Thermador Range PD48 Manuel utilisateur

CARE AND USE MANUAL

Models

PD304

PD36

PD48

For Thermador

Professional

®

Dual Fuel Ranges

A Special Message to our Customers

Thank you for selecting the Thermador Professional

®

Range. We recommend that you take

time to read this entire booklet before using your new appliance for the first time.

The booklet contains suggestions we believe will be helpful as well as directions for using all

the features of this range. Keep it in a handy place, as it has the answers to questions that

may occur when you start to cook.

Let us know if we can help you. When you write, please include the model and serial number

of your range.

Sincerely,

Thermador Consumer Scientists

WARNING:

If the information in this manual is not

followed exactly, a fire or explosion may

result causing property damage, personal

injury or death.

— Do not store or use gasoline or other flam-

mable vapors and liquids in the vicinity of this

or any other appliance.

— WHAT TO DO IF YOU SMELL GAS

■ Do not try to light any appliance.

■ Do not touch any electrical switch.

■ Do not use any phone in your building.

■ Immediately call your gas supplier from a

neighbor’s phone. Follow the gas supplier’s

instructions.

■ If you cannot reach your gas supplier, call the

fire department.

— Installation and service must be performed

by a qualified installer, service agency or the

gas suppler.

AVERTISSEMENT

L’information fournie dans le présent

manuel doit être rigoureusement

respectée, sous peine d’un incendie ou

d’explosion susceptible d’entraîner des

dommages, des blessures ou la mort.

— N’entreposez pas et n’utilisez pas

d’essence ou autres produits inflammables

dans le voisinage de cette cuisinière ou de

tout autre appareil.

— SI VOUS SENTEZ UNE ODEUR DE GAZ

■ N’allumez aucun appareil.

■ Ne touchez pas aux interrupteurs

électriques.

■ N’utilisez pas les téléphones du bâtiment.

■ Appelez immédiatement votre compagnie

de gaz de chez un voisin. Suivez les in-

structions de la compagnie.

■ Si vous n’arrivez pas à contacter votre

compagnie de gaz, appelez les pompiers.

— L’installation et les réparations doivent être

réalisées par un installateur qualifié, un

centre de réparation agréé ou la compagnie

de gaz.

1

Introduction. .................................................1

Gas Type Verification. ..................................1

Care and Use Manual Conventions. ...........2

Section One: General Safety Instructions

Safety ........................................................... 3 – 4

Precautions ..................................................5 – 6

Section Two: Before You Begin

Before Using Your Range for the First Time......7

Section Three: Description

2

This manual contains important Care and Use information for all Thermador Professional

®

Ranges. When

using this manual, it is critical that you know the model number of your range, as some information will be

unique to each range. The model number may be found on the rating plate located on the range as identified

on Page 43 of this manual. The charts on the following pages summarize the various range models and

identify the features of each range.

Introduction

PD Ranges, featuring a Gas Cooking Surface with Self-Cleaning Electric Oven,

with Electric Convection and Electric Broiler.

Dual Fuel PD304..................... Dual Fuel, 30" wide Range with Four Gas

Cooktop Burners and self-cleaning Electric Oven

Dual Fuel PD364GE................ Dual Fuel, 36" wide Range with Four Gas

Cooktop Burners, Electric Griddle and self-cleaning Electric Oven

Dual Fuel PD364GL ................ Dual Fuel, 36" wide Range with Four

Gas Cooktop Burners, Grill and self-cleaning Electric Oven

Dual Fuel PD366 ..................... Dual Fuel, 36" wide Range with Six Gas

Cooktop Burners and self-cleaning Electric Oven

Dual Fuel PD486GE................ Dual Fuel, 48" wide Range with Six Gas Cooktop Burners,

Electric Griddle, large self-cleaning Electric Oven

and one secondary oven.

Dual Fuel PD486GL ............... Dual Fuel, 48" wide Range with Six

Gas Cooktop Burners, Grill, large self-cleaning Electric Oven

and one secondary oven.

Dual Fuel PD484GGE ............ Dual Fuel, 48" wide Range with Four Gas Cooktop Burners,

Grill, Electric Griddle, large self-cleaning Electric Oven

and one secondary oven.

INTRODUCTION: CARE AND USE MANUAL

Accessible parts may

become hot when the grill

and/or griddle is in use.

Young children must be

kept away.

Gas and ELECTRICAL REQUIREMENTS AND GROUNDING INSTRUCTIONS

Section ONe: GENERAL SAFETY INSTRUCTIONS

Safety Precautions

Save these instructions

It is the personal responsibility and obligation of you, the user, to have

this appliance connected to the electrical power supply in accordance

with the National Electrical Code and/or applicable local codes and

ordinances by a qualified electrician.

See Installation Instructions for electrical requirements and

grounding instructions.

