RAIS Viva 100 L Classic Gas Installation & Operation Manual

1

POSITIV

OUTLINE

NEGATIV

Installation & Operation Manual

RAIS VIVA L Direct Vent Gas Stove

USA / Canada

2

USA / Canada

English RAIS

- U

ser manual for VIVA L Gas

Report # __________

This appliance may be installed in an aftermar-

ket, permanently located manufactured home

(USA only) or in a mobile home, where not

prohibited by local codes.

This appliance is for use only with the type of

gas indicated on the rating plate. This applian-

ce is not convertible for use with other gases,

unless a certiﬁed conversion kit is used.

Ce manual est disponsible en Français sur demande.

FIRE OR EXPLOSION HAZARD

Failure to follow safety warnings exactly could result in serious injury, death, or pro-

perty damage.

-Do not store or use gasoline or other ﬂammable vapors and liquids in the

vicinity of this or any other appliance.

WHAT TO DO IF YOU SMELL GAS

• Do not try to light any appliance.

• Do not touch any electrical switch; do not use any phone in you building.

• Leave the building immediately.

• Immediately call your gas supplier from a neighbor’s phone. Follow the gas

supplier’s instructions.

• If you cannot reach your gas supplier, call the ﬁre department.

- Installation and service must be performed by a qualiﬁed installer, service

agency or the gas supplier.

3

Assurez-vous de bien suivre les instructions données dans cette notice pour

réduire au minimum le risque d’incindie ou d’explosion ou pour éviter tout

dommage matériel, toute blessure ou la mort.

English RAIS

- U

ser manual for VIVA L Gas

Ne pas entreposer ni utilizer d’essence ni d’autres vapeurs ou liquides inﬂam-

mables dans le voisinage de cet appareil ou de tout autre appareil.

-QUE FAIRE SI VOUS SENTEZ UNE ODEUR DE GAZ:

•Ne pas tenter d’allumer d’appareil.

•Ne touchez à aucan interrupteur. Ne pas vous servir des téléphones se

trouvant dans le bâtiment où vous trouvez.

•Appelez immédiatement votre fournisseur de gaz depuis un voisin. Suivezles

instructions du fournisseur.

•Si vous ne pouvez rejoindre le fournisseur de gaz, appelez le service des incin-

die.

- L’installation et l’entretien doivent être assurés par un installateur ou un ser-

vice d’entretien qualiﬁé ou par le fournisseur de gaz.

Cet appareil peut être installé dans une

maison préfabriquée (mobile) déjà instal-

lée à demeure si kes règlements locaux le

permettent.

Cet appareil doit être uniquement avec

las type de gaz indiqué sur la plaque

signalétique. Cet appareil ne peut être

converti à d’autres gaz, sauf si une trousse

de conversion est utilisée.

Ne pas utiliser cet appareils’il a été plongé,

meme partiellement, dans l’eau. Appe-

ler un technician qualiﬁé pour inspecter

l’appareail et remplacer toute partie du

système de commande et toute comman-

de qui a été plongée dans /’eau.

Attention. Au moment de l’entretien des

com- mandes, étiquetez tous les ﬁls avant

de les dé- brancher. Des erreurs de la

câblage peuvent en- traîner un fonctionne-

ment inadequate et dan- gereux.

S’assurer que l’appareil fonctionne adéqu-

ate- ment une fois l’entretien terminé.

AVERTISSEMENT. Ne pas utiliser l’appareil

si le panneau frontal en verre n’est pas

en place, est craqué ou brisé. Conﬁez le

remplacement du panneau à un technician

agree.

INSTALLATEUR: Laissez cette notice avec l’appareil.

COMSOMMATEUR: Conservez cette notice pour consultation ultérieur.

INSTALLER: Leave this manual with the appliance.

CONSUMER: Retain this manual for furture reference.

4

English RAIS

- U

ser manual for VIVA L Gas

This manual covers the following models:

Viva 100 L Gas – without side glass

Viva 100 LG Gas – with side glass

Viva 100 L Classic Gas – without side glass

Viva 100 LG Classic Gas – with side glass

Viva 120 L Gas – without side glass

Viva 120 LG Gas – with side glass

Viva 120 L Classic Gas – without side glass

Viva 120 LG Classic Gas – with side glass

Viva 160 L Gas – without side glass

Viva 160 LG Gas – with side glass

Viva 160 L Classic Gas – without side glass

Viva 160 LG Classic Gas – with side glass

5

Reservations for printing errors.

