Pre-assembled
W **CAUTION: Use only Mr. Bar-B-Q
Products LLC factory-authorized
fire glass/lava rock. The use of
any fire glass/lava rock that is
not factory-authorized can be
dangerous and will void your
warranty.
Expanded View
Sold Separately
37
1
15
2
9
16
20
4
7
6
10
14
8
11
12
5
13
31
17
30
36
19
3
21
8
11
11
12
12
13
13
16
17
17
18
16
16
22
24
23
25
26
27
28
29
31
32
33
34
35
35
11
12
Need help? 1.888.398.8643
Do not return to place of purchase.
Replacement Parts
1.888.398.8643
6
1
DO NOT RETURN TO PLACE OF PURCHASE.
For assistance, call 1.888.398.8643 toll-free. Please have your owner’s
manual and model number available for reference.
Note: The model number is printed on a label which can be found on the inside door,
back or side of the base assembly.
Assembly Tips:
1. Select an area where you will assemble this product. To protect components,
choose a smooth surface that’s free of cracks or openings.
2. Spread out all parts.
3. Tighten all hardware connections by hand first. Then, before completing each
step, go back and fully tighten all hardware. Be careful not to over-tighten.
That could damage surfaces or strip threads.
4. For best results, complete each step in the order presented.
To complete assembly you will need:
• (1) Leak detection solution (instructions on how to make the solution are
included in the “Operating Instructions” section of this manual).
• (1) Precision-filled LP gas grill tank with Acme Type 1 external threaded valve
connection (standard grill size) (not included).
Typical assembly is approximately one hour.
W CAUTION: Two (2) people will be required for assembly.
W WARNING: Failure to position the parts in accordance with
these diagrams or failure to use only parts specifically
approved with this appliance may result in property damage
or personal injury.
Assembly Instructions
4
Attach Side and Rear Panels
Note: Attach bottom screws before attaching top screws. Do not fully tighten screws
until step 5.
A
x 12
3
Attach Legs
Note: Do not fully tighten screws until step 5.
A
x 8
2
Turn Outdoor Fire Pit Over
W CAUTION: Two (2) people will be required to turn the outdoor
fire pit over.
W CAUTION: To avoid scratches choose a smooth surface that’s
free of cracks or openings.
31
31
32
33
A
7
LP Gas Outdoor Fire Pit
Model No.: GAD19102ES
Assembly Instructions (continued)
6
Attach Door Knob and Door and Turn Outdoor Fire Pit
Over
W CAUTION: Two (2) people will be required to turn the outdoor
fire pit upright on feet.
B
x 1
D
x 1
7
Place Fire Glass
W CAUTION: Do NOT dump fire glass out of package. Carefully
place fire glass by hand so dust does not clog burner.
W CAUTION: Use only Mr. Bar-B-Q Products LLC factory-
authorized fire glass. The use of any fire glass that is not
factory-authorized can be dangerous and will void your
warranty.
W CAUTION: Do NOT cover igniter cover.
Note: Fire glass should be 0.8-1.6 in (2-4 cm) diameter. Approx. 11 lbs (5 kg) of fire
glass is needed.
8
Place Table Insert
W WARNING: NEVER place table insert on outdoor fire pit while
in use.
W WARNING: NEVER place table insert on outdoor fire pit while
the outdoor fire pit is still hot.
5
Attach LP Gas Tank Prevent Bar to Base, then Attach
Base
Note: Tighten all screws from steps 2-5.
A
x 2
C
x 4
A
C
D
B
Need help? 1.888.398.8643
Do not return to place of purchase.
Replacement Parts
1.888.398.8643
8
9
Insert Battery
Note: Remove plastic wrapper before installing battery.
E
x 1
OPTIONAL ITEM SOLD SEPARATELY
10
Place Lighting Hook
E
+
-
12
Place Lava Rocks
W CAUTION: When switching from fire glass, remove all fire
glass before placing lava rock.
W CAUTION: Do NOT dump lava rocks out of package. Carefully
place lava rocks by hand so dust does not clog burner.
W CAUTION: Use only Mr. Bar-B-Q Products LLC factory-
authorized lava rock. The use of any lava rock that is not
factory-authorized can be dangerous and will void your
warranty.
W CAUTION: Do NOT cover igniter cover.
Note: Lava rocks should be 0.8-2.0 in. (2-5 cm) diameter. Approx. 5.07 lbs. (2.3 kg)
of lava rocks are needed.
11
Store Table Insert
Hang the table insert on the inner side of door.
W WARNING: NEVER place table insert onto outdoor fire pit while
in use.
W WARNING: NEVER take out and place table insert onto outdoor
fire pit while the outdoor fire pit is still hot.
Assembly Instructions (continued)
9
LP Gas Outdoor Fire Pit
Model No.: GAD19102ES
Checking for Leaks
W WARNING: Before using this outdoor
fire pit, make sure you have read,
understand and are following
all information provided in the
“Important Safeguards” section
on page 2. Failure to follow those
instructions can cause death, serious
injury or property damage.
W WARNING: The burner must be
replaced prior to the appliance being
put into operation if it is evident
that the burner is damaged. The
replacement burner shall be that
specified by the manufacturer.
Burner Connections
1. Make sure the regulator hose and valve
connections are securely fastened to the burner
and the tank.
2. Visually check the connection between the
burner/venturi tube and orifice.
3. Make sure the burner/venturi tube fits over the
orifice.
W WARNING: Failure to inspect
this connection or follow these
instructions could cause a fire or an
explosion which can cause death,
serious bodily injury or damage to
property.
4. Please refer to diagram for proper installation
(Figures 1 and 2).
5. If the burner/venturi tube does not rest flush
to the orifice, as shown, please contact
1.888.398.8643 for assistance.
Tank/Gas Line Connection
1. Make 2-3 oz. of leak detection solution by
mixing one part liquid dishwashing soap with
three parts water.
2. Make sure control knobs are in the “ OFF”
position (Figure 3).
3. Connect LP gas tank per “Installing LP Gas
Tank” section.
4. Turn LP gas tank valve to “OPEN.”
5. Spoon several drops of solution, or use a squirt
bottle, at all “X” locations (Figures 1 and 2).
a. If any bubbles appear, turn LP gas tank valve
to “CLOSED,” reconnect and re-test.
b. If you continue to see bubbles after
several attempts, turn LP gas tank valve to
“CLOSED” and disconnect LP gas tank, per
“Disconnecting LP Gas Tank” section. Contact
1.888.398.8643 for assistance.
c. If no bubbles appear after one minute, turn
LP gas tank valve to “CLOSED,” wipe away
solution and proceed.
Upper Burner Lighting
W DANGER: Failure to follow these
lighting instructions may result in
serious bodily injury or death, or in a
fire or an explosion causing damage
to property.
W WARNING: NEVER light the burner with the cover on the outdoor fire
pit.
W CAUTION: Keep outdoor gas appliance area clear and free from
combustible materials, gasoline and other flammable vapors and
liquids.
W CAUTION: Do NOT obstruct the flow of combustion and ventilation air.
W CAUTION: Check and clean burner/venturi tubes for insects and insect
nests. A clogged tube can lead to a fire.
Note: The upper and lower burners are independent.
Note: This outdoor fire pit is equipped with a pilot light that allows for safer startups and
shutdowns. Pilot must be lit before main burner can be started.
Lighting
1. Make sure all labels, packaging and protective films have been removed from the outdoor
fire pit.
2. Check for obstructions of airflow to the burner. Spiders, insects and webs can clog the
burner/venturi tube. A clogged burner tube can lead to a fire.
Installing LP Gas Tank
To operate, you will need one precision-filled standard grill LP gas
tank with external valve threads.
W CAUTION: LP gas tank must be properly
disconnected and removed prior to moving this
outdoor fire pit.
Inserting LP Gas Tank
W WARNING: Make sure LP gas tank valve is closed.
1. Open door.
2. Loosen LP gas tank retainer bolt by turning counter-clockwise.
3. Place precision-filled LP gas tank upright into hole in outdoor fire pit base so the tank valve
is facing the gas line connection.
4. Secure tank by turning LP gas tank retainer bolt clockwise until tight.
5. Close door.
6.
Connecting LP Gas Tank
1. Make sure the control knob is in the “ OFF” position
(Figure 3).
2. Before connecting, be sure there is no debris caught in the
head of the LP gas tank, head of the regulator valve or in the
head of the burner or burner ports.
3. Connect regulator/hose assembly to tank by turning knob
clockwise until it stops.
4. Perform leak check per “Checking for Leaks” section.
Disconnecting LP Gas Tank
1. Make sure the control knob is in the “ OFF” position
(Figure 3).
2. Before disconnecting, make sure the LP gas tank valve is
“CLOSED.”