ALWAYS DISCONNECT THE

ELECTRICAL PLUG FROM THE

WALL RECEPTACLE BEFORE

SERVICING THIS UNIT.

It is recommended that a

dedicated circuit servicing this

appliance be provided.

The use of gas cooking appliances

results in the production of heat

and moisture.

PLEASE READ CAREFULLY

If for any reason a gas control knob is turned ON and there is no

electrical power to operate the electronic igniters on the range's

cooktop burners, turn OFF the gas control knob and wait 5

minutes for the gas to dissipate before lighting the burner manu-

ally.

To light the burners manually, carefully hold a lighted match to the

burner ports and turn the gas control knob to HI. During a power

failure you can use the standard cooktop burners, but each must

be lit with a match.

DO NOT attempt to light the two left burners manually. These

burners are equipped with the ExtraLow

®

feature and cannot be lit

manually.

CAUTION - ALL MODELS

IN CASE OF AN ELECTRICAL FAILURE

FOR PERSONAL SAFETY,

THIS APPLIANCE MUST BE

CONNECTED TO A

PROPERLY GROUNDED

AND POLARIZED ELEC-

TRICAL POWER SUPPLY.

3

TESTED IN ACCORDANCE

WITH:

• ANSI Z21.1 for Household

Gas Appliances

• UL858 Edition for Household

Electric Ranges

• CAN/CSA-22.2 No. 61-M89 for

Household Cooking Ranges

• CAN/CGA 1.1-M81 Domestic

Gas Ranges

Check your local building codes

for the proper method of

installation. In the absence of local

codes, this unit should be installed

in accordance with the National

Fuel Gas Code No. Z223.1 current

issue and the National Electrical

Code ANSI/NFPA No. 70 current

issue or the Can - B149 Installation

Codes for Gas Burning Appliances

and C22.1 Canadian Electrical

Code Part 1.

Dual-Fuel Models:

PD304

120/240 volts, 60 Hz.,

35 Amp electrical circuit required.

Dual-Fuel Models:

PD364GE, PD364GL,

PD366

120/240 volts, 60 Hz.,

35 Amp electrical circuit required.

Dual-Fuel Models:

PD486GE, PD486GL,

PD484GGE

120/240 volts, 60 Hz.,

50 Amp electrical circuit required.

CAUTION

WARNING

Safety Practices to Avoid

Personal Injury

When properly cared for, your

new

Thermador Professional

®

Range

has been designed to be a safe,

reliable appliance. However, use

extreme care when using this

restaurant caliber range as this

type of appliance provides intense

heat. When using kitchen

appliances, basic safety pre-

cautions must be followed,

including the following:

Read this Care and Use Manual

carefully before using your new

range to reduce the risk of fire,

electrical shock, or injury to

persons.

Insure proper installation and

servicing. Follow the installation

instructions provided with this

product. Have the range installed

and electrically grounded by a

qualified technician.

Have the installer show you

where the electric circuit

breaker and the gas supply shut

off valve are located so you know

how and where to turn off the gas

and electricity to the range.

• If you smell gas:

• Do not try to light any appli-

ance.

• Do not touch any electrical

switch.

• Do not use any phone in your

building.

• Immediately call your gas sup-

plier from a neighbor’s phone.

Follow the gas supplier’s in-

struction.

• If you cannot reach your gas

supplier, call the fire depart-

ment.

• Installation and service must

be performed by a qualified in-

staller, service agency or the

gas supplier.

In the event a burner goes out and

gas escapes, open a window or

a door. Do not attempt to use the

range until the gas has had time to

dissipate. Wait at least 5 minutes

before using the range.

Do not repair or replace any

part of the appliance unless

specifically recommended in this

manual. All other servicing should

be referred to a qualified

technician.

Children should not be left alone

or unattended in an area where

appliances are in use. They

should never be allowed to sit or

stand on any part of the appliance.

If children are allowed to use the

appliance, they must be closely

supervised.

CAUTION: Do not store items

of interest to children above or

at the back of the range. If

children should climb onto the

appliance to reach these items,

they could be seriously injured.

Never use any part of the range

or oven for storage. Flammable

materials can catch fire and

plastic items may melt or ignite.

Do not hang articles from any

part of the appliance or place

anything against the oven. Some

fabrics are quite flammable and

may catch on fire.

If the range is near a window, be

certain the curtains do not blow

over or near the range burners;

they could catch on fire.

Do not use water on grease fires.

Turn appliance off and smother

fire with baking soda or use a dry

chemical or foam-type

extinguisher.

Never let clothing, potholders,

or other flammable materials

come in contact with or too

close to any element, burner or

burner grate until it has cooled.

Fabric may ignite and result in

personal injury.

Use only dry potholders: moist

or damp potholders on hot

surfaces may cause burns from

steam. Do not use a towel or other

bulky cloth in place of potholders.

