Quadra-Fire MTVERNON-AE-PDB Le manuel du propriétaire

Quadra-Fire
Marque
Quadra-Fire
Modèle
MTVERNON-AE-PDB
Catégorie
Poêles
Taper
Le manuel du propriétaire

Ce manuel convient également à

1 7034-276 January 29, 2014
MT. VERNON PELLET STOVE
ADVANCED ENERGY (AE)
Model(s):
MTVERNON-AE-CSB
MTVERNON-AE-MBK
MTVERNON-AE-PBK
MTVERNON-AE-PDB
MTVERNON-AE-PFT
MTVERNON-AE-PMH
O-T L
Tested and
Listed by
Portland
Oregon USA
OMNI-Test Laboratories, Inc.
CUS
NOTICE: DO NOT DISCARD THIS MANUAL
Owner’s Manual
Operation & Care
INSTALLER: Leave this manual with party responsible for use and operation.
OWNER: Retain this manual for future reference.
Contact your dealer with questions regarding installation, operation, or service.
HOT SURFACES!
Glass and other surfaces are hot
during operation AND cool down.
Hot glass will cause burns.
• Do not touch glass until it is cooled
• NEVER allow children to touch glass
• Keep children away
• CAREFULLY SUPERVISE children in same room as
replace.
• Alert children and adults to hazards of high temperatures
• High temperatures may ignite clothing or other
ammablematerials.
• Keep clothing, furniture, draperies and other ammable
materials away.
WARNING
If the information in these instruc-
tions is not followed exactly, a
remayresultcausingproperty
damage, personal injury, or death.
• Donotstoreorusegasolineorotheram-
mablevaporsandliquidsinthevicinityof
this or any other appliance.
• Donotoverre-Ifheaterorchimneycon-
nectorglows,youareoverring.Overring
will void your warranty.
• Complywithallminimumclearancesto
combustiblesasspecied.Failureto
complymaycausehousere.
WARNING
CAUTION
Testedandapprovedforwoodpellets,shelledeld
corn,wheatandblackoilsunowerseeds.Burningof
any other type of fuel voids your warranty.
NOTE
ToobtainaFrenchtranslationofthismanual,pleasecontact
yourdealerorvisitwww.quadrare.com
Pourobtenirunetraductionfrançaisedecemanuel,s’ilvous
plaîtcontactervotrerevendeurouvisitezwww.quadrare.com
CAUTION
Checkbuildingcodespriortoinstallation.
• InstallationMUSTcomplywithlocal,regional,stateandna-
tional codes and regulations.
• Consultlocalbuilding,reofcialsorauthoritieshavingjuris-
dictionaboutrestrictions,installationinspection,andpermits.
061-S-68-6
2 7034-276 January 29, 2014
MT. VERNON AE
B. Sample of Serial Number / Safety Label
LOCATION: Back of Stove
CAUTION
:
HOT WHILE IN OPERATION DO NOT TOUCH, KEEP CHILDREN, CLOTHING AND
FURNITURE AWAY. CONTACT MAY CAUSE SKIN BURNS. SEE NAMEPLATE AND INSTRUCTIONS.
Operate this unit with fuel hopper lid closed. Failure to do so may result in emissions products' combustion from the
hopper under certain conditions. Maintain hopper seal in good condition. Do no over fill the hopper.
ATTENTION:
CHAUD LORS DE L'OPÉRATION. NE PAS TOUCHER. GARDEZ LES ENFANTS ET LES VÊTEMENTS LOIN DE L'ESPACE DÉSIGNÉ DE
L'INSTALLATION. LE CONTACT PEUT CAUSER DES BRÛLURES À LA PEAU. VOIR L'ÉTIQUETTE ET LES INSTRUCTIONS.
Opérez cet appareil avec le
couvercle de la trémie fermé. Le défaut de ne pas suivre les instructions peut résulter, sous certaines conditions, en une combustion des émissions des produits venant de
la trémie. Ne pas remplir la trémie trop pleine.
ESPACES LIBRES MINIMUM DES MATÉRIAUX COMBUSTIBLES:
INSTALLATION DE L’ALCÔVE
Une hauteur minimum de l'alcôve:
43
in.(
1092mm)
Une hauteur minimum m
ur de côté
de l'alcôve:
6 in. (152mm)
Une épaisseur
minimum m
ur de côté
de l'alcôve:
40 in. (1016mm)
La profondeur maximum de l'alcôve:
36 in. (914mm)
Note 1: Dans les installations résidentielles, lorsque les pièces
TPVNT-MV, (dessus de l'adapteur de ventilation 3 in. - 3 in.) et
812-3570 (le ressaut de l'adapteur 3 in. - 6 in.), un tuyau
connecteur de 6 in. pour mur simple de calibre 24 peut être
utilisé.
Note 2: Pour l'installation dans les maisons préfabriquées,
lorsque les pièces TPVNT-MV, (dessus de l'adapteur de
ventilation 3 in. - 3 in.) et 812-3570 (le ressaut de l'adapteur 3
in. - 6 in.), utilisez un tuyau connecteur enregistré pour mur
double. Un assemblage d'air extérieur (pièce 811-0872), doit
être utilisé pour l'installation dans les maisons préfabriquées.
PROTECTION
DU SOL
Installez et le poêle doit être placé sur une assise non combustible s’étendant
tout autour de lui, comme les schémas l’indiquent. Mesurez la distance du
devant (K) de la surface de la porte vitrée.
*Un protecteur incombustible de plancher doit s'étendre sous le conduit de
cheminée pour une installation de ventilation horizontale ou sous un adapteur de
ventilation de dessus pour une installation verticale. CANADA - REQUIRENT.
A
B
G
G
D
E
F
C
C
A 2 in (51mm)
B 6 in. (152mm)
C 2 in. (51mm)
D 3 in. (76mm)
E 6 in. (152mm)
F 8 in. (203mm)
G 3 in. (76mm)
Appareil de chauffage inséré de combustible solide/de type de boulettes. Accepté dans l'installation dans les maisons
mobiles. Cet appareil a été testé et enregistré pour l'usage dans les Maisons Mobiles en accord avec OAR 814-23-9000
jusqu'à 814-23-909.
Testé à: ASTM E1509-04, ULC S627-00, ULC/ORD-C1482-M1990
Room Heating. Pellet Burning Type, (UM) 84-HUD POUR USAGE
AVEC LES BOULETTES DE BOIS. VOIR LE MANUEL DU
PROPRI
É
TAIRE POUR D’AUTRES OPTIONS DE CARBURANT.
OMNI-Test Laboratories, Inc. a déterminé que cet appareil se conforme avec la
norme de l’Association Canadienne de normalisation (CSA) B415.1 ainsi que le
Titre 40 du Code Fédéral de Régulations des États-Unis, partie 60, sous-partie
AAA. Accréditations OMNI-Test Laboratories : Le Conseil Canadien des Normes
(CCN/SCC), l’Institue des Standards Nationaux Américain (ANSI) et l’Agence de
Protection Environnemental (EPA).
Puissance de Rendement: 60,000 Btu's/hr
Puissance Électrique: 115 VAC, 60 Hz, Début 5 Amps, Courir 1.25 Amps
Éloignez le fil électrique de l'appareil. Ne pas faire passer le fil électrique au
dessus ou en dessous de l'appareil. Ne pas bloquer l’espace au dessous de
l’appareil.
DANGER:
Il y a risque de décharge électrique. Déconnectez le fil électrique de
la prise de contact avant le service.
Remplacez la vitre seulement avec une vitre céramique de 5 mm disponible
chez votre fournisseur.
Pour allumer, monter la température du thermostat au dessus de la température de
la pièce, le poêle s'allumera automatiquement. Pour éteindre, descendre la
température du thermostat en dessous de la température de la pièce. Pour des
instructions supplémentaires, référez vous au manuel du propriétaire. Gardez la
porte d'ouverture et la porte des cendres fermées hermétiquement durant l'opération.
I
nstallez et utilisez en accord avec les instructions
d'installation et d'opération du fabricant. Contactez le bureau
de la construction ou le bureau des incendies au sujet des
restrictions et des inspections d'installation dans votre
voisinage. Ne pas obstruez l'espace en dessous de l'appareil.
A
VIS - Pour Les Maisons Mobiles: Ne pas installer dans
une chambre à coucher. Un tuyau extérieur de combustion
d'air doit être installé et ne doit pas être obstrué lorsque
l'appareil est en usage. La structure intégrale du plancher, du
plafond et des murs de la maison mobile doit être
maintenue
intacte.
Référez vous aux instructions du fabricant et des codes locaux
pour les précautions requises pour passer une cheminée à
travers un mur ou un plafond combustibles, et les
compensations maximums.
Inspectez et nettoyez la cheminée fréquemment. Ne pas
connecter cet appareil à une cheminée servant un autre
appareil.
Utilisez systèm de ventilation "L" ou "P" diamètre 76mm ou
102mm.
PRÉVENTION DES FEUX DE MAISON
PREVENT HOUSE FIRES
Install and use only in accordance with manufacturer's installation
and operating instructions. Contact local building or fire officials
about restrictions and inspection in our area.
WARNING - FOR MOBILE HOMES:
Do not install
appliance in a sleeping room. An outside combustion air inlet must
be provided. The structural integrity of the mobile home floor,
ceiling and walls must be maintained.
Refer to manufacturer's instructions and local codes for
precautions required for passing chimney through a combustible
wall or ceiling. Inspect and clean vent system frequently in
accordance with manufacturer's instructions.
DO NOT CONNECT THIS UNIT TO A CHIMNEY SERVING
ANOTHER APPLIANCE.
Use a 3 in. or 4 in. diameter type "L" or "PL" venting system.
I*
J
J
K
I* = 2 in. (51mm)
J = 2 in. (51mm)
K = 6 in. (152mm)
G
G
D
E
F
C
C
A
B
2013
2014
2015
JAN FEB MAR APR MAY JUN
JULY AUG SEPT OCT NOV DEC
Mt. Vernon Pellet
Stove AE
Report / Rapport
061-S-68-6
ALCOVE INSTALLATION:
Min. Alcove Height:
43 in. (
1092mm)
Min. Alcove Side Wall:
6 in. (152mm)
Min. Alcove Width:
40 in. (1016mm)
Max. Alcove Depth:
36 in. (914mm)
A 2 in (51mm)
B 6 in. (152mm)
C 2 in. (51mm)
D 3 In (76mm)
E 6 in (152mm)
F 8 in.(203mm)
G 3 in. (76mm)
MINIMUM CLEARANCES TO COMBUSTIBLE MATERIALS
FLOOR PROTECTION
Use a non-combustible floor protector, extending
beneath heater and to the front/sides/rear as indicated.
Measure front distance (K) from the surface of the
glass door.
I* = 2 in. (51mm)
J = 2 in. (51mm)
K = 6 in. (152mm)
I*
J
J
K
Note 1:
In residential
installations, when using
Parts TPVNT-MV, (3 in. - 3
in. Top Vent Adapter) and
812-3570 (3 in. - 6 in. Offset
Adapter), 24 gauge 6 in.
single wall flue connector
may be used.
*
Non-combustible floor protection must extend beneath the
flue pipe when installed with horizontal venting or under the
Top Vent Adapter with vertical installation. RECOMMENDED
IN USA
SERIAL NO.
/
NUMÉRO DU
007001
Listed Solid Fuel Room Heater/Pellet
Type Stove.
Also suitable for Mobile
Home Installation. This appliance has
been tested and listed for use in
Manufactured Homes in accordance with
OAR 814-23-9000 through 814-23-909.
Tested to: ASTM E1509-04, ULC S627-00,
ULC/ORD-C1482-M1990 Room Heating
Pellet Burning Type, (UM) 84-HUD FOR USE
ONLY WITH PELLETIZED WOOD. See Owner’s
Manual for other fuel options.
OMNI-Test Laboratories, Inc. has determined
that this appliance complies with Canadian