3. Disconnect regulator/hose assembly from LP gas tank by
turning knob counterclockwise until it is loose.
W CAUTION: LP gas tank must be properly
disconnected and removed prior to moving
this outdoor fire pit.
4. Place the protective cap cover on the LP tank and store the tank outdoors in a well
ventilated area out of direct sunlight.
20 lb
9 Kg
17.9 in. / 45.5 cm
12.2 in. / 31 cm
Figure 1
LP Gas
Connection
LP Gas Valve
with Orifice
Figure 2
X
X
X
X
X
Figure 3
OFF / ARRÊT
Figure 4
K
F
AA
Figure 5
11.8 in. – 19.7 in.
30 – 50 cm
Need help? 1.888.398.8643
Do not return to place of purchase.
Replacement Parts
1.888.398.8643
10
Operating Instructions
3. Make sure the control knobs are in the “ OFF” position (Figure 3).
4. Clear small area of glass rocks away from the igniter cover (Figure 4).
5. Connect LP gas tank per “Installing LP Gas Tank” section.
6. Slowly turn LP gas tank valve 1 revolution to “OPEN.”
7. Push and turn control knob to (HIGH). Continue to hold the control knob in to light.
8. After the fire pit lights, continue to hold the control knob in for 20 seconds to heat the
thermocouple, a safety device that stops the gas flow when a fire pit is not lit. Holding the
knob in for 20 seconds warms it up so the gas flow will continue.
9. After 20 seconds, release and turn control knob counterclockwise to adjust flame to
desired height.
10. After three attempts, if ignition does not occur, turn the burner control knob to “ OFF.”
11. Wait 5 minutes, fan with a newspaper or magazine, and repeat lighting procedure.
12. If igniter does not light burner:
a. Wearing heat-resistant gloves, position a lit long match or lit long butane lighter near
the pilot housing (Figure 4).
b. Push and turn control knob to (HIGH).
c. Remove match/lighter once burner is lit.
W CAUTION: After lighting - using a fire pit tool and heat-resistant
gloves, carefully move the fire glass/lava rock back to their proper
position, being careful to avoid the flame.
13. After lighting, observe the burner flame. Make sure all burner ports are lit and flame height
matches illustration (Figure 5).
W CAUTION: If ignition does not occur in 5 seconds, turn control knob
to “ OFF,” wait 5 minutes, fan with a newspaper or magazine, and
repeat lighting procedure.
Turning Off
1. Turn LP gas tank valve to “CLOSED.”
2. Turn control knob to the “ OFF” position.
Note: A “poof” sound is normal as the last of the LP gas is burned.
3. Disconnect LP gas tank per “Disconnecting LP Gas Tank” section.
Lower Burner Lighting
W DANGER: Failure to follow these lighting instructions may result in
serious bodily injury or death, or in a fire or an explosion causing
damage to property.
W WARNING: NEVER light the burner with the cover on the outdoor fire
pit.
W WARNING: Always use this outdoor fire pit on a hard, level, non-
combustible surface such as concrete, rock or stone. An asphalt or
blacktop surface may not be acceptable for this purpose.
W CAUTION: Keep outdoor gas appliance area clear and free from
combustible materials, gasoline and other flammable vapors and
liquids.
W CAUTION: Do NOT obstruct the flow of combustion and ventilation air.
W CAUTION: Check and clean burner/venturi tubes for insects and insect
nests. A clogged tube can lead to a
fire.
W CAUTION: If relighting a hot heater,
always wait at least 5 minutes before
relighting.
Note: The upper and lower burners are independent.
Note: This outdoor fire pit is equipped with a pilot
light that allows for safer startups and shutdowns.
Pilot must be lit before main burner can be started.
Lighting
1. Make sure all labels, packaging and protective
films have been removed from the outdoor fire
pit.
2. Check for obstructions of airflow to the burner.
Spiders, insects and webs can clog the burner/
venturi tube. A clogged burner tube can lead to
a fire.
3. Make sure the control knobs are in the “ OFF”
position (Figure 3).
4. Connect LP gas tank per “Installing LP Gas
Tank” section.
5. Turn LP gas tank valve to “OPEN.”
6. Push and turn control knob to (HIGH). Continue
to hold the control knob in to light.
7. After the fire pit lights, continue to hold the
control knob in for 20 seconds to heat the
thermocouple, a safety device that stops the gas
flow when a fire pit is not lit. Holding the knob in
for 20 seconds warms it up so the gas flow will
continue.
8. After 20 seconds, release and turn control knob counterclockwise to adjust heat to desired
temperature.
9. After three attempts, if ignition does not occur, turn the burner control knob to “ OFF.”
10. Wait 5 minutes, fan with a newspaper or magazine, and repeat lighting procedure.
11. If igniter does not light burner:
a. Use a lit matchbook match secured with the lighting hook (included with the outdoor
fire pit) to light the lower burner.
b. Access the burner through the side Panel (Figure 6).
c. Position lit match near side of burner (Figure 7).
Important: Always use the lighting hook (included) when lighting burners with a
match.
d. Push and turn control knob to (HIGH).
e. Remove match/lighter once burner is lit.
W CAUTION: After lighting - using a fire pit tool and heat-resistant
gloves, carefully move the fire glass/lava rock back to their proper
position, being careful to avoid the flame.
12. After lighting, observe the burner flame. Make sure all burner ports are lit and flame height
matches illustration (Figure 8).
W CAUTION: If ignition does not occur in 5 seconds, turn control knob
to “ OFF,” wait 5 minutes, fan with a newspaper or magazine, and
repeat lighting procedure.
TIP: The burner may be noisy when initially lit. To eliminate excessive noise from the burner
turn the control knob to the (pilot) position, then turn the knob to the level of heat desired.
TIP: Remove manufacturing oils on this heater for the first time by operating the heater for at
least 15 minutes on (HIGH). This will “heat clean” the internal parts and dissipate odors.
When Heater is On
W WARNING: Dome and burner are extremely hot to the touch during
operation. Never touch the dome or burner while the heater is
operating. The surface of heater’s emitter can reach temperatures
approaching 1600ºF.
W WARNING: Do NOT touch metal parts of heater until they have
completely cooled to avoid burns, unless you are wearing protective
gear (pot holders, gloves, BBQ mittens, etc.).
• Emitter screen will become bright red due to intense heat. The color is more visible at
night.
• Burner will display tongues of blue and yellow flame. These flames should not be yellow or
produce thick black smoke, indicating an obstruction of airflow through the burners. The
flame should be blue with straight yellow tops (Figure 8).
• If excessive yellow flame is detected, turn off heater and visit BlueRhino.com for cleaning
instructions or call 1.888.398.8643.
W CAUTION: If burner flame goes out during operation, immediately turn
the control knob to the “ OFF” position, LP gas tank valve “CLOSED”
and let the gas clear for 5 minutes before lighting per “Lighting”
section.
Re-lighting
Note: For your safety, the control knob cannot be turned the the “ OFF” position without first
depressing control knob in (LOW/PILOT) position and then rotating it to “ OFF.”
1. Turn control knob to “ OFF.”
2. Wait at least 5 minutes to let gas dissipate, fan with a newspaper or magazine.
3. Light per “Lighting” section.
Turning Off
1. Turn control knob clockwise to the (LOW/PILOT) position. Burner will extinguish but pilot
will remain “ON.”
2. Turn LP gas tank valve to “CLOSED.”
Note: A “poof” sound is normal as the last of the LP gas is burned.
3. Disconnect LP gas tank per “Disconnecting LP Gas Tank” section.
Note: After use, some discoloration of the emitter screen is normal.
Cleaning and Care
W CAUTION:
1. All cleaning and maintenance should be done when outdoor fire pit
is cool and with the fuel supply disconnected.
2. Do NOT clean any outdoor fire pit part in a self-cleaning oven. The
extreme heat will damage the finish.
3. Do NOT enlarge valve orifices or burner ports when cleaning the
valves or burners.
Notices
1. This outdoor fire pit should be thoroughly cleaned and inspected on a regular basis.
2. Abrasive cleaners will damage this product.
Figure 6
K
F
AA
Figure 7
K
F
AA
Figure 8
Burner
Flame
Slight
Yellow
Slight
Blue
Dark
Blue
11
LP Gas Outdoor Fire Pit
Model No.: GAD19102ES
Cleaning and Care (continued)
3. NEVER use oven cleaner to clean any part of this outdoor fire pit.
4. More frequent cleaning may be required as necessary. It is imperative that control
compartment, burners and circulating air passageways of the heater be kept clean.
5. Have the outdoor fire pit inspected annually. Any repairs should be made by a
qualified service person.
