Thermador PRL304EH Manual and User Guide EN

For Thermador

Professional

®

PRO-HARMONY™ Gas Ranges

CARE AND USE MANUAL

Models /

Modèles:

P30

P36

Pour les cuisinières à gaz Thermador

Professional

®

PRO-HARMONY

TM

MANUEL D’UTILISATION ET

D’ENTRETIEN

— Do not store or use gasoline or other flam-

mable vapors and liquids in the vicinity of

this or any other appliance.

— WHAT TO DO IF YOU SMELL GAS

■ Do not try to light any appliance.

■ Do not touch any electrical switch.

■ Do not use any phone in your building.

■ Immediately call your gas supplier from a

neighbor’s phone. Follow the gas supplier’s

instructions.

■ If you cannot reach your gas supplier, call the

fire department.

— Installation and service must be performed

by a qualified installer, service agency or the

gas suppler.

WARNING:

If the information in this manual is not

followed exactly, a fire or explosion may

result causing property damage, personal

injury or death.

AVERTISSEMENT

L’information fournie dans le présent

manuel doit être rigoureusement suivie,

sous risque d'incendie ou d’explosion

susceptible d’entraîner des dommages,

des blessures ou la mort.

— N’entreposez pas et n’utilisez pas

d’essence ou autres produits inflammables

à proximité de la cuisinière ou de tout

autre appareil.

—

SI VOUS DÉTECTEZ UNE ODEUR

DE GAZ

■ N’allumez aucun appareil.

■ Ne touchez pas aux interrupteurs

électriques.

■ N’utilisez pas les téléphones du bâtiment.

■ Appelez immédiatement votre compagnie

de gaz de chez un voisin. Suivez les

instructions de la compagnie.

■ Si vous n’arrivez pas à contacter votre

compagnie de gaz, appelez les pompiers.

— L’installation et les réparations doivent être

réalisées par un installateur qualifié, un

centre de réparation agréé ou la compagnie

de gaz.

This Thermador Appliance is made by

BSH Home Appliances Corporation

5551 McFadden Ave.

Huntington Beach, CA 92649

Questions?

1-800-735-4328

www.thermador.com

We look forward to hearing from you!

Introduction ............................................... 1-2

Gas Type Verification ................................... 1

Section One: General Safety Instructions

Safety Precautions ....................................... 2 – 5

Section Two: Before You Begin

Before Using Your Range for the First Time ...... 6

Section Three: Description

Model & Parts Identification – 36" Range .............. 7

Model & Parts Identification – 30" Range .............. 8

Section Four: Using the Cooktop

Using the Cooktop ...................................... 9 – 11

Flame Setting Guidelines ................................. 11

Proper Cookware ..................................... 12 – 13

Surface Burner Cooking

Recommendations .................................. 14 – 15

Using the Grill . ......................................... 16 – 17

Grill Cooking Recommendations ..................... 18

About the Griddle.............................................. 19

Griddle Cooking Recommendations ................ 19

Section Five: Using the Oven

Bake ................................................................. 20

Convection ....................................................... 21

Convection Bake .............................................. 22

Setting Bake/Convection Bake ......................... 23

Other Uses of Bake ......................................... 24

Baking Recommendations............................... 25

Broil .................................................................. 26

Setting Broil ...................................................... 27

Broiling and Roasting Recommendations ....... 28

Section Six: Care and Maintenance

Range Cleaning Recommendations ........ 29 – 33

Section Seven: Before Calling For Service

Do-It-Yourself Maintenance .............................. 34

Before Calling For Service. .............................. 35

Data Rating Plate ............................................. 35

Warranty ..................................................... 36-37

Contents

INTRODUCTION

The Thermador Professional

®

Ranges are free-

standing units available in a number of configurations.

All models feature a gas cooking surface with a

professional size,

gas convection oven with broil

capability.

GAS TYPE VERIFICATION

Verify the type of gas supplied to the location. Ensure

that the appliance is connected to the type of gas for

which it is certified. Models come from the factory

certified for use with natural gas or with propane (LP)

gas. Make certain your range and gas type are the

same. Refer to the product rating label which can be

located as indicated on Page 37.

IMPORTANT

All ranges must be installed with a backguard.

The 30" model comes with a low back. For all

other models, one of three available backguards

must be ordered separately and installed at the

back of the range. The three backguard choices

include a Low Back, Pot and Pan Shelf, or Island

Trim. Before using the range, insure that it is

equipped with a proper backguard. DO NOT

attempt to use a backguard that is not designed

to fit your particular model range. Refer to the

Installation Instructions accompanying this ap-

pliance for more information.

1

CAUTION

When connecting the unit to propane gas, make

certain the propane gas tank is equipped with its

own high-pressure regulator in addition to the

pressure regulator supplied with the range. The

maximum gas pressure to this appliance

must not exceed 14.0 inches water column

(34.9 mb) from the propane gas tank to the

pressure regulator.

INTRODUCTION

WARNING

To avoid possible burn or fire hazard, a backguard

designed specifically for this range must be

installed whenever the range is used.

This manual contains important Care and Use

information for all Thermador Professional

®

Ranges.

When using this manual, it is critical that you know

the model number of your range, as some information

will be unique to each range. The model number may

be found on the rating plate located on the range as

identified on Page 35 of this manual. The charts on

the following pages summarize the various range

models and identify the features of each range.