Do not let potholders touch hot

elements, hot burners, or burner

grates.

For personal safety, wear

proper apparel. Loose fitting

garments or hanging sleeves

should never be worn while using

this appliance. Some synthetic

fabrics are highly flammable and

should not be worn while cooking.

Do not use aluminum foil to line

any part of the oven or range.

Use of a foil liner could result in a

shock or fire hazard, or the

obstruction of the flow of

combustion and ventilation air. Foil

is an excellent heat insulator and

heat will be trapped beneath it.

This will upset the cooking

performance and can damage the

finish of the oven or the range.

TO REDUCE THE

RISK OF TIPPING OF

THE APPLIANCE, IT

MUST BE SECURED

BY A PROPERLY

INSTALLED ANTI-TIP

DEVICE. VERIFY THAT THE

ANTI-TIP DEVICE IS EN-

GAGED PER INSTALLATION

IN–STRUCTIONS. (NOTE:

ANTI-TIP DEVICE IS

REQUIRED ON ALL 30" AND

36" RANGES)

Section One: GENERAL SAFETY INSTRUCTIONS

WARNING

4

Section One: GENERAL SAFETY INSTRUCTIONS

Safety Precautions

Warning: The appliance is

for cooking. Based on safety

considerations, never use the oven

or cooktop to warm or heat a room.

Also, such use can damage the

cooktop or oven parts.

When using the cooktop: DO NOT

TOUCH THE BURNER GRATES

OR THE IMMEDIATE SUR-

ROUNDING AREA. Areas

adjacent to the burners may

become hot enough to cause

burns.

Never leave the range

unattended when using high

flame settings. Boil overs cause

smoking and greasy spillovers that

may ignite. More importantly, if

the burner flames are smothered,

unburned gas will escape into the

room. See Inside Front Cover

regarding gas leaks.

Only certain types of glass,

heat-proof glass-ceramic,

ceramic, earthenware, or other

glazed utensils are suitable for

range use. This type of utensil

may break with sudden

temperature changes. Use only

on low or medium heat settings

according to the utensil

manufacturer’s directions.

Do not heat unopened food

containers; a buildup of pressure

may cause the container to burst.

During cooking, set the burner

control so that the flame heats

only the bottom of the pan and

does not extend beyond the

bottom of the pan.

Avoid using high flame setting with

a pan larger than the grate or

with one that spans more than

one burner, such as a griddle, for

prolonged periods of time. This

can result in poor combustion that

generates harmful by-products.

Use caution to insure that drafts

like those from forced air vents or

fans do not blow flammable

material toward the flames or push

the flames so that they extend

beyond the edges of the pot.

Always use utensils that have

flat bottoms large enough to

cover the burner. The use of

undersized utensils could expose

a portion of the flame and may

result in ignition of clothing.

Do not use flammable cleaners to

clean the range.

To minimize the risk of burns,

ignition of flammable materials

and unintentional spillage,

position handles of utensils

inward so they do not extend over

adjacent work areas, cooking

areas, or the edge of the range's

cooktop.

Hold the handle of the pan to

prevent movement of the utensil

when stirring or turning food.

DO NOT use pots or pans on the

grill section.

Do not use the grill for cooking

excessively fatty meats or

products which promote flare-

ups.

The optional cutting board

accessory must be removed

before operating the griddle

beneath or burners adjacent to it.

GREASE IS FLAMMABLE. Let

hot grease cool before attempting

to handle it. Avoid letting grease

deposits collect. Clean after each

use.

For proper lighting and

performance of the burners, keep

the igniter ports clean. It is

necessary to clean these when

there is a boil over or when the

burner does not light even though

the electronic igniters click. See

Page 39.

5

WARNING

After a spill or boil over, turn off

the burner and clean around the

burner and burner ports. After

cleaning, check for proper

operation.

Clean the range with caution.

Avoid steam burns; do not use a

wet sponge or cloth to clean the

cooktop while it is hot. Some

cleaners produce noxious fumes

if applied to a hot surface. Follow

directions provided by the cleaner

manufacturer.

Be sure all cooktop controls are

turned off and the cooktop is cool

before using any type of aerosol

cleaner on or around the cooktop.

The chemical that produces the

spraying action could, in the

presence of heat, ignite or cause

metal parts to corrode.

When using the oven: DO NOT

TOUCH THE BROILER ELEMENT

,

THE INTERIOR SURFACES OF

THE OVEN OR THE EXTERIOR

AREA IMMEDIATELY SUR-

ROUNDING THE DOOR. Interior

oven surfaces become hot enough

to cause burns. The heat deflector,

which deflects heat away from the

cooktop and the trim on the top

and sides of the oven door, will

also be hot when the oven is in

use.

Place oven racks in desired

position while oven is cool. If a

rack must be moved while the

oven is hot, do not let the

potholders contact the broiler

element.

