Eurotech ReliaGATE 10-20 Le manuel du propriétaire

ReliaGATE 10

-20

Multi

-Service Gateway and Edge Controller

USER MANUAL

Rev

1.0 – May 2015 – 110129-0001B

ReliaGATE 10

-20

Multi

-Service Gateway and Edge Controller

USER MANUAL

Rev

B – March 2019 – 110129-0001B

Trademarks

All trademarks or registered trademarks, logos, designs and products appearing in this document are property of

their respective owners

Revision History

Revision

Description

Date

1

Initial Release

Nov 2014

2

Update

May 2015

A

Updated product images

Added warnings in French

Updated SW features list

Minor grammar and formatting updates

September 2015

B

Updated GPIO input range specification

Added reverse polarity warning note

Updated CE Directive

Updated links to Eurotech website

Updated debug section

Updated references to 3G (changed to cellular)

March 2019

ReliaGATE 10-20 User Manual Table of Contents

3

110129

-0001B

Table of Contents

Trademarks .................................................................................................................................................................. 2

Revision History ........................................................................................................................................................... 2

Table of Contents .......................................................................................................................................................... 3

Safety and Regulatory .................................................................................................................................................. 7

Alerts that can be found throughout this manual ......................................................................................................... 8

Alertes peuvant être trouvées dans ce manuel ........................................................................................................... 8

Safety Notices and Warnings ...................................................................................................................................... 9

Avis de sécurité et avertissements .............................................................................................................................. 9

Do not operate in an explosive atmosphere .......................................................................................................... 9

Ne pas utiliser dans une atmosphère explosive .................................................................................................... 9

Antistatic precautions ............................................................................................................................................. 9

Précautions antistatiques ....................................................................................................................................... 9

Connection to power supply or other devices ...................................................................................................... 10

Raccordement à l'alimentation ou d'autres appareils .......................................................................................... 10

Installation ............................................................................................................................................................ 11

Ventilation............................................................................................................................................................. 11

Maintenance ......................................................................................................................................................... 11

Cleaning ............................................................................................................................................................... 12

Nettoyage ............................................................................................................................................................. 12

Life Support Policy ..................................................................................................................................................... 12

Politique Life Support ................................................................................................................................................ 12

Warranty .................................................................................................................................................................... 12

CE Notice ................................................................................................................................................................... 12

Directive RED 2014/53/EU ........................................................................................................................................ 13

WEEE ........................................................................................................................................................................ 13

RoHS ......................................................................................................................................................................... 13

EMC Requirements for Industry Canada .................................................................................................................. 13

FCC Part 15 Class B Statement ................................................................................................................................ 14

Technical Assistance ................................................................................................................................................. 14

Transportation ...................................................................................................................................................... 14

Conventions ............................................................................................................................................................... 15

Product Overview ........................................................................................................................................................ 17

Block Diagram ........................................................................................................................................................... 18

Features ..................................................................................................................................................................... 19

Product Options ......................................................................................................................................................... 19

Related Documents ................................................................................................................................................... 20

Product Specifications ............................................................................................................................................... 21

Front Panel Interfaces ............................................................................................................................................... 22

Power Supply ....................................................................................................................................................... 22

Ethernet ................................................................................................................................................................ 23

USB ...................................................................................................................................................................... 23

Serial 1 ................................................................................................................................................................. 24

Serial 2 ................................................................................................................................................................. 24

Rear Panel Interfaces ................................................................................................................................................ 25

Wi-Fi (IEEE 802.11) and Bluetooth ...................................................................................................................... 25

GPS (Optional) ..................................................................................................................................................... 25

Discrete I/O .......................................................................................................................................................... 26

ReliaCELL 10-20 Docking Bay: USB/Cellular, SD, SIM, Debug ......................................................................... 27

Table of Contents ReliaGATE 10-20 User Manual

4

110129-

0001B

Other Features ........................................................................................................................................................... 28

Accelerometer ...................................................................................................................................................... 28

Real Time Clock (RTC) ........................................................................................................................................ 29

User Interface ............................................................................................................................................................ 30

LED Indicators ...................................................................................................................................................... 30

Environmental ............................................................................................................................................................ 31