GAS AND ELECTRICAL REQUIREMENTS AND GROUNDING INSTRUCTIONS

SECTION ONE: GENERAL SAFETY INSTRUCTIONS

Safety Precautions

SAVE THESE INSTRUCTIONS

It is the personal responsibility and obligation of you, the user, to have

this appliance connected to the electrical power supply in accordance

with the National Electrical Code and/or applicable local codes and

ordinances by a qualified electrician.

See Installation Instructions for electrical requirements and

grounding instructions.

It is recommended that a dedicated

circuit servicing this appliance be

provided.

The use of gas cooking appliances

results in the production of heat

and moisture.

30" Gas Model:

120 volts, 60 Hz.,

10 Amp electrical circuit required.

36" Gas Models:

120 volts, 60 Hz.,

10 Amp electrical circuit required.

36" gas range with electric griddle

- 20 Amp circuit required.

PLEASE READ CAREFULLY

If for any reason a gas control knob is turned ON and there is no

electrical power to operate the electronic igniters on the range's

cooktop burners, turn OFF the gas control knob and wait 5 minutes

for the gas to dissipate before lighting the burner manually.

To light the burners manually, carefully hold a lighted match to the

burner ports and turn the gas control knob to

. During a power

failure you can use the standard cooktop burners, but each must

be lit with a match.

DO NOT attempt to light the two left burners manually. These

burners are equipped with the ExtraLow

®

feature and cannot be lit

manually.

CAUTION - ALL MODELS

IN CASE OF AN ELECTRICAL FAILURE

FOR PERSONAL SAFETY,

THIS APPLIANCE MUST BE

CONNECTED TO A

PROPERLY GROUNDED

AND POLARIZED ELECTRICAL

POWER SUPPLY.

2

Accessible parts may

become hot when the grill

is in use. Young children

must be kept away.

TESTED IN ACCORDANCE WITH:

• ANSI Z21.1 for Household Gas

Appliances

• UL858 for Household Electric

Ranges

• CAN/CSA-22.2 No. 61-M89 for

Household Cooking Ranges

• CAN/CGA 1.1-M81 Domestic

Gas Ranges

Check your local building codes for

the proper method of installation.

In the absence of local codes, this

unit should be installed in

accordance with the National Fuel

Gas Code No. Z223.1 current issue

and the National Electrical Code

ANSI/NFPA No. 70 current issue

or the Can - B149 Installation Codes

for Gas Burning Appliances and

C22.1 Canadian Electrical Code

Part 1.

CAUTION

ALWAYS DISCONNECT THE

ELECTRICAL PLUG FROM THE

WALL RECEPTACLE BEFORE

SERVICING THIS UNIT.

WARNING

Safety Practices to Avoid

Personal Injury

When properly cared for, your

new

Thermador Professional

®

Range

has been designed to be a safe,

reliable appliance. However, use

extreme care when using this

restaurant caliber range as this

type of appliance provides intense

heat. When using kitchen

appliances, basic safety pre-

cautions must be followed,

including the following:

Read this Care and Use Manual

carefully before using your new

range to reduce the risk of fire,

electrical shock, or injury to

persons.

Insure proper installation and

servicing. Follow the installation

instructions provided with this

product. Have the range installed

and electrically grounded by a

qualified technician.

Have the installer show you where

the gas supply shut-off valve is

located so that you know how and

where to turn off the gas to the

range.

Do not repair or replace any part of

the appliance unless specifically

recommended in this manual. All

other servicing should be referred

to a qualified technician.

Children should not be left alone

or unattended in an area where

appliances are in use. They should

never be allowed to sit or stand on

any part of the appliance. If

children are allowed to use the

appliance, they must be closely

supervised.

CAUTION: Do not store items of

interest to children above or at the

back of the range. If children should

climb onto the appliance to reach

these items, they could be

seriously injured.

When children become old enough

to operate the appliance, it is the

legal responsibility of the parents

or legal guardians to ensure that

they are instructed in safe

practices by qualified persons.

Never use any part of the range or

oven for storage. Flammable

materials can catch fire and plastic

items may melt or ignite.

Do not hang articles from any part

of the appliance or place anything

against the oven. Some fabrics are

quite flammable and may catch on

fire.

If the range is near a window, be

certain the curtains do not blow

over or near the range burners;

they could catch on fire.

Have an appropriate fire

extinguisher available, nearby,

highly visible and easily accessible

near the appliance. DO NOT USE

WATER ON GREASE FIRES.

Turn appliance off and smother

fire with baking soda or use a dry

chemical or foam-type

extinguisher. Never let clothing,

potholders, or other flammable

materials come in contact with or

too close to any infrared burner,

top burner or burner grate until it

has cooled. Fabric may ignite and

result in personal injury.

Use only dry potholders: moist or

damp potholders on hot surfaces

may cause burns from steam. Do

not use a towel or other bulky cloth

in place of potholders. Do not let

potholders touch hot infrared

burners, hot burners, or burner

grates.

For personal safety, wear proper

apparel. Loose fitting garments or

hanging sleeves should never be

worn while using this appliance.

Some synthetic fabrics are highly

flammable and should not be worn

while cooking.

Do not use aluminum foil to line

any part of the oven or range. Use

of a foil liner could result in a shock

or fire hazard, or the obstruction of

the flow of combustion and

ventilation air. Foil is an excellent

heat insulator and heat will be

trapped beneath it. This will upset

the cooking performance and can

damage the finish of the oven or

the range.

SECTION ONE: GENERAL SAFETY INSTRUCTIONS

3

WARNING

RANGE TIPPING HAZARD

• All ranges can tip and injury can result. To prevent

accidental tipping of the range, attach it to the floor, wall

or cabinet by installing the Anti-Tip Device supplied.

