Wacker Neuson PT6LS Manuel utilisateur

Operator’s Manual

Pump

PT 6L

Notice d’Emploi

Pompe

5000185276 10 0912

5

000185276

EN-FR

Copyright

notice

All rights, including copying and distribution rights, are reserved.

This publication may be photocopied by the original purchaser of the machine. Any

other type of reproduction is prohibited without express written permission from

Wacker Neuson Production Americas LLC.

Any type of reproduction or distribution not authorized by Wacker Neuson Production

Americas LLC represents an infringement of valid copyrights. Violators will be

prosecuted.

Trademarks

All trademarks referenced in this manual are the property of their respective owners.

Manufacturer

Wacker Neuson Production Americas LLC

N92W15000 Anthony Avenue

Menomonee Falls, WI 53051 U.S.A.

Tel: (262) 255-0500 · Fax: (262) 255-0550 · Tel: (800) 770-0957

www.wackerneuson.com

Original

instructions

This Operator’s Manual presents the original instructions. The original language of this

Operator’s Manual is American English.

5000185252 10 0912

PT 6L Foreword

wc_tx001594gb.fm 3

Foreword

SAVE THESE INSTRUCTIONS—This manual contains important instructions for

the machine models below. These instructions have been written expressly by

Wacker Neuson Production Americas LLC and must be followed during installation,

operation, and maintenance of the machines.

Machines

covered by

this manual

Machine

documentation

 From this point forward in this documentation, Wacker Neuson Production

Americas LLC will be referred to as Wacker Neuson.

 Keep a copy of the Operator’s Manual with the machine at all times.

 Use the separate Parts Book supplied with the machine to order replacement

parts.

 Refer to the separate Repair Manual for detailed instructions on servicing and

repairing the machine.

 If you are missing any of these documents, please contact Wacker Neuson to

order a replacement or visit www.wackerneuson.com.

 When ordering parts or requesting service information, be prepared to provide

the machine model number, item number, revision number, and serial number.

Expectations

for

information in

this manual

 This manual provides information and procedures to safely operate and

maintain the above Wacker Neuson model(s). For your own safety and to

reduce the risk of injury, carefully read, understand, and observe all instructions

described in this manual.

 Wacker Neuson expressly reserves the right to make technical modifications,

even without notice, which improve the performance or safety standards of its

machines.

 The information contained in this manual is based on machines manufactured

up until the time of publication. Wacker Neuson reserves the right to change

any portion of this information without notice.

CALIFORNIA

Proposition

65 Warning

Engine exhaust, some of its constituents, and certain vehicle components, contain

or emit chemicals known to the State of California to cause cancer and birth

defects or other reproductive harm.

Laws

pertaining to

spark

arresters

NOTICE: State Health Safety Codes and Public Resources Codes specify that in

certain locations spark arresters be used on internal combustion engines that use

hydrocarbon fuels. A spark arrester is a device designed to prevent accidental

discharge of sparks or flames from the engine exhaust. Spark arresters are

qualified and rated by the United States Forest Service for this purpose. In order to

comply with local laws regarding spark arresters, consult the engine distributor or

the local Health and Safety Administrator.

Machine Item Number

PT 6LT

PT 6LS

0007175

0007174

Foreword PT 6L

4 wc_tx001594gb.fm

Manufacturer’s

approval

This manual contains references to approved parts, attachments, and

modifications. The following definitions apply:

 Approved parts or attachments are those either manufactured or provided by

Wacker Neuson.

 Approved modifications are those performed by an authorized Wacker

Neuson service center according to written instructions published by Wacker

Neuson.

 Unapproved parts, attachments, and modifications are those that do not

meet the approved criteria.