Standards Association (CSA) B415.1 and Title
40 of the U.S. Code of Federal Regulations, Part
60, SubPart AAA.OMNI-Test Laboratories
Accrediations: The Standards Council of
Canada, the American National Standards
Institute, and the U.S. Environmental Protection
Agency.
Input Rating: 60,000 Btu's/hr. Electrical
Rating:
115 VAC, 60 Hz, Start 5 Amps, Run
1.25 AMPS.
Route power cord away from unit. Do not route
cord under or in front of appliance. Do not obstruct
the space beneath the heater.
DANGER:
Risk of electrical shock.
Disconnect power supply before servicing.
Replace glass only with 5mm ceramic
available from your dealer. To start, set
thermostat above room temperature, the
stove will light automatically. To shutdown,
set thermostat to below room temperature.
For further instruction refer to owner's
manual.
Keep viewing and ash removal
doors tightly closed during operation.
DO NOT REMOVE THIS LABEL
NE PAS ENLEVER L’
É
QUETTE
7034-107E
Note 2: In manufactured home
installation, when using Part
TPVNT-MV, (3 in. - 3 in. Top Vent
Adapter) and 812-3570 (3 in. - 6 in.
Offset Adapter), use listed double
wall flue connector. An Outside Air
Kit (Part 811-0872), must be used
with manufactured home installation.
1445 Highway North,
Colville, WA 99114
www.quadrafire.com
Manufactured by / Fabriqu
é
par:
O-T L
Tested and
Listed by
Portland
Oregon USA
OMNI-Test Laboratories, Inc.
CUS
Made in U.S.A. of US and
imported parts.
Fabriqué aux États-Unis-d’Amérique
par des pièces d’origine américaine
et pièces importées.
Serial No.
Model
Name
TestLab&
Report No.
Mfg.Date
SAMPLE
A. Congratulations
Hearth&HomeTechnologieswelcomesyoutoourtradition
of excellence! In choosing a Quadra-Fire appliance, you
haveourassuranceofcommitmenttoquality,durability,and
performance.
This commitment begins with our research of the market,
including ‘Voice of the Customer’ contacts, ensuring we
makeproductsthat will satisfy your needs. Our Research
and Development facility then employs the world’s most
advanced technology to achieve the optimum opera-
tionof ourstoves,insertsand replaces.Andyet we are
old-fashioned when it comes to craftsmanship. Each unit
ismeticulouslyfabricatedandgoldandnickelsurfacesare
hand-nishedforlastingbeautyandenjoyment.Ourpledge
to quality is completed as each model undergoes a quality
control inspection.
Wewishyouandyourfamilymany yearsofenjoymentin
the warmth and comfort of your hearth appliance. Thank
you for choosing Quadra-Fire.
NOTE: Clearances may only be reduced by means
approved by the regulatory authority having jurisdiction
and Welcome to the Quadra-Fire Family!
January 29, 2014 7034-276 3
MT. VERNON AE
TABLE OF CONTENTS
Safety Alert Key:
• DANGER! Indicates a hazardous situation which, if not avoided willresultindeathorseriousinjury.
• WARNING! Indicates a hazardous situation which, if not avoided mayresultindeathorseriousinjury.
• CAUTION! Indicates a hazardous situation which, if not avoided, mayresultinminorormoderateinjury.
• NOTICE: Indicates practices which may cause damage to the appliance or to property.
A. Congratulations..................................................................2
B.SampleofSerialNumber/SafetyLabel............................2
C. Warranty Policy .................................................................4
1 Listing and Code Approvals ..............6
A.ApplianceCertication ......................................................6
B.BTU&EfciencySpecications........................................6
C.GlassSpecications .........................................................6
D. Electrical Rating................................................................6
E.MobileHomeApproved .................................................... 6
2 Operating Instructions .......................7
A. Fire Safety .........................................................................7
B.Non-CombustibleMaterials ...............................................7
C.CombustibleMaterials ......................................................7
D.FuelMaterialandFuelStorage ........................................7
E. GeneralOperatingInformation .........................................8
F.BeforeYourFirstFire ........................................................9
G. Filling the Hopper with Fuel ...............................................9
H. Starting Your First Fire .....................................................9
I.FireCharacteristicsandFlameHeightAdjustment ............9
J. Clear Space.......................................................................10
K. Ignition Cycles ...................................................................10
L.FrequentlyAskedQuestions .............................................12
3 Wall Control Operating Instructions 13
A. Introduction .......................................................................13
B.LanguageSelection ..........................................................13
C.TheMainScreen ..............................................................13
D.GeneralInformationAboutUsingtheWallControl ...........14
E.TheMainMenu .................................................................14
F.QuickStartGuide ...............................................................18
G. Service Information ..........................................................20
H. Error Codes .......................................................................20
I.BatteryBack-upSystem(Optional) ....................................20
4 Maintenance and Service.................21
A. Proper Shutdown Procedure ............................................21
B.QuickReferenceMaintenanceChart................................21
C.GeneralMaintenanceandCleaning .................................22
D. Soot or Creosote Fire .......................................................26
E.HighAshFuelContentMaintenance .................................26
5 Troubleshooting Guide ....................27
6 Service Parts Replacement .............28
A.GlassReplacement-DoorAssembly ...............................28
B.BafeRemoval ................................................................28
C.ConvectionBlowerReplacement .....................................29
E.Combustion(Exhaust)BlowerReplacement ....................29
7 Reference Materials..........................30
A. Component Functions .......................................................30
B.ComponentLocations ........................................................32
C. Exploded Drawings............................................................33
D. Service Parts List...............................................................34
4 7034-276 January 29, 2014
MT. VERNON AE
Page 54 7022-122 January 19, 2011
R
Castile Pellet Insert
4
021-645C 12-29-10 Page 1 of 2
Hearth & Home Technologies Inc.
LIMITED LIFETIME WARRANTY
H
earth & Home Technologies Inc., on behalf of its hearth brands (”HHT”), extends the following warranty for
H
HT gas, wood, pellet, coal and electric hearth appliances that are purchased from an HHT authorized dealer.
W
ARRANTY COVERAGE:
H
HT warrants to the original owner of the HHT appliance at the site of installation, and to any transferee taking ownership
o
f the appliance at the site of installation within two years following the date of original purchase, that the HHT appliance
w
ill be free from defects in materials and workmanship at the time of manufacture. After installation, if covered compo-
n
ents manufactured by HHT are found to be defective in materials or workmanship during the applicable warranty period,
H
HT will, at its option, repair or replace the covered components. HHT, at its own discretion, may fully discharge all of its
o
bligations under such warranties by replacing the product itself or refunding the verified purchase price of the product
i
tself. The maximum amount recoverable under this warranty is limited to the purchase price of the product. This warranty
i
s subject to conditions, exclusions and limitations as described below.
W
ARRANTY PERIOD:
W
arranty coverage begins on the date of original purchase. In the case of new home construction, warranty coverage
begins on the date of first occupancy of the dwelling or six months after the sale of the product by an independent,
a
uthorized HHT dealer/ distributor, whichever occurs earlier. The warranty shall commence no later than 24 months
f
ollowing the date of product shipment from HHT, regardless of the installation or occupancy date. The warranty period fo
r
parts and labor for covered components is produced in the following table.
T
he term “Limited Lifetime” in the table below is defined as: 20 years from the beginning date of warranty coverage for
g
as appliances, and 10 years from the beginning date of warranty coverage for wood, pellet, and coal appliances. These
t
ime periods reflect the minimum expected useful lives of the designated components under normal operating conditions.
See conditions, exclusions, and limitations on next page.
Parts Labor Gas Wood Pellet EPA
Wood Coal Electric Venting
XXXXXXX
All parts and material except as
covered by Conditions,
Exclusions, and Limitations
listed
XXX Igniters, electronic components,
and
g
lass
XXXXX Factor
y
-installed blowers
X Molded refractor
yp
anels
X Fire
p
ots and burn
p
ots
5
y
ears 1
y
ear X X Castin
g
s and baffles
7 years 3 years X X X Manifold tubes,
HHT chimne
y
and termination
10
y
ears 1 year X Burners, logs and refractory
Limited
Lifetime 3 years X X X X X Firebox and heat exchanger
XXXXXXX All replacement parts
be
y
ond warrant
yp
eriod
Warranty Period HHT Manufactured Appliances and Venting
1 Year
Components Covered
3 years
2 years
90 Days
C. Warranty Policy
January 29, 2014 7034-276 5
MT. VERNON AE
R
January 19, 2011 7022-122 Page 55
Castile Pellet Insert
4021-645C 12-29-10 Page 2 of 2
WARRANTY CONDITIONS:
 