TABLE OF CONTENTS

IMPORTANT SAFETY INFORMATION

........................................................ 6

GENERAL COMMENTS ............................................................................ 9

INTRODUCTION .................................................................................... 10

GUARANTEE ......................................................................................... 11

SPECIFICATIONS .................................................................................... 12

INSTALLATION ....................................................................................... 13

MASSACHUSETTS REQUIREMENTS ....................................................... 15

VENTING ............................................................................................... 16

GAS CONNECTION ............................................................................... 24

CHANGES TO CHIMNEY CONNECTION ................................................. 25

CONVERSION TO BOTTLED GAS (LPG) .................................................. 28

ARRANGEMENT OF EMBERS AND CERAMIC LOGS ............................... 36

START-UP - INSERTION OF BATTERIES .................................................... 40

SETTING UP OF THE ELECTRONIC CODE ............................................... 42

COMMISSIONING ................................................................................. 43

INITIAL IGNITION ................................................................................... 45

USER INSTRUCTIONS ............................................................................. 46

USING STOVE WITHOUT REMOTE CONTROL ......................................... 52

SERVICE ................................................................................................ 54

MAINTENANCE INSTRUCTIONS ............................................................. 55

ACCESSORIES ....................................................................................... 59

INSTALLATION OF MYFIRE WI-FI BOX .................................................... 60

SPARE PARTS LIST ................................................................................. 62

FILL OUT THE INSTALLATION RECORD FORM,

IT CAN BE FOUND IN THE BACK OF THE MANUAL

WE STRONGLY SUGGEST THAT YOU READ THIS MANUAL THO-

ROUGHLY BEFORE BE- GININNG THE INSTALLATION OF THE RAIS

GAS STOVE. ALTHOUGH THE BASIC REQUIREMENTS FOR THE

INSTALLATION OF ALL DIRECT VENT GAS HEATERS ARE SIMILAR,

EACH SPECIFIC PRODUCT HAS ITS OWN UNIQUE SET-UP AND

INSTALLATION REQUIREMENTS THAT MUST BE FOLLOWED EXAC-

TLY. PLAN YOUR INSTALLATION IN ADVANCE BY CAREFULLY RE-

VIEWING ALL THE INFORMATION CONTAINED IN THIS MANUAL.

2

30-10-2017

3716510 - Viva L GAS US-CAN

Revision :

Date :

English RAIS

- U

ser manual for VIVA L Gas

6

English RAIS

- U

ser manual for VIVA L Gas

IMPORTANT SAFETY INFORMATION

THE INSTALLATION MUST CONFORM WITH LOCAL CODES OR, IN THE ABSENCE OF

LOCAL CODES, WITH THE NATIONAL FUEL

GAS CODE, ANSI Z223.1 OR THE CANADIAN INSTALLATION CODE, CAN/CGA B149.

A MANUFACTURED HOME (USA ONLY) OR MOBILE HOME OEM INSTALLATION

MUST CONFORM WITH THE MANUFACTURED HOME CONSTRUCTION AND SAFETY

STANDARD, TITLE 24 CFR, PART 3280 OR WHEN SUCH A STANDARD IS NOT APPLI-

CABLE, THE STANDARD FOR MANUFACTURED HOME INSTALLATIONS, ANSI/BCSBCS

A225.1, OR STANDARD FOR GAS EQUIPPED RECREATIONAL VEHICLES AND MOBILE

HOUSING, CSA Z240.4.

THE APPLIANCE AND ITS APPLIANCE MAIN GAS VALVE MUST BE DISCONNECTED

FROM THE GAS SUPPLY PIPING SYSTEM

DURING ANY PRESSURE TESTING OF THAT SYSTEM AT TEST PRESSURES IN EXCESS

OF 1/2 PSI (3.5 KPA).

THE APPLIANCE MUST BE ISOLATED FROM THE GAS SUPPLY PIPING SYSTEM BY

CLOSING ITS EQUIPMENT SHUTOFF VALVE DURING ANY PRESSURE TESTING OF THE

GAS SUPPLY PIPING SYSTEM AT TEST PRESSURES EQUAL TO OR LESS THAN 1/2 PSI

(3.5 KPA).

THE INSTALLATION MUST PROVIDE FOR ADEQUATE VENTILATION AIR TO THE APPLI-

ANCE.

THIS GAS APPLIANCE MUST NOT BE CONNECTED TO A CHIMNEY FLUE SERVING A

SEPARATE SOLID-FUEL BURNING APPLIANCE.

THE APPLIANCE, WHEN INSTALLED, MUST BE ELECTRICALLY GROUNDED IN AC-

CORDANCE WITH LOCAL CODES, OR, IN THE ABSENCE OF LOCAL CODES, WITH

THE NATIONAL ELECTRICAL CODE ANSI/NFPA 70, OR THE CANADIAN ELECTRICAL

CODE, CSA C22. 1.

WHEN THE APPLIANCE IS INSTALLED DIRECTLY ON CARPETING OR NON-CERAMIC

TILE OR OTHER COMBUSTIBLE MATERIAL OTHER THAN WOOD FLOORING, THE AP-

PLIANCE SHALL BE INSTALLED ON A METAL OR WOOD PANEL EXTENDING THE FULL

WIDTH AND DEPTH OF THE APPLIANCE. A COMMERCIALLY AVAILABLE HEARTH

PAD MEETS THIS REQUIREMENT.