• A risk of tip-over may exist if the appliance is not

installed in accordance with these instructions.

• If the range is pulled away from the wall for cleaning,

service or any other reason, ensure that the Anti-Tip

Device is properly reengaged when the range is pushed

back against the wall. In the event of abnormal usage

(such as a person standing, sitting, or leaning on an

open door), failure to take this precaution can result in

tipping of the range. Personal injury might result from

spilled hot liquids or from the range itself.

WARNING

NEVER cover any slots, holes

or passages in the oven

bottom or cover an entire rack

with materials such as

aluminum foil. Doing so blocks

air flow through the oven and

may cause carbon monoxide

poisoning. Aluminum foil

linings may also trap heat,

causing a fire hazard.

SECTION ONE: GENERAL SAFETY INSTRUCTIONS

Safety Precautions

WARNING: The appliance

is for cooking. Based on safety

considerations, never use

the oven or cooktop to warm or

heat a room. Also, such use can

damage the cooktop or oven

parts.

Avoid using high flame setting with

a pan larger than the grate or with

one that spans more than one

burner, such as a griddle, for

prolonged periods of time. This

can result in poor combustion that

generates harmful by-products.

Use caution to insure that drafts

like those from forced air vents or

fans do not blow flammable

material toward the flames or push

the flames so that they extend

beyond the edges of the pot.

Always use utensils that have flat

bottoms large enough to cover the

burner. The use of undersized

utensils could expose a portion of

the flame and may result in ignition

of clothing.

Do not use flammable cleaners to

clean the range.

To minimize the risk of burns,

ignition of flammable materials and

unintentional spillage, position

handles of utensils inward so they

do not extend over adjacent work

areas, cooking areas, or the edge

of the range's cooktop.

Hold the handle of the pan to

prevent movement of the utensil

when stirring or turning food.

DO NOT use pots or pans on the

grill section.

Do not use the grill for cooking

excessively fatty meats or

products which promote flare-ups.

The optional cutting board

accessory must be removed

before operating the griddle

beneath or burners adjacent to it.

GREASE IS FLAMMABLE. Let

hot grease cool before attempting

to handle it. Avoid letting grease

deposits collect. Clean after each

use.

For proper lighting and

performance of the burners, keep

the igniter ports clean. It is

necessary to clean these when

4

WARNING

After a spill or boil over, turn off

the burner and clean around the

burner and burner ports. After

cleaning, check for proper

operation.

Clean the range with caution.

Avoid steam burns; do not use a

wet sponge or cloth to clean the

range while it is hot. Some cleaners

produce noxious fumes if applied

to a hot surface. Follow directions

provided by the cleaner man-

ufacturer.

Be sure all cooktop controls are

turned off and the cooktop is cool

before using any type of aerosol

cleaner on or around the cooktop.

The chemical that produces the

spraying action could, in the

presence of heat, ignite or cause

metal parts to corrode.

When using the oven:

DO

NOT TOUCH THE INFRARED

BURNER, THE INTERIOR

SURFACES OF THE OVEN OR

THE EXTERIOR AREA IM-

MEDIATELY SURROUNDING

THE DOOR. Interior oven surfaces

become hot enough to cause

burns. The heat deflector, which

deflects heat away from the

cooktop and the trim on the top

and sides of the oven door, will

also be hot when the oven is in

use.

Place oven racks in desired

position while oven is cool. If a

rack must be moved while the

oven is hot, do not let the

potholders contact the infrared

burner.

Use care when opening the oven

door; let hot air or steam escape

before removing or replacing foods.

WARNING

NEVER use this appliance as

a space heater to heat or

warm the room. Doing so may

result in carbon monoxide

poisoning and overheating of

the oven.

When using the cooktop: DO NOT

TOUCH THE BURNER

GRATES OR THE IMMEDIATE

SUR- ROUNDING AREA. Areas

adjacent to the burners may

become hot enough to cause

burns.

Never leave the range

unattended when using high

flame settings. Boil overs cause

smoking and greasy spillovers that

may ignite. More importantly, if the

burner flames are smothered,

unburned gas will escape into the

room. See Inside Front Cover

regarding gas leaks.

Only certain types of glass,

heat-proof glass-ceramic,

ceramic, earthenware, or other

glazed utensils are suitable for

cooking on the range burners.

This type of utensil may break

with sudden temperature

changes. Use only on low or

medium heat settings according

to the utensil manufacturer’s

directions.

Do not heat unopened food

containers; a buildup of pressure

may cause the container to burst.

During cooking, set the burner

control so that the flame heats

only the bottom of the pan and

does not extend beyond the bottom

of the pan.

there is a boil over or when the

burner does not light even though

the electronic igniters activate. See

Page 31.

SECTION ONE: GENERAL SAFETY INSTRUCTIONS

Safety Precautions

Do not clean, rub, damage,

move or remove the door

gasket. It is essential for a good

seal during baking. If the gasket

becomes worn or excessively

soiled with food particles, replace

gasket to assure a tight seal.

DO NOT obstruct the flow of

combustion or ventilation air.

For safety reasons and to avoid

equipment damage, never sit,

stand, or lean on the oven door.

Service should only be done by

authorized technicans. Techni-

cians must disconnect the power

supply before servicing this unit.

Listen to be sure the cooling blower

runs whenever the oven controls

are set to broil or bake modes. If

the fan does not operate, do not

use the oven. Call an authorized

5

service center for service.