Use care when opening the oven

door; let hot air or steam escape

before removing or replacing

foods.

Before self-cleaning the oven,

remove the broiler pan, oven racks

and any other utensils, and excess

spillage.

Section One: GENERAL SAFETY INSTRUCTIONS

Safety Precautions

Do not clean, rub, damage,

move or remove the door

gasket. I

t is essential for a good

seal during baking and while self-

cleaning the oven. If the gasket

becomes damaged or has excessive

food spillage, replace the door

gasket. This will assure a tight seal.

Protect the self-cleaning

feature. Clean only those parts

indicated in this booklet. Do not

use commercial oven cleaners or

oven liner protective coatings of

any kind in or around the large

self-cleaning oven.

DO NOT obstruct the flow of

combustion or ventilation air.

For safety reasons and to avoid

equipment damage, never sit,

stand, or lean on the oven door.

6

Service should only be done by

authorized technicans. Techni-

cians must disconnect the power

supply before servicing this unit.

Listen to be sure the cooling

blower runs whenever the oven

controls are set to broil or self-

clean. If the fan does not operate,

do not use the oven. Call an

authorized service center for

service.

Clean the ventilator hood and filters

above the range frequently so

grease from cooking vapors does

not accumulate on them.

• In case of fire or when inten-

tionally “flaming” liquor or

other spirits on the range's

cooktop, follow hood man-

ufacturer’s instructions.

California Proposition 65

Warning: The burning of gas

cooking fuel and the elimination of

soil during self-cleaning generate

some by-products which are on

the list of substances which are

known by the State of California to

cause cancer or reproductive

harm. California law requires

businesses to warn customers of

potential exposure to such

substances. To minimize exposure

to these substances, always

operate this unit according to the

instructions contained in this

booklet and provide good

ventilation to the room when

cooking with gas, during and

immediately after self-cleaning the

oven.

BEFORE USING YOUR RANGE FOR THE FIRST TIME, CHECK THAT YOU HAVE THESE ITEMS:

*

Backguard must be ordered and shipped separately. It is not included with the range shipment. ‡The

aluminum broil pan is for the Secondary Oven; the porcelain & chrome broil pan is for the Main Oven.

DESCRIPTION PD PD PD PD PD PD PD

304 364GE 364GL 366 484GGE 486GE 486GL

Oven Racks Large Oven 3 3 3 3 3 3 3

Oven Racks 12-inch Oven 2 2 2

Two-Piece Broil Pan 1 1 1 1 2‡ 2‡ 2‡

Star Burner Caps 4 4 4 6 4 6 6

Burner Grates 2 2 2 3 2 3 3

Control Knobs 5 6 6 7 8 9 9

Cast Iron Grill Grate 1 1 1

Stainless Steel Radiant 1 1 1

Coated

Titanium

-

Surface

Griddle

111

Product Registration Card 1 1 1 1 1 1 1

Backguard 1 * * * * * *

Installation Instructions 1 1 1 1 1 1 1

Use and Care Manual 1 1 1 1 1 1 1

Section Two: BEFORE YOU BEGIN

1. Check that you have the items listed on Page 6.

2. Record the Model and Serial number on Page

43. See "Data Rating Plate." These may be

used for any future contacts with your servicer or

the factory. Enter this information on the Product

Registration Card included with this product then

mail it to the indicated address.

3. Optional Accessories. Grill Cover, Grill Plate,

Chopping Board, Griddle Cover, Wok Support

Ring and other accessories are available from

your Thermador Dealer. Contact the Thermador

Parts Department toll-free at 800/735-4327 for

more information.

4. Position the racks correctly in the oven.

The correct rack position depends on the recipe

and the cooking mode. The rack positions are

numbered from the bottom of the oven, like

an elevator. Rack position 3 is the most

frequently used position. Place rack(s) in the

proper position before turning on the oven.

Insert the racks as follows:

a. Hold the rack with the back rail in the up

position towards the rear of the oven. Slip it

into the oven so the rack slides are between

the rack and the rack guides.

b. Tip the front of the rack up slightly as it slides

into the oven so that the safety stops clear the

rack slides. The safety stops on the back of

the rack will keep it from sliding out of the

oven when it is pulled forward.

5. Ensure that the burner caps are correctly

seated on the burner bases of the range's

cooktop. Turn on each burner to check for

proper flame color. See Page 14 for details.

Remove all packaging materials

and temporary labels from oven

and cooktop.

7

Before Using Your Range for the First Time

BEFORE BAKING OR BROILING, the oven and

broiler should be turned on to burn off the manufac-

turing oils. Turn the oven on to 450°F (230°C) for 20

to 30 minutes; then turn the broiler to "Broil" for same

length of time. You may wish to turn on the ventilator

above your range during this time.