Unapproved parts, attachments, or modifications may have the following

consequences:

 Serious injury hazards to the operator and persons in the work area

 Permanent damage to the machine which will not be covered under warranty

Contact your Wacker Neuson dealer immediately if you have questions about

approved or unapproved parts, attachments, or modifications.

wc_bo5000185252_10TOC.fm 5

Table of ContentsPT 6L

Foreword 3

1 Safety Information 9

1.1 Signal Words Used in this Manual ....................................................... 9

1.2 Machine Description and Intended Use ............................................. 10

1.3 State Regulations Concerning Trailers ............................................... 12

1.4 Safety Guidelines for Operating the Machine ..................................... 12

1.5 Operator Safety while Using Internal Combustion Engines ............... 14

1.6 Service Safety .................................................................................... 15

1.7 Towing Safety ..................................................................................... 16

1.8 Reporting Trailer Safety Defects ........................................................ 16

2 Labels 17

2.1 Label Locations .................................................................................. 17

2.2 Label Meanings .................................................................................. 18

3 Lifting and Transporting 21

3.1 Lifting the Machine ............................................................................. 21

3.2 Tires ................................................................................................... 22

3.3 Wheels and Lug Nuts ......................................................................... 22

3.4 Tongue Jack ....................................................................................... 22

3.5 Safety Chains ..................................................................................... 23

3.6 Lights .................................................................................................. 24

4 Operation 25

4.1 Preparing the Machine for First Use ................................................... 25

4.2 Control / Component Descriptions ..................................................... 25

4.3 Control / Component Locations .......................................................... 26

4.4 Recommended Fuel ........................................................................... 27

4.5 Before Starting the Engine ................................................................. 27

4.6 Before Starting the Pump ................................................................... 27

4.7 Starting ............................................................................................... 28

6 wc_bo5000185252_10TOC.fm

Table of Contents PT 6L

4.8 Stopping ..............................................................................................29

4.9 Automatic Shutdown System ..............................................................30

4.10 Important Operation Note ....................................................................30

4.11 Hoses ..................................................................................................31

4.12 Hose Couplings ...................................................................................31

4.13 Hose Clamps .......................................................................................31

4.14 Strainer ................................................................................................31

4.15 Discharge Port .....................................................................................32

4.16 Covers .................................................................................................33

4.17 Towing the Machine ............................................................................35

4.18 Emergency Shutdown Procedure ........................................................36

5 Maintenance 37

5.1 Periodic Maintenance Schedule ..........................................................37

5.2 Engine Fuel Delivery System Maintenance .........................................38

5.3 Servicing the Air Cleaner .....................................................................38

5.4 Maintaining the Fuel Filter ...................................................................39

5.5 Priming the Fuel System .....................................................................39

5.6 Lubrication ...........................................................................................40

5.7 Engine Oil ............................................................................................41

5.8 Valve Clearances ................................................................................41

5.9 Fan Belt ...............................................................................................42

5.10 Pump Housing Mounting Bolts ............................................................43

5.11 Mechanical Seal Lubrication ...............................................................44

5.12 Bearing Housing Lubrication ...............................................................45

5.13 Impeller Inspection ..............................................................................45

5.14 Engine Cooling Fins ............................................................................48

5.15 Battery .................................................................................................48

5.16 Troubleshooting ...................................................................................49

5.17 Long-Term Storage .............................................................................50

6 Technical Data 51

6.1 Engine .................................................................................................51

6.2 Pump ...................................................................................................52

6.3 Lubrication ...........................................................................................52

6.4 Trailer and Skid ...................................................................................52

6.5 Dimensions ..........................................................................................53

wc_bo5000185252_10TOC.fm 7

Table of ContentsPT 6L

7 Schematics 54

7.1 Trailer Wiring ...................................................................................... 54

7.2 Electrical Wiring (0007174 < Rev 120; 0007175 < Rev 123) ............ 55

7.3 Electrical Wiring Components (0007174 < Rev 120; 0007175 < Rev 123) . 56

7.4 Electrical Wiring (0007174 > Rev 119; 0007175 > Rev 122) ............ 57

7.5 Electrical Wiring Components (0007174 > Rev 119; 0007175 > Rev 122) . 58

8 AEM Safety Manual 59

Tire Safety Information 71

8 wc_bo5000185252_10TOC.fm

Table of Contents PT 6L

PT 6L Safety Information

wc_si000524gb.fm 9

1 Safety Information

1.1 Signal Words Used in this Manual

This manual contains DANGER, WARNING, CAUTION, NOTICE, and

NOTE signal words which must be followed to reduce the possibility

of personal injury, damage to the equipment, or improper service.