Mechanical Specifications ......................................................................................................................................... 33

Mounting the ReliaGATE 10-20 ................................................................................................................................. 34

Mounting a ReliaCELL 10-20 Modem ....................................................................................................................... 34

Administrative Console .............................................................................................................................................. 35

Logging In .................................................................................................................................................................. 35

Booting up and using the Serial Console .................................................................................................................. 35

Remote Login ............................................................................................................................................................ 35

Security Settings ........................................................................................................................................................ 36

Linux Peripheral Access ............................................................................................................................................ 37

Ethernet ..................................................................................................................................................................... 37

Wi-Fi .......................................................................................................................................................................... 37

Serial Ports ................................................................................................................................................................ 37

Accelerometer ............................................................................................................................................................ 37

Flash Memory ............................................................................................................................................................ 38

Analog Inputs ............................................................................................................................................................. 38

GPIO .......................................................................................................................................................................... 38

CAN Bus .................................................................................................................................................................... 39

ReliaCELL 10-20 ....................................................................................................................................................... 39

GPS ........................................................................................................................................................................... 40

Watchdog ................................................................................................................................................................... 40

Suspend/Resume ...................................................................................................................................................... 41

Linux Application Development ................................................................................................................................ 43

Developing Applications ............................................................................................................................................ 43

Installing the Toolchain .............................................................................................................................................. 43

Internet of Things (IoT) Application Development................................................................................................... 45

Everyware Software Framework (ESF) ..................................................................................................................... 45

Everyware Cloud (EC) ............................................................................................................................................... 46

Appendix A – BSP 10.x.x ............................................................................................................................................ 47

Administrative ............................................................................................................................................................ 47

Logging In............................................................................................................................................................. 47

Booting up and using the Serial Console ............................................................................................................. 47

Remote Login ....................................................................................................................................................... 47

Security Settings .................................................................................................................................................. 48

Peripheral Access ...................................................................................................................................................... 49

Ethernet ................................................................................................................................................................ 49

Wi-Fi ..................................................................................................................................................................... 49

Serial Ports ........................................................................................................................................................... 49

Accelerometer ...................................................................................................................................................... 49

Flash Memory ...................................................................................................................................................... 50

Analog Inputs ....................................................................................................................................................... 50

GPIO .................................................................................................................................................................... 50

CAN Bus............................................................................................................................................................... 51

ReliaCELL 10-20 .................................................................................................................................................. 51

ReliaGATE 10-20 User Manual Table of Contents

5

110129

-0001B

GPS ...................................................................................................................................................................... 52

Watchdog ............................................................................................................................................................. 52

Suspend/Resume ................................................................................................................................................. 53

ReliaGATE 10-20 User Manual Safety and Regulatory

7

110129

-0001B

Safety and Regulatory

Carefully read and understand the instructions in this manual before using this device.

Whenever you have any doubt regarding the operation of this device, consult this manual or contact your local

Eurotech Technical Support Team (see the last page of this manual for details).

Keep this manual for future reference.

To lower the risk of personal injury, electric shock, fire or damage to equipment, observe the following

precautions, as well as using good technical judgment, whenever installing or using the device.

Eurotech has made every effort to ensure the accuracy of this document; however, Eurotech assumes no liability

resulting from any error/omission in this document, or from the use of the information contained herein.

Eurotech reserves the right to revise this document or to make changes to its content at any time without any

obligation to notify any person of such revision or changes.

Sécurité et réglementation

Lire attentivement la notice et comprendre les instructions avant d'utiliser cet appareil.

Chaque fois que vous avez le moindre doute concernant le fonctionnement de cet appareil, consultez ce manuel

ou contactez notre équipe locale de support technique Eurotech (voir la dernière page de ce manuel pour plus de

détails).

Conservez ce manuel.

Pour réduire le risque de blessures corporelles, de choc électrique, d’incendie ou de dégâts matériels,

respectez les précautions de ce manuel, ainsi que les précautions habituelles d’utilisation de tout matériel

électrique, à chaque installation ou utilisation de l'appareil.