6. Inspect heater before each use.
7. Spiders and insects can create a dangerous condition that may damage the heater
or make it unsafe. Keep burner area clean of all spiders, webs and insects. Clean
burner holes by using a heavy-duty pipe cleaner. Compressed air may help clear
away smaller particles.
8. Check heater immediately if any of the following conditions exist:
a. You smell gas in conjunction with extreme yellow tipping of burner flames.
b. Heater does not reach proper temperature.
Note: At temperatures less than 40ºF, heat output will be reduced.
c. Heater’s glow is excessively uneven.
d. Burner makes popping noises during use.
Note: A “poof” sound is normal as the last of the LP gas is burned.
9. Carbon deposits may create a fire hazard. Keep dome and emitter clean at all times.
10. Do NOT clean heater with combustible or corrosive cleaners. Use warm, soapy water.
11. Do NOT paint engine, engine access panel or dome.
12. After a period of storage and/or non use, check for leaks, burner obstructions and
inspect for any abrasion, wear or cuts to the hose.
13. Check under the dome and engine area periodically for any obstructions such as
spiderwebs, bird nests, etc.
Before Each Use:
1. Keep the outdoor fire pit area clear and free from any combustible materials, gasoline, and
other flammable vapors and liquids.
2. Do NOT obstruct the flow of the combustion of LP gas and the ventilation of air.
3. Keep the ventilation opening(s) of the LP gas tank area free and clear from debris.
4. Visually check the burner flames to make sure your outdoor fire pit is working properly
(Figure 5).
5. See below for proper cleaning instructions.
6. Check all gas connections for leaks.
7. Check components for any signs of damage or rust.
8. Check for obstructions of airflow to the burner. Spiders, insects and webs can clog the
burner/venturi tube. A clogged burner/venturi tube can lead to a fire.
9. If damage to any component is detected, do NOT operate until repairs are completed.
Cleaning Surfaces
1. Wipe surfaces clean with mild dishwashing detergent or baking soda mixed with water.
2. For stubborn stains, use a citrus-based cleaner and a nylon scrubbing brush.
3. Rinse clean with water.
4. Allow to air dry.
Note: While cleaning your unit, be sure to keep the area around the burner and pilot assembly
dry at all times.
W CAUTION: Do NOT submerge the control valve assembly. If the gas
control is submerged in water, do NOT use it. It must be replaced.
Maintenance
To enjoy years of outstanding performance from your heater, make sure you perform the
following maintenance activities on a regular basis:
1. Keep exterior surfaces clean.
2. Perform routine maintenance.
3. Air flow must be unobstructed. Keep controls, burner, and circulating air passageways
clean. Signs of possible blockage include:
• Gas odor with extreme yellow tipping of flame.
• Outdoor fire pit does NOT reach the desired temperature.
• Lower burner on outdoor fire pit glow is excessively uneven.
• Lower burner on outdoor fire pit makes popping noises.
Note: In a salt-air environment (such as near an ocean), corrosion occurs more quickly than
normal. Frequently check for corroded areas and repair them before operating.
TIP: Use high-quality automobile wax to help maintain the appearance of your outdoor fire pit.
Apply to exterior surfaces. Do NOT apply to burners, emitter screen or domes.
Cleaning Burner
W WARNING: All cleaning should be done when appliance is cool and
with the fuel supply disconnected per “Disconnecting LP Gas Tank.”
1. Remove the fire glass/lava rock
2. Remove all dirt/dust from the burner, igniter cover and venturi area with a small brush and/
or compressed air.
3. Visually inspect the burner for any rust or damage. If damage is found, replace necessary
parts with new from the manufacturer.
4. Clean any clogged burner ports with a stiff wire (such as an opened paper clip).
5. Carefully replace the fire glass/lava rock being cautious not to block the igniter cover.
Before Storing
1. Turn LP gas tank valve to “CLOSED.”
2. Turn control knob to the “ OFF” position.
Note: A “poof” sound is normal as the last of the gas is burned.
3. Disconnect LP gas tank per “Disconnecting LP Gas Tank” section.
4. Clean all surfaces.
5. Lightly coat the burner with cooking oil to prevent excess rusting.
W CAUTION: NEVER place cover on hot outdoor fire pit.
6. If storing the outdoor fire pit indoors, cover the outdoor fire pit and store in a cool dry
location away from children and pets.
7. If storing the outdoor fire pit outdoors, cover the outdoor fire pit with a cover for protection
from the weather.
8. Store outdoor fire pit upright in an area sheltered from direct contact with inclement
weather (such as rain, sleet, hail, snow, dust, debris and high winds).
9. Place the protective cap cover on the LP tank and store the tank outdoors in a well
ventilated area out of direct sunlight.
Product Registration
For faster warranty service, please register your product immediately. To register, email
[email protected] with your name, address, phone number and copy of your receipt or
call 1.888.398.8643.
Replacement Parts
For replacement parts, call 1.888.398.8643.
Limited Warranty
Mr. Bar-B-Q Products LLC warrants to the original retail purchaser of this product, and to no
other person, that if this product is assembled, maintained, and operated in accordance with
the printed instructions accompanying it, then for a period of one (1) year from the date of
purchase, all parts in such product shall be free from defects in material and workmanship.
Mr. Bar-B-Q Products LLC may require reasonable proof of your date of purchase. Therefore,
you should retain your sales slip or invoice. This Limited Warranty shall be limited to the repair
or replacement of parts, which prove defective under normal use and service and which
Mr. Bar-B-Q Products LLC shall determine in its reasonable discretion upon examination to be
defective. Before returning any parts, you should contact Mr. Bar-B-Q Products LLC Customer
Care Department using the contact information listed below. If Mr. Bar-B-Q Products LLC
confirms, after examination, a defect covered by this Limited Warranty in any returned part,
and if Mr. Bar-B-Q Products LLC approves the claim, Mr. Bar-B-Q Products LLC will replace
such defective part without charge. If you return defective parts, transportation charges must
be prepaid by you. Mr. Bar-B-Q Products LLC will return replacement parts to the original retail
purchaser, freight or postage prepaid.
This Limited Warranty does not cover any failures or operating difficulties due to accident,
abuse, misuse, alteration, misapplication, improper installation or improper maintenance or
service by you or any third party, or failure to perform normal and routine maintenance on
the product as set out in this owner’s manual. In addition, the Limited Warranty does not cover
damage to the finish, such as scratches, dents, discoloration, rust or other weather damage,
after purchase.
This Limited Warranty is in lieu of all other express warranties. Mr. Bar-B-Q Products LLC
disclaims all warranties for products that are purchased from sellers other than authorized
retailers or distributors, including the warranty of merchantability or the warranty of
fitness for a particular purpose. Mr. Bar-B-Q Products LLC ALSO DISCLAIMS ANY AND ALL
IMPLIED WARRANTIES, INCLUDING WITHOUT LIMITATION THE IMPLIED WARRANTIES OF
MERCHANTABILITY AND FITNESS FOR A PARTICULAR PURPOSE. Mr. Bar-B-Q Products LLC
SHALL HAVE NO LIABILITY TO PURCHASER OR ANY THIRD PARTY FOR ANY SPECIAL, INDIRECT,
PUNITIVE, INCIDENTAL, OR CONSEQUENTIAL DAMAGES. Mr. Bar-B-Q Products LLC further
disclaims any implied or express warranty of, and assumes no responsibility for, defects in
workmanship caused by third parties.
This Limited Warranty gives the purchaser specific legal rights; a purchaser may have other
rights depending upon where he or she lives. Some jurisdictions do not allow the exclusion or
limitation of special, incidental or consequential damages, or limitations on how long a warranty
lasts, so the above exclusion and limitations may not apply to everyone.
Mr. Bar-B-Q Products LLC does not authorize any person or company to assume for it any
other obligation or liability in connection with the sale, installation, use, removal, return, or
replacement of its equipment, and no such representations are binding on
Mr. Bar-B-Q Products LLC.
Mr. Bar-B-Q Products LLC
10 Hub Dr., Ste 101, Melville, NY 11747 USA
1.888.398.8643
Need help? 1.888.398.8643
Do not return to place of purchase.
Replacement Parts
1.888.398.8643
12
Specifications
Upper Burner
Certifications:
ANS Z21.97 • CSA 2.41- 2017
Rating:
Maximum 30,000 BTU/hr. input
Fuel:
Liquid Propane Gas (LP)
Tank Size:
Nominal 20 lb / 5 Gallon
Inlet Gas Supply Pressure:
Maximum – 11.00 in. W.C.
Minimum – 11.00 in. W.C.
Manifold Pressure:
11.00 in. W.C.