NOTICE: Used without the safety alert symbol, NOTICE indicates a

situation which, if not avoided, could result in property damage.

Note: A Note contains additional information important to a procedure.

This is the safety alert symbol. It is used to alert you to potential personal hazards.

f Obey all safety messages that follow this symbol.

DANGER

DANGER indicates a hazardous situation which, if not avoided, will result in death

or serious injury.

f To avoid death or serious injury from this type of hazard, obey all safety mes-

sages that follow this signal word.

WARNING

WARNING indicates a hazardous situation which, if not avoided, could result in

death or serious injury.

f To avoid possible death or serious injury from this type of hazard, obey all safety

messages that follow this signal word.

CAUTION

CAUTION indicates a hazardous situation which, if not avoided, could result in

minor or moderate injury.

f To avoid possible minor or moderate injury from this type of hazard, obey all

safety messages that follow this signal word.

Safety Information PT 6L

10 wc_si000524gb.fm

1.2 Machine Description and Intended Use

This machine is a centrifugal trash pump. The Wacker Neuson Trash

Pump consists of a trailer with integral fuel tank onto which are

mounted a diesel engine, and an impeller pump with ports for water

suction and discharge. The engine rotates the impeller during

operation. Waste water is drawn into the pump through the suction

port and expelled through the discharge port. The operator connects

hoses to the pump and routes them so that water and solids are

drained from the work area and discharged into an appropriate

location.

This machine is intended to be used for general de-watering applications.

This machine is intended for the pumping of clear water, or water

containing solids up to the size stated within the product specifications,

and up to the flow, head, and suction lift limits also stated within the

product specifications.

This machine has been designed and built strictly for the intended use

described above. Using the machine for any other purpose could

permanently damage the machine or seriously injure the operator or

other persons in the area. Machine damage caused by misuse is not

covered under warranty.

The following are some examples of misuse:

• Pumping flammable, explosive, or corrosive fluids

• Pumping hot or volatile fluids that result in pump cavitation

• Operating the pump outside of product specifications due to

incorrect diameter hoses, incorrect length hoses, other inlet or

outlet restrictions, or excessive suction lift or head

• Using the machine as a ladder, support, or work surface

• Using the machine to carry or transport passengers or equipment

• Operating the machine outside of factory specifications

• Operating the machine in a manner inconsistent with all warnings

found on the machine and in the Operator’s Manual

This machine has been designed and built in accordance with the

latest global safety standards. It has been carefully engineered to

eliminate hazards as far as practicable and to increase operator

safety through protective guards and labeling. However, some risks

may remain even after protective measures have been taken. They

are called residual risks. On this machine, they may include exposure

to:

• Heat, noise, exhaust, and carbon monoxide from the engine

• Fire hazards from improper refueling techniques

PT 6L Safety Information

wc_si000524gb.fm 11

• Fuel and its fumes

• Personal injury from improper lifting the trailer tongue

• Projectile hazard from discharge

• Crushing hazards from a tipping or falling pump (placing the

vibrating pump on an uneven surface or near the edge of a trench

increases the risk of the pump falling over)

• Typical hazards related to towing a trailer on roads and highways

To protect yourself and others, make sure you thoroughly read and

understand the safety information presented in this manual before

operating the machine.

Safety Information PT 6L

12 wc_si000524gb.fm

1.3 State Regulations Concerning Trailers

Trailer laws covering such things as brakes, lights, safety chains, etc.,

will vary from state to state. Make certain that your trailer is in

compliance with the regulations of the state in which the trailer will be

used. If you are not sure what these regulations are, contact the state

motor vehicle department for information.