Please read Page 41 in Section 6: Care and

Maintenance before cleaning the oven racks.

Large Electric Main and Oven Rack Positions

Aluminum foil should never be used to cover

the oven racks or to line the oven. Do not

remove the broiler element in the electric

oven.

1

2

3

4

5

CAUTION

Section Three: DESCRIPTION

Model and Parts Identification

Dual Fuel Model PD484GGE - Shown

Model PD486GE – Has a griddle and six burners, two ExtraLow

®

and four standard.

Model PD486GL – Has a grill and six burners, two ExtraLow

®

and four standard.

Key for PD484GGE Models

(shown)

Electric Oven Interior

15. Oven Interior Lights (2)

16. Broil Element

17. Oven Thermostat

18. Rack Guides

19. Oven Rack

(3 included, not shown)

20. Bake Element (hidden)

21. Convection Fan Cover

8

1

2

3

4

14

7

6

5

11

9

10

14

12

13

8

9

15

16

17

18

15

19

20

21

8

7

1. 22" High Shelf Backguard,

12" Low Back, or Island Trim - shown

(Backguard ordered separately)

2. Burner Grates & Burners

3. Gas Grill

4. Electric Griddle

5. Control Knobs, ExtraLow

®

Burners (2)

6. Control Knobs, Standard

Burners (2)

7. Control Knobs, Grill (1) and

Griddle (1)

8. Oven Controls, Temperature

Indicator

9. Light and Selector Switches,

Main and Secodary Ovens

10. Oven Door

11. Viewing Window

12. Secondary Oven

(2 racks included)

13. Kick Panel (Product Rating

Label Located Behind Kick Panel)

14. Range Feet (4)

WARNING:

To provide proper

ventilation, do NOT

remove range feet.

9

1. 22" High Shelf Backguard,

12" Low Back or 4" Island Trim - shown

(Backguard ordered separately)

2. Burner Grates & Burners

3. Control Knobs, ExtraLow

®

Burners (2)

4. Control Knobs, Standard Burners (4)

5. Oven Controls, temperature

indicator

6. Oven Light and Selector Switches

7. Oven Door

8. Viewing Window

9. Kick Panel (Product Rating Label

Located Behind Kick Panel)

10. Range Feet (4)

Dual Fuel Model PD366 - Shown

Model PD364GE– Has a center griddle and four burners, two ExtraLow

®

and two standard.

Model PD364GL – Has a center grill and four burners, two ExtraLow

®

and two standard.

Key for PD366 Models (shown)

Electric Oven Interior,

Please see Page 8

Section Three: DESCRIPTION

WARNING:

To provide proper

ventilation, do NOT

remove range feet.

1

2

5

2

4

3

6

2

4

10

8

7

9

10

Section Three: DESCRIPTION

Model and Parts Identification

1. 9" Low Back

(Island Trim - shown - and High Shelf

ordered separately)

2. Burner Grates & Burners

3. Control Knobs, ExtraLow

®

Burners (2)

4. Control Knobs, Standard Burners (2)

5. Oven Controls, Temperature Indicator

6. Oven Light and Selector Switches

7. Oven Door

8. Viewing Window

9. Kick Panel (Product Rating Label

Located Behind Kick Panel)

10. Range Feet (4)

Dual Fuel Model PD304 - Shown

Key for PD304 Models

Electric Oven Interior,

Please see Page 8

10

WARNING:

To provide proper ventila-

tion, do NOT remove

range feet.

1

2

3

4

5

6

7

8

9

10

Section Four: USING THE COOKTOP

Sealed Burners

USING THE COOKTOP

The cooktop features four or six

gas surface burners; each rated

at 15,000 BTU/HR. The burners

are sealed to the stainless steel

top frame to prevent liquid spills

from accumulating below the top

surface, making it easier to clean.

On all models, the two left burners

have the exclusive ExtraLow

feature, the remaining burners are

standard. Each burner has its own

control knob.

ExtraLow® Burner

Control Knob

CONTROL KNOBS

The two words above each control

knob identifies the burner

position. For example, LEFT

FRONT, RIGHT FRONT, etc.

Standard Burner

Control Knob

Bezel

Knob

The control knobs for two sealed

gas burners, one in front and one

in the rear, are located directly in

front of and below the pair of

burners on the control panel.

OPERATION OF THE

BURNERS

• Press in on the knob and turn it

counter-clockwise to the HI

setting.

• The igniter for the selected

sealed burner clicks and

sparks.

• After flame ignition, the igniter

stops clicking.

• Rotate the knob to any flame

setting between HI and LO.

• The Blue Burner Signal Light,

between the burners, will light

when adjacent burners are lit.

They will remain on until the

burner is turned off.

BTU Output for Standard Burners

• HI is equivalent

to

15,000 BTU

/

HR.