Safety Features:
100% Burner shut-off
Thermocouple
Manufacturer:
Mr. Bar-B-Q Products LLC
Made In:
China
Lower Burner
Certifications:
ANS Z83.26 • CSA 2.37 - 2017
Rating:
Maximum 11,000 BTU/hr. input
Heat Range:
Up to 20 foot diameter
Fuel:
Liquid Propane Gas (LP)
Tank Size:
Nominal 20 lb / 5 Gallon
Inlet Gas Supply Pressure:
Maximum – 150 PSI
Minimum – 5 PSI
Manifold Pressure:
11.00 in. W.C.
Engine:
IPP E1
Safety Features:
100% Burner shut-off
Magnetic valve
Manufacturer:
Mr. Bar-B-Q Products LLC
Made In:
China
13
LP Gas Outdoor Fire Pit
Model No.: GAD19102ES
Troubleshooting - Upper Burner
Problem Possible Cause Prevention/Cure
Burner will not light using igniter
LP gas tank valve is closed
Make sure regulator is securely attached to the LP gas tank per “Installing LP
Gas Tank,” then turn LP gas tank valve to “OPEN.”
LP gas tank is low or empty Exchange, refill or replace LP gas tank
LP gas leak
1. Turn LP gas tank valve to “CLOSED”
2. Wait 5 minutes for gas to clear
3. Follow “Checking for Leaks” section
Battery needs to be changed Replace the “AA” battery (follow assembly step for inserting battery)
Electrode and burners are wet Wipe dry with cloth
Electrode cracked or broken - sparks at crack Replacement part(s) may be needed - contact Customer Care at 888.398.8643
Wire loose or disconnected
Reconnect wire or replacement part(s) may be needed - contact Customer Care
at 888.398.8643
Wire is shorting (sparking) between igniter and electrode Replacement part(s) may be needed - contact Customer Care at 888.398.8643
Thermocouple is not operating correctly
1. Disconnect LP Gas tank per “Disconnect LP Gas Tank” section.
2. Clean area around thermocouple.
3. Connect LP gas tank per “Connect LP Gas Tank” section.
4. Relight per “Lighting” section.
5. If the outdoor fire pit is still not working, please contact Customer Care at
888.398.8643 for additional assistance.
Bad igniter Replacement part(s) may be needed - contact Customer Care at 888.398.8643
Burner will not light with match
No gas flow
Check if LP gas tank is empty
a. If empty, exchange, refill or replace LP gas tank
b. If LP gas tank is not empty, refer to “Sudden drop in gas flow or
reduced flame height” (see below)
LP gas tank is low or empty Exchange, refill or replace LP gas tank
LP gas leak
1. Turn LP gas tank valve to “CLOSED”
2. Wait 5 minutes for gas to clear
3. Follow “Checking for Leaks” section
Coupling nut and regulator not fully connected
Turn the coupling nut about one-half to three-quarters additional turn until solid
stop. Tighten by hand only - do NOT use tools
Obstruction of gas flow
1. Clear burner/venturi tube
2. Check for bent or kinked hose
Disengagement of burner to valve Re-engage burner and valve
Spider webs or insect nest in burner/venturi tube Clean burner/venturi tube
Thermocouple is not operating correctly
1. Disconnect LP Gas tank per “Disconnect LP Gas Tank” section.
2. Clean area around thermocouple.
3. Connect LP gas tank per “Connect LP Gas Tank” section.
4. Relight per “Lighting” section.
5. If the outdoor fire pit is still not working, please contact Customer Care at
888.398.8643 for additional assistance.
Burner ports clogged or blocked Clean burner ports
Sudden drop in gas flow or reduced flame height
Out of gas Exchange, refill or replace LP gas tank
Overfilling prevention device may have been activated
1. Turn control knob to “ OFF”
2. Wait 30 seconds and light outdoor fire pit per “Lighting” section
3. If flames are still too low, reset the overfilling prevention device:
a. Turn control knob(s) “ OFF”
b. Turn LP gas tank valve to “CLOSED”
c. Disconnect regulator
d. Turn control knobs to (HIGH)
e. Wait one minute
f. Turn control knobs to “ OFF”
g. Reconnect regulator and leak check connections, being careful not to
fully open valve
h. Light outdoor fire pit per “Lighting” section
Irregular flame pattern, flame does not run the
full length of burner
Burner ports are clogged or blocked Clean burner ports
Flame is yellow or orange
New burner may have residual manufacturing oils Burn outdoor fire pit for 15 minutes and reinspect
Spider webs or insect nest in burner/venturi tube Clean burner/venturi tube
Poor alignment of valve to burner/venturi tube Ensure burner/venturi tube is properly engaged with valve
Flame goes out
High or gusting winds Do not use outdoor fire pit in high winds
Low on LP gas Exchange, refill or replace LP gas tank
Excess flow valve tripped Refer to “Sudden drop in gas flow or reduced flame height”
Thermocouple is not operating correctly
1. Disconnect LP Gas tank per “Disconnect LP Gas Tank” section.
2. Clean area around thermocouple.
3. Connect LP gas tank per “Connect LP Gas Tank” section.
4. Relight per “Lighting” section.
5. If the outdoor fire pit is still not working, please contact Customer Care at
888.398.8643 for additional assistance.
Flashback (fire in venturi/burner tube(s)) Burner and/or burner/venturi tube is blocked Clean burner and/or burner/venturi tube
Flame seems to lose heat when burning in cold
weather - temperature below 50ºF
Ice has built up on the outside of the LP gas tank
because the vaporization process is too slow
1. Turn off per “Turning Off” section
2. Replace with a spare LP gas tank
3. Reconnect LP gas tank per “Installing LP Gas Tank” section
4. Follow “Checking for Leaks” section
5. Light outdoor fire pit per “Lighting” section
For assistance, please visit us at MrBarBQProducts.com or call 1.888.398.8643.
Need help? 1.888.398.8643
Do not return to place of purchase.
Replacement Parts
1.888.398.8643
14
Troubleshooting - Lower Burner
Problem Possible Cause Prevention/Cure
Pilot won’t light
LP gas tank valve is closed
Make sure regulator is securely attached to the LP gas tank per “Installing LP Gas Tank,”
then turn LP gas tank valve to “OPEN.”
LP gas tank is low or empty Exchange, refill or replace LP gas tank
LP gas leak
1. Turn LP gas tank valve to “CLOSED”
2. Wait 5 minutes for gas to clear
3. Follow “Checking for Leaks” section
Battery needs to be changed Replace the “AA” battery (follow assembly step for inserting battery)
Igniter fails
Light the heater manually with a match, per the “Lighting Instructions.” If heater lights with
a match, replace igniter - contact Customer Care at 888.398.8643.
Blockage in pilot or orifice
Clean the pilot assembly: Download and follow the correct cleaning instructions from
BlueRhino.com.
Air in gas line
1. Open gas line and bleed it (pressing control knob in) for not more than 1 - 2 minutes or
until you smell gas
2. Turn control knob to “ OFF”
3. Wait at least 5 minutes for gas to dissipate
4. Light per “Lighting” section.
Burner won’t light
Note: Burner operates at reduced
efficiency below 40ºF (5ºC).
Control knob is NOT in an ON position Review “Lighting” section and try again
Control knob IS in an ON position Review “Lighting” section and try again
LP gas tank is low or empty Exchange, refill or replace LP gas tank
LP gas leak
1. Turn LP gas tank valve to “CLOSED”
2. Wait 5 minutes for gas to clear
3. Follow “Checking for Leaks” section
Blockage in orifice Clear blockage: Download and follow the correct cleaning instructions from BlueRhino.com
Connection between gas valve and burner assembly is
loose
1. Turn off heater per “Turning Off” section.
2. Disconnect LP gas tank per “Disconnecting LP Gas Tank” section.
3. Tighten connection.
4. Perform leak check per “Checking for Leaks” instructions.
5. Light per “Lighting” section.
Thermocouple is not operating correctly
1. Disconnect LP Gas tank per “Disconnect LP Gas Tank” section.
2. Clean area around thermocouple.
3. Connect LP gas tank per “Connect LP Gas Tank” section.
4. Relight per “Lighting” section.
5. If the outdoor fire pit is still not working, please contact Customer Care at
888.398.8643 for additional assistance.
Air in gas line
1. Open gas line and bleed it (pressing control knob in) for not more than 1 - 2 minutes or
until you smell gas.
2. Wait 5 minutes for gas to clear
3. Follow “Checking for Leaks” section
Pilot won’t stay lit
Note: Heater operates at reduced
efficiency below 40ºF (5ºC).
Dirt built up around pilot
Clean the pilot assembly: Download and follow the correct cleaning instructions from
BlueRhino.com.
Connection between gas valve and pilot assembly is
loose
1. Turn off heater per “Turning Off” section.
2. Disconnect LP gas tank per “Disconnecting LP Gas Tank” section.
3. Tighten connection.
4. Perform leak check per “Checking for Leaks” section.
5. Light per “Lighting” section.
Air in gas line
Open gas line and bleed it (pressing control knob in) for not more than 1 - 2 minutes or until
you smell gas.