In some states, trailers must be registered and licensed by the State

Department of Transportation. Before towing, be sure to check

licensing requirements.

1.4 Safety Guidelines for Operating the Machine

Familiarity and proper training are required for the safe operation of the

machine. Machines operated improperly or by untrained personnel

can be hazardous. Read the operating instructions contained in this

manual and the engine manual, and familiarize yourself with the

location and proper use of all controls. Inexperienced operators should

receive instruction from someone familiar with the machine before

being allowed to operate it.

Operator qualifications

Only trained personnel are permitted to start, operate, and shut down

the machine. They also must meet the following qualifications:

• have received instruction on how to properly use the machine

• are familiar with required safety devices

The machine must not be accessed or operated by:

• children

• people impaired by alcohol or drugs

Personal Protective Equipment (PPE)

Wear the following Personal Protective Equipment (PPE) while

operating this machine:

• Close-fitting work clothes that do not hinder movement

• Safety glasses with side shields

• Hearing protection

• Safety-toed footwear

1.4.1 Do not touch the engine or muffler while the engine is on or

immediately after it has been turned off. These areas get hot and may

cause burns.

1.4.2 Do not use accessories or attachments that are not recommended by

Wacker Neuson. Damage to equipment and injury to the user may

result.

WARNING

PT 6L Safety Information

wc_si000524gb.fm 13

1.4.3 Do not leave the machine running unattended.

1.4.4 Never operate this machine in applications for which it is not intended.

1.4.5 Do not open the priming plug when the pump is hot. Do not loosen or

remove inlet or discharge hose fittings when the pump is hot. Hot water

inside could be pressurized much like the radiator on an automobile.

Allow the pump to cool to the touch before loosening the plug and

before loosening or removing the inlet or discharge hose fittings.

1.4.6 NEVER position the pump on a loose, uneven, or unstable surface

where it can tip, roll, slide or fall! The pump must be secure before

operating. Position the pump on a firm, flat surface; adjust the trailer

jacks to be sure the pump is level and supported firmly.

1.4.7 NEVER open the pump housing cover while the pump is operating or

start the pump with the cover off. The rotating impeller inside the pump

can cut or sever objects caught in it.

1.4.8 NEVER block or restrict flow from the inlet line or the discharge line.

Remove kinks from the discharge line before starting the pump.

Operation with a blocked inlet line or discharge line can cause water

inside the pump to overheat.

1.4.9 NEVER reach into or insert anything into the pump while the engine is

on! The impeller inside the pump housing is turning at all times while

the engine is running.

1.4.10 DO NOT allow anyone to stand in front of the discharge port when

starting the engine or while priming the pump! The sudden out-rush of

water could push or knock a person down.

1.4.11 ALWAYS make sure the hose connections on the pump are tight. A

loose connection could cause water to spray or result in a hose falling

off the pump while it is in operation.

1.4.12 ALWAYS make sure the water stream from the pump discharge is not

directed in such a way so as to cause erosion to the surrounding

ground or damage or weakening of nearby structures!

Safety Information PT 6L

14 wc_si000524gb.fm

1.5 Operator Safety while Using Internal Combustion Engines

Operating safety

When running the engine:

• Keep the area around exhaust pipe free of flammable materials.

• Check the fuel lines and the fuel tank for leaks and cracks before

starting the engine. Do not run the machine if fuel leaks are present

or the fuel lines are loose.

When running the engine:

• Do not smoke while operating the machine.

• Do not run the engine near sparks or open flames.

• Do not touch the engine or muffler while the engine is running or

immediately after it has been turned off.

• Do not operate a machine when its fuel cap is loose or missing.

• Do not start the engine if fuel has spilled or a fuel odor is present.

Move the machine away from the spill and wipe the machine dry

before starting.

Refueling safety

When refueling the engine:

• Clean up any spilled fuel immediately.

• Refill the fuel tank in a well-ventilated area.

• Replace the fuel tank cap after refueling.