Clean the ventilator hood and filters

above the range frequently so

grease from cooking vapors does

not accumulate on them.

• In case of fire or when inten-

tionally “flaming” liquor or

other spirits on the range's

cooktop, follow hood man-

ufacturer’s instructions.

California Proposition 65

Warning: The burning of gas

cooking fuel generates some by-

products which are on the list of

substances which are known by

the State of California to cause

cancer or reproductive harm.

California law requires businesses

to warn customers of potential

exposure to such substances. To

minimize exposure to these

substances, always operate this

unit according to the instructions

contained in this booklet and

provide good ventilation to the

room when cooking with gas.

BEFORE USING YOUR RANGE FOR THE FIRST TIME, CHECK THAT YOU HAVE THESE ITEMS:

*

Backguard must be ordered and shipped separately. It is

not included with the range shipment.

DESCRIPTION

Oven Racks 3 3 3 3

Two-Piece Broil Pan 1 1 1 1

Star Burner Caps 4 4 4 6

Center Grate 1

Burner Grates 2 2 2 3

Control Knobs 5 6 6 7

Coated Titanium Grill 1

Coated

Titanium

Griddle

1

Product Registration Card 1 1 1 1

Backguard 1 * * *

Installation Instructions 1 1 1 1

Use and Care Manual 1 1 1 1

WARNING:

To avoid possible burn or fire

hazard, a backguard designed

specifically for this range must

be installed whenever the range

is used.

30"

4-Burner

36" w/

Griddle

36" w/

Grill

36"

6-Burner

SECTION TWO: BEFORE YOU BEGIN

1. Check that you have the items listed on Page 5.

2. Record the Model and Serial number on

Page 35. See "Data Rating Plate." These may

be used for any future contacts with Customer

Service. Enter this information on the Product

Registration Card included with this product then

mail it to the indicated address.

3. Optional Accessories. Grill Plate, Gas Black

Knob Kit, Chopping Board, Griddle Cover, Wok

Support Ring and other accessories are avail-

able from your Thermador Dealer.

4. Position the racks correctly in the oven.

The correct rack position depends on the recipe

and the cooking mode. The rack positions are

numbered from the bottom of the oven, like an

elevator. Rack position 3 is the most frequently

used position. Place rack(s) in the proper posi-

tion before turning on the oven.

Insert the racks as follows:

a. Hold the rack with the back rail in the up

position towards the rear of the oven. Slip it

into the oven so the rack slides are between

the rack and the rack guides.

b. Tip the front of the rack up slightly as it slides

into the oven so that the safety stops clear the

rack slides. The safety stops on the back of

the rack will keep it from sliding out of the

oven when it is pulled forward.

5. Ensure that the burner caps are correctly

seated on the burner bases of the range's

cooktop. Turn on each burner to check for

proper flame color. See Page 11 for details.

Remove all packaging materials

and temporary labels from oven

and cooktop.

6

Before Using Your Range for the First Time

BEFORE BAKING OR BROILING, the oven and

broiler should be turned on to burn off the manufac-

turing oils. Turn the oven on to 450°F (230°C) for 20

to 30 minutes; then turn the broiler to "Broil" for same

length of time. You may wish to turn on the ventilator

above your range during this time. Please note that it

is normal for small amounts of smoke to be visible

from the range, during this initial breaking-in process.

Please read Page 33 in Section 6: Care and

Maintenance before cleaning the oven racks.

Aluminum foil should never be used to cover

the oven racks or to line the oven. Do not

remove the infrared burner in the gas oven.

1

2

3

4

5

Oven Rack Positions

CAUTION

1. 22" Pot and Pan Shelf,

9" Low Back or 3" Island Trim

(Backguard ordered separately)

2. Burner Grates & Burners

3. Control Knob, ExtraLow

®

Burners (2)

4. Control Knobs, Standard Burners (4)

5. Oven Temperature Selector

6. Oven Selector Switch

7. Oven Door

8. Viewing Window

9. Kick Panel

10. Range Feet (4)

Key for 36" Models

SECTION THREE: DESCRIPTION

Model and Parts Identification

Gas Oven Interior

11. Oven Interior Light

12. Broil Burner

13. Oven Thermostat Sensor

14. Rack Guides

15. Oven Racks (3 included)

16. Bake Burner (hidden)

17. Convection Fan Cover

18. Broil Glow Igniter

7

1

2

5

2

3

6

2

4

10

8

7

9

10

11

12

13

14

15

16

17

WARNING:

To provide proper

ventilation, do NOT

remove range feet.

18

4

SECTION THREE: DESCRIPTION

Model and Parts Identification

1. 6" Low Back - shown

(Island Trim and Pot and Pan Shelf

ordered separately)

2. Burner Grates & Burners

3. Control Knob, ExtraLow

®

Burners (2)

4. Control Knobs, Standard Burners (2)

5. Oven Temperature Selector

6. Oven Selector Switch

7. Oven Door

8. Viewing Window

9. Kick Panel

10. Range Feet (4)

Key for 30" Model

8

1

2

3

4

5

6

7

8

9

10

Gas Oven Interior,

Please see Page 7.

WARNING:

To provide proper ventila-

tion, do NOT remove range

feet.

4

SECTION FOUR: USING THE COOKTOP

SEALED BURNERS

Using the Cooktop

The cooktop features four or six

gas surface burners; each rated

at 15,000 BTU/HR(13,000 BTU/

HR using Propane). The burners

are sealed to the stainless steel

top frame to prevent liquid spills

from accumulating below the top

surface, making it easier to clean.