Eurotech a fait tous les efforts nécessaires afin d’assurer l'exactitude de ce document. Toutefois, Eurotech décline

toute responsabilité résultant d'une erreur ou omission dans ce document, ou de l'utilisation de l'information

contenue dans ce document.

Eurotech réserve le droit de réviser ce document ou d'apporter des modifications à son contenu à tout moment et

sans aucune obligation de notifier toute personne de telles révisions ou modifications.

Safety and Regulatory ReliaGATE 10-20 User Manual

8

110129-

0001B

Alerts that can be found throughout this manual

Alertes peuvant être trouvées dans ce manuel

Symbol

Meaning

DANGER!

Information highlighting potential electrical shock hazards:

• Personal injury or death could occur.

• Damage to the system, connected peripheral devices, or software could occur.

Always use appropriate safety precautions. Also ensure that the installation meets all the requirements as

set out for the environment that the equipment will be deployed in.

DANGER!

Informations soulignant un risque de choc électrique:

• De graves blessures ou la mort peuvent être provoquées.

• Des dommages au système, aux périphériques connectés, ou au logiciel pourraient se produire.

Toujours suivre les précautions de sécurité appropriées. Assurez-vous également que l'installation réponde

à toutes les exigences nécessaires à l'environnement d’utilisation du matériel

WARNING!

Information highlighting potential hazards:

• Personal injury or death could occur.

• Damage to the system, connected peripheral devices, or software could occur.

Always use appropriate safety precautions. Also ensure that the installation meets all the requirements as

set out for the environment that the equipment will be deployed in.

DANGERS!

Informations soulignant les dangers potentiels:

• De graves blessures ou la mort peuvent être provoquées.

• Des dommages au système, aux périphériques connectés, ou au logiciel pourraient se produire.

Toujours suivre les précautions de sécurité appropriées. Assurez-vous également que l'installation réponde

à toutes les exigences nécessaires à l'environnement d’utilisation du matériel

NOTE

These will highlight important features or instructions.

Note: Caractéristiques ou instructions importantes.

ReliaGATE 10-20 User Manual Safety and Regulatory

9

110129

-0001B

Safety Notices and Warnings

Observe the following safety precautions during all phases of operation, service, and repair of the device.

Failure to comply with these precautions or with specific warnings elsewhere in this manual violates safety

standards of design, manufacture, and intended use of the device.

Eurotech assumes no liability for the customer’s failure to comply with these requirements.

The safety precautions listed below represent warnings of certain dangers of which Eurotech is aware. You, as the

user of the device, should follow these warnings and all other safety precautions necessary for the safe operation

of the device in your operating environment.

Avis de sécurité et avertissements

Respectez les consignes de sécurité suivantes lors de toutes les phases de fonctionnement, de service et de

réparation de l'appareil.

Le non-respect de ces consignes ou des avertissements spécifiques contenus dans ce manuel viole les normes

de conception, de fabrication, de sécurité, et d'utilisation de l'appareil.

Eurotech décline toute responsabilité lors du non-respect de ces exigences par les clients.

Les précautions de sécurité indiquées ci-dessous représentent les avertissements de certains dangers connus

d’Eurotech. En tant qu'utilisateur de l'appareil, vous devez suivre ces avertissements et toutes les autres mesures

de sécurité nécessaires pour un fonctionnement sûr de l'appareil.

Do not operate in an explosive atmosphere

Ne pas utiliser dans une atmosphère explosive

WARNING!

Do not operate the equipment in the presence of flammable gases or fumes. Operation of any

electrical equipment in such an environment constitutes a definite safety hazard.

ATTENTION!

Ne pas faire fonctionner l'équipement en présence de gaz ou de vapeurs inflammables. L'utilisation

de tout équipement électrique dans un tel environnement constitue un réel danger.

Antistatic precautions

Précautions antistatiques

WARNING!

To avoid ESD (Electro Static Discharge) damage, always use appropriate antistatic precautions

when handing any electronic equipment.

ATTENTION!

Pour éviter les dommages dus aux décharges ESD (Electro Static Discharge), utilisez toujours les

protections antistatiques appropriées lors de la manipulation de tout équipement électronique.

Safety and Regulatory ReliaGATE 10-20 User Manual

10

110129-

0001B

Connection to power supply or other devices

Raccordement à l'alimentation ou d'autres appareils

DANGER!