• Do not smoke.

• Do not refuel a hot or running engine.

• Do not refuel the engine near sparks or open flames.

• Use suitable tools for refueling (for example, a fuel hose or funnel).

WARNING

Internal combustion engines present special hazards during operation and fueling.

Failure to follow the warnings and safety standards could result in severe injury or

death.

f Read and follow the warning instructions in the engine owner’s manual and the

safety guidelines below.

DANGER

Exhaust gas from the engine contains carbon monoxide, a deadly poison.

Exposure to carbon monoxide can kill you in minutes.

f NEVER operate the machine inside an enclosed area, such as a tunnel, unless

adequate ventilation is provided through such items as exhaust fans or hoses.

PT 6L Safety Information

wc_si000524gb.fm 15

1.6 Service Safety

A poorly maintained machine can become a safety hazard! In order

for the machine to operate safely and properly over a long period of

time, periodic maintenance and occasional repairs are necessary.

Personal Protective Equipment (PPE)

Wear the following Personal Protective Equipment (PPE) while

servicing or maintaining this machine:

• Close-fitting work clothes that do not hinder movement

• Safety glasses with side shields

• Hearing protection

• Safety-toed footwear

In addition, before servicing or maintaining the machine:

• Tie back long hair.

• Remove all jewelry (including rings).

1.6.1 Do not attempt to clean or service the machine while it is running.

Rotating parts can cause severe injury.

1.6.2 Do not use gasoline or other types of fuels or flammable solvents to

clean parts, especially in enclosed areas. Fumes from fuels and

solvents can become explosive.

1.6.3 DO NOT attempt to clean or service the machine while it is running.

1.6.4 Do not operate the machine without an air cleaner.

1.6.5 When replacement parts are required for this machine, use only

Wacker Neuson replacement parts or those parts equivalent to the

original in all types of specifications, such as physical dimensions,

type, strength, and material.

1.6.6 Keep the machine clean and labels legible. Replace all missing and

hard-to-read labels. Labels provide important operating instructions

and warn of dangers and hazards.

1.6.7 Reinstall the safety devices and guards after repairs and maintenance.

1.6.8 ALWAYS check all external fasteners at regular intervals.

1.6.9 ALWAYS remain aware of moving parts and keep hands, feet, and

loose clothing away from the moving parts of the machine.

WARNING

Safety Information PT 6L

16 wc_si000524gb.fm

1.7 Towing Safety

Towing a large trailer requires special care. Both the trailer and vehicle

must be in good condition and securely fastened to each other to

reduce the possibility of an accident.

1.7.1 ALWAYS check that the hitch and coupling on the vehicle are rated

equal to, or greater than, the trailer’s “gross vehicle weight rating”

(GVWR).

1.7.2 ALWAYS inspect the hitch and coupling for wear or damage. DO NOT

tow the trailer using defective parts.

1.7.3 ALWAYS make sure the coupling is securely fastened to the vehicle.

1.7.4 ALWAYS check the tires on the trailer for tread wear, inflation, and

condition. Replace worn tires.

1.7.5 ALWAYS connect the safety chains.

1.7.6 ALWAYS connect the breakaway cable safety hook to the bumper or

rear of the vehicle. DO NOT attach it to the hitch.

1.7.7 ALWAYS test the surge brakes on the trailer and the brakes on the

vehicle that will be used for towing.

1.7.8 ALWAYS make sure directional and trailer lights are connected and

working properly.

1.7.9 ALWAYS check that the lug nuts holding the wheels are tight and that

none are missing.

1.8 Reporting Trailer Safety Defects

If you believe your trailer has a defect which could cause a crash or

could cause injury or death, you should immediately inform the

National Highway Traffic Safety Administration (NHTSA) in addition to

notifying Wacker Neuson Corporation.

If NHTSA receives similar complaints, it may open an investigation;

and if it finds that a safety defect exists in a group of vehicles, it may

order a recall and remedy campaign. However, NHTSA cannot

become involved in individual problems between you, your dealer, or

Wacker Neuson Corporation.