 
 


 

This warranty is void if:
 


 
 

LIMITATIONS OF LIABILITY:
 







WARRANTY EXCLUSIONS:

 

 

 
-

 -

 

-







 
 
 -
-


6 7034-276 January 29, 2014
MT. VERNON AE
EPACertied: 4.16 grams per hour
Efciency: 81.4% - 83.6%
EPA BTU Output: 14,620-52,460/hr
Heating Capacity: 2,400 - 3,800 square feet
depending on climate zone
Vent Size: 3” or 4” Type “L” or “PL”
Fuels: Pellets, Shelled Field Corn,
WheatandBlackSunower
Seeds
Shipping Weight: 429lbs
*BTUwillvary,dependingonthetypeoffuelyouuseinyour
appliance.ConsultyourQuadra-Firedealerforbestresults.
C.GlassSpecications
This stove is equipped with 5mm ceramic glass. Replace
glass only with 5mm ceramic glass. Please contact your
dealer for replacement glass.
D. Electrical Rating
115 VAC, 60 Hz, Start 5 Amps, Run 1.25 Amps
Model Mt.VernonPelletStove
Laboratory OMNITestLaboratories,Inc.
Report No. 061-S-68-6
Type SolidFuelRoomHeater/PelletFuel
BurningType
Standard ASTME1509-04,ULCS627-00and
ULC/ORD-C1482-M1990RoomHeater
PelletFuelBurningtypeand(UM)
84-HUD,MobileHomeApproved.
FCC Complies with Part 15 of FCC Rules.
Operationissubjecttothefollowing
twoconditions:(1)thisdevicemaynot
causeharmfulinterference,and(2)this
device must accept any interference
received, including interference that may
cause undesired operation.
• Installationanduseofanydamagedappliance.
• Modicationoftheappliance.
• Installation other than as instructed by Hearth & Home
Technologies.
• Installationand/oruseofanycomponentpartnotapprovedby
Hearth&HomeTechnologies.
• Operatingappliancewithoutfullyassemblingallcomponents.
• Operatingappliancewithoutlegsattached(ifsuppliedwithunit).
• DoNOTOverre-Ifapplianceorchimneyconnectorglows,
youareoverring.
Anysuchactionthatmaycausearehazard.
1 Listing and Code Approvals
A.ApplianceCertication
NOTE:Hearth&HomeTechnologies,manufacturerof
this appliance, reserves the right to alter its products, their
specicationsand/orpricewithoutnotice.
NOTICE: This installation must conform with local codes. In
theabsenceoflocalcodesyoumustcomplywiththeASTM
E1509-04, ULC S627-00, (UM) 84-HUD and ULC/ORD-
C-1482.
Improper installation, adjustment, alteration, service or
maintenancecancauseinjuryorpropertydamage.
Forassistanceoradditionalinformation,consultaqualied
installer, service agency or your dealer.
Quadra-FireisaregisteredtrademarkofHearth&Home
Technologies.
WARNING
FireRisk.
Hearth&HomeTechnologiesdisclaimsany
responsibilityfor,andthewarrantywillbe
voidedby,thefollowingactions:
B.BTU&EfciencySpecications
E. Mobile Home Approved
• Thisapplianceisapprovedformobilehomeinstalla-
tions when not installed in a sleeping room and when
anoutsidecombustionairinletisprovided.
• Thestructuralintegrityofthemobilehomeoor,ceil-
ing,andwallsmustbemaintained.
• The appliance must be properly grounded to the
frameofthemobilehomeanduseonlyListedpellet
vent Class “L” or “PL” connector pipe.
• OutsideAirKit,partOAK-ACCmustbeinstalledina
mobilehomeinstallation.
January 29, 2014 7034-276 7
MT. VERNON AE
User Guide
2 Operating Instructions
A. Fire Safety
To provide reasonable re safety, the following should be
given serious consideration:
• InstallatleastonesmokedetectorandCO monitor on each
oorofyourhome.
• Locatedetectorsawayfromtheheatingapplianceandclose
to the sleeping areas.
• Follow the detector’s manufacturer’s placement and
installation instructions and maintain regularly.
• ConvenientlylocateaClassAreextinguishertocontend
withsmallres.
• Intheeventofahopperre:
• Evacuatethehouseimmediately.
• Notifyredepartment.
B. Non-Combustible Materials
Materialwhichwillnotigniteandburn,composedofany
combinationofthefollowing:
- Steel - Plaster
 -Brick   -Iron
- Concrete - Tile
- Glass - Slate
MaterialsreportedaspassingASTM E 136, Standard
Test Method for Behavior of Metals, in a Vertical Tube
Furnace of 750° C.
C. Combustible Materials
Materialmadeof/orsurfacedwithanyofthefollowing
materials:
- Wood - Compressed Paper
 -PlantFibers  -Plastic
 -Plywood/OSB  -SheetRock(drywall)
Anymaterialthatcanigniteandburn:ameproofedornot,
plastered or un-plastered.
D. Fuel Material and Fuel Storage
Pelletfuelqualitycangreatlyuctuate.This appliance has
beendesignedtoburnawidevarietyoffuels,givingyouthe
choice to use the fuel that is most economical in your region.
Hearth&HomeTechnologiesstronglyrecommendsonlyusing
PelletFuelInstitute(PFI)certiedfuel.
FuelMaterial
• Madefromsawdustorwoodby-products
• Shelledeldcorn&otherbiomassfuels
• Dependingonthesourcematerialitmayhaveahighor
low ash content.
HigherAshContentMaterial
• Hardwoodswithahighmineralcontent
• Fuelthatcontainsbark
• Standardgradepellets,highashpellets,cornandother
biomassfuels
LowerAshContentMaterial
• Softwoods
• Fuelswithlowmineralcontent
• Premiumgradepellets
Shelled Field Corn
• Mustbe15%orlessmoisturecontent.
• Mustbecleanandfreefromdebris
• Neverburncornstraightfromtheeld
• Stalkparts,excessivenesandcobremnants,etc.willclog
the auger mechanism
• Cornwithexcessivegraindustmustbescreened bysifting
with3/16inch(4.7mm)meshscreening
CAUTION! Do not burn fuel that contains an additive;
(such as soybean oil).
• Maycausehopperres
 • Damagetoproductmayresult
Readtheingredientslistonthepackage.Ifyouarebuying
cornorwheattheonlyingredientthatshouldbelistedis
cornorwheat.
WARNING! Risk of Chemical Poisoning!
DoNOTburntreatedseedcorn
 •Chemicalpesticidesareharmfulorfatalifswallowed
 •Burningtreatedseedcornwillvoidyourwarranty
Clinkers
Mineralsandothernon-combustiblematerialssuchassand
willturnintoahard,glass-likesubstancecalledaclinkerwhen
heatedintherepot.
Trees from different areas will vary in mineral content. That
iswhysomefuelsproducemoreclinkersthanothers.
Moisture
Alwaysburndryfuel.Burningfuelwithhighmoisturecontent
takes heat from the fuel and tends to cool the appliance,
robbingheatfromyourhome.Damppelletfuelcanclogthe
feed system.
FireRisk.
WARNING
• Donotoperateappliancebeforereadingand
understanding operating instructions.
• Failuretooperateapplianceproperlymaycause
ahousere.
8 7034-276 January 29, 2014
MT. VERNON AE
HOT WHILE IN OPERATION. KEEP CHILDREN, CLOTHING
AND FURNITURE AWAY. CONTACT MAY CAUSE SKIN
BURNS.
CAUTION
Size
•
Pelletsareeither1/4inchor5/16inch(6-8mm)indiameter
• Lengthshouldbenomorethat1-1/2inches(38mm)
• Pellet lengths can vary from lot to lot from the same
manufacturer
• Duetolengthvariations,theameheight(feedrate)may
needadjustingoccasionally.Seepage 9 for instructions.
Performance
• Higherashcontentrequirestheashdrawertobeemptied
more frequently
• Hardwoodsrequiremoreairtoburnproperly
• Setwallcontrolto“UtilityPellet”iftherepotandashpan
arellingquickly.Thiswillcausetheauto-cleansystem
toemptytherepotmoreoften.
• Premiumwoodpelletsproducethehighestheatoutput.
• Burningpelletslongerthan1-1/2inches(38mm)cancause
an inconsistentfuelfeedrateand/ormissedignitions.
Werecommendthatyoubuyfuelinmulti-tonlotswhenever
possible.However,wedorecommendtryingvariousbrands
beforepurchasingmulti-tonlotstoensureyour satisfaction.
CAUTION! Testedandapprovedforwoodpellets,shelled