• LO is equivalent to 2,100 BTU

/

HR.

BTU Output for ExtraLow® Burners

• HI is equivalent to

15,000 BTU

/

HR.

• LO is equivalent to

3,000 BTU

/

HR.

• XLO is equivalent to

370 BTU

/

HR.

ExtraLow®

Burners

The controls for the two left

burners, front and rear, have

flame settings even lower than the

standard LO settings.

The drawing shows that the

control knob has an additional

range between the LO and XLO

settings. When the knob is set

within this range, the flame cycles

off and on. By varying the length

of time the flame is off and on,

the heat is reduced even further

to cook delicate foods. For

example, these very low settings

are suitable for simmering and

poaching, melting chocolate and

butter, holding cooked foods at

temperatures without scorching or

burning, etc.

ExtraLow

®

Range

12

Sealed Star®

Brass Burner Base

Setting Indicator

13

ExtraLow Techniques

• The type and quantity of food

affects which setting to use.

• The pan selected affects the

setting. Its size, type, material,

and whether a lid is used, all

affect the consistency of the

cooking temperature.

Operation of the ExtraLow

Burners

• XLO, the very lowest setting, is

achieved by cycling the flame

ON for approximately 8

seconds and OFF for 52

seconds of each minute.

• When the knob is set just below

the LO setting, the flame will

cycle ON for approximately 52

seconds and OFF for 8

seconds of each minute.

• To vary the amount of low heat

to suit the food and quantity, the

control can be set anywhere

within the LO and XLO range

marked on the knob.

• The number and dash

designations, shown in the

drawing, are for reference only.

Numbers do not actually

appear on the knob. The

number indicates the position

of the flame setting as

represented on the cooking

chart, pages 17 and 18, with the

flame on longer at the #4

setting than on #1 setting.

ExtraLow Settings

Electronic

Single Point

Ignition

Star® Burner

Components

Each burner has its own electronic

igniter that sparks when the

burner is turned on. Each burner

should light in 4 seconds or less.

If a burner does not light, check

to see that the cap is positioned

correctly on the base. Do not

touch the burners when the

igniters are sparking. If a burner

fails to ignite, refer to the section

on Page 43, “Before Calling for

Service.”

Burner

Cap

BURNER CAP

Ports

Brass

Burner

Base

• To maintain a low or simmer

heat, bring food to a rolling boil.

Stir well, then cover the pan and

lower the heat to a setting just

below LO.

• Check periodically to see if the

control knob should be turned

to another setting.

• If an over-size pan is used, the

simmer action may occur

mainly in the center of the pan.

To equalize the temperature

throughout the food, stir the

food around the outer edges of

the pan into the food in the

center.

• It is normal to stir food

occasionally while simmering.

This is especially important

when simmering for several

hours, such as for a homemade

spaghetti sauce or beans.

• When lowering the flame

setting, adjust it in small steps.

• If the setting is too low to hold

a simmer, bring the food back

to a boil before re-setting to a

higher heat.

• It is normal not to see simmer

bubbles immediately after the

food has been stirred.

• There may be bubbling when

the flame cycles ON and no

bubbles when the flame is OFF.

Even when the flame is OFF,

there will be steam and a slight

quiver on the liquid’s surface.

Section Four: USING THE COOKTOP

1

2

3

4

IGNITER

14

AUTOMATIC RE-IGNITION

If any one or more burners or grill

blow out, the electronic igniter

automatically sparks to re-light the

flame.

Do not touch the burners

when the igniters are sparking.

IMPORTANT:

• For proper combustion do not

use the cooktop without the

burner grates in place.

• There is a slight sound

associated with gas

combustion and ignition. This

is a normal condition.

• On cooktops using propane

gas (LP), a slight “pop” sound

may be heard at the burner

ports a few seconds after the

burner has been turned off.

FLAME DESCRIPTION

• The burner flame color should

be blue with no yellow on the

tips. It is not uncommon to see

orange in the flame color; this

indicates the burning of

airborne impurities in the gas

and will disappear with use.

• With propane (LP) gas, slight

yellow tips on the

primary cone

are normal.

• The flame should burn

completely around the burner

cap. If it doesn’t, check that the

cap is positioned correctly on

the base and that the ports are

not blocked.

• The flame should be stable with

no excessive noise or fluttering.

FLAME HEIGHT

• The correct flame height

depends on 1) size and

material of pan being used; 2)

food being cooked; and 3)

amount of liquid in the pan.

• Never extend the flame beyond

the base of the pan.

• Use a low or medium flame for

pan materials that conduct the

heat slowly, such as porcelain

coated steel or glass-ceramic.

POWER FAILURE

• In the event of a power failure,

only the standard burners

can be manually lit. It is

necessary to light each one

individually.

• If the cooktop is being used

when the power failure occurs,

turn all knobs to the OFF

position.