THE APPLIANCE AREA MUST BE KEPT CLEAR AND FREE FROM COMBUSTIBLE MATE-

RIALS, GASOLINE AND OTHER FLAMMABLE VAPORS AND LIQUIDS.

THE FLOW OF COMBUSTION AND VENTILATION AIR MUST NOT BE OBSTRUCTED.

DO NOT USE THIS APPLIANCE IF ANY PART HAS BEEN UNDER WATER. IMMEDIATE-

LY CALL A QUALIFIED SERVICE TECHNICIAN TO INSPECT THE APPLIANCE AND TO

REPLACE ANY PART OF THE CONTROL SYSTEM AND ANY GAS CONTROL WHICH

HAS BEEN UNDER WATER.

DUE TO HIGH TEMPERATURES, THE APPLIANCE SHOULD BE LOCATED OUT OF

TRAFFIC AND AWAY FROM FURNITURE AND DRAPERIES.

English RAIS

- U

ser manual for VIVA L Gas

CHILDREN AND ADULTS SHOULD BE ALERTED TO THE HAZARDS OF HIGH SURFACE

TEMPERATURES AND SHOULD STAY AWAY TO AVOID BURNS OR CLOTHING IGNITI-

ON.

YOUNG CHILDREN SHOULD BE CAREFULLY SUPERVISED WHEN THEY ARE IN THE

SAME ROOM AS THE APPLIANCE. TODDLERS, YOUNG CHILDREN AND OTHERS

MAY BE SUSCEPTIBLE TO ACCIDENTAL CONTACT BURNS. A PHYSICAL BARRIER IS

RECOMMENDED IF THERE ARE AT-RISK INDIVIDUALS IN THE HOUSE. TO RESTRICT

ACCESS TO A FIREPLACE OR STOVE, INSTALL AN ADJUSTABLE SAFETY GATE TO

KEEP TODDLERS, YOUNG CHILDREN AND OTHER AT-RISK INDIVIDUALS OUT OF THE

ROOM AND AWAY FROM HOT SURFACES.”

CLOTHING OR OTHER FLAMMABLE MATERIAL SHOULD NOT BE PLACED ON OR

NEAR THE APPLIANCE.

ANY SCREEN OR GUARD REMOVED FOR SERVICING AN APPLIANCE MUST BE RE-

PLACED PRIOR TO OPERATING THE APPLIANCE.

INSTALLATION AND REPAIR SHOULD BE DONE BY A QUALIFIED SERVICE PERSON.

THE APPLIANCE SHOULD BE INSPECTED BEFORE USE AND AT LEAST ANNUALLY BY

A PROFESSIONAL SERVICE PERSON.

MORE FREQUENT CLEANING MAY BE REQUIRED DUE TO EXCESSIVE LINT FROM

CARPETING, BEDDING MATERIAL, ETC. IT IS IMPERATIVE THAT THE CONTROL COM-

PARTMENTS, BURNERS AND CIRCULATING AIR PASSAGEWAYS OF THE APPLIANCE

BE KEPT CLEAN.

A BARRIER DESIGNED TO REDUCE THE RISK OF BURNS FROM THE HOT VIEWING

GLASS IS PROVIDED WITH THIS APPLIANCE (3711901) AND SHALL BE INSTALLED

FOR THE PROTECTION OF CHILDREN AND OTHER AT-RISK INDIVIDUALS.

3711901

IF THE BARRIER BECOMES DAMAGED, THE BARRIER SHALL BE

REPLACED WITH THE MANUFACTURER’S BARRIER FOR THIS

APPLIANCE.

WARNING: Do not operate the appliance with the glass door assembly removed,

or if the glass is cracked or broken. Replacement of the glass should be

done by a qualiﬁed service person.

WARNING: Use only door assembly that includes the glass panel, frame and gas

ket. Do not use substitute materials. Do not strike or slam the glass front.

Do not use abrasive cleaners. Do not clean when hot.

8

English RAIS

- U

ser manual for VIVA L Gas

NE PAS SE SERVER DE CET APPAREIL S’IL A ÉTÉ PLUNGE DANS L’EAU, MÊME PARTI-

ELLEMENT. FAIRE INSPECTER L’APPAREIL PAR UN TECHNICIAN QUALIFIÉ ET REMPLA-

CER TOUTE PARTIE DU SYSTÈME DE CONTRÔLE ET TOUTE COMMANDE QUI ONT

ÉTÉ PLONGÉES DANS L’EAU.

CET APPAREIL PEUT ÊTRE INSTALLÉ DANS UNE MAISON PRÉFABRIQUÉE (MOBILE)

DÉJÀ INSTALLÉE À DEMEURE SI LES RÈGLEMENTS LOCAUX LE PERMETTENT.