Before applying power to the system, thoroughly review all installation, operation, and safety

instructions.

Failure to install the system power supply correctly or to follow all operating instructions correctly

may create an electrical shock hazard, which can result in personal injury or loss of life, and/or

damage to equipment or other property

DANGER!

Avant de mettre le système sous tension, examiner attentivement toutes les instructions

d'installation, d'exploitation et de sécurité.

Ne pas installer l'alimentation électrique correctement ou ne pas de suivre toutes les instructions

correctement peut créer un risque de choc électrique, pouvant entrainer des blessures graves, la

mort et / ou endommager l'équipement ou d'autres biens

• To avoid injuries, always disconnect power and discharge circuits before touching them.

• Pour éviter les blessures, toujours débrancher les circuits d'alimentation et de décharge avant de les toucher.

• Only start the device with a power supply that meets the requirements stated on the voltage label. In case of

uncertainties about the required power supply, please contact the Eurotech Technical Support Team or the

electricity authority

• Ne démarrer l'appareil qu’avec une alimentation répondant aux exigences indiquées sur l'étiquette de tension. En cas

d'incertitudes sur l'alimentation requise, contactez l'équipe de support technique Eurotech.

• Before connecting other equipment carefully read any supplied instructions

• Avant de connecter d'autres équipements, lire attentivement les instructions fournies

• Always disconnect the power before connecting or disconnecting cables

• Toujours débrancher l'alimentation avant de connecter ou déconnecter les câbles

• Do not perform connections with wet hands

• Ne pas effectuer les connexions avec les mains mouillées

• Check any power cords for damage before use

• Vérifiez l’état des cordons d'alimentation avant utilisation

• Use certified power cables. The power cable must meet the requirements (voltage and current) of the device.

• Utilisez des câbles d'alimentation certifiés. Le câble d'alimentation doit répondre aux exigences (tension et courant) de

l'appareil.

• Position cables with care. Avoid positioning cables in places where they may be trampled on or compressed

by objects placed on them. Take particular care of the plug, power-point and outlet of power cable

• Positionnez les câbles avec soin. Evitez de placer les câbles dans des endroits où ils peuvent être piétinés ou compressées

par des objets placés sur eux. Prenez un soin particulier de la prise, et de la sortie du câble d'alimentation

• Avoid overcharging any power outlets

• Evitez de surcharger les prises de courant

• Only apply power to the device or connected equipment after checking that all the above conditions have

been met

• N’alimenter l'appareil ou l’équipement connecté qu’après avoir vérifié que toutes les conditions ci-dessus ont été

respectées

ReliaGATE 10-20 User Manual Safety and Regulatory

11

110129

-0001B

Installation

WARNING!

•

Verify that the mounting location can withstand the added loads caused by the addition of the

device, it should be firmly secured so that it will not cause any potentially hazardous

situations (e.g. falling down due to vibration or shock)

• Do not operate the device near heat sources or flames.

ATTENTION!

• • Vérifiez que l'emplacement de montage peut supporter les charges supplémentaires

causées par l'ajout de l'appareil, il doit être solidement fixé afin de ne pas provoquer de

situations potentiellement dangereuses (par exemple, tomber à cause des vibrations ou des

chocs)

• • Ne pas utiliser l'appareil près de sources de chaleur ou de flammes.

NOTE:

If the device must be moved from one place to another with different ambient temperatures, ensure sufficient

time for the temperature of the device to stabilize before repowering.

NOTE:

Si l'appareil doit être déplacé d'un endroit à un autre soumis à différentes températures ambiantes, prévoir

suffisamment de temps pour que la température de l'appareil se stabilise avant de remettre le courant.

Ventilation

WARNING!

Ensure adequate ventilation to avoid overheating, Eurotech suggests the following steps:

• When installing the device within a cabinet, rack or other enclosed space, be sure to leave

sufficient space to allow adequate air circulation

ATTENTION!

Assurer une ventilation adéquate pour éviter la surchauffe, Eurotech suggère les étapes suivantes:

• Lorsque vous installez l'appareil dans une armoire, rack ou un autre espace clos, assurez-

vous de laisser un espace suffisant pour permettre une circulation d'air suffisante

Maintenance

DANGER!