eldcorn,wheatandblackoilsunowerseeds.Burningof
anyothertypeoffuelvoidsyourwarranty.
Changing to Different Fuel Type
• Empty the hopper of the previous fuel
•
Thoroughlyvacuumhopperbeforellingwiththenewfuel
• SelecttheappropriatesettingontheFUELSELECTION
screen on the thermostat wall control
The burn rate, BTU content and heat output will all vary
depending on the fuel selected.
Storage
• Woodpelletsshouldbeleftintheiroriginalsealedbaguntil
usingtopreventmoistureabsorption.
• Shelledcorn,wheatorsunowerseedsshouldbestoredin
atightcontainertopreventitfromabsorbingmoisturefrom
damporwetoors.
• Thiswillalsopreventrodentsfrombecomingaproblem
.
• Donotstoreanypelletfuelwithintheclearancerequirements
or in an area that would hinder routine cleaning and
maintenance.
E. General Operating Information
1. Thermostat Wall Control - Automatic Setting
The appliance is like most modern furnaces; when the
thermostat wall control calls for heat, your appliance will
automatically light and deliver heat.
When the room is up to temperature and the wall control is
satisedtheappliance will shut down.
Intheautomaticsettingtheheatoutputleveliscontrolledby
thewallcontrol.Select“Automatic”ontheAUTO/MANUAL
screen. Figure 8.1.
2. Thermostat Wall Control - Manual Setting
Whenyouselect“Manual”ontheAUTO/MANUALscreenthe
appliance will still automatically turn on and off according to
the temperature setting.
However,youwillbeabletomanuallycontroltheheatoutput
levels. Adjust the heat output levels by using the HEAT
OUTPUTLEVELscreen.Figure 8.2.
AUTO/MANUAL SETTINGS
Automatic
Manual
Off
Medium High
3. Auto-Clean Firepot System
Yourapplianceisequippedwithanautomaticrepotcleaning
systemthatwillchangethefrequencyofcleaningbasedon
thefuelbeingburned.
The auto-clean system will clean itself immediately on initial
plug in. If there is a power outage, as soon as power is
restoreditwillrecycleandcleanitselfifthereisnoreinthe
repot.
NOTE:Userisresponsiblefor removingthe ashfromthe
ash drawer.
Figure 8.1
Figure 8.2
Read and understand Section 3: Thermostat Wall
ControlOperatingInstructionsfordetailedoperating
instructions. The wall control is an integral part of how to
operate this appliance.
Testedandapprovedforwoodpellets,shelledeldcorn,
wheatandblackoilsunowerseeds.Burningofany
other type of fuel voids your warranty.
CAUTION
January 29, 2014 7034-276 9
MT. VERNON AE
3. Automatic or Manual Setting
Theautomaticsettingwillcontroltheheatoutputbasedon
the comfort level selection. The manual setting allows you
to manually control the heat output settings. See page 27,
Ignition Cycles.
NOTE: See the Wall Control Thermostat manual for
detailed instructions.
I. Fire Characteristics and Flame Height
Adjustment
(FeedRate)Aproperlyadjustedrewillhaveanactive
amepatternandtheamewillriseandfallsomewhat.
This is normal.
• OnHIGHsetting,theamewillextendapproximately8
inches(203mm)outoftherepot.Ifitisnot8inches
(203mm)tall,increasetheameheight.
• OnMEDIUMorLOWsettingtheamewillbeshorter.
• Reducetheameheightiftherehastallameswith
blacktailsandseemssomewhatlazy.Thismayalso
indicatethattherepotand/orheatexchangerneeds
tobecleaned.RefertoSection 4forMaintenanceand
Cleaning Instructions.
AdjustingtheFlameHeight(FeedRate)
• Setyourapplianceto“MANUAL”modeonthewallcon-
trol.
• SettheheatoutputleveltoHIGH.
• Adjusttheameheightusingthe“FLAMEHEIGHTAD-
JUST” screen on the wall control. Figure 9.3.
F. Before Your First Fire
• First,makesureyourappliancehasbeenproperlyinstalled
andthatallsafetyrequirementshavebeenmet.
• Payparticularattentiontothereprotection,ventingand
thermostat wall control installation instructions.
• Doublecheckthattheashpan,hopperandreboxare
emptyandthenclosethereboxdoor.
NOTICE:
Thetipofthermocouplemustbeincontactwiththe
inside end of the thermocouple cover or missed ignitions can
occur.
G. Filling the Hopper with Fuel
• Checkthehopperandmakesureitisemptybeforelling
with fuel.
• Openthecasttophopperlid.
• Donotoverllthehopper.Thehopperlidmustbecom-
pletely closed to maintain proper vacuum and for the
feedmotortooperate.AnerrorICONwillappearonthe
wall control if the hopper lid is not properly closed.
• Donot leave anypartof the fuelbagon the appliance
afterllinghopper.
H. Starting Your First Fire
1. Fuel Selection
Tostartyourrstre,youmust:
• Select the appropriate fuel on the FUEL SELECTION
screen on the thermostat wall control to match the fuel
youhavechosentoburn.
• Iftheproper fuelis notselected yourappliance willnot
operate properly.
• Forexample,ifyouhaveselectedwoodpelletsandyou
areburningcorn,theappliancemaynotlight,itmaygo
out or overfeed. Figure 9.1.
NOTE: Ifyouarelightingyourapplianceforthersttime:
• Thefeedtubewillbeemptyand itcantakesometimeto
llitwithfuelbeforeyouwillseeare
• Putahandfuloffuelintherepot(priming)tospeedup
the process. You can also do this when you have run
completely out of fuel.
Sunflower Seeds
Corn
Utility Pellet
Softwood Pellet
Wheat
Hardwood Pellet
DONE SELECT
FUEL SELECTION
2. Comfort Level Selection
Onceyourfuelisselected,selectthetemperatureatthedesired
settingontheSETCOMFORTLEVELscreen.Figure 9.2.
Figure 9.2
Figure 9.1
74ºF
Figure 9.3
10 7034-276 January 29, 2014
MT. VERNON AE
J. Clear Space
WARNING! RISK OF FIRE! DoNOTplacecombustible
objectsinfrontoftheappliance.Hightemperaturesmay
igniteclothing,furnitureordraperies.Maintainaminimum
clearanceof3feet(914mm)infrontofappliance.
Mantel:
Avoid placing candles and other heat-sensitive
objectsonmantelorhearth.Heatmaydamagethese
objects.
NOTICE: Clearancesmayonlybereducedbymeansap-
provedbytheregulatoryauthorityhavingjurisdiction.
WARNING! RISK OF FIRE! Keepcombustiblematerials,
gasolineandotherammablevaporsandliquidsclearof
appliance.
• DoNOTstoreammablematerialsintheappliance’s
vicinity.
 DONOTUSEGASOLINE,LANTERNFUEL,KEROSENE,
CHARCOALLIGHTERFLUIDORSIMILARLIQUIDSTO
STARTOR“FRESHENUP”AFIREINTHISHEATER.
• DONOTBURNGARBAGEORFLAMMABLEFLUIDSSUCH
ASGASOLINE,NAPHTHAORENGINEOIL.
• DONOTUSECHEMICALSOFFLUIDSTOSTARTTHEFIRE.
Keepallsuchliquidswellawayfromtheheaterwhileitisin
useascombustiblematerialsmayignite.
K. Ignition Cycles
Theapplianceengineiscontrolledbythedigitalthermostat
wall control. The digital display on the wall control will tell
you what your appliance is doing in the upper left corner
(SystemStatus).Figure 10.1.
Every time the thermostat calls for heat, the appliance steps
throughvecycles:
1 Start-Up Cycle 4 Shutdown Cycle
2 Soft-Start Cycle 5 Auto-Clean Cycle
3 Heating Cycle
Thedurationandcharacteristicsofthesecyclesmaybedif-
ferent with each type of fuel selected.
Figure 10.1
WARNING! RISK OF FIRE!
DoNOToperateappliance:
• Withappliancedooropen
• Withrepotooropen
• Withashpanremoved
1. Start-Up Cycle
During this cycle:
• Igniter turns on for 90 seconds to heat up the air in the
repot
• Combustionblowerstarts
• Vacuum switch comes on
• Feedmotorturnsonaddingfueltotherepotandthe
appliancewaitsfortheretostart
The duration of start-up depends on the type and quality of
fuelused.Itisnormaltoseesomesmokeduringtheigni-