On all models, the two left burners

have the exclusive ExtraLow

feature, the remaining burners are

standard. Each burner has its own

control knob.

CONTROL KNOBS

The two words above each control

knob identifies the burner position.

For example, LEFT FRONT,

RIGHT FRONT, etc.

Standard Burner

Control Knob

Bezel

Knob

The control knobs for two sealed

gas burners, one in front and one

in the rear, are located directly in

front of and below the pair of

burners on the control panel.

OPERATION OF THE

BURNERS

• Press in on the knob and turn it

counter-clockwise to the

setting.

• The igniter for the selected

sealed burner clicks and

sparks.

• After flame ignition, the igniter

stops clicking.

• Rotate the knob to any flame

setting between HI and SIM.

• The Blue Burner Signal Light,

between the burners, will light

when adjacent burners are lit.

They will remain on until the

burner is turned off.

BTU Output for Standard Burners

• HI is equivalent

to

15,000 BTU

/

HR (13,000 BTU/HR using

Propane).

• SIM is equivalent to 2,100 BTU

/

HR.

BTU Output for ExtraLow

®

Burner

• HI is equivalent to

15,000 BTU

/

HR (13,000 BTU/HR using

Propane).

• SIM is equivalent to

3,000 BTU

/

HR.

• XLO is equivalent to

370 BTU

/

HR.

ExtraLow

®

Burners

The control for the two left burners,

front and rear, have flame settings

even lower than the standard SIM

settings.

The drawing shows that the

control knob has an additional

range between the SIM and XLO

settings. When the knob is set

within this range, the flame cycles

off and on. By varying the length

of time the flame is off and on, the

heat is reduced even further to

cook delicate foods. For example,

these very low settings are

suitable for simmering and

poaching, melting chocolate and

butter, holding cooked foods at

temperatures without scorching or

burning, etc.

9

Sealed Star

®

Brass Burner Base

Setting Indicator

ExtraLow

®

Burner

Control Knob

ExtraLow

®

Range

10

SECTION FOUR: USING THE COOKTOP

Operation of the ExtraLow

Burners

• XLO, the very lowest setting, is

achieved by cycling the flame

ON for approximately 8

seconds and OFF for 52

seconds of each minute.

• When the knob is set just below

the SIM setting, the flame will

cycle ON for approximately 52

seconds and OFF for 8

seconds of each minute.

• To vary the amount of low heat

to suit the food and quantity, the

control can be set anywhere

within the SIM and XLO range

marked on the knob.

• The number and dash

designations, shown in the

drawing, are for reference only.

Numbers do not actually

appear on the knob. The

number indicates the position

of the flame setting as

represented on the cooking

chart, Pages 14 and 15, with

the flame on longer at the #4

setting than on #1 setting.

ExtraLow Techniques

• The type and quantity of food

affects which setting to use.

• The pan selected affects the

setting. Its size, type, material,

and whether a lid is used, all

affect the consistency of the

cooking temperature.

• To maintain a low or simmer

heat, bring food to a rolling boil.

Stir well, then cover the pan and

lower the heat to a setting just

below SIM.

• Check periodically to see if the

control knob should be turned

to another setting.

• If an over-size pan is used, the

simmer action may occur

mainly in the center of the pan.

To equalize the temperature

throughout the food, stir the

food around the outer edges of

the pan into the food in the

center.

• It is normal to stir food

occasionally while simmering.

This is especially important

when simmering for several

hours, such as for a homemade

spaghetti sauce or beans.

• When lowering the flame

setting, adjust it in small steps.

• If the setting is too low to hold

a simmer, bring the food back

to a boil before re-setting to a

higher heat.

• It is normal not to see simmer

bubbles immediately after the

food has been stirred.

• There may be bubbling when

the flame cycles ON and no

bubbles when the flame is OFF.

Even when the flame is OFF,

there will be steam and a slight

quiver on the liquid’s surface.

Each burner has its own electronic

igniter that sparks when the

burner is turned on. Each burner

should light in 4 seconds or less.

If a burner does not light, check

to see that the cap is positioned

correctly on the base.

If a burner fails to ignite, refer to

the section on Page 35, “Before

Calling for Service.”

BURNER CAP

Ports

IGNITER

Star

®

Burner

Components

Burner

Cap

Brass

Burner

Base

ExtraLow Settings

1

2

3

4

CAUTION

Do not touch the burners

when the igniters are

sparking.

11

AUTOMATIC RE-IGNITION

If any one or more burners or grill

blow out, the electronic igniter

automatically activates to re-light

the flame.

Do not touch the burners

when the igniters are active.

IMPORTANT:

• For proper combustion do not

use the cooktop without the

burner grates in place.

• There is a slight sound

associated with gas

combustion and ignition. This is

a normal condition.

• On cooktops using propane

gas (LP), a slight “pop” sound

may be heard at the burner

ports a few seconds after the

burner has been turned off.

FLAME DESCRIPTION

• The burner flame color should

be blue with no yellow on the

tips. It is not uncommon to see

orange in the flame color; this

indicates the burning of

airborne impurities in the gas

and will disappear with use.

• With propane (LP) gas, slight

yellow tips on the

primary cone

are normal.

• The flame should burn

completely around the burner

cap. If it doesn’t, check that the

cap is positioned correctly on

the base and that the ports are

not blocked.

• The flame should be stable with

no excessive noise or fluttering.

FLAME HEIGHT

• The correct flame height

depends on 1) size and

material of pan being used; 2)

food being cooked; and 3)

amount of liquid in the pan.