CE APPAREIL DOIT ÊTRE UTILISE UNIQUEMENT AVEC LE TYPE DE GAZ INDIQUÉ SURE

LA PLAQUE SIGNALÉTIQUE. CET APPAREIL NE PEUT ÊTRE CONVERTI À D’AUTRES

GAZ, SAUF SI UNE TROUSSE DE CONVERSION EST UTILISE.

EN RAISON DES TEMPERATURES ÉLEVÉES, L’APPAREIL DEVRAIT ÊTRE INSTALLÉ DANS UN ENDROIT

OÙ IL Y A PEU DE CIRCULATION ET LOIN DU MOBILIER ET DES TENTURES.

LES ENFANTS ET LES ADULTES DEVRAIENT ÊTRE INFORMÉS DES DANGERS QUE POSENT LES TEM-

PERATURES DE SURFACE ÉLEVÉES ET SE TENIR À DISTANCE AFIN D’ÉVITER DES BRÛLURES OU QUE

LEURS VÊTEMENTS NE S’ENFLAMMENT.

LES JEUNES ENFANTS DEVRAIENT ÊTRE SURVEILLÉS ÉTROITEMENT LORSQU’ILS SE TROUVENT

DANS LA MEME PIÈCE QUE L’APPAREIL. LES TOUT PETITS, LES JEUNES ENFANTS OU LES ADULTES

PEUVENT SUBIR DES BRÛLURES S’ILS VIENNENT EN CONTACT AVEC LA SURFACE CHAUDE. IL EST

RECOMMANDÉ D’INSTALLER UNE BARRIER DE SÉCURITÉ; CETTE MESURE EMPÊCHERA LES TOUT

PETITS, LES JEUNES ENFANTS ET TOUTE AUTRE PERSONNE À RISQUÉ D’AVOIR ACCÈS À LA PIÈCE

ET AUX SURFACES CHAUDES.

UN ÉCRAN DESTINE À RÉDUIRE LE RISQUÉ DE BRÛLURE ATTRIBUTABLE À LA VITRE CHAUDE EST

FOURNI AVEC CET APPAREIL ET DEVRAIT ÊTRE INSTALLÉ POUR LA PROTECTION DES ENFANTS ET

DES PERSONNES À RISQUÉ.

SI LÉCRAN EST ENDOMMAGÉ, IL DOIT ÊTRE REMPLACÉ PAR CELUI FOURNIT PAR LE FABRICANT DE

CET APPAREIL.

ON NE DEVRAIT PAS PLACER DE VÊTEMENTS NID’AUTRES MATIÈRES INFLAMMABLES SUR L’APPA-

REIL NI À PROXIMITÉ.

TOUT ÉCRAN OU PROTECTEUR RETIRE POUR PERMETTRE L’ENTETIEN DE L’APPAREIL DOIT ÊTRE

REMIS EN PLACE AVANT DE METTRE L’APPAREIL EN MARCHE.

L’INSTALLATION ET LA REPARATION DEVRAIT ÊTRE CONFIÉES À UN TECHNICIAN QUALIFIÉ. L’AP-

PAREIL DEVRAIT FAIRE L’OBJET D’UNE INSPECTION PAR UN TECHNICIAN PROFESSIONNEL AVANT

D’ÊTRE UTILIZE ET AU MOINS UNE FOIS L’AN PAR LA SUITE. DES NETTOYAGES PLUS FREQUENTS

PEUVENT ÊTRE NECESSARIES SI LES TAPIS, LA LITERIE, ET CETERA PRODUISENT UNE QUANTITÉ

IMPORTANTE DE POUSSIÈRE. IL EST ESSENTIAL QUE LES COMPARTIMENTS ABRITANT LES COM-

MANDES, LES BRÛLURES ET LES CONDUITS DE CIRCULATION D’AIR DE LAPPAREIL SOIENT TENUS

PROPRES.

SEULES LES TROUSSES DE GARNITURE FOURNIES PAR LE FABRICANT DOIVENT ÊTRE UTILISÉES

POUR L’INSTALLATION DE CET APPAREIL.

AVERTISSEMENT: RISQUE DE DOMMAGES OU DE BLESSURES SI LES PIECES NE SONT PAS INSTAL-

LÉES CONFORMÉMENT À CES SCHEMAS ET OU SI DES PIECES AUTRES QUE CELLES SPÉCIFIQUE-

MENT APPROUVÉES AVEC CET APPAREIL SONT UTILISÉES.

LES DÉGAGEMENTS SONT CONFORMES AUX CODES D’INSTALLATION LOCAUX ET AUX EXIGEN-

CIES DU FOURNISSEUR DE GAZ.