tion process as moisture evaporates and the fuel lights. The
smokewillstoponcetherestarts.
2. Soft Start Cycle (SS-Low / SS-Med)
Oncethereislit:
• The appliance moves into the low soft-start cycle as it
continuestobuildthere
• Morefuelwillbeadded
• Astherebuilds,theappliancewillchangetomedium
soft-start mode
• Theheatingcyclebegins
3. Heating Cycle ( Auto / Man - L, ML, M, MH, H)
Thereare two choices in theAutomatic / Manual menu of
how your appliance will operate:
Automatic Mode
• The wall control will turn the heat output level up or down
depending on how far the room temperature is from the
desired temperature
• ThedigitaldisplaywillreadAUTO:M,i.e.automatic-medi-
um level
• As the room temperature approaches the desired tem-
perature, the appliance will turn down to lower settings
• Whenthehomereachesyoursettemperature,theappli-
ance will go into the shutdown cycle
January 29, 2014 7034-276 11
MT. VERNON AE
Manual Mode
• Set the heat output setting from the main screen
• TherightbottombuttonwillreadHEATOUTPUT
• Youcanoperatetheappliancefromanyofthe5levels
• Onthelowestlevel(MAN:L)theappliancewillstayon
longer,burnlessfuelperhour,andwilltakelongerto
bringthehomeuptoyourdesiredtemperature
• Onthehighestsetting(MAN:H)theappliancewillburn
morefuelperhour,andbringyourhomeuptotempera-
turemorequickly
•
InManualmodetheheatoutputdoesnotchangebutwill
stay at the setting you chose until the comfort level is
reached (meaning the thermostat has been satised).
TurntoOFFtostopoperation.
4. Shutdown Cycle
Onceyourhomehasreachedyoursettemperature:
• Appliancewillstopfeedingfuelandallowretodiminish
• Convectionblowerwillcontinuetorununtiltheappliance
cools to appropriate temperature
• Appliancewillbegintheauto-cleancycle
5. Auto-Clean Cycle
Therepotauto-cleansystemwillcycle:
• Whentheapplianceisrstpluggedin
• When the house reaches temperature and the appliance
shuts down
• Atprescribedintervals,dependingonthetypeoffuelse-
lected
• Whenstartingupafteranelectricalinterruption
If your appliance is running and the auto-clean cycle is initi-
ated, the appliance will revert to shutdown cycle.
• Theooroftherepotwillopenanddumptheashinto
the ash pan
• It takes approximately 2 minutes to complete the au-
to-clean cycle
• Theoorwillthenshut,andifthethermostatisstillcalling
forheat,therewillstartagain
• Duringthisauto-cleancycle,theconvectionblowermay
continuetorun.Thecombustionblowerwillcontinueto
run.
Additional Screen Messages:
READY It is telling you that the home is up to temperature
anddoesn’tneedanyheat.
- - - - - The screen will show 5 dashes when the wall
controlandthecontrolboardareNOTcommunicatingwith
eachother.Checkthatthewiringonthethermostatisprop-
erly connected.
MAINTENANCE BURN This indicates the appliance is
operating on battery backup, prior to the auto-clean.  The
maintenanceburnwillkeepthesystemfromshuttingdown
as the appliance will not automatically re-light in battery
back-upmode.
OFF TheAUTO/MANUALSETTINGscreenhasbeenset
toOFF.SettheappliancetoOFFwhenperformingperiodic
maintenance to prevent an unexpected startup.
BLANK SCREEN TheON/OFFswitchmaybeinOFF
position or make sure electrical power is supplied to the
appliance.TurntoONposition.
WARNING
FireRisk
DoNOToperateappliance:
• Withappliancedooropen.
• Withrepotooropen.
DoNOTstorefuel:
• Closerthanrequiredclearancestocom-
bustiblestoappliance.
• Withinspacerequiredforloadingorash
removal.
12 7034-276 January 29, 2014
MT. VERNON AE
L. Frequently Asked Questions
ISSUES SOLUTIONS
1. Metallicnoise 1. Noiseiscausedbymetalexpandingandcontractingas
it heats up and cools down, similar to the sound pro-
ducedbyafurnaceorheatingduct.Thisnoisedoesnot
affect the operation or longevity of your appliance.
2. Ashbuild-uponglass 2. This is normal. Clean the glass.
3. Glass has turned dirty 3. Excessivebuildupofash.Thelowerburnsettingswill
producemoreash,thehigherburnsettingsproduce
less.Themoreitburnsonlowthemorefrequentclean-
ing of the glass is required.
4. Firehastallameswithblacktailsandislazy 4. Theameheightadjustmentneedstobereducedor
therepotneedscleaning.Heatexchangerorexhaust
blowerneedscleaning.
5. Excessivesmokeystart-up 5. Eithertherepotisdirtyorthereistoomuchfuelat
start-up and not enough air.
6. Largeameatstart-up 6. Thisisnormal.Flamewillsettledownoncethereis
established.Somesmokeisnormal.
7. MechanicalNoise 7. Theooroftherepotintheauto-cleansystemmay
makesomenoiseasitscrapestheashintotheash
pan.
Contact your dealer foradditionalinformationregardingoperationandtroubleshooting.
Visitwww.quadrare.comtolocateadealer.
Odorsandvaporsreleasedduringinitialoperation.
• Curingofhightemperaturepaint.
• Openwindowsforaircirculation.
Odorsmaybeirritatingtosensitiveindividuals.
CAUTION
January 29, 2014 7034-276 13
MT. VERNON AE
A. Introduction
Welcome to the Quadra-Fire family. This manual will help
you understand and operate the wall control attached to
your new pellet appliance.
TheQuadra-Fire WallControl is not just a traditionalther-
mostat,butanintegralpartofthepelletappliancesystem.
While it has many of the features one would expect from
an advanced thermostat, including programmable setback
capabilitiesandcurrenttemperaturedisplay,italsoindicates
thesystem’scurrentoperatingcycleandstate.Itdoesthis
bycommunicatingwiththeapplianceviaawiredconnection.
Additionally, it allows you to set parameters that will optimize
the performance of your pellet appliance system. These pa-
rameters are accessed with an easy to navigate menu sys-
tem.
B. Language Selection
The language selection function is under the USER
SETTINGS found on pages 17. Please refer to that
section for complete detailed instructions.
C. The Main Screen
Thekeytobeingcomfortablewhileoperatingyournewwall
control is to familiarize yourself with the main screen. The
main screen shows, at a glance, the status of the system,
the most important settings and the current temperature. Ad-
ditionally, the main screen indicates with simple icons many
useractionsrequiredtokeepyourapplianceworkingasin-
tended. Figure 13.1.
READY
73
Set at: 73
12:30 PM
HEAT OUTPUT
MENU
Current Time
System Status
Current Set
Temperature
Current
Temperature
Function Labels for the Function Buttons
Notifications
Icons
Figure 13.1
Figure 13.2
1. System Status Codes
The status area is used to indicate the current status of the
system. It indicates if the system is running in automatic or
manual cycle, if it is turned on or off and where it is in the
operating sequence.
a. START-UP
Indicates that the appliance is in start-up cycle and is in
the process of lighting an initial charge of fuel.
b. SS-LOW or SS-MED (SS = soft start)
Indicates the soft-start portion of the lighting sequence. In
thesestagestherebeginstograduallybuildtooperating
temperature.
c. AUTO: (x) or MAN: (x) (x) = heat output level
Indicatesboththeoperatingcycle(automaticormanual)
and the current heat output level. The heat output level
willbe“H”high,“MH”mediumhigh,“M”medium,“ML”me-
dium low and “L” low.
d. READY