• The standard burners can be

lighted by holding a match at

the ports and turning the control

knob to the HI position. Wait

until the flame is burning all

around the burner cap before

adjusting the flame to the

desired height.

• Neither ExtraLow burner can be

used during a power failure. Be

sure to turn them off.

• If either ExtraLow burner is on

when a power failure occurs,

they cannot be turned back on

until both knobs are first turned

off.

• The griddle or grill cannot be

used during a power failure.

• If you smell gas, refer to safety

precautions listed inside the

front cover.

Flame Color

Secondary

Cone

Primary

Cone

Light Blue

Dark Blue

Warning

In the event of a power failure,

all knobs are to be turned to the

OFF Position. Only the

standard burners can be lit

manually.

Section Four: USING THE COOKTOP

15

Section Four: USING THE COOKTOP

Cookware Recommendations

CAUTION:

❱❱

❱ Food packaged in aluminum foil should not

be placed directly on the burner grate.

Aluminum foil can melt during cooking.

❱❱

❱ Do not let plastic, paper or cloth come in

contact with a hot burner grate. They may

melt or catch fire.

❱❱

❱ Never let a pan boil dry. This can damage

your pan and the cooking surface.

• Select the base diameter to match the diameter

of the flame. The diameter of the flame should be

the same size as the pan base or slightly smaller.

Oversize or under size pans sacrifice cooking

performance. A 5

-1

/2" (140 mm) base size is

generally the smallest recommended.

• Professional quality pans with metal handles are

recommended because plastic handles can melt

or blister, if the flame extends up the side of the

pan. Professional quality pans are found at

restaurant supply stores and gourmet specialty

shops. All cookware should have these

characteristics: good heat conductivity, good

balance, correctly sized base diameter, a heavy,

flat base, and a proper fitting lid. For best cooking

results, the flame should be contained under the

bottom of the pan.

• Aluminum and copper are pan materials that

conduct the heat quickly and evenly. These metals

are sometimes attached to the base or in the core

between stainless steel.

• Balance is important for stability and even cooking.

The handle must not be heavier than the pan and

tilt it unevenly. A pan must sit level on the grate

without rocking or wobbling.

• A heavy, flat base is more apt to remain flat when

heated. Pan bases that are warped, dented, ridged

or too lightweight will heat unevenly. Heat and cool

pans gradually to avoid sudden temperature

changes which tend to distort cookware. Do not

add cold water to a hot pan.

• A properly fitting lid will shorten cooking time and

make it possible to use lower heat settings.

Balanced Pan

Base Diameter

Flat Base Pan

Covered Pan

(51 mm)

➤

16

Section Four: USING THE COOKTOP

Flat-bottom Wok Pan

Specialty Cookware

Cooking Recomendations

Suggestions for Using the Recommenda-

tions

Use the chart on Pages 17 and 18 as a guide. The

settings you use will vary depending on the pans

selected and the starting temperature of the food.

On the chart, the “Finish Setting” has been separated

for the standard and ExtraLow burners. There may

or may not be a change between the two burner

settings.

The ExtraLow setting can be either a cooking or a

holding setting.

Raise or lower the flame setting gradually. Allow time

for the pan and the food to adjust to the new setting.

Round-Bottom Wok

in Support Ring

• Woks – Either flat based or round bottom woks

with the accessory ring can be used on models

without a built-in wok burner. Round bottom woks

must be used with a support ring. The porcelain-

coated cast iron wok support ring must be

purchased separately.

• Canners and Stock Pots – Select one with a base

diameter that extends no more than 2 inches

(51mm) beyond the grate.

Standard Size Water Bath Canner

21 to 22 quarts (19.95 to 20.9 liters),

with an 11 to 12 inch base (279 to 305 mm)

and a 9 to 11 inch depth (229 to 279 mm).

Standard Size Pressure Canner

8 to 22 quarts (7.6 to 20.9 liters), with an

8 to 11 inch base (203 to 279 mm) and

a 6

-1

/2" to 12 inch depth (165 - 305 mm).

Canning Tips:

• A flat base pan is preferred to one with a concave,

convex or rippled base.

• When using two canners at the same time, use

staggered burners. Do not block air to the burners.

A flame needs the right amount of air for complete

combustion.

• Use a cover on a canner when bringing the

contents to a boil.

• Once the contents have reached a boil on HI, use

the lowest flame possible to maintain the boil or

pressure.

• Canning produces a large amount of steam. Take

precautions to prevent burns.