9

General Comments

This RAIS product is an extremely effective convection gas stove with a sealed combus-

tion chamber for chimneys with a balanced draught. It is ﬁtted with a burner with the

latest burner technology. It has a variable heat output because it uses a special control

system that makes it possible to use three burners for high output or one burner for a

lower output. One of the burners, called the "Main burner" is located in the centre of

the stove, the second and third burners, called the "Secondary burners" are located

behind the Main burner. The secondary burners can be switched on and off while the

stove is on.

Where there is a natural gas connection, the local gas supply conditions should be inves-

tigated to ensure that the gas composition and pressure suit the stove's settings.

If the stove is connected to bottled gas, only gas bottles ﬁtted with a gas regulator (Low

pressure regulator) providing the correct gas pressure may be connected. For this reason,

gas bottles without a regulator must not be connected.

This stove must only be installed, set up and serviced by an authorised and qualiﬁed

plumbing and heating engineer/Gas installer. The installation must comply with local and

national Building Regulations and Gas Regulations and the user manual must be adhered

to. The user manual should be left with the customer, who should keep this for later use.

The manual is necessary when the stove is to be serviced.

Ensure that the chimney terminal is not blocked in any way and is free of vegetation

in the form of trees, bushes etc. and that objects are not resting against the chimney's

terminal or the protection around the terminal.

The door glass should always be cleaned before the stove is turned on and ﬁngerprints

wiped as these can be burned into the glass.

The stove must not be used if the door glass is split, cracked, removed or if the door is

open. Do not use the stove if the door gasket is broken or worn.

This stove is designed for use in many different installation situations, which can be seen

in this manual. Only chimneys approved by RAIS may be used with this product. (see

chimney section)

This stove is intended for chimneys with balanced draughts (Air intake and draught in

same chimney) so there is no need for any extra air supply for combustion. Suitable ven-

tilation is recommended in the room in order to achieve a pleasant living environment.

This product is a heating appliance so the surfaces become very hot and should not be

touched during use. It is therefore recommended that you use an approved stove screen

to protect children, older people and persons with reduced mobility in the same area as

the stove.

Keep curtains, washing, furniture etc. at a minimum distance of 300 mm from this stove.

The stove must not be used for burning waste.

If the stove is extinguished or goes out, do not attempt to turn it back on until a mini-

mum of 3 minutes have passed.

English RAIS

- U

ser manual for VIVA L Gas

10

Introduction

congratulations with your new RAIS Product.

A RAIS stove is more than just a source of heat, it also expresses how you put the em-

phasis on good design and high quality in your home.

In order get the most pleasure and beneﬁt from your new stove, it is important that

you read the manual thoroughly before it is installed and put to use.

For the purpose of the guarantee and all contact regarding the stove in general, it is

important that you can state the stove's production number. We therefore recommend

that you write down the number in the form below. Also write down where the stove

was bought and who installed the stove.

The production number can be found at the bottom of the stove.

English RAIS

- U

ser manual for VIVA L Gas

11

Guarantee

RAIS

stoves are checked several times with regard to safety, as well as the quality of

materials and manufacturing. We offer a guarantee on all models and the guarantee

commences on the date of installation.

The guarantee covers:

• documented functional faults due to incorrect manufacture

• documented material faults

The guarantee does not cover:

• door and glass gaskets

• ceramic glass

• the appearance of the surface structure or texture of the natural stone

• the appearance of the stainless steel and colour changes and patina

• expansion blemishes

• batteries

The guarantee is invalidated in the event of:

• damage due to overﬁring

• damage due to external inﬂuences and the use of unsuitable fuels

• failure to comply with statutory or recommended installation instructions and in

the event the user's own modiﬁcations of the stove.

• lack of servicing and care

In the event of damage, please contact your dealer. In the event of claims under the

guarantee, we will decide how the damage is to be repaired. In the event of repairs, we

will ensure they are performed professionally.

In the event of guarantee claims concerning repaired parts or parts delivered later,

please refer to national/EU law/provisions in relation to renewed guarantee periods.

The guarantee provisions applying at any time may be requested from RAIS

English RAIS

- U

ser manual for VIVA L Gas

12

English RAIS

- U

ser manual for VIVA L Gas

SPECIFICATIONS

INPUT Natural Gas Propane (LP)

Input Rating-Btu/hr 31,000 25,600

Min. Input-Btu/hr 8,000 8,000

Oriﬁce-Marking (Front) 120 80

Oriﬁce-Marking (Rear) 260 (x2) 100 (x2)

GAS SUPPLY

Manifold Pressure 4.0”w.c. / 1.0kPa 10.8”w.c. / 2.7kPa

Min. Supply Pressure 4.0”w.c. / 1.0kPa 11.0”w.c. / 2.8kPa

Max. Supply Pressure 10.0”w.c. / 2.5kPa 13.0”w.c. / 3.3kPa

EFFICIENCY

Steady State Efﬁciency (At Min. Input Rate and Using Minimum Allowable Vent

Length)-%

Top Vent / Rear Vent 78 78.2

Annual Fuel Utilization Efﬁciency [AFUE](Using Minimum Allowable Vent Length) -%

Top Vent / Rear Vent 77 77

Canadian p.4 Efﬁciency (Using Minimum Allowable Vent Length)- %

Top Vent / Rear Vent 70 / 72 69 / 70

Maximum Observed

-Steady State Efﬁciency -% 73.6 70.1

NOTE: The maximum achievable steady state efﬁciency can vary depending the installa-

tion and on how the stove is operated.