Indicates that the system is turned on and is functioning
normally,butthereisnocallforheat(theroomtempera-
tureisnotbelowthesettemperature).
e. SHUTDOWN
Indicates the system is shutting down, either because it
is no longer calling for heat or the maximum burn time
hasbeenreachedandthesystemmustrunanauto-clean
cycle.
f. AUTO-CLEAN
Indicatesthesystemisrunningtherepotauto-cleancy-
cle.
g. OFF
Indicatesthesystemhasbeenshutdownbytheuser.
h. MAINT BURN (Battery Back-up Only)
Themaintenanceburnistokeepthesystemfromshutting
downwhenoperatingonbatterybackup.Theappliance
willnotautomaticallyre-lightinbatteryback-upmode.
2. Current Time
Indicates the current time. The time is used for the program-
mablesetbackfeaturesofthewallcontrol.
3. Set Temperature
Indicates the current set temperature. It will change auto-
matically as the control progresses through the 7 day set-
backprogram.IfthewallcontrolisinHOLDTEMPcyclethe
13 Volts 12 Volts 11 Volts Battery
Below
10 Volts
HopperLidOpen DoorOpen Low Fuel
Fully Charged 2/3Charge 1/3Charge No Charge
OperatingonOptionalBatteryBackup
3 Wall Control Operating Instructions
14 7034-276 January 29, 2014
MT. VERNON AE
Auto/Manual/Off
User Settings
Fuel Type
MENU
Set Comfort Level Program
Set Date
Service Info
MENU
Set Day/Time
Figure 14.1
“Set at:” indication will change to “Hold at:” and displays the
operating temperature setting.
4.NoticationIcons
The system notication area uses icons to indicate if an
action needs to be taken. In battery mode it indicates the
approximatechargelevelofthebattery.5. Function But-
tons
Thefunctionbuttonshavetwolabelsabovetheminthedis-
playarea.Theirlabelscanchangedependingonthemenu
screen.Onthemainscreentheleftbuttonwillbringupthe
systemmenu and therightbutton has functionalityonlyin
MANUALcycle.Figure 14.2.
5. Current Temperature
The current temperature area indicates the temperature of
the room where the wall control is located. The tempera-
turedisplayedcanbeinunitsofFahrenheitorCelsius.The
desired units can be selected via the system menu.  See
Figure 6.5 on page 6.
D. General Information About Using the Wall
Control
Whenabuttonispressedandthescreenchangesfromthe
mainscreentooneoftheotherscreens,thebacklightwillil-
luminatethedisplayarea.Asbuttonsarepressed,theback-
lightcontinuestobeilluminated.
Most screens have a DONE button which can be used to
return to the previous screen ultimately returning to the main
screen.
Thewallcontrolwillautomaticallyrevertbacktothestarting
screen if there is no activity for 15 seconds except for the
COMFIRMFUELCHANGEscreen.Themainscreenwillbe
illuminated for an additional 10 seconds and the backlight
will shut off.
Ifthewallcontrolissubjectedtoastaticshock,thescreen
maygoblank.Ifthishappens,wait25secondsandpress
anybutton. This will reset the screenrestorefunctionality
andturnonthebacklight.Ifthisdoesnotwork,callyour
dealer.
E. The Main Menu
The menu is the heart of customizing the operation of the
pelletappliancesystemtoyourpersonalliking.Thechoices
on this menu are:
1. Set Comfort Level (Temperature)
The most basic operation of the wall control is to turn the
appliance on or off depending on the requirement for heat.
Fromthemainscreen,theSETCOMFORTLEVELscreen
canbeactivatedbypressingtheUPorDOWNbuttononthe
right side of the display area.
Thersttimeeitherbuttonispressedthedisplaychangesto
theSETCOMFORTLEVELscreenandshowsthecurrent
settemperature.SubsequentpressesorholdingtheUPor
DOWNbuttonwillchangethesettemperature. Figure 14.2.
You can override the programming either permanently or
temporarily.  The HOLDTEMP button (lower right) on the
SET COMFORT LEVEL screen is used to override preset
programming. Figure 14.3. BypressingtheHOLDTEMP
button,thecurrentsettemperaturewillpermanentlyoverride
anyprogrammedtemperatureinthe7daysetbackprogram-
ming. This is a convenient way of overriding a program when
your schedule changes temporarily and you don’t want to
reprogramthesetbackfunctionsonthewallcontrol.
Toreleasethepermanentoverride,pressthebuttonlabeled
RESUMEwhenintheHOLDTEMPcycle.Pressingthebut-
ton again will resume the programming at the next program
interval. Figure 14.4.
To temporarily override the programming, use the UP and
DOWNbuttonsonlyanddonotpresstheHOLDTEMPbut-
ton. The display will show how long the new temperature will
hold before it returns to the next scheduled programming.
Figure 14.3.
SET COMFORT LEVEL
ON HOLD
RESUME
DONE
74ºF
Figure 14.3
Figure 14.2
Function Buttons
Buttons
Up
Down
Figure 14.4
2. Auto / Manual / Off Selection
a. Automatic
IntheAUTOMATICcyclethewallcontrolwillturntheap-
pliance on and off automatically and also turns the heat
output level up or down depending on the temperature
setting. The further away the room temperature is from
the set temperature, the higher the heat output.
January 29, 2014 7034-276 15
MT. VERNON AE
b. Manual
InMANUALcycle,theheatoutputremainsthesame
regardlessofthedifferencebetweenthesetandroom
temperatures. The wall control will function as a simple
on/offthermostat.WhenthesystemissettoMANUAL
theHEATOUTPUTselectionisaddedinthelowerright
corner.
Pressthebuttonunderthisselection toaccess thisfea-
ture.TheHEATOUTPUTscreenisusedtosetthelevel
of heat produced whenever the wall control calls for heat.
Figure 15.3. TheHEATOUTPUTscreenisnotaccessible
inAUTOMATICcycle.
AUTO/MANUAL SETTINGS
Manual
Off
Automatic
Manual
Medium
AUTO/MANUAL SETTINGS
Automatic
Manual
Off
Figure 15.1
Figure 15.2
Figure 15.3
3. Fuel Type
TheFUELTYPEscreenisusedtoselectthefuelthatwillbe
used with the pellet system. The list on this screen indicates
allfuelchoicesavailabletoburnintheappliance.
NOTE: The list of fuels can be updated by your local
dealer as they become available.
Figure 15.5
c. OFF
This selection turns the appliance off. When the appli-
anceissettoOFF,itwillnotlightregardlessofroomtem-
perature. Use this setting when cleaning and maintaining
your appliance.
Manual
Off
Automatic
Figure 15.4
Toselectafueltype,usetheUP/DOWNbuttonstoscrollto
thedesiredfueltypeandthenpressthebuttonunder“Se-
lect”. The arrow will change to indicate the currently select-
ed fuel.
NOTE:Ifyouareburningahighashfuelsetthefuelselec-
tion to “Utility Pellets”.
Whenpurchasingcornorwheattoburninyourappliance,
readtheingredientlabelverycarefully.Do NOT purchase
fuel that contains any additivessuchasoils(i.e.soybean
oil)andmealsasitwillresultinpoorapplianceperformance.
Ifyouarebuyingcornorwheattheonlyingredientthatshould
belistediscornorwheat.
4. Program (7 Day Programming)
The wall control is pre-programmed at 68oF for all time set-
tings. It will remain there until it is re-programmed.
Thewallcontrolcanbeprogrammedasasetbackthermo-
stat.Eachdayoftheweekhasfourprogramperiods.The
wallcontrolmenushavesomefeaturesthatmakeiteasyto
Monday
Full Week
Mon-Fri
Sat-Sun
PROGRAMMING RANGE
Figure 15.6
Sunflower Seeds
Corn
Utility Pellet
Softwood Pellet
Wheat
Hardwood Pellet
DONE SELECT
FUEL SELECTION
a. Full Week
NOTE: It is important to note that the most recent pro-
gramming entry will override all previous programming for