Thermocouple is not operating correctly
1. Disconnect LP Gas tank per “Disconnect LP Gas Tank” section.
2. Clean area around thermocouple.
3. Connect LP gas tank per “Connect LP Gas Tank” section.
4. Relight per “Lighting” section.
5. If the outdoor fire pit is still not working, please contact Customer Care at
888.398.8643 for additional assistance.
Burner won’t stay lit
Connection between gas valve and burner assembly is
loose
Tighten connection and perform leak check.
Thermocouple is not operating correctly
1. Disconnect LP Gas tank per “Disconnect LP Gas Tank” section.
2. Clean area around thermocouple.
3. Connect LP gas tank per “Connect LP Gas Tank” section.
4. Relight per “Lighting” section.
5. If the outdoor fire pit is still not working, please contact Customer Care at
888.398.8643 for additional assistance.
Blockage in burner
1. Turn off heater per “Turning Off” instructions.
2. Remove blockage and clean burner inside and outside:
Download and follow the correct cleaning instructions from BlueRhino.com
3. If the heater is still not working, replacement part(s) may be needed - contact Customer
Care at 888.398.8643
Burner flame is low
Note: Heater operates at reduced
efficiency below 40ºF (5ºC).
LP gas tank is low or empty Exchange, refill or replace LP gas tank
Outdoor temperature is less than 40ºF and tank is less
than 1/4 full
1. Turn off heater per “Turning Off” section.
2. Connect a full LP Gas Tank per “Connecting LP Gas Tank” section.
Supply hose is bent or kinked
1. Turn off heater per “Turning Off” section.
2. Straighten hose. If cracked obtain a new hose from the manufacturer - contact
Customer Care at 888.398.8643
Emitter glows uneven
Note: Bottom 1 in of emitter normally
does NOT glow.
LP gas tank is low or empty Exchange, refill or replace LP gas tank
Base is not on a level surface Place heater on a level surface
Blockage in burner
1. Turn off heater per “Turning Off” section.
2. When cool, remove blockage and clean burner inside and outside.
3. Download and follow the correct cleaning instructions from BlueRhino.com.
Thick black smoke Blockage in burner
1. Turn off heater per “Turning Off” section.
2. When cool, remove blockage and clean burner inside and outside.
3. Download and follow the correct cleaning instructions from BlueRhino.com.
For assistance, please visit us at MrBarBQProducts.com or call 1.888.398.8643.
Need help? 1.888.398.8643
Do not return to place of purchase.
Replacement Parts
1.888.398.8643
1
MANUEL D’UTILISATION
Table des matières
Mises en garde importantes ..................................................Page 2
Vue éclatée des pièces et quincaillerie .............................................. 5
Instructions d’assemblage ....................................................... 6
Installer la bouteille de propane ................................................... 9
Fonctionnement .............................................................. 10
Nettoyage et entretien ......................................................... 11
Enregistrement de l’appareil..................................................... 11
Pièces de rechange ........................................................... 12
Garantie limitée .............................................................. 12
Caractéristiques techniques ..................................................... 12
Guide de dépannage........................................................... 13
L’utilisation et l’installation de cet appareil doivent être conformes aux codes locaux. En l’absence de codes
locaux, suivre la dernière édition du National Fuel Gas Code (Code national de gaz combustible), les normes
ANSI Z223.1/NFPA 54, ou le International Fuel Gas Code (Code international de gaz combustible). Cet appareil
doit être mis à la terre conformément aux codes locaux ou en l’absence de codes locaux suivre le National
Electrical Code (Code électrique national) et la norme ANSI/NFPA 70 selon le cas.
Pour une installation au Canada, ces instructions, bien qu’en général acceptables, risquent de ne pas être
conformes aux codes d’installation canadiens surtout en matière de tuyauterie en surface ou dans le sol.
Au Canada, l’installation de cet appareil doit être conforme aux codes locaux et/ou à la norme canadienne
CAN/CGA B149.1 (code d’installation pour appareils et équipements au propane).
CE MANUEL CONTIENT DE L’INFORMATION IMPORTANTE CONCERNANT LA SÉCURITÉ. CONSERVEZ CE MANUEL
POUR CONSULTATION FUTURE.
Si vous êtes en train d’assembler cet appareil pour quelqu’un d’autre, veuillez lui remettre ce manuel pour qu’il
puisse le lire et le conserver pour consultation future.
AVERTISSEMENT : Ce produit peut vous exposer à des substances chimiques, y compris du
monoxyde de carbone, de la suie, du phtalate de diisononyle (DINP), du plomb et les constituants
du plomb, reconnus par l’État de la Californie comme pouvant causer le cancer, des malformations
congénitales et avoir d’autres effets néfastes sur l’appareil reproducteur. Se laver les
mains après avoir manipuler le produit. Pour de plus amples renseignements, voir
www.P65Warnings.ca.gov.
MONOXYDE DE CARBONE
• Cette appareil peut produire du monoxyde de carbone, un gaz
inodore.
• L’utilisation de cet appareil dans des espaces clos peut
entraîner la mort.
• Ne jamais utiliser cet appareil dans un espace clos comme un
véhicule de camping, une tente, une automobile ou une maison.
· DANGER
Fabriqué à partir de 75% de
bagasse de canne à sucre
(résidu de pulpe de canne à sucre
sans danger pour l’environnement)
AVERTISSEMENT
POUR USAGE A L’EXTERIEUR
SEULEMENT.
W L’installation et l’entretien de cet appareil doivent
être effectués par un installateur qualifié, un
service de réparation agréé ou votre fournisseur de
bouteilles de gaz.
AVERTISSEMENT
W INSTALLATEUR : Laisser ce manuel avec l’appareil.
W UTILISATEUR : Conserver ce manuel afin de pouvoir
le consulter ultérieurement.
AVERTISSEMENT
POUR VOTRE SÉCURITÉ:
W Le non-respect des consignes contenues dans ce
manuel risque de provoquer un incendie ou une
explosion et d’entraîner des dégâts matériels, des
blessures graves voire la mort.
W QUE FAIRE EN CAS D’ODEUR DE GAZ:
• Ne tenter en aucun cas d’allumer un appareil
quelconque.
• Ne pas toucher d’interrupteur électrique; ne pas
téléphoner en utilisant un téléphone de votre
bâtiment.
• Appeler immédiatement votre fournisseur de
bouteilles de gaz en utilisant le téléphone d’un
voisin habitant dans un autre bâtiment.
• Suivre les instructions du fournisseur de bouteilles
de gaz.
• Si le fournisseur de bouteilles de gaz est
injoignable, appeler les pompiers.
W Non destiné à la cuisson.
AVERTISSEMENT
POUR VOTRE SÉCURITÉ:
1. Une installation, un réglage, une modification, une
réparation ou un entretien inapproprié peut être la
cause de blessures ou de dégâts matériels.
2. Veuillez lire attentivement les instructions
d’installation, d’utilisation et d’entretien avant
d’installer ou de réparer ce matériel.
DANGER
Ne jamais laisser cet appareil allumé sans surveillance.
MANUEL D’UTILISATION
Brevets en instance
Fabriqué en Chine pour : Mr. Bar-B-Q Products LLC
10 Hub Dr., Ste 101, Melville, NY 11747 États-Unis • 1.888.398.8643 • MrBarBQProducts.com
© Mr. Bar-B-Q Products LLC
Endless Summer
®
est une marque déposée de Mr. Bar-B-Q Products LLC. GAD19102ES-EF-OM-F101
Foyer d’extérieur au propane
avec
«Donovan»
Modèle nº
: GAD19102ES
DANGER
RISQUE D’INCENDIE ET D’EXPLOSION
En cas d’odeur de gaz :
• Couper l’arrivée de gaz de l’appareil.
• Éteindre toute flamme nue.
• Si l’odeur persiste, s’éloigner immédiatement
de l’appareil et de l’endroit où il se trouve.
• Après s’être éloigné de l’endroit où se trouve
l’appareil, appeler le fournisseur de gaz ou le
service d’incendie.
Le non-respect des ces consignes risque de provoquer
un incendie ou une explosion et d’entraîner des dégâts
matériels, des blessures graves ou la mort.
AVERTISSEMENT
POUR VOTRE SÉCURITÉ :
1. Ne pas entreposer ni utiliser de l’essence ni d’autres
vapeurs ou liquides inflammables dans le voisinage
de l’appareil, ni de tout autre appareil.
2. Une bouteille de propane qui n’est pas raccordée en
vue de son utilisation, ne doit pas être entreposée
dans le voisinage de cet appareil ou de tout autre
appareil.