It is recommended that the pilot ﬂame be turned off if the appliance will not be in use

for an extended period of time. This appliance is equipped for use with the fuel type

indicated on the rating plate. Fuel conversion kits that include the necessary parts and

instructions are included with the stove or are available from your installer, dealer or

RAIS.

This appliance has been certiﬁed by Intertek, Inc. to ANSI Z21.50 • CSA 2.22 Vented

Gas Fireplace Heaters and CGA 2.17-M91 (R2009), Gas-Fired Appliances for Use At

High Altitudes.

The VIVA L is approved for installation at elevations up to 4500 feet (1370 meters) in

U.S. and Canada without change. If your installation is at an elevation greater than

these, consult with the local authority having jurisdiction for gas product installations to

determine their speciﬁc requirements for high altitude installations.

Intertek Testing & Certiﬁcation Ltd,

Registered ofﬁce: Academy Place, 1 to 9 Brook Street, Brentwood, Essex

CM14 5NQ, United Kingdom. Registered No: 3272281

(England), VAT No: GB 672-7639-96-011

T: +44 1277 223 400

F: +44 1277 223 127

13

English RAIS

- U

ser manual for VIVA L Gas

INSTALLATION

Several issues must be addressed when selecting a suitable location for your VIVA L.

The minimum clear- ances to combustible construction are listed below. In addition, ac-

cess to the gas supply must be considered. The location of the stove will also affect the

venting requirements and you must be certain the location will allow compliance with

the venting requirements. You must also insure that your installation provides adequate

accessibility clearance for servicing and proper operation.

When the appliance is installed directly on carpeting or non-ceramic tile or other com-

bustible material other than wood ﬂooring, the appliance shall be installed on a metal

or wood panel extending the full width and depth of the appliance. A commercially

available hearth pad meets this requirement.

Installation and repair should be done by a qualiﬁed service person. The appliance

should be inspected before use and at least annually by a professional service person.

More frequent cleaning may be required due to excessive lint from carpeting, bedding

material, etc. It is imperative that the control compartment, burners and circulating air

passageways of the appliance be kept clean.

Gas installation

Once it has been decided where the stove will be positioned, a gas installation should

be established in the vicinity of the stove so that the gas supply and stove can be con-

nected.

Ventilation

This stove has a sealed combustion chamber and is intended for a balanced draught.

There is therefore no need for an extra air supply.

It is recommended that sufﬁcient fresh air is supplied to the room to maintain a com-

fortable environment.

This stove may be installed in a completely airtight building or a building with mechani-

cal ventilation.

UNPACKING AND PLACING THE VIVA L

By now, you will have removed the shipping carton from the base pallet. The VIVA L

is shipped in a specially designed shipping carton. Cut the strapping that secures the

stove to the pallet and remove the wooden cribbing from the top of the stove. Remove

the plastic bag that covers the stove. Remove the barrier (3711901) by unscrewing the

4 bolts holding the barrier, with the 3mm hex key ﬁxed to the pallet and. Be careful not

to scratch the paint of the stove when removing the barrier. Open the door with the

10mm spanner ﬁxed to the pallet, by turning the two hooks holding the door. Remove

the package of logs and accessories that is packed inside the stove and set it aside. Lift

the stove up and off the pallet. Remove transit packing material. Remove any packing

material from inside the ﬁrebox.

The VIVA L is equipped with leveling bolts to make it easier to install the stove on an

irregular surface. They can be adjusted later. Move the VIVA L to location where it will

be installed. Using as little adjustment as possible for each leveling bolt, adjust them as

needed to get the stove as level as possible both side to side and front to back.

14

English RAIS

- U

ser manual for VIVA L Gas

MINIMUM CLEARANCES TO COMBUSTIBLE CONSTRUCTION

Stove to Left Side Wall 6” (150mm) Stove to Corner Wall 2” (51mm)

Stove to Right Side Wall 6” (150mm) Stove to Ceiling 35” (890mm)

Stove to Rear Wall 2” (51mm) Stove to 12” Deep Mant el 12” (305mm)

Max. Alcove Depth 24” (610mm) Stove to 1½” (38mm) Trim 2” (51mm)

A = 6” (150mm)

B = 6” (150mm)

C = 2” (51mm)

D=24” (610mm)

Walls

F = 35” (890mm)

G = 12” (305mm)

H = 12” (305mm) Max.