an individual day or range of days.
The small triangle on the left side indicates the current ac-
tive programming line. Figure 15.6. For each of the four
intervalsavailabletoprogramtherearethreeadjustable
values: set hour, set minutes and set temperature. You
will need to increase or decrease the hour to change from
AMtoPM.
programgroupsofdaysalike.Thisminimizesthenumber
of steps required to program the wall control for most appli-
cations.
To access the programming screen, select Program from
the menu screen and then select the desired programming
rangefromthePROGRAMMINGRANGEscreen.
16 7034-276 January 29, 2014
MT. VERNON AE
PROGRAM: Full Week
Wake: 6:30 AM 68 F
o
Day: 7:59 AM 68 F
o
Evening: 4:00 PM 68 F
o
Night: 11:00 PM 68 F
o
DONE SET/NEXT
PROGRAM: Full Week
Wake: 6:30 AM 68 F
o
Day: 7:59 AM 68 F
o
Evening: 4:00 PM 68 F
o
Night: 11:00 PM 68 F
o
DONE SET/NEXT
PROGRAM: Full Week
Wake: 6:30 AM 68 F
o
Day: 7:59 AM 68 F
o
Evening: 4:00 PM 68 F
o
Night: 11:00 PM 68 F
o
DONE SET/NEXT
Figure 16.1 Figure 16.2
Figure 16.3
5. Set Day/time
a. Set Day/Time
Inorderforthesetbackfunctiontoworkproperlythewall
controlmustbeawareofthecurrenttime.TheSETDAY/
TIMEscreen is usedtosetthe system clock. Whenthe
screenisenteredthedayoftheweekishighlighted.
UsetheUP/DOWNbuttonstochangethistothecurrent
dayoftheweek.Pressthebuttonunder“Set/Next”and
thehighlightwillbemovedtothecurrenthoureld.Again,
usetheUP/DOWNbuttonstosetthistothecurrenthour.
Pressthe“Set/Next”buttonagainandthecurrentminute
display is highlighted.
UsetheUP/DOWNbuttonstoadjust tothe correctmin-
utesandpress“Set/Next”onelasttime.Thehighlightwill
movebacktotheoriginaldayofweekdisplay.
Wednesday 10 47
DONE SET/NEXT
Figure 16.4
Wednesday 47
10
Wednesday 4710
Figure 16.5
Figure 16.6
b. Set Date
When the SET DATE screen is entered the month name
is highlighted. Use the UP/DOWN buttons to select the
propermonththenpressthebuttonunder“Set/Next.”
The highlight will move to the day of the month display.
UsingtheUP/DOWNbuttons,selectthecurrentdatethen
press“Set/Next.”Thehighlightwillmovetotheyeardis-
play.Selectthecurrentyearandpress“Set/Next”thenthe
highlightwillbebackonthemonthnamedisplay.
September
2007
September
2007
28
September
200728
Figure 16.7 Figure 16.8
Figure 16.9
6. User Settings
Items that are rarely changed are stored under the USER
SETTINGS.
a. Temp Units F/C
TEMPUNITSisusedtochangefromFahrenheittoCel-
siusandbackforthetemperaturesdisplayed.
Figure 16.10
Figure 16.11
USER SETTINGS
Temp Units F/C
Flame Height Adjust
Temp Differential
USER SETTINGS
Temp Cal
Properties
Elevations
Conv Blower Speed
Whenthescreenisrstenteredthe“WakeHour”ishigh-
lighted.UsetheUP/DOWNbuttonstoadjustthehourto
thedesiredhourandpressthebuttonunder“Set/Next”.
Thehighlightwillmovetotheminutesdisplay.Adjustthe
minutesandpress“Set/Next.”Thehighlightisnowonthe
temperature value. Set the desired temperature for the
Wakeperiodandpress“Set/Next.”
The highlight is now on the hour display for the Day peri-
od, and the triangle has moved to the second line. Contin-
ueprogrammingeachvalueasdesired.(Tostorethenal
valuebesuretopress“Set/Next”toreturnthehighlightto
therstvalueonthescreen.)
Whenyouarenishedmakingchanges,orifyoujusten-
tered the programming screen to view the set program,
press “Done” or let the display return to the main screen
automatically.
January 29, 2014 7034-276 17
MT. VERNON AE
b. Flame Height Adjust
FLAMEHEIGHTADJUSTisusedtoadjustameheight(fuel
feedrate)forspecicinstallationandfueltype.Thedealer
will usually adjust this if necessary on installation and can
adviseonspecicsettingsforaparticularapplication.
Figure 17.1
d. Temperature Calibration
TEMPERATURE CAL is used to calibrate the tempera-
ture on the wall control. If for some reason you feel the
wall control is not accurately reading the temperature you
cancalibrateittoathermostatthatyouknowisaccurate.
PresstheUP/DOWNbuttonstodesiredtemperature.
c. Temp Differential
TEMPERATURE DIFFERENTIAL is used to change the
setdefaulttemperaturedifferential.Thissetshowfarbe-
low the set point the wall control allows the room tempera-
turetofallbeforetheapplianceturnsbackon.Itisusually
set at time of installation.
Figure 17.2
TEMPERATURE CAL
71.6
O
FCal Adj:
-13
DONE SET
Figure 17.3
e. Properties
PROPERTIESshowstheversionofsoftwareforthecontrol
boardandwallcontrol.Ifyouareplacingaservicecallwith
yourdealer,theymayaskyoutogotothisscreenandread
them the information under “WC” and “SC”.
WC
SC
CB
CV
40h
6Bh
000
000
UFTI: 029
Rev: 004
TC: -28
PROPERTIES
DONE
Figure 17.4
f. Elevation
ELEVATION allows you to adjust the appliance to your
specicelevation.PresstheUP/DOWNbuttonstoselect
your elevation. The message in the center will change
betweenNORMALandHIGH.IfyouselectHIGH,itwill
replace the normal fuel tables with specic high fuel ta-
bles.YouMUST select a fuel type after selecting HIGH.
Please note that changing the elevation will delete any
customornewfueltableloadedintotheappliance.You
mustconrmyourchoiceontheCONFIRMELEVATION
CHANGE screen. This allows you to reverse your deci-
sion if necessary. Figure 17.6
ELEVATION
Over 4000 FT
Normal / High
Up to 4000 FT
DONE
Figure 17.5
CONFIRM ELEVATION CHANGE
YES
Changing elevations will
delete any custom or
new fuel tables loaded into
the stove.
Are you sure?
NO
Figure 17.6
g. Convection Blower Speed
CONVBLOWERSPEEDallowsyoutoadjusttheblower
speedtoyourindividualpreference.PresstheUP/DOWN
buttonstoselectyourblowerspeed.Themessageinthe
centerwillchangebetweenNORMALandQUIET.
NORMALallowstheconvectionblowertoreachmaximum
RPMat135degreesandQUIETat165degrees.
CONV BLOWER SPEED
Normal
Normal / Quiet
Quiet
DONE
Figure 17.7
h. Language Selection
LANGUAGE allows you to select from four different lan-
guages. To select a language scroll down to the last item
ontheUSERSETTINGscreenusingtheDOWNbutton.
Using the UP/DOWN buttons select the preferred lan-
guage and then press Select and then press Done.
LANGUAGE
SELECT
DONE
Français
Norvégien
Suédois
Anglais
Figure 17.8
18 7034-276 January 29, 2014
MT. VERNON AE
F. Quick Start Guide
NOTICE:
Anybuttonpressedwillturnonthebacklight.Wallcontrolwillautomati-
callyrevertbacktothestartingscreenifthereisnoactivityfor15seconds;except
forthe“CONFIRMFUELCHANGE”screen.
READY
71 Set at: 68
12:30 PM
MENU
1. At the starting screen, press “MENU”
button once or twice until “MENU”
screen appears.
2. Highlight “FUEL TYPE” using the “UP/
DOWN” buttons to the right side of the
display. Press “SELECT”.
Auto/Manual/Off
User Settings
Fuel Type
MENU
Set Comfort Level
3. Scroll down and highlight “HARD-
WOODPELLET”oryourfueltype.
Sunflower Seeds
Wheat
FUEL SELECTION
Softwood Pellet
Hardwood Pellet
5. Press “DONE” to conrm fuel
change.
CONFIRM FUEL CHANGE
Please empty hopper
of old fuel type and
ensure firebox is clean.
Please refer to
section 8 in manual.
DONE
2. Highlight“AUTO/MANUAL/OFF”.
Press “SELECT”.
User Settings
Fuel Type
MENU
Set Comfort Level
Auto/Manual/Off
3. Highlight“MANUAL”.Press“SELECT”.
AUTO/MANUAL SETTINGS