• Never extend the flame beyond

the base of the pan.

• Use a low or medium flame for

pan materials that conduct the

heat slowly, such as porcelain

coated steel or glass-ceramic.

POWER FAILURE

• In the event of a power failure,

only the standard burners can

be manually lit. It is necessary

to light each one individually.

• If the cooktop is being used

when the power failure occurs,

turn all knobs to the OFF

position.

• The standard burners can be lit

by holding a match at the ports

and turning the control knob to

the

position. Wait until the

flame is burning all around the

burner cap before adjusting the

flame to the desired height.

• Neither ExtraLow burner can be

used during a power failure. Be

sure to turn them off.

• If either ExtraLow burner is on

when a power failure occurs,

they cannot be turned back on

until both knobs are first turned

off.

• The griddle or grill cannot be

used during a power failure.

• If you smell gas, refer to safety

precautions listed inside the

front cover.

Flame Color

Secondary

Cone

Primary

Cone

Light Blue

Dark Blue

WARNING

In the event of a power failure,

all knobs are to be turned to the

OFF Position. Only the

standard burners can be lit

manually.

SECTION FOUR: USING THE COOKTOP

12

SECTION FOUR: USING THE COOKTOP

Cookware Recommendations

• Select the base diameter to match the diameter

of the flame. The diameter of the flame should be

the same size as the pan base or slightly smaller.

Oversize or under size pans sacrifice cooking

performance. A 5

-1

/2" (140 mm) base size is

generally the smallest recommended.

• Professional quality pans with metal handles are

recommended because plastic handles can melt

or blister, if the flame extends up the side of the

pan. Professional quality pans are found at

restaurant supply stores and gourmet specialty

shops. All cookware should have these

characteristics: good heat conductivity, good

balance, correctly sized base diameter, a heavy,

flat base, and a proper fitting lid. For best cooking

results, the flame should be contained under the

bottom of the pan.

• Aluminum and copper are pan materials that

conduct the heat quickly and evenly. These metals

are sometimes attached to the base or in the core

between stainless steel.

• Balance is important for stability and even cooking.

The handle must not be heavier than the pan and

tilt it unevenly. A pan must sit level on the grate

without rocking or wobbling.

• Placements of large stock pots should be

staggered when used on the cooktop.

• Bakeware, such as large casserole pans, cookie

sheets, etc. should never be used on the cooktop.

• A heavy, flat base is more apt to remain flat when

heated. Pan bases that are warped, dented, ridged

or too lightweight will heat unevenly. Heat and cool

pans gradually to avoid sudden temperature

changes which tend to distort cookware. Do not

add cold water to a hot pan.

• A properly fitting lid will shorten cooking time and

make it possible to use lower heat settings.

BALANCED PAN

BASE DIAMETER

FLAT BASE PAN

COVERED PAN

(51 mm)

CAUTION

• Food packaged in aluminum foil should not

be placed directly on the burner grate.

Aluminum foil can melt during cooking.

• Do not let plastic, paper or cloth come in

contact with a hot burner grate. They may

melt or catch fire.

• Never let a pan boil dry. This can damage

your pan and the cooking surface.

13

SECTION FOUR: USING THE COOKTOP

FLAT-BOTTOM WOK PAN

Specialty Cookware

COOKING

RECOMENDATIONS

SUGGESTIONS FOR USING THE RECOM-

MENDATIONS

Use the chart on Pages 14 and 15 as a guide. The

settings you use will vary depending on the pans

selected and the starting temperature of the food.

On the chart, the “Finish Setting” has been separated

for the standard and ExtraLow burners. There may

or may not be a change between the two burner

settings.

The ExtraLow setting can be either a cooking or a

holding setting.

Raise or lower the flame setting gradually. Allow time

for the pan and the food to adjust to the new setting.

ROUND-BOTTOM WOK

IN SUPPORT RING

• Woks – Either flat based or round bottom woks

with the accessory ring can be used on models

without a built-in wok burner. Round bottom woks

must be used with a support ring. The porcelain-

coated cast iron wok support ring must be

purchased separately.

• Canners and Stock Pots – Select one with a base

diameter that extends no more than 2 inches

(51mm) beyond the grate.

Standard Size Water Bath Canner

21 to 22 quarts (19.95 to 20.9 liters),

with an 11 to 12 inch base (279 to 305 mm) and

a 9 to 11 inch depth (229 to 279 mm).

Standard Size Pressure Canner

8 to 22 quarts (7.6 to 20.9 liters), with an

8 to 11 inch base (203 to 279 mm) and

a 6

-1

/2" to 12 inch depth (165 - 305 mm).

CANNING TIPS:

• A flat base pan is preferred to one with a concave,

convex or rippled base.

• When using two canners at the same time, use

staggered burners. Do not block air to the burners.

A flame needs the right amount of air for complete

combustion.

• Use a cover on a canner when bringing the

contents to a boil.

• Once the contents have reached a boil on HI, use

the lowest flame possible to maintain the boil or

pressure.

• Canning produces a large amount of steam. Take

precautions to prevent burns.