I = 2” (51mm)

E = 2” (51mm)

CORNER

D

C

A B

E

F

H

G

I

D

C

A B

E

F

H

G

I

D

C

A B

E

F

H

G

I

PLEASE NOTE!

The ﬂoor construction must be able to bear the weight of the stove and chimney, if ap-

plicable. If the existing design does not satisfy this prerequisite, suitable measures must

be taken (e.g., a load distribution slab). Consult a construction expert.

The stove must be positioned at a safe distance from ﬂammable material.

It must be ensured that ﬂammable objects (e.g., furniture) are not positioned closer

than the distances stated in the following sections with regard to installation (risk of

ﬁre).

When you choose where you wish to position your stove, you should consider the heat

distribution to the other rooms. Then you will get the maximum possible pleasure from

your stove.

Inspect the stove for defects upon receipt.

15

MASSACHUSETTS REQUIREMENTS

The gas stove is shipped with a 3/8” NPT female connection. The gas supply piping should have

a separate gas shutoff valve and a 1/8” NPT plugged tapping upstream of the valve. The stove

and its main control valve must be disconnected from the gas supply piping system during any

pressure testing of that system at test pressures in excess of 1/2 psi (3.5 kPa). The stove must be

isolated from the gas supply piping system by closing the main control valve during any pressure

testing of the gas supply system at test pressures equal to or less than 1/2 psi (3.5 kPa). After the

gas supply has been connected, use a commercial gas leak detector or apply a soapy water solu-

tion to all the ﬁttings to check for gas leaks. Never use a ﬂame to test for leaks.

REQUIREMENTS FOR THE COMMONWEALTH OF MASSACHUSETTS

This product must be installed by a licensed plumber or gas ﬁtter when installed within the

Commonwealth of Massachusetts. If this appliance is installed in a dwelling, building or structure

used in whole or in part for residential purposes and the installation includes a horizontal vent

termination that is less than seven (7) feet above the ﬁnished grade in the area of the venting,

including but not limited to decks and porches, a hard-wired carbon monoxide detector with an

alarm and battery back-up must be installed on the ﬂoor level of the dwelling, building or struc-

ture where the appliance is to be installed.

Additionally, a hard-wired or battery operated carbon monoxide detector with an alarm must be

installed on each additional level of the dwelling, building or structure served by the appliance.

It shall be the responsibility of the property owner to secure the services of qualiﬁed licensed

professionals for the installation of hard-wired carbon monoxide detectors.

In the event that the horizontally vented appliance is installed in a crawl space or attic, the hard-

wired carbon monoxide detector with alarm and battery back-up may be installed on the next

adjacent ﬂoor level.

In the event that this requirement cannot be met at the time of completion of the installation of

the appliance, the owner shall have a period of thirty (30) days to comply with the requirement.

However, during said thirty

(30) day period, a battery operated carbon monoxide detector with alarm must be installed.

Each carbon monoxide detector as required in accordance with the above provisions must com-

ply with NFPA 720 and be ANSI/UL 2034 and IAS certiﬁed.

In addition when the stove is horizontally vented and the vent termination is less than seven (7)

feet above ﬁnished grade a metal or plastic identiﬁcation plate must be permanently mounted

to the exterior of the building at a minimum height of eight (8) feet above grade directly in line

with the exhaust vent terminal. The sign shall read, in print size no less than one-half (1/2) inch

in size, “GAS VENT DIRECTLY BELOW. KEEP CLEAR OF ALL OBSTRUCTIONS”.

A COPY OF THESE INSTRUCTIONS PLUS ALL VENTING INSTRUCTIONS WHICH INCLUDE PARTS

LISTS, AND/OR ALL VENTING DESIGN INSTRUCTIONS MUST REMAIN WITH THE STOVE AT THE

COMPLETION OF THE INSTALLATION.

ATTENTION INSTALLERS: Mark below which venting system was used in the installation. These

instructions must remain with the VIVA L Installation & Operation Manual.

To avoid confusion discard the all vent manufacturers instructions that do not apply to this

installation.

Simpson DuraVent GS AmeriVent Direct Selkirk DT

BDM Pro-Form DVS ICC EXCEL Direct OLYMPIA CHIMNEY SUPPLY Ventis

English RAIS

- U

ser manual for VIVA L Gas

16

VENTING

The VIVA L Gas Stove has been tested and listed for installation with 4” X 6

5/8” Simpson DuraVent GS®, AmeriVent Direct® , Selkirk DT® , BDM Pro-Form

DVS®, ICC EXCEL Direct® and OLYMPIA CHIMNEY SUPPLY Ventis® direct vent-

ing components. For speciﬁc installation requirements, follow the installation instruc-

tions included by the venting manufacturer with the venting system components you

have chosen. The total vent length may not exceed 50 feet (15m), including vertical rise

and horizontal run. The vent lengths are measured from the stove, not the ﬂoor. The

minimum vertical vent rise when using a vertical vent termination is 2 feet (600mm).