• Never open, dismantle or repair the device!

• For your maintenance or repair requirement please contact a qualified Eurotech engineer.

If the device does not function correctly and you are unable to find a solution, feel free to contact

the Eurotech Technical Support Team.

DANGER!

• Ne jamais ouvrir, démonter ou tenter de réparer l'appareil!

• Pour votre entretien ou pour la réparation contactez un technicien qualifié Eurotech.

Si l’appareil ne fonctionne pas correctement et que vous êtes incapable de trouver une solution,

vous pouvez contacter l'équipe de support technique Eurotech.

Safety and Regulatory ReliaGATE 10-20 User Manual

12

110129-

0001B

If the equipment does not work properly, especially if smells unusual, unplug it immediately and contact the

Eurotech Technical Support Team (see last page of this manual for further details).

Si l'équipement ne fonctionne pas correctement, surtout en cas d’odeurs inhabituelles, débranchez-le

immédiatement et contactez l'équipe d'assistance technique Eurotech (voir la dernière page de ce manuel pour

plus de détails).

Cleaning

Nettoyage

WARNING!

When cleaning the device, remember to:

• Ensure sufficient ESD protection during the cleaning process.

• Remove any power from the device.

• When cleaning an enclosed system or peripheral use a dry cloth on the external casing.

• Do not use detergents, aerosol sprays, solvents or abrasive sponges.

ATTENTION!

Lors du nettoyage de l'appareil, pensez à:

• Assurer une protection ESD suffisante pendant le processus de nettoyage.

• Débrancher l'appareil.

• Lors du nettoyage d'un système ou d’un périphérique clos, utiliser un chiffon sec sur le

boîtier externe.

• Ne pas utiliser de détergents, d'aérosols, de solvants ou d'éponges abrasives.

Life Support Policy

Politique Life Support

WARNING!

Users must not use Eurotech products as critical components of life support devices or systems

without the express written approval of Eurotech Spa.

ATTENTION!

Les utilisateurs ne doivent pas utiliser les produits Eurotech dans des dispositifs critiques ou des

systèmes d’assistance de la vie sans l'autorisation expresse écrite de Eurotech Spa.

Warranty

Please contact your local Eurotech Sales Office for detailed warranty terms and conditions.

Refer to the back covers of this manual for full contact details.

CE Notice

This product is CE marked.

The CE mark on the product indicates that it conforms with the essential requirements of the

applicable EC directives.

Eurotech is not responsible for the use of its products together with equipment (e.g. power supplies,

personal computers, etc...) that are not CE marked and compliant with technical requirements

specified in this manual.

ReliaGATE 10-20 User Manual Safety and Regulatory

13

110129

-0001B

Directive RED 2014/53/EU

This product meets the requirements of the Directive 2014/53/EU of the European Parliament and of the Concil of

16 April 2014 on the harmonization of the laws of the Member States relating to the marking available on the market

of radio equipment.

WEEE

The information below complies with the regulations set out in the 2002/96/EC directive, subsequently superseded

by 2003/108/EC. It refers electrical and electronic equipment and the waste management of such products.

When disposing of a device, including all of its components, subassemblies and materials that are an integral part

of the product, you should consider the WEEE directive.

The use of the following symbol, attached to the equipment, packaging, instruction literature, or the

guarantee sheet, states that the device has been marketed after August 13th 2005, and implies that

you must separate all of its components when possible, and dispose of them in accordance with waste

disposal legislations:

• Because of the substances present in the equipment, improper use or disposal of the refuse can cause

damage to human health and the environment.

• With reference to WEEE, it is compulsory not to dispose of the equipment with normal urban refuse; an

arrangement for separate collection and disposal is essential.

• To avoid any possible legal implications, contact your local waste collection body for full recycling information.

RoHS

This device, including all the components, subassemblies and the consumable materials that are an integral part

of the product, have been manufactured in compliance with the European directive 2002/95/EC known as the RoHS

directive (Restrictions of the use of certain Hazardous Substances). This directive targets the reduction of certain

hazardous substances previously used in electrical and electronic equipment (EEE).