Need help? 1.888.398.8643
Do not return to place of purchase.
Replacement Parts
1.888.398.8643
2
Mises en garde importantes
DANGER – Gaz inflammable sous pression. Une fuite de GPL peut causer
un incendie ou une explosion si enflammée entraînant des blessures
corporelles graves ou la mort. Communiquer avec le fournisseur de GPL pour
les réparations ou pour disposer de cette bouteille ou du GPL non utilisé.
Avertissement – Pour usage à l’extérieur seulement. *Ne pas utiliser ni
entreposer la bouteille dans un bâtiment, un garage ou un endroit fermé.
• Apprenez à reconnaître l’odeur du GPL. Si vous entendez,
voyez ou sentez une fuite de GPL, éloignez immédiatement
toutes les personnes de la bouteille et appelez le service
d’incendie. Ne tentez aucune réparation.
• Avertissement pour le fournisseur de GPL :
Assurez-vous que la bouteille a été purgée de tout
l’air avant de procéder au remplissage initia.
Assurez-vous de ne pas trop remplir la bouteille.
Assurez-vous que la date de requalification de
la bouteille a été vérifiée.
• Le contact avec le contenu liquide de la bouteille peut
causer des brûlures à la peau par le froid.
• Ne pas permettre aux enfants de jouer avec la bouteille.
• Si la bouteille n’est pas raccordée pour utilisation,
s’assurer que le robinet est fermé. Les bouteilles des
appareils autonomes de cuisson en plein air doivent être
limitées à une capacité d’au plus 30 lb.
• Ne pas utiliser, entreposer ni transporter une bouteille si
elle risque d’être exposée à des températures élevées. La
soupape de décharge pourrait s’ouvrir et libérer une
grande quantité de gaz inflammable.
• Lors du transport, sécuriser la bouteille en position debout
et s’assurer que le robinet est fermé.
Lors du raccordement pour utilisation :
• Utilisez uniquement conformément aux codes en vigueur.
• Lisez et suivez les instructions du fabricant.
• Consultez les instructions du fabricant visant le
raccordement de la bouteille fournie avec l’appareil.
• Assurez-vous que l’évent du régulateur n’est pas dirigé
vers le haut.
• Fermez tous les robinets sur l’appareil.
• Ne pas utiliser d’allumette ou de flamme nue pour vérifier
la présence d’une fuite de gaz. Appliquez une solution
d’eau savonneuse sur les zones marquées d’un « X ».
Ouvrir le robinet de la bouteille. Si des bulles se forment,
fermez le robinet et demandez à une personne qualifiée
pour l’entretien d’appareils au GPL de faire les
réparations requises. Avant d’allumer l’appareil, vérifiez
aussi les robinets et les raccordements de l’appareil afin
de vous assurer qu’il n’y a pas de fuite.
• Allumez l’appareil selon les instructions du fabricant.
• Lorsque vous n’utilisez pas l’appareil, gardez le robinet de
la bouteille fermé.
Avertissement :
NE PAS RETIRER, BARBOUILLER OU EFFACER CETTE ÉTIQUETTE
*SAUF DANS LES CAS PERMIS SELON LES NORMES L’ANSI/NFPA 58 ou la CSA B149.2
DANGER. Ne pas entreposer une bouteille de GPL sous l’appareil ou à proximité de celui-ciet de toute source de chaleur.
Ne jamais remplir une bouteille de GPL à plus de 80 % de sa capacité : un incendie causant la mort ou des blessures graves peut se produire.
3
Foyer d’extérieur au propane
modèle n˚ : GAD19102ES
W DANGER : Le non-respect des avis de danger, des mises en garde et des consignes de sécurité de ce manuel risque de provoquer un incendie ou une
explosion et d’entraîner des dégâts matériels, des blessures graves voire la mort.
W MISES EN GARDE :
W NE PAS utiliser ce foyer d’extérieur avant de lire toutes les instructions
de ce manuel d’utilisation.
W Cet appareil doit être utilisé uniquement à l’extérieur et NE doit PAS être
utilisé dans un immeuble, un garage ou tout autre espace clos.
W NE PAS utiliser ou allumer cet appareil à moins de 3,05 m de tout mur,
construction ou immeuble.
W Pour usage domestique seulement. Ce foyer d’extérieur N’est PAS
destiné à un usage commercial.
W NE PAS utiliser le foyer pour se chauffer ou pour cuisiner à l’intérieur.
Des émanations TOXIQUES de monoxyde de carbone peuvent
s’accumuler et provoquer l’asphyxie.
W Ce foyer d’extérieur a été homologué uniquement pour être utilisé
aux États-Unis et/ou au Canada en toute sécurité. NE PAS modifier ce
foyer d’extérieur afin de pouvoir l’utiliser autre part. Toute modification
ou altération présentera un danger de fonctionnement et entraînera
l’annulation de la garantie.
W Avis aux personnes habitant en appartements : Vérifier auprès de la
gérance pour connaître les conditions requises, la réglementation et
le code de prévention des incendies de votre complexe d’habitations
collectives concernant l’utilisation de ce foyer d’extérieur au propane.
Si permis, utiliser le foyer en le posant au sol en laissant une distance
de sécurité de 3 m (10 pieds) entre le foyer et toute structure. NE PAS
utiliser sur ou sous un balcon.
W Ce foyer d’extérieur doit être utilisé uniquement avec du propane
liquide (GPL). Toute utilisation de gaz naturel avec ce foyer d’extérieur
ou tentative de conversion au gaz naturel de ce foyer d’extérieur est
dangereuse et entraînera l’annulation de la garantie.
W Caractéristiques du propane (GPL) :
a. Le propane est un gaz inflammable et dangereux si ce dernier n’est
pas manipulé correctement. Il est indispensable de connaître les
dangers encourus avant d’utiliser tout appareil fonctionnant au
propane.
b. Le propane, qui risque d’exploser sous pression, est plus lourd que
l’air, se dépose et demeure au sol.
c. Le propane à l’état naturel est inodore. Pour votre sécurité, un
odorisant ayant l’odeur de choux avariés a été ajouté.
d. Tout contact du propane avec la peau risque d’entraîner des
engelures.
W Il est nécessaire de brancher une bouteille de propane pour faire
fonctionner le foyer d’extérieur. Seules les bouteilles marquées
«propane » peuvent être utilisées.
a. La bouteille de propane doit être fabriquée, marquée et mise en
service conformément à la Réglementation sur les bouteilles de
gaz de pétrole liquéfié établie par le Ministère des transports des
États-Unis (DOT) ou répondre à la Norme nationale du Canada, CAN/
CSA-B339 sur les bouteilles, sphères et tubes destinés au transport
de produits dangereux et la commission.
b. La bouteille de propane doit être placée afin de permettre
l’extraction des vapeurs de gaz.
c. La bouteille de propane doit être équipée d’un système d’arrêt
volumétrique (OPD) empêchant tout remplissage excessif et d’un
raccord rapide QCCI ou d’un raccord de Type 1 (CGA810) pour le
branchement de la bouteille de propane.
d. La bouteille de propane doit posséder un col afin de protéger le
robinet et la valve de la bouteille.
e. Ne jamais utiliser une bouteille de propane si le corps, la valve, le
robinet, le col ou le socle sont endommagés.
f. Toute bouteille bosselée ou présentant des traces de rouille risque
d’être dangereuse et devrait être vérifiée par votre fournisseur avant
de l’utiliser.
g. Ne pas laisser tomber la bouteille ni la manipuler brusquement ou
brutalement!
h. Les bouteilles de gaz doivent être entreposées à l’extérieur, hors de
la portée des enfants et ne doivent pas être entreposées dans un
bâtiment, un garage ou dans tout autre lieu fermé. Les bouteilles
de gaz ne doivent jamais être entreposées dans un endroit où la
température risque de dépasser 51,6°C (125°F)!
i. NE PAS introduire d’outil ni de corps étranger dans la sortie du
robinet de la bouteille de gaz ni dans la soupape de sécurité. Vous
risquez d’endommager la soupape et de provoquer une fuite. Toute
fuite de propane risque de provoquer une explosion ou un incendie
et d’entraîner des blessures graves voire la mort.
j. Ne jamais garder une bouteille de propane pleine dans une voiture
ou dans le coffre d’une voiture sous une forte chaleur. La chaleur
peut provoquer une augmentation de la pression du gaz, pouvant
provoquer l’ouverture de la soupape de sécurité et lui permettre de
s’échapper.
k. Mettre un bouchon antipoussière sur la sortie du robinet de la
bouteille lorsque la bouteille n’est pas utilisée. Installer uniquement
le bouchon antipoussière sur la sortie du robinet de la bouteille de
gaz qui est fourni avec le robinet de la bouteille. L’emploi d’autres
types de bouchons risque d’entraîner une fuite de propane.
l. NE PAS entreposer une bouteille de propane de rechange sous ou à
proximité de cet appareil.
m. Ne jamais remplir la bouteille de propane à plus de 80% de sa
capacité.
n. Les consignes ci-dessus doivent être strictement respectées et le
non respect de ces consignes risque de provoquer un incendie et
d’entraîner des dégâts matériels ou des blessures graves.