17

Section Four: USING THE COOKTOP

Surface Burner Cooking Recommendations

BEVERAGES MED – heat milk, LO – finish heating XLO – keep warm,

Cocoa cover cover*

BREADS MED – preheat skillet MED LO to MED – Same as Standard

French Toast, Pancakes, cook

Grilled Sandwiches

BUTTER 4 to 3 – allow 5 to 10

Melting XLO – to hold minutes to melt

CEREALS HI – cover, bring MED LO to MED – XLO – to hold, cover*

Cornmeal, Grits, water to a boil, add finish cooking

Oatmeal cereal

according to package

directions

CHOCOLATE Use XLO 2 to XLO – allow 10

Melting to 15 minutes to melt

XLO – to hold*

DESSERTS MED LO to MED – MED LO to MED Same as Standard

Candy cook following recipe

Pudding and Pie Filling MED LO LO MED LO

Mix cook according to

package directions

Pudding MED LO – Bring milk LO MED LO – to cook

to a boil

EGGS MED HI –

cover, bring

Use XLO XLO– cook 3 to 4

Cooked in Shell water to a boil, add minutes for soft cooked;

eggs, cover or 15 to 20 minutes for

hard cooked

Fried, Scrambled MED – LO to MED LO XLO– to hold for a

melt butter, add eggs finish cooking short period*

Poached HI – bring water to MED to MED HI – Same as Standard

the boiling point, finish cooking

add eggs

MEAT, FISH, POULTRY HI – until meat starts MED LO to MED – Same as Standard

Bacon, Sausage Patties to sizzle finish cooking

Braising: Swiss Steak, HI – melt fat, then Use XLO 3 to 2 –

Pot Roast, Stew Meat brown on MED HI to simmer until tender

HI, add liquid, cover,

Quick Frying: Breakfast MED HI to HI – MED HI to HI – Same as Standard

Steaks preheat skillet fry quickly

Frying: Chicken HI – heat oil, then LO cover, finish Same as Standard

brown on MED cooking

Deep Frying: Shrimp HI – heat oil MED HI – to Same as Standard

maintain temperature

Pan Frying: Lamb Chops,

HI – preheat skillet MED HI to HI – 4 to 3 – to hold, covered

Thin Steaks, Hamburgers,

brown meat 4 to 3 – t

o hold, uncovered

Link Sausage

Poaching: Chicken, HI – Cover, bring Use XLO 4 to 3 – to finish cooking

whole or pieces, Fish liquids to a boil

Food Start Setting Finish Setting Finish Setting

Standard Burners ExtraLow® Burners

18

Section Four: USING THE COOKTOP

Surface Burner Cooking Recommendations

* We recommend that these foods be stirred occasionally.

Simmering: Stewed HI – cover, 4 to 1 – simmer slowly

Chicken, Corned Beef, bring liquid

Tongue, etc. to a boil

PASTAS HI – bring water to a MED HI to HI – to

Same as for Standard Burners

Macaroni, Noodles, boil, add pasta

maintain a rolling boil

Spaghetti

POPCORN (use a heavy, HI – cover, heat until MED HI to HI –

Same as for Standard Burners

flat bottom pan) kernels start to pop finish popping

PRESSURE COOKER MED HI to HI – build MED LO to MED –

Same as for Standard Burners

Meat up pressure maintain pressure

Vegetables HI – build up pressure MED LO to MED –

Same as for Standard Burners

maintain pressure

RICE HI – cover, bring 4 to 2 – cook according

water to a boil, add to package directions

rice, cover XLO – to hold, cover

SAUCES MED HI to HI – cook 2 to XLO – simmer

Tomato Base meat/vegetables, (2 to 3 to thicken sauce,

follow recipe uncovered).

White, Cream, Bernaise, MED LO – melt fat, LO to MED LO – XLO – to hold, cover*

follow recipe finish cooking

Hollandaise XLO to LO XLO XLO –

t

o hold, lowest setting

SOUPS, STOCK HI – cover, bring 3 to 2 – simmer

liquid to a boil XLO – to hold, cover*

VEGETABLES HI – cover, bring MED LO to MED – XLO – to hold, cover

Fresh water and vegetables

cook

10

to

30

minutes,

to a boil or until tender

Frozen HI – cover, bring MED LO to MED –

Same as for Standard Burners

water and vegetables cook according to

to a boil package directions

Deep Frying HI – heat oil MED to MED HI –

Same as for Standard Burners

maintain frying

temperature

In Pouch HI – cover, bring LO to MED LO –

Same as for Standard Burners

water and vegetables cook according to

to a boil package directions

Saute HI – heat oil or melt MED LO to MED –

Same as for Standard Burners

butter, add vegetables cook to desired

doneness

Stir Fry HI – heat oil, add MED HI to HI –

Same as for Standard Burners

vegetables finish cooking

Food Start Setting Finish Setting Finish Setting

Standard Burners ExtraLow® Burner

La page est en cours de chargement...

Thermador Range PD48 Manuel utilisateur

Ce manuel convient également à

Thermador Range PD48 Manuel utilisateur

dans d''autres langues

Documents connexes

Autres documents