EMC Requirements for Industry Canada

This Class B digital apparatus meets all requirements of the Canadian Interference‐

Causing Equipment Regulations. This device complies with Industry Canada RSS

Appliance radio exempt from licensing. The operation is permitted for the following

two conditions:

1. The device may not cause harmful interference, and

2. The user of the device must accept any interference suffered, even if the

interference is likely to jeopardize the operation.

Safety and Regulatory ReliaGATE 10-20 User Manual

14

110129-

0001B

Disclaimer:

This equipment generates and can radiate radio frequency energy and may cause harmful interference to

radio communications. If this equipment does cause harmful interference to radio or television reception,

which can be determined by turning the equipment off and on, the user is encouraged to try to correct the

interference by such measures as reorienting the receiving antenna, increasing separation between

equipment and receiver, or connecting the equipment into an outlet on a different electrical circuit.

Additional restrictions and requirements may be listed in the System Specifications.

Disclaimer:

Cet équipement génère et peut émettre des ondes radiofréquence et peut causer des interférences

nuisibles aux communications radio. Si cet équipement provoque des interférences nuisibles à la réception

de radio ou de télévision, ce qui peut être déterminé en allumant et éteignant l'équipement, l'utilisateur est

encouragé à essayer de corriger l'interférence par des mesures telles que la réorientation de l'antenne de

réception, en augmentant la distance de séparation entre l'équipement et le récepteur, ou de raccorder

l'appareil à une prise sur un circuit électrique différent.

Des restrictions et des exigences supplémentaires peuvent être mentionnées dans les spécifications du

système.

FCC Part 15 Class B Statement

This equipment has been tested and found to comply with the limits for a Class B digital device,

pursuant to part 15 of the FCC Rules. These limits are designed to provide reasonable protection

against harmful interference in a residential installation. This equipment generates, uses, and

can radiate radio frequency energy and, if not installed and used in accordance with the

instructions, may cause harmful interference to radio communications.

Warning: Changes or modifications to this unit not expressly approved by the party responsible for compliance

could void the user’s authority to operate the equipment.

Technical Assistance

For any technical questions, or if you cannot isolate a problem with your device, or for any enquiry about repair and

returns policies, feel free to contact your local Eurotech Technical Support Team.

See the back cover for full contact details.

Transportation

When transporting any module or system, for any reason, it should be packed using anti-static material and placed

in a sturdy box with enough packing material to adequately cushion it.

Warning:

Any product returned to Eurotech that is damaged due to inappropriate packaging will not be

covered by the warranty!

ATTENTION!

Tout produit retourné à Eurotech et endommagé en raison de l'emballage inapproprié ne sera pas

couvert par la garantie!

ReliaGATE 10-20 User Manual Safety and Regulatory

15

110129

-0001B

Conventions

The following table describes the conventions for signal names used in this document.

Convention

Explanation

GND

Digital ground plane

#

Active low signal

_P

Positive signal in differential pair

_N

Negative signal in differential pair

The following table describes the abbreviations for direction and electrical characteristics of a signal used in this

document.

Type

Explanation

I

Signal is an input to the system

O

Signal is an output from the system

IO

Signal may be input or output

P

Power and ground

A

Analog signal

3.3

3.3 V signal level

5

5 V signal level

NC

No Connection

Reserved

Use is reserved to Eurotech

ReliaGATE 10-20 User Manual Product Overview

17

110129

-0001B

Product Overview

The ReliaGATE 10-20 is a ready-to-deploy, industrial-grade, gateway for advanced Internet of Things applications.

It is a smart device that enables communications, edge computational power, simplified application deployment,

and integration with Internet of Things (IoT) and Machine to Machine (M2M) platforms for immediate service

generation. It provides a capable communication architecture and offers connectivity to a wide range of sensors

and edge devices making it easy to collect data from the field and deliver it to your business application. ReliaGATE

10-20 supports wireless applications including GPS, Wi-Fi, cellular and wired connectivity such as USB 2.0, Gigabit

Ethernet, serial ports, CAN 2.0b, Analog inputs, and isolated digital I/O.