W Votre foyer d’extérieur a été vérifié en usine afin de s’assurer que
les raccords ne présentent aucune fuite. Vérifier à nouveau tous les
raccords en suivant les instructions du chapitre « Fonctionnement » du
manuel car il est possible qu’ils se soient desserrés lors du transport.
W Vérifier que l’appareil ne présente aucune fuite même si ce dernier a été
assemblé pour vous par quelqu’un d’autre.
W NE PAS utiliser le foyer d’extérieur en cas de fuite de gaz. Toute fuite de
gaz risque de provoquer un incendie ou une explosion.
W Il est obligatoire de suivre toutes les procédures de détection de fuite
avant d’utiliser cet appareil. Afin d’éviter tout risque d’incendie et
d’explosion lorsque l’on recherche une fuite :
a. Vérifier que le circuit ne présente pas de fuite en effectuant un « test
d’étanchéité » avant d’allumer le foyer d’extérieur à chaque fois que
la bouteille de gaz est branchée afin de l’utiliser.
b. Interdiction de fumer. NE PAS utiliser ni laisser de sources d’ignition
à proximité du foyer d’extérieur lorsque l’on recherche une fuite.
c. Effectuer le test d’étanchéité en plein air, dans un emplacement bien
aéré.
d. NE PAS utiliser d’allumettes, de briquets ou de flamme nue afin de
rechercher une fuite.
e. La prise d’alcool, de médicaments ou de drogues risque de nuire à
l’aptitude de l’utilisateur à assembler ou à utiliser cet appareil en
toute sécurité.
f. La présence de fortes odeurs, ou si vous avez un rhume ou des
sinus bouchés, risque de nuire à la détection d’une fuite de propane.
Faites preuve de précaution et de bon sens lorsque vous effectuez
un test d’étanchéité et recherchez une fuite.
g. NE PAS utiliser le foyer d’extérieur avant d’avoir réparé toute les
fuites. S’il s’avère impossible d’arrêter une fuite, débrancher la
bouteille de propane. Contacter un réparateur ou votre fournisseur
de bouteilles de propane.
W NE PAS utiliser ni entreposer d’essence ou de liquides aux vapeurs
inflammables à moins de 7,62 m (25 pieds) de cet appareil.
W NE PAS utiliser le foyer d’extérieur en présence de vapeurs et
émanations explosives. Veiller à ce que la zone autour du foyer
d’extérieur demeure dégagée et dépourvue de matières combustibles,
d’essence et d’autres liquides aux vapeurs inflammables.
W Ce foyer d’extérieur, NE doit PAS être utilisé par des enfants.
Mises en garde importantes
Vous avez besoin d’aide? Appelez le 1.888.398.8643.
Ne retournez pas au point de vente.
Pour pièces de rechange
1.888.398.8643
4
W NE PAS installer ni utiliser ce foyer d’extérieur à bord d’un bateau ou
d’un véhicule récréatif.
W Ne pas raccorder à une alimentation en gaz éloignée.
W Ne jamais essayer de raccorder ce foyer d’extérieur au circuit de
propane d’une caravane, autocaravane ou de votre maison.
W Veiller à toujours utiliser cet appareil conformément aux codes
locaux, nationaux et de votre province. Contacter les pompiers et les
services de lutte contre les incendies pour de plus amples informations
concernant l’incinération à l’extérieur et la prévention des incendies.
W Faire preuve des mêmes précautions que s’il s’agissait d’un feu normal
en plein air.
W NE PAS utiliser le foyer d’extérieur afin de brûler du bois, des briquettes
de charbon de bois, du charbon, des bûches en bois d’aggloméré, du
bois ayant séjourné dans l’eau, des ordures, des feuilles, du papier, du
carton, du contreplaqué, du bois peint ou teint ou du bois impregné sous
pression
W Il est primordial que le compartiment de la valve du foyer d’extérieur, les
brûleurs et les passages par où l’air circule demeurent propres. Vérifier
le foyer d’extérieur avant chaque utilisation.
W NE PAS utiliser le foyer d’extérieur à moins qu’il ne soit COMPLÈTEMENT
assemblé et que les pièces ne soient toutes fixées et serrées.
W NE PAS utiliser le foyer d’extérieur à proximité de voitures, de camions,
de camionnettes ou de véhicules récréatifs.
W NE PAS utiliser le foyer d’extérieur sous un abri, une structure
suspendue ou en saillie ou à proximité de toute construction
combustible non-protégée. Éviter d’utiliser cet appareil à proximité
d’arbres ou de buissons ou sous ces derniers.
W Placer toujours le foyer d’extérieur sur une surface plane, dure et non
combustible telle que du béton ou de la pierre. Il est déconseillé de le
placer sur de l’asphalte ou du bitume.
W NE PAS utiliser le foyer d’extérieur pour la cuisson.
W Ne pas utiliser cet appareil s’il a été plongé, même partiellement,
dans l’eau. Appeler un technicien qualifié pour inspecter l’appareil et
remplacer toute partie du système de commande et toute commande
qui a été plongée dans l’eau.
W NE PAS porter de vêtements inflammables ou amples en utilisant le
foyer d’extérieur.
W NE PAS utiliser le foyer d’extérieur s’il y a du vent.
W Ne jamais se pencher au-dessus du foyer d’extérieur pour l’allumer ou
lorsqu’il est allumé.
W NE PAS utiliser le foyer d’extérieur à moins que le brûleur ne soit
solidement fixé.
W Veiller à ce que les câbles et cordons électriques demeurent toujours
loin du foyer d’extérieur lorsqu’il est en train de fonctionner.
W Certaines surfaces du foyer d’extérieur deviendront trop chaudes au
toucher lorsqu’il est allumé. Pour éviter tout risque de brûlure, ne pas
toucher le foyer d’extérieur avant qu’il n’ait complètement refroidi à
moins de porter des gants de protection (gants, maniques isolantes,
mitaines résistantes à la chaleur).
W NE JAMAIS laisser un foyer d’extérieur allumé sans surveillance
surtout si des enfants ou des animaux domestiques et de compagnie se
trouvent à proximité.
W Prévenir les enfants et les adultes du danger que présentent les
surfaces brûlantes du foyer et ne pas les laisser demeurer à proximité
afin d’éviter qu’ils ne se brûlent ou que leurs vêtements ne prennent
feu.
W Surveiller attentivement les enfants lorsqu’ils se trouvent à proximité de
l’appareil.
W NE PAS accrocher de vêtements ou d’articles inflammables sur
l’appareil ou à proximité de l’appareil.
W Tout cache protecteur ou dispositif de protection ayant été retiré afin de
procéder à une réparation ou à l’entretien de l’appareil doit être remis
en place avant de mettre en marche l’appareil.
W Si l’appareil en possède une, la housse doit être retirée lorsque le
brûleur est allumé.
W Si l’appareil en possède une, la partie centrale de la table doit être
retirée avant d’allumer le brûleur et ne doit pas être remise en place
tant que le brûleur est allumé.
W NE PAS essayer de déplacer le foyer d’extérieur quand il est allumé.
Laisser le foyer d’extérieur complètement refroidir avant de le déplacer
ou de le remiser.
W Ce foyer d’extérieur doit être vérifié et nettoyé en entier régulièrement.
W Ce foyer d’extérieur doit être vérifié au moins une fois par an par un
réparateur qualifié. En fonction de la fréquence d’utilisation, l’appareil
risquera de devoir être nettoyé plus souvent. NE PAS utiliser le foyer
jusqu’à ce que toutes les pièces défectueuses aient été réparées ou
remplacées.
W Utiliser uniquement le régulateur et le tuyau fournis. Utiliser uniquement
le régulateur et le tuyau spécifiés par le Mr. Bar-B-Q Products LLC.
W Utiliser uniquement des pièces agréées de l’usine Mr. Bar-B-Q Products
LLC. L’emploi de toute pièce non agréée peut être dangereux et
entraînera l’annulation de la garantie.
W Utiliser uniquement des pierres de lave et de verre agréées de l’usine
Mr. Bar-B-Q Products LLC. L’emploi de pierres de lave et de verre non
agréées par l’usine peut être dangereux et entraînera l’annulation de la
garantie.
W NE PAS utiliser cet appareil avant de lire le chapitre « Fontionnement »
de ce manuel.