Manual
Off
Automatic
Manual
CHOOSING FUEL TYPE
TURNING ON APPLIANCE
7. Fill the hopper with fuel. If the hopper
was completely empty or has run out of
fuel,putapproximately 1/2cup of pel-
letsintotherepotforaquickrestart.
8. Besurethehopperlidandglassdoor
arebothclosed.
1. Atthestartingscreen,press“MENU”.
Function Buttons
Buttons
Up
Down
READY
73 Set at: 73
12:30 PM
HEAT OUTPUT
MENU
Room
Temp
Wall Control for Reference
6. Press “DONE” twice or wait 15 sec-
onds for starting screen to reappear.
4.
Press“DONE”twiceorwait15seconds
for starting screen to re-appear.
READY
71
Set at: 68
12:30 PM
MENU
4. Now press “SELECT” to choose new
fuel.
READY
71 Set at: 68
12:30 PM
MENU
1. Atthestartingscreen,press“MENU”
button once or twice until “MENU”
screen appears.
3. Highlight“TEMPUNITSF/C”usingthe
“UP/DOWN”buttonstotherightsideof
the display. Press “SELECT”.
CHOOSING TEMP UNIT:
°F or °C
5. Press“DONE”twiceagain,orwait15
seconds for starting screen to re-ap-
pear.
4. Press the “UP” or “DOWN” button
to set desired temperature unit and
press “SELECT”..
USER SETTINGS
Flame Height Adjust
Temp Differential
Temp Units F/C
Auto/Manual/Off
Fuel Type
Set Comfort Level
User Settings
MENU
2. Highlight “USER SETTINGS” using
the “UP/DOWN” buttons to the right
side of the display. Press “SELECT”.
January 29, 2014 7034-276 19
MT. VERNON AE
READY
71 Set at: 74
12:30 PM
HEAT OUTPUT
MENU
Hold at:
Medium High
1. At the starting screen, press “HEAT
OUTPUT”.
2. Usethe“UP”buttontochange“HEAT
OUTPUTLEVEL”to”MEDIUM-HIGH”.
SETTING HEAT OUTPUT
1. Pressandhold“UP”or“DOWN”but-
ton to set desired temperature.
74ºF
2. Press“HOLDTEMP”.
SETTING COMFORT LEVEL
READY
71 Set at: 68
12:30 PM
HEAT OUTPUT
MENU
NOTE: Set temperature must be 3
degrees higher than room
temperature for appliance to
start.
SET COMFORT LEVEL
ON HOLD
RESUME
DONE
74ºF
3. Press“DONE”.
3. Press “DONE” twice or wait 15 sec-
onds for starting screen to re-appear.
HOPPER OUT OF FUEL
SHUTDOWN
71 Set at: 74
12:30 PM
HEAT OUTPUT
MENU
Hold at:
STARTUP
71 Set at: 74
12:30 PM
HEAT OUTPUT
MENU
Hold at:
Min Firepot Temp
SERVICE
RETRY
ERROR LIST
1. If the appliance has stopped operat-
ing,checkthewallcontrolscreen.If
it is showing “Min Firepot Temp” the
hopper has run out of fuel.
2. Fill the hopper with fuel and press the
“RETRY”buttontwice.Thersttime
turns on the back light, the second
time starts the retry function.
3. If the wall control screen changes to
a “SHUTDOWN” screen that means
your appliance has not completed the
full shutdown cycle. Depending on
whereit wasin thecycle it can take
from one to ten minutes to restart.
When the shutdown cycle is complete
the wall control screen will display
“STARTUP”. Continue to Step 4.
4. If the wall control screen changes to
a “STARTUP” screen after pressing
“RETRY” that means your appliance
has already completed the shutdown
cycle. You must wait until the wall
control screen displays the startup
screenandthenput1/2cupofpellets
intherepotforaquickrestart.
5. Besurethehopperlidandglassdoor
arebothclosed.
20 7034-276 January 29, 2014
MT. VERNON AE
H. Error Codes
If a system error occurs that forces the system to stop op-
erating an error screen appears. Depending upon the error
type, up to three retry attempts are allowed after which a
service professional is required.
Press the ERROR LIST button to display the latest error.
See page 30 for a list of error codes.
G. Service Information
The SERVICE INFORMATION screen displays contact in-
formationfor Hearth & HomeTechnologiesCustomerSer-
vice Line. The local dealer may have changed this upon or
beforetheinstallationtoindicateadealerhotline.
www.quadrafire.com
to locate your nearest
dealer
DONE
ERROR LIST
Figure 20.2
MANUAL LIGHT PROCEDURE
Press “CONTINUE”
button to start manual
lighting sequence
Current Tem: 72 F
O
CONTINUE
MANUAL LIGHT PROCEDURE
Please wait while
feed charge is loading
into firepot
MANUAL LIGHT PROCEDURE
Open door...
Manually light fuel...
Close door
Figure 20.1
13 Volts 12 Volts 11 Volts Battery
Below
10 Volts
Refer to page ___forinstructionsonhowtoattachthecable
to appliance. The following are screens you will see when
usingaback-upbattery.
OperatingonBatteryBack-Up
• Abatteryiconappearsonyourwallcontroltoletyouknow
youarenowoperatingonbatterypower.Figure 20.3.
• Firemustbemanuallylitastheappliancewillnolonger
automatically light. See section G on page 9.
• Useonlyapprovedrestartinggeltostartre.
• Highburnrateisnolongeravailableonbatteryback-up.
• Each level drops down one level, i.e the high burn be-
comesmedium-highburnandsoon.
• Ifthebatterychargefallsbelow10voltitcannolonger
sustain the appliance operation and the appliance will
shutdown.Youmustdisconnectandreconnectthebat-
tery to start it up again.
RecommendedBattery
• 12voltdeepcyclebattery,(i.e.,marineorRVtype).
• A 12 volt battery cable is available through your local
dealer.
WARNING! Risk of Injury!
• Blowersmaycontinuetorunandwouldbeexposedto
human contact.
Figure 20.3
MAINT BURN
73
Set at: 73
12:30 PM
HEAT OUTPUT
MENU
“Maint Burn” will display when
the thermostat has reached the
set room temperature and will
run on low until it reaches its
auto-clean cycle time.
Battery icon.
Figure 20.4
Wall Control Display
Thewallcontrolwilldisplaythebatteryiconwhenoperating
inthebatteryback-upmode.Figure 20.4.
I. Battery Back-up System (Optional)
CAUTION!
• HookuptobatteryterminalsBEFOREyouplugbattery
into appliance.
• Damagetointernalelectroniccomponentsmayoccur.
Theappliancehasbeendesignedtooperateonanoptional
batteryback-upsystem.
If you have frequent power outages in your region, hook
theapplianceuptoa12voltbatteryanditwillautomatically
switchtobatterypowerintheeventofapowerfailure.The
12 volt power cord sold as a separate accessory does not
chargethebattery.
La page charge ...
La page charge ...
La page charge ...
La page charge ...
La page charge ...
La page charge ...
La page charge ...
La page charge ...
La page charge ...
La page charge ...
La page charge ...
La page charge ...
La page charge ...
La page charge ...
La page charge ...
La page charge ...
La page charge ...
La page charge ...
La page charge ...
La page charge ...
  • Page 1 1
  • Page 2 2
  • Page 3 3
  • Page 4 4
  • Page 5 5
  • Page 6 6
  • Page 7 7
  • Page 8 8
  • Page 9 9
  • Page 10 10
  • Page 11 11
  • Page 12 12
  • Page 13 13
  • Page 14 14
  • Page 15 15
  • Page 16 16
  • Page 17 17
  • Page 18 18
  • Page 19 19
  • Page 20 20
  • Page 21 21
  • Page 22 22
  • Page 23 23
  • Page 24 24
  • Page 25 25
  • Page 26 26
  • Page 27 27
  • Page 28 28
  • Page 29 29
  • Page 30 30
  • Page 31 31
  • Page 32 32
  • Page 33 33
  • Page 34 34
  • Page 35 35
  • Page 36 36
  • Page 37 37
  • Page 38 38
  • Page 39 39
  • Page 40 40

Quadra-Fire MTVERNON-AE-PDB Le manuel du propriétaire

Quadra-Fire
Marque
Quadra-Fire
Modèle
MTVERNON-AE-PDB
Catégorie
Poêles
Taper
Le manuel du propriétaire
Ce manuel convient également à
Télécharger le PDF
rapport

dans d''autres langues

Documents connexes

Autres documents