With the ReliaGATE 10-20, you can easily manage configuration and deliver out-of-the-box connectivity for your

IoT/M2M and connected applications. It comes with an optimized Yocto-based Linux operating system specifically

targeted for this device. The ReliaGATE 10-20 comes with Java and OSGi-based middleware for IoT gateways,

Eurotech’s Everyware™ Software Framework (ESF). ESF abstracts and isolates the application developer from

the complexity of the hardware subsystems and ensures application portability across architectures. ESF built-in

components are configurable services covering the most-common building blocks for IoT applications such as I/O

access, network configuration, data services, and remote management. ESF support the Eurotech’s Everyware™

Cloud for remote access and remote management of IoT gateways.

The following figure shows a full-featured ReliaGATE 10-20. A ReliaCELL 10-20 cellular module is mounted. Actual

units may vary in appearance depending on the selected options.

Figure 1. ReliaGATE 10-20, with ReliaCELL 10-20

Product Overview ReliaGATE 10-20 User Manual

18

110129-

0001B

Block Diagram

The following diagram illustrates the standard product delivery for the ReliaGATE 10-20. Additional factory options

are shown in green. Inquire with your local sales representative for any non-standard features.

UART 4

Buf

UART 1

Xcvr

USB 5

USB6

USB7

Gigabit Ethernet 2

Gigabit Ethernet 1

Power

RTC

AUD6

MIPI

CSI-2

2x3 LEDs

GPIOs

Smart Power

Controller

Reset

Vin

Power InputIGN

CPU OFF

Alive

USB-

ETH

Audio

CODEC

ReliaGATE 10-20

ReliaCELL 10-20

( USB 3.0)

3.3V

USB OTG

LCD

HDMI

SIM

GPS (SMA)

UART 5

UART 2

SPI

Bus 3

SD 4

(8-bit)

SD 2

(4-bit)

Keypad

GPIO

USB

2.0

LVDS

Display 0

DDR3

BAT

7-

Port

USB

HUB

USB 1

USB 2

USB 3

USB4

Xcvr

Buf

I

2

C

eMMC

NAND

flash

Power

Manager

Freescale i. MX 6

Processor

x2 USB

USB OTG

microSD

Serial 1

Serial 2

GPS

CAN

Bus

CAN I/F

x2 A/D

Line Out (R)

Mic (R)

CAN 2.0b

DRAM

Cellular

A/D

Reset

RESET

Serial 5

Serial 4

SATA

Serial 5

Serial 4

PCIe

Wi-

Fi

Wi-Fi/BT (SMA)

BT

Accelerometer

x4 GPIO

Boot Switch

ReliaGATE 10-20 User Manual Product Overview

19

110129

-0001B

Features

Processor

• Freescale iMX6 800MHz Solo or Quad Core processor

Memory

• 512MB to 2GB DDR3 DRAM

• 4GB to 64GB on-board flash with soldered down eMMC

• MicroSD expansion slot

Communications

• Two gigabit Ethernet ports

• Three USB 2.0 host ports

• Two serial ports

• One CAN 2.0b

• Wi-Fi IEEE 802.11

• Bluetooth

• GPS receiver (Optional)

• Cellular: Accepts all variants of ReliaCELL 10-20 modems

Indicators

• Six (6) LED status indicators (four are user programmable)

Discrete I/Os

• Two analog inputs

• Four digital inputs/outputs

Software

• Yocto-based Linux Operating System

• Everyware Software Framework (v 3.0.2 or higher)

• Supports Everyware Cloud for remote management

Power Supply

• Supports 6-36VDC (12V Nominal), with transient protection, vehicle ignition input, and a Low Power Mode

• 4 W power consumption, typical

• 17W, maximum

Other

• Battery-backed real-time clock (RTC)

• Accelerometer

• Industrial Temperature Rated (Operational): -40ºC to +80ºC

Product Options

If your application requires any additional features or options, contact your local Eurotech sales representative for

availability.

Product Overview ReliaGATE 10-20 User Manual

20

110129-

0001B

Eurotech ReliaGATE 10-20 Le manuel du propriétaire

Eurotech ReliaGATE 10-20 Le manuel du propriétaire

dans d''autres langues

Documents connexes

Autres documents