W Le remisage du foyer d’extérieur à l’intérieur est autorisé seulement si
la bouteille a été débranchée et retirée de l’appareil et correctement
entreposée à l’extérieur.
W NE PAS tenter de débrancher le régulateur de gaz de la bouteille ou de
débrancher une pièce quelconque de l’alimentation du gaz lorsque le
foyer d’extérieur est allumé.
W Lorsque l’on n’utilise pas le foyer d’extérieur, fermer l’alimentation du
gaz au niveau de la bouteille.
W MISE EN GARDE : Le régulateur de pression de gaz prévu avec cet
appareil de cuisson à gaz pour l’extérieur doit être utilisé. Ce régulateur
est réglé pour une pression de sortie de 11 pouces (28 cm)
de colonne d’eau.
W La pression minimale d’alimentation en gaz de ce foyer d’extérieur pour
la calibration initiale est de 11 po (27,9 cm) de colonne d’eau.
W La pression d’entrée maximum pour ce foyer d’extérieur est de 28 cm
(11 po.) de colonne d’eau.
W Fermer le robinet de la bouteille de propane, débrancher le régulateur
avant de tester la pression de la tuyauterie à une pression égale ou
supérieure à ½ psi (3.5 kPa).
W NE PAS s’asseoir sur la surface carrelée du manteau du foyer ni sur
toute autre pièce du foyer.
W NE rien jeter dans le feu lorsque l’appareil est allumé.
W Les pierres de verre ou de lave sont brûlantes. Gardez les enfants et les
animaux de compagnie à une distance sécuritaire de cet appareil.
W L’ouverture du col de la bouteille devrait être orientée vers la porte pour
faciliter l’accès.
W NE PAS entreposer de matières combustibles dans le compartiment
inférieur du socle.
W Porter des gants de protection pour assembler cet article.
W NE PAS forcer les pièces les unes dans les autres afin d’éviter toute
blessure et éviter d’endommager cet article.
W Les consignes ci-dessus doivent être strictement respectées et le non
respect de ces consignes risque de provoquer des dégâts matériels ou
d’entraîner des blessures graves voire la mort.
Mises en garde importantes (suite)
5
Foyer d’extérieur au propane
modèle n˚ : GAD19102ES
Outils requis pour l’assemblage (non fournis)
Tournevis cruciforme Phillips nº 2 1 pc
Quincaillerie
A
Vis
Nickelée, noire, à tête bombée Phillips, M5x12
22 pcs
B
Vis
Nickelée, noire, à épaulement M6x12
1 pc
C
Vis
Nickelée, noire, à tête bombée Phillips, M5X25
4 pcs
D
Vis
Nickelée, noire, à tête bombée Phillips, M4X8
1 pc
E
Pile AA 1 pc
Liste des pièces
1
Pierres de verre couleur
bronze
GLS-BRN
2
Couvercle de la table
58-23-817
3
Cuve*
58-24-161
4
Protège-veilleuse*
58-23-896
5
Brûleur*
58-24-162
6
Manteau*
58-24-163
7
Bouclier thermique A*
58-24-164
8
Supports*
58-24-165
9
Bouclier thermique B*
58-24-166
10
Coupole*
58-24-167
11
Bouclier thermique
latéral (4)*
58-24-168
12
Panneau supérieur (4)
58-24-169
13
Panneau inférieur (3)
58-24-170
14
Partie inférieur du
brûleur*
58-24-171
15
Bouclier thermique C*
58-24-172
16
Support du bouclier
thermique latéral (4)*
58-24-173
17
Montant supérieur (3)*
58-24-174
18
Montant supérieur B*
58-24-175
19
Bouclier thermique
inférieur*
58-24-178
20
Bouclier thermique de la
bouteille de propane*
58-24-179
21
Capuchon de pile*
58-23-897
22
Bouton de commande
(2)*
58-23-139
23
Control Panel Assembly*
58-24-180
24
Régulateur et tuyau*
58-24-181
25
Tige d’allumage
58-23-956
26
Barre de protection de la
bouteille de propane
58-24-182
27
Socle*
58-24-183
28
Boulon de fixation de la
bouteille de propane*
58-24-062
29
Porte*
58-24-184
30
Poignée de porte*
58-24-185
31
Pied A (2)
58-24-186
32
Pied B
58-24-187
33
Pied C
58-24-188
34
Aimant*
58-23-804
35
Patin (4)*
58-24-147
36
Housse
58-24-189
37
Pierres de lave (non
requises et vendues
séparément)**
58-24-190
* Pré-monté
W **ATTENTION : Utiliser
uniquement des pierres de lave et
de verre agréées de l’usine
Mr. Bar-B-Q Products LLC
L’emploi de pierres de lave et de
verre non agréées par l’usine
peut être dangereux et entraînera
l’annulation de la garantie.
Vue éclatée
Articles vendus séparément
37
1
15
2
9
16
20
4
7
6
10
14
8
11
12
5
13
31
17
30
36
19
3
21
8
11
11
12
12
13
13
16
17
17
18
16
16
22
24
23
25
26
27
28
29
31
32
33
34
35
35
11
12
Vous avez besoin d’aide? Appelez le 1.888.398.8643.
Ne retournez pas au point de vente.
Pour pièces de rechange
1.888.398.8643
6
Instructions d’assemblage
1
NE PAS RETOURNER AU MAGASIN AVEC CET ARTICLE.
Pour toute assistance technique, appelez le numéro sans frais
1.888.398.8643. Faites en sorte que votre manuel d’utilisation et le
numéro de série soient à portée de main afin de pouvoir vous y référer.
Pour faciliter l’assemblage:
1. Pour éviter de perdre des petites pièces ou la quincaillerie d’installation,
assemblez cet article sur une surface plane qui ne comporte pas de trous ni
de fissures.
2. Étalez toutes les pièces et la quincaillerie d’installation.
3. Serrez à la main toute les fixations et la visserie en premier. Une fois l’étape
terminée, serrez-les complètement en veillant à ne pas trop les serrer afin
d’éviter d’endommager la surface de l’appareil et de fausser le filetage.
4. Suivez toutes les étapes dans l’ordre afin d’assembler correctement cet
article.
Pour effectuer l’assemblage, vous aurez besoin des choses suivantes:
• une (1) solution de détection de fuites (voir instructions sur la préparation de
la solution au chapitre « Fonctionnement »).
• une (1) bouteille de propane liquide pour barbecue remplie avec précision
avec raccord de robinet à filetage externe Acme de type 1 (barbecue taille
standard) (non fournis).
Temps d’assemblage: environ une (1) heure.
W ATTENTION : Il faut deux (2) personnes pour effectuer
l’assemblage.
W AVERTISSEMENT : Tout défaut de placer les pièces selon
ces schémas ou de n’utiliser que des pièces spécifiquement
approuvées pour cet appareil peut causer des dommages
matériels et des blessures.
4
Fixer le panneau arrière et les panneaux latéraux
Remarque: Fixez les vis de fond avant de fixer les vis supérieures. Ne serrez pas les
vis complètement avant l’étape 5.
A
x 12
3
Fixer les pieds
Remarque : Ne serrez pas les vis complètement avant l’étape 5.
A
x 8
2
Placer le foyer d’extérieur face vers le bas
W ATTENTION : Il faudra deux (2) personnes pour remettre le
foyer debout.
W ATTENTION : Pour éviter toute égratignure, placer l’appareil
sur une surface lisse qui ne présente pas de rayures ni de
fentes.
31
31
32
33
A
La page charge ...
La page charge ...
La page charge ...
La page charge ...
La page charge ...
La page charge ...
La page charge ...
La page charge ...
La page charge ...
La page charge ...
-
1
-
2
-
3
-
4
-
5
-
6
-
7
-
8
-
9
-
10
-
11
-
12
-
13
-
14
-
15
-
16
-
17
-
18
-
19
-
20
-
21
-
22
-
23
-
24
-
25
-
26
-
27
-
28
-
29
-
30
Endless Summer Donovan Le manuel du propriétaire
- Taper
- Le manuel du propriétaire
- Ce manuel convient également à
dans d''autres langues
Documents connexes
Autres documents
-
USSC HCFTALOAK Manuel utilisateur
-
Red Mountain Valley 8922643 Le manuel du propriétaire
-
RST Brands OP-PSCLB5MFT-GY-K Mode d'emploi
-
Lynx Fire Pit Manuel utilisateur
-
Pleasant Hearth OFG321S Manuel utilisateur
-
Camp Chef FP30 Manuel utilisateur
-
Cosco 88-533DBTE Manuel utilisateur
-
-
Pleasant Hearth OFG466TA Manuel utilisateur
-
OVE Decors 15PC1R-THOR03-GRY Mode d'emploi