14

SECTION FOUR: USING THE COOKTOP

Surface Burner Cooking Recommendations

BEVERAGES MED – heat milk, SIM – finish heating XLO – keep warm,

Cocoa cover cover*

BREADS MED – preheat skillet MED LO to MED – Same as Standard

French Toast, Pancakes, cook

Grilled Sandwiches

BUTTER 4 to 3 – allow 5 to 10

Melting XLO – to hold minutes to melt

CEREALS HI – cover, bring MED LO to MED – XLO – to hold, cover*

Cornmeal, Grits, water to a boil, add finish cooking

Oatmeal cereal

according to package

directions

CHOCOLATE Use XLO 2 to XLO – allow 10

Melting to 15 minutes to melt

XLO – to hold*

DESSERTS MED LO to MED – MED LO to MED Same as Standard

Candy cook following recipe

Pudding and Pie Filling MED LO SIM MED LO

Mix cook according to

package directions

Pudding MED LO – Bring milk SIM MED LO – to cook

to a boil

EGGS MED HI –

cover, bring

Use XLO XLO– cook 3 to 4

Cooked in Shell water to a boil, add minutes for soft cooked;

eggs, cover or 15 to 20 minutes for

hard cooked

Fried, Scrambled MED – SIM to MED LO XLO– to hold for a

melt butter, add eggs finish cooking short period*

Poached HI – bring water to MED to MED HI – Same as Standard

the boiling point, finish cooking

add eggs

MEAT, FISH, POULTRY HI – until meat starts MED LO to MED – Same as Standard

Bacon, Sausage Patties to sizzle finish cooking

Braising: Swiss Steak, HI – melt fat, then Use XLO 3 to 2 –

Pot Roast, Stew Meat brown on MED HI to simmer until tender

HI, add liquid, cover

Quick Frying: Breakfast MED HI to HI – MED HI to HI – Same as Standard

Steaks preheat skillet fry quickly

Frying: Chicken HI – heat oil, then SIM – cover, finish Same as Standard

brown on MED cooking

Deep Frying: Shrimp HI – heat oil MED HI – to Same as Standard

maintain temperature

Pan Frying: Lamb Chops,

HI – preheat skillet MED HI to HI – 4 to 3 – to hold, covered

Thin Steaks, Hamburgers,

brown meat 4 to 3 – t

o hold, uncovered

Link Sausage

Poaching: Chicken, HI – Cover, bring Use XLO 4 to 3 – to finish cooking

whole or pieces, Fish liquids to a boil

Food Start Setting Finish Setting Finish Setting

Standard Burners ExtraLow® Burners

15

SECTION FOUR: USING THE COOKTOP

Surface Burner Cooking Recommendations

* It is recommended that these foods be stirred occasionally.

Simmering: Stewed HI – cover, 4 to 1 – simmer slowly

Chicken, Corned Beef, bring liquid

Tongue, etc. to a boil

PASTAS HI – bring water to a MED HI to HI – to

Same as for Standard Burners

Macaroni, Noodles, boil, add pasta

maintain a rolling boil

Spaghetti

POPCORN (use a heavy, HI – cover, heat until MED HI to HI –

Same as for Standard Burners

flat bottom pan) kernels start to pop finish popping

PRESSURE COOKER Med. HI to HI – build MED LO to MED –

Same as for Standard Burners

Meat up pressure maintain pressure

Vegetables HI – build up pressure MED LO to MED –

Same as for Standard Burners

maintain pressure

RICE HI – cover, bring 4 to 2 – cook according

water to a boil, add to package directions

rice, cover XLO – to hold, cover

SAUCES Med. HI to HI – cook 2 to XLO – simmer

Tomato Base meat/vegetables, (2 to 3 to thicken sauce,

follow recipe uncovered).

White, Cream, Bernaise, Med. LO – melt fat, SIM to MED LO – XLO – to hold, cover*

follow recipe finish cooking

Hollandaise XLO to SIM XLO XLO –

t

o hold, lowest setting

SOUPS, STOCK HI – cover, bring 3 to 2 – simmer

liquid to a boil XLO – to hold, cover*

VEGETABLES HI – cover, bring MED LO to MED – XLO – to hold, cover

Fresh water and vegetables

cook

10

to

30

minutes,

to a boil or until tender

Frozen HI – cover, bring MED LO to MED –

Same as for Standard Burners

water and vegetables cook according to

to a boil package directions

Deep Frying HI – heat oil MED to MED HI –

Same as for Standard Burners

maintain frying

temperature

In Pouch HI – cover, bring SIM to MED LO –

Same as for Standard Burners

water and vegetables cook according to

to a boil package directions

Saute HI – heat oil or melt MED LO to MED –

Same as for Standard Burners

butter, add vegetables cook to desired

doneness

Stir Fry HI – heat oil, add MED HI to HI –

Same as for Standard Burners

vegetables finish cooking

Food Start Setting Finish Setting Finish Setting

Standard Burners ExtraLow

®

Burners

16

THE GRILL

(Available on some models)

When cooking food on the grill you

will achieve the same flavor as

meat cooked on an outdoor grill.

This flavor is actually created by

the fats and juices that are brought

to the surface of the food and

seared

by

the

heat from the grill

plate.

Your new Thermador Professional

®

grill is equipped with an aluminized

steel tube burner typical of those

used in restaurants. Automatic

ignition is used to eliminate the

continuous pilots found on

restaurant grills. The grill burner is

rated at 12,000 BTU/HR (same

rating using Propane).

AUTOMATIC

REIGNITION

The electronic igniter auto-

matically glows to light the

burner. DO NOT TOUCH any

burner while the igniter is

active.

A VENTILATING HOOD of adequate cubic-feet-per-minute capacity vented to the outside of the house

is recommended for installation ABOVE THE RANGE. For most kitchens with a wall mounted hood, a

certified hood

is recommended. The hood must be installed according to installation instructions

furnished with the hood and local building code requirements. Refer to ventilation requirements in the

Installation Instructions for additional information.