To contact NHTSA, you may either contact the Auto Safety Hotline toll-

free at 1-800-424-9393 (or 366-0129 in Washington DC area),

www.nhtsa.com, or write to NHTSA, U.S. Department of

Transportation, 400 7th Street SW, (NSA-11), Washington, DC 20590.

You can also obtain other information about motor vehicle safety from

the Auto Safety Hotline.

WARNING

PT 6L Labels

wc_si000523gb.fm 17

2 Labels

2.1 Label Locations

wc_gr001145

1

13

19

3

7

6

3

16

8

18

14

10

9

5

19

6

4

12

11

17

2

Labels PT 6L

18 wc_si000523gb.fm

2.2 Label Meanings

1

DANGER!

Asphyxiation hazard.

 Engines emit carbon monoxide.

 Do not run the machine indoors or in an

enclosed area.

 NEVER use inside a home or garage, EVEN

IF doors and windows are open.

 Only use OUTSIDE and far away from win-

dows, doors, and vents.

 Read the Operator’s Manual.

 No sparks, flames, or burning objects near

the machine.

 Stop the engine before refueling.

CAUTION!

Use only clean, filtered diesel fuel.

2

Storage location of Operator’s Manual. The

Operator’s Manual should be stored on the

machine.

3

CAUTION!

Read and understand the supplied Operator’s

Manual before operating this machine. Failure to

do so increases the risk of injury to yourself and

others.

4

NOTICE

Lifting point.

5

WARNING!

Hot surface

6

WARNING!

Pressurized contents. Do not open when hot!

PT 6L Labels

wc_si000523gb.fm 19

7

WARNING!

Never pump volatile, flammable, or low-flash-

point fluids. These fluids could ignite or

explode.

8

Tire Information

Certification Label (VIN Number)

Also attached to each unit is a Certification

Label. This label specifies that the trailer con-

forms with all Federal Motor Vehicle Standards

in effect at the time of manufacture. The label

includes the Vehicle Identification Number (VIN)

for the trailer.

9

This machine may be covered by one or more

patents.

10

A nameplate listing the model number, item

number, revision number, and serial number is

attached to each unit. Please record the infor-

mation found on this nameplate so it will be

available should the nameplate become lost or

damaged. When ordering parts or requesting

service information, you will always be asked to

specify the model number, item number, revision

number, and serial number of the unit.

11

CAUTION!

Service oil bath air filter daily before starting

engine. Severe engine damage will occur if oil

bath filter is low or empty.

12

CAUTION!

Engine overheat - Check fan belt.

Labels PT 6L

20 wc_si000523gb.fm

13

Ultra low sulfur fuel only.

14

Transport position of the jack

15

NOTICE

Add oil to air cleaner before starting engine.

16

WARNING

Operation of this equipment may create sparks

that can start fires around dry vegetation. A

spark arrester may be required. The operator

should contact local fire agencies for laws or

regulations relating to fire prevention require-

ments.

17

WARNING!

Explosion hazard. Do not use evaporative start-

ing fluids, such as ether, on this engine. The

engine is equipped with a cold starting aid.

Using evaporative starting fluids can cause an

explosion which can cause engine damage, per-

sonal injury, or death. Read and follow the

engine starting instructions in this Operator's

Manual.

18

CAUTION

Wheel nuts must be tightened to 85 ft.lbs.

19

NOTICE

No lift point.

WARNING

Operation of This Equipment May Create Sparks That Can Start Fires Around Dry

Vegetation. A Spark Arrestor May be Required. The Operator Should Contact Local

Fire Agencies For Laws or Regulations Relating to Fire Prevention Requirements.

Per CAL. PRC. CODE

La page charge ...

Wacker Neuson PT6LS Manuel utilisateur

Ce manuel convient également à

Wacker Neuson PT6LS Manuel utilisateur

dans d''autres langues

Documents connexes

Autres documents