The minimum vertical rise required when using a horizontal vent termination is 2 feet

(600mm). The maximum allowed horizontal vent run is 12 feet (3.6m).

For venting system installation details, refer to the instructions provided with the

venting system you have chosen. Each brand has speciﬁc installation requirements that

must be followed to insure a safe and functional venting system for your VIVA L.

English RAIS

- U

ser manual for VIVA L Gas

17

Horizontal Wall Vent Termination

Flue sizing:

VIVA L : Ø4”x6 5/8”⅝ Connector on Appliance.

Ø4”x6 5/8”⅝Maybe used Throughout, Alternatively,

Ø5”x8” Expander may be used, so that Ø5”x8” ﬂue can be used

thereafter.

Flue Terminal: Ø4”x6 5/8” Alternatively, Ø5”x8” Maximum pipe extension, for out

side wall (H)

= 4 X Vertical Pipe Rise (V) -1. For Ø5”x8” ﬂue.

= 2 X Vertical Pipe Rise (V) . For Ø4”x6 5/8”⅝ﬂue.

Maximum Permissable run (H) =50 feet (15m).

Vertical Rise Horizontal Run

Ø5”x8” Flue

Horizontal Run

Ø 4”x6 5/8”⅝ Flue

Feet metres Feet metres Feet metres

1’ 0.3 3’5” 1.1 2’ 0.6

2’ 0.6 7’6” 2.3 4’ 1.2

3’ 0.9 11’6” 3.5 6’ 1.8

4’ 1.2 15’6” 4.7 8’ 2.4

5’ 1.5 19’6” 5.9 10’ 3.0

6’ 1.8 23’6” 7.2 12’ 3.7

7’ 2.1 27’6” 8.4 14’ 4.3

8’ 2.4 31’6” 9.6 16’ 4.9

9’ 2.7 35’6” 10.8 18’ 5.5

10’ 3.0 39’6” 12.0 20’ 6.1

11’ 3.4 43’6” 13.3 22’ 6.7

12’ 3.7 47’6” 14.5 24’ 7.3

13’ 4.0 50’ 15 26’ 7.9

14’ 4.3 50’ 15 28’ 8.5

15’ 4.6 50’ 15 30’ 9.1

16’ 4.9 50’ 15 32’ 9.8

17’ 5.2 50’ 15 34’ 10.4

18’ 5.5 50’ 15 36’ 11.0

19’ 5.8 50’ 15 38’ 11.6

20’ 6.1 50’ 15 40’ 12.2

21’ 6.4 50’

15 42’ 12.8

22’ 6.7 50’ 15 44’ 13.4

23’ 7.0 50’ 15 46’ 14.0

24’ 7.3 50’ 15 48’ 14.6

25’ 7.6 50’ 15 50’ 15

English RAIS

- U

ser manual for VIVA L Gas

18



6

2



7

6



6

2



7

6

Minimum Vertical Flue Height: - 2 feet (600mm)

Flue Restrictors to be ﬁtted, Ø 4”x6 5/8”⅝:

Vertical Rise < 3 feet (1m) - No Restrictor

Vertical Rise 3 – 8 feet (1-2m) - Ø62mm Restrictor

Vertical Rise > 8feet (2m) - Ø76mm Restrictor

Vertical Roof Vent Termination

Flue sizing:

VIVA L : Ø4”x6 5/8”⅝ Connector on Appliance.

Ø4”x6 5/8”⅝Maybe used Throughout, Alternatively,

Ø5”x8” Expander may be used, so that Ø5”x8” ﬂue can be used

thereafter.

Flue Terminal: Ø4”x6 5/8”⅝Alternatively, Ø5”x8”

Minimum Vertical Flue Height: - 20”(0.5m)

Flue Restrictors to be ﬁtted, Ø 4”x6 5/8”⅝:

Vertical Rise < 3 feet (1m) - No Restrictor

Vertical Rise 3 – 8 feet (1-2m) - Ø62mm Restrictor

Vertical Rise > 8feet (2m) - Ø76mm Restrictor

English RAIS

- U

ser manual for VIVA L Gas

19

Vertical Roof Termination

English RAIS

- U

ser manual for VIVA L Gas

20

Vertical Roof Termination on angle

English RAIS

- U

ser manual for VIVA L Gas

La page charge ...

RAIS Viva 100 L Classic Gas Installation & Operation Manual

Ce manuel convient également à

RAIS Viva 100 L Classic Gas Installation & Operation Manual

dans d''autres langues

Documents connexes

Autres documents