CONTROL KNOB

The burner control has an infinite

number of heat settings, and there

are no fixed positions on the control

knob between HI and LO. To turn

the burner on, press the control

knob and rotate it counter-

clockwise to the

position. After

the flame is completely around the

burner, adjust the knob to the

desired heat setting.

Control Knob

NOTE: When used with pro-

pane gas, a slight pop or

flash may occur at the burner

ports a few seconds after the

burner has been turned off.

This usually occurs after the

burner has been on awhile.

This is normal.

BURNER EFFICIENCY AND

FLAME CHARACTERISTICS

The burner flame should be blue in

color and stable with no yellow

tips, excessive noise or lifting. It

should burn completely along both

sides of the burner tube.

An improper gas-air mixture may

cause either a yellow tipped flame

or burner flutter. Have the flame

adjusted by a technician. Foreign

particles may cause an orange

flame during initial use. This will

disappear with use.

If the flame is uneven, flutters,

makes excessive noise or lifts,

check to see if the BURNER ports

are clogged. If the ports are

clogged, use a wire, a straightened

paper clip or needle to clear the

ports. If the condition persists,

contact a service agency for

adjustment.

Using the Gas Grill

SECTION FOUR: USING THE COOKTOP

Grill

17

Using the Grill

GRILLING SUGGESTIONS

• Trim any excess fat from the meat before cooking. Cut slits in

the remaining fat around the edges at 2" (51 mm) intervals.

• Brush on basting sauce toward the end of cooking.

• Use a spatula or tongs instead of a fork to turn the meat.

A fork

punctures the meat and lets the juices run out. Be cautious

when turning meat over.

• The grill grate has sides and a rear food guard that are de-

signed to make foods easier to turn with a spatula.

• After the juices begin to bubble to the surface, turn the meat

only once. This helps keep the juices in the meat.

• Some pieces of meat and poultry cook faster than others. Move

those pieces to the cooler area of the grill until the rest have

finished.

• The doneness of meat is affected by the thickness of the cut.

Chefs say it is impossible to have a rare doneness with a thin

cut.

• Add seasoning or salt after grilling.

COOKING ON THE GRILL

• Preheat grill on HI setting for 10

to 15 minutes minimum.

The

hot grill sears the food, sealing

in the juices. The longer the

preheat, the faster the meat

browns and the darker the grill

marks.

• Grilling requires high heat for

searing and proper browning.

Most foods are cooked at the

higher heat settings for most of

the cooking time. However, for

some foods, it may be

necessary to turn the heat to a

lower setting after the initial

browning. This cooks the food

through without burning the

outside.

• Foods cooked for a long time

or basted with a sugary

marinade many need a lower

heat setting near the end of the

cooking time.

• When the grill has cooled,

empty the grease into a grease

resistant container. Clean the

grease tray and grill plate with

warm, soapy water and rinse

with clear water.

• The grease tray may be placed

in the dishwasher for cleaning.

SECTION FOUR: USING THE COOKTOP

CAUTION:

• Do not leave the grill unattended while in

use.

• If childred are allowed to use the grill, they

must be closely supervised.

DESCRIPTION

The built-in grill is made of restaurant-quality

aluminum that is coated with titanium. This produces

a surface with even heat that is easy to clean.

A maple chopping block and stainless steel cover

are available as accessories and are purchased

separately. Both are sized to fit on top of the surface

when the grill is not being used.

The maple chopping block and stainless steel cover

must be removed before turning the grill on.

PREPARING THE GRILL

The grill must be tilted slightly forward for optimum

performance. See Installation Manual for procedure

to check and adjust the grill for proper tilt of the grill

plate. During installation, the installer is responsible

for leveling the product. The grill plate should be

washed with warm soapy water then rinsed with clear

water prior to use.

SECTION FOUR: USING THE COOKTOP

GRILL GREASE TRAY

• Push the tray under the front edge of the grill

overhang to catch grease or food residue.

• Clean the tray after every use. When removing

the tray, use care when tipping it so that the

contents do not spill.

• After cooling, pour the grease into a grease

resistant container for disposal.

About the Gas Grill

CAUTION:

The grill is hot after use. Allow sufficient

time for grill components to cool before

cleaning.

Push grease tray

forward before use.

Grill Grease Tray

18

Grill Plate

Food Guard

GRILL COOKING RECOMMENDATIONS

Before cooking, verify that the grill is properly

assembled. The food guard must be positioned at the

back of the grill plate, as shown in the illustration.

Any utensil may be used on the grill surface.

Care should be taken that the surface is not gouged.

FOOD SETTING TIME (minutes)

Breakfast Sausage

Boneless Chicken Breast

Boneless Pork Chops (1"thick)

Ham slices (1/2"thick)

Filet Mignon (1-1/2" thick)

T-Bone Steak (1" thick)

Salmon Steak (1" thick)

Italian Sausage

Ground Beef Patties (6 oz)

Hot Dogs

Skewered Shrimp

Sliced Fruits or Vegetables

Medium - High

High

Medium

High

Medium

Low - Medium

7 to 11

17 to 23

17 to 20

6 to 8

13 to 18

15 to 20

17 to 20

13 to 16

10 to 15

7 to 12

6 to 8

6 to 10

La page charge ...

Thermador PRL304EH Manual and User Guide EN

Thermador PRL304EH Manual and User Guide EN

dans d''autres langues

Documents connexes

Autres documents